BRAKE CALIPER FAILED TO RELEASE, BOILING THE BRAKE FLUID (UNBEKNOWNST TO ME UNTIL IT CAME TIME TO APPLY THE BRAKES). THE BRAKE PEDAL WENT ALL THE WAY TO THE FLOOR. I LET IT UP COMPLETELY AND WHEN DEPRESSED, IT WENT TO THE FLOOR ONCE AGAIN. I USED THE TRANSMISSION (GEARING DOWN) AND THE EMERGENCY BRAKE TO BRING VEHICLE TO A ST…
Read full complaint
BRAKE CALIPER FAILED TO RELEASE, BOILING THE BRAKE FLUID (UNBEKNOWNST TO ME UNTIL IT CAME TIME TO APPLY THE BRAKES). THE BRAKE PEDAL WENT ALL THE WAY TO THE FLOOR. I LET IT UP COMPLETELY AND WHEN DEPRESSED, IT WENT TO THE FLOOR ONCE AGAIN. I USED THE TRANSMISSION (GEARING DOWN) AND THE EMERGENCY BRAKE TO BRING VEHICLE TO A STOP. THE MASTER CYLINDER BRAKE INDICATOR LIGHT NEVER ILLUMINATED. WHEN REPAIRS WERE COMPLETED, THE PRIMARY FAULT WAS IDENTIFIED AS EXTREMELY RUSTY FRONT BRAKE CALIPERS. ONE DID NOT RELEASE COMPLETELY AFTER A BRAKE APPLICATION, CAUSING SUFFICIENT HEAT BUILDUP TO BOIL THE BRAKE FLUID. MECHANIC SAID THE REAR BRAKES WERE BADLY OUT OF ADJUSTMENT, GIVING THE OPINION THAT WAS THE REASON THE MASTER CYLINDER INDICATOR LIGHT DID NOT ILLUMINATE. UNTIL THIS INCIDENT OCCURRED, I DID NOT KNOW THAT IT WAS INCUMBENT ON THE VEHICLE OPERATOR TO OCCASIONALLY MAKE REVERSE MOVES WITH AGGRESSIVE BRAKE APPLICATIONS (DONE SEVERAL TIMES) TO CINCH UP THE REAR BRAKE ADJUSTMENT. THUS, OVER TIME, THE FRONT BRAKES WERE BASICALLY DOING ALMOST ALL THE BRAKING EFFORT. IF I HAD HAD THE PRESENCE OF MIND TO PUMP THE BRAKE PEDAL REPEATEDLY, I PERHAPS COULD HAVE CAUSED THE REAR BRAKES TO ENGAGE, AND BRING THE VEHICLE TO A STOP WITHOUT DOWNGEARING AND USING THE EMERGENCY BRAKE.*AK
THE DUAL FUEL TANK SELECTOR VALVE MAY MALFUNCTION AND CAUSE AN OVERFILL CONDITION IN ONE OF THE FUEL TANKS, RESULTING IN AN OVERFLOW OF FUEL PAST THE FILLER CAP.
Consequence & remedy
Consequence: THE OVERFLOW OF FUEL PAST THE FILLER CAP CAUSES A FUELLEAKAGE, WHICH CAN RESULT IN A FIRE WHEN EXPOSED TO A SOURCE OF IGNITION.
Remedy: REPLACE THE DUAL FUEL TANK SELECTOR VALVE.
UNDER CERTAIN CONDITIONS, THE SNAP RING THAT LOCATES THE PARK GEAR ON THE OUTPUT SHAFT OF THE TRANSMISSION MAY FRACTURE.
Consequence & remedy
Consequence: WHEN THE GEAR IS PLACED IN PARK, THE PARK GEAR WOULD NOTENGAGE, ALLOWING THE TRUCK TO ROLL FREELY IF THE PARKING BRAKE IS NOT PROPERLYSET. THIS COULD RESULT IN AN ACCIDENT.
Remedy: INSTALL IMPROVED SNAP RING AND REVISED TRANSMISSION EXTENSION HOUSING.
NYLON TIES THAT SUPPORT THE MAIN WIRING HARNESS TO THE CHASSIS COULD WEAR AND BREAK DUE TO EXCESSIVE VIBRATION. THUS, WIRING HARNESS COULD FALL ON ENGINE COMPONENTS AND SHORT CIRCUIT.
Consequence & remedy
Consequence: THIS COULD CAUSE LOSS OF ELECTRICAL SYSTEM WHICH COULDRESULT IN AN UNDERHOOD FIRE.
Remedy: INSTALL RETROFIT RIT OF PLASTIC-COATED METAL CLAMPS, LOOM FOR POSITIVE BATTERY CABLES AND RE-ROUTE WIRING.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
6
SQ99005 · Front Brake Fade
Opened Feb 10, 1999 · Closed Sep 21, 2001
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
FRONT BRAKES CAN FADE
EA93014 · Alternator Belt Failure
Opened Jun 4, 1993 · Closed Jul 29, 1994
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
EA91044 · Loss Of Brake Effectivenes
Opened Oct 30, 1991 · Closed Oct 30, 1992
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
===
EA91031 · Fuel Expulsion
Opened Jun 26, 1991 · Closed Nov 1, 1991
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
PE91077 · Loss Of Brake Effectivenes
Opened May 23, 1991 · Closed Oct 31, 1991
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
PE90056 · Trnsmssion Park Gear Fail
Opened Mar 12, 1990 · Closed Jun 12, 1990
Status: closed (inferred from source dates) · Power Train:automatic Transmission:gear Position Indication (prndl)
There is no summary currently available
1989 Ford E350 Problems, Complaints & Recalls | Skip That Year
Illustration