Electrical SystemEngine And Engine CoolingService Brakes, Hydraulic
CONSUMER HAS MULTIPLE PROBLEMS: FIRST, ABS LOCKED UP & WOULDN'T UNLOCK UNTIL VEHICLE STOPPED. DEALER HAS CHANGED EVERY PART THEY CAN THINK OFF, DIDN'T HAVE A CLUE TO A REMEDY. MANUFACTURER SAID ABS WAS ONLY USED FOR EMERGENCY PURPOSES. SECOND, PROBLEM INVOLVED BRAKE FLUID LEAKING. DEALER FOUND A SEAL LEAKING, AND PUT …
Read full complaint
CONSUMER HAS MULTIPLE PROBLEMS: FIRST, ABS LOCKED UP & WOULDN'T UNLOCK UNTIL VEHICLE STOPPED. DEALER HAS CHANGED EVERY PART THEY CAN THINK OFF, DIDN'T HAVE A CLUE TO A REMEDY. MANUFACTURER SAID ABS WAS ONLY USED FOR EMERGENCY PURPOSES. SECOND, PROBLEM INVOLVED BRAKE FLUID LEAKING. DEALER FOUND A SEAL LEAKING, AND PUT IN A NEW MASTER CYLINDER. CONSUMER PICKED VEHICLE UP, AND IT DIDN'T MAKE IT FOR 3 BLOCKS. FRONT WHEELS LOCKED UP. ONLY THING THAT DEALER HAD TO SAY WAS SOMETIMES THEY GET BAD PARTS. CONSUMER HAS MORE INFORMATION TO SEND IN.*AK FACTORY BATTERY SHORTED OUT ALONG WITH RADIO. THE DASH CLUSTER, THERMOSTAT AND HOUSING ON ENGIE,CRANK SENSOR, BOTH FRONT ROTORS AND CALIPERS AND STEERING GEAR BOX WERE REPLACED. *YH
NHTSA ODI #880157
Mileage unknown · Jan 17, 2001
EquipmentSeatsService Brakes, Hydraulic
THE PASSENGER QUAD DOOR SPEAKER BUZZES, DEALER REPLACED SPEAKER, THE BUZZING NOISE IS STILL PRESENT. *SLC
NHTSA ODI #559046
Mileage unknown · Jun 13, 2000
Service Brakes, Hydraulic
WHILE TRAVELING ON HIGHWAY BRAKES LOCKED UP AND STARTED TO SMOKE. TOOK VEHICLE TO DEALER, AND MECHANIC NOTICED BURNED AREAS ON HUBS, AND DID NOT REPLACE THEM OR THE SHOES. VEHICLE WAS PARKED AND ROLLED FORWARD INTO A TREE. EACH TIME DEALER WAS INFORMED, AND NOTHING SHOWED UP AS DEFECTIVE. *AK *ML
ON CERTAIN 4X4 PICKUP TRUCKS EQUIPPED WITH THE SNOW PLOW PREPARATION PACKAGE, THE TIRES SUPPLIED ON SOME VEHICLES MAY HAVE GROSS AXLE WEIGHT RATINGS THAT SLIGHTLY EXCEED THE MAXIMUM TIRE LOAD CAPACITY AS DEFINED IN FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS."
Consequence & remedy
Consequence: Not supplied
Remedy: DEALERS WILL PROVIDE REPLACEMENT P245/75R16 TIRES TO MEET THE LOAD CARRYING CAPACITY SPECIFIED ON THE VEHICLE CERTIFICATION LABEL AND ACCOMMODATE THE ADDITION OF A COMMERCIALLY AVAILABLE SNOW PLOW AND HARDWARE. OWNER NOTIFICATION BEGAN ON DECEMBER 22, 2003. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-992-1997.
VEHICLE DESCRIPTION: PICKUP TRUCKS. SOUND DEADENER MATERIAL INSIDE THE STEERING WHEEL COULD BECOME DETACHED FROM THE COVER AND HOUSING. NOTE: THE RAM PICKUP TRUCKS WERE BUILT AT THE WARREN ASSEMBLY PLANT ("S" IN THE 11TH VIN POSITION) FROM MAY 16, 2000 THROUGH OCTOBER 23, 2000; ST. LOUIS NORTH ASSEMBLY PLANT ("J" IN THE 11TH VIN POSITION) FROM MAY 19, 2000 THROUGH OCTOBER 23, 2000; LAGO ALBERTO ASSEMBLY PLANT ("M" IN THE 11TH VIN POSITION) FROM MAY 23, 2000 THROUGH OCTOBER 23, 2000; AND SALTILLO ASSEMBLY PLANT ("G" IN THE 11TH VIN POSITION) FROM MAY 23, 2000 THROUGH OCTOBER 23, 2000. IMPORTANT: VEHICLES THAT HAVE ALREADY HAD THE PROPER CLOCKSPRING INSTALLED, ACCORDING TO WARRANTY RECORDS, HAVE BEEN EXCLUDED FROM THIS RECALL. IN ADDITION, 1997-2000 MODEL YEAR VEHICLES THAT HAVE HAD A SUSPECT REPLACEMENT CLOCKSPRING INSTALLED, ACCORDING TO WARRANTY RECORDS, HAVE BEEN ADDED TO THIS RECALL.
