IllustrationWHEN DRIVING AT 40 MPH AND COMING TO A STOP SIGN, CONSUMER APPLIED THE BRAKES, AND THE BRAKE'S WERE HARD. ABS SYSTEM KICKED IN AND LOCKED UP CAUSING VEHICLE TO GO STRAIGHT THROUGH A STOP SIGN WHICH COULD HAVE RESULTED IN A COLLISION. *AK *YC
1992 Ford Aerostar
Owner reports · Recalls · Investigations
More warning signs than most Aerostar years
Owner complaints for the 1992 Ford Aerostar are substantially higher than the model-year median of 135.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Aerostar years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 12 of 317 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Power Train. Review the 75 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 64 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 52 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
29 crash reports30 fire reports19 injury reports
Service Brakes, Hydraulic complaints
52 reportsBRAKES SMELL LIKE SMOKE, AND THEY CHATTER AND LOSE POWER. *AK
RUBBER PORTION OF THE BRAKE HOSE SEPARATED FROM METAL FITTING THAT CONNECTS TO THE BRAKE LINE, CAUSING A LOSS OF BRAKING POWER, RESULTING IN A COLLISION. *AK
ABS SYSTEM GRABS ON DAMP/WET DAYS CAUSING WHEELS TO SLIDE AT LOW/MED SPEEDS RESULTING IN VEHICLE SLIDING INTO DITCH ON A SNOWY DAY. NLM
IN THE LAST YEAR BOTH OF THE FRONT BRAKE LINES HAVE RUPTURED, LEAVING US WITH NO BRAKES. THE RUPTURES OCCURRED AT LOW SPEEDS AR WHEN PUTTING THE VAN INTO DRIVE. ONLY THIS PREVENTED US FROM THE POTENTIAL OF SERIOUS INJURY. FORD TELLS ME THAT THERE HAS BEEN ON RECALL ON THIS AND I AM LEFT WONDERING IF THIS WILL CONTINUE TO OCCUR. …
Read full complaint
IN THE LAST YEAR BOTH OF THE FRONT BRAKE LINES HAVE RUPTURED, LEAVING US WITH NO BRAKES. THE RUPTURES OCCURRED AT LOW SPEEDS AR WHEN PUTTING THE VAN INTO DRIVE. ONLY THIS PREVENTED US FROM THE POTENTIAL OF SERIOUS INJURY. FORD TELLS ME THAT THERE HAS BEEN ON RECALL ON THIS AND I AM LEFT WONDERING IF THIS WILL CONTINUE TO OCCUR. MECHANICS THAT FIXD THE CAR BOTH SAID THIS WAS A FORD DEFECT BECAUSE THEY HAVE NEVER SEEN THIS TYPE OF FAILURE BEFORE AND THIS WAS ABNORMAL. MY WIFE WILL NO LONGER DRIVE THE CAR.....WHAT RECOURSE DO WE HAVE AND IS THIS A PROBLEM WITH THESE VEHICLES? *AK
WHEN DRIVING AND TRYING TO USE THE TURNING SIGNAL IT DOESN'T WORK AND THE BACK UP LAMP ISN'T WORKING EITHER. ALSO, HEATER MALFUNCTIONED, AND THE RED BRAKE LIGHT AND THE YELLOW ANTI- BRAKE LIGHT STAYS ON. CONSUMER HAD JUST BROUGHT THE VEHICLE BACK FROM REPAIR SHOP FOR A RECALL SERVICE, AND THE CONSUMER IS HAVING ALL OF TYP…
Read full complaint
WHEN DRIVING AND TRYING TO USE THE TURNING SIGNAL IT DOESN'T WORK AND THE BACK UP LAMP ISN'T WORKING EITHER. ALSO, HEATER MALFUNCTIONED, AND THE RED BRAKE LIGHT AND THE YELLOW ANTI- BRAKE LIGHT STAYS ON. CONSUMER HAD JUST BROUGHT THE VEHICLE BACK FROM REPAIR SHOP FOR A RECALL SERVICE, AND THE CONSUMER IS HAVING ALL OF TYPES OF PROBLEMS WITH VEHICLE. *AK
VEHICLE TRAPS DIRT BETWEEN THE DUST PLATES BEHIND THE DISC BRAKES CAUSING THE BRAKES TO FADE AND MAKE NOISE.
