TL* THE CONTACT OWNS A 1997 DODGE RAM 2500. THE CONTACT STATED THAT THE VEHICLE WAS PARKED FOR SEVERAL WEEKS AND APPROXIMATELY ONE QUARTER TANK OF GASOLINE EVAPORATED. THE FAILURE RECURRED FIFTEEN TIMES. THE VEHICLE WAS TAKEN TO TWO DIFFERENT DEALERS BUT NEITHER COULD DETERMINE THE CAUSE FOR THE FAILURE. FIFTEEN YEARS PASSED AND…
Read full complaint
TL* THE CONTACT OWNS A 1997 DODGE RAM 2500. THE CONTACT STATED THAT THE VEHICLE WAS PARKED FOR SEVERAL WEEKS AND APPROXIMATELY ONE QUARTER TANK OF GASOLINE EVAPORATED. THE FAILURE RECURRED FIFTEEN TIMES. THE VEHICLE WAS TAKEN TO TWO DIFFERENT DEALERS BUT NEITHER COULD DETERMINE THE CAUSE FOR THE FAILURE. FIFTEEN YEARS PASSED AND THE CONTACT BEGAN TO SMELL GASOLINE WHEN EXITING THE VEHICLE. HE ALSO NOTICED GASOLINE FUEL LEAKING FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS AND THE CONTACT WAS INFORMED THAT THE FUEL PUMP WAS LEAKING AND BASED ON THE COMPONENTS THAT WERE SURROUNDING THE FUEL PUMP, HAD BEEN LEAKING FOR QUITE SOME TIME. THE PRESSURE RELIEF ROLL OVER VALVE WAS IDENTIFIED AS THE CAUSE OF THE FAILURE. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED BUT OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 6 AND THE CURRENT MILEAGE WAS 43,385. UPDATED 6/14/13 *CN
NHTSA ODI #10507509
141,500 miles · Sep 11, 2003
Fuel System, Other
1997 DODGE DIESEL 2500: FUEL LINE DIRECTLY BEHIND DRIVERS SIDE FRONT WHEEL HAS A HOLE WORN IN IT BY WAY OF CONTACT WITH NEIGHBORING FUEL OR OTHER LINE. THE NEIGHBORING LINE HAS A CONNECTOR OR FITTING THAT THROUGH VIBRATION AND DIRECT CONTACT HAS WORN A HOLE IN THE METAL FUEL LINE. THE LINE IS PRESSURIZED ADN RELEASES DIESEL F…
Read full complaint
1997 DODGE DIESEL 2500: FUEL LINE DIRECTLY BEHIND DRIVERS SIDE FRONT WHEEL HAS A HOLE WORN IN IT BY WAY OF CONTACT WITH NEIGHBORING FUEL OR OTHER LINE. THE NEIGHBORING LINE HAS A CONNECTOR OR FITTING THAT THROUGH VIBRATION AND DIRECT CONTACT HAS WORN A HOLE IN THE METAL FUEL LINE. THE LINE IS PRESSURIZED ADN RELEASES DIESEL FUEL THROUGH THE HOLE ONTO THE VEHICLE FRAME AND UNDERCARRIAGE. RATE OF LEAKAGE IS SUFFUCIENT TO RELEASE APPROXIMATELY ONE GALLON OF FUEL IN A 20 MINUTE PERIOD. LINE IS ALSO CORRODED FROM YEARS OF WINTER ROAD SURFACE TREATMENT AND MAY HAVE CONTRIBUTED TO THE WEAR OF THE LINE. HOWEVER THERE IS NO QUESTION THAT CONTACT BETWEEN TEH TWO LINES IS THE MAIN REASON FOR THE DAMAGE LINE AND FUEL LEAK. THE VEHICLE IS BEING REPAIRED AT THE DODGE DEALER IN CULPEPER VIRGINIA, DURING THE WEEK OF SEPTEMBER 15, 2003. *AK
NHTSA ODI #10038734
65,000 miles · Jan 30, 2003
Fuel System, DieselFuel System, Other
FUEL GUAGE IS BROKEN FOR THE SECOND TIME. FIRST WAS UNDER WARRANTY IN 1999. THE SENDING UNIT WAS REPLACED. NOW IT IS BROKEN AGAIN BUT THE DEALER SAYS IT IS OUT OF WARRANTY AND WILL COST $$$. AFTER SPEAKING WITH OTHER OWNERS AND SOME MECHANICS I FOUND THIS TO BE A COMMON PROBLEM AND FEEL IT SOULD BE A RECALL ITEM.
NHTSA ODI #10004964
Mileage unknown · May 8, 2002
Fuel System, Other
FUEL GAUGE IS ERRATIC. GAGE READS FULL WHEN TANK IS FULL. 50 MILES LATER IT READS EMPTY AND THE FUEL WARNING LIGHT COMES ON.*AK
NHTSA ODI #761688
Mileage unknown · Apr 17, 2001
Fuel System, Other
GAS GUAGE DOES NOT WORK. THIS IS A COMMON PROBLEM WITH THESE DODGE TRUCKS, DODGE SHOULD DO SOMETHING ABOUT IT. THERE IS NO WAY TO TELL THE AMOUNT OF FUEL LEFT IN THE TANK.*AK
NHTSA ODI #744149
Mileage unknown · Aug 1, 2000
Fuel System, Other
GASOLINE GAUGE NEEDLE DOESN'T WORK. NEEDLE OF THE GAUGE DOESN'T SHOW CORRECT AMOUT OF GASOLINE. *AK
NHTSA ODI #866516
Mileage unknown · Sep 8, 1999
Fuel System, GasolineFuel System, Other
FUEL LINES. VAPOR LOCK FUEL SYSTEM.
