NHTSA owner reports · September 18, 2026 snapshot.
Unknown Or Other complaints
96 reportsClear category filterMileage unknown · Nov 18, 2025
Electrical SystemEngineUnknown Or Other
While driving my 2021 Ford Bronco Sport, I experienced a strong chemical/fume smell entering the cabin, which caused headache and nausea. I later found that the battery installed in the vehicle had vent holes with visible liquid residue indicating leakage. I did not authorize or install this battery — it appears the battery was …
Read full complaint
While driving my 2021 Ford Bronco Sport, I experienced a strong chemical/fume smell entering the cabin, which caused headache and nausea. I later found that the battery installed in the vehicle had vent holes with visible liquid residue indicating leakage. I did not authorize or install this battery — it appears the battery was changed without my knowledge while the vehicle was in a lender’s possession. This created a serious safety concern because the fumes entered the HVAC system and the vehicle became unsafe to operate. I had the vehicle towed to two separate Ford dealerships. Both refused to inspect the HVAC system or provide a proper safety diagnosis. One dealer admitted the battery had “traces of leaking fluid,” but no diagnostic inspection was performed, and they attempted to close the repair order without documenting the safety concern. I was forced to replace the battery out of pocket just to safely drive the vehicle, but the original leaking battery and the exposure incident should still be investigated. My safety was put at risk, and the dealerships refused proper inspection or remediation.
NHTSA ODI #11700017
Mileage unknown · Oct 28, 2025
Electrical SystemEngineUnknown Or Other
I took my vehicle into my local ford dealership to get three active recalls remedied. Within 24 hours, my check engine light reappeared as well as "service engine soon" on my way into work. Upon leaving work, the dash lights were gone. They would come and go periodically. After about a week, it would pop up "service engine soon"…
Read full complaint
I took my vehicle into my local ford dealership to get three active recalls remedied. Within 24 hours, my check engine light reappeared as well as "service engine soon" on my way into work. Upon leaving work, the dash lights were gone. They would come and go periodically. After about a week, it would pop up "service engine soon" and within ten minutes, regardless of speed, the RPMs would fly all the way up and the vehicle would act as if I took my foot off of the gas, almost immediately stopping on the highway. I would have to almost immediately pull off of the road and my vehicle would stall, flashing "shift system failure" as well as failing to let me put the vehicle into park or any other gear. Taking it into the shop, they told me that was due to a software bug WHICH THEY JUST "FIXED" with a recall update. They also proceeded to tell me there is metal debris in my oil and I need my transmission rebuilt, quoting me $13,000.
NHTSA ODI #11696088
Mileage unknown · Oct 13, 2025
Seat BeltsService BrakesUnknown Or Other
Low engine oil pressure sensor flashes & can’t accelerate past 40mph
NHTSA ODI #11693097
Mileage unknown · Sep 2, 2025
Unknown Or Other
I am reporting a serious and recurring issue with the catalytic converter on my 2021 Ford Bronco Sport (1.5L EcoBoost), which has resulted in reduced efficiency and partial blockage, causing exhaust gases to enter the cabin and triggering engine code P0171. My safety and the safety of others have been compromised because exhaust…
Read full complaint
I am reporting a serious and recurring issue with the catalytic converter on my 2021 Ford Bronco Sport (1.5L EcoBoost), which has resulted in reduced efficiency and partial blockage, causing exhaust gases to enter the cabin and triggering engine code P0171. My safety and the safety of others have been compromised because exhaust fumes, including carbon monoxide, have entered the cabin, which is particularly dangerous as I am currently pregnant. In addition, the engine experiences RPM fluctuations and revs up on its own, sometimes hesitating during acceleration, creating a risk of loss of control or accidents, and reduced engine efficiency contributes to unpredictable vehicle behavior. The problem has been confirmed by a dealership, which diagnosed the catalytic converter inefficiency and provided a $2,000 replacement quote. This issue has been widely reported among other 2021 Bronco Sport owners, indicating a recurring problem. The vehicle has been inspected by the dealership, which ran diagnostics and verified the codes. Prior to the failure, the Check Engine Light illuminated, and I experienced exhaust fumes in the cabin, unusual odors, reduced engine performance, and RPM surges with hesitation during acceleration, first appearing around 80,000. This defect poses not only a serious safety hazard, but also environmental concerns, as the failing catalytic converter increases emissions of harmful gases, including carbon monoxide, hydrocarbons, and nitrogen oxides, contributing to air pollution and greenhouse gas emissions. I respectfully request that this issue be formally investigated by Ford and NHTSA for a possible recall, that consideration be given to goodwill or warranty coverage for affected vehicles, that guidance be provided for the safe operation of vehicles exhibiting this defect, particularly for pregnant passengers or others at risk, and that the environmental impact of this defect be considered during the investigation.
