IllustrationDASH IS ALL CRACKED UP ALLOWING SHARP PLASTIC PROJECTILES IN AND ABOUT THE CAB THAT CAN CUT YOU IN A WRECK SUN GETTING ON ELECTRICAL WIRES DESTROYING THEM AND NOW SHORTS AND SOMETIMES DONT WORK RIGHT
1996 Dodge RAM 3500
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 1996 Dodge RAM 3500 do not stand out strongly from the model-year median of 124.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all RAM 3500 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 23 of 124 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 36 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 19 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 16 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
5 crash reports10 fire reports3 injury reports
Electrical System complaints
10 reportsTL* THE CONTACT OWNS A 1996 DODGE RAM 3500. THE CONTACT STATED THAT WHILE PARKED, A THERMAL EVENT STARTED IN THE VEHICLE. UPON INSPECTION, IT WAS FOUND THAT THE FIRE ORIGINATED IN THE INSTRUMENT PANEL ABOVE THE HEADLIGHT SWITCH. THE CONTACT ALSO STATED THAT THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER NHTSA CAMPAIGN ID NUMBER: 99V…
Read full complaint
TL* THE CONTACT OWNS A 1996 DODGE RAM 3500. THE CONTACT STATED THAT WHILE PARKED, A THERMAL EVENT STARTED IN THE VEHICLE. UPON INSPECTION, IT WAS FOUND THAT THE FIRE ORIGINATED IN THE INSTRUMENT PANEL ABOVE THE HEADLIGHT SWITCH. THE CONTACT ALSO STATED THAT THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER NHTSA CAMPAIGN ID NUMBER: 99V024000 (EXTERIOR LIGHTING:HEADLIGHTS:SWITCH). THE MANUFACTURER WAS CONTACTED AND STATED THAT AN INVESTIGATOR WILL INSPECT THE VEHICLE. THE VEHICLE WAS DESTROYED. THE APPROXIMATE FAILURE MILEAGE WAS 170,000.
FIRE IN ENGINE AREA,,,,,FUEL PRE-HEATER CATCHES FIRE IN THE WIRING BECAUSE OF BAD SEAL ON ELECTRICAL CONNECTORS THAT ALLOW RUST TO FORM IN TRUCKS IN SNOW AND SALT COUNTRY...LUCKILY I WAS GETTING HOME AND STEPPING OUT OF THE TRUCK WHEN I SPOTTED THE FIRE,,,,IF NOT THE TRUCK WOULD HAVE BURN TO THE GROUND DURING THE NIGHT,,,OR I CO…
Read full complaint
FIRE IN ENGINE AREA,,,,,FUEL PRE-HEATER CATCHES FIRE IN THE WIRING BECAUSE OF BAD SEAL ON ELECTRICAL CONNECTORS THAT ALLOW RUST TO FORM IN TRUCKS IN SNOW AND SALT COUNTRY...LUCKILY I WAS GETTING HOME AND STEPPING OUT OF THE TRUCK WHEN I SPOTTED THE FIRE,,,,IF NOT THE TRUCK WOULD HAVE BURN TO THE GROUND DURING THE NIGHT,,,OR I COULD HAVE BEEN ASLEEP AT A TRUCK STOP AS I OFTEN DO WHEN I AM ON THE ROAD TO THE RACES...ACCORDING TO FELLOW MEMBERS OF THE TURBO DIESEL REGISTER (WE SUPPLIED ALL THE INFO AND DAMAGED PARTS TO YOUR ORGANIZATION LAST YEAR CONCERNING THE THROTTLE CABLE PROBLEM)),,,THIS FUEL HEATER FIRE IS A VERY COMMON OCCURRENCE IN THESE 94 TO 97 TRUCKS WITH THE CUMMINS DIESEL ENGINE.. HOW DOES CHRYSLER GET AWAY WITH ALL THESE SAFETY ISSUES. THIS COULD VERY EASILY CAUSE DEATH IF NOT ADDRESSED.. THANKS FOR YOUR TIME.. *NLM
SMOKE WAS COMING FROM INSIDE OF VEHICLE THROUGH VENT PANEL AREA. HE WAS ABLE TO PULL OVER TO SHOULDERS. FIRE DEPARTMENT WAS CALLED OUT.*AK
CONSUMER PULLED OVER TO SHOULDER 0FF ROAD AND LEFT VEHICLE RUNNING TO ASSIST ANOTHER MOTORIST. WHEN HE RETURNED TO VEHICLE, THERE WAS SMOKE INSIDE COMING FROM UNDERNEATH DASHBOARD. VEHICLE WAS TOWED TO DEALERSHIP. MECHANIC TOLD HIM THAT HEADLIGHT SWITCH NEEDED TO BE REPLACED. *AK
