IllustrationSEAT BELT CONECTOR ON DRIVERS SIDE . PUTTON RELEASE IS FROZEN . WILL NOT LOCK BELT ON .*AK
1988 Ford Aerostar
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 1988 Ford Aerostar do not stand out strongly from the model-year median of 135.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Aerostar years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 8 of 177 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Fuel System, Gasoline. Review the 52 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 46 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Seat Belts. Review the 28 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
7 crash reports41 fire reports5 injury reports
Seat Belts complaints
28 reportsFRONT DRIVER AND PASSENGER SIDE SEAT BELTS FAILED. NLM
THIS VEHICLE IS NOT EQUIPPED WITH SHOULDER BELTS IN THE REAR SEATS. I HAVE A THREE-YEAR-OLD SON THAT IS QUICKLY OUTGROWING HIS SAFETY SEAT. (A CENTURY MODEL THAT FITS IN THE MIDDLE OF THE 2ND SEAT POSITION AND IS RESTRAINED BY A LAP BELT). I HAVE PURCHASED A HIGH BACK BOOSTER SEAT (AGAIN A CENTURY) THAT LIKE ALL OF THE HIGH BACK…
Read full complaint
THIS VEHICLE IS NOT EQUIPPED WITH SHOULDER BELTS IN THE REAR SEATS. I HAVE A THREE-YEAR-OLD SON THAT IS QUICKLY OUTGROWING HIS SAFETY SEAT. (A CENTURY MODEL THAT FITS IN THE MIDDLE OF THE 2ND SEAT POSITION AND IS RESTRAINED BY A LAP BELT). I HAVE PURCHASED A HIGH BACK BOOSTER SEAT (AGAIN A CENTURY) THAT LIKE ALL OF THE HIGH BACKED BOOSTER SEATS I HAVE SEEN, REQUIRE THE USE OF A LAP AND SHOULDER BELT. I HAVE TRIED TO OBTAIN INFORMATION ABOUT INSTALLING AFTERMARKET SHOULDER STRAPS FROM FORD MOTOR COMPANY. FIRST I CALLED THE SERVICE DEPARTMENT OF MY LOCAL DEALER (BIG VALLEY FORD, STOCKTON CA). THE PERSON I SPOKE TO IN THE PARTS DEPARTMENT WAS CLUELESS CONCERNING THIS ISSUE AND PROVIDED NO SUGGESTIONS. NEXT I CONTACTED FORD MOTOR COMPANY THROUGH ITS OWNER CONNECTION @ HTTP://WWW.OWNERCONNECTION.COM/FORMSLOGIN.ASP?/HOME/HOME.ASP?. I WAS TOLD THAT I NEEDED TO SPEAK TO MY LOCAL DEALER. I RESPONDED THAT I HAD TRIED MY LOCAL DEALER AND THAT THEY HAD BEEN OF NO HELP. THEY AGAIN REFERRED ME TO MY LOCAL DEALER. NEXT I VISITED THE LOCAL DEALER. I SPOKE TO A CUSTOMER REP IN THE SERVICE DEPARTMENT. I WAS TOLD THAT "IF IT IS NOT ORIGINAL EQUIPMENT, WE DO NOT TOUCH IT." I HAVE SEARCHED THE WEB FOR HELP BUT CAN NOT FIND ANY. I FOUND A SITE (HTTP://WWW.CHILDSAFETY.ORG/FORD/01.20.98.HTML) THAT LISTS REAR SEAT SHOULDER BELT ACCESSORY KITS BY FORD, BUT THEY DO NOT INCLUDE THE AEROSTAR. CAN YOU HELP ME? IS IT POSSIBLE TO SAFELY INSTALL A SHOULDER STRAP IN THE 2ND SEAT OF THIS VAN? IF SO, WHERE CAN I OBTAIN THE CORRECT BELT AND HARDWARE AND INSTRUCTIONS ON INSTALLATION? I HAVE SEEN SEVERAL UNIVERSAL BELTS ON THE WEB, BUT NONE THAT COME WITH INSTALLATION INSTRUCTIONS. THAT MAKES ME WEARY OF THEIR PRODUCTS. THANK YOU
