NHTSA owner reports · September 18, 2026 snapshot.
Fuel System, Gasoline complaints
50 reportsClear category filter65,785 miles · May 20, 2005
Fuel System, Gasoline
CAMPAIGNS 98V184000 AND 98V130000 CONCERN FUEL LEAKAGE ON THE 1993 EAGLE VISION. ON MAY 13, 1999 THE O RINGS WERE REPLACED ON MY EAGLE BY THE PREVIOUS OWNER. ON MARCH 31, 2000, AFTER PURCHASING THE CAR I HAD TO TAKE MY CARE IN TO A GARAGE DUE TO THE STRONG SMELL OF GASOLINE. THE REPAIR SHOP FOUND A GAS LEAK. THEY REPLACE…
Read full complaint
CAMPAIGNS 98V184000 AND 98V130000 CONCERN FUEL LEAKAGE ON THE 1993 EAGLE VISION. ON MAY 13, 1999 THE O RINGS WERE REPLACED ON MY EAGLE BY THE PREVIOUS OWNER. ON MARCH 31, 2000, AFTER PURCHASING THE CAR I HAD TO TAKE MY CARE IN TO A GARAGE DUE TO THE STRONG SMELL OF GASOLINE. THE REPAIR SHOP FOUND A GAS LEAK. THEY REPLACED THE FUEL RAIL GASKET WHICH COST A TOTAL OF $214.02. I BELIEVE THE CAUSE OF THIS PROBLEM WAS CAUSED BY THE LEAKAGE OF THE O RINGS. THE REPLACEMENT OF THE FUEL RAIL GASKET SHOULD BE COVERED UNDER CAMPAIGN NO. 98V130000. I AM REQUESTING REIMBURSEMENT FOR THE $214.02. ALSO, I WOULD LIKE TO KNOW IF THERE IS ANYTHING ALSE I SHOULD DO TO MAKE THE CAR SAFER SUCH AS HAVING THE ENGINE FUEL RAIL REPLACED, WHICH IT APPEARS WASN'T DONE WHEN THE O RINGS WERE REPLACED BY THE PREVIOUS OWNER.
NHTSA ODI #10121668
148,650 miles · Apr 20, 2004
Fuel System, Gasoline
AMENDMENT TO NHTSA ODI COMPLAINT NUMBER 10066149. FUEL RAIL/INJECTION SYSTEM FUEL LINE O-RING LEAK. REFERENCE NHTSA 98V184000/CHRYSLER RECALL 790. 1) 1 INCIDENT OF RECALL NOTICE AND ATTEMPTED RECALL SERVICE. AFTER RECALL SERVICE PERFORMED ON MARCH 18 1999 THERE WERE 2 INCIDENTS OF FUEL RAIL/O-RING LEAK CONFIRMED AS FOLLOW…
Read full complaint
AMENDMENT TO NHTSA ODI COMPLAINT NUMBER 10066149. FUEL RAIL/INJECTION SYSTEM FUEL LINE O-RING LEAK. REFERENCE NHTSA 98V184000/CHRYSLER RECALL 790. 1) 1 INCIDENT OF RECALL NOTICE AND ATTEMPTED RECALL SERVICE. AFTER RECALL SERVICE PERFORMED ON MARCH 18 1999 THERE WERE 2 INCIDENTS OF FUEL RAIL/O-RING LEAK CONFIRMED AS FOLLOWS: 2) RIGHT (PASSENGER) SIDE FUEL RAIL CRACKED AND LEAKED (OCTOBER 17 2002) 3) LEFT (DRIVER) SIDE FUEL INLET LINE O-RING FAILED AND LEAKED (APRIL 13 2004). CUSTOMER WAS MADE TO PAY FOR REPAIRS OF 3RD INCIDENT FOR $583.00 TO REPLACE ENTIRE FUEL RAIL ASSEMBLY CHRYSLER PART NUMBER 5015231AA. INSPECTION OF PARTS RETURNED TO CUSTOMER SHOW THAT FUEL INLET O-RING IS DEFECTIVE (HARDENED AND SHRUNKEN) AND IS BLACK IN COLOR (RECALL REPLACEMENT O-RING IS SUPPOSED TO BE BLUE IN COLOR). IT HAS BEEN CONFIRMED THAT 2ND INCIDENT OF FUEL LEAK WAS DUE TO RECALL SERVICE REPAIR OF MARCH 18 1999 NOT PROPERLY PERFORMED AS FUEL INLET O-RING WAS NEVER REPLACED (VILLAGE MOTORS CHELSEA MI-MECHANIC MISTAKE). IT SHOULD ALSO BE NOTED THAT RECALL SERVICE PROCEDURE TO "REINFORCE RIGHT (PASSENGER) SIDE FUEL RAIL DID NOT PREVENT FUEL LEAK INCIDENT OF OCTOBER 17 2002. CUSTOMER IS SEEKING REIMBURSEMENT FOR $583.00 FROM CHRYSLER DUE TO IMPROPER RECALL SERVICE OF DEFECTIVE O-RING. NHTSA ASSISTANCE WOULD BE APPRECIATED.
