Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 1 of 13 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Visibility. Review the 4 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Exterior Lighting. Review the 3 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 2 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports4 fire reports0 injury reports
What owners actually said
13 reports
105,200 miles · Jun 23, 2011
Exterior LightingFire
TL* THE CONTACT OWNS A 1997 FLEETWOOD DISCOVERY. THE CONTACT STATED THAT THERE WAS A BURNING ODOR COMING FROM THE FRONT END OF THE VEHICLE. HE THEN DISCOVERED THAT THE HEADLIGHT WIRES WERE MELTED. THE CONTACT REPAIRED THE FAILURE AND BOTH THE DEALER AND MANUFACTURER WERE NOTIFIED. THE FAILURE MILEAGE WAS 105,200 AND THE CURRE…
Read full complaint
TL* THE CONTACT OWNS A 1997 FLEETWOOD DISCOVERY. THE CONTACT STATED THAT THERE WAS A BURNING ODOR COMING FROM THE FRONT END OF THE VEHICLE. HE THEN DISCOVERED THAT THE HEADLIGHT WIRES WERE MELTED. THE CONTACT REPAIRED THE FAILURE AND BOTH THE DEALER AND MANUFACTURER WERE NOTIFIED. THE FAILURE MILEAGE WAS 105,200 AND THE CURRENT MILEAGE WAS 105,663.
NHTSA ODI #10408711
Mileage unknown · Apr 15, 2002
Visibility
FRONT WINDSHIELD KEEPS POPPING OUT.*AK *TT
NHTSA ODI #8007672
Mileage unknown · Aug 20, 2001
Tires
DURING A RECENT TRIP THE MOTORHOME EXPERIENCED THREE BLOWOUTS, THE TIRES HAD 33000 MILES ON IT (MICHELIN SIZE 235/80R/22.5 XTRV TIRES).
NHTSA ODI #562599
Mileage unknown · May 28, 2001
Electrical SystemFire
ON THE DATE INDICATED, WHILE THE MOTORHOME WAS PLUGGED INTO 115V 30 AMP A/C POWER, WITH ONE ROOF AIR CONDITIONER OPERATING, AN ELECTRICAL FIRE OCCURRED IN THE JUNCTION BOX. THE FIRE, APPARENTLY CAUSED BY A SHORT CIRCUIT, CONSUMED A CONSIDERABLE AMOUNT OF WIRING INSULATION. FORTUNATELY, THE FIRE DID NOT SPREAD TO OTHER MATERIAL…
Read full complaint
ON THE DATE INDICATED, WHILE THE MOTORHOME WAS PLUGGED INTO 115V 30 AMP A/C POWER, WITH ONE ROOF AIR CONDITIONER OPERATING, AN ELECTRICAL FIRE OCCURRED IN THE JUNCTION BOX. THE FIRE, APPARENTLY CAUSED BY A SHORT CIRCUIT, CONSUMED A CONSIDERABLE AMOUNT OF WIRING INSULATION. FORTUNATELY, THE FIRE DID NOT SPREAD TO OTHER MATERIAL. DAMAGE REQUIRED REPLACEMENT OF THE POWERTEK BREAKER BOX AND REPAIR OF THE WIRING. THIS WAS THE SECOND TIME THAT THIS HAD OCCURRED IN THIS MOTORHOME. A VERY SIMILAR ELECTRICAL SHORT AND FIRE OCCURRED IN JULY 2000. DAMAGE WAS NOT AS EXTENSIVE AND ONLY THE WIRING NEEDED TO BE REPAIRED. THESE INCIDENTS ARE BEING REPORTED TO NHTSA AS A SAFETY HAZARD. OTHER OWNERS OF THE DISCOVERY MOTORHOME HAVE REPORTED SIMILAR INCIDENTS. FLEETWOOD HAS REFUSED TO PROVIDE ME WITH ANY FINANCIAL ASSISTANCE TO CORRECT THE DAMAGE RESULTING FROM THE MOST RECENT INCIDENT. TO THE BEST OF MY KNOWLEDGE, FLEETWOOD HAS NEVER ACKNOWLEDGED THE PROBLEM. NO RECALL HAS EVER BEEN ISSUED. THERE ARE NO SPECIAL PERIODIC MAINTENANCE PROCEDURES IN THE OWNER'S MANUAL NOR HAVE ANY BEEN SENT TO OWNERS. *AK