NHTSA ODI #11684571
Mileage unknown · Aug 26, 2025
EngineUnknown Or Other
Transmission shudders at low speeds (around 25-40 mph) when accelerating. This happens when shifting around 2nd gear something’s between 2nd and 3rd. Many online forums report the same issue in similar model vehicles and year when vehicle is just outside of warranty period issue occurred out of nowhere and happens consistently.
NHTSA ODI #11683230
Mileage unknown · Aug 17, 2025
Fuel/propulsion SystemUnknown Or Other
While driving car lost power, engine revs but doesn’t go, RPMs rev up. Please do your job and fix this car that has thousands of dollars owed on it because I wanted a broncho sport
NHTSA ODI #11681196
Mileage unknown · Aug 7, 2025
Forward Collision AvoidanceSuspensionUnknown Or Other
Car suddenly and dangerously braked on highway with no other vehicles around. Afterwards the tool and check engine lights came on. All advance trac systems failed. Dealership replaced the broken bolts and rear axle. In review it appears recall 21s04 should apply. Site shows 2021 broncos from Hermosillo plant apply. Rep stated bu…
Read full complaint
Car suddenly and dangerously braked on highway with no other vehicles around. Afterwards the tool and check engine lights came on. All advance trac systems failed. Dealership replaced the broken bolts and rear axle. In review it appears recall 21s04 should apply. Site shows 2021 broncos from Hermosillo plant apply. Rep stated building date range 7/22-11/24. How can this apply to a 2021 ford recall?
NHTSA ODI #11679032
Mileage unknown · Jul 24, 2025
Unknown Or Other
So the window switches are cutting my fingers. Whatever was used to coat the switches peels like sturdy tin foil and has sliced my fingers multiple times as well as my passengers. I had to peel that coating off the switches so no one keeps getting injured in my vehicle. I just bought this car used in April and it cut me the firs…
Read full complaint
So the window switches are cutting my fingers. Whatever was used to coat the switches peels like sturdy tin foil and has sliced my fingers multiple times as well as my passengers. I had to peel that coating off the switches so no one keeps getting injured in my vehicle. I just bought this car used in April and it cut me the first time I got in it I wasn't thinking of anything until it kept cutting me and other people.
