WHEELS ON MY 2002 DODGE RAM WITH 17 INCH ALLOY (GREY LOOKING) OPTION WHEELS HAS AIR VENTALATION OPENINGS FOR THE ROTORS WHICH IS TOO SMALL AND DOESN'T ALLOW ENOUGH AIR TO COOL OFF ROTORS. .THIS DEFECT IN THE WHEELS OPENING CAUSES ROTORS TO OVERHEAT QUICKLY AND NOT BE ABLE TO COOL OFF. THIS WARPS THE ROTORS CAUSING INCREASED ST…
Read full complaint
WHEELS ON MY 2002 DODGE RAM WITH 17 INCH ALLOY (GREY LOOKING) OPTION WHEELS HAS AIR VENTALATION OPENINGS FOR THE ROTORS WHICH IS TOO SMALL AND DOESN'T ALLOW ENOUGH AIR TO COOL OFF ROTORS. .THIS DEFECT IN THE WHEELS OPENING CAUSES ROTORS TO OVERHEAT QUICKLY AND NOT BE ABLE TO COOL OFF. THIS WARPS THE ROTORS CAUSING INCREASED STOPPING DISTANCES, AND SHIMMY OR SHAKE WHEN BRAKES APPLIED. TRUCK VIBRATES HARSHLY AT HIGHWAY SPEEDS WHEN GOING TO SLOW DOWN AT OFF RAMPS. IF WHEELS WERE DESIGNED TO ALLOW MORE AIR. I HAVE BROUGHT TO DEALER TO CHECK BRAKE SYSTEM AND IT'S FOUND THAT BRAKES ARE FINE BUT ROTORS ARE WARPED. 3000 MILES LATER AND ROTORS ARE WARPED AGAIN. THIS WILL KEEP HAPPENING UNLESS I CHANGE RIMS AND MY DODGE RAM . AT DODGE TRUCK WORLD.COM THERE IS A LIST OF OWNERS WITH SAME PROBLEM . THIS ALSO COULD CAUSE FIRE OR INABILITY TO STOP.*AK
ON CERTAIN 4X4 PICKUP TRUCKS EQUIPPED WITH THE SNOW PLOW PREPARATION PACKAGE, THE TIRES SUPPLIED ON SOME VEHICLES MAY HAVE GROSS AXLE WEIGHT RATINGS THAT SLIGHTLY EXCEED THE MAXIMUM TIRE LOAD CAPACITY AS DEFINED IN FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS."
Consequence & remedy
Consequence: Not supplied
Remedy: DEALERS WILL PROVIDE REPLACEMENT P245/75R16 TIRES TO MEET THE LOAD CARRYING CAPACITY SPECIFIED ON THE VEHICLE CERTIFICATION LABEL AND ACCOMMODATE THE ADDITION OF A COMMERCIALLY AVAILABLE SNOW PLOW AND HARDWARE. OWNER NOTIFICATION BEGAN ON DECEMBER 22, 2003. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-992-1997.
ON CERTAIN PICKUP TRUCKS, THE DETENT SYSTEM ON THE EXTERIOR MIRROR HOUSINGS MAY LOSE THE FUNCTIONALITY.
Consequence & remedy
Consequence: THIS COULD POTENTIALLY AFFECT REARWARD FIELD OF VISION, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL A MIRROR DETENT RETAINER KIT TO CORRECT THIS CONDITION. OWNER NOTIFICATION BEGAN ON APRIL 10, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
ON CERTAIN PICKUP TRUCKS, THE ELECTRICAL CONNECTOR AT THE BOTTOM OF THE STEERING COLUMN CONTAINS AN UNDER-SIZED TERMINAL FOR THE HVAC BLOWER MOTOR CIRCUIT. LOCALIZED HEATING FROM CURRENT FLOW WITH THE BLOWER SPEED SET ON HIGH MAY CAUSE THE TERMINAL CONTACTS TO RELAX AND LOSE ELECTRICAL CONTACT. THIS CAN CAUSE THE HVAC BLOWER MOTOR TO BECOME INOPERATIVE.
Consequence & remedy
Consequence: THIS CONDITION COULD CAUSE IMPAIRMENT OF VISIBILITY IN INCLEMENT WEATHER, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL A WIRING HARNESS OVERLAY TO CORRECT THIS CONDITION. OWNER NOTIFICATION BEGAN APRIL 15, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE02096 · Rear Axle Failure
Opened Dec 26, 2002 · Closed May 15, 2003
Status: closed (inferred from source dates) · Power Train:axle Assembly; Power Train:driveline:differential Unit
SEE ATTACHED REPORT.
Additional source detail variants (2)
Power Train:axle Assembly
SEE ATTACHED REPORT.
Power Train:driveline:differential Unit
SEE ATTACHED REPORT.
2002 Dodge RAM 1500 Problems, Complaints & Recalls | Skip That Year
Illustration