DRIVER'S SEAT BELT LATCH BROKE AND THE SEATBELT SYSTEM DOES NOT RETRACT WHICH WON'T PROTECT THE OCCUPANT IN EVENT OF A CRASH. PLEASE PROVIDE FURTHER INFORMATION. *AK
DRIVER'S SEAT BELT WILL NOT LATCH, SPRING BROKEN IN FEMALE PART, IF YOU DO MANAGE TO GET IT HOOKED IT WILL RELEASE WITH THE SLIGHTEST TENSION. PRIOR TO THIS SEATBELT ALSO HAD SLACK WOULD HAVE TO ADJUST IT WHILE DRIVING. *MJS
BROKEN SPRING IN SEAT BELT BUCKLE CLASP. *AK
SEAT BELT BUCKLE FAILURE. *AK
FAILURE ON THE DRIVER SIDE SEAT BELT BUCKLE, SEAT BELT WILL NOT STAY ENGAGED IN THE BUCKLE, PE94-025. *AK
THE FRONT PASSENGER SEATBELT WILL NOT RESTRAIN AT ALL. PLEASE DESCRIBE. *AK
SEAT BELT BROKE. *SD
Official recalls
498V190000 · Fuel System, Gasoline:storage:tank Assembly
Aug 11, 1998
VEHICLE DESCRIPTION: MINI VANS ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: ALABAMA, ARIZONA, ARKANSAS, CALIFORNIA (10 SOUTHERN COUNTIES OF LOS ANGELES, ORANGE, SAN BERNADINO, SAN DIEGO, RIVERSIDE, VENTURA, SANTA BARBARA, SAN LUIS OBISPO, IMPERIAL, AND KERN), FLORIDA, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NEVADA (CLARK COUNTY), OKLAHOMA, SOUTH CAROLINA, AND TEXAS, AND IN THE U.S. TERRITORIES COVERED BY THE FEDERAL STATUTES. THE UPPER PORTION OF THE FUEL TANK CAN DEVELOP SMALL CRACKS DUE TO EXTENDED EXPOSURE TO VERY HIGH AMBIENT TEMPERATURES. FUEL VAPOR OR LEAKAGE COULD OCCUR AT THESE CRACKS.
Consequence & remedy
Consequence: IF AN IGNITION SOURCE IS PRESENT, A FIRE COULD RESULT.
Remedy: DEALERS WILL REPLACE THE FUEL TANK, REGARDLESS OF MILEAGE, THROUGH MARCH 31, 2002. THIS COVERAGE WILL ONLY BE FOR STRUCTURAL CRACKS AT THE TOP OF THE TANK AND WILL NOT INCLUDE OTHER DAMAGE CAUSED BY AN ACCIDENT OR ROAD DEBRIS.
96V071000 · Electrical System:ignition
Apr 25, 1996
THE IGNITION SWITCH COULD EXPERIENCE AN INTERNAL SHORT CIRCUIT.
Consequence & remedy
Consequence: THIS CONDITION COULD CAUSE OVERHEATING, SMOKE, AND POSSIBLY FIRE IN THE STEERING COLUMN AREA OF THE VEHICLE.
Remedy: DEALERS WILL REPLACE THE IGNITION SWITCH.
91V136000 · Structure:body:hatchback/liftgate:support Device/strut
Aug 19, 1991
SOME LIFTGATE GAS CYLINDER-TO-BODY ATTACHMENT BALL STUDS MAY FRACTURE IN EITHER THE OPEN OR CLOSED POSITION.