NHTSA ODI #11675982
Mileage unknown · Jun 7, 2025
Unknown Or Other
Sunroof exploded
NHTSA ODI #11665472
Mileage unknown · Apr 20, 2025
Power TrainUnknown Or OtherVehicle Speed Control
Purchased the Bronco Sport brand new in September 2021. Almost from the outset, the vehicle has been a nightmare. We just purchased our third battery. The vehicle died at an intersection and had to be towed to the dealership. They replaced the battery but it again failed. We have experienced numerous electrical issues with …
Read full complaint
Purchased the Bronco Sport brand new in September 2021. Almost from the outset, the vehicle has been a nightmare. We just purchased our third battery. The vehicle died at an intersection and had to be towed to the dealership. They replaced the battery but it again failed. We have experienced numerous electrical issues with the vehicle as well as with the brakes and the power train. We have had the shift system fault notification come on several times. We took it in to the dealership who made some repairs and the notification went away for awhile. However, most recently, we were driving the vehicle down the interstate when it suddenly would not accelerate. We were very lucky to be able to maneuver the vehicle onto the shoulder. After a few minutes, the vehicle started and we were able to drive it home very slowly on side roads. We took the Bronco Sport to the dealership again and notified them of the multiple trips we had made there to fix this code issue. The dealership did a diagnostic and had a transmission specialist look at the car. The conclusion was that we needed a brand new transmission to the tune of $11K. Additionally, the dealership stated that we likely had rear differential issues as well - the subject of one of the many recalls on this lemon of a vehicle. We have not had the diagnostic performed as we are waiting on Ford to let us know if they will buy back the vehicle. Again, we purchased the car new and it has about 80K miles on it. There is no discernible reason for the transmission to fail on a car this new which has primarily been driven to and from work. A quick Google and social media search shows this is a pervasive problem with the 2021 Bronco Sport - many owners are experiencing electrical, power train and transmission issues. NHTSA needs to investigate this matter before someone is seriously injured or killed because of the failure of Ford in manufacturing the 2021 Bronco Sport.
NHTSA ODI #11655719
Official recalls
16May 27, 2026
Ford Motor Company (Ford) is recalling certain 2021-2026 Bronco Sport and 2022-2026 Maverick vehicles. The front lower control arm ball joints may have been incorrectly installed or incorrectly repaired at the vehicle assembly plant, allowing the control arm to disconnect from the front wheel knuckle.
Consequence & remedy
Consequence: A detached control arm can cause a loss of vehicle control, increasing the risk of a crash.
Remedy: Owners are advised not to drive their vehicles until the remedy is completed. Dealers will inspect and repair the front lower control arm ball joints as necessary, free of charge.Owner notification letters were mailed September 2, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S36. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on May 29, 2026.
Oct 10, 2025
Ford Motor Company (Ford) is recalling certain 2016-2019 Lincoln MKC, 2016-2023 Explorer, 2019-2020 Fusion, 2019-2024 Ranger, 2020-2022 Lincoln Corsair, Escape, 2021-2024 Bronco, Bronco Sport, and 2022-2024 Maverick vehicles. The engine block heater may crack and develop a coolant leak, causing it to short circuit when the block heater is plugged in.
Consequence & remedy
Consequence: An electrical short circuit can increase the risk of a fire.
Remedy: Owners are advised not to plug in their block heater until the vehicle is remedied. Dealers will replace the block heater, free of charge. Owners will also have a alternative option to replace engine block heater element with a threaded blanking plug, and remove the block heater electrical cord. Interim letters, notifying owners of the safety risk, were mailed December 3, 2025. Additional letters will be sent once the final remedy is available, anticipated September 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SA4. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on October 15, 2025.
Jul 11, 2025
Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco Sport and 2020-2022 Escape vehicles equipped with 1.5L engines. A fuel injector may crack and leak fuel inside the engine compartment.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source, such as hot engine or exhaust components, can increase the risk of a fire.
Remedy: Dealers will update the engine control software. In addition, dealers will replace the high-pressure fuel rail assembly and fuel injectors, free of charge. As an interim repair, dealers will update the engine control software, free of charge. Interim owner notification letters notifying owners of the safety risk were mailed August 29, 2025. Second letters will be sent once the final remedy is available, anticipated in July 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S76. This recall expands and replaces previous recall numbers 22V-859, 24V187, and 25V165. Vehicles previously remedied under 22V-859, 24V187, and 25V165 will need to have the new final remedy performed once it is available.
