NHTSA owner reports · September 18, 2026 snapshot.
Engine complaints
78 reportsClear category filterMileage unknown · Dec 4, 2025
Engine
Recurring Safety Defect: Powertrain Cooling System Failure causing Engine Overheating, Coolant Intrusion, and Loss of Motive Power. The vehicle has experienced three catastrophic cooling system failures within a 9-month period, posing a crash and fire risk. Incident 1 (February 2025): Water pump failure caused significant cool…
Read full complaint
Recurring Safety Defect: Powertrain Cooling System Failure causing Engine Overheating, Coolant Intrusion, and Loss of Motive Power. The vehicle has experienced three catastrophic cooling system failures within a 9-month period, posing a crash and fire risk. Incident 1 (February 2025): Water pump failure caused significant coolant loss. Diagnosed and repaired by authorized dealer under warranty. Incident 2 (June 2025): Vehicle leaked coolant and emitted visible smoke and burning odors from the exhaust. Dealer diagnosed internal turbocharger failure resulting in coolant intrusion into the engine and exhaust system. The catalytic converter was damaged by coolant burn-off and required replacement. This failure kept the vehicle out of service for 38 days. Incident 3 (November 2025): The vehicle engine overheated again while driving, triggering the "Fail-Safe" cooling mode. This resulted in a sudden reduction of motive power (limp mode), creating a collision hazard at highway speeds. The Check Engine light illuminated. Dealer diagnosis confirmed codes P1285 (Cylinder Head Overtemperature) and P05A1 (Active Grille Shutter failure). The manufacturer's dealer has confirmed the current failure but refuses to acknowledge it as part of the recurring powertrain thermal defect. The safety risk involves sudden deceleration in traffic due to overheating protection mode and potential fire risk from repeated coolant leaks onto hot engine components. The vehicle is currently at the dealer and available for inspection.
NHTSA ODI #11703132
Mileage unknown · Oct 1, 2025
Electrical SystemEngineFire
I went to start my car it did not start but repeatedly kept trying to start itself over and over the car locked up completely i couldn't push the brake or anything it wouldn't stop it disappeared from my app..the car cranked itself repeatedly until it caught fire and electrical smoke was rolling i had to call the fire department…
Read full complaint
I went to start my car it did not start but repeatedly kept trying to start itself over and over the car locked up completely i couldn't push the brake or anything it wouldn't stop it disappeared from my app..the car cranked itself repeatedly until it caught fire and electrical smoke was rolling i had to call the fire department i was parked at a dayhab for special needs had to run and have them to remove all of the special needs people in wheelchairs and or with other adaptive equipment had to run into another office building and tell them to remove their vehicles i had a serious worry that this could have hurt or even killed people they at the ford dealer that has had my car 21 days said it's the starter no way the starter just went nuts for no reason we had to call the fire department and everything they replaced the battery which my understanding has recall 24s24 which says causes glitches either someone is blaming a starter for something other than that
NHTSA ODI #11690883
Mileage unknown · Sep 28, 2025
EngineFuel/propulsion System
As you may know, my Ford Bronco 2022 is under NHTSA Recall 25V467 as of July 2025. October is approaching, and so far, Ford Motor Company has not found any remedy for this problem, which can not only cause a spontaneous engine fire, but can also cause the death of those inside the vehicle or a serious accident if it occurs while…
Read full complaint
As you may know, my Ford Bronco 2022 is under NHTSA Recall 25V467 as of July 2025. October is approaching, and so far, Ford Motor Company has not found any remedy for this problem, which can not only cause a spontaneous engine fire, but can also cause the death of those inside the vehicle or a serious accident if it occurs while driving. My vehicle is for daily use, and I have to transport my son to school every day, risking his life and mine, with the uncertainty of the vehicle catching fire. I ask that you consider requiring Ford Motor Company to collect these vehicles or exchange them for others of the same value that are not at risk.
NHTSA ODI #11690217
Mileage unknown · Sep 18, 2025
Engine
I am filing this complaint regarding a recall affecting my 2022 Ford Bronco Sport. I received a recall notice concerning the possibility of the vehicle catching fire. Despite numerous attempts to resolve the issue, Ford continues to ignore the warnings and say "we are working on fixing the issue." I feel unsafe and will not d…
Read full complaint
I am filing this complaint regarding a recall affecting my 2022 Ford Bronco Sport. I received a recall notice concerning the possibility of the vehicle catching fire. Despite numerous attempts to resolve the issue, Ford continues to ignore the warnings and say "we are working on fixing the issue." I feel unsafe and will not drive this vehicle until there is a resolution. Ford has taking months/years to fix this issue with no resolution in sight.
