Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 48 of 349 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Engine And Engine Cooling. Review the 158 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Service Brakes, Hydraulic. Review the 42 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 36 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
28 crash reports32 fire reports20 injury reports
What owners actually said
349 reports
Mileage unknown · Aug 8, 2000
Equipment
I NOTICED THAT MY AIR CONDITIONER WAS BLOWING WARM AIR ON JULY 4TH WHICH WAS A REALLY HOT DAY I CONTACTED QUICK LUBE ON THE FOLLOWING TUESDAY THEY INFORMED ME IT WAS MY COMPRESSOR THEY SAID THAT IT WAS WAY PREMATURE TO LOSE A COMPRESSOR AT 47,000 MILES AND THAT I SHOULD CONTACT MY DEALERSHIP WHICH I DID THEY PROCEEDED TO INFORM …
Read full complaint
I NOTICED THAT MY AIR CONDITIONER WAS BLOWING WARM AIR ON JULY 4TH WHICH WAS A REALLY HOT DAY I CONTACTED QUICK LUBE ON THE FOLLOWING TUESDAY THEY INFORMED ME IT WAS MY COMPRESSOR THEY SAID THAT IT WAS WAY PREMATURE TO LOSE A COMPRESSOR AT 47,000 MILES AND THAT I SHOULD CONTACT MY DEALERSHIP WHICH I DID THEY PROCEEDED TO INFORM ME THAT THAT WAS JUST THE WAY THE COOKIE CRUMBLES AND $ 800.00 LATER I WAS A VERY DISGRUNTELED VEHICLE OWNER I THINK IT IS RIDICULOUS THAT WE SPEND GOOD MONEY ON A CAR AND THIS IS HOW WE ARE REPAID FOR GOOD MAINTINENCE ON OUR CAR . I WILL NEVER BUY ANOTHER DODGE AGAIN !!!! S. *AK
NHTSA ODI #726998
Mileage unknown · Jul 28, 2000
Service Brakes, Hydraulic
VEHICLE EXPERIENCED TOTAL BRAKE FAILURE ON FOUR OCCASIONS. BRAKE PEDAL WOULD GO TO THE FLOOR MOMENTARILY, AND RETURN AFTER PUMPING THE PEDAL A FEW TIMES. VEHICLE BEEN IN DEALER'S SHOP ON TWO OCCASIONS. DEALER INFORMED CONSUMER THAT NOTHING COULD BE FOUND. *AK
NHTSA ODI #866263
Mileage unknown · Jul 23, 2000
Engine And Engine Cooling
THE HEAD GASKET BEGAN LEAKING PROFUSELY AT 31,000 MILES. MY WARRENTY IS OVER AND WANT INFORMATION ON HOW TO GAIN A REPLACEMENT FROM THE DEALERSHIP. I HAVE SEARCHED THE WEB AND HAVE FOUND NUMEROUS COMPLAINTS ABOUT THIS PART IN THE STRATUS. IS ANYTHING BEING DONE? *AK
NHTSA ODI #725871
Mileage unknown · Jul 22, 2000
Service Brakes, Hydraulic
WHEN I USED THE BACK BUTTON TO CORRECT AN ITEM, THE ORIGINAL COMMENTS WERE WIPED OUT. YOU HAVE TO FIX THAT. WE HAVE HAD FOUR BRAKE FAILURES ON OUR DODGE. EACH HAS BEEN EXACTLY THE SAME. THE FIRST TWO WERE ON SUCCESSIVE DAYS WHEN THE CAR HAD LESS THAN 10000 MILES ON IT. BOSCO DODGE INSPECTED THEY BRAKES THEN AND WAS NOT ABLE T…
