AVI FOODSYSTEMS VEHICLE # [XXX] IS A DANGER ON THE ROAD IT IS NOT FEDERALLY INSPECTED AND YOU CAN SEE THE TRUCK IS A HAZARD. I FEEL BAD FOR THE DRIVER EVERYTIME I SEE HER COME TO OUR ACCOUNT. SHE IS RISKING HER LIFE DRIVING THAT VEHICLE. THIS TRUCK HAS OHIO PLATES AND IS IN ERIE,PA I WANTED TO INFORM D.O.T. ANONYMOUSLY. I…
Read full complaint
AVI FOODSYSTEMS VEHICLE # [XXX] IS A DANGER ON THE ROAD IT IS NOT FEDERALLY INSPECTED AND YOU CAN SEE THE TRUCK IS A HAZARD. I FEEL BAD FOR THE DRIVER EVERYTIME I SEE HER COME TO OUR ACCOUNT. SHE IS RISKING HER LIFE DRIVING THAT VEHICLE. THIS TRUCK HAS OHIO PLATES AND IS IN ERIE,PA I WANTED TO INFORM D.O.T. ANONYMOUSLY. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
NHTSA ODI #10604266
30,000 miles · Nov 22, 2013
Service Brakes
TL* THE CONTACT OWNS A 2004 FORD E-450. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 40 MPH, THE BRAKES SUDDENLY ENGAGED INDEPENDENTLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS. THE MECHANIC STATED THAT THE ALUMINUM PUCKS IN THE BRAKING SYSTEM EXPANDED WHEN HEATED, CAUSING THE BRAKES TO ENGAGE. THE M…
Read full complaint
TL* THE CONTACT OWNS A 2004 FORD E-450. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 40 MPH, THE BRAKES SUDDENLY ENGAGED INDEPENDENTLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS. THE MECHANIC STATED THAT THE ALUMINUM PUCKS IN THE BRAKING SYSTEM EXPANDED WHEN HEATED, CAUSING THE BRAKES TO ENGAGE. THE MECHANIC RECOMMENDED REPLACING THE ALUMINUM PUCKS WITH STEEL ONES. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 30,000. UPDATED 3/28/14*CN
NHTSA ODI #10553339
26,000 miles · Aug 7, 2013
Service Brakes
TL* THE CONTACT OWNS A 2004 FORD E450 SD. THE CONTACT STATED THAT WHILE DRIVING VARIOUS SPEEDS, THE BRAKES WOULD SEIZE INDEPENDENTLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS WHERE BOTH THE FRONT AND REAR BRAKES WERE REPLACED. THE MASTER CYLINDER WAS ALSO INCLUDED IN THE REPAIR. THE FAILURE RECURRED NUMEROU…
Read full complaint
TL* THE CONTACT OWNS A 2004 FORD E450 SD. THE CONTACT STATED THAT WHILE DRIVING VARIOUS SPEEDS, THE BRAKES WOULD SEIZE INDEPENDENTLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS WHERE BOTH THE FRONT AND REAR BRAKES WERE REPLACED. THE MASTER CYLINDER WAS ALSO INCLUDED IN THE REPAIR. THE FAILURE RECURRED NUMEROUS TIMES. THERE HAD BEEN OTHER REPAIRS THAT INVOLVED THE REPLACEMENT OF THE BRAKES. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 26,000.
CERTAIN PICKUP TRUCKS, SPORT UTILITY VEHICLES AND VANS EQUIPPED WITH 6.0L DIESEL ENGINES MAY EXPERIENCE STALLING WITHOUT WARNING WHILE DRIVING AND MAY OR MAY NOT RESTART.
Consequence & remedy
Consequence: SHOULD THE ENGINE STALL, A VEHICLE CRASH COULD OCCUR.
