1.RIDING ONE NIGHT HEADLIGHTS JUST GO OFF ON THE HIGHWAY,SMELLED PLASTIC BURNING/ 2.HEADLIGHT SWITCH OVERHEATING MELTING PLUG CONNECTED TO WIRING/ HAPPENS ALL THE TIME/ FIRE OR EVEN CAUSE A WRECK OR GET A TRAFFIC VIOLATION. …
Read full complaint
1.RIDING ONE NIGHT HEADLIGHTS JUST GO OFF ON THE HIGHWAY,SMELLED PLASTIC BURNING/ 2.HEADLIGHT SWITCH OVERHEATING MELTING PLUG CONNECTED TO WIRING/ HAPPENS ALL THE TIME/ FIRE OR EVEN CAUSE A WRECK OR GET A TRAFFIC VIOLATION. 3.CHANGED SWITCH CHANGED PLUG SAME THING HAPPENED AGAIN &AGAIN,LOOKED AT PARTS ON OTHER CARS SAME MODEL SAME YEAR DIFFERENT MODEL DIFFERENT YEAR SAME PROBLEM IN THE SAME SPOT!! [ THE FORD 1992 CROWN VICTORIA]. *TR
NHTSA ODI #10307687
Mileage unknown · May 1, 2005
Electrical System
MY FATHER BOUGHT A USED 1992 FORD CROWN VICTORIA LS. WHEN YOU TURN ON THE PARK OR DRIVING LIGHTS, THE ENTIRE DASHBOARD IS SO DIM YOU CAN HARDLY READ THE SPEEDOMETER. I HAVE BEEN DRIVING THE CAR FOR MY FATHER AND IT IS AN ACCIDENT WAITING TO HAPPEN. IN THE EVENING, THE PROBLEM RESOLVES ITSELF, IT IS DURING THE DAY.*AK
NHTSA ODI #10118788
100,000 miles · Mar 28, 2005
Electrical SystemFire
WHILE DRIVING 60 MPH THE BRAKE SENSOR LIGHT CAME ON AND THE VEHICLE BEGAN SMOKING WITHOUT WARNING. WHEN THE CONSUMER PULLED OFF THE ROAD HE NOTICED THAT FLAMES WERE COMING FROM THE FRONT END. AS A RESULT THE VEHICLE WAS CONSIDERED A TOTAL LOSS. *NM THE FIRE DEPARTMENT INDICATED IT WAS A ELECTRICAL FIRE. *BF
NHTSA ODI #10113077
Mileage unknown · Dec 26, 2003
Electrical System
ELECTRONIC ENGINE CONTROL (COMPUTER) FAILED TWICE CAUSING ENGINE TO STALL.*AK
NHTSA ODI #10051106
Mileage unknown · Aug 6, 2002
Electrical System
LOTS OF HEAT IS COMING FROM STEERING COLUMN, EVEN WHEN IGNITION IS TURNED OFF. CONSUMER IS CONCERNED ABOUT THE POSSIBILITY OF AN ELECTRICAL FIRE, THE CONSUMER BELIEVES THIS PROBLEM IS RELATED TO RECALL 96V-071.*AK
NHTSA ODI #8015648
Mileage unknown · May 8, 2002
Electrical System
CAR STALLS AT ALL SPEEDS WHEN GAS ISNT BEING APPLIED-SAME DIAGNOSIS FOR 1991' MODELS RECALLED! I BELIEVE MY 1992 IS EARLY MODEL W/SAME EXACT SYMPTOMS!*AK
NHTSA ODI #761696
Mileage unknown · Mar 1, 2001
Electrical SystemStructureVisibility
DASHBOARD LIGHT COMES ON AND OFF INTERMENTETLY. HEADLIGHTS/WINDSHIELD, AND SUN ROOF ARE NOT OPERABLE. DEALERSHIP IS AWARE OF PROBLEM.*AK SUN ROOF HAD ELECTRICAL SURGE AND BLEW OUT A CONTROL MODULE. THE SAME THING OCCURED WITH LEFT REAR DOOR MOTOR. *YH
NHTSA ODI #881892
