NHTSA owner reports · September 18, 2026 snapshot.
Engine And Engine Cooling complaints
11 reportsClear category filterMileage unknown · Oct 16, 2011
Engine And Engine CoolingService Brakes, HydraulicVehicle Speed Control
I WAS TRAVELING HOME TO CAMDEN, TN FROM WEST FRANKFORT, IL WITH MY CHILDREN ON HWY 69. CRUISE CONTROL WAS ENGAGED. WHEN ENTERING A LOWER SPEED ZONE, I ATTEMPTED TO SLOW THE VEHICLE, BUT AFTER ATTEMPTING TO SLOW THE VEHICLE, UPON RELEASING THE BRAKE, THE VEHICLE WOULD INCREASE IN SPEED AGAIN AND THE ENGINE CONTINUED TO RUN HIGH.…
Read full complaint
I WAS TRAVELING HOME TO CAMDEN, TN FROM WEST FRANKFORT, IL WITH MY CHILDREN ON HWY 69. CRUISE CONTROL WAS ENGAGED. WHEN ENTERING A LOWER SPEED ZONE, I ATTEMPTED TO SLOW THE VEHICLE, BUT AFTER ATTEMPTING TO SLOW THE VEHICLE, UPON RELEASING THE BRAKE, THE VEHICLE WOULD INCREASE IN SPEED AGAIN AND THE ENGINE CONTINUED TO RUN HIGH. I KNEW THERE WAS A MAJOR PROBLEM WHEN I WAS GOING UPHILL AND THE VEHICLE WAS INCREASING IN SPEED RELATIVELY QUICKLY. I PRESSED HARD ON THE BRAKES, BUT THE BRAKES WERE VERY HARD TO PRESS. I KNEW WE WERE IN TROUBLE AT THIS POINT BECAUSE I HAD JUST REPLACED ALL FOUR BRAKES THE WEEK BEFORE, SO I KNEW THE BRAKES WERE FINE. I SHIFTED THE VEHICLE INTO NEUTRAL, ENGAGED THE EMERGENCY BRAKE, AND MANAGED TO PULL THE VEHICLE OFF TO THE SHOULDER IN FRONT OF A BP GAS STATION IN MURRAY, KY. I TURNED OFF THE CAR, WAITED ABOUT ONE MINUTE AND STARTED IT AGAIN, BUT THE VEHICLE WAS RUNNING HIGH, AS THOUGH THE ACCELERATOR WAS STUCK. A FRIEND CAME TO HELP ME AND WE MANAGED TO GET THE VEHICLE RUNNING AGAIN AND I TRAVELED HOME THE NEXT DAY. THE SAME THING HAPPENED AGAIN ON 10/14/2011. I WAS TRAVELING TO WORK WITH A CO-WORKER AND I PUT THE VEHICLE INTO CRUISE (FOR THE FIRST TIME SINCE THE SEPTEMBER INCIDENT). SUDDENLY, UPON TRYING TO SLOW DOWN TO MAKE A RIGHT HAND TURN, THE VEHICLE BRAKES BECAME VERY HARD TO PRESS, THE ENGINE RAN HIGH, AND THE SPEED BEGAN TO INCREASE. I IMMEDIATELY KNEW THAT THE SAME THING WAS HAPPENING AS BEFORE, SO I IMMEDIATELY LOOKED FOR A SAFE PLACE TO PULL OVER (NO GOOD SHOULDERS ON A WINDY COUNTRY ROAD), PUT THE VEHICLE IN NEUTRAL, ENGAGED THE EMERGENCY BRAKE, STOPPED AND TURNED OFF THE VEHICLE. WHEN I TURNED IT BACK ON, IT WAS RUNNING HIGH STILL. I TURNED IT OFF, SHOOK THE ACCELERATOR PEDAL VIGOROUSLY AND THE VEHICLE RAN LIKE NORMAL. I HAVE NOT USED THE CRUISE CONTROL SINCE AND HAVE REMAINED WITHOUT INCIDENT. *TR
NHTSA ODI #10430375
112,000 miles · Jan 11, 2010
Engine And Engine CoolingFire
AS I WAS WATCHING TV IN MY HOUSE WITH MY SON. I NOTICED SOME YELLOW FLICKERING LIGHTS THROUGH MY WINDOW SHADES. I THOUGHT THERE WAS A TOW TRUCK OUT FRONT. I OPENED THE SHADE AND IT WAS MY VAN ON FIRE. *TR
NHTSA ODI #10299075
Mileage unknown · Jun 23, 2008
Engine And Engine CoolingFire
TL*THE CONTACT OWNED A 1992 FORD E150. THE ENGINE COMPARTMENT CAUGHT FIRE WHILE THE VEHICLE WAS PARKED. THE CONTACT CALLED THE FIRE DEPARTMENT, BUT EXTINGUISHED THE FIRE BEFORE THEY ARRIVED. SHE WAS INFORMED THAT THE FIRE ORIGINATED BETWEEN THE HEADLIGHTS AND DASHBOARD. A POLICE REPORT WAS FILED. THE VEHICLE WAS DESTROYED A…
Read full complaint
TL*THE CONTACT OWNED A 1992 FORD E150. THE ENGINE COMPARTMENT CAUGHT FIRE WHILE THE VEHICLE WAS PARKED. THE CONTACT CALLED THE FIRE DEPARTMENT, BUT EXTINGUISHED THE FIRE BEFORE THEY ARRIVED. SHE WAS INFORMED THAT THE FIRE ORIGINATED BETWEEN THE HEADLIGHTS AND DASHBOARD. A POLICE REPORT WAS FILED. THE VEHICLE WAS DESTROYED AND THE CONTACT RECEIVED APPROXIMATELY 5-6 RECALL NOTICES. THE CURRENT AND FAILURE MILEAGES WERE UNKNOWN.