WHEN DRIVING AT ANY SPEED THE BRAKES ARE WORKING INTERMITTENTLY WHICH CAUSE A PROBLEM. VEHICLE HAS BEEN IN REPAIR SHOP FOR DIFFERENT REASONS, AS WELL AS FOR THE BRAKES. DEALER CAN'T DETERMINE THE PROBLEM. *AK
WHILE DRIVING THE VAN ABOUT 35 MPH DRIVER APPLIED THE BRAKES AND THERE WAS 90% BRAKE LOSS. DRIVER WAS ABLE TO AVOID A CRASH. THIS WAS DUE TO CORROSION OF THE BRAKE LINE. THE BRAKE LINE HAS BEEN REPLACED BY THE FORD DEALERSHIP. PLEASE DESCRIBE ANY FURTHER DETAILS.
THERE IS A POPPING NOISE COMING FROM THE BRAKES, CAUSING FLUID TO FLOW OUT FROM THE BRAKES. ALSO, CONSUMER LOST CONTROL OF THE STEERING DUE TO THE STEERING WHEEL LOCKING UP. CONSUMER LEFT VEHICLE AT THE DEALER. *AK
Official recalls
399V094000 · Power Train:transfer Case (4-WHEEL Drive)
Apr 28, 1999
VEHICLE DESCRIPTION: ALL WHEEL DRIVE PASSENGER MINIVANS. (THIS INCLUDES ALL 1992 AWD AEROSTARS NOT PREVIOUSLY INCLUDED IN SAFETY RECALL 97V-204/97S83). THESE VEHICLES CAN DEVELOP POWERTRAIN BENDING RESONANCE OR TRANSFER CASE OUTPUT SHAFT BUSHING DISPLACEMENT. THE POWERTRAIN BENDING RESONANCE OR THE OUTPUT SHAFT BUSHING DISPLACEMENT CAN RESULT IN STRUCTURAL FAILURE OF THE TRANSMISSION AND/OR TRANSFER CASE. FLUID EXPLUSION, DRIVESHAFT SEPARATION OR LOSS OF VEHICLE DRIVE CAN RESULT.
Consequence & remedy
Consequence: THIS CONDITION CAN CAUSE A LOSS OF VEHICLE CONTROL, AND, IF THE EXPELLED FLUID CONTACTS THE EXHAUST SYSTEM, A VEHICLE FIRE COULD OCCUR.
Remedy: DEALERS WILL INSTALL A NEW TRANSFER CASE REAR OUTPUT SHAFT BUSHING AND AN ALUMINUM DRIVESHAFT WILL BE INSTALLED.
99V029000 · Electrical System:ignition:switch
Feb 9, 1999
VEHICLE DESCRIPTION: MINI VANS. THESE VEHICLES WERE PRODUCED WITH A HIGHER THAN SPECIFIED ELECTRICAL LOAD THROUGH THE ACCESSORY POWER FEED CIRCUIT. THE POTENTIAL FOR CONTACT BETWEEN THE B2 (BATTERY), A2 (ACCESSORY), AND P1 (PROOF) CIRCUITS CAN OCCUR, CREATING A SHORT CIRCUIT, ALLOWING CURRENT TO FLOW THROUGH THE GROUND WIRE.
Consequence & remedy
Consequence: THIS CAN CAUSE OVER HEATING AND THE POTENTIAL FOR A VEHICLE FIRE.