TRUCK BURNED APROXIMATELY 45 MINUTES AFTER SHUTTING DOWN IN MY DRIVEWAY. CHRYSLER IS SENDING ME RECALL NOTICES THAT ARE ANYWHERE FROM 1 1/2 YRS OLD TO 6 WEEKS BEFORE THE FIRE, AND THEY ARE COMING IN THE MAIL NOW, ALMOST 4 MONTHS AFTER THE FIRE. CHRYSLER WILL NOT ADMIT RESPONSIBILITY FOR THE FIRE, EVEN WHILE SENDING ME RECALLS TH…
Read full complaint
TRUCK BURNED APROXIMATELY 45 MINUTES AFTER SHUTTING DOWN IN MY DRIVEWAY. CHRYSLER IS SENDING ME RECALL NOTICES THAT ARE ANYWHERE FROM 1 1/2 YRS OLD TO 6 WEEKS BEFORE THE FIRE, AND THEY ARE COMING IN THE MAIL NOW, ALMOST 4 MONTHS AFTER THE FIRE. CHRYSLER WILL NOT ADMIT RESPONSIBILITY FOR THE FIRE, EVEN WHILE SENDING ME RECALLS THIS LATE AFTER THE FIRE. *AK
AFTER RECALL REPAIR 97V-068 OF THE IGNITION SWITCH AND WIRING BOTH BATTERIES WENT DEAD, THE BATTERY ISOLATOR WIRING IS DIRECTLY LINKED INTO BLOWER MOTORS WHICH WAS THE WRONG SOURCE FOR POWER CAUSING ELECTRICAL DRAW TO THE BATTERY ISOLATOR AND BATTERIES, DEALER FOUND NEW POWER SOURCE FOR BATTERIES. NLM
TRUCK BURNED APROX. 45 MINUTES AFTER SHUTTING DOWN IN MY DRIVEWAY.
TRANSMISSION WILL NOT SHIFT INTO 5TH GEAR,CAUSE UNKNOWN, ACCELERATOR CABLE WAS REPLACED,ELECTRICAL SHORT WITH ABS AND CONSUMER ALSO STATES RADIO IS INOPERATIVE. *ADJ
TRANSMISSION DEFECTIVE CAUSING TORQUE CONVERTER TO LOCK UP, REPLACEMENT OF ENTIRE TRANSMISSION NECESSARY. MJS
Official recalls
199V024000 · Exterior Lighting:headlights:switch
Feb 5, 1999
VEHICLE DESCRIPTION: MODEL 3500 LIGHT DUTY TRUCKS ONLY. OPERATION OF THE HEADLAMPS OVER AN EXTENDED PERIOD OF TIME CAN RESULT IN HEADLAMP SWITCH FAILURE, CAUSING THE HEADLAMPS OR PARK LAMPS TO GO OUT.
Consequence & remedy
Consequence: IF THE LIGHTS FAIL, A VISIBILITY PROBLEM COULD OCCUR, INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE HEADLAMP SWITCH INCLUDING A RELAY IN THE PARK LAMP WIRING CIRCUIT.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2DP03006 · Seat Back Failure
Opened Sep 23, 2003 · Closed Apr 8, 2004
Status: closed (inferred from source dates) · Seats; Seats:front Assembly:recliner
ODI HAS IDENTIFIED 30 INCIDENTS WHERE IT IS ALLEGED THE SEAT BACK COLLAPSED IN A REAR IMPACT CRASH.THESE INCIDENTS ARE ALLEGED TO HAVE CONTRIBUTED TO 23 INJURIES AND TWO DEATHS.THE DATA PRESENTED TO ODI SHOW THAT THE SEAT BACK STRENGTH OF THE FRONT SEATS COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 207. SEATING SYSTEM.ACCORDING TO DAIMLERCHRYLSER THE FRONT SEATS WERE DESIGNED TO COLLAPSE REARWARD IN REAR IMPACT CRASHES AS PART OF THE ENERGY ABSORPTIONCAPABILITIES OF THE SEATING SYSTEM TO REDUCE THE CHANCE OF SERIOUS INJURY TO THE OCCUPANT.RATES OF OCCURANCE WERE COMPARED TO PEER VEHICLES, AND IT WAS SHOWN THAT THE PERFORMACE OF THE SUBJECT VEHICLE WAS COMPARABLE TO THOSE VEHICLES.IN VIEW OF THE FORGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION REMEDY OF A SAFETY DEFECT IN THE SUBJECT VEHICLES AS DEFINED BY THE PETITIONER AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THERFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE THE NHTSA'S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY'S MISSION, THE PETITION IS DENIED.FOR FURTHER DETAILS, REFER TO ODI'S RESPONSE TO THE PETITION PUBLISHED IN THE FEDERAL REGISTER VOL.69, NO. 60 , DATED MARCH 29, 2004.