NHTSA ODI #10066549
150,000 miles · Apr 19, 2004
Fuel System, GasolineFire
FUEL WAS LEAKING FROM THE FUEL RAIL. CONSUMER HAD VEHICLE TOWED TO THE DEALERSHIP. VEHICLE CAUGHT ON FIRE WHILE BEING TOWED TO THE DEALERSHIP, AND DEALERSHIP REFUSED TO HONOR THE FUEL LEAKAGE RECALL 98V184000 BECAUSE OF THE FIRE. VEHICLE HAD BEEN AT THE DEALERSHIP FOR A MONTH. *AK
NHTSA ODI #10067390
148,700 miles · Apr 14, 2004
Fuel System, Gasoline
FUEL RAIL/INJECTION SYSTEM LEAK. REFERENCE NHTSA 98V184000 AND CHRYSLER RECALL NUMBER 790. 3 INCIDENTS OF FUEL SYSTEM LEAK DUE TO DEFECTIVE FUEL RAIL SYSTEM LEAK. NHTSA 98V184000/CHRYSLER RECALL 790 IS FOR SUPPOSEDLY FIXING RIGHT (PASSENGER) SIDE INJECTION RAIL BUT FAILS TO ACKNOWLEDGE AND ADDRESS FIXING LEFT (DRIVER) SIDE…
Read full complaint
FUEL RAIL/INJECTION SYSTEM LEAK. REFERENCE NHTSA 98V184000 AND CHRYSLER RECALL NUMBER 790. 3 INCIDENTS OF FUEL SYSTEM LEAK DUE TO DEFECTIVE FUEL RAIL SYSTEM LEAK. NHTSA 98V184000/CHRYSLER RECALL 790 IS FOR SUPPOSEDLY FIXING RIGHT (PASSENGER) SIDE INJECTION RAIL BUT FAILS TO ACKNOWLEDGE AND ADDRESS FIXING LEFT (DRIVER) SIDE FUEL INJECTION RAIL WHICH HAS SAME PROBLEM. NOTE: ROOT CAUSE OF FUEL LEAK IS THAT THE FUEL INJECTION RAIL IS MADE OF A PLASTIC WHICH EVENTUALLY SHRINKS OR CRACKS.
NHTSA ODI #10066149
120,000 miles · Jan 12, 2004
Fuel System, Gasoline
RECALL NHTSA# 98V184000. FUEL INJECTION DELIVERY SYSTEM CAN LEAK FUEL FROM SOME OF THE SEALING O-RINGS OR FROM HAIR LINE CRACKS IN THE THERMOSTAT FUEL INJECTION RAIL. THE CONSUMERS VEHICLE HAD THE SAME PROBLEM. DEALER NOTIFIED. *AK THE DEALERSHIP STATED THAT THE CAR WAS NOT IN GOOD CONDITION TO DRIVE. THE CONSUMER WANTS TO GET …
Read full complaint
RECALL NHTSA# 98V184000. FUEL INJECTION DELIVERY SYSTEM CAN LEAK FUEL FROM SOME OF THE SEALING O-RINGS OR FROM HAIR LINE CRACKS IN THE THERMOSTAT FUEL INJECTION RAIL. THE CONSUMERS VEHICLE HAD THE SAME PROBLEM. DEALER NOTIFIED. *AK THE DEALERSHIP STATED THAT THE CAR WAS NOT IN GOOD CONDITION TO DRIVE. THE CONSUMER WANTS TO GET THIS SAFETY PROBLEM TAKEN CARE OF AS SOON AS POSSIBLE. *CB *JB
NHTSA ODI #10049844
Mileage unknown · Aug 25, 2002
Electrical SystemEngine And Engine CoolingEquipment
I BOUGHT THIS CAR IN 1998 AND HAVE HAD TO FIX IT MYSELF MANY TIMES. I CANNOT AFFORD TO PAY SOMEONE TO FIX IT. BUT IF THERE HAS EVER BEEN A LEMON IT IS THIS CAR. I HAVE TO SAY THE MOTOR IS A GOOD ONE. BUT EVERY THING SURROUNDING IT IS JUNK. AT THIS TIME IT IS IN MY MOMS GARAGE AND I'M STILL MAKING PAYMENTS ON IT AND CAN'T EVEN DR…
Read full complaint
I BOUGHT THIS CAR IN 1998 AND HAVE HAD TO FIX IT MYSELF MANY TIMES. I CANNOT AFFORD TO PAY SOMEONE TO FIX IT. BUT IF THERE HAS EVER BEEN A LEMON IT IS THIS CAR. I HAVE TO SAY THE MOTOR IS A GOOD ONE. BUT EVERY THING SURROUNDING IT IS JUNK. AT THIS TIME IT IS IN MY MOMS GARAGE AND I'M STILL MAKING PAYMENTS ON IT AND CAN'T EVEN DRIVE IT. RIGHT NOW IT NEEDS: 1.) TIMING BELT 2.) WIRING PROBLEM UNDER DASH-DOME LIGHTS ON ALL THE TIME, A/C CONTROLS WON'T WORK PROPERLY. 3.) INNER TIE RODS NEED REPLACED AGAIN-(4TH TIME) 4.) SPARK PLUG WIRES GO BAD IN ABOUT 12 MONTHS.(THE GOOD ONES). 5.) TIRES ARE GOING BAD EVERY 6 MONTHS BECAUSE OF TIERODS. 6,) PARKING BRAKE CABLE BROKE. 7.) CATALYTIC CONVERTER. 8.) FUEL RAIL O-RINGS NEED REPLACED. WHEN IT WAS RUNNING IT WAS CONSTANTLY DYING ON ME WHILE DRIVING AND WHILE IDLING, AND FINALLY THE OTHER DAY (AFTER REPLACEING THE COIL PACK AND AN IGNITION RELAY) IT DIED AND WOULN'T RESTART AT ALL.........................WHAT CAN OR WILL YOU DO ABOUT THIS LEMON THAT I HAVE HAD TO CONSTANTLY FIX FOR THE WHOLE 4 YEARS THAT I HAVE OWNED THE CAR//????????????????