NHTSA ODI #11688038
Mileage unknown · Sep 6, 2025
Engine
I noticed my coolant level dropping about a year ago. I would fill up the coolant reservoir and the coolant level would drop within a few days. The issue was from the water pump leaking. I replaced the water pump with an OEM ford water pump. One year later the coolant level is dropping, and I have the same issue again. Lookin…
Read full complaint
I noticed my coolant level dropping about a year ago. I would fill up the coolant reservoir and the coolant level would drop within a few days. The issue was from the water pump leaking. I replaced the water pump with an OEM ford water pump. One year later the coolant level is dropping, and I have the same issue again. Looking at some of the forums, this appears to be a common issue with this make and mode.
NHTSA ODI #11685510
Mileage unknown · Jul 12, 2025
EngineFuel/propulsion System
Vehicle stutters when driving at slower speeds, usually between 22-27 MPH. After purchasing my vehicle used I have found that others have been reporting the same issue, to include in brand new Bronco Sports, and have been advised that is just how they are. Switching to sport mode does seem to help but the stutters occurs at diff…
Read full complaint
Vehicle stutters when driving at slower speeds, usually between 22-27 MPH. After purchasing my vehicle used I have found that others have been reporting the same issue, to include in brand new Bronco Sports, and have been advised that is just how they are. Switching to sport mode does seem to help but the stutters occurs at different speeds. There has been no known part identified as causing the issue. There are no warnings displayed and no codes showing.
NHTSA ODI #11673068
Mileage unknown · Jun 11, 2025
Electrical SystemEngineService Brakes
Vehicle locked up while driving. Has a new battery already. Full aux electrical function is fine but after shut down while driving will not restart, shift out of gear, roll or steer. All electrical works fine. To tow onto flat bed, had to drag the tires.
NHTSA ODI #11666435
Mileage unknown · May 9, 2025
Engine
The water pump began leaking somewhere around 62,000 miles, however there were no visible signs of a leak and no maintenance warnings appeared on the dashboard. I only know there was a leak because I took my Bronco Sport into the Ford dealership to have other recalls repaired and they advised me to have the water pump replaced a…
Read full complaint
The water pump began leaking somewhere around 62,000 miles, however there were no visible signs of a leak and no maintenance warnings appeared on the dashboard. I only know there was a leak because I took my Bronco Sport into the Ford dealership to have other recalls repaired and they advised me to have the water pump replaced as it was leaking. I have researched this issue and it appears to be a very common issue with Bronco Sports of all years. This issue can put others or myself at risk because it would be very easy for the engine to run out of coolant and seize up in potentially very dangerous traffic situations. Because Ford doesn't have a way for Bronco Sport drivers to come aware of this issue unless vigilantly checking coolant levels every week, it would be very easy for the engine to overheat and stall before the driver can become aware there was even an issue.
NHTSA ODI #11659890
Mileage unknown · May 5, 2025
EnginePower Train
On [XXX], the vehicle overheated during a commute, resulting in a blown radiator cap and an empty engine coolant reservoir. Coolant levels had been properly maintained up to that point. The following day, engine coolant was again low, though no visible leaks were found. On April 12, I requested warranty service but was told “ser…
Read full complaint
On [XXX], the vehicle overheated during a commute, resulting in a blown radiator cap and an empty engine coolant reservoir. Coolant levels had been properly maintained up to that point. The following day, engine coolant was again low, though no visible leaks were found. On April 12, I requested warranty service but was told “services aren’t rendered on Saturdays” despite the service department being open. An appointment was scheduled for April 14 to inspect the overheating damage and address recall #25502. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6) When I arrived on April 14, I was denied service due to the department being “backed up and understaffed.” I expressed concern about further driving the car in its condition, but Service Advisor Bill Crovo insisted it was safe to drive and denied my request to leave the vehicle on-site. I was also not offered a complimentary vehicle or alternative transportation. On April 17, I called to escalate the matter. The General Service Manager, Chris Gagnon, not only dismissed my concerns but stated he could refuse service on a vehicle that is clearly under active warranty coverage. This is not only unprofessional — it is illegal under Massachusetts consumer protection law. At this point, I was forced to seek help from other dealerships, one of which advised me to pressure the selling dealership to fulfill its obligation. I called back, and Mr. Gagnon assured me the issue would be handled. The vehicle was taken in on April 18, and the water pump was replaced. On April 24, I picked it up and drove just 21 miles before the engine began making an unfamiliar noise and the coolant reservoir was, once again, empty. I got the vehicle towed to a different dealership, Salem Ford in New Hampshire. The second dealership confirmed — in writing — that the first dealership skipped a critical step during the water pump replacement, directly causing the continued issue.