NHTSA ODI #10232072
Mileage unknown · Aug 7, 2001
Engine And Engine Cooling
EXHAUST MANIFOLD BROKE, FUMES STARTED COMING INTO VEHICLE. MANIFOLD HAS BEEN REPLACED TWICE. CONTACTED FORD, AND FORD STATED IT WAS OUT OF WARRANTY.*AK
NHTSA ODI #893735
Mileage unknown · Feb 16, 2001
Engine And Engine Cooling
FUEL VENT LINE HOSE DEVELOPED CRACKS. WHEN TANK IS FULL WITH GAS VENT LINE LEAKS. FORD HAS NOT BEEN CONTACTED. *AK
NHTSA ODI #880726
Mileage unknown · Nov 22, 1999
Engine And Engine Cooling
ENGINE OIL PAN HAS CORRODED AND RUSTED THROUGH, CAUSING AN OIL LEAK IN THE VEHICLE. DEALER SAID OIL PAN NEEDED TO BE REPLACED. *AK
NHTSA ODI #851563
Mileage unknown · Sep 1, 1998
Electrical SystemEngine And Engine Cooling
THE VEHICLE OVERHEATS, BUT THERE IS NO TRACE OF LEAKAGE. THE OVERHEATING HAS BLOWN A FUSE, CAUSING THE CARGO LIGHTS /THE RADIO AND THE TRANSMISSION TO MALFUNCTION. THE MANUFACTURER WILL BE NOTIFIED. *AK
NHTSA ODI #827476
Mileage unknown · Aug 29, 1997
Engine And Engine Cooling
THE OIL PAN IS RUSTING THROUGH.
NHTSA ODI #523031
Mileage unknown · Aug 27, 1996
Engine And Engine CoolingService Brakes, HydraulicSteering
WHEN APPLYING THE BRAKES, THE VEHICLE PULLS TO THE RIGHT/REPLACED FRONT BRAKE ROTORS/ CALIPER PIN, ALSO POWER STEEERING BELT/ENGINE BELTS FAILED, CAUSING ENGINE NOISE/FRONT END MISALIGNMENT, RESULTING IN VEHICLE PULLING TO THE RIGHT. *AK
NHTSA ODI #800302
Mileage unknown · Jul 8, 1996
Engine And Engine Cooling
OILPAN RUSTED THROUGH CAUSING AN OIL LEAK AND A FIRE ONTO CROSSOVER EXHAUST PIPE. LUCKILY NO DAMAGE FROM FIRE. *AK
NHTSA ODI #985691
Official recalls
4Oct 13, 2009
FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Consequence & remedy
Consequence: A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.
Remedy: FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
Feb 4, 2008
FORD IS RECALLING 225,000 MY 1992-2003 ECONOLINE, MY 1993-1995 TAURUS SHO, MY 1992-1998 CROWN VICTORIA, MY 1993 BRONCO, F-SERIES, MY 1995-1997 F-SERIES SUPER DUTY STRIPPED CHASSIS, MY 1992-1998 MERCURY GRAND MARQUIS, AND MY 1992-1995 LINCOLN TOWN CAR VEHICLES. THE AFFECTED VEHICLES WERE PREVIOUSLY REPAIRED USING A WIRING HARNESS THAT IS NOT COMPATIBLE WITH THE VEHICLE CIRCUIT POLARITY.
Consequence & remedy
Consequence: AS A RESULT, THE FUSE IS LOCATED IN THE OUTPUT CIRCUIT RATHER THAN IN THE INTENDED INPUT POWER FEED CIRCUIT, AND MAY NOT OFFER THE INTENDED PROTECTION IN THE EVENT OF AN ELECTRICAL SHORT TO GROUND.
Remedy: DEALERS WILL INSTALL A NEW WIRING HARNESS, OR REPLACE THE MATING ELECTRICAL COMPONENT. THE RECALL BEGAN ON FEBRUARY 18, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Aug 3, 2007
ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Consequence & remedy
Consequence: THIS COULD RESULT IN AN UNDERHOOD FIRE.
Remedy: DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
Aug 24, 1992
THE TIRE CERTIFICATION LABELS INCORRECTLY IDENTIFY THE VEHICLE TIRE REQUIREMENTS AS P235/75R15 SL (STANDARD LOAD), RATHER THAN AS P235/75R15 XL (EXTRA LOAD).
Consequence & remedy
Consequence: THE CERTIFICATION LABELS ON THE AFFECTED VEHICLES DO NOTCOMPLY WITH FMVSS 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THANPASSENGER CARS." INCORRECT TIRE SELECTION COULD RESULT IN SUDDEN FAILURE OFA TIRE WHILE THE VEHICLE IS IN MOTION, AND RESULT IN A VEHICLE ACCIDENT.
Remedy: CORRECT TIRE INFORMATION LABELS AND INSTALLATION INSTRUCTIONS WILL BE MAILED TO THE OWNERS OF THESE VEHICLES. OWNERS WILL BE INSTRUCTED THAT DEALERS CAN INSTALL THE LABEL PROVIDED IF THEY PREFER.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3PE96072 · Loss Of Steering Control
Opened Dec 5, 1996 · Closed Apr 29, 1997
Status: closed (inferred from source dates) · Steering
There is no summary currently available
EA93020 · Parking Brake Failure
Opened Jul 28, 1993 · Closed Sep 23, 1994
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
Additional source detail variants (2)
Service Brakes, Hydraulic
There is no summary currently available
Service Brakes, Hydraulic
There is no summary currently available
PE93015 · Parking Brake Failure
Opened Mar 9, 1993 · Closed Jul 27, 1993
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
Illustration