NHTSA ODI #746007
Mileage unknown · May 8, 2001
Electrical SystemExterior Lighting
WHEN HEADLIGHTS WERE TURNED ON ELECTRICAL WIRING AND HEADLIGHT SWITCH STARTED MELTING, THERE WAS SMOKE UNDER DASH. CONSUMER COULD ONLY DRIVE DURING DAY TIME.*AK *JB
NHTSA ODI #887697
Mileage unknown · May 8, 2001
VisibilityFire
WHILE VEHICLE WAS PARKED IN CONSUMER'S DRIVEWAY IT CAUGHT ON FIRE, AND WAS COMPLETELY DESTROYED. AN ALLSTATE INSURANCE INSPECTOR STATED THAT CIRCUIT BOARD IN FRONT HEATING VENT WAS FAULTY AND FAILED. THIS RESULTED IN FAN COMING ON AND REMAINING ON .*AK *JB
NHTSA ODI #887672
Mileage unknown · May 6, 2001
VisibilityFire
INSURANCE INVESTAGATER SAID FIRE DUE TO FAULTY HEATER CIRCUT BOARD, THIS CAUSED FAN TO COME ON BLOWING FIRE THROUGH MOTORHOME, OTHER OWNERS OF THIS TYPE OF MOTORHOME SHOULD BE INFORMED TO THE POSIBLITY OF FIRES, IF WE WERE IN THE MOTORHOME WE COULD HAVE BEEN SERIOUSLY INJURED OR KILLED. FLEETWOOD SAID NO RESPONSEABILITY WOULD B…
Read full complaint
INSURANCE INVESTAGATER SAID FIRE DUE TO FAULTY HEATER CIRCUT BOARD, THIS CAUSED FAN TO COME ON BLOWING FIRE THROUGH MOTORHOME, OTHER OWNERS OF THIS TYPE OF MOTORHOME SHOULD BE INFORMED TO THE POSIBLITY OF FIRES, IF WE WERE IN THE MOTORHOME WE COULD HAVE BEEN SERIOUSLY INJURED OR KILLED. FLEETWOOD SAID NO RESPONSEABILITY WOULD BE TAKEN ON THEIR PART, FLEETWOOD DID TAKE AN ACCIDENT REPORT.
NHTSA ODI #744999
Mileage unknown · Jul 18, 2000
Fuel System, Gasoline
WHILE OPERATING MOTORHOME AT HIGHWAY SPEED, ITS FUEL LINE RUPTURED, RESULTING IN DIESEL FUEL SEEPAGE THROUGHOUT MOTORHOME.*AK
NHTSA ODI #725632
Mileage unknown · Jul 3, 2000
Equipment
MAGIC CHEF RANGE: TOP FORWARD VALVE STICKS IN ON POSITION AND CAN'T BE TURNED OFF. TURNED ALL THE PROPANE OFF, AND STILL IT WAS ON. CONTACTED DEALER, AND REPLACED THE FORWARD VALVE. HOWEVER, IT HAPPENED AGAIN. SERIAL# TO THE RANGE 10885756SH AND MODEL#85TB3BK. *AK *ML
NHTSA ODI #864685
Mileage unknown · Mar 30, 2000
Equipment
THE LARGE BURNER CONTROL VALVE STARTED TO STICK IN THE ON POSITION DUE TO EXCESSIVE HEAT TO THE POINT THAT IT PARTIALLY MELTED THE PLASTIC KNOB, THIS IS POSSIBLY A DESIGN FLAW AND POTENTIALLY A SAFETY HAZARD. NLM
CERTAIN MOTOR HOMES AND TRAVEL TRAILERS EQUIPPED WITH A TWO-DOOR REFRIGERATOR, MANUFACTURED BY THE DOMETIC CORPORATION, MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.
