I DROVE MY 2000 DODGE 3500 CUMMINS DIESEL WITH 85000 MILES TO WORK AND TURNED IT OFF, WHEN I CAME BACK IT WOULD NOT START. CHRYSLER REFUSED TO HELP. I THEN HAD THE VP44 INJECTOR PUMP REPLACE AT A COST OF $1550.00 TO ME . EXPRESSWAY DODGE TOLD ME THAT THE ENGINE WAS STILL UNDER WARRANTY BY CUMMINS BUT THE PUMP WAS NOT COVERED BY …
Read full complaint
I DROVE MY 2000 DODGE 3500 CUMMINS DIESEL WITH 85000 MILES TO WORK AND TURNED IT OFF, WHEN I CAME BACK IT WOULD NOT START. CHRYSLER REFUSED TO HELP. I THEN HAD THE VP44 INJECTOR PUMP REPLACE AT A COST OF $1550.00 TO ME . EXPRESSWAY DODGE TOLD ME THAT THE ENGINE WAS STILL UNDER WARRANTY BY CUMMINS BUT THE PUMP WAS NOT COVERED BY CHRYSLER.
NHTSA ODI #10134219
44,000 miles · Jun 19, 2003
Fuel System, Diesel
MY COMPLAINT CONCERNS MY VEHICLE AND SEVERAL THOUSAND OTHERS THAT BELONG TO MEMBERS OF THE TURBO DIESEL REGISTER. THE REASON IM WRITING IS IN HOPES THAT WE CAN GET A SAFETY ISSUE ADDRESSED, AND CORRECTED ONCE AND FOR ALL. THERE HAS BEEN A REPEATED TREND OVER SEVERAL YEARS NOW CONCERNING THE LIFT PUMP (FUEL TRANSFER PUMP) UTILIZ…
Read full complaint
MY COMPLAINT CONCERNS MY VEHICLE AND SEVERAL THOUSAND OTHERS THAT BELONG TO MEMBERS OF THE TURBO DIESEL REGISTER. THE REASON IM WRITING IS IN HOPES THAT WE CAN GET A SAFETY ISSUE ADDRESSED, AND CORRECTED ONCE AND FOR ALL. THERE HAS BEEN A REPEATED TREND OVER SEVERAL YEARS NOW CONCERNING THE LIFT PUMP (FUEL TRANSFER PUMP) UTILIZED IN THE 2500/3500 CUMMINS DIESEL APPLICATION. I AM A MEMBER OF THE FAILED LIFT PUMP CLUB AND HAVE EXPERIENCED THIS LIFT PUMP FAILURE ON MY 2000 3500 DODGE CTD. THIS FAILURE CAUSES THE TRUCK TO LOOSE POWER AND SOMETIMES DIE. THIS CAN BE LIFE THREATENING IF THE TRUCK OWNER IS ON THE HIGHWAY TOWING A LOADED TRAILER. I HOW OWN A 2002 3500 CTD AND WOULD LIKE THIS DESIGN PROBLEM CORRECTED. I AM NOT ALONE IN THIS CONCERN, THERE ARE THOUSANDS OF 1998.5 - 2002, 24 VALVE CUMMINS TURBO DIESEL OWNERS THAT ARE CONCERNED AND HAVE COMPLAINED TO DODGE ABOUT THIS PROBLEM WITH NO RESOLUTION. THIS CAN BE DOCUMENTED BY GOING TO THE TURBO DIESEL REGISTER ON THE WEB. HTTP://WWW.TURBODIESELREGISTER.COM/FORUMS/SHOWTHREAD.PHP?S=&THREADID=75368&PERPAGE=15&PAGENUMBER=2. *NLM
VEHICLE DESCRIPTION: PICKUP TRUCKS. SOUND DEADENER MATERIAL INSIDE THE STEERING WHEEL COULD BECOME DETACHED FROM THE COVER AND HOUSING. NOTE: THE RAM PICKUP TRUCKS WERE BUILT AT THE WARREN ASSEMBLY PLANT ("S" IN THE 11TH VIN POSITION) FROM MAY 16, 2000 THROUGH OCTOBER 23, 2000; ST. LOUIS NORTH ASSEMBLY PLANT ("J" IN THE 11TH VIN POSITION) FROM MAY 19, 2000 THROUGH OCTOBER 23, 2000; LAGO ALBERTO ASSEMBLY PLANT ("M" IN THE 11TH VIN POSITION) FROM MAY 23, 2000 THROUGH OCTOBER 23, 2000; AND SALTILLO ASSEMBLY PLANT ("G" IN THE 11TH VIN POSITION) FROM MAY 23, 2000 THROUGH OCTOBER 23, 2000. IMPORTANT: VEHICLES THAT HAVE ALREADY HAD THE PROPER CLOCKSPRING INSTALLED, ACCORDING TO WARRANTY RECORDS, HAVE BEEN EXCLUDED FROM THIS RECALL. IN ADDITION, 1997-2000 MODEL YEAR VEHICLES THAT HAVE HAD A SUSPECT REPLACEMENT CLOCKSPRING INSTALLED, ACCORDING TO WARRANTY RECORDS, HAVE BEEN ADDED TO THIS RECALL.