Consequence & remedy
Consequence: WHEN THIS OCCURS, THE MATERIAL COULD INTERFERE WITH THE CLOCKSPRING RIBBON AND CAUSE AN OPEN CIRCUIT. THE DRIVER AIR BAG SYSTEM WILL BECOME DISABLED, AND THE AIR BAG WARNING LAMP WILL ILLUMINATE ON THE INSTRUMENT PANEL.
Remedy: DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY. OWNER NOTIFICATION BEGAN JUNE 18, 2001. ALSO SOME 1997-200 MODEL YEAR VEHICLES THAT, ACCORDING TO WARRANTY RECORDS, HAVE HAD A SUSPECT REPLACEMENT CLOCKSPRING INSTALLED, WILL ALSO BE INCLUDED IN THIS CAMPAIGN. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE08047 · 2000-2001 Dodge RAM Pickup Hood Latch
Opened Jul 25, 2008 · Closed Dec 17, 2008
Status: closed (inferred from source dates) · Latches/locks/linkages:hood:latch; Structure:body:hood:hinge And Attachments
THE AGENCY OPENED THIS INVESTIGATION BASED ON 30 COMPLAINTS ALLEGING THAT THE HOODS ON MODEL YEAR (MY) 2000 AND 2001 DODGE RAM PICKUP TRUCKS FLEW UP AND BLOCKED THE DRIVER'S VISION.THESE VEHICLES HAVE A PRIMARY HOOD LATCH AND A SECONDARY (BACKUP) HOOD LATCH.THE SECONDARY LATCH IS DESIGNED TO SECURE THE HOOD IF THE PRIMARY HOOD LATCH IS NOT PROPERLY CLOSED OR OTHERWISE MALFUNCTIONS.IN THESE COMPLAINTS, THE SECONDARY HOOD LATCH MALFUNCTIONED, APPARENTLY DUE TO CORROSION, AND DID NOT LATCH.DODGE CONDUCTED RECALL 01V-040 IN 1999 TO ADDRESS SIMILAR PROBLEMS ON MODEL YEAR 1994-1997 DODGE RAM PICKUP TRUCKS.THE INFORMATION CHRYSLER PROVIDED IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER INDICATED THAT THE MY 2000 AND 2001 VEHICLES WERE EQUIPPED WITH SECONDARY HOOD LATCHES WITH STAINLESS STEEL RETURN SPRINGS, AS OPPOSED TO THE EARLIER RECALLED TRUCKS THAT HAD ZINC COATED CARBON STEEL RETURN SPRINGS.THE RECALLED COMPONENTS WERE SUSCEPTIBLE TO CORROSION-INDUCED FAILURE DUE TO THE TYPE OF MATERIAL USED, WHEREAS THE CORROSION FAILURES IN THE NEWER MODELS APPEAR TO BE DUE TO LUBRICATION LOSS OVER TIME (REGULAR APPLICATION OF GREASE IS ADVISED PER INSTRUCTIONS IN THE OWNERS' MANUAL). ODI'S REVIEW OF CHRYSLER'S WARRANTY, COMPLAINT, AND INJURY DATA FOR THE 2000 AND 2001 VEHICLES INDICATES THAT THE RATES FOR SUBJECT VEHICLES ARE LOW AND ARE DECLINING.A POTENTIAL DEFECT TREND HAS NOT BEEN IDENTIFIED.THIS INVESTIGATION IS CLOSED.
