← New search

2022 Ford Bronco

Owner reports · Recalls · Investigations

When problems were reported

Mileage at the reported incident

Limited mileage data: 68 of 374 reports include usable mileage. There isn’t enough coverage to show a useful chart.

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Visibility/wiper. Review the 65 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Engine. Review the 51 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Service Brakes. Review the 40 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

6 crash reports2 fire reports3 injury reports

Service Brakes complaints

40 reports
Clear category filter
Mileage unknown · Jun 20, 2023
Service Brakes

2022 Ford bronco has by default an auto engine shut off when coming to a stop and set of conditions are met. The event occurred to a MANUAL transmission 2022 ford bronco. ~4/5/23, driver was driving up the canyon at an incline when encountering stop and go traffic. After stopping on the incline, the engine shut off per normal …

Read full complaint

2022 Ford bronco has by default an auto engine shut off when coming to a stop and set of conditions are met. The event occurred to a MANUAL transmission 2022 ford bronco. ~4/5/23, driver was driving up the canyon at an incline when encountering stop and go traffic. After stopping on the incline, the engine shut off per normal operation after shifting to neutral with the brake pedal firmly pushed. About 1-2 seconds after engine shutoff, while driver has brake firmly pushed, the car begins to roll back, with an apparent loss in brake power. Only after driver clutched in to first gear and stalled the vehicle did Vehicle arrest in its rearward motion, narrowly avoiding backing into the car that is stopped behind. From an outward observation the auto start/stop is not suited for standard manual transmission operation when stopped on an incline. The roll back apparently is due to loss of brake power/boost when the auto-start stop function stops the engine.

NHTSA ODI #11527894

Mileage unknown · May 4, 2023
Power TrainService Brakes

1st Issue: Antilock brake failure Brand new 2022 Bronco purchased mid Dec with around 2000 miles in February the brakes failed to stop with the pedal to the floor at traffic light and finally all 4 wheels locked up skidding into traffic. Luckily no accident. Repaired took 3 weeks to get the part. 2nd Issue: May 1st Powertrain m…

Read full complaint

1st Issue: Antilock brake failure Brand new 2022 Bronco purchased mid Dec with around 2000 miles in February the brakes failed to stop with the pedal to the floor at traffic light and finally all 4 wheels locked up skidding into traffic. Luckily no accident. Repaired took 3 weeks to get the part. 2nd Issue: May 1st Powertrain malfunction at 3000 miles pulled up to a stop sign the engine shut off. Finally after 30 minutes the engine started back. Drove it straight to Ford Service dept. Telling me today the part they need is on indefinite backorder. Prior to the failure no lights came on, but the Ford Pass App showed them. Powertrain Malfunction, Antilock fault, Hill assist warning, and pre collision assist not available. Dealership thought is an app issue and couldn’t repair unless the lights came on. In both cases the warning lights came on after the fact.

NHTSA ODI #11520488

Mileage unknown · Feb 16, 2023
Service Brakes

BRAKE LIGHT CAME ON WHILE DRIVING. BRAKE PEDAL GOT HARD WHEN DEPRESSING. BRAKE PEDAL THEN WENT TO THE FLOOR. I WENT TO THE LOCAL FORD DEALER WHERE I PURCHASED THE VEHICLE. I WAS TOLD THAT THE BRAKE PART NEEDED WOULD NOT BE AVAILABLE FOR A COUPLE MONTHS AND WAS TOLD NOT TO DRIVE THE CAR. THE VEHICLE WAS DISABLED FROM 08/18/2022…

Read full complaint

BRAKE LIGHT CAME ON WHILE DRIVING. BRAKE PEDAL GOT HARD WHEN DEPRESSING. BRAKE PEDAL THEN WENT TO THE FLOOR. I WENT TO THE LOCAL FORD DEALER WHERE I PURCHASED THE VEHICLE. I WAS TOLD THAT THE BRAKE PART NEEDED WOULD NOT BE AVAILABLE FOR A COUPLE MONTHS AND WAS TOLD NOT TO DRIVE THE CAR. THE VEHICLE WAS DISABLED FROM 08/18/2022 TILL 11/11/2022, APPROXIMATELY 3 MONTHS. THE VEHICLE WAS FINALLY REPAIRED ON 11/11/2022 AND RELEASED BACK TO ME. AS OF THIS DATE 02/16/2022 FORD HAS DONE NOTHING TO COMPENSATE ME FOR 3 MONTHS OF LOST VEHICLE USAGE AND 3 MONTH WARRANTY EXTENSION. A SURROGATE WAS APPOINTED BY FORD AND SHE DID NOTHING TO GET ME ANY COMPENSATION FROM FORD OR EXTENDING MY WARRANTY. THE SURROGATE REFUSES TO ANSWER EMAILS OR PHONE CALLS FROM ME IN REGARD TO THE VEHICLE.

