I WAS DRIVING THE MOTORHOME UP THE DRIVEWAY AT MY HOME AND HAD NOTICED VERY WEAK BRAKING ON MY RETURN TRIP FROM REFUELING THE VEHICLE (5 MILES) AS I PULLED INTO THE DRIVEWAY UP A HILL AND TOWARDS MY HOME, I ENGAGED THE BRAKES AS I GOT CLOSER AND THE PEDAL PUSHED RIGHT TO THE FLOOR. I PUMPED IT A FEW TIME, AND DID GET SOME BR…
Read full complaint
I WAS DRIVING THE MOTORHOME UP THE DRIVEWAY AT MY HOME AND HAD NOTICED VERY WEAK BRAKING ON MY RETURN TRIP FROM REFUELING THE VEHICLE (5 MILES) AS I PULLED INTO THE DRIVEWAY UP A HILL AND TOWARDS MY HOME, I ENGAGED THE BRAKES AS I GOT CLOSER AND THE PEDAL PUSHED RIGHT TO THE FLOOR. I PUMPED IT A FEW TIME, AND DID GET SOME BRAKING, WITH CONSIDERABLE IMMEDIATE FADE. I WAS ABLE TO BRING THE VEHICLE TO A STOP BY ACTIVATING THE EMERGENCY BRAKES. EXITING THE VEHICLE, I FOUND A LARGE STREAM OF BRAKE FLUID ON THE DRIVEWAY SURFACE. UPON FURTHER REVIEW, I FOUND A STEEL BRAKE LINE DRIPPING FLUID, AND WHEN THE BRAKE PEDAL IS DEPRESSED THE FLUID SHOOTS OUT, AT A HIGH RATE AND LARGE VOLUME.
CERTAIN MOTOR HOMES AND TRAVEL TRAILERS EQUIPPED WITH A TWO-DOOR REFRIGERATOR, MANUFACTURED BY THE DOMETIC CORPORATION, MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.
Consequence & remedy
Consequence: RELEASE OF COOLANT UNDER CERTAIN CONDITIONS COULD IGNITE AND RESULT IN A FIRE.
Remedy: FLEETWOOD WILL BE WORKING WITH DOMETIC IN ORDER TO REPAIR THESE REFRIGERATORS (PLEASE SEE 06E076). DOMETIC WILL REPAIR THESE REFRIGERATORS BY INSTALLING A SECONDARY BURN HOUSING, A THERMAL FUSE, AND A MELT FUSE FREE OF CHARGE. DOMETIC HAS RETAINED STERICYCLE INC. TO MANAGE THIS CAMPAIGN. STERICYCLE WILL ASSIST YOU IN LOCATING DEALERSHIPS OR SERVICE CENTERS AND WILL PROVIDE ASSISTANCE WITH SCHEDULING OF APPOINTMENTS. OWNERS MAY CONTACT DOMETIC/STERICYCLE AT 1-888-446-5157 OR FLEETWOOD AT 1-800-322-8216.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE07055 · Gasoline Supply Line To Gen'r Seepage
Opened Nov 14, 2007 · Closed Mar 14, 2008
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
ODI'S INVESTIGATION HAS FOUND THAT THE 1/4 INSIDE DIAMETER FUEL HOSE THAT PROVIDES GASOLINE TO THE VEHICLE'S ON-BOARD GENERATOR CAN CRACK AND SEEP FUEL. COMPLAINT SUMMARIES INDICATE THAT OWNERS HAVE TYPICALLY DETECTED A SEEPING FUEL LINE THROUGH (1) THE ODOR OF RAW GASOLINE FUMES AND/OR (2) ERRATIC OR NON-START GENERATOR PERFORMANCE.ODI HAS FOUND THAT THE FUEL IN THE GENERATOR FUEL SUPPLY HOSE IS PULLED INTO THE GENERATOR BY SUCTION SO THE GENERATOR IS LIKELY TO PULL AIR INTO THE FUEL LINE THROUGH MINOR CRACKS IN THE FUEL LINE CAUSING ERRATIC GENERATOR PERFORMANCE WELL BEFORE THE CRACKS WILL INCREASE IN SIZE SUFFICIENTLY TO SEEP SIGNIFICANT AMOUNTS OF GASOLINE.RISK OF FIRE IS NEGLIGIBLE SINCE THE VOLUME OF FUEL SEEPAGE IS SMALL AND THE SEEPAGE IS UNLIKELY TO SPRAY BECAUSE THE FUEL LINE IS NOT PRESSURIZED.ALSO, THE FUEL TANK , GENERATOR, AND FUEL LINES ARE MOUNTED AT THE REAR OF THE VEHICLE DISTANT FROM HOT ENGINE PARTS AND/OR ANY OTHER LIKELY SOURCES OF IGNITION. FLEETWOOD HAS INFORMED ODI THAT THEY INTEND TO PROVIDE ANOTIFICATION TO AFFECTED OWNERS THAT (1) ADVISES THAT THE GENERATOR FUEL LINE SHOULD BE INSPECTED FREQUENTLY AND (2) DESCRIBES THE SYMPTOMS OF A DETERIORATING FUEL LINE SO THAT AFFECTED OWNERS WILL RECOGNIZE THE SYMPTOMS INDICATING A FUEL LINE LEAK OR SEEP HAS, OR IS ABOUT TO OCCUR, SO THE OWNERS MAY APPROPRIATELY DIAGNOSE AND RESPOND BY CORRECTING THE PROBLEM.