NHTSA ODI #609718
Official recalls
0
No recalls in this snapshot.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
DP03006 · Seat Back Failure
Opened Sep 23, 2003 · Closed Apr 8, 2004
Status: closed (inferred from source dates) · Seats; Seats:front Assembly:recliner
ODI HAS IDENTIFIED 30 INCIDENTS WHERE IT IS ALLEGED THE SEAT BACK COLLAPSED IN A REAR IMPACT CRASH.THESE INCIDENTS ARE ALLEGED TO HAVE CONTRIBUTED TO 23 INJURIES AND TWO DEATHS.THE DATA PRESENTED TO ODI SHOW THAT THE SEAT BACK STRENGTH OF THE FRONT SEATS COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 207. SEATING SYSTEM.ACCORDING TO DAIMLERCHRYLSER THE FRONT SEATS WERE DESIGNED TO COLLAPSE REARWARD IN REAR IMPACT CRASHES AS PART OF THE ENERGY ABSORPTIONCAPABILITIES OF THE SEATING SYSTEM TO REDUCE THE CHANCE OF SERIOUS INJURY TO THE OCCUPANT.RATES OF OCCURANCE WERE COMPARED TO PEER VEHICLES, AND IT WAS SHOWN THAT THE PERFORMACE OF THE SUBJECT VEHICLE WAS COMPARABLE TO THOSE VEHICLES.IN VIEW OF THE FORGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION REMEDY OF A SAFETY DEFECT IN THE SUBJECT VEHICLES AS DEFINED BY THE PETITIONER AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THERFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE THE NHTSA'S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY'S MISSION, THE PETITION IS DENIED.FOR FURTHER DETAILS, REFER TO ODI'S RESPONSE TO THE PETITION PUBLISHED IN THE FEDERAL REGISTER VOL.69, NO. 60 , DATED MARCH 29, 2004.
Additional source detail variants (2)
Seats
ODI HAS IDENTIFIED 30 INCIDENTS WHERE IT IS ALLEGED THE SEAT BACK COLLAPSED IN A REAR IMPACT CRASH.THESE INCIDENTS ARE ALLEGED TO HAVE CONTRIBUTED TO 23 INJURIES AND TWO DEATHS.THE DATA PRESENTED TO ODI SHOW THAT THE SEAT BACK STRENGTH OF THE FRONT SEATS COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 207. SEATING SYSTEM.ACCORDING TO DAIMLERCHRYLSER THE FRONT SEATS WERE DESIGNED TO COLLAPSE REARWARD IN REAR IMPACT CRASHES AS PART OF THE ENERGY ABSORPTIONCAPABILITIES OF THE SEATING SYSTEM TO REDUCE THE CHANCE OF SERIOUS INJURY TO THE OCCUPANT.RATES OF OCCURANCE WERE COMPARED TO PEER VEHICLES, AND IT WAS SHOWN THAT THE PERFORMACE OF THE SUBJECT VEHICLE WAS COMPARABLE TO THOSE VEHICLES.IN VIEW OF THE FORGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION REMEDY OF A SAFETY DEFECT IN THE SUBJECT VEHICLES AS DEFINED BY THE PETITIONER AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THERFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE THE NHTSA'S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY'S MISSION, THE PETITION IS DENIED.FOR FURTHER DETAILS, REFER TO ODI'S RESPONSE TO THE PETITION PUBLISHED IN THE FEDERAL REGISTER VOL.69, NO. 60 , DATED MARCH 29, 2004.
Seats:front Assembly:recliner
ODI HAS IDENTIFIED 30 INCIDENTS WHERE IT IS ALLEGED THE SEAT BACK COLLAPSED IN A REAR IMPACT CRASH.THESE INCIDENTS ARE ALLEGED TO HAVE CONTRIBUTED TO 23 INJURIES AND TWO DEATHS.THE DATA PRESENTED TO ODI SHOW THAT THE SEAT BACK STRENGTH OF THE FRONT SEATS COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 207. SEATING SYSTEM.ACCORDING TO DAIMLERCHRYLSER THE FRONT SEATS WERE DESIGNED TO COLLAPSE REARWARD IN REAR IMPACT CRASHES AS PART OF THE ENERGY ABSORPTIONCAPABILITIES OF THE SEATING SYSTEM TO REDUCE THE CHANCE OF SERIOUS INJURY TO THE OCCUPANT.RATES OF OCCURANCE WERE COMPARED TO PEER VEHICLES, AND IT WAS SHOWN THAT THE PERFORMACE OF THE SUBJECT VEHICLE WAS COMPARABLE TO THOSE VEHICLES.IN VIEW OF THE FORGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION REMEDY OF A SAFETY DEFECT IN THE SUBJECT VEHICLES AS DEFINED BY THE PETITIONER AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THERFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE THE NHTSA'S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY'S MISSION, THE PETITION IS DENIED.FOR FURTHER DETAILS, REFER TO ODI'S RESPONSE TO THE PETITION PUBLISHED IN THE FEDERAL REGISTER VOL.69, NO. 60 , DATED MARCH 29, 2004.
1997 Dodge RAM 2500 Problems, Complaints & Recalls | Skip That Year
Illustration