NHTSA ODI #11507709

Mileage unknown · Feb 15, 2023
Service Brakes

While driving!! My brake pedal felt rock hard , I HAD NO BRAKES !! The car kept cruising , luckily for us! Vermont is very rural and roads was wide open with no traffic, I had some time to keep stomping on the brakes till I was able to regain braking power, this could have killed us!! If I needed to slow down I would not have be…

Read full complaint

While driving!! My brake pedal felt rock hard , I HAD NO BRAKES !! The car kept cruising , luckily for us! Vermont is very rural and roads was wide open with no traffic, I had some time to keep stomping on the brakes till I was able to regain braking power, this could have killed us!! If I needed to slow down I would not have been!! I had a 3 year on in the back and my pregnant girlfriend in the passenger, I almost shit my pants when I realized the brake pedal was unresponsive! I had no service !! We had to drive the car with intermittent braking just so that I can’t get some sell service!! I contacted a fire dealer that was 40 minutes from my location to give them a heads up, I was advised to call ford customer relations, my case number is CAS-41297357-H8T7R8 They towed the bronco on Monday to bring it to that dealer while I’m here in Vermont for about a week , I have no vehicle, ford offered 40/day in reimbursement if I get a rental, unfortunately this isn’t 2013 where I can actually find a car rental for that price , cheapest was 90 per day. I posted this on Facebook and was so surprised that this has happened to other bronco owners !!

NHTSA ODI #11507340

Mileage unknown · Feb 13, 2023
Parking BrakeService Brakes

During flat towing the EBB shuts down making the auxiliary brake ineffective, this a safety concern. Ford is aware of the situation, but has failed to address this safety issue.

NHTSA ODI #11507100

Mileage unknown · Jan 21, 2023
Service Brakes

Flat Towing 2022 Ford Bronco with 2.7 V6 engine. After connecting my Bronco to the motorhome and putting it in the tow mode the following will occur. About 45 mins after turning the ignition off and closing the doors the EBB (Electronic Brake Boost) in the Bronco shuts down leaving the Bronco without any brake boost and leaves t…

Read full complaint

Flat Towing 2022 Ford Bronco with 2.7 V6 engine. After connecting my Bronco to the motorhome and putting it in the tow mode the following will occur. About 45 mins after turning the ignition off and closing the doors the EBB (Electronic Brake Boost) in the Bronco shuts down leaving the Bronco without any brake boost and leaves the supplemental brake system ineffective. When first connecting the Bronco to the motorhome the brake boost is active and the supplemental brake system must be set to match, or it will lock up the brakes on the Bronco when you stop. After the boost shuts down the supplemental brake system cannot apply enough force to the Bronco brakes to assist in stopping and suddenly, without notice, it takes a much greater distance to stop the motorhome than it did when the boost was working. Ford came up with a temporary work around so the EBB never comes on. This involves pulling fuses but you.have to wait for 5 minutes after you close the doors for the vehicle to go enter sleep mode. To take the Bronco out of flat tow mode you must again wait 5 minutes after opening the hood and closing the doors before re-installing the fuses. When flat towing behind with a motorhome it is impossible to backup with the tow vehicle attached. Having to wait 5 minutes before being able to disconnect the tow vehicle is very dangerous in many situations.

NHTSA ODI #11502955

Mileage unknown · Jan 21, 2023
Electrical SystemService Brakes

This vehicle is supposed to be flat tow able. If I go to flat tow this car it will lock up the wheels during the first hour or so while towing behind my motor home using a supplemental braking system. I find out later from a forum online that I need to remove some fuses to tow it properly. I hear Ford is working on this issue fo…

Read full complaint

This vehicle is supposed to be flat tow able. If I go to flat tow this car it will lock up the wheels during the first hour or so while towing behind my motor home using a supplemental braking system. I find out later from a forum online that I need to remove some fuses to tow it properly. I hear Ford is working on this issue for a couple years but how many tire lock ups before someone gets hurt?