NHTSA ODI #766195
Mileage unknown · Mar 11, 2002
Fuel System, Gasoline
DRIVER TOOK VEHICLE IN AFTER RECEIVING RECALL LETTER 98V130 CONCERNING FUEL INJECTION O-RING LEAK. DRIVER WAS SMELLING GAS INSIDE VEHICLE. UPON PICKING UP VEHICLE TWO DAYS LATER, VEHICLE STALLED, AND WAS HIT BY ANOTHER CAR. WHITE SMOKE AND GAS WERE POURING OUT OF EXHAUST. TOWED TO A MECHANIC. MECHANIC STATED THAT VEHICLE COUL…
Read full complaint
DRIVER TOOK VEHICLE IN AFTER RECEIVING RECALL LETTER 98V130 CONCERNING FUEL INJECTION O-RING LEAK. DRIVER WAS SMELLING GAS INSIDE VEHICLE. UPON PICKING UP VEHICLE TWO DAYS LATER, VEHICLE STALLED, AND WAS HIT BY ANOTHER CAR. WHITE SMOKE AND GAS WERE POURING OUT OF EXHAUST. TOWED TO A MECHANIC. MECHANIC STATED THAT VEHICLE COULD HAVE CAUGHT ON FIRE. ALSO, DEALER MAY HAVE PINCHED A GAS LINE DURING THE RECALL, AND THAT CAUSED STALLING AND GAS SHOOTING OUT.*AK CONSUMER STATED IT IS NOT A GAS LINE THAT MAY NOT HAVE BEEN PINCHED, BUT MAYBE THE O-RING, WHEN THE VEHICLE WAS TAKEN TO THE MECHANIC, CONSUMER WAS INFORMED THAT THE VEHICLE WAS OUT OF GAS AND THE PROBLEM WAS THE INTAKE GASKET, OXYGEN INSERTS, EGR VALVE AND PLUGS, CONSUMER STATED THAT THE VEHICLE CONTAINED GAS, THE MECHANIC INFORMED CONSUMER THAT THE GAS GAUGE WAS WRONG, CONSUMER STATES THE VEHICLE WAS RUNNING FINE UNTIL THE RECALL WAS PERFORMED.*JB
NHTSA ODI #8005332
Mileage unknown · Feb 7, 2002
Fuel System, Gasoline
AFTER NOTICING STRONG SMELL OF FUEL TOOK VEHICLE TO MECHANIC. MECHANIC INDICATED THAT THERE WAS A FUEL LEAKAGE JUST LIKE MENTIONED IN RECALL 98 V 184 000. TOOK VEHICLE TO DEALER, AND THEY COULD NOT FIND THE LEAKAGE. PLEASE PROVIDE MORE INFORMATION.*AK
NHTSA ODI #8003745
Mileage unknown · Sep 24, 2001
Electrical SystemEngine And Engine CoolingEquipment
MANUFACTURER WOULD NOT PROPERLY FIX SAFETY ITEM DURING WARRANTY AND WANT TO CHARGE NOW. NO SAFETY DEFECT LISTED. *AK
NHTSA ODI #752518
Mileage unknown · Dec 27, 2000
Fuel System, Gasoline
FUEL RAILS SPRAYING GAS ONTO ENGINE. THE FUEL RAILS WERE A NATIONAL RECALL LAST YEAR. OUR FUEL RAILS WERE REPLACED BY FIRKINS CHRYSLER PLYMOUTH. SINCE THAT TIME WE REPLACED THE ENGINE WITH ANOTHER1993 EAGEL VISION ENGINE. THE FUEL RAILS BEGAN SPRAYING GAS ON THE ENGINE IN A LARGE STREAM. FIRKINS STATES THEY ARE NOT RESPONSIBLE …
Read full complaint
FUEL RAILS SPRAYING GAS ONTO ENGINE. THE FUEL RAILS WERE A NATIONAL RECALL LAST YEAR. OUR FUEL RAILS WERE REPLACED BY FIRKINS CHRYSLER PLYMOUTH. SINCE THAT TIME WE REPLACED THE ENGINE WITH ANOTHER1993 EAGEL VISION ENGINE. THE FUEL RAILS BEGAN SPRAYING GAS ON THE ENGINE IN A LARGE STREAM. FIRKINS STATES THEY ARE NOT RESPONSIBLE FOR REPLACING THE RAILS SINCE THEY REPLACED THEM ONCE. I DO NOT UNDERSTAND WHY CHRYSLER IS NOT REPONSIBLE FOR A DEFECTIVE PART THAT IS THE ORGINAL PART THAT CAME ON THE ENGINE AND IS ON RECALL. PLEASE ASSIST ME IN THIS ISSUE, WE WERE CHARGED $310.69 FOR A PART THAT WAS DEFECTIVE FROM CHRYSLER AND CLEARLY DOCUMENTED BY THE NATIONAL RECALL. THANK YOU. *AK
NHTSA ODI #738382
NHTSA investigations
9DP04007 · Fuel Rail, Brake Fluid, Chassis
Opened Oct 13, 2004 · Closed Oct 27, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline:fuel Injection System:fuel Rail; Service Brakes, Hydraulic:fluid; Structure:frame And Members