NHTSA ODI #11659083
67,000 miles · Apr 29, 2025
EngineEngine And Engine Cooling
The contact owns a 2022 Ford Bronco sport. The contact stated while driving at an undisclosed speed, the O2 sensor warning light illuminated. The vehicle was taken to an independent mechanic where the failure was diagnosed with a failed O2 sensor. The contact was informed that the O2 sensor needed to be replaced. The vehicle was…
Read full complaint
The contact owns a 2022 Ford Bronco sport. The contact stated while driving at an undisclosed speed, the O2 sensor warning light illuminated. The vehicle was taken to an independent mechanic where the failure was diagnosed with a failed O2 sensor. The contact was informed that the O2 sensor needed to be replaced. The vehicle was not repaired. The contact was informed that the O2 sensor had been ordered. The vehicle was taken to the dealer for an oil change and the contact was informed of a coolant leak. The vehicle was not repaired. The vehicle was driven to the residence. The vehicle was put up on the lift by the contact who is an independent mechanic. The contact performed an inspection of the vehicle and became aware that the coolant pump, catalytic convertor, and serpentine belt had failed. The dealer was made aware of the failure. The vehicle was taken to the dealer where the failures were confirmed. The contact was informed that the catalytic convertor, coolant pump, and serpentine belt needed to be replaced. The vehicle was being repaired. The contact was informed that the repairs were not covered under recall. The manufacturer was made aware of the failure and a case was filed. The failure mileage was approximately 67,000.
NHTSA ODI #11657560
Official recalls
15May 27, 2026
Ford Motor Company (Ford) is recalling certain 2021-2026 Bronco Sport and 2022-2026 Maverick vehicles. The front lower control arm ball joints may have been incorrectly installed or incorrectly repaired at the vehicle assembly plant, allowing the control arm to disconnect from the front wheel knuckle.
Consequence & remedy
Consequence: A detached control arm can cause a loss of vehicle control, increasing the risk of a crash.
Remedy: Owners are advised not to drive their vehicles until the remedy is completed. Dealers will inspect and repair the front lower control arm ball joints as necessary, free of charge.Owner notification letters were mailed September 2, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S36. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on May 29, 2026.
Oct 10, 2025
Ford Motor Company (Ford) is recalling certain 2016-2019 Lincoln MKC, 2016-2023 Explorer, 2019-2020 Fusion, 2019-2024 Ranger, 2020-2022 Lincoln Corsair, Escape, 2021-2024 Bronco, Bronco Sport, and 2022-2024 Maverick vehicles. The engine block heater may crack and develop a coolant leak, causing it to short circuit when the block heater is plugged in.
Consequence & remedy
Consequence: An electrical short circuit can increase the risk of a fire.
Remedy: Owners are advised not to plug in their block heater until the vehicle is remedied. Dealers will replace the block heater, free of charge. Owners will also have a alternative option to replace engine block heater element with a threaded blanking plug, and remove the block heater electrical cord. Interim letters, notifying owners of the safety risk, were mailed December 3, 2025. Additional letters will be sent once the final remedy is available, anticipated September 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SA4. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on October 15, 2025.
Jul 11, 2025
Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco Sport and 2020-2022 Escape vehicles equipped with 1.5L engines. A fuel injector may crack and leak fuel inside the engine compartment.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source, such as hot engine or exhaust components, can increase the risk of a fire.
Remedy: Dealers will update the engine control software. In addition, dealers will replace the high-pressure fuel rail assembly and fuel injectors, free of charge. As an interim repair, dealers will update the engine control software, free of charge. Interim owner notification letters notifying owners of the safety risk were mailed August 29, 2025. Second letters will be sent once the final remedy is available, anticipated in July 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S76. This recall expands and replaces previous recall numbers 22V-859, 24V187, and 25V165. Vehicles previously remedied under 22V-859, 24V187, and 25V165 will need to have the new final remedy performed once it is available.