NHTSA ODI #11502951

Mileage unknown · Nov 1, 2022
Electrical SystemForward Collision AvoidanceService Brakes

Randomly the following takes place while vehicle is in motion at various speeds… Hill assist warning followed by (in rapid succession) pre collision assist not available, antilock brake fault Then the brakes momentarily give out then come back in non-powered mode which dangerously locks up the wheels when stopping System th…

Read full complaint

Randomly the following takes place while vehicle is in motion at various speeds… Hill assist warning followed by (in rapid succession) pre collision assist not available, antilock brake fault Then the brakes momentarily give out then come back in non-powered mode which dangerously locks up the wheels when stopping System then resets itself Bronco6g forums have reported similar issues

NHTSA ODI #11491822

Mileage unknown · Oct 24, 2022
EngineForward Collision AvoidanceService Brakes

Vehicle reported Anti-Brake Fault. Vehicle reported Pre-Collision Fault. Vehicle reported 4 different hill start Assist Failures. I noticed the Pre-Collison feature did not work because the breaks never activated when there was a sudden merge into my lane going 65 miles per hour. The car says that the pre-collision feature is e…

Read full complaint

Vehicle reported Anti-Brake Fault. Vehicle reported Pre-Collision Fault. Vehicle reported 4 different hill start Assist Failures. I noticed the Pre-Collison feature did not work because the breaks never activated when there was a sudden merge into my lane going 65 miles per hour. The car says that the pre-collision feature is enabled but did not respond to a vehicle that came close to causing a wreck.

NHTSA ODI #11490693

Mileage unknown · Oct 17, 2022
Electrical SystemService Brakes

The 2022 Bronco is listed as being able to be flat towed behind a motorhome and the software allows it to be put into flat tow mode. 49 states require that flat towed vehicles over a certain weight have supplemental braking. When the supplemental brake system is installed in a Bronco with the 2.7 liter engine it stops working co…

Read full complaint

The 2022 Bronco is listed as being able to be flat towed behind a motorhome and the software allows it to be put into flat tow mode. 49 states require that flat towed vehicles over a certain weight have supplemental braking. When the supplemental brake system is installed in a Bronco with the 2.7 liter engine it stops working correctly after 45 minutes because the electronic brake booster shuts off. This results in the supplemental braking system not having enough power to activate the brakes and can cause a serious accident because the motorhome cannot stop soon enough. Ford issued TSB 22-2210 to temporarily correct this issue but it simply disables the electronic brake booster (must remove fuses) and again leaves the towed vehicle with insufficient braking. Ford claims they are working a software update due out in September 2022, it is now mid October and no recall has been issued.

NHTSA ODI #11489546

Official recalls

23

26V468000 · Electrical System:wiring:front Underhood; Engine

Jul 20, 2026

Ford Motor Company (Ford) is recalling certain 2021-2026 Bronco and Bronco Raptor vehicles. The engine compartment wiring harness may become damaged and short circuit.

Consequence & remedy

Consequence: A short circuit in the engine compartment can create heat or spark, increasing the risk of a fire.

Remedy: Dealers will install sheathing over the wiring, free of charge. This is a Phased campaign. Phase 1 will include 2026 Bronco Raptor notified owners on 7/31/2026. Phase 2 will include 2021-2025 Bronco Raptor vehicle will notify owners on or about 8/14/2026. Phase 3 will include 2021-2026 Bronco will notify owners on or about 9/1/2026. Owner notification letters were mailed August 5, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S55. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on July 23, 2026.

Additional source detail variants (2)

Engine

Ford Motor Company (Ford) is recalling certain 2021-2026 Bronco and Bronco Raptor vehicles. The engine compartment wiring harness may become damaged and short circuit.

Consequence: A short circuit in the engine compartment can create heat or spark, increasing the risk of a fire.

Remedy: Dealers will install sheathing over the wiring, free of charge. This is a Phased campaign. Phase 1 will include 2026 Bronco Raptor notified owners on 7/31/2026. Phase 2 will include 2021-2025 Bronco Raptor vehicle will notify owners on or about 8/14/2026. Phase 3 will include 2021-2026 Bronco will notify owners on or about 9/1/2026. Owner notification letters were mailed August 5, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S55. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on July 23, 2026.

Electrical System:wiring:front Underhood

Ford Motor Company (Ford) is recalling certain 2021-2026 Bronco and Bronco Raptor vehicles. The engine compartment wiring harness may become damaged and short circuit.