Jun 27, 2025
Ford Motor Company (Ford) is recalling certain 2018-2022 Transit Connect, 2019-2020 MKZ, MKX, Edge, Continental, F-150, Nautilus, Fusion, 2019-2023 Ranger, Mustang, 2020-2021 EcoSport, Expedition, Navigator, 2020-2022 Escape, F-250 SD, Corsair, 2020-2023 Aviator, Transit, 2020-2024 Explorer, 2021-2024 Bronco Sport, and 2022-2024 Maverick vehicles. A software error may cause the rearview camera to display a blank image, or the image may remain on the display after the backing event has ended.
Consequence & remedy
Consequence: A rearview camera that displays a blank image can reduce the driver's view behind the vehicle. A rearview image that continues to be displayed after the vehicle is shifted out of reverse may distract the driver. Both of these situations can increase the risk of a crash.
Remedy: Dealers will update the rearview camera software, free of charge. Owner notification letters were mailed September 4, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S72.
Mar 14, 2025
Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco Sport and 2022-2023 Maverick vehicles previously repaired incorrectly under recall number 24V-267. The body and power train control modules may fail to detect a change in the 12-volt battery state of charge.
Consequence & remedy
Consequence: An undetected low battery charge can result in a loss of electrical accessories such as hazard lights, or cause a loss of drive power, increasing the risk of a crash.
Remedy: Dealers will recalibrate the body control module and power train control module, free of charge. Owner notification letters were mailed April 23, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S26.
Additional source detail variants (2)
Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco Sport and 2022-2023 Maverick vehicles previously repaired incorrectly under recall number 24V-267. The body and power train control modules may fail to detect a change in the 12-volt battery state of charge.
Consequence: An undetected low battery charge can result in a loss of electrical accessories such as hazard lights, or cause a loss of drive power, increasing the risk of a crash.
Remedy: Dealers will recalibrate the body control module and power train control module, free of charge. Owner notification letters were mailed April 23, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S26.
Electrical System:body Control Module/bcm
Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco Sport and 2022-2023 Maverick vehicles previously repaired incorrectly under recall number 24V-267. The body and power train control modules may fail to detect a change in the 12-volt battery state of charge.
Consequence: An undetected low battery charge can result in a loss of electrical accessories such as hazard lights, or cause a loss of drive power, increasing the risk of a crash.
Remedy: Dealers will recalibrate the body control module and power train control module, free of charge. Owner notification letters were mailed April 23, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S26.
Mar 14, 2025
Ford Motor Company (Ford) is recalling certain 2020-2022 Escape and 2021-2023 Bronco Sport vehicles previously repaired incorrectly under recall numbers 22V-859 or 24V-187. A fuel injector may crack and leak fuel inside the engine compartment.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source such as hot engine or exhaust components, can increase the risk of a fire.
Remedy: Dealers will update the powertrain control module (PCM) software, free of charge. Owner notification letters were mailed April 22, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S21.
Jan 17, 2025
Ford Motor Company (Ford) is recalling certain 2021-2023 Bronco Sport and 2022-2023 Maverick vehicles. The 12-volt battery may experience degradation and suddenly fail.
Consequence & remedy
Consequence: Battery failure can result in a loss of electrical accessories, including the hazard lights, or cause a loss of drive power, increasing the risk of a crash.
Remedy: Dealers will inspect and if necessary, replace the 12-volt battery, free of charge. Owner notification letters were mailed May 2, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S02. Vehicles in this recall were previously repaired under 24V-267 and will need to have the new remedy completed.
Apr 12, 2024
Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco Sport and 2022-2023 Maverick vehicles. The body and power train control modules may fail to detect a change in the 12-volt battery state of charge.
Consequence & remedy
Consequence: An undetected low battery charge can result in a loss of electrical accessories such as hazard lights, or cause a loss of drive power, increasing the risk of a crash.
Remedy: Dealers will recalibrate the body control module and power train control module, free of charge. Owner notification letters were mailed on June 4, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S24.
Additional source detail variants (2)
Electrical System:body Control Module/bcm
Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco Sport and 2022-2023 Maverick vehicles. The body and power train control modules may fail to detect a change in the 12-volt battery state of charge.
