NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
50 reportsMileage unknown · Feb 19, 2026
EngineService BrakesSteeringCrash
on Jan 15, 2025. A cold start for the Bronco, putting in reverse, the vehicle lurched back and to the hard right, uncommanded acceleration at a high rate of speed, steering locked up, brakes locked up, tires spinning, engine revving causing the bronco to smash into the exterior of my home garage area. Then, shifting to drive, …
Read full complaint
on Jan 15, 2025. A cold start for the Bronco, putting in reverse, the vehicle lurched back and to the hard right, uncommanded acceleration at a high rate of speed, steering locked up, brakes locked up, tires spinning, engine revving causing the bronco to smash into the exterior of my home garage area. Then, shifting to drive, the vehicle again lurched, uncommanded acceleration hard to the left now, steering locked up, brakes locked up, tires spinning engine revving traveling 20-30 feet crashing into the electrical box coming to rest on top of it. Numerous faults showing multiple systems malfunctioning causing this incident.
NHTSA ODI #11719009
Mileage unknown · Feb 8, 2026
Structure
Structural crack in molded in color roof compromising the integrity of vehicle roof.
NHTSA ODI #11716568
Mileage unknown · Jan 31, 2026
Forward Collision AvoidanceService Brakes
Loss of braking. Note weather was cold in single digits Fahrenheit and midly snowy. I drove my 2025 Ford Bronco that was purchased in Octorber about 20 minutes to drop off my child at daycare. Going into the daycare I turned to Slippery/4A mode. After about 5 minutes inside I pulled out and switched back to Normal/2H mode. Less …
Read full complaint
Loss of braking. Note weather was cold in single digits Fahrenheit and midly snowy. I drove my 2025 Ford Bronco that was purchased in Octorber about 20 minutes to drop off my child at daycare. Going into the daycare I turned to Slippery/4A mode. After about 5 minutes inside I pulled out and switched back to Normal/2H mode. Less than half a mile later I got multiple warnings that the brakes, EBB, collision detect, and ABS had faulted, and I should service now. I only had the electronic parking brake available. I was able to use it and engine braking with my manual transmission to get to off the road to a parking lot, although I did also receive a parking brake overheat fault the turn before getting into the parking lot. I shut the vehicle off without the parking brake on. I turned it back on and the dash warning lights all disappeared after a few seconds. Brake function returned and I drove it to a Ford service center about 1 mile away. They were not able to reproduce the problem or find any DTCs. I did get notifications of some of the faults to my Ford app on my phone. I am uploading the redacted RO and screenshots of the Ford notifications. Losing braking obviously put myself and my passenger pregnant wife at risk. Thankfully I was moving at lower speeds on a flat section of road and not taking a highway exit at the time of failure.
NHTSA ODI #11714693
Mileage unknown · Jan 15, 2026
Electrical SystemEngineVehicle Speed Control
While slowly backing into our home garage, the vehicle accelerated brakes were not working and smashed into the side of the house, put the car in drive to move it. It accelerated forward over correcting and drove into our power box and came to a halt. No brakes were working and the wheels/steering locked up.
NHTSA ODI #11711063
Mileage unknown · Jan 8, 2026
Electrical SystemEnginePower Train
While driving, after a missed downshift that causes engine bogging, the vehicle experiences a loss of engine power. The engine remains running but will not produce usable torque and will not rev above approximately 800 RPM, despite clutch disengagement and selecting the correct gear. Holding the clutch fully depressed does not i…
Read full complaint
While driving, after a missed downshift that causes engine bogging, the vehicle experiences a loss of engine power. The engine remains running but will not produce usable torque and will not rev above approximately 800 RPM, despite clutch disengagement and selecting the correct gear. Holding the clutch fully depressed does not immediately restore power; instead, after approximately 4 seconds, the engine stalls or cycles/resets, after which normal operation resumes. The condition persists until the vehicle nearly stops, the engine stalls, or the ignition is cycled. This has occurred in traffic and adverse weather conditions and is repeatable.”