Read full complaint
WHEN I USED THE BACK BUTTON TO CORRECT AN ITEM, THE ORIGINAL COMMENTS WERE WIPED OUT. YOU HAVE TO FIX THAT. WE HAVE HAD FOUR BRAKE FAILURES ON OUR DODGE. EACH HAS BEEN EXACTLY THE SAME. THE FIRST TWO WERE ON SUCCESSIVE DAYS WHEN THE CAR HAD LESS THAN 10000 MILES ON IT. BOSCO DODGE INSPECTED THEY BRAKES THEN AND WAS NOT ABLE TO FIND THE CAUSE. THEY DID REPLACE THE MASTER CYLINDER WITH A FACTORY REPLACEMENT. THIS SPRING, THEY FAILED AGAIN IN THE SAME MANNER. AGAIN, THE DODGE DEALER WAS NOT ABLE TO PINPOINT THE PROBLEM. HE DID NOT REPLACE ANYTHING AT THAT TIME. TODAY THE BRAKES FAILED IN THE SAME MANNER. HOW DO THEY FAIL? EACH TIME THE CAR WAS PARKED IN THE GARAGE OVER NIGHT. THIS WAS THE FIRST TIME THE CAR WAS MOVED THAT DAY. THREE TIMES THE BRAKES FAILED LESS THAN 100 FEET FROM THE DRIVEWAY. MY WIFE WAS STOPPING THE CAR AT THE INTERSECTION. THE FOURTH TIME WAS THREE BLOCKS AWAY. IN EACH INSTANCE THE CAR LOST ALL BRAKING POWER TO ALL WHEELS AS THE BRAKES WERE APPLIED. THE BAKES AND CAR OPERATED NORMALLY AFTER EACH INSTANCE. IN MY MIND, IT SOUNDS AS IF THE ANTI-LOCKS HUNG UP IN THE OPEN POSITION. *AK
NHTSA ODI #725822
Mileage unknown · Jul 14, 2000
Engine And Engine Cooling
EINGINE HEAD GASKET IS LEAKING. GASKET IS BEING REPLACED BY DEALERSHIP. PLEASE PROVIDE ANY FURTHER INFORMATION.*AK
NHTSA ODI #865409
Mileage unknown · Jul 9, 2000
Engine And Engine Cooling
EXHAUST MANIFOLD - UPON DEALER REPLACING DEFECTIVE CYLINDER HEAD GASKET, WAS NOTIFIED BY DEALER THAT THE EXHAUST MANIFOLD HAS A CRACK AND SHOULD BE REPLACED. PRIOR TO TAKING TO DEALER ANOTHER GARAGE HAD DETERMINED THE CAUSE FOR OVERHEATING TO BE FROM A DEFECTIVE HEAD GASKET. THEY DID NOT MENTION ANYTHING ABOUT CRACK IN EXHAUST M…
Read full complaint
EXHAUST MANIFOLD - UPON DEALER REPLACING DEFECTIVE CYLINDER HEAD GASKET, WAS NOTIFIED BY DEALER THAT THE EXHAUST MANIFOLD HAS A CRACK AND SHOULD BE REPLACED. PRIOR TO TAKING TO DEALER ANOTHER GARAGE HAD DETERMINED THE CAUSE FOR OVERHEATING TO BE FROM A DEFECTIVE HEAD GASKET. THEY DID NOT MENTION ANYTHING ABOUT CRACK IN EXHAUST MANIFOLD DURING THEIR INSPECTION OF THE VEHICLE. OWNER FEELS DAMAGE WAS CAUSED BY THE DEALER UPON REMOVAL OF THE CYLINDER HEAD OR DUE TO EXCESSIVE HEAT CAUSED BY OVERHEATING FROM THE DEFECTIVE HEAD GASKET. DEALER REFUSED TO ACKNOWLEDGE RESPONSIBLITY AND REFUSED TO CONTACT DODGE FACTORY REPRESENTATIVE. THEY