Remedy: DEALERS WILL INSTALL A JUMPER HARNESS WITH A RELAY WHICH WILL RE-ROUTE AND ACTIVATE ALL A2 ACCESSORIES THROUGH THE RELAY.
97V204000 · Power Train:transfer Case (4-WHEEL Drive)
Nov 13, 1997
VEHICLE DESCRIPTION: ALL WHEEL DRIVE PASSENGER MINIVANS. THESE VEHICLES CAN DEVELOP POWERTRAIN BENDING RESONANCE OR TRANSFER CASE OUTPUT SHAFT BUSHING DISPLACEMENT. THE POWERTRAIN BENDING RESONANCE OR THE OUTPUT SHAFT BUSHING DISPLACEMENT CAN RESULT IN STRUCTURAL FAILURE OF THE TRANSMISSION AND/OR TRANSFER CASE. FLUID EXPLUSION, DRIVESHAFT SEPARATION OR LOSS OF VEHICLE DRIVE CAN RESULT.
Consequence & remedy
Consequence: THIS CONDITION CAN CAUSE A LOSS OF VEHICLE CONTROL, AND, IF THE EXPELLED FLUID CONTACTS THE EXHAUST SYSTEM, A VEHICLE FIRE COULD OCCUR.
Remedy: DEALERS WILL INSTALL A NEW TRANSFER CASE REAR OUTPUT SHAFT BUSHING AND AN ALUMINUM DRIVESHAFT WILL BE INSTALLED.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5PE02076 · Luggage Compartment Door Drops Abruptly
Opened Oct 10, 2002 · Closed Mar 10, 2003
Status: closed (inferred from source dates) · Structure:body:hatchback/liftgate:support Device/strut
ODI HAS IDENTIFIED 30 INCIDENTS RESULTING IN MINOR TO MODERATE PERSONAL INJURIES THAT HAVE BEEN CAUSED BY ABRUPT DOOR DROPS OVER THE APPROXIMATELY EIGHT - TWELVE YEAR PERIOD OF PRODUCT USAGE AND EXPOSURE (1991-1995 TO 2003).MOST OF THE INJURY INCIDENTS APPEAR TO HAVE BEEN CAUSED BY A FRACTURE OF THE GAS FILLED LIFT ASSIST CYLINDER MOUNTING STUD.STUD FRACTURES HAVE OCCURRED RANDOMLY OVER TIME AND DO NOT EXHIBIT ANY APPARENT TREND RELATING TO DATE OF VEHICLE PRODUCTION OR TIME-IN-SERVICE (EXPOSURE).THE ODI CLOSING REPORT SUMMARIZES THE DETAILS OF THIS INVESTIGATION.
PE99035 · Front Brake Hose
Opened May 12, 1999 · Closed Sep 23, 1999
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
ALLEGED THAT A FRONT BRAKE HOSE RUPTURES OR FAILS AT THE INTERFACE BETWEEN THE RUBBER HOSE AND THE BRASS FITTING
EA99002 · Transfer Cases And Rear Drive Shaft
Opened Jan 7, 1999 · Closed Nov 14, 2000
Status: closed (inferred from source dates) · Power Train
There is no summary currently available
RQ98012 · Transfer Cases And Rear Driveshaft
Opened Jul 31, 1998 · Closed Jan 7, 1999
Status: closed (inferred from source dates) · Power Train:transfer Case (4-WHEEL Drive)
There is no summary currently available
RQ97015 · Parking Pawl
Opened Oct 29, 1997 · Closed Apr 1, 1999
Status: closed (inferred from source dates) · Power Train:automatic Transmission
WHEN THE AUTOMATIC SHIFT LEVER IS PLACED IN THE PARK POSITION, THE PARKING PAWL DOES NOT ALWAYS ENGAGE THE PARK GEAR.THIS CAN LEAD TO THE VEHICLE JUMPING OUT OF GEAR UNINTENTIONALLY AND CAUSE THE VEHICLE TO START ROLLING INADVERTENTLY