Consequence: A short circuit in the engine compartment can create heat or spark, increasing the risk of a fire.

Remedy: Dealers will install sheathing over the wiring, free of charge. This is a Phased campaign. Phase 1 will include 2026 Bronco Raptor notified owners on 7/31/2026. Phase 2 will include 2021-2025 Bronco Raptor vehicle will notify owners on or about 8/14/2026. Phase 3 will include 2021-2026 Bronco will notify owners on or about 9/1/2026. Owner notification letters were mailed August 5, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S55. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on July 23, 2026.

26V403000 · Structure:body

Jun 24, 2026

Ford Motor Company (Ford) is recalling certain 2022-2026 Bronco vehicles. The fender flares may not be properly secured and detach from the vehicle.

Consequence & remedy

Consequence: A detached fender flare can become a road hazard and increase the risk of a crash.

Remedy: Dealers will inspect and repair, or replace the fender flares as necessary, free of charge. Owner notification letters were mailed September 1, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S47. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning August 7, 2026.

26V299000 · Structure:body:roof And Pillars

May 12, 2026

Ford Motor Company (Ford) is recalling certain 2021-2022 Bronco vehicles. The 3-door and 5-door Molded-In-Color (MIC) hardtop roof panels may have been manufactured improperly, which can allow sections of the outer roof panel to separate and detach from the vehicle.

Consequence & remedy

Consequence: A detached section of roof can create a road hazard, increasing the risk of a crash.

Remedy: Dealers will inspect and replace the hard top as necessary, free of charge. Interim letters, notifying owners of the safety risk were mailed May 28, 2026. Additional letters will be sent once the remedy is available, anticipated in November 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S32. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on May 12, 2026.

26V236000 · Power Train:automatic Transmission

Apr 14, 2026

Ford Motor Company (Ford) is recalling certain 2021-2025 Bronco vehicles. The transmission to transfer case joint may be misaligned due to an incorrectly performed previous repair, which could lead to wear of the transmission output shaft splines and transfer case input splines.

Consequence & remedy

Consequence: Excessive wear of the transmission and transfer case splines may result in a loss of drive power or vehicle rollaway, increasing the risk of a crash.

Remedy: Dealers will inspect the transmission to transfer case joint and replace the transmission and transfer case as necessary, free of charge. Owner notification letters were mailed July 9, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S26. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on April 15, 2026.

26V124000 · Back Over Prevention:software

Mar 3, 2026

Ford Motor Company (Ford) is recalling certain 2021-2026 Ford Bronco and 2021-2024 Ford Edge vehicles. The Accessory Protocol Interface Module (APIM) may overheat and shutdown, which can prevent the rearview camera image from displaying as intended.

Consequence & remedy

Consequence: A rearview camera that fails to display an image can reduce the driver’s view behind the vehicle, increasing the risk of a crash.

Remedy: The APIM software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed April 13, 2026. Owners may contact Ford Customer Service at 1-866-436-7332. Ford's number for this recall is 26S09. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on March 5, 2026.

25V888000 · Back Over Prevention: Sensing System: Camera

Dec 18, 2025

Ford Motor Company (Ford) is recalling certain 2021-2022 Bronco vehicles equipped with 8-inch SYNC infotainment screens that were previously repaired incorrectly under recall number 23V165. The rearview camera image may still be displayed after a backing event has ended. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."

Consequence & remedy

Consequence: A rearview image that continues to be displayed after the vehicle is shifted out of reverse may distract the driver, increasing the risk of a crash.

Remedy: Dealer will update the SYNC module software ,free of charge. Owner notification letters were mailed January 28, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25C72. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning January 30, 2026.

25V721000 · Seats:critical Fasteners

Oct 23, 2025

Ford Motor Company (Ford) is recalling certain 2021-2023 Bronco vehicles. The front seats may have a loose or dislodged seat frame height-adjust pivot bolt.

Consequence & remedy

Consequence: A seat with a dislodged bolt may not properly restrain an occupant in a crash, increasing the risk of injury.

Remedy: Dealers will inspect and replace the pivot links and bolts as necessary, free of charge. Owner notification letters were mailed April 28, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SB5. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov beginning October 28, 2025.

25V685000 · Equipment:electrical:engine Block Heater

Oct 10, 2025

Ford Motor Company (Ford) is recalling certain 2016-2019 Lincoln MKC, 2016-2023 Explorer, 2019-2020 Fusion, 2019-2024 Ranger, 2020-2022 Lincoln Corsair, Escape, 2021-2024 Bronco, Bronco Sport, and 2022-2024 Maverick vehicles. The engine block heater may crack and develop a coolant leak, causing it to short circuit when the block heater is plugged in.