ON SEPTEMBER 5, 2004, MR. ROBERT GALENTY OF ISELIN, NJ, PETITIONED THE AGENCY TO CONDUCT DEFECT INVESTIGATIONS OF CERTAIN MODEL YEAR (MY) 1993-1997 VEHICLES PRODUCED BY DAIMLERCHRYSLER CORPORATION.HIS PETITION IDENTIFIED THREE ISSUES OF CONCERN: 1) FUEL LEAKING FROM THE FUEL INJECTOR RAILS; 2) BRAKE FLUID CONTAMINATION RESULTING IN BRAKE FAILURE; AND 3) SUSCEPTIBILITY OF THE VEHICLE FRAME TO DAMAGE WHILE THE VEHICLE IS BEING TOWED.MR. GALANTY ALLEGED THAT HIS 1996 DODGE INTREPID HAD EACH OF THESE THREE PROBLEMS.CONCERNING FUEL RAIL LEAKAGE, DAIMLERCHRYSLER COMMENCED A RECALL (98V-184) OF APPROXIMATELY 722,600 VEHICLES TO ADDRESS ENGINE FUEL RAIL LEAKS THAT COULD LEAD TO A FIRE, INCLUDING THOSE VEHICLES CITED IN THE PETITION AND THE PETITIONER'S 1996 DODGE INTREPID.ON OCTOBER 7, 1998, NHTSA OPENED A RECALL QUERY INVESTIGATION (RQ98-018) TO EVALUATE THE ADEQUACY OF THE RECALL REMEDY.THAT INVESTIGATION WAS CLOSED ON JULY 8, 2002 WITHOUT REQUIRING FURTHER ACTION BY DAIMLERCHRYSLER.VERY RECENTLY, ON JUNE 9, 2004, NHTSA DENIED A PETITION (RP04-001) TO REOPEN RQ98-018 AFTER FINDING THAT THERE WAS NO NEW INFORMATION THAT WOULD INDICATE ANY BASIS FOR REOPENING IT.THIS IS STILL THE CURRENT POSITION OF NHTSA ON THIS ISSUE.CONCERNING BRAKE FLUID CONTAMINATION AND FRAME ALIGNMENT, A REVIEW OF NHTSA'S DATABASE SHOWS NO OTHER COMPLAINTS ON EITHER ONE OF THESE ISSUES ON THE VEHICLES CITED IN THE PETITION.
Additional source detail variants (3)
Fuel System, Gasoline:fuel Injection System:fuel Rail
ON SEPTEMBER 5, 2004, MR. ROBERT GALENTY OF ISELIN, NJ, PETITIONED THE AGENCY TO CONDUCT DEFECT INVESTIGATIONS OF CERTAIN MODEL YEAR (MY) 1993-1997 VEHICLES PRODUCED BY DAIMLERCHRYSLER CORPORATION.HIS PETITION IDENTIFIED THREE ISSUES OF CONCERN: 1) FUEL LEAKING FROM THE FUEL INJECTOR RAILS; 2) BRAKE FLUID CONTAMINATION RESULTING IN BRAKE FAILURE; AND 3) SUSCEPTIBILITY OF THE VEHICLE FRAME TO DAMAGE WHILE THE VEHICLE IS BEING TOWED.MR. GALANTY ALLEGED THAT HIS 1996 DODGE INTREPID HAD EACH OF THESE THREE PROBLEMS.CONCERNING FUEL RAIL LEAKAGE, DAIMLERCHRYSLER COMMENCED A RECALL (98V-184) OF APPROXIMATELY 722,600 VEHICLES TO ADDRESS ENGINE FUEL RAIL LEAKS THAT COULD LEAD TO A FIRE, INCLUDING THOSE VEHICLES CITED IN THE PETITION AND THE PETITIONER'S 1996 DODGE INTREPID.ON OCTOBER 7, 1998, NHTSA OPENED A RECALL QUERY INVESTIGATION (RQ98-018) TO EVALUATE THE ADEQUACY OF THE RECALL REMEDY.THAT INVESTIGATION WAS CLOSED ON JULY 8, 2002 WITHOUT REQUIRING FURTHER ACTION BY DAIMLERCHRYSLER.VERY RECENTLY, ON JUNE 9, 2004, NHTSA DENIED A PETITION (RP04-001) TO REOPEN RQ98-018 AFTER FINDING THAT THERE WAS NO NEW INFORMATION THAT WOULD INDICATE ANY BASIS FOR REOPENING IT.THIS IS STILL THE CURRENT POSITION OF NHTSA ON THIS ISSUE.CONCERNING BRAKE FLUID CONTAMINATION AND FRAME ALIGNMENT, A REVIEW OF NHTSA'S DATABASE SHOWS NO OTHER COMPLAINTS ON EITHER ONE OF THESE ISSUES ON THE VEHICLES CITED IN THE PETITION.
Service Brakes, Hydraulic:fluid
ON SEPTEMBER 5, 2004, MR. ROBERT GALENTY OF ISELIN, NJ, PETITIONED THE AGENCY TO CONDUCT DEFECT INVESTIGATIONS OF CERTAIN MODEL YEAR (MY) 1993-1997 VEHICLES PRODUCED BY DAIMLERCHRYSLER CORPORATION.HIS PETITION IDENTIFIED THREE ISSUES OF CONCERN: 1) FUEL LEAKING FROM THE FUEL INJECTOR RAILS; 2) BRAKE FLUID CONTAMINATION RESULTING IN BRAKE FAILURE; AND 3) SUSCEPTIBILITY OF THE VEHICLE FRAME TO DAMAGE WHILE THE VEHICLE IS BEING TOWED.MR. GALANTY ALLEGED THAT HIS 1996 DODGE INTREPID HAD EACH OF THESE THREE PROBLEMS.CONCERNING FUEL RAIL LEAKAGE, DAIMLERCHRYSLER COMMENCED A RECALL (98V-184) OF APPROXIMATELY 722,600 VEHICLES TO ADDRESS ENGINE FUEL RAIL LEAKS THAT COULD LEAD TO A FIRE, INCLUDING THOSE VEHICLES CITED IN THE PETITION AND THE PETITIONER'S 1996 DODGE INTREPID.ON OCTOBER 7, 1998, NHTSA OPENED A RECALL QUERY INVESTIGATION (RQ98-018) TO EVALUATE THE ADEQUACY OF THE RECALL REMEDY.THAT INVESTIGATION WAS CLOSED ON JULY 8, 2002 WITHOUT REQUIRING FURTHER ACTION BY DAIMLERCHRYSLER.VERY RECENTLY, ON JUNE 9, 2004, NHTSA DENIED A PETITION (RP04-001) TO REOPEN RQ98-018 AFTER FINDING THAT THERE WAS NO NEW INFORMATION THAT WOULD INDICATE ANY BASIS FOR REOPENING IT.THIS IS STILL THE CURRENT POSITION OF NHTSA ON THIS ISSUE.CONCERNING BRAKE FLUID CONTAMINATION AND FRAME ALIGNMENT, A REVIEW OF NHTSA'S DATABASE SHOWS NO OTHER COMPLAINTS ON EITHER ONE OF THESE ISSUES ON THE VEHICLES CITED IN THE PETITION.