Consequence & remedy
Consequence: IF A BALL STUD FRACTURES, THE LIFTGATE WILL NOT REMAIN INTHE OPEN POSITION. BODILY INJURY COULD RESULT IF THE LIFTGATE DROPS WHILESOMEONE IS UNDER IT.
Remedy: REPLACE THE GAS CYLINDER-TO-BODY ATTACHMENT BALL STUDS.
88V091000 · Electrical System:wiring
Jun 6, 1988
VEHICLES EQUIPPED WITH TRAILER TOW PACKAGE HAVE A TRAILER TAILLIGHT RELAY ASSEMBLY THAT CONTAINS WIRES OF SMALLER GAUGE THAN THE FUSE LINK WHICH PROTECTS THE CIRCUIT.
Consequence & remedy
Consequence: SHOULD A SHORT CIRCUIT OCCUR IN THE WIRING WITHIN THERELAY OR IF WATER INTRUSION OCCURS THE SMALLER GAUGE WIRE IN THE RELAY WILLFUNCTION AS A FUSE LINK AND OVERHEAT. THE POSSIBILITY EXISTS FOR A FIRE IF THEWIRES ARE EXPOSED TO COMBUSTIBLE MATERIALS.
Remedy: INSTALLATION OF A RELAY WITH WIRES OF GAUGE ADEQUATE TO PROTECT THE CIRCUIT.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
12EA96030 · Cracked Fuel Tanks
Opened Dec 20, 1996 · Closed Aug 13, 1998
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
CRACKED FUEL TANKS ARE LEAKING FUEL
PE96050 · Cracked Fuel Tanks
Opened Aug 6, 1996 · Closed Dec 20, 1996
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
CRACKED FUEL TANKS ARE LEAKING FUEL
EA94025 · Seat Belt Buckle Failure
Opened Jul 19, 1994 · Closed Sep 30, 1997
Status: closed (inferred from source dates) · Seat Belts:front:buckle Assembly
There is no summary currently available
PE94021 · Seat Belt Buckle Failure
Opened Mar 4, 1994 · Closed Jul 19, 1994
Status: closed (inferred from source dates) · Seat Belts:front:buckle Assembly
There is no summary currently available
PE91127 · Park Pawl Bending
Opened Sep 16, 1991 · Closed Nov 8, 1991
Status: closed (inferred from source dates) · Power Train:automatic Transmission
There is no summary currently available
Additional source detail variants (2)
Power Train:automatic Transmission
There is no summary currently available
Power Train:automatic Transmission
There is no summary currently available
EA91015 · Liftgate Failure
Opened Feb 1, 1991 · Closed Sep 20, 1991
Status: closed (inferred from source dates) · Structure
There is no summary currently available
PE91005 · Liftgate Failure
Opened Oct 18, 1990 · Closed Feb 1, 1991
Status: closed (inferred from source dates) · Structure
There is no summary currently available
EA90042 · Throttle Sticking
Opened Aug 31, 1990 · Closed Dec 31, 1991
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
EA89021 · Windshield Wiper Motor
Opened Mar 23, 1989 · Closed May 4, 1990
Status: closed (inferred from source dates) · Visibility
===
PE89092 · Power Steering Locking
Opened Feb 23, 1989 · Closed Jul 20, 1989
Status: closed (inferred from source dates) · Steering
SUMMARY:THE COMPLAINTS ALLEGE THAT POWER STEERING WAS STIFF ORSTEERING LOCKED.FORD HAS ISSUED TWO SERVICE BULLETINS:ONE ON LEAKINGSEALS AND ONE ON COMPLAINTS OF STIFF STEERING.===
PE89021 · Seat Belt Cutting
Opened Dec 9, 1988 · Closed Aug 3, 1989
Status: closed (inferred from source dates) · Seat Belts
There is no summary currently available
PE89010 · Windshield Wiper Motor
Opened Nov 1, 1988 · Closed Mar 23, 1989
Status: closed (inferred from source dates) · Visibility
There is no summary currently available