Consequence & remedy

Consequence: An electrical short circuit can increase the risk of a fire.

Remedy: Owners are advised not to plug in their block heater until the vehicle is remedied. Dealers will replace the block heater, free of charge. Owners will also have a alternative option to replace engine block heater element with a threaded blanking plug, and remove the block heater electrical cord. Interim letters, notifying owners of the safety risk, were mailed December 3, 2025. Additional letters will be sent once the final remedy is available, anticipated September 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SA4. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on October 15, 2025.

25V455000 · Fuel System, Gasoline:delivery:fuel Pump

Jul 7, 2025

Ford Motor Company (Ford) is recalling certain 2021-2023 Bronco, Explorer, Lincoln Aviator, F-250 SD, F-350 SD, F-450 SD, F-550 SD, 2021-2022 Lincoln Navigator, Mustang, F-150, and 2022 Expedition vehicles. The low-pressure fuel pump may fail, which can result in an engine stall while driving.

Consequence & remedy

Consequence: An engine stall increases the risk of a crash.

Remedy: Dealers will replace the low pressure fuel pump on super duty vehicles and update the powertrain control module (PCM) software on all other affected vehicles, free of charge. Owner notification letters were mailed July 27, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S75.

25V273000 · Back Over Prevention: Sensing System: Camera

May 14, 2025

Ford Motor Company (Ford) is recalling certain 2022-2023 Bronco vehicles. The 360-degree view camera may not display a rearview image when the vehicle is placed in reverse.

Consequence & remedy

Consequence: Loss of the rearview camera image can reduce the driver's view of what is behind the vehicle, increasing the risk of a crash.

Remedy: Dealers will replace the rearview camera, free of charge. Owner notification letters were mailed October 8, 2025. Owners may contact Ford Customer Service at 1-866-436-7332. Ford's number for this recall is 23S48. This recall expands previous recall number 23V-598.

25V312000 · Back Over Prevention: Sensing System: Camera

May 9, 2025

Ford Motor Company (Ford) is recalling certain 2021-2022 Bronco vehicles equipped with 8-inch SYNC infotainment screens that were repaired incorrectly under recall 22V-825. The rearview camera image may still be displayed after a backing event has ended. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."

Consequence & remedy

Consequence: A rearview image that continues to be displayed after the vehicle is shifted out of reverse may distract the driver, increasing the risk of a crash.

Remedy: Dealers will update SYNC module software, free of charge. Owner notification letters were mailed June 18, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25C14.

25V315000 · Back Over Prevention:software

May 9, 2025

Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco, F-150, 2021-2024 Edge, 2022-2025 Escape, F-250, F-350, F-450, F-550, F-600, 2022-2024 Expedition, 2022-2025 Transit, 2021-2023 Mach-E, 2024 Ranger, Mustang, 2021-2023 Lincoln Nautilus, 2022-2024 Navigator, and 2023-2024 Corsair vehicles. A software error may cause the rearview camera image to delay, freeze, or not display when the vehicle is in reverse.

Consequence & remedy

Consequence: A frozen or missing rearview camera image can reduce the driver's view behind the vehicle, increasing the risk of a crash.

Remedy: The accessory protocol interface module (APIM) software will be updated by a dealer or through an over-the-air update, free of charge. This will be a phased campaign, with the remedy becoming available in different phases based on model and model years. Interim letters notifying owners of the safety risk were mailed on June 26, 2025. Additional letters will be mailed once the final remedy is available on each phase. Owner notification letters were sent on October 8, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S49.

25V025000 · Suspension:rear:shock Absorber

Jan 17, 2025

Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco vehicles. The rear shock absorbers may corrode and fail, resulting in detachment of the external reservoir.

Consequence & remedy

Consequence: An external reservoir that detaches from a vehicle can create a road hazard, increasing the risk of a crash.

Remedy: Dealers will replace the rear shock absorbers, as necessary free of charge. Owner notification letters were mailed August 15, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S01.

24V635000 · Engine And Engine Cooling:engine:hard Parts Internal/mechanical

Aug 23, 2024

Ford Motor Company (Ford) is recalling certain 2021-2022 Bronco, F-150, Edge, Explorer, Lincoln Nautilus, and Lincoln Aviator vehicles equipped with either a 2.7L or 3.0L Nano EcoBoost engine. The engine intake valves may break while driving, which can result in engine failure and a loss of drive power.