Consequence: An undetected low battery charge can result in a loss of electrical accessories such as hazard lights, or cause a loss of drive power, increasing the risk of a crash.
Remedy: Dealers will recalibrate the body control module and power train control module, free of charge. Owner notification letters were mailed on June 4, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S24.
Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco Sport and 2022-2023 Maverick vehicles. The body and power train control modules may fail to detect a change in the 12-volt battery state of charge.
Consequence: An undetected low battery charge can result in a loss of electrical accessories such as hazard lights, or cause a loss of drive power, increasing the risk of a crash.
Remedy: Dealers will recalibrate the body control module and power train control module, free of charge. Owner notification letters were mailed on June 4, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S24.
Nov 18, 2022
Ford Motor Company (Ford) is recalling certain 2020-2023 Escape and 2021-2023 Bronco Sport vehicles equipped with 1.5L engines. A fuel injector may crack and leak fuel inside the engine compartment.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source such as hot engine or exhaust components, can increase the risk of a fire.
Remedy: Dealers will update the engine control software to include fuel injector leak detection and install a drain tube, free of charge. Interim owner notification letters informing owners of the safety risk were mailed January 9, 2023. Remedy parts are expected to be available in 1st Quarter of 2023. Owner notification letters were mailed February 28, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S73. This recall includes all vehicles previously recalled under 22V-191. Vehicles previously remedied under 22V-191 will need to have the new remedy performed.
Mar 25, 2022
Ford Motor Company (Ford) is recalling certain 2020-2022 Escape and 2021-2022 Bronco Sport vehicles equipped with 1.5L engines. The engine oil separator housing may crack and develop an oil leak.
Consequence & remedy
Consequence: An oil leak in the presence of an ignition source such as hot engine or exhaust components, can increase the risk of a fire.
Remedy: Dealers will inspect the oil separator for damage or oil leaks, and replace the oil separator and seals, as necessary, free of charge. Owner notification letters were mailed April 18, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S21.
Nov 23, 2021
Ford Motor Company (Ford) is recalling certain 2021-2022 Bronco Sport and Escape vehicles. The rear brake linings may have been manufactured incorrectly, which can affect braking performance. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 135, "Light Vehicle Brake Systems."
Consequence & remedy
Consequence: During certain situations, the driver may have to apply more brake pedal force, and the distance required to stop the vehicle may be extended, increasing the risk of a crash.
Remedy: Dealers will replace the front brake pads, free of charge. Owner notification letters were mailed August 17, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21C31.
Oct 15, 2021
Ford Motor Company (Ford) is recalling certain 2021 Bronco Sport vehicles. The moonroof glass may not have been bonded correctly to the moonroof frame, which could result in the glass panel detaching from the vehicle.
Consequence & remedy
Consequence: A detached glass panel can become a road hazard, and increase the risk of a crash or injury.
Remedy: Dealers will inspect the moonroof glass date code and replace the glass, if necessary, free of charge. Owner notification letters were mailed November 18, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S46.
Aug 10, 2021
Ford Motor Company (Ford) is recalling certain 2021 Escape, Lincoln Corsair, and 2021-2022 Bronco Sport vehicles. The fuel delivery module may leak inside the fuel tank, causing low fuel pressure which could result in an engine stall.
Consequence & remedy
Consequence: An engine stall increases the risk of a crash.
Remedy: Dealers will replace the fuel delivery module, free of charge. Interim notification letters (remedy not available) were mailed on September 30, 2021. Owner notification letters were mailed on December 14, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S38.
Feb 16, 2021
Ford Motor Company (Ford) is recalling certain 2021 Bronco Sport vehicles. These vehicles may have been produced with incorrect front lower control arms.
Consequence & remedy
Consequence: An incorrect lower control arm may affect vehicle handling and control, increasing the risk of a rollover crash.