NHTSA ODI #11709688
Mileage unknown · Dec 30, 2025
Exterior Lighting
Description of Incident: > While driving in freezing drizzle/sleet conditions in northern Minnesota, the factory-installed LED headlights on my 2025 Ford Bronco became obscured by ice buildup within 15 minutes of driving. The Safety Issue: > the LED headlights do not produce sufficient heat to melt frozen precipitation. This re…
Read full complaint
Description of Incident: > While driving in freezing drizzle/sleet conditions in northern Minnesota, the factory-installed LED headlights on my 2025 Ford Bronco became obscured by ice buildup within 15 minutes of driving. The Safety Issue: > the LED headlights do not produce sufficient heat to melt frozen precipitation. This resulted in a degradation of forward visibility during nighttime driving, creating a safety hazard. I was forced to pull over repeatedly on a high-speed roadway to manually scrape ice from the lenses. Request: > I am reporting this as a design defect for vehicles sold in northern climates. The lack of a heating element or de-icing mechanism in the standard LED equipment makes the vehicle unsafe for nighttime driving during freezing weather with high humidity conditions.
NHTSA ODI #11707925
Mileage unknown · Dec 8, 2025
Electrical SystemSteeringVehicle Speed ControlCrashInjury
Accident Statement – Instrument Panel Cluster Failure & Collision While driving my 2025 Ford Outerbanks, the Instrument Panel Cluster (IPC) screen suddenly went completely black without warning. At the time of the malfunction, I was attempting to merge into traffic on my left with my left turn signal activated. Simultaneously, …
Read full complaint
Accident Statement – Instrument Panel Cluster Failure & Collision While driving my 2025 Ford Outerbanks, the Instrument Panel Cluster (IPC) screen suddenly went completely black without warning. At the time of the malfunction, I was attempting to merge into traffic on my left with my left turn signal activated. Simultaneously, an 18-wheeler in the lane beside me was merging to his right. The sudden loss of my IPC screen meant I could not see my speedometer, warning indicators, safety messages, or any visibility cues needed to safely judge traffic speed and spacing. This created an immediate hazardous situation and made it extremely difficult to manage both my own speed and the surrounding traffic patterns. As I recognized the danger, I attempted to brake and avoid a collision. During this moment, my steering wheel began to shake slightly—possibly due to the lane-keeping or lane-safety system responding. Despite my efforts to correct and avoid impact, the 18-wheeler collided with my vehicle. At the time of the crash, I had no visibility of any dashboard warnings, alerts, vehicle speed, or safety notifications due to the IPC failure. My insurance representative has inspected my vehicle and deemed it a total loss.
NHTSA ODI #11703800
Mileage unknown · Dec 3, 2025
Exterior Lighting
Driving in sub-freezing temperatures with snow/rain falling and slush on the road, the headlights iced over with thick slush and ice and reduced visibility to dangerous levels requiring me to pull off the road and chip off the ice putting myself in a dangerous situation being on the side of the road during a storm.
NHTSA ODI #11702675
Mileage unknown · Nov 13, 2025
Power Train
The slave Cylinder failed causing the clutch to not fully disengage burning out the clutch at only 783 miles on the vehicle. Ford headquarters claims driver misuse, dealership disagrees at such low mileage.
NHTSA ODI #11699271
Mileage unknown · Oct 20, 2025
Unknown Or Other
When I purchased my vehicle I noticed the round rod that contains the backup camera, which is mounted on the spare tire bracket to be all scratched and scruffed up. The dealership (Hawk Ford, Carol Stream) agreed to replace this. Their are scratches inside where the camera sits around the threading and the rod it self is all b…
Read full complaint
When I purchased my vehicle I noticed the round rod that contains the backup camera, which is mounted on the spare tire bracket to be all scratched and scruffed up. The dealership (Hawk Ford, Carol Stream) agreed to replace this. Their are scratches inside where the camera sits around the threading and the rod it self is all banged up. I showed the dealer ship this and they replaced the mounting bracket, not the rod so when I got my car back I contacted them right away and sent before and after pictures. Manager went into lot and said all of the other ones he checked had the same issue. He was going to contact Ford to see if they were aware and how to go about this concern affecting my vehicle and all others on their lot. It should be new with no physical defects, but it appears used. When you buy a new car, you expect everything to be new and look new but this does not.