Additional source detail variants (2)
Seats
ODI HAS IDENTIFIED 30 INCIDENTS WHERE IT IS ALLEGED THE SEAT BACK COLLAPSED IN A REAR IMPACT CRASH.THESE INCIDENTS ARE ALLEGED TO HAVE CONTRIBUTED TO 23 INJURIES AND TWO DEATHS.THE DATA PRESENTED TO ODI SHOW THAT THE SEAT BACK STRENGTH OF THE FRONT SEATS COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 207. SEATING SYSTEM.ACCORDING TO DAIMLERCHRYLSER THE FRONT SEATS WERE DESIGNED TO COLLAPSE REARWARD IN REAR IMPACT CRASHES AS PART OF THE ENERGY ABSORPTIONCAPABILITIES OF THE SEATING SYSTEM TO REDUCE THE CHANCE OF SERIOUS INJURY TO THE OCCUPANT.RATES OF OCCURANCE WERE COMPARED TO PEER VEHICLES, AND IT WAS SHOWN THAT THE PERFORMACE OF THE SUBJECT VEHICLE WAS COMPARABLE TO THOSE VEHICLES.IN VIEW OF THE FORGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION REMEDY OF A SAFETY DEFECT IN THE SUBJECT VEHICLES AS DEFINED BY THE PETITIONER AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THERFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE THE NHTSA'S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY'S MISSION, THE PETITION IS DENIED.FOR FURTHER DETAILS, REFER TO ODI'S RESPONSE TO THE PETITION PUBLISHED IN THE FEDERAL REGISTER VOL.69, NO. 60 , DATED MARCH 29, 2004.
Seats:front Assembly:recliner
ODI HAS IDENTIFIED 30 INCIDENTS WHERE IT IS ALLEGED THE SEAT BACK COLLAPSED IN A REAR IMPACT CRASH.THESE INCIDENTS ARE ALLEGED TO HAVE CONTRIBUTED TO 23 INJURIES AND TWO DEATHS.THE DATA PRESENTED TO ODI SHOW THAT THE SEAT BACK STRENGTH OF THE FRONT SEATS COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 207. SEATING SYSTEM.ACCORDING TO DAIMLERCHRYLSER THE FRONT SEATS WERE DESIGNED TO COLLAPSE REARWARD IN REAR IMPACT CRASHES AS PART OF THE ENERGY ABSORPTIONCAPABILITIES OF THE SEATING SYSTEM TO REDUCE THE CHANCE OF SERIOUS INJURY TO THE OCCUPANT.RATES OF OCCURANCE WERE COMPARED TO PEER VEHICLES, AND IT WAS SHOWN THAT THE PERFORMACE OF THE SUBJECT VEHICLE WAS COMPARABLE TO THOSE VEHICLES.IN VIEW OF THE FORGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION REMEDY OF A SAFETY DEFECT IN THE SUBJECT VEHICLES AS DEFINED BY THE PETITIONER AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THERFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE THE NHTSA'S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY'S MISSION, THE PETITION IS DENIED.FOR FURTHER DETAILS, REFER TO ODI'S RESPONSE TO THE PETITION PUBLISHED IN THE FEDERAL REGISTER VOL.69, NO. 60 , DATED MARCH 29, 2004.
PE00048 · Loss Of Throttle Control
Opened Dec 11, 2000 · Closed Mar 7, 2001
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
ALLEGED THAT THE THROTTLE CABLE CAN FRAY OR SEVER DURING NORMAL USE RESULTING IN THE THROTTLE NOT RETURNING TO IDLE OR AN INABILITY TO ACCELERATE.