IllustrationOWNER STATES THAT VEHICLE CAUGHT ON FIRE AND THAT FIRE DEPARTMENT COULD NOT FIND THE PROBLEM. OWNER FURTHER NOTES THAT DASHBOARD WAS IN FLAMES. *AK
1992 Ford Aerostar
Owner reports · Recalls · Investigations
More warning signs than most Aerostar years
Owner complaints for the 1992 Ford Aerostar are substantially higher than the model-year median of 135.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Aerostar years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 12 of 317 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Power Train. Review the 75 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 64 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 52 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
29 crash reports30 fire reports19 injury reports
What owners actually said
317 reportsHEATER/DEFROSTER INOPERATIVE, CAUSING POOR VISIBILITY.
DOOR ASSEMBLY FAILURE, SLIDING DOOR WILL NOT OPEN FROM INSIDE OR OUTSIDE, IN FOR REPAIR, WILL PROVIDE REPAIR RECEIPT. *AK
OWNER SAID THAT HE FINDS IT VERY HARD TO GET THE CAR INTO PARK, AND ALSO IT IS VERY HARD TO GET THE KEY TO RELEASE FROM THE STEERING COLUMN. *AK
APPLIED BRAKES(ABS) AT 30 -35 MPH VEHICLE STARTED TO SLOW DOWN BUT, DIDN'T STOP DUE TO THIS FAILURE THE VEHICLE REAR ENDED ANOTHER VEHICLE. PLEASE DESCRIBE DETAILS. *AK
WHILE DRIIVNG THE VEHICLE THE AIR BAG WARNING LIGHT CAME ON, CRUISE CONTROL WENT OUT AND THE CLOCK WENT CRAZY, VEHICLE AT DEALERSHIP AT THIS TIME. *AK
OWNER STATES THAT HIS AIRBAG WARNING LIGHT COMES ON WHILE DRIVING AND THAT IT DOES NOT GO OUT, OWNER ALSO NOTES THAT DEALER SAID THAT IT WAS A FAULTY MONITOR WHICH IS CAUSING THE PROBLEM. *AK
DURING A COLD NIGHT WITH A TEMPERATURE OF BELOW 32 DEGREES, REAR ANTI-LOCK BRAKES FREEZE UP AND STAY LOCKED UP THROUGH NEXT MORNING HOURS. HAVE TO WAIT TO THAW. *AK
WHEN TURNING THE IGNITION ON THERE IS A NOISE AND VEHICLE STARTS TO SMOKE; TOOK TO DEALER, CONSUMER DOESN'T WANT TO PAY FOR THEM TO CHECK THE VEHICLE, THINKS FORD SHOULD PAY FOR IT. THERE IS INFORMATION ON THE INTERNET SAID FORD MISSED A LOT OF CARS IN THE IGNITION RECALL . *AK
TRANSMISSION NOT MOVING IN ANY GEARS. *YC
Official recalls
399V094000 · Power Train:transfer Case (4-WHEEL Drive)
Apr 28, 1999
VEHICLE DESCRIPTION: ALL WHEEL DRIVE PASSENGER MINIVANS. (THIS INCLUDES ALL 1992 AWD AEROSTARS NOT PREVIOUSLY INCLUDED IN SAFETY RECALL 97V-204/97S83). THESE VEHICLES CAN DEVELOP POWERTRAIN BENDING RESONANCE OR TRANSFER CASE OUTPUT SHAFT BUSHING DISPLACEMENT. THE POWERTRAIN BENDING RESONANCE OR THE OUTPUT SHAFT BUSHING DISPLACEMENT CAN RESULT IN STRUCTURAL FAILURE OF THE TRANSMISSION AND/OR TRANSFER CASE. FLUID EXPLUSION, DRIVESHAFT SEPARATION OR LOSS OF VEHICLE DRIVE CAN RESULT.
Consequence & remedy
Consequence: THIS CONDITION CAN CAUSE A LOSS OF VEHICLE CONTROL, AND, IF THE EXPELLED FLUID CONTACTS THE EXHAUST SYSTEM, A VEHICLE FIRE COULD OCCUR.
Remedy: DEALERS WILL INSTALL A NEW TRANSFER CASE REAR OUTPUT SHAFT BUSHING AND AN ALUMINUM DRIVESHAFT WILL BE INSTALLED.
