IN A HARD RAIN OR EVEN WASHING UP UNDERNEATH THE TRUCK THE 4WD SERVICE LIGHT COMES ON AND IT WILL SAY IT'S TRYING TO TRANSFER OVER TO 4WD AND WHEN IT TRIED WITH ME I WAS RUNNING AROUND 55 MPH! IT JERKS THE [XXX] OUT OF THE TRUCK WITH A LOUD HAMMER NOISE! IT WILL CAUSE A PERSON TO WRECK IF YOU ARE NOT EXPECTING IT ! IT WAS BOUGHT…
Read full complaint
IN A HARD RAIN OR EVEN WASHING UP UNDERNEATH THE TRUCK THE 4WD SERVICE LIGHT COMES ON AND IT WILL SAY IT'S TRYING TO TRANSFER OVER TO 4WD AND WHEN IT TRIED WITH ME I WAS RUNNING AROUND 55 MPH! IT JERKS THE [XXX] OUT OF THE TRUCK WITH A LOUD HAMMER NOISE! IT WILL CAUSE A PERSON TO WRECK IF YOU ARE NOT EXPECTING IT ! IT WAS BOUGHT NEW IN 2019 AND STARTED THE 4WD CRAP AT 4,500 MILES NOT TO MENTION THE TRAILER BRAKE CONTROLLER DOESN'T WORK EITHER NOW, FOUND THAT OUT THE HARD WAY WITH 22 ROLLS OF HAY AND NO IT'S NOT THE TRAILER MY FORD TRUCK HAS TRAILER BRAKES, SAME TRAILER. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
NHTSA ODI #11342811
60,000 miles · Mar 21, 2014
Power TrainSteeringSuspension
TL* THE CONTACT STATED WHILE DRIVING 60 MPH, THE FRONT END OF THE VEHICLE STARTED TO SHAKE. AS A RESULT OF THE FAILURE, THE TRANSFER CASE FAILED . THE CONTACT STATED HE HAD TO APPLY THE BREAKS AND TURN THE ENGINE OFF IN ORDER TO STOP THE VEHICLE FROM SHAKING . THE MANUFACTURER WAS NOTIFIED MANY TIMES.. UPDATED 05/12/2014*LJ
NHTSA ODI #10574078
Mileage unknown · Nov 10, 1999
Power Train
NOTICED TRANSMISSION LEAKING UNDERNEATH. IT WAS LEAKING ONTO THE EXHAUST SYSTEM PIPE AND CATALYTIC CONVERTER, CLEARLY BACK TO THE BRAKES AND REAR BUMPER. CONTACTED DEALER WHO WAS NOT ABLE TO HELP DUE TO EXPIRED WARRANTY. TRANSMISSION COOLER LINES WERE CLAMPED TOGETHER WHERE THEY CAN RUBED EACH OTHER AND WORE OUT. *AK
NHTSA ODI #852787
Mileage unknown · Jul 28, 1999
Power Train
TRUCK VIBRATES EXCESSIVELY ,THE DEALER HAS REPLACED TRANSMISSION/TORQUE CONVERTER AND THE PROBLEM STILL EXISTS. YH
NHTSA ODI #547557
Mileage unknown · Dec 2, 1998
Electrical SystemEngine And Engine CoolingPower Train
TRAILER TOW HARNESS SWITCH BURNED.
NHTSA ODI #542990
Mileage unknown · Nov 17, 1998
Power Train
THE TRANSMISSION COOLING LINES RUB TOGETHER, CAUSING THE LINES TO BURN THROUGH AND LEAK ALL THE TRANSMISSION FLUID. DEALER HAS BEEN CONTACTED. *AK
NHTSA ODI #830949
Mileage unknown · Oct 27, 1998
Exterior LightingPower Train
HARNESS/HEADLAMP SWITCH FAILED RESULTING IN MELTING.