Consequence & remedy
Consequence: WHEN THIS OCCURS, THE MATERIAL COULD INTERFERE WITH THE CLOCKSPRING RIBBON AND CAUSE AN OPEN CIRCUIT. THE DRIVER AIR BAG SYSTEM WILL BECOME DISABLED, AND THE AIR BAG WARNING LAMP WILL ILLUMINATE ON THE INSTRUMENT PANEL.
Remedy: DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY. OWNER NOTIFICATION BEGAN JUNE 18, 2001. ALSO SOME 1997-200 MODEL YEAR VEHICLES THAT, ACCORDING TO WARRANTY RECORDS, HAVE HAD A SUSPECT REPLACEMENT CLOCKSPRING INSTALLED, WILL ALSO BE INCLUDED IN THIS CAMPAIGN. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
PE08047 · 2000-2001 Dodge RAM Pickup Hood Latch
Opened Jul 25, 2008 · Closed Dec 17, 2008
Status: closed (inferred from source dates) · Latches/locks/linkages:hood:latch; Structure:body:hood:hinge And Attachments
THE AGENCY OPENED THIS INVESTIGATION BASED ON 30 COMPLAINTS ALLEGING THAT THE HOODS ON MODEL YEAR (MY) 2000 AND 2001 DODGE RAM PICKUP TRUCKS FLEW UP AND BLOCKED THE DRIVER'S VISION.THESE VEHICLES HAVE A PRIMARY HOOD LATCH AND A SECONDARY (BACKUP) HOOD LATCH.THE SECONDARY LATCH IS DESIGNED TO SECURE THE HOOD IF THE PRIMARY HOOD LATCH IS NOT PROPERLY CLOSED OR OTHERWISE MALFUNCTIONS.IN THESE COMPLAINTS, THE SECONDARY HOOD LATCH MALFUNCTIONED, APPARENTLY DUE TO CORROSION, AND DID NOT LATCH.DODGE CONDUCTED RECALL 01V-040 IN 1999 TO ADDRESS SIMILAR PROBLEMS ON MODEL YEAR 1994-1997 DODGE RAM PICKUP TRUCKS.THE INFORMATION CHRYSLER PROVIDED IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER INDICATED THAT THE MY 2000 AND 2001 VEHICLES WERE EQUIPPED WITH SECONDARY HOOD LATCHES WITH STAINLESS STEEL RETURN SPRINGS, AS OPPOSED TO THE EARLIER RECALLED TRUCKS THAT HAD ZINC COATED CARBON STEEL RETURN SPRINGS.THE RECALLED COMPONENTS WERE SUSCEPTIBLE TO CORROSION-INDUCED FAILURE DUE TO THE TYPE OF MATERIAL USED, WHEREAS THE CORROSION FAILURES IN THE NEWER MODELS APPEAR TO BE DUE TO LUBRICATION LOSS OVER TIME (REGULAR APPLICATION OF GREASE IS ADVISED PER INSTRUCTIONS IN THE OWNERS' MANUAL). ODI'S REVIEW OF CHRYSLER'S WARRANTY, COMPLAINT, AND INJURY DATA FOR THE 2000 AND 2001 VEHICLES INDICATES THAT THE RATES FOR SUBJECT VEHICLES ARE LOW AND ARE DECLINING.A POTENTIAL DEFECT TREND HAS NOT BEEN IDENTIFIED.THIS INVESTIGATION IS CLOSED.