Jun 27, 2025
Ford Motor Company (Ford) is recalling certain 2018-2022 Transit Connect, 2019-2020 MKZ, MKX, Edge, Continental, F-150, Nautilus, Fusion, 2019-2023 Ranger, Mustang, 2020-2021 EcoSport, Expedition, Navigator, 2020-2022 Escape, F-250 SD, Corsair, 2020-2023 Aviator, Transit, 2020-2024 Explorer, 2021-2024 Bronco Sport, and 2022-2024 Maverick vehicles. A software error may cause the rearview camera to display a blank image, or the image may remain on the display after the backing event has ended.
Consequence & remedy
Consequence: A rearview camera that displays a blank image can reduce the driver's view behind the vehicle. A rearview image that continues to be displayed after the vehicle is shifted out of reverse may distract the driver. Both of these situations can increase the risk of a crash.
Remedy: Dealers will update the rearview camera software, free of charge. Owner notification letters were mailed September 4, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S72.
Mar 14, 2025
Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco Sport and 2022-2023 Maverick vehicles previously repaired incorrectly under recall number 24V-267. The body and power train control modules may fail to detect a change in the 12-volt battery state of charge.
Consequence & remedy
Consequence: An undetected low battery charge can result in a loss of electrical accessories such as hazard lights, or cause a loss of drive power, increasing the risk of a crash.
Remedy: Dealers will recalibrate the body control module and power train control module, free of charge. Owner notification letters were mailed April 23, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S26.
Additional source detail variants (2)
Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco Sport and 2022-2023 Maverick vehicles previously repaired incorrectly under recall number 24V-267. The body and power train control modules may fail to detect a change in the 12-volt battery state of charge.
Consequence: An undetected low battery charge can result in a loss of electrical accessories such as hazard lights, or cause a loss of drive power, increasing the risk of a crash.
Remedy: Dealers will recalibrate the body control module and power train control module, free of charge. Owner notification letters were mailed April 23, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S26.
Electrical System:body Control Module/bcm
Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco Sport and 2022-2023 Maverick vehicles previously repaired incorrectly under recall number 24V-267. The body and power train control modules may fail to detect a change in the 12-volt battery state of charge.
Consequence: An undetected low battery charge can result in a loss of electrical accessories such as hazard lights, or cause a loss of drive power, increasing the risk of a crash.
Remedy: Dealers will recalibrate the body control module and power train control module, free of charge. Owner notification letters were mailed April 23, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S26.
Mar 14, 2025
Ford Motor Company (Ford) is recalling certain 2020-2022 Escape and 2021-2023 Bronco Sport vehicles previously repaired incorrectly under recall numbers 22V-859 or 24V-187. A fuel injector may crack and leak fuel inside the engine compartment.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source such as hot engine or exhaust components, can increase the risk of a fire.
Remedy: Dealers will update the powertrain control module (PCM) software, free of charge. Owner notification letters were mailed April 22, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S21.
Jan 17, 2025
Ford Motor Company (Ford) is recalling certain 2021-2023 Bronco Sport and 2022-2023 Maverick vehicles. The 12-volt battery may experience degradation and suddenly fail.
Consequence & remedy
Consequence: Battery failure can result in a loss of electrical accessories, including the hazard lights, or cause a loss of drive power, increasing the risk of a crash.
Remedy: Dealers will inspect and if necessary, replace the 12-volt battery, free of charge. Owner notification letters were mailed May 2, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S02. Vehicles in this recall were previously repaired under 24V-267 and will need to have the new remedy completed.
Apr 12, 2024
Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco Sport and 2022-2023 Maverick vehicles. The body and power train control modules may fail to detect a change in the 12-volt battery state of charge.
Consequence & remedy
Consequence: An undetected low battery charge can result in a loss of electrical accessories such as hazard lights, or cause a loss of drive power, increasing the risk of a crash.
Remedy: Dealers will recalibrate the body control module and power train control module, free of charge. Owner notification letters were mailed on June 4, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S24.
Additional source detail variants (2)
Electrical System:body Control Module/bcm
Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco Sport and 2022-2023 Maverick vehicles. The body and power train control modules may fail to detect a change in the 12-volt battery state of charge.
Consequence: An undetected low battery charge can result in a loss of electrical accessories such as hazard lights, or cause a loss of drive power, increasing the risk of a crash.
Remedy: Dealers will recalibrate the body control module and power train control module, free of charge. Owner notification letters were mailed on June 4, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S24.
Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco Sport and 2022-2023 Maverick vehicles. The body and power train control modules may fail to detect a change in the 12-volt battery state of charge.