99V029000 · Electrical System:ignition:switch
Feb 9, 1999
VEHICLE DESCRIPTION: MINI VANS. THESE VEHICLES WERE PRODUCED WITH A HIGHER THAN SPECIFIED ELECTRICAL LOAD THROUGH THE ACCESSORY POWER FEED CIRCUIT. THE POTENTIAL FOR CONTACT BETWEEN THE B2 (BATTERY), A2 (ACCESSORY), AND P1 (PROOF) CIRCUITS CAN OCCUR, CREATING A SHORT CIRCUIT, ALLOWING CURRENT TO FLOW THROUGH THE GROUND WIRE.
Consequence & remedy
Consequence: THIS CAN CAUSE OVER HEATING AND THE POTENTIAL FOR A VEHICLE FIRE.
Remedy: DEALERS WILL INSTALL A JUMPER HARNESS WITH A RELAY WHICH WILL RE-ROUTE AND ACTIVATE ALL A2 ACCESSORIES THROUGH THE RELAY.
97V204000 · Power Train:transfer Case (4-WHEEL Drive)
Nov 13, 1997
VEHICLE DESCRIPTION: ALL WHEEL DRIVE PASSENGER MINIVANS. THESE VEHICLES CAN DEVELOP POWERTRAIN BENDING RESONANCE OR TRANSFER CASE OUTPUT SHAFT BUSHING DISPLACEMENT. THE POWERTRAIN BENDING RESONANCE OR THE OUTPUT SHAFT BUSHING DISPLACEMENT CAN RESULT IN STRUCTURAL FAILURE OF THE TRANSMISSION AND/OR TRANSFER CASE. FLUID EXPLUSION, DRIVESHAFT SEPARATION OR LOSS OF VEHICLE DRIVE CAN RESULT.
Consequence & remedy
Consequence: THIS CONDITION CAN CAUSE A LOSS OF VEHICLE CONTROL, AND, IF THE EXPELLED FLUID CONTACTS THE EXHAUST SYSTEM, A VEHICLE FIRE COULD OCCUR.
Remedy: DEALERS WILL INSTALL A NEW TRANSFER CASE REAR OUTPUT SHAFT BUSHING AND AN ALUMINUM DRIVESHAFT WILL BE INSTALLED.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5PE02076 · Luggage Compartment Door Drops Abruptly
Opened Oct 10, 2002 · Closed Mar 10, 2003
Status: closed (inferred from source dates) · Structure:body:hatchback/liftgate:support Device/strut
ODI HAS IDENTIFIED 30 INCIDENTS RESULTING IN MINOR TO MODERATE PERSONAL INJURIES THAT HAVE BEEN CAUSED BY ABRUPT DOOR DROPS OVER THE APPROXIMATELY EIGHT - TWELVE YEAR PERIOD OF PRODUCT USAGE AND EXPOSURE (1991-1995 TO 2003).MOST OF THE INJURY INCIDENTS APPEAR TO HAVE BEEN CAUSED BY A FRACTURE OF THE GAS FILLED LIFT ASSIST CYLINDER MOUNTING STUD.STUD FRACTURES HAVE OCCURRED RANDOMLY OVER TIME AND DO NOT EXHIBIT ANY APPARENT TREND RELATING TO DATE OF VEHICLE PRODUCTION OR TIME-IN-SERVICE (EXPOSURE).THE ODI CLOSING REPORT SUMMARIZES THE DETAILS OF THIS INVESTIGATION.
PE99035 · Front Brake Hose
Opened May 12, 1999 · Closed Sep 23, 1999
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
ALLEGED THAT A FRONT BRAKE HOSE RUPTURES OR FAILS AT THE INTERFACE BETWEEN THE RUBBER HOSE AND THE BRASS FITTING
EA99002 · Transfer Cases And Rear Drive Shaft
Opened Jan 7, 1999 · Closed Nov 14, 2000
Status: closed (inferred from source dates) · Power Train
There is no summary currently available
RQ98012 · Transfer Cases And Rear Driveshaft
Opened Jul 31, 1998 · Closed Jan 7, 1999
Status: closed (inferred from source dates) · Power Train:transfer Case (4-WHEEL Drive)
There is no summary currently available
RQ97015 · Parking Pawl
Opened Oct 29, 1997 · Closed Apr 1, 1999
Status: closed (inferred from source dates) · Power Train:automatic Transmission
WHEN THE AUTOMATIC SHIFT LEVER IS PLACED IN THE PARK POSITION, THE PARKING PAWL DOES NOT ALWAYS ENGAGE THE PARK GEAR.THIS CAN LEAD TO THE VEHICLE JUMPING OUT OF GEAR UNINTENTIONALLY AND CAUSE THE VEHICLE TO START ROLLING INADVERTENTLY