Additional source detail variants (2)
Latches/locks/linkages:hood:latch
THE AGENCY OPENED THIS INVESTIGATION BASED ON 30 COMPLAINTS ALLEGING THAT THE HOODS ON MODEL YEAR (MY) 2000 AND 2001 DODGE RAM PICKUP TRUCKS FLEW UP AND BLOCKED THE DRIVER'S VISION.THESE VEHICLES HAVE A PRIMARY HOOD LATCH AND A SECONDARY (BACKUP) HOOD LATCH.THE SECONDARY LATCH IS DESIGNED TO SECURE THE HOOD IF THE PRIMARY HOOD LATCH IS NOT PROPERLY CLOSED OR OTHERWISE MALFUNCTIONS.IN THESE COMPLAINTS, THE SECONDARY HOOD LATCH MALFUNCTIONED, APPARENTLY DUE TO CORROSION, AND DID NOT LATCH.DODGE CONDUCTED RECALL 01V-040 IN 1999 TO ADDRESS SIMILAR PROBLEMS ON MODEL YEAR 1994-1997 DODGE RAM PICKUP TRUCKS.THE INFORMATION CHRYSLER PROVIDED IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER INDICATED THAT THE MY 2000 AND 2001 VEHICLES WERE EQUIPPED WITH SECONDARY HOOD LATCHES WITH STAINLESS STEEL RETURN SPRINGS, AS OPPOSED TO THE EARLIER RECALLED TRUCKS THAT HAD ZINC COATED CARBON STEEL RETURN SPRINGS.THE RECALLED COMPONENTS WERE SUSCEPTIBLE TO CORROSION-INDUCED FAILURE DUE TO THE TYPE OF MATERIAL USED, WHEREAS THE CORROSION FAILURES IN THE NEWER MODELS APPEAR TO BE DUE TO LUBRICATION LOSS OVER TIME (REGULAR APPLICATION OF GREASE IS ADVISED PER INSTRUCTIONS IN THE OWNERS' MANUAL). ODI'S REVIEW OF CHRYSLER'S WARRANTY, COMPLAINT, AND INJURY DATA FOR THE 2000 AND 2001 VEHICLES INDICATES THAT THE RATES FOR SUBJECT VEHICLES ARE LOW AND ARE DECLINING.A POTENTIAL DEFECT TREND HAS NOT BEEN IDENTIFIED.THIS INVESTIGATION IS CLOSED.
Structure:body:hood:hinge And Attachments
THE AGENCY OPENED THIS INVESTIGATION BASED ON 30 COMPLAINTS ALLEGING THAT THE HOODS ON MODEL YEAR (MY) 2000 AND 2001 DODGE RAM PICKUP TRUCKS FLEW UP AND BLOCKED THE DRIVER'S VISION.THESE VEHICLES HAVE A PRIMARY HOOD LATCH AND A SECONDARY (BACKUP) HOOD LATCH.THE SECONDARY LATCH IS DESIGNED TO SECURE THE HOOD IF THE PRIMARY HOOD LATCH IS NOT PROPERLY CLOSED OR OTHERWISE MALFUNCTIONS.IN THESE COMPLAINTS, THE SECONDARY HOOD LATCH MALFUNCTIONED, APPARENTLY DUE TO CORROSION, AND DID NOT LATCH.DODGE CONDUCTED RECALL 01V-040 IN 1999 TO ADDRESS SIMILAR PROBLEMS ON MODEL YEAR 1994-1997 DODGE RAM PICKUP TRUCKS.THE INFORMATION CHRYSLER PROVIDED IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER INDICATED THAT THE MY 2000 AND 2001 VEHICLES WERE EQUIPPED WITH SECONDARY HOOD LATCHES WITH STAINLESS STEEL RETURN SPRINGS, AS OPPOSED TO THE EARLIER RECALLED TRUCKS THAT HAD ZINC COATED CARBON STEEL RETURN SPRINGS.THE RECALLED COMPONENTS WERE SUSCEPTIBLE TO CORROSION-INDUCED FAILURE DUE TO THE TYPE OF MATERIAL USED, WHEREAS THE CORROSION FAILURES IN THE NEWER MODELS APPEAR TO BE DUE TO LUBRICATION LOSS OVER TIME (REGULAR APPLICATION OF GREASE IS ADVISED PER INSTRUCTIONS IN THE OWNERS' MANUAL). ODI'S REVIEW OF CHRYSLER'S WARRANTY, COMPLAINT, AND INJURY DATA FOR THE 2000 AND 2001 VEHICLES INDICATES THAT THE RATES FOR SUBJECT VEHICLES ARE LOW AND ARE DECLINING.A POTENTIAL DEFECT TREND HAS NOT BEEN IDENTIFIED.THIS INVESTIGATION IS CLOSED.
PE02049 · Tire Valve
Opened Jun 3, 2002 · Closed Oct 1, 2002
Status: closed (inferred from source dates) · Tires
No summary supplied.
2000 Dodge RAM 3500 Problems, Complaints & Recalls | Skip That Year
Illustration