Consequence & remedy

Consequence: A loss of drive power increases the risk of a crash.

Remedy: Dealers will perform an engine cycle test and replace the engine as necessary, free of charge. Owner notification letters were mailed July 3, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S55.

23V379000 · Equipment:other:labels

May 26, 2023

Ford Motor Company (Ford) is recalling certain 2022-2023 Bronco, 2023 Super Duty F-250, and 2019-2023 Ranger vehicles. The Tire and Loading Information (TREAD) label states the incorrect load carrying capacity, which can result in an overloaded vehicle. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 110, "Tire Selection and Rims."

Consequence & remedy

Consequence: An overloaded vehicle increases the risk of a crash.

Remedy: Ford will mail a new TREAD label to install over the existing label, free of charge. Owners will also have the option to take their vehicle to a Ford or Lincoln dealer to have the new label installed, free of charge. Owner notification letters were mailed July 21, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23C18.

23V358000 · Seat Belts:critical Fasteners

May 18, 2023

Ford Motor Company (Ford) is recalling certain 2021-2023 Bronco vehicles built with the 5-Door body style. The first-row seat belt latch plates may be difficult to access from their stowed position. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."

Consequence & remedy

Consequence: Difficulty accessing the seat belt latches may result in occupants not wearing their seat belts, increasing the risk of injury in a crash.

Remedy: Dealers will add a sliding clip latch stop to the driver and front passenger seat belts, free of charge. Interim owner notification letters notifying owners of the safety risk were mailed July 14, 2023. Owner letters informing owners that parts are available were mailed on October 2, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23C16.

23V165000 · Back Over Prevention: Sensing System: Camera

Mar 10, 2023

Ford Motor Company (Ford) is recalling certain 2021-2022 Bronco vehicles equipped with 8-inch SYNC infotainment screens that were previously remedied under recall 22V-825. The rearview camera image may still be displayed after a backing event has ended. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."

Consequence & remedy

Consequence: A rearview image that continues to be displayed after the vehicle is shifted out of reverse may distract the driver, increasing the risk of a crash.

Remedy: The SYNC module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed on March 28, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23C05.

23V155000 · Steering

Mar 8, 2023

Ford Motor Company (Ford) is recalling certain 2023 Bronco Wildtrak and 2022 Bronco Raptor vehicles. Internal damage to the steering gear may require increased steering effort or cause the steering wheel to lock-up.

Consequence & remedy

Consequence: A steering wheel that locks-up can result in a complete loss of steering control, increasing the risk of a crash.

Remedy: Owners are advised not to drive their vehicles until the remedy is performed. Dealers will replace the steering gear, free of charge. Owner notification letters were mailed March 31, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S09.

23V070000 · Power Train:automatic Transmission

Feb 10, 2023

Ford Motor Company (Ford) is recalling certain 2022-2023 F-150, Mustang, Explorer, Bronco, and 2023 Lincoln Aviator vehicles equipped with automatic transmissions. The transmission may contain a loose bolt which could prevent the transmission from engaging the park gear, although the gear shifter position may indicate that the vehicle has been shifted to "PARK."

Consequence & remedy

Consequence: The inability to secure the vehicle in the park position can result in a rollaway, increasing the risk of a crash or injury.

Remedy: Dealers will inspect and, if necessary, replace the transmissions, free of charge. Owner notification letters were mailed April 25, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S06.

22V928000 · Air Bags:sensor:side Impact

Dec 14, 2022

Ford Motor Company (Ford) is recalling certain 2021-2022 Bronco vehicles. The right or left side impact sensors may not be properly secured to the vehicle.

Consequence & remedy

Consequence: An improperly secured side impact sensor may cause the air bags to unintentionally deploy, or not to deploy as intended, increasing the risk of injury in a crash.

Remedy: Dealers will inspect the side impact sensor attachments and repair, as necessary, free of charge. Owner notification letters were mailed January 20, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S77.

22V825000 · Back Over Prevention: Sensing System: Camera

Nov 3, 2022

Ford Motor Company (Ford) is recalling certain 2021-2022 Bronco vehicles equipped with rearview camera systems and 8-inch screen displays. The rearview camera image may still be displayed after a backing event has ended. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."