Structure:frame And Members
ON SEPTEMBER 5, 2004, MR. ROBERT GALENTY OF ISELIN, NJ, PETITIONED THE AGENCY TO CONDUCT DEFECT INVESTIGATIONS OF CERTAIN MODEL YEAR (MY) 1993-1997 VEHICLES PRODUCED BY DAIMLERCHRYSLER CORPORATION.HIS PETITION IDENTIFIED THREE ISSUES OF CONCERN: 1) FUEL LEAKING FROM THE FUEL INJECTOR RAILS; 2) BRAKE FLUID CONTAMINATION RESULTING IN BRAKE FAILURE; AND 3) SUSCEPTIBILITY OF THE VEHICLE FRAME TO DAMAGE WHILE THE VEHICLE IS BEING TOWED.MR. GALANTY ALLEGED THAT HIS 1996 DODGE INTREPID HAD EACH OF THESE THREE PROBLEMS.CONCERNING FUEL RAIL LEAKAGE, DAIMLERCHRYSLER COMMENCED A RECALL (98V-184) OF APPROXIMATELY 722,600 VEHICLES TO ADDRESS ENGINE FUEL RAIL LEAKS THAT COULD LEAD TO A FIRE, INCLUDING THOSE VEHICLES CITED IN THE PETITION AND THE PETITIONER'S 1996 DODGE INTREPID.ON OCTOBER 7, 1998, NHTSA OPENED A RECALL QUERY INVESTIGATION (RQ98-018) TO EVALUATE THE ADEQUACY OF THE RECALL REMEDY.THAT INVESTIGATION WAS CLOSED ON JULY 8, 2002 WITHOUT REQUIRING FURTHER ACTION BY DAIMLERCHRYSLER.VERY RECENTLY, ON JUNE 9, 2004, NHTSA DENIED A PETITION (RP04-001) TO REOPEN RQ98-018 AFTER FINDING THAT THERE WAS NO NEW INFORMATION THAT WOULD INDICATE ANY BASIS FOR REOPENING IT.THIS IS STILL THE CURRENT POSITION OF NHTSA ON THIS ISSUE.CONCERNING BRAKE FLUID CONTAMINATION AND FRAME ALIGNMENT, A REVIEW OF NHTSA'S DATABASE SHOWS NO OTHER COMPLAINTS ON EITHER ONE OF THESE ISSUES ON THE VEHICLES CITED IN THE PETITION.
EA03011 · Auto Trans IGNITION-PARK Interlock
Opened Jul 17, 2003 · Closed Jan 30, 2004
Status: closed (inferred from source dates) · Power Train:automatic Transmission; Power Train:automatic Transmission:lever And Linkage:floor Shift
THE MANUFACTURER REPORTS ABOVE ARE BASED ON DAIMLERCHRYSLER?S (DC) ANALYSIS OF MODEL YEAR (MY) 1998 (POPULATION = 356,384) AND 1999 (POPULATION = 486,948) JA, JX AND LH FAMILY SUBJECT VEHICLE DATA (EARLIER MYS EXCLUDED).THE POPULATION NUMBER INCLUDES ALL MYS.THE PRECISE NUMBER OF DUPLICATES BETWEEN ODI AND DC REPORTS CANNOT BE DETERMINED DUE TO MISSING OR INCOMPLETE INFORMATION.THE FATALITY INCIDENT INVOLVED AN ELDERLY PERSON WHO ATTEMPTED TO STOP A ROLL AWAY VEHICLE AND RECEIVED FATAL INJURIES.ODI ALSO GATHERED INFORMATION ON MY 1997-99 PROWLER VEHICLES IN THIS INVESTIGATION. THE PROWLER VEHICLES WERE MANUFACTURED WITH A DIFFERENT DESIGN SHIFTER MECHANISM (THE SHIFT LEVER IS SHORTER).THERE ARE NO COMPLAINTS OF PROWLER INTERLOCK FAILURE IN ODI?S DATABASE, AND DC HAS RECEIVED NO REPORTS EITHER.THE PROWLER IS EXCLUDED FROM THE RECALL SCOPE.THE INVESTIGATION INVOLVED A CONDITION WHERE THE INTERLOCK SYSTEM COULD FAIL (OR BE MADE INOPERATIVE BY THE OPERATOR) DURING VEHICLE USE, POSSIBLY INADVERTENTLY.THE INTERLOCK SYSTEM IS REQUIRED UNDER FMVSS 114.WITH THE TRANSMISSION IN THE PARK POSITION AND THE IGNITION KEY OFF, THE COMBINED ACTION OF PRESSING THE SHIFT BUTTON AND PULLING THE SHIFT LEVER REARWARD MAY RESULT IN THE OPERATOR OVERCOMING THE INTERLOCK SYSTEM AND CAUSE THE MECHANICAL LINKAGE OF THE SYSTEM TO DISCONNECT.WHEN THIS OCCURS, THERE IS NO OVERT INDICATION TO AN OPERATOR THAT THE SYSTEM IS DEFEATED, AND AN INCREASED RISK OF VEHICLE ROLL-AWAY EXISTS.UNDER RECALL 04V021, DC WILL REPLACE DAMAGED SHIFT MECHANISMS, AND WILL INSTALL ON ALL VEHICLES A DEVICE WHICH INHIBITS THE OPERATOR?S ABILITY TO OVERCOME THE INTERLOCK AND DEFEAT THE SYSTEM.BEGINNING WITH MY 2000, DC INCORPORATED A BRAKE AND TRANSMISSION SHIFTER INTERLOCK (BTSI) SYSTEM INTO THE SUBJECT VEHICLES.INTRODUCTION OF BTSI INVOLVED DESIGN CHANGES TO THE SHIFT MECHANISM, ONE OF WHICH RESULTED IN REDUCED MECHANICAL ADVANTAGE (RMA) OF THE SHIFT BUTTON.THE RMA SHIFTER REQUIRES INCREASED FORCES TO OVERCOME THE INTERLOCK SYSTEM, MAKING THE SHIFTER LESS SUSCEPTIBLE TO DAMAGE.