SAID IT WAS SAFE TO RE-INSTALL THE CRACKED EXHAUST MANIFOLD AND DRIVE THE VEHICLE. WE ARE CONCERNED ABOUT EXHAUST FUMES COMING INTO THE VEHICLE AND FEEL IT IS UNSAFE. STEERING RACK - THE POWER STEERING FAILED AND CAUSED VEHICLE TO BE VIRTUALLY UNDRIVEABLE. WHEN WE CONTACTED THE MANUFACTURER, WE WERE TOLD IT WAS OUT OF THE WARRANTY PERIOD. WE THEREFORE PAID TO HAVE IT REPLACED AT A COST OF ALMOST $800. WE FEEL THAT THE RACK AND PINION STEERING RACK ASSEMBLY SHOULD NOT HAVE FAILED WITH ONLY 52,000 MILES ON THE VEHICLE.*AK
NHTSA ODI #725170
Mileage unknown · Jul 7, 2000
Power Train
OUR TRANSMISSION HAD AT LEAST 1500 DOLLARS WORTH OF DAMAGE FROM THE FACTORY. THE LOCAL DODGE DEALER 'S SERVICE DEPT SEES AT LEAST ONE PER WEEK. IT DOESN'T SEEM RIGHT.*AK
NHTSA ODI #725086
Mileage unknown · Jun 28, 2000
Vehicle Speed ControlCrash
CRUISE CONTROL, WHICH WAS NOT BEING USED AT THE TIME AND WHICH WAS NOT OPERABLE [HAD NOT BEEN WORKING PRIOR TO THE ACCIDENT] SUDDENLY AND WITHOUT PRIOR WARNING CAUSED THE CAR TO ACCELERATE AS IF THE ACCELERATOR PEDAL WERE FLOORBOARDED. DRIVER AVOIDED OTHER TRAFFIC BUT ENDED UP IN A FIELD. CAR WAS TOTALED. INSPECTION OF THE CIR…
Read full complaint
CRUISE CONTROL, WHICH WAS NOT BEING USED AT THE TIME AND WHICH WAS NOT OPERABLE [HAD NOT BEEN WORKING PRIOR TO THE ACCIDENT] SUDDENLY AND WITHOUT PRIOR WARNING CAUSED THE CAR TO ACCELERATE AS IF THE ACCELERATOR PEDAL WERE FLOORBOARDED. DRIVER AVOIDED OTHER TRAFFIC BUT ENDED UP IN A FIELD. CAR WAS TOTALED. INSPECTION OF THE CIRCUIT BOARD INSIDE THE CRUISE CONTROL SERVO UNIT WAS FOUND TO BE FAULTY. *AK
NHTSA ODI #724682
Mileage unknown · Jun 23, 2000
Air BagsInjury
THE AIR BAG LIGHT FLASHED FOR A SEC THEN IT WENT OFF RIPPING MY HAND OFF THE STERING WHEEL I HAD MY FAMILY IN THE CAR . IT WAS LOUD AND MY ARM HAD PLASTIC IN IT . *AK
NHTSA ODI #724433
Mileage unknown · Jun 19, 2000
Engine And Engine Cooling
AT 61,000 MILES OIL STARTED LEAKING FROM ENGINE HEAD GASKET. THIS CAUSED VEHICLE TO USE MORE FUEL/ STALL, AND ENGINE TO BLOW OUT. PLEASE PROVIDE ANY FURTHER INFORMATION. *AK
ON CERTAIN PASSENGER VEHICLES, THE FLOOR SHIFTER IGNITION-PARK INTERLOCK MAY FAIL AND ALLOW THE SHIFTER TO BE MOVED OUT OF THE PARK POSITION WITH THE KEY REMOVED. AN INOPERATIVE INTERLOCK MAY ALSO ALLOW THE KEY TO BE REMOVED WHEN THE SHIFTER HAS NOT BEEN PLACED IN THE PARK POSITION.
Consequence & remedy
Consequence: EITHER CIRCUMSTANCE MAY RESULT IN THE VEHICLE ROLLING AWAY WITHOUT WARNING.