NHTSA ODI #542281
Mileage unknown · Oct 16, 1998
Power Train
CONSUMER HAS BEEN EXPERIENCING TRANSMISSION FAILURE DURING OPERATION OF THE VEHICLE. CONSUMER HAS CONTACTED THE DEALER . PLEASE PROVIDE ANY FURTHER DETAILS.*AK
NHTSA ODI #829054
Mileage unknown · May 11, 1998
Power Train
THE PLASTIC FITTING ON THE TRANSMISSION PRESSURE LINE BECOMES HOT AND MELTS, ALLOWING THE TRANSMISSION FLUID TO LEAK OUT. AT THIS TIME ALL POWER IS LOST AND DRIVER HAS NO CONTROL OVER THE TRUCK. THE PROBLEM HAS BEEN CORRECTED AT OWNER'S EXPENSE. *AK
NHTSA ODI #823205
Mileage unknown · Nov 10, 1997
Power Train
WHEN TRAVELING AND UPON APPLYING FORCE TO THE BRAKE PEDAL, CONSUMER NOTICED VIBRATION IN THE STEERING COLUMN. THE VEHICLE PULLED TO THE LEFT AND RIGHT, CAUSING THE CONSUMER TO LOSE CONTROL OF THE VEHICLE. CONSUMER HAS CONTACTED THE DEALER, DEALER HAS REPLACED THE RIGHT SEAL AND THE LEFT SEAL. PLEASE PROVIDE FURTHER DETAILS. *A…
Read full complaint
WHEN TRAVELING AND UPON APPLYING FORCE TO THE BRAKE PEDAL, CONSUMER NOTICED VIBRATION IN THE STEERING COLUMN. THE VEHICLE PULLED TO THE LEFT AND RIGHT, CAUSING THE CONSUMER TO LOSE CONTROL OF THE VEHICLE. CONSUMER HAS CONTACTED THE DEALER, DEALER HAS REPLACED THE RIGHT SEAL AND THE LEFT SEAL. PLEASE PROVIDE FURTHER DETAILS. *AK
VEHICLE DESCRIPTION: MODEL 3500 LIGHT DUTY TRUCKS ONLY. OPERATION OF THE HEADLAMPS OVER AN EXTENDED PERIOD OF TIME CAN RESULT IN HEADLAMP SWITCH FAILURE, CAUSING THE HEADLAMPS OR PARK LAMPS TO GO OUT.
Consequence & remedy
Consequence: IF THE LIGHTS FAIL, A VISIBILITY PROBLEM COULD OCCUR, INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE HEADLAMP SWITCH INCLUDING A RELAY IN THE PARK LAMP WIRING CIRCUIT.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
7
DP03006 · Seat Back Failure
Opened Sep 23, 2003 · Closed Apr 8, 2004
Status: closed (inferred from source dates) · Seats; Seats:front Assembly:recliner
ODI HAS IDENTIFIED 30 INCIDENTS WHERE IT IS ALLEGED THE SEAT BACK COLLAPSED IN A REAR IMPACT CRASH.THESE INCIDENTS ARE ALLEGED TO HAVE CONTRIBUTED TO 23 INJURIES AND TWO DEATHS.THE DATA PRESENTED TO ODI SHOW THAT THE SEAT BACK STRENGTH OF THE FRONT SEATS COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 207. SEATING SYSTEM.ACCORDING TO DAIMLERCHRYLSER THE FRONT SEATS WERE DESIGNED TO COLLAPSE REARWARD IN REAR IMPACT CRASHES AS PART OF THE ENERGY ABSORPTIONCAPABILITIES OF THE SEATING SYSTEM TO REDUCE THE CHANCE OF SERIOUS INJURY TO THE OCCUPANT.RATES OF OCCURANCE WERE COMPARED TO PEER VEHICLES, AND IT WAS SHOWN THAT THE PERFORMACE OF THE SUBJECT VEHICLE WAS COMPARABLE TO THOSE VEHICLES.IN VIEW OF THE FORGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION REMEDY OF A SAFETY DEFECT IN THE SUBJECT VEHICLES AS DEFINED BY THE PETITIONER AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THERFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE THE NHTSA'S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY'S MISSION, THE PETITION IS DENIED.FOR FURTHER DETAILS, REFER TO ODI'S RESPONSE TO THE PETITION PUBLISHED IN THE FEDERAL REGISTER VOL.69, NO. 60 , DATED MARCH 29, 2004.