NHTSA ODI #11694461
Official recalls
19Jul 20, 2026
Ford Motor Company (Ford) is recalling certain 2021-2026 Bronco and Bronco Raptor vehicles. The engine compartment wiring harness may become damaged and short circuit.
Consequence & remedy
Consequence: A short circuit in the engine compartment can create heat or spark, increasing the risk of a fire.
Remedy: Dealers will install sheathing over the wiring, free of charge. This is a Phased campaign. Phase 1 will include 2026 Bronco Raptor notified owners on 7/31/2026. Phase 2 will include 2021-2025 Bronco Raptor vehicle will notify owners on or about 8/14/2026. Phase 3 will include 2021-2026 Bronco will notify owners on or about 9/1/2026. Owner notification letters were mailed August 5, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S55. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on July 23, 2026.
Additional source detail variants (2)
Engine
Ford Motor Company (Ford) is recalling certain 2021-2026 Bronco and Bronco Raptor vehicles. The engine compartment wiring harness may become damaged and short circuit.
Consequence: A short circuit in the engine compartment can create heat or spark, increasing the risk of a fire.
Remedy: Dealers will install sheathing over the wiring, free of charge. This is a Phased campaign. Phase 1 will include 2026 Bronco Raptor notified owners on 7/31/2026. Phase 2 will include 2021-2025 Bronco Raptor vehicle will notify owners on or about 8/14/2026. Phase 3 will include 2021-2026 Bronco will notify owners on or about 9/1/2026. Owner notification letters were mailed August 5, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S55. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on July 23, 2026.
Electrical System:wiring:front Underhood
Ford Motor Company (Ford) is recalling certain 2021-2026 Bronco and Bronco Raptor vehicles. The engine compartment wiring harness may become damaged and short circuit.
Consequence: A short circuit in the engine compartment can create heat or spark, increasing the risk of a fire.
Remedy: Dealers will install sheathing over the wiring, free of charge. This is a Phased campaign. Phase 1 will include 2026 Bronco Raptor notified owners on 7/31/2026. Phase 2 will include 2021-2025 Bronco Raptor vehicle will notify owners on or about 8/14/2026. Phase 3 will include 2021-2026 Bronco will notify owners on or about 9/1/2026. Owner notification letters were mailed August 5, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S55. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on July 23, 2026.
Jun 24, 2026
Ford Motor Company (Ford) is recalling certain 2022-2026 Bronco vehicles. The fender flares may not be properly secured and detach from the vehicle.
Consequence & remedy
Consequence: A detached fender flare can become a road hazard and increase the risk of a crash.
Remedy: Dealers will inspect and repair, or replace the fender flares as necessary, free of charge. Owner notification letters were mailed September 1, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S47. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning August 7, 2026.
May 27, 2026
Ford Motor Company (Ford) is recalling certain 2025-2026 Explorer, Ranger, and Bronco vehicles. The engine may fail, which can result in a loss of drive power.
Consequence & remedy
Consequence: A sudden loss of drive power can increase the risk of a crash.
Remedy: Dealers will replace the engine long block, free of charge. Interim letters, notifying owners of the safety risk, were mailed June 5, 2026. Additional letters will be sent once the remedy is available, anticipated in November 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S35. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on May 28, 2026.
Apr 28, 2026
Ford Motor Company (Ford) is recalling certain 2024-2026 Ranger and Bronco vehicles. The front seats may have a loose or dislodged seat frame height-adjust pivot bolt.
Consequence & remedy
Consequence: A seat with a dislodged bolt may not properly restrain an occupant in a crash, increasing the risk of injury.
Remedy: Dealers will inspect and replace the pivot links and bolts as necessary, free of charge. Owner notification letters were mailed May 22, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford’s number for this recall is 26S30. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov beginning April 30, 2026.
Apr 14, 2026
Ford Motor Company (Ford) is recalling certain 2021-2025 Bronco vehicles. The transmission to transfer case joint may be misaligned due to an incorrectly performed previous repair, which could lead to wear of the transmission output shaft splines and transfer case input splines.
Consequence & remedy
Consequence: Excessive wear of the transmission and transfer case splines may result in a loss of drive power or vehicle rollaway, increasing the risk of a crash.