Remedy: DEALERS WILL INSTALL A NEW LOAD-LIMITING PUSH ROD INTO THE FLOOR SHIFTER LEVER OF THE AFFECTED VEHICLES. OWNER NOTIFICATION BEGAN ON JUNE 14, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS. THE ADJUSTMENT OF THE CABLE CONNECTING THE CONSOLE SHIFTER MECHANISM TO THE IGNITION KEY CAN CAUSE A TRAPPED KEY CONDITION WHICH CAN RESULT IN A LOW FORCE REQUIRED TO DEPRESS THE SHIFT BUTTON. A COMBINATION OF APPLYING A MIS-ADJUSTED RELEASE BUTTON WITH A LOW FORCE ATTEMPT TO SHIFT OUT OF PARK WITH THE KEY IN THE LOCKED POSITION, CAN BREAK THE CONNECTING PIN IN THE SHIFTER.
Consequence & remedy
Consequence: IF THIS HAPPENS, THE "IGNITION-PARK" INTERLOCK SYSTEM WILL BE NONFUNCTIONAL.
Remedy: DEALERS WILL INSPECT FOR PROPER OPERATION OF THE SYSTEM. ANY VEHICLES THAT ARE NOT FUNCTIONAL AFTER THE INSPECTION WILL HAVE THE SHIFT MECHANISM AND CABLE REPLACED WITH A "SELF-ADJUSTING" DESIGN.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE LOWER CONTROL ARM BALL JOINT CAN SEPARATE DUE TO LOSS OF LUBRICATION.
Consequence & remedy
Consequence: SEPARATION OF THE BALL JOINT COULD CAUSE A LOSS OF STEERING CONTROL INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL INSPECT THE BALL JOINT END HOUSING COVER SEAL FOR LEAKAGE WITH A HIGH PRESSURE AIR TESTER AND THE RUBBER BOOT WILL BE VISUALLY INSPECTED FOR DAMAGE. IF THE COVER SEAL LEAKS OR THE BOOT IS DAMAGED, THE LOWER CONTROL ARM WILL BE REPLACED.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE SECONDARY HOOD LATCH SPRING CAN DISENGAGE FROM ITS RETENTION HOLE IF THE HOOD IS SLAMMED SHUT.
Consequence & remedy
Consequence: IF THIS CONDITION OCCURS SIMULTANEOUSLY WITHOUT ENGAGING THE PRIMARY LATCH, THE HOOD WOULD NOT BE RESTRAINED INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE SECONDARY HOOD LATCH SPRING WITH A LONGER END HOOK SPRING.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3
EA03011 · Auto Trans IGNITION-PARK Interlock
Opened Jul 17, 2003 · Closed Jan 30, 2004
Status: closed (inferred from source dates) · Power Train:automatic Transmission; Power Train:automatic Transmission:lever And Linkage:floor Shift
THE MANUFACTURER REPORTS ABOVE ARE BASED ON DAIMLERCHRYSLER?S (DC) ANALYSIS OF MODEL YEAR (MY) 1998 (POPULATION = 356,384) AND 1999 (POPULATION = 486,948) JA, JX AND LH FAMILY SUBJECT VEHICLE DATA (EARLIER MYS EXCLUDED).THE POPULATION NUMBER INCLUDES ALL MYS.THE PRECISE NUMBER OF DUPLICATES BETWEEN ODI AND DC REPORTS CANNOT BE DETERMINED DUE TO MISSING OR INCOMPLETE INFORMATION.THE FATALITY INCIDENT INVOLVED AN ELDERLY PERSON WHO ATTEMPTED TO STOP A ROLL AWAY VEHICLE AND RECEIVED FATAL INJURIES.ODI ALSO GATHERED INFORMATION ON MY 1997-99 PROWLER VEHICLES IN THIS INVESTIGATION. THE PROWLER VEHICLES WERE MANUFACTURED WITH A DIFFERENT DESIGN SHIFTER MECHANISM (THE SHIFT LEVER IS SHORTER).THERE