Consequence & remedy

Consequence: A rearview image that continues to be displayed after the vehicle is shifted out of reverse may distract the driver, increasing the risk of a crash.

Remedy: The SYNC module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed on March 25, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22C27.

22V451000 · Visibility:windshield

Jun 24, 2022

Ford Motor Company (Ford) is recalling certain 2022 Bronco and Ranger vehicles. The windshield may not have been properly bonded to the vehicle, which could allow it to detach during a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 212, "Windshield Mounting."

Consequence & remedy

Consequence: A windshield that separates from a vehicle during a crash can increase the risk of injury.

Remedy: Dealers will remove and reinstall the windshield, free of charge. Owner notification letters were mailed July 18, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22C12.

22V411000 · Latches/locks/linkages:doors:lock

Jun 10, 2022

Ford Motor Company (Ford) is recalling certain four-door 2021-2022 Bronco vehicles. The passenger-side rear door may be opened from inside of the vehicle when the child safety lock is in the "ON" position.

Consequence & remedy

Consequence: A malfunctioning child safety lock increases the risk of injury to a child occupant.

Remedy: Dealers will inspect the passenger-side child safety locks door child safety lock and latch, and replace them, if necessary, free of charge. Owner notification letters were mailed June 28, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S44.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

2

PE24019 · Low-pressure Fuel Pump Failure

Opened Jul 29, 2024 · Closed Sep 19, 2025

Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:fuel Pump

On July 29, 2024, the Office of Defects Investigation (ODI) opened PE24019 to investigate complaints of low-pressure fuel pump failures in MY 2021 Ford Bronco vehicles. Some consumers reported that the failure occurred without warning while driving, resulting in a complete loss of motive power with no ability to restart the engine. Ford determined that several other vehicle models contain low-pressure fuel pumps substantially similar to the 2021 Ford Bronco, including the 2022-2023 Ford Bronco, 2018-2023 Ford F-150, 2022-2023 Ford Expedition, 2019-2023 Lincoln Navigator, 2020-2023 Ford F-250-F-550, 2024 Ford Super Duty Chassis Cab, 2024-2025 Ford Ranger, 2020-2023 Ford Explorer, 2020-2023 Lincoln Aviator, and 2021-2025 Ford Mustang. ODI's investigation found that the affected vehicles may lose fuel pressure and flow from the fuel delivery module (consisting of a low-pressure fuel pump, jet pump, reservoir, and other parts) due to a low-pressure pump failure. This can cause the engine to stall while driving. The root cause is reduced internal clearance in the fuel pump, increasing friction and sensitivity to vapor lock. Fuel blockage from contamination inside the jet pump also contributed to the failure. Ford stated that the contamination source was unknown. On July 7, 2025, Ford filed recall 25V-455 for certain 2021-2023 Ford F-550 SD/F-450 SD/F-350 SD/F-250 SD, 2021-2022 Lincoln Navigator, 2021-2022 Ford Mustang, 2021-2022 Ford F-150, 2021-2023 Ford Explorer, 2022 Ford Expedition, and 2021-2023 Ford Bronco vehicles produced between July 1, 2021, and July 30, 2022. The recall also included certain 2021-2023 Lincoln Aviator produced between July 1, 2021, and December 21, 2022. Ford explained in its recall filingthat the production dates used for the recall were based on changes in the manufacturing process. Specifically, Ford determined that in June 2021, the supplier modified the jet pump manufacturing process, producing fuel pump chambers with a lower-than-specified internal clearance. In July 2022, the supplier implemented corrective actions to the manufacturing process by adding two additional vacuum pumps to reduce contamination during the production of the jet pump. ODI has identified approximately 1,000 reports involving vehicles covered in this investigation but excluded from recall 25V-455. However, even with such reports, these vehicles experienced comparatively lower failure rates than the vehicles that are subject to Recall 25V-455. Ford has explained that these vehicles were excluded from the recall population because they did not experience the manufacturing changes that prompted the recall. Specifically, according to Ford, vehicles built before July 1, 2021 (the recall production start date), were not affected by the supplier’s change to the jet pump manufacturing process. Even after closing this investigation, ODI will continue to monitor complaints for vehicles excluded from recall 25V-455 to consider whether they exhibit the same risks as the vehicles encompassed by the recall. The recall remedy is currently under development. In view of Ford’s recall action, ODI is closing this Preliminary Evaluation, but will continue to monitor the issue as a remedy is developed and implemented. ODI will take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