Additional source detail variants (2)
Seats
ODI HAS IDENTIFIED 30 INCIDENTS WHERE IT IS ALLEGED THE SEAT BACK COLLAPSED IN A REAR IMPACT CRASH.THESE INCIDENTS ARE ALLEGED TO HAVE CONTRIBUTED TO 23 INJURIES AND TWO DEATHS.THE DATA PRESENTED TO ODI SHOW THAT THE SEAT BACK STRENGTH OF THE FRONT SEATS COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 207. SEATING SYSTEM.ACCORDING TO DAIMLERCHRYLSER THE FRONT SEATS WERE DESIGNED TO COLLAPSE REARWARD IN REAR IMPACT CRASHES AS PART OF THE ENERGY ABSORPTIONCAPABILITIES OF THE SEATING SYSTEM TO REDUCE THE CHANCE OF SERIOUS INJURY TO THE OCCUPANT.RATES OF OCCURANCE WERE COMPARED TO PEER VEHICLES, AND IT WAS SHOWN THAT THE PERFORMACE OF THE SUBJECT VEHICLE WAS COMPARABLE TO THOSE VEHICLES.IN VIEW OF THE FORGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION REMEDY OF A SAFETY DEFECT IN THE SUBJECT VEHICLES AS DEFINED BY THE PETITIONER AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THERFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE THE NHTSA'S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY'S MISSION, THE PETITION IS DENIED.FOR FURTHER DETAILS, REFER TO ODI'S RESPONSE TO THE PETITION PUBLISHED IN THE FEDERAL REGISTER VOL.69, NO. 60 , DATED MARCH 29, 2004.
Seats:front Assembly:recliner
ODI HAS IDENTIFIED 30 INCIDENTS WHERE IT IS ALLEGED THE SEAT BACK COLLAPSED IN A REAR IMPACT CRASH.THESE INCIDENTS ARE ALLEGED TO HAVE CONTRIBUTED TO 23 INJURIES AND TWO DEATHS.THE DATA PRESENTED TO ODI SHOW THAT THE SEAT BACK STRENGTH OF THE FRONT SEATS COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 207. SEATING SYSTEM.ACCORDING TO DAIMLERCHRYLSER THE FRONT SEATS WERE DESIGNED TO COLLAPSE REARWARD IN REAR IMPACT CRASHES AS PART OF THE ENERGY ABSORPTIONCAPABILITIES OF THE SEATING SYSTEM TO REDUCE THE CHANCE OF SERIOUS INJURY TO THE OCCUPANT.RATES OF OCCURANCE WERE COMPARED TO PEER VEHICLES, AND IT WAS SHOWN THAT THE PERFORMACE OF THE SUBJECT VEHICLE WAS COMPARABLE TO THOSE VEHICLES.IN VIEW OF THE FORGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION REMEDY OF A SAFETY DEFECT IN THE SUBJECT VEHICLES AS DEFINED BY THE PETITIONER AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THERFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE THE NHTSA'S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY'S MISSION, THE PETITION IS DENIED.FOR FURTHER DETAILS, REFER TO ODI'S RESPONSE TO THE PETITION PUBLISHED IN THE FEDERAL REGISTER VOL.69, NO. 60 , DATED MARCH 29, 2004.