Remedy: Dealers will inspect the transmission to transfer case joint and replace the transmission and transfer case as necessary, free of charge. Owner notification letters were mailed July 9, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S26. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on April 15, 2026.
Mar 3, 2026
Ford Motor Company (Ford) is recalling certain 2025 Ranger, Lincoln Nautilus, Mustang, Maverick, Explorer, Escape, Lincoln Corsair, Bronco Sport, and Bronco vehicles. The exhaust gas recirculation (EGR) valve may fail, resulting in an unexpected loss of drive power.
Consequence & remedy
Consequence: An unexpected loss of drive power increases the risk of a crash.
Remedy: Dealers will replace the EGR valves, free of charge. Owner notification letters were mailed July 31, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S10. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on March 4, 2026.
Mar 3, 2026
Ford Motor Company (Ford) is recalling certain 2021-2026 Ford Bronco and 2021-2024 Ford Edge vehicles. The Accessory Protocol Interface Module (APIM) may overheat and shutdown, which can prevent the rearview camera image from displaying as intended.
Consequence & remedy
Consequence: A rearview camera that fails to display an image can reduce the driver’s view behind the vehicle, increasing the risk of a crash.
Remedy: The APIM software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed April 13, 2026. Owners may contact Ford Customer Service at 1-866-436-7332. Ford's number for this recall is 26S09. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on March 5, 2026.
Dec 1, 2025
Ford Motor Company (Ford) is recalling certain 2025 Lincoln Navigator, F-150, Expedition, Bronco, and Ranger vehicles. The Electronic Brake Booster (EBB) module may malfunction while driving or when the driver is utilizing an Advanced Driver Assistance System (ADAS) feature, resulting in a loss of power brake assist.
Consequence & remedy
Consequence: An unexpected loss of power brake assist while driving can extend stopping distance and increase the risk of a crash. Additionally, a loss of power brake assist while ADAS features are engaged can result in the vehicle not braking as expected, increasing the risk of a crash.
Remedy: Dealers will replace the electronic brake booster, free of charge. Owner notification letters were mailed February 26, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SD4. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on December 3, 2025.
Nov 14, 2025
Ford Motor Company (Ford) is recalling certain 2025-2026 Bronco and Bronco Sport vehicles. The Instrument Panel Cluster (IPC) may fail at startup.
Consequence & remedy
Consequence: An instrument panel display that does not show critical information, such as warning lights or vehicle speed, increases the risk of a crash.
Remedy: The instrument panel cluster software will be updated by a dealer or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed December 4, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SC3.
Oct 10, 2025
Ford Motor Company (Ford) is recalling certain 2025 Bronco and Ranger vehicles. During manufacturing, the windshield may not have been properly bonded to the vehicle, allowing it to detach in a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 212, "Windshield Mounting."
Consequence & remedy
Consequence: In the event of a crash, windshield detachment can increase the risk of injury.
Remedy: Dealers will remove and replace the windshield, free charge. Owner notification letters were mailed October 20, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25C52. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on October 14, 2025.
Jul 25, 2025
Ford Motor Company (Ford) is recalling certain 2025 Lincoln Navigator, F-150, Expedition, Bronco, and Ranger vehicles. The Electronic Brake Booster (EBB) module may malfunction while driving or when the driver is utilizing an Advanced Driver Assistance System (ADAS) feature, resulting in a loss of power brake assist.
Consequence & remedy
Consequence: An unexpected loss of power brake assist while driving can extend stopping distance and increase the risk of a crash. Additionally, a loss of power brake assist while ADAS features are engaged can result in the vehicle not braking as expected, increasing the risk of a crash.
Remedy: The EBB module software will be updated over-the-air (OTA) or by a dealer, free of charge. Owner notification letters were mailed on August 22, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S77.
Jun 13, 2025
Ford Motor Company (Ford) is recalling certain 2025 Bronco vehicles. The active vent flap on the passenger side may prevent the air bag from deploying as intended. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence & remedy
Consequence: An air bag that does not deploy as intended increases the risk of injury during a crash.
Remedy: Dealers will replace the passenger air bag module, free of charge. Owner notification letters were mailed October 3, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25C27.