Additional source detail variants (2)
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
ODI'S INVESTIGATION HAS FOUND THAT THE 1/4 INSIDE DIAMETER FUEL HOSE THAT PROVIDES GASOLINE TO THE VEHICLE'S ON-BOARD GENERATOR CAN CRACK AND SEEP FUEL. COMPLAINT SUMMARIES INDICATE THAT OWNERS HAVE TYPICALLY DETECTED A SEEPING FUEL LINE THROUGH (1) THE ODOR OF RAW GASOLINE FUMES AND/OR (2) ERRATIC OR NON-START GENERATOR PERFORMANCE.ODI HAS FOUND THAT THE FUEL IN THE GENERATOR FUEL SUPPLY HOSE IS PULLED INTO THE GENERATOR BY SUCTION SO THE GENERATOR IS LIKELY TO PULL AIR INTO THE FUEL LINE THROUGH MINOR CRACKS IN THE FUEL LINE CAUSING ERRATIC GENERATOR PERFORMANCE WELL BEFORE THE CRACKS WILL INCREASE IN SIZE SUFFICIENTLY TO SEEP SIGNIFICANT AMOUNTS OF GASOLINE.RISK OF FIRE IS NEGLIGIBLE SINCE THE VOLUME OF FUEL SEEPAGE IS SMALL AND THE SEEPAGE IS UNLIKELY TO SPRAY BECAUSE THE FUEL LINE IS NOT PRESSURIZED.ALSO, THE FUEL TANK , GENERATOR, AND FUEL LINES ARE MOUNTED AT THE REAR OF THE VEHICLE DISTANT FROM HOT ENGINE PARTS AND/OR ANY OTHER LIKELY SOURCES OF IGNITION. FLEETWOOD HAS INFORMED ODI THAT THEY INTEND TO PROVIDE ANOTIFICATION TO AFFECTED OWNERS THAT (1) ADVISES THAT THE GENERATOR FUEL LINE SHOULD BE INSPECTED FREQUENTLY AND (2) DESCRIBES THE SYMPTOMS OF A DETERIORATING FUEL LINE SO THAT AFFECTED OWNERS WILL RECOGNIZE THE SYMPTOMS INDICATING A FUEL LINE LEAK OR SEEP HAS, OR IS ABOUT TO OCCUR, SO THE OWNERS MAY APPROPRIATELY DIAGNOSE AND RESPOND BY CORRECTING THE PROBLEM.
Fuel System, Gasoline
ODI'S INVESTIGATION HAS FOUND THAT THE 1/4 INSIDE DIAMETER FUEL HOSE THAT PROVIDES GASOLINE TO THE VEHICLE'S ON-BOARD GENERATOR CAN CRACK AND SEEP FUEL. COMPLAINT SUMMARIES INDICATE THAT OWNERS HAVE TYPICALLY DETECTED A SEEPING FUEL LINE THROUGH (1) THE ODOR OF RAW GASOLINE FUMES AND/OR (2) ERRATIC OR NON-START GENERATOR PERFORMANCE.ODI HAS FOUND THAT THE FUEL IN THE GENERATOR FUEL SUPPLY HOSE IS PULLED INTO THE GENERATOR BY SUCTION SO THE GENERATOR IS LIKELY TO PULL AIR INTO THE FUEL LINE THROUGH MINOR CRACKS IN THE FUEL LINE CAUSING ERRATIC GENERATOR PERFORMANCE WELL BEFORE THE CRACKS WILL INCREASE IN SIZE SUFFICIENTLY TO SEEP SIGNIFICANT AMOUNTS OF GASOLINE.RISK OF FIRE IS NEGLIGIBLE SINCE THE VOLUME OF FUEL SEEPAGE IS SMALL AND THE SEEPAGE IS UNLIKELY TO SPRAY BECAUSE THE FUEL LINE IS NOT PRESSURIZED.ALSO, THE FUEL TANK , GENERATOR, AND FUEL LINES ARE MOUNTED AT THE REAR OF THE VEHICLE DISTANT FROM HOT ENGINE PARTS AND/OR ANY OTHER LIKELY SOURCES OF IGNITION. FLEETWOOD HAS INFORMED ODI THAT THEY INTEND TO PROVIDE ANOTIFICATION TO AFFECTED OWNERS THAT (1) ADVISES THAT THE GENERATOR FUEL LINE SHOULD BE INSPECTED FREQUENTLY AND (2) DESCRIBES THE SYMPTOMS OF A DETERIORATING FUEL LINE SO THAT AFFECTED OWNERS WILL RECOGNIZE THE SYMPTOMS INDICATING A FUEL LINE LEAK OR SEEP HAS, OR IS ABOUT TO OCCUR, SO THE OWNERS MAY APPROPRIATELY DIAGNOSE AND RESPOND BY CORRECTING THE PROBLEM.
1999 Fleetwood Bounder Problems, Complaints & Recalls | Skip That Year
Illustration