DP03002 · Steering Column Separation
Opened May 7, 2003 · Closed Jul 22, 2003
Status: closed (inferred from source dates) · Steering:column
MR. LARRY A. SACKEY SUBMITTED A PETITION TO THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) BY LETTER DATED APRIL 18, 2003, REQUESTING THAT NHTSAFURTHER INVESTIGATE THE DEFECTIVE COLLAPSIBLE STEERING SHAFT SYSTEM ON 1987-1995 VEHICLES MANUFACTURED BY THE DAIMLERCHRYSLER CORPORATION.IN PART BECAUSE OF 49 CFR ? 30120(G), NHTSA HAS DECIDED TO LIMIT THE SCOPE OF THE PETITION VEHICLES TO 1993-1995 MODELS, EXCLUDING THE 1993 JEEP GRAND CHEROKEE AND 1994-1995 DODGE RAM SERIES TRUCKS THAT WERE RECALLED (93V210 & 96V230) FOR STEERING COLUMN FAILURE.IF THE ANALYSIS OF THESE VEHICLES HAD IDENTIFIED A POTENTIAL PROBLEM, THE SCOPE COULD HAVE BEEN EXPANDED IN AN INVESTIGATION.A REVIEW OF ODI'S DATA BASE SHOWS NO RECENT COMPLAINTS AND A LACK OF A COMPLAINT TREND CONCERNING THE SUBJECT ISSUE ON THE SUBJECT VEHICLES AS A WHOLE OR BY INDIVIDUAL MODELS.THEREFORE, THE PETITION IS DENIED.FOR DETAILS, SEE FEDERAL REGISTER NOTICE VOLUME 68, NO. 130, JULY 8, 2003.
PE00048 · Loss Of Throttle Control
Opened Dec 11, 2000 · Closed Mar 7, 2001
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
ALLEGED THAT THE THROTTLE CABLE CAN FRAY OR SEVER DURING NORMAL USE RESULTING IN THE THROTTLE NOT RETURNING TO IDLE OR AN INABILITY TO ACCELERATE.
PE99026 · Front Suspension Spring/shock Absorber
Opened Apr 16, 1999 · Closed Aug 31, 1999
Status: closed (inferred from source dates) · Suspension
ALLEGE FAILURE OF THE COIL SPRING/SHOCK ABSORBER BRACKET AT ITS ATTACHMENT TO THE VEHICLE FRAME MAY ALLOW COLLAPSE OF THE FRONT SUSPENSION, AND POTENTIALLY AFFECT STEERING OR BRAKING SYSTEM PERFORMANCE
EA98010 · Headlight Circuit
Opened May 8, 1998 · Closed Dec 10, 1999
Status: closed (inferred from source dates) · Exterior Lighting
THE HEADLAMP SWITCH IN THE SUBJECT VEHICLES CAN OVER-HEAT AND FAIL RESULTING IN LOSS OF HEAD LAMPS AND POSSIBLY OTHER LIGHTS.DAIMLERCHRYSLER CONDUCTED A SERIES OF TESTS AND DETERMINED THAT THE 3500 SERIES IS PRONE TO GENERATING HEAD LAMP SWITCH TEMPERATURES IN EXCESS OF THE SWITCH LUBRICANT THRESHOLD OF 100 DEGREES CENTIGRADE.WHEN THIS OCCURS, THE LUBRICANT SOLIDIFIES AND ADHERES TO THE SWITCH CONTACH SURFACES INCREASING INTERNAL RESISTANCE AND THERFORE, TEMPERATURE.DAIMLERCHRYSLER INFORMED THE NHTSA THAT IT WOULD INITIATE A RECALL OF 79,3665 MODEL YEAR 1994-1997 DODGE 3500 SERIES RAM TRUCKS ONLY BASED ON ADDITIONAL TESTING FROM WHICH IT DETERMINED THAT THE 1500/2500 SERIES VEHICLES NOMINALLY OPERATE SIGNIFICANTLY BELOW THE TEMPERATURE THRESHOLD OF THE SWITCH LUBRICANT.OWNERS OF 1500/2500 SERIES TRUCKS WERE SENT A NOTIFICATION LETTER ADVISING OF THE PROPER METHODS FOR ADDING AFTERMARKET LIGHTING ACCESSORIES.
PE98002 · Headlight Circuit Failure
Opened Jan 14, 1998 · Closed May 8, 1998
Status: closed (inferred from source dates) · Exterior Lighting
There is no summary currently available
PE94072 · Trans Hose Separation
Opened Oct 3, 1994 · Closed Mar 22, 1995
Status: closed (inferred from source dates) · Power Train
There is no summary currently available
1994 Dodge RAM 3500 Problems, Complaints & Recalls | Skip That Year
Illustration