Consequence: An undetected low battery charge can result in a loss of electrical accessories such as hazard lights, or cause a loss of drive power, increasing the risk of a crash.
Remedy: Dealers will recalibrate the body control module and power train control module, free of charge. Owner notification letters were mailed on June 4, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S24.
Mar 8, 2024
Ford Motor Company (Ford) is recalling certain 2022-2023 Bronco Sport and 2022 Escape vehicles equipped with 1.5L engines. A fuel injector may crack and leak fuel inside the engine compartment.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source such as hot engine or exhaust components, can increase the risk of a fire.
Remedy: Dealers will update the engine control software to include fuel injector leak detection and install a drain tube, free of charge. Owner notification letters were mailed on April 24, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S16. This recall is an expansion of previous recall number 22V-859.
Nov 18, 2022
Ford Motor Company (Ford) is recalling certain 2020-2023 Escape and 2021-2023 Bronco Sport vehicles equipped with 1.5L engines. A fuel injector may crack and leak fuel inside the engine compartment.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source such as hot engine or exhaust components, can increase the risk of a fire.
Remedy: Dealers will update the engine control software to include fuel injector leak detection and install a drain tube, free of charge. Interim owner notification letters informing owners of the safety risk were mailed January 9, 2023. Remedy parts are expected to be available in 1st Quarter of 2023. Owner notification letters were mailed February 28, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S73. This recall includes all vehicles previously recalled under 22V-191. Vehicles previously remedied under 22V-191 will need to have the new remedy performed.
Oct 20, 2022
Ford Motor Company (Ford) is recalling certain 2022 Bronco Sport vehicles. The fuel pump control module (FPCM) bracket may not be secured to the fuel tank assembly, which can lead to FPCM failure and cause an engine stall.
Consequence & remedy
Consequence: An engine stall can increase the risk of a crash.
Remedy: Dealers will replace the fuel tank, free of charge. Owner notification letters were mailed December 1, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S66.
Sep 14, 2022
Ford Motor Company (Ford) is recalling certain 2022-2023 Bronco Sport and 2022 F-150 vehicles. The parking lights may flicker when the headlights are activated. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: Flickering parking lights can reduce visibility, increasing the risk of a crash.
Remedy: Dealers will replace the LED Driver module, free of charge. Owner notification letters were mailed March 29, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22C22.
Mar 25, 2022
Ford Motor Company (Ford) is recalling certain 2020-2022 Escape and 2021-2022 Bronco Sport vehicles equipped with 1.5L engines. The engine oil separator housing may crack and develop an oil leak.
Consequence & remedy
Consequence: An oil leak in the presence of an ignition source such as hot engine or exhaust components, can increase the risk of a fire.
Remedy: Dealers will inspect the oil separator for damage or oil leaks, and replace the oil separator and seals, as necessary, free of charge. Owner notification letters were mailed April 18, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S21.
Nov 23, 2021
Ford Motor Company (Ford) is recalling certain 2021-2022 Bronco Sport and Escape vehicles. The rear brake linings may have been manufactured incorrectly, which can affect braking performance. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 135, "Light Vehicle Brake Systems."
Consequence & remedy
Consequence: During certain situations, the driver may have to apply more brake pedal force, and the distance required to stop the vehicle may be extended, increasing the risk of a crash.
Remedy: Dealers will replace the front brake pads, free of charge. Owner notification letters were mailed August 17, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21C31.
Aug 10, 2021
Ford Motor Company (Ford) is recalling certain 2021 Escape, Lincoln Corsair, and 2021-2022 Bronco Sport vehicles. The fuel delivery module may leak inside the fuel tank, causing low fuel pressure which could result in an engine stall.
Consequence & remedy
Consequence: An engine stall increases the risk of a crash.
