WHEN THE VEHICLE WAS IDLING THE CONSUMER SMELLED A HEAVY SCENT OF OIL BURNING. WHILE DRIVING AT 65 MPH, THE ENGINE BEGAN REVVING AT A HIGH RATE. ALSO, THE TRANSMISSION GEARS WOULD NOT GO INTO THIRD OR FOURTH GEAR. THE VEHICLE WAS TAKEN TO THE DEALER, WHO INFORMED THE CONSUMER THAT THE BUSHING WAS MADE OF PLASTIC. HOWEVER, …
Read full complaint
WHEN THE VEHICLE WAS IDLING THE CONSUMER SMELLED A HEAVY SCENT OF OIL BURNING. WHILE DRIVING AT 65 MPH, THE ENGINE BEGAN REVVING AT A HIGH RATE. ALSO, THE TRANSMISSION GEARS WOULD NOT GO INTO THIRD OR FOURTH GEAR. THE VEHICLE WAS TAKEN TO THE DEALER, WHO INFORMED THE CONSUMER THAT THE BUSHING WAS MADE OF PLASTIC. HOWEVER, THE BUSHING SHOULD BE MADE FROM METAL. THE MANUFACTURER HAD BEEN INFORMED. *AK WHEN THE CABLE LINKAGE WAS DISCONNECTED, THE DESTRUCTION OF THE CLUTCH WOULD OCCUR. (LOCKING UP THE HIGHER TWO GEARS, WITHOUT THE LOCK UP ONLY THE FIRST AND SECOND GEAR WOULD WORK) *SCC *JB
NHTSA ODI #10046325
Mileage unknown · Oct 21, 1999
Power Train
WHEN GEAR INDICATOR IS PUT INTO DRIVE THE GEAR SHIFT WILL GO ALL THE WAY DOWN TO 1ST GEAR. DEALER REPLACED CABLE LINKAGE AND PROBLEM IS OCCURRING AGAIN. *AK
NHTSA ODI #851429
Mileage unknown · Jul 27, 1999
Power Train
PLASTIC GROMMET DETERIORATED CAUSING THE OVER DRIVE TO BURN OUT. YH
NHTSA ODI #547554
Mileage unknown · Jul 7, 1998
Power TrainInjury
TAXI DRIVER PLACED TRANSMISSION IN PARK GEAR AND EXITED VEHICLE. UPON OPENING REAR DOOR FOR PASSENGER, VEHICLE ROLLED, DRAGGING PASSENGER DOWN THE STREET, CAUSING INJURY.
NHTSA ODI #537364
Mileage unknown · Jul 1, 1998
Power TrainCrashInjury
WHILE EXITING VEHICLE WAS PLACED IN PARK, VEHICLE CAME OUT OF PARK AND ROLLED OVER, INJURYING PASSENGER. POSSIBLE CAUSE TRANSMISSION CAM. *AK
VEHICLE DESCRIPTION: CERTAIN 1996-1999 FORD CROWN VICTORIA POLICE, FLEET, NATURAL GAS, AND 1996-1999 LINCOLN TOWN CAR LIMOUSINE VEHICLES THAT WERE PRODUCED WITH A LOWER CONTROL ARM BALL JOINT CONTAINING A ONE PIECE BEARING; AND 1990-1996 FORD CROWN VICTORIA POLICE, FLEET, AND NGV VEHICLES AND 1990-1996 LINCOLN TOWN CAR LIMOUSINE VEHICLES THAT HAVE BEEN SERVICED WITH EITHER A BALL JOINT CONTAINING THE ONE-PIECE BEARING OR A FRONT LOWER CONTROL ARM CONTAINING A BALL JOINT WITH A ONE-PIECE BEARING. THE ONE-PIECE BEARING WITHIN THE LOWER CONTROL ARM BALL JOINT CAN WEAKEN SLOWLY DURING USE AND EVENTUALLY CRACK. THIS COULD RESULT IN SEPARATION OF THE BALL AND CAP OF THE JOINT, ALLOWING THE CONTROL ARM TO DROP TO THE GROUND.
Consequence & remedy
Consequence: IF THIS OCCURS WHILE THE VEHICLE IS MOVING, REDUCED STEERING CONTROL COULD OCCUR, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE LOWER CONTROL ARM BALL JOINTS (2).
THE REAR BRAKE LINES HAVE INADEQUATE CLEARANCE BETWEEN THE BRAKE TUBE AND THE VEHICLE UNDERBODY IN THE AREA OF THE LEFT REAR WHEEL OPENING.
Consequence & remedy
Consequence: INADEQUATE CLEARANCE CAN CAUSE ABRASION OF THE BRAKE LINEAND A LEAK CAN DEVELOP, RESULTING IN LOSS OF BRAKE FLUID TO THE REAR BRAKESYSTEM AND INCREASED STOPPING DISTANCES.
Remedy: REPAIR ANY BRAKE LINES THAT HAVE AN INDICATION OF CONTACT OR HAVE THE POTENTIAL FOR CONTACT WITH THE BODY OF THE VEHICLE. RELOCATE LINES, IF NECESSARY.
THE PARK ROD ASSEMBLY CONTAINS A PARK CAM WITH INADEQUATE SURFACE HARDNESS, WHICH COULD LEAD TO PARK DISENGAGEMENT OR NO PARK ENGAGEMENT WHEN THE LEVER IS PLACED IN PARK.
Consequence & remedy
Consequence: IF PARK IS NOT ENGAGED AND THE PARKING BRAKE IS OFF, AVEHICLE ROLL-AWAY COULD RESULT.
Remedy: REPLACE PARK ROD ASSEMBLY ON AUTOMATIC TRANSMISSIONS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
EA92002 · Brake Line Punctures
Opened Jan 15, 1992 · Closed May 21, 1992
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
PE91125 · Brake Line Punctures
Opened Sep 11, 1991 · Closed Jan 15, 1992
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
1991 Ford Crown Victoria Problems, Complaints & Recalls | Skip That Year
Illustration