ARE NO COMPLAINTS OF PROWLER INTERLOCK FAILURE IN ODI?S DATABASE, AND DC HAS RECEIVED NO REPORTS EITHER.THE PROWLER IS EXCLUDED FROM THE RECALL SCOPE.THE INVESTIGATION INVOLVED A CONDITION WHERE THE INTERLOCK SYSTEM COULD FAIL (OR BE MADE INOPERATIVE BY THE OPERATOR) DURING VEHICLE USE, POSSIBLY INADVERTENTLY.THE INTERLOCK SYSTEM IS REQUIRED UNDER FMVSS 114.WITH THE TRANSMISSION IN THE PARK POSITION AND THE IGNITION KEY OFF, THE COMBINED ACTION OF PRESSING THE SHIFT BUTTON AND PULLING THE SHIFT LEVER REARWARD MAY RESULT IN THE OPERATOR OVERCOMING THE INTERLOCK SYSTEM AND CAUSE THE MECHANICAL LINKAGE OF THE SYSTEM TO DISCONNECT.WHEN THIS OCCURS, THERE IS NO OVERT INDICATION TO AN OPERATOR THAT THE SYSTEM IS DEFEATED, AND AN INCREASED RISK OF VEHICLE ROLL-AWAY EXISTS.UNDER RECALL 04V021, DC WILL REPLACE DAMAGED SHIFT MECHANISMS, AND WILL INSTALL ON ALL VEHICLES A DEVICE WHICH INHIBITS THE OPERATOR?S ABILITY TO OVERCOME THE INTERLOCK AND DEFEAT THE SYSTEM.BEGINNING WITH MY 2000, DC INCORPORATED A BRAKE AND TRANSMISSION SHIFTER INTERLOCK (BTSI) SYSTEM INTO THE SUBJECT VEHICLES.INTRODUCTION OF BTSI INVOLVED DESIGN CHANGES TO THE SHIFT MECHANISM, ONE OF WHICH RESULTED IN REDUCED MECHANICAL ADVANTAGE (RMA) OF THE SHIFT BUTTON.THE RMA SHIFTER REQUIRES INCREASED FORCES TO OVERCOME THE INTERLOCK SYSTEM, MAKING THE SHIFTER LESS SUSCEPTIBLE TO DAMAGE.
Additional source detail variants (2)
Power Train:automatic Transmission
THE MANUFACTURER REPORTS ABOVE ARE BASED ON DAIMLERCHRYSLER?S (DC) ANALYSIS OF MODEL YEAR (MY) 1998 (POPULATION = 356,384) AND 1999 (POPULATION = 486,948) JA, JX AND LH FAMILY SUBJECT VEHICLE DATA (EARLIER MYS EXCLUDED).THE POPULATION NUMBER INCLUDES ALL MYS.THE PRECISE NUMBER OF DUPLICATES BETWEEN ODI AND DC REPORTS CANNOT BE DETERMINED DUE TO MISSING OR INCOMPLETE INFORMATION.THE FATALITY INCIDENT INVOLVED AN ELDERLY PERSON WHO ATTEMPTED TO STOP A ROLL AWAY VEHICLE AND RECEIVED FATAL INJURIES.ODI ALSO GATHERED INFORMATION ON MY 1997-99 PROWLER VEHICLES IN THIS INVESTIGATION. THE PROWLER VEHICLES WERE MANUFACTURED WITH A DIFFERENT DESIGN SHIFTER MECHANISM (THE SHIFT LEVER IS SHORTER).THERE ARE NO COMPLAINTS OF PROWLER INTERLOCK FAILURE IN ODI?S DATABASE, AND DC HAS RECEIVED NO REPORTS EITHER.THE PROWLER IS EXCLUDED FROM THE RECALL SCOPE.THE INVESTIGATION INVOLVED A CONDITION WHERE THE INTERLOCK SYSTEM COULD FAIL (OR BE MADE INOPERATIVE BY THE OPERATOR) DURING VEHICLE USE, POSSIBLY INADVERTENTLY.THE INTERLOCK SYSTEM IS REQUIRED UNDER FMVSS 114.WITH THE TRANSMISSION IN THE PARK POSITION AND THE IGNITION KEY OFF, THE COMBINED ACTION OF PRESSING THE SHIFT BUTTON AND PULLING THE SHIFT LEVER REARWARD MAY RESULT IN THE OPERATOR OVERCOMING THE INTERLOCK SYSTEM AND CAUSE THE MECHANICAL LINKAGE OF THE SYSTEM TO DISCONNECT.WHEN THIS OCCURS, THERE IS NO OVERT INDICATION