EA23002 · Loss Of Motive Power

Opened Sep 29, 2023 · Closed Oct 31, 2024

Status: closed (inferred from source dates) · Engine

On July 22, 2022, the Office of Defects Investigation (ODI) granted a Defect Petition (DP22001) and opened a Preliminary Evaluation (PE22007) to investigate allegations of loss of motive power in model year (MY) 2021 Ford Bronco vehicles equipped with 2.7L EcoBoost engines. Complainants were reporting sudden engine failure while driving resulting in a loss of motive power, often without the ability to restart. During PE22007, the cause of engine failure and loss of motive power in the subject vehicles was determined to be intake valve fracture, and the full scope of vehicles affected by the subject defect was identified as all MY 2021-2022 Ford and Lincoln models equipped with either the 2.7L or 3.0L EcoBoost engines, referred to as the “Nano” engine family.  If an intake valve fractures in the subject engines, it may drop into the cylinder and contact the piston, often resulting in catastrophic engine damage. On September 29, 2023, PE22007 was upgraded to an Engineering Analysis (EA23002) to further investigate the subject defect across the full scope of affected vehicles. During EA23002, ODI visited Ford facilities to review technical information related to intake valve fracture in “Nano” engines, coordinated with NHTSA’s Vehicle Research and Testing Center (VRTC), and analyzed updated field data relating the subject defect. Forensic analysis of fractured intake valves demonstrated that the defective components exhibited “grinding burn” or out of specification hardness in the area of the keeper grooves. The presence of grinding burn is evidence that during the groove grinding phase of production, the temperature of the valve became sufficiently high to alter the microstructure of the material and is indicative that the valve supplier’s manufacturing processes were not within control specifications. Grinding burn results in a hard, brittle microstructure and high residual stresses toward the surface of the valve. Through normal engine loading, a valve with grinding burn will likely fracture at the area of highest vulnerability, which is the third keeper groove. In its response to the EA23002 Information Request (IR) letter, Ford provided evidence of 396 customer complaints (including field reports), 825 warranty claims, and 936 engine exchanges. When considering both ODI and manufacturer failure report data, there have been reports representing 1066 unique vehicles within the subject vehicle population. Analysis of the failure report data demonstrates that vehicles equipped with potentially defective intake valves were built within a production “spike period” of May 2021 – October 2021. The beginning of the spike period corresponds to a ramp up in production at the valve supplier manufacturing facility, and the end of the spike period aligns with the implementation of several mid-production process improvements and the decision to change the metal alloy used to produce intake valves from “Silchrome Lite” to “Silchrome 1”. Ford began investigating the subject defect in July 2021, determined the root cause, and took corrective measures for the new production vehicles. Analysis of the failure report data demonstrates that these corrective actions were successful in eliminating the risk of intake valve fracture for subject vehicles produced after October 2021. However, Ford did not take any field action to address vehicles produced during the spike period, and in the several months following the implementation of the production changes, a significant number of field failures continued to occur. It is Ford’s assessment that not all valves produced during the spike period are defective, and that failures associated with the subject defect occur at low time in service. Analysis of the failure report data demonstrates that the vast majority of failures have occurred before 20,000 miles with over half of all reported failures occurring before 5,000 miles. The rate of reported failures related to the subject defect has steadily decreased since November 2021. ODI coordinated with NHTSA’s National Center for Statistics and Analysis (NCSA) to conduct statistical analysis and predict the number of future failures associated with the subject defect. The results of this analysis, and the trends identified through the failure report data are generally consistent with Ford’s assessment that defective intake valves will likely fail at a low time in service and indicate that the majority of subject vehicles equipped with defective valves have already experienced a failure. On August 23, 2024, Ford submitted recall 24V635 for subject vehicles equipped with “Nano” engines and built within the production spike period identified above (total population 90,736 vehicles). The remedy includes an inspection at a Ford/Lincoln dealership where the lifetime engine cycles of the vehicle will be determined. If a vehicle does not meet a threshold for lifetime engine cycles, the dealership will conduct a high RPM engine cycle accumulation procedure, which aims to identify if the vehicle is equipped with defective intake valves. Any vehicle that fails the accumulation procedure will receive an engine replacement under the recall. In addition to recall 24V635, Ford has stated that it will launch customer satisfaction campaign 24N12, which will provide extended warranty coverage to the subject vehicles through the earlier of 10 years or 150,000 miles. In view of the recall action being taken by Ford, ODI is closing this Engineering Analysis. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.