Additional source detail variants (2)
Power Train:automatic Transmission
THE MANUFACTURER REPORTS ABOVE ARE BASED ON DAIMLERCHRYSLER?S (DC) ANALYSIS OF MODEL YEAR (MY) 1998 (POPULATION = 356,384) AND 1999 (POPULATION = 486,948) JA, JX AND LH FAMILY SUBJECT VEHICLE DATA (EARLIER MYS EXCLUDED).THE POPULATION NUMBER INCLUDES ALL MYS.THE PRECISE NUMBER OF DUPLICATES BETWEEN ODI AND DC REPORTS CANNOT BE DETERMINED DUE TO MISSING OR INCOMPLETE INFORMATION.THE FATALITY INCIDENT INVOLVED AN ELDERLY PERSON WHO ATTEMPTED TO STOP A ROLL AWAY VEHICLE AND RECEIVED FATAL INJURIES.ODI ALSO GATHERED INFORMATION ON MY 1997-99 PROWLER VEHICLES IN THIS INVESTIGATION. THE PROWLER VEHICLES WERE MANUFACTURED WITH A DIFFERENT DESIGN SHIFTER MECHANISM (THE SHIFT LEVER IS SHORTER).THERE ARE NO COMPLAINTS OF PROWLER INTERLOCK FAILURE IN ODI?S DATABASE, AND DC HAS RECEIVED NO REPORTS EITHER.THE PROWLER IS EXCLUDED FROM THE RECALL SCOPE.THE INVESTIGATION INVOLVED A CONDITION WHERE THE INTERLOCK SYSTEM COULD FAIL (OR BE MADE INOPERATIVE BY THE OPERATOR) DURING VEHICLE USE, POSSIBLY INADVERTENTLY.THE INTERLOCK SYSTEM IS REQUIRED UNDER FMVSS 114.WITH THE TRANSMISSION IN THE PARK POSITION AND THE IGNITION KEY OFF, THE COMBINED ACTION OF PRESSING THE SHIFT BUTTON AND PULLING THE SHIFT LEVER REARWARD MAY RESULT IN THE OPERATOR OVERCOMING THE INTERLOCK SYSTEM AND CAUSE THE MECHANICAL LINKAGE OF THE SYSTEM TO DISCONNECT.WHEN THIS OCCURS, THERE IS NO OVERT INDICATION TO AN OPERATOR THAT THE SYSTEM IS DEFEATED, AND AN INCREASED RISK OF VEHICLE ROLL-AWAY EXISTS.UNDER RECALL 04V021, DC WILL REPLACE DAMAGED SHIFT MECHANISMS, AND WILL INSTALL ON ALL VEHICLES A DEVICE WHICH INHIBITS THE OPERATOR?S ABILITY TO OVERCOME THE INTERLOCK AND DEFEAT THE SYSTEM.BEGINNING WITH MY 2000, DC INCORPORATED A BRAKE AND TRANSMISSION SHIFTER INTERLOCK (BTSI) SYSTEM INTO THE SUBJECT VEHICLES.INTRODUCTION OF BTSI INVOLVED DESIGN CHANGES TO THE SHIFT MECHANISM, ONE OF WHICH RESULTED IN REDUCED MECHANICAL ADVANTAGE (RMA) OF THE SHIFT BUTTON.THE RMA SHIFTER REQUIRES INCREASED FORCES TO OVERCOME THE INTERLOCK SYSTEM, MAKING THE SHIFTER LESS SUSCEPTIBLE TO DAMAGE.