TO AN OPERATOR THAT THE SYSTEM IS DEFEATED, AND AN INCREASED RISK OF VEHICLE ROLL-AWAY EXISTS.UNDER RECALL 04V021, DC WILL REPLACE DAMAGED SHIFT MECHANISMS, AND WILL INSTALL ON ALL VEHICLES A DEVICE WHICH INHIBITS THE OPERATOR?S ABILITY TO OVERCOME THE INTERLOCK AND DEFEAT THE SYSTEM.BEGINNING WITH MY 2000, DC INCORPORATED A BRAKE AND TRANSMISSION SHIFTER INTERLOCK (BTSI) SYSTEM INTO THE SUBJECT VEHICLES.INTRODUCTION OF BTSI INVOLVED DESIGN CHANGES TO THE SHIFT MECHANISM, ONE OF WHICH RESULTED IN REDUCED MECHANICAL ADVANTAGE (RMA) OF THE SHIFT BUTTON.THE RMA SHIFTER REQUIRES INCREASED FORCES TO OVERCOME THE INTERLOCK SYSTEM, MAKING THE SHIFTER LESS SUSCEPTIBLE TO DAMAGE.
Power Train:automatic Transmission:lever And Linkage:floor Shift
THE MANUFACTURER REPORTS ABOVE ARE BASED ON DAIMLERCHRYSLER?S (DC) ANALYSIS OF MODEL YEAR (MY) 1998 (POPULATION = 356,384) AND 1999 (POPULATION = 486,948) JA, JX AND LH FAMILY SUBJECT VEHICLE DATA (EARLIER MYS EXCLUDED).THE POPULATION NUMBER INCLUDES ALL MYS.THE PRECISE NUMBER OF DUPLICATES BETWEEN ODI AND DC REPORTS CANNOT BE DETERMINED DUE TO MISSING OR INCOMPLETE INFORMATION.THE FATALITY INCIDENT INVOLVED AN ELDERLY PERSON WHO ATTEMPTED TO STOP A ROLL AWAY VEHICLE AND RECEIVED FATAL INJURIES.ODI ALSO GATHERED INFORMATION ON MY 1997-99 PROWLER VEHICLES IN THIS INVESTIGATION. THE PROWLER VEHICLES WERE MANUFACTURED WITH A DIFFERENT DESIGN SHIFTER MECHANISM (THE SHIFT LEVER IS SHORTER).THERE ARE NO COMPLAINTS OF PROWLER INTERLOCK FAILURE IN ODI?S DATABASE, AND DC HAS RECEIVED NO REPORTS EITHER.THE PROWLER IS EXCLUDED FROM THE RECALL SCOPE.THE INVESTIGATION INVOLVED A CONDITION WHERE THE INTERLOCK SYSTEM COULD FAIL (OR BE MADE INOPERATIVE BY THE OPERATOR) DURING VEHICLE USE, POSSIBLY INADVERTENTLY.THE INTERLOCK SYSTEM IS REQUIRED UNDER FMVSS 114.WITH THE TRANSMISSION IN THE PARK POSITION AND THE IGNITION KEY OFF, THE COMBINED ACTION OF PRESSING THE SHIFT BUTTON AND PULLING THE SHIFT LEVER REARWARD MAY RESULT IN THE OPERATOR OVERCOMING THE INTERLOCK SYSTEM AND CAUSE THE MECHANICAL LINKAGE OF THE SYSTEM TO DISCONNECT.WHEN THIS OCCURS, THERE IS NO OVERT INDICATION TO AN OPERATOR THAT THE SYSTEM IS DEFEATED, AND AN INCREASED RISK OF VEHICLE ROLL-AWAY EXISTS.UNDER RECALL 04V021, DC WILL REPLACE DAMAGED SHIFT MECHANISMS, AND WILL INSTALL ON ALL VEHICLES A DEVICE WHICH INHIBITS THE OPERATOR?S ABILITY TO OVERCOME THE INTERLOCK AND DEFEAT THE SYSTEM.BEGINNING WITH MY 2000, DC INCORPORATED A BRAKE AND TRANSMISSION SHIFTER INTERLOCK (BTSI) SYSTEM INTO THE SUBJECT VEHICLES.INTRODUCTION OF BTSI INVOLVED DESIGN CHANGES TO THE SHIFT MECHANISM, ONE OF WHICH RESULTED IN REDUCED MECHANICAL ADVANTAGE (RMA) OF THE SHIFT BUTTON.THE RMA SHIFTER REQUIRES INCREASED FORCES TO OVERCOME THE INTERLOCK SYSTEM, MAKING THE SHIFTER LESS SUSCEPTIBLE TO DAMAGE.
PE02082 · Safety Belt Cinching Latch Plate
Opened Nov 6, 2002 · Closed Apr 23, 2003
Status: closed (inferred from source dates) · Seat Belts
THERE ARE NO INJURIES OR FATALITIES ASSOCIATED WITH THIS ALLEGED DEFECT.WHILE CONDUCTING THIS INVESTIGATION, ODI FOUND THAT THE SUBJECT CINCHES MEET THE LOAD BEARING REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD 208, AND THAT MANY OF THE REPORTED FAILURES WERE DUE TO INCORRECT CHILD SAFETY SEAT INSTALLATIONS. ADDITIONALLY, THE REPORT RATE IS LOW (1.60/100K).THE INFORMATION AVAILABLE FAILS TO ESTABLISH THE EXISTENCE OF A DEFECT TREND AT THIS TIME.FURTHER ALLOCATION OF AGENCY RESOURCES TO THIS ISSUE IS UNWARRANTED AND THE PRELIMINARY EVALUATION IS BEING CLOSED.
EA97016 · Lower Control Arm Ball Joint Failure
Opened Sep 29, 1997 · Closed Nov 20, 1997
Status: closed (inferred from source dates) · Suspension
BY LETTER DATED NOVEMBER 6, 1997, THE MANUFACTURER ADVISED THIS AGENCY OF ITS DECISION TO INITIATE A SAFETY RECALL CAMPAIGN OF THE SUBJECT VEHICLES TO CORRECT THE DEFECT IDENTIFIED IN THIS EA.THE RECALL WILL ALSO COVER 1996 AND 1997 CHRYSLER CIRRUS/DODGE STRATUS VEHICLES, AS WELL AS 1995 THROUGH 1997 CHRYSLER SEBRING CONVERTIBLE AND PLYMOUTH BREEZE VEHICLES EQUIPPED WITH IDENTICAL LOWER CONTROL ARM BALL JOINTS.AN ESTIMATED TOTAL OF 599,00VEHICLES ARE AFFECTED BY THIS RECALL.THE MANUFACTURER'S INVESTIGATION DISCLOSED THAT PROCESS VARIABILITY, TOGETHER WITH THE BALL JOINT HOUSING COVER CRIMPING OPERATION, CAN RESULT IN AN INEFFECTIVE SEAL THAT PERMITS A LOSS OF LUBRICATION AND ACCELERTED WEAR OF THE BALL JOINT ASSEMBLY.THIS CONDITION CAN LEAD TO FAILURE AND SEPARTION OF THE LOWER CONTROL ARM BALL JOINT.THE RECALL IS IDENTIFIED AS NHTSA 97V-201 AND A COPY OF CHRYSLER'S LETTER TO NHTSA IS ATTACHED HERETO.
1997 Dodge Stratus Problems, Complaints & Recalls | Skip That Year
Illustration