Remedy: Dealers will replace the fuel delivery module, free of charge. Interim notification letters (remedy not available) were mailed on September 30, 2021. Owner notification letters were mailed on December 14, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S38.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3RQ24014 · Loss Of Motive Power
Opened Nov 15, 2024 · Closed Oct 10, 2025
Status: closed (inferred from source dates) · Electrical SYSTEM:12V/24V/48V Battery
On January 31, 2024, The Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE24002) to investigate loss of motive power allegations in model year (MY) 2021 Ford Bronco Sport vehicles. Consumers reported a loss of engine power accompanied by complete electrical system failure either while driving or after stopping at a traffic light or stop sign. The vehicles generally could not be restarted, and the incidents were commonly diagnosed by dealerships to a failed 12-Volt (12V) battery. On April 12, 2024, Ford issued safety recall 24V-267 covering 456,565 MY 2021-2024 Ford Bronco Sport and MY 2022-2023 Ford Maverick vehicles. The recall addressed loss of motive power resulting from sudden degradation of the 12V battery during the drive cycle. The recall remedy consisted of software updates to the body control module and the powertrain control module. The updated software aimed to provide warning to consumers when the battery is failing and inhibit certain vehicle functions which can lead to loss of motive power incidents. Additionally, Ford removed the existing 12V Enhanced Flooded Battery (EFB) as both a service component for the subject vehicles and original equipment for newly built Bronco Sport vehicles (during MY 2024 production), replacing it with a more robust absorbed glass mat (AGM) battery. The same AGM battery had been incorporated into Ford Maverick production in late 2022. Following recall 24V-267, ODI received loss of motive power complaints in vehicles that had previously received Ford’s software-based remedy. Consumers reported that they did not receive warnings related to the 12V battery or the vehicle’s electrical system before the loss of power. On November 15, 2024, ODI opened Recall Query (RQ24014) to assess the effectiveness of the 24V-267 recall remedy. On January 19, 2025, Ford issued recall 25V-019 covering 272,817 MY 2021-2023 Bronco Sport and MY 2022-2023 Ford Maverick vehicles. The new recall addressed the same hazard as 24V-267 but required replacement of the existing 12V battery with an AGM battery as the remedy. Ford reported that following the opening of RQ24014, it evaluated several field-returned 12V batteries, and determined that EFBs produced by battery supplier Camel potentially contained internal manufacturing defects causing loss of motive power. Ford further concluded that the software updates provided in the 24V-267 recall remedy were unable to detect battery failures quickly enough to avoid loss of motive power. Vehicles previously within the scope of recall 24V-267, but outside of the scope of recall 25V-019, are equipped with EFBs produced by a different battery supplier (Clarios). When recall 25V-019 was issued, Ford had not identified any Clarios EFBs exhibiting the same failure mode as the Camel EFBs. In light of Ford’s recall action, ODI is closing this Recall Query. The agency will continue to monitor loss of motive power complaints in Bronco Sport vehicles equipped with Clarios EFBs and reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
RQ24008 · Underhood Fires Caused By Fuel Leak
Opened Apr 11, 2024 · Closed Oct 30, 2025
Status: closed (inferred from source dates) · Fuel System, Gasoline:fuel Injection System:injectors
On April 11, 2024, NHTSA’s Office of Defects Investigation (“ODI”) opened this Recall Query (“RQ”) to investigate the adequacy of, including various safety concerns associated with, the remedy program in recalls 22V-859 (filed Nov. 18, 2022) and 24V-187 (filed Mar. 8, 2024). The vehicle population associated with these recalls includes certain MY 2020-2022 Ford Escape vehicles and MY 2021-2023 Ford Bronco Sport vehicles equipped with 1.5L engines. The safety defect in each recall involves high-pressure fuel injectors that are susceptible to cracking, allowing liquid fuel and fuel vapor to migrate onto hot surfaces within the engine compartment potentially resulting in underhood vehicle fires. The remedy programs described in recalls 22V-859 and 24V-187 are identical and involve both a software component and a hardware component. Specifically, Ford developed an updated engine control software designed to detect a pressure drop in the high-pressure fuel rail, provide instrument cluster messaging to the driver, invoke a strategy to disable the high-pressure fuel pump, derate the engine output, and lower the temperatures of possible ignition sources within the engine compartment. Additionally, Ford would install a tube into the engine’s cylinder head drain hole to shunt spilled liquid fuel past the various hot surfaces within the engine compartment and ultimately discard the spilled liquid fuel onto the roadway. ODI identified various safety concerns with this remedy program, which, among other things, notably did not include repairing or replacing the defective part and potentially did include the introduction of new safety defects (like fuel spilling near the spark plugs and fuel spilling onto the public roadway). NHTSA opened this investigation to evaluate these concerns with the remedy program, including whether the vehicles were still susceptible to underhood fires even post-remedy. As described in more detail in the Additional Summary posted simultaneously with this resume, ODI conducted a thorough investigation that included analyzing data and other materials received in response to two Information Requests, as well as inspections of post-remedy vehicles that experienced an underhood fire. ODI and Ford worked to identify and locate vehicles that experienced post-remedy fires and conduct joint vehicle inspections. ODI’s investigation also prompted Ford to initiate a more in-depth evaluation of the defect, including Ford’s conducting component level testing of high-pressure fuel injectors. ODI met with Ford on several occasions throughout this investigation to jointly conduct certain of these described tasks and to discuss test results. A collateral issue surfaced as a result of this investigation: in March 2025, Ford realized that despite relevant repairs having been recorded as successfully completed, approximately 33,576 vehicles subject to recalls 22V-859 and 24V-187 did not have the software component of the remedy program installed correctly. Thus, on March 27, 2025, Ford filed a new related recall (25V-165) for these vehicles, notifying NHTSA and the public that they were still at risk of experiencing an underhood vehicle fire due to cracked fuel injectors despite the consumer having had their vehicle remedied pursuant to one of the two earlier recalls. In June 2025, Ford committed to implementing a new remedy program to repair the vehicles. On July 11, 2025, Ford documented this commitment in a new recall filing (25V-467), which explains that Ford’s upcoming remedy program will involve proactive replacement of all high-pressure fuel injectors within the recall population. In view of the recall action taken by Ford, ODI is closing this Recall Query, which was opened given NHTSA’s concerns that the initial remedy programs of the software to detect the pressure drop plus installation of the drain tube did not constitute an adequate repair. The agency reserves the right to take additional action if warranted by future circumstances.