Remedy: Ford will notify owners, and dealers will inspect and replace the front lower control arms, if necessary, free of charge. The recall began April 9, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S03.
Feb 16, 2021
Ford Motor Company (Ford) is recalling certain 2021 Bronco Sport vehicles. The rear suspension subframe assembly may have loose or missing bolts.
Consequence & remedy
Consequence: Loose or missing bolts may affect the vehicle's handling and control, increasing the risk of a crash. It could also reduce the vehicle's performance in a rear impact crash, increasing the risk of injury.
Remedy: Ford will notify owners, and dealers will inspect the rear suspension bolts, and secure or replace the bolts, as necessary, free of charge. The recall began March 10, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S04.
Jan 15, 2021
Ford Motor Company (Ford) is recalling certain 2020-2021 Edge, 2020 Lincoln Nautilus and Ford Escape and 2021 Lincoln Corsair and Ford Bronco Sport vehicles. An inadequate amount of lubricant in the rear drive unit may cause seizure of the rear drive axle.
Consequence & remedy
Consequence: If the rear drive unit seizes, there may be a loss of drive and/or a loss of vehicle control, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will check the rear drive unit lubricant level. Axles found to have lubricant at the minimum level will be filled to the full level. Axles found to be below the minimum lubricant fill level will be replaced, free of charge. This recall began March 12, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S02.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2RQ24014 · Loss Of Motive Power
Opened Nov 15, 2024 · Closed Oct 10, 2025
Status: closed (inferred from source dates) · Electrical SYSTEM:12V/24V/48V Battery
On January 31, 2024, The Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE24002) to investigate loss of motive power allegations in model year (MY) 2021 Ford Bronco Sport vehicles. Consumers reported a loss of engine power accompanied by complete electrical system failure either while driving or after stopping at a traffic light or stop sign. The vehicles generally could not be restarted, and the incidents were commonly diagnosed by dealerships to a failed 12-Volt (12V) battery. On April 12, 2024, Ford issued safety recall 24V-267 covering 456,565 MY 2021-2024 Ford Bronco Sport and MY 2022-2023 Ford Maverick vehicles. The recall addressed loss of motive power resulting from sudden degradation of the 12V battery during the drive cycle. The recall remedy consisted of software updates to the body control module and the powertrain control module. The updated software aimed to provide warning to consumers when the battery is failing and inhibit certain vehicle functions which can lead to loss of motive power incidents. Additionally, Ford removed the existing 12V Enhanced Flooded Battery (EFB) as both a service component for the subject vehicles and original equipment for newly built Bronco Sport vehicles (during MY 2024 production), replacing it with a more robust absorbed glass mat (AGM) battery. The same AGM battery had been incorporated into Ford Maverick production in late 2022. Following recall 24V-267, ODI received loss of motive power complaints in vehicles that had previously received Ford’s software-based remedy. Consumers reported that they did not receive warnings related to the 12V battery or the vehicle’s electrical system before the loss of power. On November 15, 2024, ODI opened Recall Query (RQ24014) to assess the effectiveness of the 24V-267 recall remedy. On January 19, 2025, Ford issued recall 25V-019 covering 272,817 MY 2021-2023 Bronco Sport and MY 2022-2023 Ford Maverick vehicles. The new recall addressed the same hazard as 24V-267 but required replacement of the existing 12V battery with an AGM battery as the remedy. Ford reported that following the opening of RQ24014, it evaluated several field-returned 12V batteries, and determined that EFBs produced by battery supplier Camel potentially contained internal manufacturing defects causing loss of motive power. Ford further concluded that the software updates provided in the 24V-267 recall remedy were unable to detect battery failures quickly enough to avoid loss of motive power. Vehicles previously within the scope of recall 24V-267, but outside of the scope of recall 25V-019, are equipped with EFBs produced by a different battery supplier (Clarios). When recall 25V-019 was issued, Ford had not identified any Clarios EFBs exhibiting the same failure mode as the Camel EFBs. In light of Ford’s recall action, ODI is closing this Recall Query. The agency will continue to monitor loss of motive power complaints in Bronco Sport vehicles equipped with Clarios EFBs and reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