Consequence & remedy
Consequence: RELEASE OF COOLANT UNDER CERTAIN CONDITIONS COULD IGNITE AND RESULT IN A FIRE.
Remedy: FLEETWOOD WILL BE WORKING WITH DOMETIC IN ORDER TO REPAIR THESE REFRIGERATORS (PLEASE SEE 06E076). DOMETIC WILL REPAIR THESE REFRIGERATORS BY INSTALLING A SECONDARY BURN HOUSING, A THERMAL FUSE, AND A MELT FUSE FREE OF CHARGE. DOMETIC HAS RETAINED STERICYCLE INC. TO MANAGE THIS CAMPAIGN. STERICYCLE WILL ASSIST YOU IN LOCATING DEALERSHIPS OR SERVICE CENTERS AND WILL PROVIDE ASSISTANCE WITH SCHEDULING OF APPOINTMENTS. OWNERS MAY CONTACT DOMETIC/STERICYCLE AT 1-888-446-5157 OR FLEETWOOD AT 1-800-322-8216.
VEHICLE DESCRIPTION: MOTOR HOMES. THE POWER STEERING GEAR BOX HYDRAULIC LINES ARE ROUTED TOO CLOSE TO A SHARP EDGE. THIS CAN CAUSE THE LINES TO RUPTURE AND RESULT IN A HYDRAULIC FLUID LEAK.
Consequence & remedy
Consequence: THIS FLUID LEAKAGE CAN CAUSE LOSS OF THE POWER STEERING ASSIST FEATURE.
Remedy: DEALERS WILL INSPECT, REPLACE OR REPAIR DAMAGED HOSES AS NECESSARY, AND RELOCATE THE AFFECTED HYDRAULIC LINES.
VEHICLE DESCRIPTION: MOTOR HOMES. THE DRIVER'S AND PASSENGER'S SIDE WINDOWS DO NOT MEET THE REQUIREMENTS OF FMVSS NO. 205, "GLAZING MATERIALS," FOR AN ACCEPTABLE LEVEL OF TINT.
Consequence & remedy
Consequence: THIS CONDITION COULD CAUSE THE DRIVER REDUCED VISIBILITY THROUGH THE SIDE WINDOWS WHEN BACKING UP, WHEN USING THE MIRRORS FOR LANE CHANGES, OR WHENEVER LOOKING THROUGH THE WINDOWS, INCREASING THE RISK OF A VEHICLE CRASH.
VEHICLE DESCRIPTION: CLASS A MOTOR HOMES EQUIPPED WITH A VINYL PROTECTIVE FRONT COVER. THIS COVER INCLUDES A MESH WHICH COVERS THE FRONT HEADLIGHT ASSEMBLY. THIS MESH INTERFERES WITH THE PHOTOMETRIC PERFORMANCE OF THE HEADLIGHTS RESULTING IN A NONCOMPLIANCE TO FMVSS NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Consequence & remedy
Consequence: THE INTERFERING MESH CAUSES THE EFFECTIVE BRIGHTNESS OF THE HEADLIGHTS AND TURN SIGNALS TO BE LESS THAN REQUIRED. THE DECREASE IN HEADLIGHT BRIGHTNESS CAN DECREASE THE ABILITY TO VIEW THE ROAD WHILE DRIVING AT NIGHT OR IN OTHER INSTANCES WHERE HEADLIGHTS WOULD BE NEEDED. ALSO, THE DECREASED BRIGHTNESS OF THE TURN SIGNALS WILL AFFECT THE VISIBILITY OF THESE SIGNALS TO FOLLOWING VEHICLES.
Remedy: OWNERS WILL BE PROVIDED WITH INSTRUCTIONS AND REPAIR PARTS NECESSARY TO PERFORM THIS RECALL. IF OWNERS SO DESIRE, THEY CAN HAVE A DEALER PERFORM THIS REMEDY FOR THEM.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
1997 Fleetwood Discovery Problems, Complaints & Recalls | Skip That Year
Illustration