Mileage unknown · Feb 20, 2001
Electrical SystemFire
VEHICLE CAUGHT ON FIRE DUE TO A DEFECTIVE SPEED CONTROL DEACTIVATION SWITCH AND CONNECTOR SHELL WHICH RELATES TO RECALL 99V124, HOWEVER FORD FOUND NO EVIDENCE OF A MANUFACTURING OR DESIGN DEFECT AND DENIED ANY LIABILITY FOR THE CLAIM. (ATTORNEY FOR CLIENT) *SLC REFERENCED IN EA02-025
NHTSA ODI #559762
Mileage unknown · Aug 11, 2000
Electrical System
IGNITION SWITCH OVERHEATS WHILE DRIVING, CAUSING KEY TO GET HOT. DEALER HAS BEEN CONTACTED. *AK PROBLEM MUST HAVE BEEN STARTER SHORT, THEY REPLACED STARTER AND HAVE NOT HAD PROBLEM. *YH
NHTSA ODI #867570
Mileage unknown · May 11, 2000
Electrical SystemEngine And Engine CoolingEquipment
CLEARCOAT OF PAINT COMING OFF IN BLOCKS/STRIPS,FLY ONTO WINDSHIELD WHILE DRIVING, PAINT RUSTING. BRAKE PEDAL DOESN'T RETURN UP, POPS UP WHEN TURNING & ROUGH ON ROUGH RD.,WEAR OUT QUICKLY. ELEC. DR. LOCKS DON'T WORK. DRIVER ELEC. SEAT WONT GO BACK,ENGINE:SPARK KNOCK,CAR PULLS LEFT, ENGINE CHECK LIGHT GOES ON,SOLENOID REPLACED 3X…
Read full complaint
CLEARCOAT OF PAINT COMING OFF IN BLOCKS/STRIPS,FLY ONTO WINDSHIELD WHILE DRIVING, PAINT RUSTING. BRAKE PEDAL DOESN'T RETURN UP, POPS UP WHEN TURNING & ROUGH ON ROUGH RD.,WEAR OUT QUICKLY. ELEC. DR. LOCKS DON'T WORK. DRIVER ELEC. SEAT WONT GO BACK,ENGINE:SPARK KNOCK,CAR PULLS LEFT, ENGINE CHECK LIGHT GOES ON,SOLENOID REPLACED 3X,FUSE BLOWS FOR INTERIOR LTS CLUSTER,DIFFICULTY REMOVING KEY FROM IGNIITION,SEAT TRACK COVERS OFF, CLIMATE CONTROL INOPERABLE PRECEEDED BY INITIAL HOT AIR FROM A/C, STEERING WHEEL VIBRATES,HOOD LATCH DIFFICULT TO CLOSE. *AK
FORD IS RECALLING 225,000 MY 1992-2003 ECONOLINE, MY 1993-1995 TAURUS SHO, MY 1992-1998 CROWN VICTORIA, MY 1993 BRONCO, F-SERIES, MY 1995-1997 F-SERIES SUPER DUTY STRIPPED CHASSIS, MY 1992-1998 MERCURY GRAND MARQUIS, AND MY 1992-1995 LINCOLN TOWN CAR VEHICLES. THE AFFECTED VEHICLES WERE PREVIOUSLY REPAIRED USING A WIRING HARNESS THAT IS NOT COMPATIBLE WITH THE VEHICLE CIRCUIT POLARITY.
Consequence & remedy
Consequence: AS A RESULT, THE FUSE IS LOCATED IN THE OUTPUT CIRCUIT RATHER THAN IN THE INTENDED INPUT POWER FEED CIRCUIT, AND MAY NOT OFFER THE INTENDED PROTECTION IN THE EVENT OF AN ELECTRICAL SHORT TO GROUND.
Remedy: DEALERS WILL INSTALL A NEW WIRING HARNESS, OR REPLACE THE MATING ELECTRICAL COMPONENT. THE RECALL BEGAN ON FEBRUARY 18, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Consequence & remedy
Consequence: THIS COULD RESULT IN AN UNDERHOOD FIRE.
Remedy: DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE SPEED CONTROL DEACTIVATION SWITCH CAN DEVELOP A RESISTIVE SHORT IN THE ELECTRICAL CIRCUIT THAT COULD POTENTIALLY RESULT IN AN UNDERHOOD FIRE. A FIRE IS POSSIBLE BOTH WHEN THE VEHICLE IS RUNNING AND WHEN THE VEHICLE ENGINE IS OFF. ALSO, THE SHORT COULD DISABLE THE SPEED CONTROL SYSTEM OR CAUSE THE BRAKE LIGHT FUSE TO OPEN.
Consequence & remedy
Consequence: A FIRE CAN ORIGINATE IN THE LEFT FRONT UNDERHOOD AREA.
Remedy: DEALERS WILL INSTALL A NEW SPEED CONTROL DEACTIVATION SWITCH AND CONNECTOR SHELL. OWNER NOTIFICATION BEGAN MAY 20, 1999.
VEHICLE DESCRIPTION: CERTAIN 1996-1999 FORD CROWN VICTORIA POLICE, FLEET, NATURAL GAS, AND 1996-1999 LINCOLN TOWN CAR LIMOUSINE VEHICLES THAT WERE PRODUCED WITH A LOWER CONTROL ARM BALL JOINT CONTAINING A ONE PIECE BEARING; AND 1990-1996 FORD CROWN VICTORIA POLICE, FLEET, AND NGV VEHICLES AND 1990-1996 LINCOLN TOWN CAR LIMOUSINE VEHICLES THAT HAVE BEEN SERVICED WITH EITHER A BALL JOINT CONTAINING THE ONE-PIECE BEARING OR A FRONT LOWER CONTROL ARM CONTAINING A BALL JOINT WITH A ONE-PIECE BEARING. THE ONE-PIECE BEARING WITHIN THE LOWER CONTROL ARM BALL JOINT CAN WEAKEN SLOWLY DURING USE AND EVENTUALLY CRACK. THIS COULD RESULT IN SEPARATION OF THE BALL AND CAP OF THE JOINT, ALLOWING THE CONTROL ARM TO DROP TO THE GROUND.
Consequence & remedy
Consequence: IF THIS OCCURS WHILE THE VEHICLE IS MOVING, REDUCED STEERING CONTROL COULD OCCUR, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE LOWER CONTROL ARM BALL JOINTS (2).
VEHICLE DESCRIPTION: POLICE AND TAXI VEHICLES. THE HOOD LATCH STRIKER CAN WEAR OR BECOME DETACHED FROM THE HOOD.
Consequence & remedy
Consequence: EITHER OF THESE CONDITIONS CAN RESULT IN THE HOOD OPENING WITHOUT WARNING WHILE THE VEHICLE IS BEING OPERATED IMPAIRING THE DRIVER'S VISIBILITY.
Remedy: DEALERS WILL INSTALL AN IMPROVED HOOD LATCH STRIKER (VEHICLES WITH 1992 MODEL HOODS) OR REVISED STRIKER PLATE ATTACHING FASTENERS (VEHICLES WITH 1993-1997 MODEL HOODS).
AN UNUSED POWER SEAT HARNESS CONNECTOR IS POSITIONED ON THE RUBBER FLOOR MAT UNDER THE SEAT. IF THE VEHICLE IS OPERATED IN COLD WEATHER IN AREAS THAT HAVE LARGE AMOUNTS OF SALT USED FOR SNOW AND ICE CONTROL, A PUDDLE OF SALTWATER CAN ACCUMULATE ON THE RUBBER FLOOR MATS, REPEATEDLY WETTING THE CONNECTOR. THIS WILL RESULT IN CORROSION OF THE CONNECTOR, CAUSING A CURRENT TO FLOW BETWEEN THE TERMINALS WITHOUT TRIPPING THE CIRCUIT BREAKER.
Consequence & remedy
Consequence: IF THIS OCCURS, CURRENT FLOW CAN HEAT THE CONNECTOR ANDRELEASE FUMES INTO THE PASSENGER COMPARTMENT, AND CAN RESULT IN A VEHICLE FIRE.