PE24002 · Loss Of Motive Power
Opened Jan 31, 2024 · Closed Aug 19, 2024
Status: closed (inferred from source dates) · Electrical SYSTEM:12V/24V/48V Battery
On January 31, 2024, the Office of Defects Investigation (ODI) opened PE24002 to investigate allegations of loss of motive power in model year (MY) 2021 Ford Bronco Sport vehicles. At that time, ODI had received 31 Vehicle Owner Questionnaires (VOQs), with consumers commonly reporting a loss of engine power accompanied by complete electrical system failure which occurred either while driving, or after coming to a stop. The investigation revealed that MY 2021-2024 Ford Bronco Sport and certain MY 2022-2023 Ford Maverick vehicles are equipped with a 12V enhanced flooded battery (EFB), which may experience an abrupt failure during a drive cycle. The failure is the result of an internal corrosion issue, which is influenced by long exposure to high under-hood temperatures. If the sudden loss of 12V battery voltage is not detected by the vehicle’s battery management sensor, the vehicle can experience a loss of power event without providing any warning to the driver. Following a loss of power due to battery failure, the vehicle may be without all 12V accessories including hazard lights and typically will not be able to be restarted. In its March 2024 response to ODI’s information request, Ford provided 367 customer complaints (including field reports, lawsuits, and legal claims) and 1005 warranty claims relating to the alleged defect. When combining ODI and manufacturer failure report data, there are 1,368 unique VINs represented across MY 2021-2023 Ford Bronco Sport vehicles. One of the VOQs submitted to NHTSA reported a minor rear-end collision resulting from a loss of power event. Included within Ford’s complaints were a reported single-vehicle collision and a vehicle fire which occurred following a loss of power event at a traffic light (fire cause and origin was not determined). Additionally, across ODI and manufacturer data, there were 12 allegations of either acid leaking from the 12V battery or smoke emitting from the battery area within the engine compartment. On April 12, 2024, Ford submitted recall 24V267 for MY 2021-2024 Ford Bronco Sport and certain MY 2022-2023 Ford Maverick vehicles (total population 456,565). The recall remedy provides updated calibrations to the body control module and powertrain control module. Ford indicated that the update will result in improved detection of 12V battery state of charge during drive cycles and will provide notification to the driver if the battery significantly degrades while driving. Additionally, Ford has replaced the EFB with an absorbed glass mat (AGM) battery as both a service component for the subject vehicles and as original equipment for Bronco Sport vehicles with production dates beginning in mid-March 2024. The warranty claim rate for peer vehicles equipped with an AGM battery is substantially lower than that for the subject vehicle population. In view of the recall action being taken by Ford, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Electrical SYSTEM:12V/24V/48V Battery
On January 31, 2024, the Office of Defects Investigation (ODI) opened PE24002 to investigate allegations of loss of motive power in model year (MY) 2021 Ford Bronco Sport vehicles. At that time, ODI had received 31 Vehicle Owner Questionnaires (VOQs), with consumers commonly reporting a loss of engine power accompanied by complete electrical system failure which occurred either while driving, or after coming to a stop. The investigation revealed that MY 2021-2024 Ford Bronco Sport and certain MY 2022-2023 Ford Maverick vehicles are equipped with a 12V enhanced flooded battery (EFB), which may experience an abrupt failure during a drive cycle. The failure is the result of an internal corrosion issue, which is influenced by long exposure to high under-hood temperatures. If the sudden loss of 12V battery voltage is not detected by the vehicle’s battery management sensor, the vehicle can experience a loss of power event without providing any warning to the driver. Following a loss of power due to battery failure, the vehicle may be without all 12V accessories including hazard lights and typically will not be able to be restarted. In its March 2024 response to ODI’s information request, Ford provided 367 customer complaints (including field reports, lawsuits, and legal claims) and 1005 