2026 Bronco Sport Badlands Sasquatch edition with less than three-thousand miles that we purchased brand new had a major transmission failure and was rendered inoperable. The Bronco Sport transmission pan cracked and the gasket failed upon driving home from a routine, ten minute trip to the grocery store resulting in sudden loss…
Read full complaint
2026 Bronco Sport Badlands Sasquatch edition with less than three-thousand miles that we purchased brand new had a major transmission failure and was rendered inoperable. The Bronco Sport transmission pan cracked and the gasket failed upon driving home from a routine, ten minute trip to the grocery store resulting in sudden loss of transmission fluid. The transmission fluid blew all over the engine compartment when this occurred The vehicle had to be towed to the dealership where it remains as of today (one week after the incident occurred). The issue has been confirmed by the Ford dealer. There were zero warning lamps or messages, but there was a smell of something burning. When the vehicle was parked, fluid poured out on the garage floor and continued to leak until it was put on a tow truck. We have a case number with Ford and are trying to see if there is an option for Ford to buy the vehicle back or to work with us on replacing it due to the incident and the vehicle being approximately two months old. Had we been driving at highway speed or were further from home, this could have resulted in an accident.
Ford Motor Company (Ford) is recalling certain 2026 Explorer, Bronco, Bronco Sport, Mustang, and Ranger vehicles. The engine piston domes may have been manufactured incorrectly, which can result in piston dome failure and lead to a loss of drive power.
Consequence & remedy
Consequence: An unexpected loss of drive power increases the risk of a crash.
Remedy: Dealers will inspect the engine pistons and replace the engine long block, if necessary, free of charge. Interim letters, notifying owners of the safety risk, were mailed September 3, 2026. Additional letters will be sent once the remedy is available, anticipated in December 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S61. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on August 28, 2026.
Ford Motor Company (Ford) is recalling certain 2026 Maverick, F-150, and Bronco Sport vehicles. Certain vehicle joints may be improperly tightened. This can lead to detached parts, unsecured cargo, degraded crash protection, electrical system failure, or a loss of vehicle stability.
Consequence & remedy
Consequence: Improperly tightened vehicle joints may lead to a loss of vehicle control, electrical failure, or detached parts, increasing the risk of a crash or fire.
Remedy: Dealers will inspect and tighten the vehicle joints or repair and replace the joint retention mechanisms as necessary, free of charge. Owner notifications letters are expected to be mailed September 21, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S60. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on August 26, 2026.
Ford Motor Company (Ford) is recalling certain 2021-2026 Bronco Sport and 2022-2026 Maverick vehicles. The front lower control arm ball joints may have been incorrectly installed or incorrectly repaired at the vehicle assembly plant, allowing the control arm to disconnect from the front wheel knuckle.
Consequence & remedy
Consequence: A detached control arm can cause a loss of vehicle control, increasing the risk of a crash.
Remedy: Owners are advised not to drive their vehicles until the remedy is completed. Dealers will inspect and repair the front lower control arm ball joints as necessary, free of charge.Owner notification letters were mailed September 2, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S36. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on May 29, 2026.
Ford Motor Company (Ford) is recalling certain 2025 Maverick and 2026 Bronco Sport vehicles equipped with a 1.5L or 2.0L MPC engine and an engine block heater. The engine block heater may overheat when the vehicle is parked with the block heater plugged in.
Consequence & remedy
Consequence: An overheated engine block heater can increase the risk of a fire.
Remedy: Owners are advised not to plug in their block heater until the vehicle is remedied. Dealers will replace the block heater, and inspect and replace the electrical cord if necessary, free of charge. Owners will also have an alternative option to replace the engine block heater element with a threaded plug, and remove the block heater electrical cord. Owner notification letters were mailed June 10, 2026. This recall expands previous NHTSA recall number 25V343. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S52. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on April 14, 2026.
Additional source detail variants (2)
Electrical System
Ford Motor Company (Ford) is recalling certain 2025 Maverick and 2026 Bronco Sport vehicles equipped with a 1.5L or 2.0L MPC engine and an engine block heater. The engine block heater may overheat when the vehicle is parked with the block heater plugged in.
Consequence: An overheated engine block heater can increase the risk of a fire.
Remedy: Owners are advised not to plug in their block heater until the vehicle is remedied. Dealers will replace the block heater, and inspect and replace the electrical cord if necessary, free of charge. Owners will also have an alternative option to replace the engine block heater element with a threaded plug, and remove the block heater electrical cord. Owner notification letters were mailed June 10, 2026. This recall expands previous NHTSA recall number 25V343. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S52. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on April 14, 2026.
Equipment:electrical:engine Block Heater
Ford Motor Company (Ford) is recalling certain 2025 Maverick and 2026 Bronco Sport vehicles equipped with a 1.5L or 2.0L MPC engine and an engine block heater. The engine block heater may overheat when the vehicle is parked with the block heater plugged in.
Consequence: An overheated engine block heater can increase the risk of a fire.
Remedy: Owners are advised not to plug in their block heater until the vehicle is remedied. Dealers will replace the block heater, and inspect and replace the electrical cord if necessary, free of charge. Owners will also have an alternative option to replace the engine block heater element with a threaded plug, and remove the block heater electrical cord. Owner notification letters were mailed June 10, 2026. This recall expands previous NHTSA recall number 25V343. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S52. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on April 14, 2026.
Ford Motor Company (Ford) is recalling certain 2025-2026 Bronco Sport and Maverick vehicles. The Occupant Classification Sensor (OCS) unit may fail to correctly detect the presence of an adult or child in the front passenger seat. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 208, "Occupant Crash Protection."
Consequence & remedy
Consequence: Failure to correctly detect a passenger may result in the air bag not deploying as intended, increasing the risk of injury during a crash.
Remedy: Dealers will replace the passenger seat occupant classification sensor, free of charge. Owner notification letters were mailed June 25, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C19. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on April 2, 2026.
Ford Motor Company (Ford) is recalling certain 2025-2026 Bronco and Bronco Sport vehicles. The Instrument Panel Cluster (IPC) may fail at startup.
Consequence & remedy
Consequence: An instrument panel display that does not show critical information, such as warning lights or vehicle speed, increases the risk of a crash.
Remedy: The instrument panel cluster software will be updated by a dealer or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed December 4, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SC3.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2026 Ford Bronco Sport Problems, Complaints & Recalls | Skip That Year
Illustration