Remedy: DEALERS WILL REMOVE THE UNUSED CONNECTOR AND INSTALL A SEALED HEAT SHRINK CAP OVER THE AFFECTED WIRES.
INCORRECT INSTRUMENT PANEL WIRING ASSEMBLIES IN SOME VEHICLES WILL NOT ACTUATE THE "ANTI-LOCK" BRAKE WARNING LIGHTS.
Consequence & remedy
Consequence: THE VEHICLES DO NOT MEET THE SPECIFICATIONS OF FMVSS 105.THE DRIVER WOULD NOT BE AWARE WHEN THE ANTI-LOCK BRAKE SYSTEM IS MALFUNCTIONING.
Remedy: MODIFY THE WIRE ASSEMBLY TO ALLOW ACTUATION OF THE ANTI-LOCK BRAKE WARNING LIGHTS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
10
EA02025 · Speed Control Deactivation Switch Fires
Opened Sep 6, 2002 · Closed Jun 30, 2004
Status: closed (inferred from source dates) · Engine And Engine Cooling
BASED ON THE LOW RATE OF FIRE INCIDENTS (2.5 INCIDENTS PER 100,000 VEHICLES SOLD) WHERE FAILURE OF THE SCDS IS INVOLVED AND THE AGE OF THE VEHICLES ? 7 TO 11 YEARS ? A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
DP02007 · FUEL-FED Fires
Opened Aug 22, 2002 · Closed Dec 4, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
THE FARS DATA SHOWS THAT THE RISK OF FIRE FROM IMPACT IN ALL DIRECTIONS IN THE SUBJECT VEHICLES IS THE SAME AS ALL OTHER SEDANS.THE SUBJECT VEHICLES ARE NOT OVER REPRESENTED WITH RESPECT TO THE RISK OF FIRE IN REAL-WORLD HIGH-ENERGY CRASHES.A FURTHER DISCUSSION OF ISSUES RELATED TO POST CRASH FIRES IN THE SUBJECT VEHICLES IS SET OUT IN THE CLOSING REPORT FOR SQ 01-014 AND THAT REPORT IS IN THE DOCKET FOR THIS PETITION.AFTER REVIEWING THE PETITION AND ITS SUPPORTING MATERIALS, AS WELL AS INFORMATION FURNISHED BY FORD AND GM, AND INFORMATION WITHIN THE AGENCY'S POSSESSION FROM PREVIOUS INVESTIGATIONS AND OTHER RELATED ACTIONS,NHTSA HAS CONCLUDED THAT FUTHER INVESTIGATION CONCERNING POST-CRASH FIRES IN THE SUBJECT VEHICLES IS NOT LIKELY TO LEAD TO A DECISION THAT THE VEHICLES CONTAIN A SAFETY DEFECT.
SQ01014 · Post Rear End Collision Fires
Opened Nov 27, 2001 · Closed Oct 3, 2002
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage
There is no summary currently available
RQ01002 · Engine Compartment Fires
Opened Sep 20, 2001 · Closed Sep 6, 2002
Status: closed (inferred from source dates) · Engine And Engine Cooling
No summary supplied.
EA95011 · Undercarriage Fuel Line Interference
Opened Mar 29, 1995 · Closed Jan 30, 1997
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
PE94077 · Fuel Line Interference
Opened Nov 4, 1994 · Closed Mar 29, 1995
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
PE94073 · Brake Line Punctures
Opened Oct 4, 1994 · Closed Dec 28, 1994
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
EA94022 · Steering Power Assist Fail
Opened Jun 30, 1994 · Closed Mar 2, 1995
Status: closed (inferred from source dates) · Steering
There is no summary currently available
PE94032 · Steering Power Assist Failure
Opened Apr 8, 1994 · Closed Jun 30, 1994
Status: closed (inferred from source dates) · Steering
There is no summary currently available
PE93086 · Hood FLY-UP While Driving
Opened Oct 1, 1993 · Closed Feb 28, 1994
Status: closed (inferred from source dates) · Structure
There is no summary currently available
1992 Ford Crown Victoria Problems, Complaints & Recalls | Skip That Year
Illustration