warranty claims relating to the alleged defect. When combining ODI and manufacturer failure report data, there are 1,368 unique VINs represented across MY 2021-2023 Ford Bronco Sport vehicles. One of the VOQs submitted to NHTSA reported a minor rear-end collision resulting from a loss of power event. Included within Ford’s complaints were a reported single-vehicle collision and a vehicle fire which occurred following a loss of power event at a traffic light (fire cause and origin was not determined). Additionally, across ODI and manufacturer data, there were 12 allegations of either acid leaking from the 12V battery or smoke emitting from the battery area within the engine compartment. On April 12, 2024, Ford submitted recall 24V267 for MY 2021-2024 Ford Bronco Sport and certain MY 2022-2023 Ford Maverick vehicles (total population 456,565). The recall remedy provides updated calibrations to the body control module and powertrain control module. Ford indicated that the update will result in improved detection of 12V battery state of charge during drive cycles and will provide notification to the driver if the battery significantly degrades while driving. Additionally, Ford has replaced the EFB with an absorbed glass mat (AGM) battery as both a service component for the subject vehicles and as original equipment for Bronco Sport vehicles with production dates beginning in mid-March 2024. The warranty claim rate for peer vehicles equipped with an AGM battery is substantially lower than that for the subject vehicle population. In view of the recall action being taken by Ford, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Electrical SYSTEM:12V/24V/48V Battery
On January 31, 2024, the Office of Defects Investigation (ODI) opened PE24002 to investigate allegations of loss of motive power in model year (MY) 2021 Ford Bronco Sport vehicles. At that time, ODI had received 31 Vehicle Owner Questionnaires (VOQs), with consumers commonly reporting a loss of engine power accompanied by complete electrical system failure which occurred either while driving, or after coming to a stop. The investigation revealed that MY 2021-2024 Ford Bronco Sport and certain MY 2022-2023 Ford Maverick vehicles are equipped with a 12V enhanced flooded battery (EFB), which may experience an abrupt failure during a drive cycle. The failure is the result of an internal corrosion issue, which is influenced by long exposure to high under-hood temperatures. If the sudden loss of 12V battery voltage is not detected by the vehicle’s battery management sensor, the vehicle can experience a loss of power event without providing any warning to the driver. Following a loss of power due to battery failure, the vehicle may be without all 12V accessories including hazard lights and typically will not be able to be restarted. In its March 2024 response to ODI’s information request, Ford provided 367 customer complaints (including field reports, lawsuits, and legal claims) and 1005 warranty claims relating to the alleged defect. When combining ODI and manufacturer failure report data, there are 1,368 unique VINs represented across MY 2021-2023 Ford Bronco Sport vehicles. One of the VOQs submitted to NHTSA reported a minor rear-end collision resulting from a loss of power event. Included within Ford’s complaints were a reported single-vehicle collision and a vehicle fire which occurred following a loss of power event at a traffic light (fire cause and origin was not determined). Additionally, across ODI and manufacturer data, there were 12 allegations of either acid leaking from the 12V battery or smoke emitting from the battery area within the engine compartment. On April 12, 2024, Ford submitted recall 24V267 for MY 2021-2024 Ford Bronco Sport and certain MY 2022-2023 Ford Maverick vehicles (total population 456,565). The recall remedy provides updated calibrations to the body control module and powertrain control module. Ford indicated that the update will result in improved detection of 12V battery state of charge during drive cycles and will provide notification to the driver if the battery significantly degrades while driving. Additionally, Ford has replaced the EFB with an absorbed glass mat (AGM) battery as both a service component for the subject vehicles and as original equipment for Bronco Sport vehicles with production dates beginning in mid-March 2024. The warranty claim rate for peer vehicles equipped with an AGM battery is substantially lower than that for the subject vehicle population. In view of the recall action being taken by Ford, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration