TL* THE CONTACT OWNS A 2012 FIAT 500. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 18V817000 (POWER TRAIN) HOWEVER, THE PART TO DO THE RECALL REPAIR WAS NOT YET AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER HAD EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE VEHICLE WAS TAKEN TO FIAT OF BURLI…
Read full complaint
TL* THE CONTACT OWNS A 2012 FIAT 500. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 18V817000 (POWER TRAIN) HOWEVER, THE PART TO DO THE RECALL REPAIR WAS NOT YET AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER HAD EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE VEHICLE WAS TAKEN TO FIAT OF BURLINGAME LOCATED AT (2 CALIFORNIA DR SUITE A, BURLINGAME, CA 94010) BUT WAS NOT REPAIRED DUE TO PARTS NOT BEING AVAILABLE. THE MANUFACTURER WAS INFORMED OF THE FAILURE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PART DISTRIBUTION DISCONNECTS. *DT *JB*DT*JB
NHTSA ODI #11309799
Mileage unknown · Feb 12, 2020
Power Train
TL* THE CONTACT OWNS 2012 FIAT 500. THE CONTACT RECEIVED A RECALL NOTIFICATION OF NHTSA CAMPAIGN NUMBER 19V817000 (POWER TRAIN) HOWEVER, THE PARTS FOR THE RECALL REPAIR WAS NOT YET AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER HAD EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE VEHICLE WAS TAKEN TO AUTO NAT…
Read full complaint
TL* THE CONTACT OWNS 2012 FIAT 500. THE CONTACT RECEIVED A RECALL NOTIFICATION OF NHTSA CAMPAIGN NUMBER 19V817000 (POWER TRAIN) HOWEVER, THE PARTS FOR THE RECALL REPAIR WAS NOT YET AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER HAD EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE VEHICLE WAS TAKEN TO AUTO NATION FIAT NORTH DENVER LOCATED AT (749 W 104TH AVE SUITE 100, NORTHGLENN, CO 80234 303-578-6121) WHERE IT WAS CONFIRMED THAT PARTS WERE NOT AVAILABLE FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.
NHTSA ODI #11308798
42,000 miles · Feb 10, 2020
Power Train
TL* THE CONTACT OWNS A 2012 FIAT 500 SPORT HATCHBACK. THE CONTACT STATED WHILE DRIVING AT APPROXIMATELY 65 MPH THE RIDE OF THE VEHICLE WAS NOT SMOOTH. THE CONTACT THAT THE CHECK ENGINE WARNING LIGHT ILLUMINATED AND THERE WAS AN ODOR OF SMOKE IN THE CABIN OF THE VEHICLE. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO FIAT OF BU…
Read full complaint
TL* THE CONTACT OWNS A 2012 FIAT 500 SPORT HATCHBACK. THE CONTACT STATED WHILE DRIVING AT APPROXIMATELY 65 MPH THE RIDE OF THE VEHICLE WAS NOT SMOOTH. THE CONTACT THAT THE CHECK ENGINE WARNING LIGHT ILLUMINATED AND THERE WAS AN ODOR OF SMOKE IN THE CABIN OF THE VEHICLE. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO FIAT OF BURLINGAME LOCATED AT 2 CALIFORNIA DR SUITE A BURLINGAME, CA 94010, WHERE THE TECHNICIAN REPLACED THE PCV VALVE SEAL AND ALSO REPAIRED THE CABLE SHIFTER IN THE VEHICLE. THE CONTACT STATED THAT THE FAILURE RECURRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 42,000.
NHTSA ODI #11308291
Mileage unknown · Feb 6, 2020
Power Train
TL* THE CONTACT OWNS A 2012 FIAT 500. THE CONTACT RECEIVED A NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 19V817000 (POWER TRAIN) HOWEVER, THE PART TO DO THE RECALL REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE CONTACT CONTACTED PUTNAM CHRYSLER JEEP DOD…
Read full complaint
TL* THE CONTACT OWNS A 2012 FIAT 500. THE CONTACT RECEIVED A NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 19V817000 (POWER TRAIN) HOWEVER, THE PART TO DO THE RECALL REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE CONTACT CONTACTED PUTNAM CHRYSLER JEEP DODGE 3 CALIFORNIA DR, BURLINGAME, CA 94010 WHERE THEY INFORMED THE CONTACT THAT THE PARTS WAS NOT AVAILABLE. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE AND PROVIDED A CASE NUMBER TO THE CONTACT. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.
NHTSA ODI #11307487
Mileage unknown · Jan 13, 2020
Power Train
TL* THE CONTACT OWNS A 2012 FIAT 500. THE CONTACT STATED THAT AFTER CONTACTING THE LOCAL DEALER STEVEN WADE FIAT (1724 S. HILTON DR. ST. UTAH), THE CONTACT WAS INFORMED THAT THE PARTS NEEDED TO REPAIR THE VEHICLE FOR NHTSA CAMPAIGN NUMBER 16V302000 (POWER TRAIN) WERE NOT AVAILABLE. THE MANUFACTURER WAS NOT NOTIFIED OF THE ISSUE.…
Read full complaint
TL* THE CONTACT OWNS A 2012 FIAT 500. THE CONTACT STATED THAT AFTER CONTACTING THE LOCAL DEALER STEVEN WADE FIAT (1724 S. HILTON DR. ST. UTAH), THE CONTACT WAS INFORMED THAT THE PARTS NEEDED TO REPAIR THE VEHICLE FOR NHTSA CAMPAIGN NUMBER 16V302000 (POWER TRAIN) WERE NOT AVAILABLE. THE MANUFACTURER WAS NOT NOTIFIED OF THE ISSUE. THE FAILURE WAS NOT PRESENT ON THE VEHICLE. PARTS DISTRIBUTION DISCONNECT.
NHTSA ODI #11298983
Mileage unknown · Jan 7, 2020
Power Train
TL* THE CONTACT OWNS A 2012 FIAT 500. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 19V817000 (POWER TRAIN) HOWEVER, THE PART FOR THE RECALL REPAIR WAS UNAVAILABLE. THE CONTACT STATED THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. FIAT OF BURLINGAME LOCATED AT 2 CALIFORNIA DR, DIRECTIO…
Read full complaint
TL* THE CONTACT OWNS A 2012 FIAT 500. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 19V817000 (POWER TRAIN) HOWEVER, THE PART FOR THE RECALL REPAIR WAS UNAVAILABLE. THE CONTACT STATED THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. FIAT OF BURLINGAME LOCATED AT 2 CALIFORNIA DR, DIRECTION BURLINGAME, CA 94010; PHONE NUMBER 650-753-1537, WAS CONTACTED BUT WERE UNABLE TO PROVIDE AN ESTIMATED DATE FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. VIN TOOL CONFIRMS PART NOT YET AVAILABLE.
NHTSA ODI #11297740
82,800 miles · Oct 29, 2019
Power Train
BOUGHT THIS VEHICLE ON OCT 19TH 2019 WHILE DRIVING THE TRANSMISSION SKIPPED SEVERAL TIMES THIS IS A 2012 500 POP MODEL FIAT AUTOMATIC. .AFRAID TO DRIVE FAST FEAR OF TRANSMISSION FAILURE ,SPECIALLY NOTICABLE WHEN GOING UP A GRADE AND WHEN DEPRESSING FUEL PEDAL TO PASS .