PE24002 · Loss Of Motive Power
Opened Jan 31, 2024 · Closed Aug 19, 2024
Status: closed (inferred from source dates) · Electrical SYSTEM:12V/24V/48V Battery
On January 31, 2024, the Office of Defects Investigation (ODI) opened PE24002 to investigate allegations of loss of motive power in model year (MY) 2021 Ford Bronco Sport vehicles. At that time, ODI had received 31 Vehicle Owner Questionnaires (VOQs), with consumers commonly reporting a loss of engine power accompanied by complete electrical system failure which occurred either while driving, or after coming to a stop. The investigation revealed that MY 2021-2024 Ford Bronco Sport and certain MY 2022-2023 Ford Maverick vehicles are equipped with a 12V enhanced flooded battery (EFB), which may experience an abrupt failure during a drive cycle. The failure is the result of an internal corrosion issue, which is influenced by long exposure to high under-hood temperatures. If the sudden loss of 12V battery voltage is not detected by the vehicle’s battery management sensor, the vehicle can experience a loss of power event without providing any warning to the driver. Following a loss of power due to battery failure, the vehicle may be without all 12V accessories including hazard lights and typically will not be able to be restarted. In its March 2024 response to ODI’s information request, Ford provided 367 customer complaints (including field reports, lawsuits, and legal claims) and 1005 warranty claims relating to the alleged defect. When combining ODI and manufacturer failure report data, there are 1,368 unique VINs represented across MY 2021-2023 Ford Bronco Sport vehicles. One of the VOQs submitted to NHTSA reported a minor rear-end collision resulting from a loss of power event. Included within Ford’s complaints were a reported single-vehicle collision and a vehicle fire which occurred following a loss of power event at a traffic light (fire cause and origin was not determined). Additionally, across ODI and manufacturer data, there were 12 allegations of either acid leaking from the 12V battery or smoke emitting from the battery area within the engine compartment. On April 12, 2024, Ford submitted recall 24V267 for MY 2021-2024 Ford Bronco Sport and certain MY 2022-2023 Ford Maverick vehicles (total population 456,565). The recall remedy provides updated calibrations to the body control module and powertrain control module. Ford indicated that the update will result in improved detection of 12V battery state of charge during drive cycles and will provide notification to the driver if the battery significantly degrades while driving. Additionally, Ford has replaced the EFB with an absorbed glass mat (AGM) battery as both a service component for the subject vehicles and as original equipment for Bronco Sport vehicles with production dates beginning in mid-March 2024. The warranty claim rate for peer vehicles equipped with an AGM battery is substantially lower than that for the subject vehicle population. In view of the recall action being taken by Ford, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Electrical SYSTEM:12V/24V/48V Battery
On January 31, 2024, the Office of Defects Investigation (ODI) opened PE24002 to investigate allegations of loss of motive power in model year (MY) 2021 Ford Bronco Sport vehicles. At that time, ODI had received 31 Vehicle Owner Questionnaires (VOQs), with consumers commonly reporting a loss of engine power accompanied by complete electrical system failure which occurred either while driving, or after coming to a stop. The investigation revealed that MY 2021-2024 Ford Bronco Sport and certain MY 2022-2023 Ford Maverick vehicles are equipped with a 12V enhanced flooded battery (EFB), which may experience an abrupt failure during a drive cycle. The failure is the result of an internal corrosion issue, which is influenced by long exposure to high under-hood temperatures. If the sudden loss of 12V battery voltage is not detected by the vehicle’s battery management sensor, the vehicle can experience a loss of power event without providing any warning to the driver. Following a loss of power due to battery failure, the vehicle may be without all 12V accessories including hazard lights and typically will not be able to be restarted. In its March 2024 response to ODI’s information request, Ford provided 367 customer complaints (including field reports, lawsuits, and legal claims) and 1005 warranty claims relating to the alleged defect. When combining ODI and manufacturer failure report