TL* THE CONTACT OWNS A 1993 FORD BRONCO. WHILE DRIVING AT APPROXIMATELY 10 MPH, THE VEHICLE STALLED AND CAUSED ANOTHER VEHICLE TO CRASH INTO THE CONTACT'S VEHICLE. A POLICE REPORT WAS FILED AND THERE WERE UNKNOWN INJURIES SUSTAINED THAT REQUIRED MEDICAL ATTENTION. IT WAS DIAGNOSED THAT THE IGNITION SWITCH NEEDED TO BE REPLACED. …
Read full complaint
TL* THE CONTACT OWNS A 1993 FORD BRONCO. WHILE DRIVING AT APPROXIMATELY 10 MPH, THE VEHICLE STALLED AND CAUSED ANOTHER VEHICLE TO CRASH INTO THE CONTACT'S VEHICLE. A POLICE REPORT WAS FILED AND THERE WERE UNKNOWN INJURIES SUSTAINED THAT REQUIRED MEDICAL ATTENTION. IT WAS DIAGNOSED THAT THE IGNITION SWITCH NEEDED TO BE REPLACED. THE CONTACT DID NOT DISCLOSE WHERE THE VEHICLE WAS TAKEN FOR DIAGNOSTIC TESTING. THE VEHICLE WAS NOT REPAIRED. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 05V017000 (ELECTRICAL SYSTEM). THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.
NHTSA ODI #10682963
Mileage unknown · Apr 19, 1999
Electrical SystemFire
VEHICLE PARKED IN DRIVEWAY. ATTEMPTED TO START, AND UPON ROTATION OF IGNITION SWITCH, SMOKE STARTED ROLLING OUT OF STEERING COLUMN. REMOVED COVER TO ACCESS UNDER CRUISE CONTROL AND DIDN'T OBSERVE ANY DAMAGE. ATTEMPTED TO START AGAIN, AND SMOKE AGAIN ROLLED OUT, BUT THIS TIME OBSERVED FLAMES FLARE UP WITH SMOKE. IMMEDIATELY SH…
Read full complaint
VEHICLE PARKED IN DRIVEWAY. ATTEMPTED TO START, AND UPON ROTATION OF IGNITION SWITCH, SMOKE STARTED ROLLING OUT OF STEERING COLUMN. REMOVED COVER TO ACCESS UNDER CRUISE CONTROL AND DIDN'T OBSERVE ANY DAMAGE. ATTEMPTED TO START AGAIN, AND SMOKE AGAIN ROLLED OUT, BUT THIS TIME OBSERVED FLAMES FLARE UP WITH SMOKE. IMMEDIATELY SHUT OFF IGNITION SWITCH AND DISCONNECTED BATTERY SUPPLY. AK
NHTSA ODI #705757
Mileage unknown · May 9, 1996
Electrical System
ELECTRICAL SHORT IN IGNITION, PREVENTING STARTER MOTOR FROM TURNING. *SD
FORD IS RECALLING 225,000 MY 1992-2003 ECONOLINE, MY 1993-1995 TAURUS SHO, MY 1992-1998 CROWN VICTORIA, MY 1993 BRONCO, F-SERIES, MY 1995-1997 F-SERIES SUPER DUTY STRIPPED CHASSIS, MY 1992-1998 MERCURY GRAND MARQUIS, AND MY 1992-1995 LINCOLN TOWN CAR VEHICLES. THE AFFECTED VEHICLES WERE PREVIOUSLY REPAIRED USING A WIRING HARNESS THAT IS NOT COMPATIBLE WITH THE VEHICLE CIRCUIT POLARITY.
Consequence & remedy
Consequence: AS A RESULT, THE FUSE IS LOCATED IN THE OUTPUT CIRCUIT RATHER THAN IN THE INTENDED INPUT POWER FEED CIRCUIT, AND MAY NOT OFFER THE INTENDED PROTECTION IN THE EVENT OF AN ELECTRICAL SHORT TO GROUND.
Remedy: DEALERS WILL INSTALL A NEW WIRING HARNESS, OR REPLACE THE MATING ELECTRICAL COMPONENT. THE RECALL BEGAN ON FEBRUARY 18, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Consequence & remedy
Consequence: THIS COULD RESULT IN AN UNDERHOOD FIRE.
Remedy: DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
THE PARKING BRAKE CONTROL SELF-ADJUST PAWL DOES NOT LINE UP PROPERLY WITH THE SELF-ADJUST RACHET CAUSING THE PAWL TO SLIP OVER ONE OR MORE TEETH IN THE RACHET.
Consequence & remedy
Consequence: WHEN THE ABOVE OCCURS, IT CAN RESULT IN PARKING BRAKE SYSTEM INEFFECTIVENESS. THE PARKING BRAKE WILL NOT HOLD THE VEHICLE, CAUSING THE VEHICLE TO ROLL FREELY, IF THE TRANSMISSION IS NOT LEFT IN GEAR.
Remedy: A WEDGE WILL BE INSTALLED WHICH WILL SERVE TO LOCK THE PARKING BRAKE SELF-ADJUST MECHANISM PAWL INTO ENGAGEMENT WITH THE RACHET. ALSO, OWNERS WILL BE ADVISED TO RELEASE AND REAPPLY THE PARKING BRAKE WHENEVER TOOTH SKIP OCCURS AND WILL BE REMINDED TO ALWAYS TURN OFF THE ENGINE AND LEAVE THE VEHICLE IN GEAR WHEN THE VEHICLE IS PARKED.
THE U-CLIP STYLE NUTS THAT RETAIN THE FRONT BUMPERS TO THE FRONT BUMPER INNER ARMS CAN FRACTURE.
Consequence & remedy
Consequence: IF ONE OF THE U-CLIP NUTS FRACTURES, THE BUMPER WILL LOOSEN AND RATTLE CAUSING FRACTURE OF THE REMAINING U-CLIP NUTS, RESULTING IN SEPARATION OF THE BUMPER FROM THE VEHICLE. IF THE BUMPER WERE TO DETACH FROM THE VEHICLE WHILE IT IS BEING DRIVEN, A VEHICLE COLLISION COULD RESULT.
Remedy: INSPECTION AND REPLACEMENT OF THE FOUR U-CLIP NUTS AND THE ASSOCIATED BOLTS.
THE TRANSFER CASES HAVE BEEN BUILT WITH THE WRONG ELECTRIC SHIFT MOTOR. THE TRANSFER CASES CAN SLIP OUT OF THE 4 X 4 HIGH GEAR POSITION DURING COASTING IN FORWARD GEARS OR WITH POWER APPLIED IN REVERSE GEAR.
Consequence & remedy
Consequence: IF THIS OCCURS, THE VEHICLE CAN ROLL FREELY AS IF INNEUTRAL POSITION REGARDLESS OF THE TRANSMISSION GEAR SELECTOR POSITION. THIS CANRESULT IN LOSS OF VEHICLE CONTROL AND AN ACCIDENT.
Remedy: REPLACE DEFECTIVE TRANSFER CASES WITH THE CORRECT VERSION.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
1993 Ford Bronco Problems, Complaints & Recalls | Skip That Year
Illustration