NHTSA ODI #11276879
Mileage unknown · Sep 30, 2019
Electronic Stability Control (esc)EnginePower Train
OIL PRESURE LIGHT COMES ON SAYING STOP TURN ENGINE OFF LOW IOL PRESSURE AFTER I DRIVE IT FOR ABOUT 10 MINS I GUESS AFTER IT GET HOT. THEN CHEXK ENGINE LIGGT COMES WITH IT. OTHER PEOPLE HAS AND ARE GOING THREW THE SAME THING WITH 2012 FIAT 509 SPORTS. ITS ALL OVER THE YOU TUBE WHY IS THIS HAPPING. I REPLACE OIL PRESURE SENSOR AND…
Read full complaint
OIL PRESURE LIGHT COMES ON SAYING STOP TURN ENGINE OFF LOW IOL PRESSURE AFTER I DRIVE IT FOR ABOUT 10 MINS I GUESS AFTER IT GET HOT. THEN CHEXK ENGINE LIGGT COMES WITH IT. OTHER PEOPLE HAS AND ARE GOING THREW THE SAME THING WITH 2012 FIAT 509 SPORTS. ITS ALL OVER THE YOU TUBE WHY IS THIS HAPPING. I REPLACE OIL PRESURE SENSOR AND CHANGED MY OIL SAME THING IT DIDNT CHANGE ANYTHING ASKING FOR A RECALL ON THE OIL PUM OR WHAT IS CAUSING THIS. PLUS IT MAKEA A SOUND AFTER DRIVING AT THE SAME TIME IT SHOWS UP WHILE PUSHING GAS PEDAL
NHTSA ODI #11265211
30,000 miles · Sep 23, 2019
Power Train
2012 FIAT POP WITH 5 SPEED MANUAL TRANSMISSION. MANUAL TRANSMISSION MAY LEAK OIL FROM CASE SEAM AND AT HALF SHAFT SEALS. FIAT DEALERSHIP REPLACED FIRST TRANSMISSION AFTER 600 MILES. LEAKING AGAIN AT 30,000 MILES. OIL IS SLUNG FROM INNER CV JOINT BOOTS INTO ENGINE COMPARTMENT AND ONTO GROUND. THIS COULD CREATE HAZARDS OF FIRE FRO…
Read full complaint
2012 FIAT POP WITH 5 SPEED MANUAL TRANSMISSION. MANUAL TRANSMISSION MAY LEAK OIL FROM CASE SEAM AND AT HALF SHAFT SEALS. FIAT DEALERSHIP REPLACED FIRST TRANSMISSION AFTER 600 MILES. LEAKING AGAIN AT 30,000 MILES. OIL IS SLUNG FROM INNER CV JOINT BOOTS INTO ENGINE COMPARTMENT AND ONTO GROUND. THIS COULD CREATE HAZARDS OF FIRE FROM HOT EXHAUST, LOSS OF TRACTION FROM OIL ON ROAD SURFACE. FIAT REFUSES TO DEAL WITH PROBLEM AFTER SECOND ROUND AND DEALERSHIP FUMBLING REPAIR. STILL HAVE LEAKS, COMPROMISED TRANSMISSION ...UNSAFE CAR.
NHTSA ODI #11257560
54,000 miles · Jul 17, 2019
Power Train
TL* THE CONTACT OWNS A 2012 FIAT 500. THE CONTACT STATED THAT THE GEAR SHIFTER FAILED TO OPERATE. WHEN THE CONTACT SHIFTED THE GEAR INTO REVERSE TO ENTER A PARKING SPACE AND THEN ATTEMPTED TO SHIFT INTO PARK, THE GEAR SHIFTER ENGAGED INTO NEUTRAL INSTEAD. THE CONTACT WAS UNABLE TO RELEASE THE GEAR OUT OF NEUTRAL. THE CONTACT APP…
Read full complaint
TL* THE CONTACT OWNS A 2012 FIAT 500. THE CONTACT STATED THAT THE GEAR SHIFTER FAILED TO OPERATE. WHEN THE CONTACT SHIFTED THE GEAR INTO REVERSE TO ENTER A PARKING SPACE AND THEN ATTEMPTED TO SHIFT INTO PARK, THE GEAR SHIFTER ENGAGED INTO NEUTRAL INSTEAD. THE CONTACT WAS UNABLE TO RELEASE THE GEAR OUT OF NEUTRAL. THE CONTACT APPLIED THE EMERGENCY BRAKE TO SECURE THE VEHICLE IN THE PARKING SPACE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS CONTACTED AND STATED THAT THE VIN WAS NOT INCLUDED IN MANUFACTURER RECALL NUMBER: R20. THE VEHICLE WAS NOT REPAIRED. THE DEALER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 54,000.
Chrysler (FCA US LLC) is recalling certain 2012-2013 Fiat 500 vehicles equipped with 6-speed automatic transmissions. The shifter cable bushing may fail allowing the cable to detach from the transmission.
Consequence & remedy
Consequence: If the shifter cable detaches from the transmission, the transmission may not shift into the gear selected by the driver. Additionally, despite selecting PARK with the shifter, the vehicle may roll away. These scenarios may increase the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the shifter cable adjuster, free of charge. The recall began January 9, 2020. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is VB4.
Additional source detail variants (2)
Power Train:automatic Transmission:lever And Linkage:floor Shift
Chrysler (FCA US LLC) is recalling certain 2012-2013 Fiat 500 vehicles equipped with 6-speed automatic transmissions. The shifter cable bushing may fail allowing the cable to detach from the transmission.
Consequence: If the shifter cable detaches from the transmission, the transmission may not shift into the gear selected by the driver. Additionally, despite selecting PARK with the shifter, the vehicle may roll away. These scenarios may increase the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the shifter cable adjuster, free of charge. The recall began January 9, 2020. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is VB4.
Power Train:automatic Transmission
Chrysler (FCA US LLC) is recalling certain 2012-2013 Fiat 500 vehicles equipped with 6-speed automatic transmissions. The shifter cable bushing may fail allowing the cable to detach from the transmission.
Consequence: If the shifter cable detaches from the transmission, the transmission may not shift into the gear selected by the driver. Additionally, despite selecting PARK with the shifter, the vehicle may roll away. These scenarios may increase the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the shifter cable adjuster, free of charge. The recall began January 9, 2020. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is VB4.
Chrysler (FCA US LLC) is recalling certain model year 2012-2016 Fiat 500 vehicles manufactured June 21, 2010, through January 12, 2016, equipped with a manual transmission. The clutch diaphragm spring may fracture and fail, causing an inability to switch gears.
Consequence & remedy
Consequence: If the clutch diaphragm spring fails, the driver may not be able to shift gears or the vehicle may lose motive power, increasing the risk of a crash.
Remedy: The remedy for this recall will include the installation of a clutch pedal limiter and a clutch pedal switch. The recall began on November 10, 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S34.
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2012 DODGE JOURNEY AND FIAT 500 VEHICLES MANUFACTURED FROM OCTOBER 24, 2011, THROUGH OCTOBER 26, 2011. SOME VEHICLES WERE ASSEMBLED WITH CONTAMINATED BRAKE FLUID AND MAY EXPERIENCE A DEGRADATION OF THE SEALING COMPONENTS WITHIN THE BRAKE SYSTEM.
Consequence & remedy
Consequence: THIS COULD LEAD TO LOSS OF BRAKING ABILITY INCREASING THE RISK OF A CRASH.
Remedy: CHRYSLER WILL NOTIFY OWNERS AND REPLACE ALL BRAKE COMPONENTS THAT COME IN CONTACT WITH HYDRAULIC BRAKE FLUID. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 1, 2012. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
EA19001 · Electrical Overstress
Opened Apr 19, 2019 · Closed Sep 19, 2024
Status: closed (inferred from source dates) · Air Bags: Air Bag/restraint Control Module
The Office of Defects Investigation (ODI) opened this investigation to determine if the failure of airbags to deploy during severe crashes, in certain vehicles, was the result of a safety related defect. During the investigation a complex failure was studied that can result in non-deployment of subject vehicle air bags and other restraint system devices in severe crash events. The subject vehicles may be equipped with an airbag control unit (ACU) for the supplemental restraint system (SRS) Electronic Control Unit (ECU) manufactured by ZF-TRW. The ECU receives signals from crash sensors mounted in the vehicle and deploys the vehicle air bags and seat belt pretensioners in accordance with manufacturer design specifications. The ECU in the subject vehicles contains a model DS84 application-specific integrated circuit (ASIC) which controls the communication of the crash sensor signal, firing commands (i.e., when to deploy the airbag(s) and/or pretensioners), and fault information (e.g., diagnostic trouble codes). In September 2016, FCA announced recall 16V-668 for certain model year (MY) 2010 to 2014 Chrysler, Dodge and Jeep products manufactured with the subject ZF-TRW ACU. In this recall, FCA discussed an EOS condition that resulted in a failure of the subject DS84 ASIC, which caused air bag non-deployment. FCA noted that the defect condition had only been observed in vehicles equipped with sensor harnessing routed across the front of the vehicle. Other FCA vehicles that also used the subject ACU, but were not equipped with cross-car harnessing, had not experienced EOS failures, despite similar time in service. During the course of this investigation, ODI sent two separate Information Request (IR) letters to six vehicle manufactures (including FCA, Hyundai, Honda, Kia, Mitsubishi, and Toyota) and one IR letter to ZF-TRW. These IR letters resulted in ODI receiving comprehensive data from these manufacturers and suppliers. Studies of this data found that the DS84 ASIC does not have sufficient protection against negative electrical transients or electrical overstress (“EOS”) that can be generated in certain severe crashes. An electrical transient occurs when the electrical power supplied to a circuit changes momentarily over a short duration of time. In these severe crash cases, the crash sensors and other powered wiring can be damaged and short circuited so as to create a negative electrical transient of sufficient intensity and duration (that are outside the vehicle manufacturer's specification) to damage the ASIC before the restraint device deployment signal is received by the SRS ECU. This damaged signal can lead to incomplete or nondeployment of the air bags and/or pretensioners. Airbag non-deployment and/or lack of pretensioner operation can increase the risk or severity of injury in a crash.A total of 8 fatalities and 14 injuries were associated with known EOS events. The common element in all investigated manufacturers vehicles is the SRS ECU containing a DS84 ASIC manufactured by ZF-TRW. The risk associated with the ASIC is equally shared among all OEMS involved in the investigation. The actual real-world risk can be mitigated by other factors which were assessed by ODI during this investigation. The first mitigating factor involves protections built into the ACU design which protect the DS84 ASIC from damage. There are multiple strategies and levels of protection employed by different OEMs that provide effective EOS mitigation. The two most common strategies at the ACU level are circuit protection diodes on the remote senor signal lines, and current limiting resistors that protect critical components. The second mitigating factor is found at the vehicle level and involves the location and routing of the wires leading from the crash sensors to the SRS ECU. If the wires are well protected in a crash and are not routed with other power wires carrying large currents, the risk for an EOS event is significantly reduced or eliminated. These design specific factors combine to produce a spectrum of risk for the vehicles equipped with ACUs using the DS84 ASIC. Given the many of years of field exposure, it is possible to divide the subject population into two groups; vehicles which have experienced EOS events, and vehicles which have not experienced EOS field events. Four of the six OEMs involved in this investigation have experienced EOS field events on at least one of their models equipped with a DS84 ASIC. All vehicle models (including the Toyota models identified in the Failure Report Summary of the opening resume for this investigation) with field events have been recalled. In an abundance of caution, ODI kept this investigation open five years to monitor field performance and did not identify any field events on vehicles not included in existing safety recalls. Given the spectrum of risk identified in this investigation and that all vehicles with a demonstrated unreasonable risk have been recalled, ODI is closing this investigation. ODI is closing this investigation with the following manufacturer safety recalls: 16V-668, 18E-043, 18V-137, 18V-363, and 20V-024. With the recall actions taken by the subject vehicle and equipment manufacturers, this investigation is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exists on other model or model year vehicles outside of the recall scopes. The agency reserves the right to take further action if warranted by the circumstances.
2012 Fiat 500 Problems, Complaints & Recalls | Skip That Year
Illustration