Additional source detail variants (2)
Latches/locks/linkages:hood:latch
THE AGENCY OPENED THIS INVESTIGATION BASED ON 30 COMPLAINTS ALLEGING THAT THE HOODS ON MODEL YEAR (MY) 2000 AND 2001 DODGE RAM PICKUP TRUCKS FLEW UP AND BLOCKED THE DRIVER'S VISION.THESE VEHICLES HAVE A PRIMARY HOOD LATCH AND A SECONDARY (BACKUP) HOOD LATCH.THE SECONDARY LATCH IS DESIGNED TO SECURE THE HOOD IF THE PRIMARY HOOD LATCH IS NOT PROPERLY CLOSED OR OTHERWISE MALFUNCTIONS.IN THESE COMPLAINTS, THE SECONDARY HOOD LATCH MALFUNCTIONED, APPARENTLY DUE TO CORROSION, AND DID NOT LATCH.DODGE CONDUCTED RECALL 01V-040 IN 1999 TO ADDRESS SIMILAR PROBLEMS ON MODEL YEAR 1994-1997 DODGE RAM PICKUP TRUCKS.THE INFORMATION CHRYSLER PROVIDED IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER INDICATED THAT THE MY 2000 AND 2001 VEHICLES WERE EQUIPPED WITH SECONDARY HOOD LATCHES WITH STAINLESS STEEL RETURN SPRINGS, AS OPPOSED TO THE EARLIER RECALLED TRUCKS THAT HAD ZINC COATED CARBON STEEL RETURN SPRINGS.THE RECALLED COMPONENTS WERE SUSCEPTIBLE TO CORROSION-INDUCED FAILURE DUE TO THE TYPE OF MATERIAL USED, WHEREAS THE CORROSION FAILURES IN THE NEWER MODELS APPEAR TO BE DUE TO LUBRICATION LOSS OVER TIME (REGULAR APPLICATION OF GREASE IS ADVISED PER INSTRUCTIONS IN THE OWNERS' MANUAL). ODI'S REVIEW OF CHRYSLER'S WARRANTY, COMPLAINT, AND INJURY DATA FOR THE 2000 AND 2001 VEHICLES INDICATES THAT THE RATES FOR SUBJECT VEHICLES ARE LOW AND ARE DECLINING.A POTENTIAL DEFECT TREND HAS NOT BEEN IDENTIFIED.THIS INVESTIGATION IS CLOSED.
Structure:body:hood:hinge And Attachments
THE AGENCY OPENED THIS INVESTIGATION BASED ON 30 COMPLAINTS ALLEGING THAT THE HOODS ON MODEL YEAR (MY) 2000 AND 2001 DODGE RAM PICKUP TRUCKS FLEW UP AND BLOCKED THE DRIVER'S VISION.THESE VEHICLES HAVE A PRIMARY HOOD LATCH AND A SECONDARY (BACKUP) HOOD LATCH.THE SECONDARY LATCH IS DESIGNED TO SECURE THE HOOD IF THE PRIMARY HOOD LATCH IS NOT PROPERLY CLOSED OR OTHERWISE MALFUNCTIONS.IN THESE COMPLAINTS, THE SECONDARY HOOD LATCH MALFUNCTIONED, APPARENTLY DUE TO CORROSION, AND DID NOT LATCH.DODGE CONDUCTED RECALL 01V-040 IN 1999 TO ADDRESS SIMILAR PROBLEMS ON MODEL YEAR 1994-1997 DODGE RAM PICKUP TRUCKS.THE INFORMATION CHRYSLER PROVIDED IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER INDICATED THAT THE MY 2000 AND 2001 VEHICLES WERE EQUIPPED WITH SECONDARY HOOD LATCHES WITH STAINLESS STEEL RETURN SPRINGS, AS OPPOSED TO THE EARLIER RECALLED TRUCKS THAT HAD ZINC COATED CARBON STEEL RETURN SPRINGS.THE RECALLED COMPONENTS WERE SUSCEPTIBLE TO CORROSION-INDUCED FAILURE DUE TO THE TYPE OF MATERIAL USED, WHEREAS THE CORROSION FAILURES IN THE NEWER MODELS APPEAR TO BE DUE TO LUBRICATION LOSS OVER TIME (REGULAR APPLICATION OF GREASE IS ADVISED PER INSTRUCTIONS IN THE OWNERS' MANUAL). ODI'S REVIEW OF CHRYSLER'S WARRANTY, COMPLAINT, AND INJURY DATA FOR THE 2000 AND 2001 VEHICLES INDICATES THAT THE RATES FOR SUBJECT VEHICLES ARE LOW AND ARE DECLINING.A POTENTIAL DEFECT TREND HAS NOT BEEN IDENTIFIED.THIS INVESTIGATION IS CLOSED.
2000 Dodge RAM 1500 Problems, Complaints & Recalls | Skip That Year
Illustration