Remedy: DEALERS WILL UPGRADE THE FUEL INJECTION CONTROL MODULE (FICM) WIRE HARNESS OR REPLACED, AND/OR HAVE A NEW INJECTION CONTROL PRESSURE (ICP)) SENSOR CONNECTOR INSTALLED FREE OF CHARGE. THE RECALL BEGAN ON JULY 22, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
ON CERTAIN VANS, A DIODE IN THE ANTI-LOCK BRAKING SYSTEM (ABS) MODULE MAY EXPERIENCE AN ELECTRICAL SHORT.
Consequence & remedy
Consequence: THE ELECTRICAL SHORT MAY CAUSE AN ABS MALFUNCTION THAT WOULD ILLUMINATE THE ABS WARNING LIGHT, OR THE MODULE MAY OVERHEAT RESULTING IN A BURNING ODOR, SMOKE, AND/OR FIRE. THIS CONDITION MAY OCCUR WHILE THE VEHICLE IS BEING DRIVEN OR UNATTENDED.
Remedy: DEALERS WILL INSTALL A NEW FUSE IN THE ABS CIRCUIT AND INSTALL A HEAT SHIELD OVER THE ABS MODULE. THE RECALL BEGAN ON OCTOBER 15, 2004. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673. ALSO FORD IS EXTENDING THE LIMITED WARRANTY (FOR A ONE TIME REPLACEMENT) OF THE ABS MODULE FOR A TOTAL OF 10 YEARS OR 150,000 MILES FROM THE WARRANTY START DATE, WHICHEVER OCCURS FIRST. IF YOUR VEHICLE HAS ALREADY ACCUMULATED MORE THAN 150,000 MILES, THIS COVERAGE WILL LAST UNTIL SEPTEMBER 30, 2005.
ON CERTAIN VANS, THE AIR FILTER ELEMENT MATERIAL PROCESS RESULTED IN AN AIR FILTER PAPER ELEMENT THAT CAN SMOLDER OR BURN. THIS CHANGE IN FILTER PAPER COMPOSITION COMBINED WITH THE CONFIGURATION OF THE AIR INDUCTION SYSTEM, MAY ALLOW HOT CARBON PARTICLES TO CONTACT THE AIR FILTER ELEMENT DURING CERTAIN DRIVING CONDITIONS THAT CREATE HOT PARTICLES.
Consequence & remedy
Consequence: THESE HOT PARTICLES MAY IGNITE THE AIR FILTER ELEMENT WITH THE POTENTIAL FOR AIR INDUCTION SYSTEM DAMAGE OR UNDERHOOD FIRE.
Remedy: DEALERS WILL INSPECT AND REPLACE THE AIR FILTER ELEMENT. THE RECALL BEGAN SEPTEMBER 27, 2004. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673. ALSO FORD IS EXTENDING THE LIMITED WARRANTY (FOR A ONE TIME REPLACEMENT) OF THE ABS MODULE FOR A TOTAL OF 10 YEARS OR 150,000 MILES FROM THE WARRANTY START DATE, WHICHEVER OCCURS FIRST. IF YOUR VEHICLE HAS ALREADY ACCUMULATED MORE THAN 150,000 MILES, THIS COVERAGE WILL LAST UNTIL SEPTEMBER 30, 2005.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE09055 · Hvac Switch Failures
Opened Dec 7, 2009 · Closed Apr 21, 2010
Status: closed (inferred from source dates) · Electrical System:wiring:interior/under Dash
ODI has received 1 complaint and reports from 4 transportation fleets alleging 182 switch failures.Each fleet operates mini buses built on a Ford E350 or E450 cutaway chassis.The OEM HVAC blower switches have melted, smoked, burned or experienced open flame and become inoperable on vehicles in each fleet.Some drivers have reported a burning smell or smoke coming from the dash.One fleet reported a vehicle fire.No injuries were sustained.However, the bus was carrying special needs children when the driver noticed smoke coming from the dash.The driver was able to evacuate the children prior to the vehicle becoming engulfed in flames.This PE has been upgraded to an Engineering Analysis (EA) to determine if the blower motor switch failures create a situation where a vehicle fire is possible and presents a safety risk to the driver and other passengers.
2004 Ford E-450 Problems, Complaints & Recalls | Skip That Year
Illustration