Power Train:automatic Transmission:lever And Linkage:floor Shift
THE MANUFACTURER REPORTS ABOVE ARE BASED ON DAIMLERCHRYSLER?S (DC) ANALYSIS OF MODEL YEAR (MY) 1998 (POPULATION = 356,384) AND 1999 (POPULATION = 486,948) JA, JX AND LH FAMILY SUBJECT VEHICLE DATA (EARLIER MYS EXCLUDED).THE POPULATION NUMBER INCLUDES ALL MYS.THE PRECISE NUMBER OF DUPLICATES BETWEEN ODI AND DC REPORTS CANNOT BE DETERMINED DUE TO MISSING OR INCOMPLETE INFORMATION.THE FATALITY INCIDENT INVOLVED AN ELDERLY PERSON WHO ATTEMPTED TO STOP A ROLL AWAY VEHICLE AND RECEIVED FATAL INJURIES.ODI ALSO GATHERED INFORMATION ON MY 1997-99 PROWLER VEHICLES IN THIS INVESTIGATION. THE PROWLER VEHICLES WERE MANUFACTURED WITH A DIFFERENT DESIGN SHIFTER MECHANISM (THE SHIFT LEVER IS SHORTER).THERE ARE NO COMPLAINTS OF PROWLER INTERLOCK FAILURE IN ODI?S DATABASE, AND DC HAS RECEIVED NO REPORTS EITHER.THE PROWLER IS EXCLUDED FROM THE RECALL SCOPE.THE INVESTIGATION INVOLVED A CONDITION WHERE THE INTERLOCK SYSTEM COULD FAIL (OR BE MADE INOPERATIVE BY THE OPERATOR) DURING VEHICLE USE, POSSIBLY INADVERTENTLY.THE INTERLOCK SYSTEM IS REQUIRED UNDER FMVSS 114.WITH THE TRANSMISSION IN THE PARK POSITION AND THE IGNITION KEY OFF, THE COMBINED ACTION OF PRESSING THE SHIFT BUTTON AND PULLING THE SHIFT LEVER REARWARD MAY RESULT IN THE OPERATOR OVERCOMING THE INTERLOCK SYSTEM AND CAUSE THE MECHANICAL LINKAGE OF THE SYSTEM TO DISCONNECT.WHEN THIS OCCURS, THERE IS NO OVERT INDICATION TO AN OPERATOR THAT THE SYSTEM IS DEFEATED, AND AN INCREASED RISK OF VEHICLE ROLL-AWAY EXISTS.UNDER RECALL 04V021, DC WILL REPLACE DAMAGED SHIFT MECHANISMS, AND WILL INSTALL ON ALL VEHICLES A DEVICE WHICH INHIBITS THE OPERATOR?S ABILITY TO OVERCOME THE INTERLOCK AND DEFEAT THE SYSTEM.BEGINNING WITH MY 2000, DC INCORPORATED A BRAKE AND TRANSMISSION SHIFTER INTERLOCK (BTSI) SYSTEM INTO THE SUBJECT VEHICLES.INTRODUCTION OF BTSI INVOLVED DESIGN CHANGES TO THE SHIFT MECHANISM, ONE OF WHICH RESULTED IN REDUCED MECHANICAL ADVANTAGE (RMA) OF THE SHIFT BUTTON.THE RMA SHIFTER REQUIRES INCREASED FORCES TO OVERCOME THE INTERLOCK SYSTEM, MAKING THE SHIFTER LESS SUSCEPTIBLE TO DAMAGE.
DP03002 · Steering Column Separation
Opened May 7, 2003 · Closed Jul 22, 2003
Status: closed (inferred from source dates) · Steering:column
MR. LARRY A. SACKEY SUBMITTED A PETITION TO THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) BY LETTER DATED APRIL 18, 2003, REQUESTING THAT NHTSAFURTHER INVESTIGATE THE DEFECTIVE COLLAPSIBLE STEERING SHAFT SYSTEM ON 1987-1995 VEHICLES MANUFACTURED BY THE DAIMLERCHRYSLER CORPORATION.IN PART BECAUSE OF 49 CFR ? 30120(G), NHTSA HAS DECIDED TO LIMIT THE SCOPE OF THE PETITION VEHICLES TO 1993-1995 MODELS, EXCLUDING THE 1993 JEEP GRAND CHEROKEE AND 1994-1995 DODGE RAM SERIES TRUCKS THAT WERE RECALLED (93V210 & 96V230) FOR STEERING COLUMN FAILURE.IF THE ANALYSIS OF THESE VEHICLES HAD IDENTIFIED A POTENTIAL PROBLEM, THE SCOPE COULD HAVE BEEN EXPANDED IN AN INVESTIGATION.A REVIEW OF ODI'S DATA BASE SHOWS NO RECENT COMPLAINTS AND A LACK OF A COMPLAINT TREND CONCERNING THE SUBJECT ISSUE ON THE SUBJECT VEHICLES AS A WHOLE OR BY INDIVIDUAL MODELS.THEREFORE, THE PETITION IS DENIED.FOR DETAILS, SEE FEDERAL REGISTER NOTICE VOLUME 68, NO. 130, JULY 8, 2003.
RQ98018 · Fuel Injection Delivery System Fuel Leak
Opened Oct 7, 1998 · Closed Jul 8, 2002
Status: closed (inferred from source dates) · Fuel System, Gasoline:fuel Injection System
No summary supplied.