Jun 13, 2025
Ford Motor Company (Ford) is recalling certain 2025 Bronco four-door vehicles. The left-hand rear door may be able to be opened from inside the vehicle when the child safety lock is in the "ON" position.
Consequence & remedy
Consequence: A malfunctioning child safety lock that allows a rear door to be opened unintentionally can increase the risk of injury.
Remedy: Dealers will inspect and replace the rear door latch, as necessary, free of charge. Owner notification letters were mailed June 27, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S64.
May 9, 2025
Ford Motor Company (Ford) is recalling certain 2024-2025 Bronco vehicles. The front lower control arm fasteners may not have been tightened properly, allowing the control arm to detach from the frame.
Consequence & remedy
Consequence: A detached control arm can cause a loss of vehicle steering and control, increasing the risk of a crash.
Remedy: Owners are advised not to drive their vehicles until they have been repaired. Dealers will inspect and verify that the lower control arm fasteners are tightened properly. If a fastener is loose or missing, the dealer will replace the fastener. Repairs will be performed free of charge. Owner notification letters were mailed June 3, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S48.
May 9, 2025
Ford Motor Company (Ford) is recalling certain 2024-2025 Bronco and Ranger vehicles. The front upper control arm ball joint fastener may be missing or tightened improperly, allowing the front upper control arm to detach from the knuckle assembly.
Consequence & remedy
Consequence: A detached control arm can cause a loss of vehicle steering and control, increasing the risk of a crash.
Remedy: Dealers will inspect and tighten, or replace the ball joint fastener as necessary, free of charge. Owner notification letters were mailed May 23, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S45.
May 9, 2025
Ford Motor Company (Ford) is recalling certain 2025 Ranger and Bronco vehicles. The bolts that secure the driver's seat frame to the body may be loose or missing. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 207, "Seating Systems."
Consequence & remedy
Consequence: A seat with loose or missing fasteners may not properly restrain an occupant during a crash, increasing the risk of injury.
Remedy: Dealers will inspect the seat fasteners and tighten or install new fasteners as necessary, free of charge. Owner notification letters were mailed May 23, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25C16.
Apr 18, 2025
Ford Motor Company (Ford) is recalling certain 2025 Bronco vehicles. The front upper control arm ball joint nut may be missing or tightened improperly, allowing the front upper control arm to detach from the knuckle assembly.
Consequence & remedy
Consequence: A detached control arm can cause a loss of vehicle steering and control, increasing the risk of a crash.
Remedy: Owners are advised not to drive their vehicles until they have been repaired. Dealers will inspect and verify that the ball joint fastener is tightened properly. If a fastener is loose or missing, the dealer will replace the ball joint and knuckle assembly. Repairs will be performed free of charge. Owner notification letters are expected to be mailed in April 2025. Owners may contact Ford Customer Service at 1-866-436-7332. Ford's number for this recall is 25S40.
Mar 14, 2025
Ford Motor Company (Ford) is recalling certain 2024-2025 F-150, Bronco, 2024 Ranger, 2025 Mustang, Explorer, and Aviator vehicles. The transmission valve body may have been machined incorrectly, which can cause reverse gear failure, or unexpected forward movement in reverse or neutral gear.
Consequence & remedy
Consequence: Unexpected vehicle movement increases the risk of a crash.
Remedy: Dealers will replace the transmission main control valve body, free of charge. Owner notification letters were mailed April 11, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S19.
Oct 16, 2024
Ford Motor Company (Ford) is recalling certain 2024 Ranger, and 2024-2025 Bronco vehicles. The front upper control arm ball joint nut may not have been installed or tightened properly, allowing the front upper control arm to detach from the knuckle assembly.
Consequence & remedy
Consequence: A detached control arm can cause a loss of vehicle steering and control, increasing the risk of a crash.
Remedy: Dealers will inspect and verify that the ball joint fastener is tightened properly. If a fastener is loose or missing, the dealer will replace the ball joint and knuckle assembly as necessary, free of charge. Owner notification letters were mailed on November 20, 2024. Owners may contact Ford Customer Service at 1-866-436-7332. Ford's number for this recall is 24S64.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration