Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 29 of 483 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Service Brakes, Hydraulic. Review the 107 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 80 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Air Bags. Review the 66 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
79 crash reports6 fire reports39 injury reports
What owners actually said
483 reports
Mileage unknown · Jan 28, 1999
Engine And Engine CoolingSuspension
THE DEFECT IS IN THE ALIGNMENT OF THE TRUCK AND THE ENGINE. WITH THE ALIGNMENT SET TO MANUFACTURER'S SPECIFICATIONS THE TRUCK STILL PULLS OUT OF THE DRIVING LANE. WITHIN TEN SECONDS THE TRUCK WILL COMPLETELY VACATE THE LANE. THE SECOND PROBLEM IS THE ENGINE HAS A "STUMBLE" OR MISS-FIRE AT IDLE. AGAIN THE MANUFACTURES STATES THE …
Read full complaint
THE DEFECT IS IN THE ALIGNMENT OF THE TRUCK AND THE ENGINE. WITH THE ALIGNMENT SET TO MANUFACTURER'S SPECIFICATIONS THE TRUCK STILL PULLS OUT OF THE DRIVING LANE. WITHIN TEN SECONDS THE TRUCK WILL COMPLETELY VACATE THE LANE. THE SECOND PROBLEM IS THE ENGINE HAS A "STUMBLE" OR MISS-FIRE AT IDLE. AGAIN THE MANUFACTURES STATES THE ENGINE IS ALSO WITHIN GUIDELINES. THE DEALER CLAIMS THERE IS AN INDUSTRY STANDARD FOR ALIGNMENT, BUT PROVIDES NO WRITTEN DOCUMENTATION ON WHAT THE STANDARDS ARE OR WHAT THE MANUFACTURER'S ACCEPTABLE TOLERANCES ARE SPECIFICALLY. DO YOU HAVE ANYTHING WHICH INDICATES ALIGNMENT STANDARDS AND ENGINE TIMING.
NHTSA ODI #702687
Mileage unknown · Jan 16, 1999
Electrical System
HORN IS ALMOST IMPOSSIBLE TO BLOW, YOU HAVE TO TAKE EYES OFF THE ROAD TO FIND HORN BUTTON
NHTSA ODI #702283
Mileage unknown · Jan 16, 1999
Electrical System
HORN IS EXTREMELY HARD TO BLOW. ECCESSIVE PRESSURE REQUIRED. ESTIMATED 25 - 30 POUNDS.
NHTSA ODI #702281
Mileage unknown · Jan 15, 1999
Electrical System
THE HORN ON THE DODGE RAM P/U IS ALMOST IMPOSSIBLE TO ENGAGE OR SOUND. A PERSON HAS TO PUSH THROUGH THE AIRBAG TO MAKE THE HORN SOUND. I HAVE HAD SEVERAL PEOPLE WHO HAVE COMPLAINED ABOUT THIS AND HAVE SEEN THE PROBLEM IN SEVERAL VEHICLES. ANY HELP YOU CAN GET DODGE TO DO IN REPLACING THE HORN WOULD BE APPRECIATED.
NHTSA ODI #702243
Mileage unknown · Jan 12, 1999
Service Brakes, Hydraulic
EXPERIENCING ONGOING PROBLEM WITH FRONT BRAKE PADS WEARING OUT PREMATURELY. VEHICLE HAD FOUR SETS OF BRAKE PADS WITHIN 30,000 MILE OF WEAR. DEALER NOTIFIED . *AK
NHTSA ODI #833424
Mileage unknown · Jan 7, 1999
Service Brakes, Hydraulic
THE TRUCK PULLS TO THE RIGHT ALL THE TIME, BUT VERY SEVERE WHEN BRAKING.
NHTSA ODI #701986
Mileage unknown · Jan 6, 1999
SuspensionVisibility
REAR SUSPENSION CLUNKS ON TURNS WITH LIGTH/NO LOAD IN BED. SOUNDS LIKE THE GAS TANK SHIFTING SIDE TO SIDE OR SPRING PACK NOISE. OTHER OWNER'S I'VE TALKED TOO HAVE SAME PROBLEM. THE REAR SLIDING GLASS WINDOW LEAKS AT THE TOP AT HIGHWAY SPEEDS IN HEAVY RAIN. THE TWO TONE PAINT IS FADING. YOU CAN SEE THE BOTTOM COLOR THROUGH THE TO…
Read full complaint
REAR SUSPENSION CLUNKS ON TURNS WITH LIGTH/NO LOAD IN BED. SOUNDS LIKE THE GAS TANK SHIFTING SIDE TO SIDE OR SPRING PACK NOISE. OTHER OWNER'S I'VE TALKED TOO HAVE SAME PROBLEM. THE REAR SLIDING GLASS WINDOW LEAKS AT THE TOP AT HIGHWAY SPEEDS IN HEAVY RAIN. THE TWO TONE PAINT IS FADING. YOU CAN SEE THE BOTTOM COLOR THROUGH THE TOP COLOR. ALSO, I'VE HEAR FROM SEVERAL OTHER OWNERS ABOUT PREMATURE FRONT BALL JOINT FAILURES ALTHOUGH I HAVEN'T HAD THIS PROBLEM YET.
NHTSA ODI #701957
Mileage unknown · Jan 5, 1999
Service Brakes, Hydraulic
WHILE DRIVING AT NORMAL HIGHWAY SPEEDS AND THE BRAKES ARE APPLIED THE VEHICLE PULLS VERY HARD TO EITHER THE LEFT OR THE RIGHT, CAUSING THE VEHICLE TO GO INTO OTHER LANES. DEALER HAS BEEN CONTACTED. *AK
NHTSA ODI #833056
Mileage unknown · Jan 5, 1999
Service Brakes, HydraulicCrashInjury
WHILE DRIVING ABOUT 5 TO 10 MPH AND COMING TO A STOP THE BRAKE PEDAL WENT DOWN TO THE FLOOR, VEHICLE DID NOT STOP. DEALER AND MANUFACTURER HAVE BEEN NOTIFIED. *AK *ML
NHTSA ODI #828672
Mileage unknown · Jan 5, 1999
Seat Belts
WHEN SYSTEM FAILED, WE WERE UNABLE TO PUT SEAT BELTS ON DUE TO COMPUTERS LOSS OF PROGRAMING. THIS IS NOT ONLY UNSAFE, BUT ILLEGAL IN THIS STATE AND MANY OTHERS.THERE SOULD BE A DEFAULT TO A MECHANICAL LOCKING SYSTEM, NOT JUST GO INOP. AND LEAVE US IN A VERY UNSAFE SITUATION. *AK
ON CERTAIN VAN AND WAGON VEHICLES EQUIPPED WITH 4-WHEEL ANTILOCK BRAKE SYSTEMS (ABS), AFTERMARKET BATTERIES MAY LEAK ELECTROLYTE ONTO THE ABS CONTROL MODULE CONNECTOR, WHICH CAN COMPROMISE SEALING INTEGRITY OF THE CONNECTOR.
Consequence & remedy
Consequence: THIS MAY ALLOW DEVELOPMENT OF A SHORT CIRCUIT IN THE CONNECTOR, WHICH COULD EVENTUALLY LEAD TO A FIRE.
Remedy: DEALERS WILL INSPECT THE ABS CONTROL MODULE CONNECTOR FOR ELECTROLYTE DAMAGE AND REPLACE THE CONNECTOR AS NECESSARY. THE RECALL WILL BEGIN ON SEPTEMBER 27, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
ON CERTAIN PICKUP TRUCKS EQUIPPED WITH DIESEL ENGINES ONLY, THE THROTTLE LINKAGE JOINTS CAN CORRODE AND CAUSE THE THROTTLE TO BIND OR STICK.
Consequence & remedy
Consequence: THIS COULD POTENTIALLY RESULT IN A LOSS OF THROTTLE CONTROL, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ROD ENDS AND BALL STUDS. OWNER NOTIFICATION BEGAN JULY 29, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
VEHICLE DESCRIPTION: PICKUP TRUCKS. SOUND DEADENER MATERIAL INSIDE THE STEERING WHEEL COULD BECOME DETACHED FROM THE COVER AND HOUSING. NOTE: THE RAM PICKUP TRUCKS WERE BUILT AT THE WARREN ASSEMBLY PLANT ("S" IN THE 11TH VIN POSITION) FROM MAY 16, 2000 THROUGH OCTOBER 23, 2000; ST. LOUIS NORTH ASSEMBLY PLANT ("J" IN THE 11TH VIN POSITION) FROM MAY 19, 2000 THROUGH OCTOBER 23, 2000; LAGO ALBERTO ASSEMBLY PLANT ("M" IN THE 11TH VIN POSITION) FROM MAY 23, 2000 THROUGH OCTOBER 23, 2000; AND SALTILLO ASSEMBLY PLANT ("G" IN THE 11TH VIN POSITION) FROM MAY 23, 2000 THROUGH OCTOBER 23, 2000. IMPORTANT: VEHICLES THAT HAVE ALREADY HAD THE PROPER CLOCKSPRING INSTALLED, ACCORDING TO WARRANTY RECORDS, HAVE BEEN EXCLUDED FROM THIS RECALL. IN ADDITION, 1997-2000 MODEL YEAR VEHICLES THAT HAVE HAD A SUSPECT REPLACEMENT CLOCKSPRING INSTALLED, ACCORDING TO WARRANTY RECORDS, HAVE BEEN ADDED TO THIS RECALL.
Consequence & remedy
Consequence: WHEN THIS OCCURS, THE MATERIAL COULD INTERFERE WITH THE CLOCKSPRING RIBBON AND CAUSE AN OPEN CIRCUIT. THE DRIVER AIR BAG SYSTEM WILL BECOME DISABLED, AND THE AIR BAG WARNING LAMP WILL ILLUMINATE ON THE INSTRUMENT PANEL.
Remedy: DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY. OWNER NOTIFICATION BEGAN JUNE 18, 2001. ALSO SOME 1997-200 MODEL YEAR VEHICLES THAT, ACCORDING TO WARRANTY RECORDS, HAVE HAD A SUSPECT REPLACEMENT CLOCKSPRING INSTALLED, WILL ALSO BE INCLUDED IN THIS CAMPAIGN. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
ON CERTAIN PICKUP TRUCKS ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE FOLLOWING "SALT BELT" STATES: MAINE, NEW HAMPSHIRE, VERMONT, MASSACHUSETTS, RHODE ISLAND, CONNECTICUT, NEW YORK, NEW JERSEY, PENNSYLVANIA, DELAWARE, MARYLAND, THE DISTRICT OF COLUMBIA, WEST VIRGINIA, OHIO, INDIANA, MICHIGAN, ILLINOIS, WISCONSIN, MINNESOTA, IOWA, AND MISSOURI. CORROSION OF THE RETURN SPRING ON THE HOOD SECONDARY LATCH COULD CAUSE THE MECHANISM TO BIND IN THE "RELEASE POSITION."
Consequence & remedy
Consequence: IF THE PRIMARY LATCH IS NOT ENGAGED, THE HOOD COULD OPEN UNEXPECTEDLY.
Remedy: DEALERS WILL REPLACE THE SECONDARY HOOD LATCH. OWNER NOTIFICATION BEGAN SEPTEMBER 17, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
VEHICLE DESCRIPTION: PICKUP TRUCKS EQUIPPED WITH OPTIONAL TRAILER HITCH. THE TRAILER HITCH SIDE BRACKETS WERE MANUFACTURED USING MATERIAL WITH INSUFFICIENT STRENGTH.
Consequence & remedy
Consequence: BRACKETS BUILT WITHOUT PROPER MATERIAL COULD FATIGUE AND FRACTURE IN THE AREA WHERE THE TRAILER HITCH MOUNTS TO THE FRAME.
Remedy: DEALERS WILL INSPECT THE TRAILER HITCHES AND REPLACE ANY TRAILER HITCH SHOWING SIGNS OF FATIGUE CRACKING. IF NO EVIDENCE OF CRACKING EXISTS, THE DEALER WILL INSTALL TWO REINFORCEMENT BRACKETS.
VEHICLE DESCRIPTION: PICKUP TRUCKS EQUIPPED WITH MANUAL TRANSMISSION, V10 ENGINES AND FOUR-WHEEL-DRIVE TRANSFER CASES. UNDER SUSTAINED MAXIMUM RATED VEHICLE LOAD, WHILE DRIVING UP A STEEP GRADE IN FOUR-WHEEL-DRIVE LOW RANGE IN HOT AMBIENT CONDITIONS, THE LOCAL EXHAUST TEMPERATURE PROXIMATE TO THE HYDRAULIC CLUTCH LINE CAN GENERATE LINE TEMPERATURES THAT EXCEED THE TEMPERATURE LIMIT OF THE CLUTCH LINE MATERIAL. IF THIS CONDITION OCCURS AND THE CLUTCH IS DEPRESSED, THE LINE COULD RUPTURE.
Consequence & remedy
Consequence: THE FLUID COULD IGNITE ON THE HOT EXHAUST POSSIBLY RESULTING IN A VEHICLE FIRE.
Remedy: DEALERS WILL REPLACE THE HYDRAULIC CLUTCH ASSEMBLY.
VEHICLE DESCRIPTION: VANS AND VANS USED FOR CONVERSION. IF A HEAVY OBJECT IMPACTS THE METAL CASING OF THE AIR BAG ELECTRONIC CONTROL MODULE (AECM), LOCATED UNDER THE DRIVER SEAT, THE MODULE COULD INADVERTENTLY DEPLOY THE AIR BAGS.
Consequence & remedy
Consequence: UNEXPECTED AIR BAG DEPLOYMENT CAN RESULT IN OCCUPANT INJURY.
Remedy: DEALERS WILL REPLACE THE AECM WITH A MODULE THAT INCORPORATES REVISED HARDWARE AND SOFTWARE ON ALL AFFECTED VEHICLES.
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS EQUIPPED WITH 5.9L - 24 VALVE DIESEL ENGINE. THE LOW PRESSURE DIESEL FUEL SUPPLY TUBE LOCATED IN THE ENGINE COMPARTMENT BETWEEN THE FILTER AND THE HIGH PRESSURE PUMP CAN FRACTURE.
Consequence & remedy
Consequence: THIS CONDITION CAN ALLOW FUEL TO LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, FUEL LEAKAGE CAN RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE LOW PRESSURE DIESEL FUEL SUPPLY TUBE.
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS. THESE VEHICLES MAY HAVE BEEN BUILT WITH BOLTS THAT WERE NOT PROPERLY HARDENED. THE BOLTS WERE USED TO ATTACH THE CAB AND THE CORE SUPPORT TO THE FRAME.
Consequence & remedy
Consequence: THIS CONDITION CAN ALLOW THE CAB TO SEPARATE FROM THE FRAME INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THESE BOLTS WITH PROPERLY HARDENED BOLTS.
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS EQUIPPED WITH 5.9L - 24 VALVE DIESEL ENGINE. AN INTERMITTENT HIGH ENGINE IDLE CONDITION CAN OCCUR DUE TO A MALFUNCTION OF THE VEHICLE SPEED SENSOR.
Consequence & remedy
Consequence: THIS CREATES A SIGNAL WHICH IS MISINTERPRETED BY THE ENGINE CONTROL SOFTWARE, CAUSING A HIGH IDLE SPEED CONDITION.
Remedy: DEALERS WILL REPLACE THE ENGINE CONTROLLER SOFTWARE TO CORRECT ERRONEOUS SPEED SENSOR SIGNALS.
VEHICLE DESCRIPTION: LIGHT DUTY TRUCKS EQUIPPED WITH EITHER A 8.0L V-10 ENGINE OR A 5.9L V-8 HEAVY DUTY GASOLINE ENGINE. AN EXHAUST SYSTEM HEAT SHIELD ATTACHING SCREW IS TOO CLOSE TO THE UNDERBODY FUEL LINE. THE LINE CAN RUB AGAINST THE SCREW, POSSIBLY CAUSING FUEL LEAKAGE.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
Remedy: DEALERS WILL REMOVE THE UNDERBODY HEAT SHIELD ATTACHING SCREW AND REPLACE IT WITH RUBBER ADHESIVE. THE CHASSIS FUEL LINE WILL BE INSPECTED FOR SIGNS OF WEAR AND ANY TUBES INDICATING WEAR WILL BE REPLACED.
Illustration