PE98022 · Rear Suspension Trailing Arm/bolt
Opened Apr 14, 1998 · Closed Aug 31, 1998
Status: closed (inferred from source dates) · Suspension
ALLEGED THAT THE REAR SUSPENSION TRAILING AND/OR ITS ATTACHMENT BOLT MAY FAIL, POSING A RISK OF LOSS OF VEHICLE CONTROL AND LOSS OF REAR SERVICE BRAKE OPERATION
EA98007 · Fuel Injector Assembly Leakage
Opened Mar 10, 1998 · Closed Feb 1, 1999
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings; Fuel System, Gasoline:fuel Injection System; Fuel System, Gasoline:fuel Injection System:fuel Rail
NITRILE RUBBER SEALS USED IN THE FUEL RAIL ASSEMBLIES OF THE SUBJECT VEHICLES AT THE SUPPLY, RETURN, AND CROSSOVER TUBE FITTINGS, AND AT THE PRESSURE REGULATOR FAIL, RESULTING IN FUEL LEAKAGE IN THE ENGINE COMPARTMENT.ALSO, THE OUTLET (RIGHT) FUEL RAIL MAY LEAK FROM CRACKS AT CERTAIN MOLD GATES IN THE THERMOSET RAIL MATERIAL.CHRYSLER WILL RECALL THE SUBJECT VEHICLES AND STATED THAT IT INTENDS TO REPLACE THE O-RINGS WITH FLUOROCARBON O-RING HAVING GREATER HEAT RESISTANCE CAPABILITY AND ATTACH REINFORCEMENTS TO THE RAIL IN THE AREAS WHERE THE CRACKING CONCERN HAS BEEN KNOWN TO OCCUR MOST FREQUENTLY.RAILS THAT ARE ALREADY CRACKED WILL BE REPLACED BY NEW, REINFORCED RAILS.
Additional source detail variants (3)
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
NITRILE RUBBER SEALS USED IN THE FUEL RAIL ASSEMBLIES OF THE SUBJECT VEHICLES AT THE SUPPLY, RETURN, AND CROSSOVER TUBE FITTINGS, AND AT THE PRESSURE REGULATOR FAIL, RESULTING IN FUEL LEAKAGE IN THE ENGINE COMPARTMENT.ALSO, THE OUTLET (RIGHT) FUEL RAIL MAY LEAK FROM CRACKS AT CERTAIN MOLD GATES IN THE THERMOSET RAIL MATERIAL.CHRYSLER WILL RECALL THE SUBJECT VEHICLES AND STATED THAT IT INTENDS TO REPLACE THE O-RINGS WITH FLUOROCARBON O-RING HAVING GREATER HEAT RESISTANCE CAPABILITY AND ATTACH REINFORCEMENTS TO THE RAIL IN THE AREAS WHERE THE CRACKING CONCERN HAS BEEN KNOWN TO OCCUR MOST FREQUENTLY.RAILS THAT ARE ALREADY CRACKED WILL BE REPLACED BY NEW, REINFORCED RAILS.
Fuel System, Gasoline:fuel Injection System
NITRILE RUBBER SEALS USED IN THE FUEL RAIL ASSEMBLIES OF THE SUBJECT VEHICLES AT THE SUPPLY, RETURN, AND CROSSOVER TUBE FITTINGS, AND AT THE PRESSURE REGULATOR FAIL, RESULTING IN FUEL LEAKAGE IN THE ENGINE COMPARTMENT.ALSO, THE OUTLET (RIGHT) FUEL RAIL MAY LEAK FROM CRACKS AT CERTAIN MOLD GATES IN THE THERMOSET RAIL MATERIAL.CHRYSLER WILL RECALL THE SUBJECT VEHICLES AND STATED THAT IT INTENDS TO REPLACE THE O-RINGS WITH FLUOROCARBON O-RING HAVING GREATER HEAT RESISTANCE CAPABILITY AND ATTACH REINFORCEMENTS TO THE RAIL IN THE AREAS WHERE THE CRACKING CONCERN HAS BEEN KNOWN TO OCCUR MOST FREQUENTLY.RAILS THAT ARE ALREADY CRACKED WILL BE REPLACED BY NEW, REINFORCED RAILS.
Fuel System, Gasoline:fuel Injection System:fuel Rail
NITRILE RUBBER SEALS USED IN THE FUEL RAIL ASSEMBLIES OF THE SUBJECT VEHICLES AT THE SUPPLY, RETURN, AND CROSSOVER TUBE FITTINGS, AND AT THE PRESSURE REGULATOR FAIL, RESULTING IN FUEL LEAKAGE IN THE ENGINE COMPARTMENT.ALSO, THE OUTLET (RIGHT) FUEL RAIL MAY LEAK FROM CRACKS AT CERTAIN MOLD GATES IN THE THERMOSET RAIL MATERIAL.CHRYSLER WILL RECALL THE SUBJECT VEHICLES AND STATED THAT IT INTENDS TO REPLACE THE O-RINGS WITH FLUOROCARBON O-RING HAVING GREATER HEAT RESISTANCE CAPABILITY AND ATTACH REINFORCEMENTS TO THE RAIL IN THE AREAS WHERE THE CRACKING CONCERN HAS BEEN KNOWN TO OCCUR MOST FREQUENTLY.RAILS THAT ARE ALREADY CRACKED WILL BE REPLACED BY NEW, REINFORCED RAILS.
PE98014 · Fuel Rail Leakage
Opened Mar 6, 1998 · Closed Jun 15, 1998
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
ALLEGED GASOLINE LEAKS FROM THE FUEL RAIL CROSS-OVER TUBE FITTINGS
EA95028 · Underhood Fuel Leaks
Opened Sep 22, 1995 · Closed Feb 24, 1997
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WAARRANTED BY THE CIRCUMSTANCES.AN ENGINEERING ANALYSIS CLOSSING REPORT IS INCLUDED IN THE PUBLIC FILE.
EA95023 · Water In Defroster System
Opened Aug 31, 1995 · Closed Dec 31, 1996
Status: closed (inferred from source dates) · Visibility:defroster/defogger/hvac System
A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER EXPENDITURE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE THE ENGINEERING ANALYSIS CLOSING REPORT (EA95-023)
Illustration