data, there are 1,368 unique VINs represented across MY 2021-2023 Ford Bronco Sport vehicles. One of the VOQs submitted to NHTSA reported a minor rear-end collision resulting from a loss of power event. Included within Ford’s complaints were a reported single-vehicle collision and a vehicle fire which occurred following a loss of power event at a traffic light (fire cause and origin was not determined). Additionally, across ODI and manufacturer data, there were 12 allegations of either acid leaking from the 12V battery or smoke emitting from the battery area within the engine compartment. On April 12, 2024, Ford submitted recall 24V267 for MY 2021-2024 Ford Bronco Sport and certain MY 2022-2023 Ford Maverick vehicles (total population 456,565). The recall remedy provides updated calibrations to the body control module and powertrain control module. Ford indicated that the update will result in improved detection of 12V battery state of charge during drive cycles and will provide notification to the driver if the battery significantly degrades while driving. Additionally, Ford has replaced the EFB with an absorbed glass mat (AGM) battery as both a service component for the subject vehicles and as original equipment for Bronco Sport vehicles with production dates beginning in mid-March 2024. The warranty claim rate for peer vehicles equipped with an AGM battery is substantially lower than that for the subject vehicle population. In view of the recall action being taken by Ford, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Electrical SYSTEM:12V/24V/48V Battery
On January 31, 2024, the Office of Defects Investigation (ODI) opened PE24002 to investigate allegations of loss of motive power in model year (MY) 2021 Ford Bronco Sport vehicles. At that time, ODI had received 31 Vehicle Owner Questionnaires (VOQs), with consumers commonly reporting a loss of engine power accompanied by complete electrical system failure which occurred either while driving, or after coming to a stop. The investigation revealed that MY 2021-2024 Ford Bronco Sport and certain MY 2022-2023 Ford Maverick vehicles are equipped with a 12V enhanced flooded battery (EFB), which may experience an abrupt failure during a drive cycle. The failure is the result of an internal corrosion issue, which is influenced by long exposure to high under-hood temperatures. If the sudden loss of 12V battery voltage is not detected by the vehicle’s battery management sensor, the vehicle can experience a loss of power event without providing any warning to the driver. Following a loss of power due to battery failure, the vehicle may be without all 12V accessories including hazard lights and typically will not be able to be restarted. In its March 2024 response to ODI’s information request, Ford provided 367 customer complaints (including field reports, lawsuits, and legal claims) and 1005 warranty claims relating to the alleged defect. When combining ODI and manufacturer failure report data, there are 1,368 unique VINs represented across MY 2021-2023 Ford Bronco Sport vehicles. One of the VOQs submitted to NHTSA reported a minor rear-end collision resulting from a loss of power event. Included within Ford’s complaints were a reported single-vehicle collision and a vehicle fire which occurred following a loss of power event at a traffic light (fire cause and origin was not determined). Additionally, across ODI and manufacturer data, there were 12 allegations of either acid leaking from the 12V battery or smoke emitting from the battery area within the engine compartment. On April 12, 2024, Ford submitted recall 24V267 for MY 2021-2024 Ford Bronco Sport and certain MY 2022-2023 Ford Maverick vehicles (total population 456,565). The recall remedy provides updated calibrations to the body control module and powertrain control module. Ford indicated that the update will result in improved detection of 12V battery state of charge during drive cycles and will provide notification to the driver if the battery significantly degrades while driving. Additionally, Ford has replaced the EFB with an absorbed glass mat (AGM) battery as both a service component for the subject vehicles and as original equipment for Bronco Sport vehicles with production dates beginning in mid-March 2024. The warranty claim rate for peer vehicles equipped with an AGM battery is substantially lower than that for the subject vehicle population. In view of the recall action being taken by Ford, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration