UPON EXITING VEHICLE AFTER SHORT TRIP (2 MILES), NOTICED STRONG FUEL ODOR. LOOKED UNDER TRUCK AND OBSERVED FUEL STREAMING DOWN OVER HOT EXHAUST PIPE BENEATH ENGINE COMPARTMENT. INSPECTION OF ENGINE REVEALED BURST LINE CONNECTING FUEL RAILS, CAUSING FUEL TO SPRAY OVER HOT ENGINE/EXHAUST, EXTREME FIRE HAZARD. CANNOT BE DRIVEN …
Read full complaint
UPON EXITING VEHICLE AFTER SHORT TRIP (2 MILES), NOTICED STRONG FUEL ODOR. LOOKED UNDER TRUCK AND OBSERVED FUEL STREAMING DOWN OVER HOT EXHAUST PIPE BENEATH ENGINE COMPARTMENT. INSPECTION OF ENGINE REVEALED BURST LINE CONNECTING FUEL RAILS, CAUSING FUEL TO SPRAY OVER HOT ENGINE/EXHAUST, EXTREME FIRE HAZARD. CANNOT BE DRIVEN DUE TO FIRE HAZARD. LINE IS NOT RUBBING ON ANYTHING OR FLEXING TO CAUSE FAILURE. *TR
NHTSA ODI #10622216
159,770 miles · Feb 26, 2014
Fuel System, Gasoline
DRIVING TRUCK IN TOWN AT APP 30MPH WHEN FUEL TANK FELL FROM TRUCK STRIKING PAVEMENT. OPENED A 5INCH HOLE IN TANK LETTING FUEL ESCAPE ONTO ROAD & VEHICLE. TANK FELL BETWEEN TRUCK FRAME AT ANGLE MAKING CONTACT WITH ROAD. FUEL SPRAY ON ROAD & TRUCK UNTIL ABLE TO STOP. *TR
NHTSA ODI #10566121
100,000 miles · Jan 7, 2012
Fuel System, Gasoline
THE VEHICLE LEAKS FROM THE TOP OF THE TANK. I HAVE HAD IT REPAIRED ONCE BY A DODGE DEALERSHIP BUT IT HAS STARTED LEAKING AGAIN AROUND THE FUEL PUMP. I HAD THE FUEL PUMP REPLACED AND IT HAS STARTED LEAKING AGAIN. I HAVE HAD IT CHECKED BY ANOTHER DEALER AND THE TANK ITSELF IS CRACKING. THEY NOTED NO DAMAGE AROUND TANK OR TO OT…
Read full complaint
THE VEHICLE LEAKS FROM THE TOP OF THE TANK. I HAVE HAD IT REPAIRED ONCE BY A DODGE DEALERSHIP BUT IT HAS STARTED LEAKING AGAIN AROUND THE FUEL PUMP. I HAD THE FUEL PUMP REPLACED AND IT HAS STARTED LEAKING AGAIN. I HAVE HAD IT CHECKED BY ANOTHER DEALER AND THE TANK ITSELF IS CRACKING. THEY NOTED NO DAMAGE AROUND TANK OR TO OTHER COMPONENTS. THEY TESTED THE ORIGINAL PUMP AND IT DID NOT LEAK. THE LEAK CAME BACK ONCE THE FUEL PUMP SEAL BEGAN TO DRY OUT. *TR
NHTSA ODI #10442765
147,000 miles · May 12, 2011
Fuel System, Gasoline
TL* THE CONTACT OWNS A 1997 DODGE 1500. THE CONTACT STATED THAT THE FUEL TANK DETACHED FROM THE VEHICLE DUE TO CORRODED STRAPS. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR SHOP WHO CONFIRMED THAT THE FAILURE HAD OCCURRED AS A RESULT OF CORROSION. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE AND THE VEHICLE WAS NOT REPAIRED. TH…
Read full complaint
TL* THE CONTACT OWNS A 1997 DODGE 1500. THE CONTACT STATED THAT THE FUEL TANK DETACHED FROM THE VEHICLE DUE TO CORRODED STRAPS. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR SHOP WHO CONFIRMED THAT THE FAILURE HAD OCCURRED AS A RESULT OF CORROSION. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE AND THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 147,000.
NHTSA ODI #10400579
200,000 miles · Mar 18, 2007
Fuel System, Gasoline
THE GAS TANK STRAP RUSTED OUT ON THE 1997 DODGE RAM 1500 EXTENDED CAB THAT WE OWN. IT WAS BEING HELD UP BY ONLY ONE STRAP.
NHTSA ODI #10185454
131,000 miles · Nov 2, 2006
Fuel System, Gasoline
GASOLINE TANK STARTED LEAKING DUE TO STRESS CRACK FAILURE. NO INDICATION OF MECHANICAL WEAR AT THE FAILURE POINT, APPEARS TO BE A FAILURE OF THE PLASTIC. *NM
NHTSA ODI #10172475
71,000 miles · Jul 10, 2006
Fuel System, Gasoline
FUEL PUMP FAILURE. *JB
NHTSA ODI #10161987
93,800 miles · Nov 28, 2005
Fuel System, GasolinePower Train
I OWN A 1997 DODGE RAM 1500 W/93,000 ON IT THE PROBLEMS BEGAN THE RADIATOR $250 JUST FOR THE PART WENT BAD THEN TRANSMISSION WENT OUT DODGE IS INFAMOUS FOR THE TRANSMISSION PROBLEMS I HAD TO PAY $1900 TO GET IT FIXED AFTER THAT WAS DONE THE FUEL RAIL & O RING STARTED TO LEAK ANOTHER WELL KNOW DEFECT ON CHRYSLER VEHICLES MY TRUCK…
Read full complaint
I OWN A 1997 DODGE RAM 1500 W/93,000 ON IT THE PROBLEMS BEGAN THE RADIATOR $250 JUST FOR THE PART WENT BAD THEN TRANSMISSION WENT OUT DODGE IS INFAMOUS FOR THE TRANSMISSION PROBLEMS I HAD TO PAY $1900 TO GET IT FIXED AFTER THAT WAS DONE THE FUEL RAIL & O RING STARTED TO LEAK ANOTHER WELL KNOW DEFECT ON CHRYSLER VEHICLES MY TRUCK WAS VISIBLY LOSING GAS & OBVIOUSLY DANGEROUS THERE IS NO WAY TO REPAIR THE DEFECTIVE CAP YOU HAVE TO BUY THE WHOLE FUEL RAIL FROM THE DEALER FOR $300 JUST FOR THE PART. I THINK THAT IS NOT ONLY RIDICULOUS BUT DANGEROUS & AN OBVIOUS PROBLEM WITH OTHER CHYRSLER VEHICLES & YET NOTHING HAS BEEN DONE. *JB
NHTSA ODI #10143795
40 miles · Apr 13, 2005
Fuel System, GasolineLatches/locks/linkagesService Brakes, Air
A LONG LIST IS AVAILABLE AT HUMES OF WATERFORD,PA. THE MOST AMAZING FAILURE OF THE VEHICHLE WAS WHEN THE DRIVER'S DOOR FLEW OPEN WHILE DRIVING AROUND THE BEND AND I WAS LUCKY THAAT NO ONCOMING TRAFFIC WAS COMING. HUMES(DEALER) FIXED IT BY A HORRIBLE WELD ON THE LATCH.*AK
NHTSA ODI #10116859
Mileage unknown · Jan 31, 2005
Air BagsFuel System, Gasoline
STARTED SMELLING STRONG GAS FUMES. HAD CHECKED AND FOUND GAS TANK WAS CRACKED ON TOP AND RUNNING DOWN BOTH SIDES VERY CLOSE TO EXHAUST PIPES. FIRE HAZARD. HAD TO HAVE GAS TANK AND FUEL PUMP REPLACED AT MY EXPENSE. SEEMS TO ME A GAS TANK SHOULD LAST LONGER THAN 7 YEARS OR BE A FACTORY DEFECT.*AK
NHTSA ODI #10108289
Official recalls
0
No recalls in this snapshot.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
DP03006 · Seat Back Failure
Opened Sep 23, 2003 · Closed Apr 8, 2004
Status: closed (inferred from source dates) · Seats; Seats:front Assembly:recliner
ODI HAS IDENTIFIED 30 INCIDENTS WHERE IT IS ALLEGED THE SEAT BACK COLLAPSED IN A REAR IMPACT CRASH.THESE INCIDENTS ARE ALLEGED TO HAVE CONTRIBUTED TO 23 INJURIES AND TWO DEATHS.THE DATA PRESENTED TO ODI SHOW THAT THE SEAT BACK STRENGTH OF THE FRONT SEATS COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 207. SEATING SYSTEM.ACCORDING TO DAIMLERCHRYLSER THE FRONT SEATS WERE DESIGNED TO COLLAPSE REARWARD IN REAR IMPACT CRASHES AS PART OF THE ENERGY ABSORPTIONCAPABILITIES OF THE SEATING SYSTEM TO REDUCE THE CHANCE OF SERIOUS INJURY TO THE OCCUPANT.RATES OF OCCURANCE WERE COMPARED TO PEER VEHICLES, AND IT WAS SHOWN THAT THE PERFORMACE OF THE SUBJECT VEHICLE WAS COMPARABLE TO THOSE VEHICLES.IN VIEW OF THE FORGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION REMEDY OF A SAFETY DEFECT IN THE SUBJECT VEHICLES AS DEFINED BY THE PETITIONER AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THERFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE THE NHTSA'S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY'S MISSION, THE PETITION IS DENIED.FOR FURTHER DETAILS, REFER TO ODI'S RESPONSE TO THE PETITION PUBLISHED IN THE FEDERAL REGISTER VOL.69, NO. 60 , DATED MARCH 29, 2004.
Additional source detail variants (2)
Seats
ODI HAS IDENTIFIED 30 INCIDENTS WHERE IT IS ALLEGED THE SEAT BACK COLLAPSED IN A REAR IMPACT CRASH.THESE INCIDENTS ARE ALLEGED TO HAVE CONTRIBUTED TO 23 INJURIES AND TWO DEATHS.THE DATA PRESENTED TO ODI SHOW THAT THE SEAT BACK STRENGTH OF THE FRONT SEATS COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 207. SEATING SYSTEM.ACCORDING TO DAIMLERCHRYLSER THE FRONT SEATS WERE DESIGNED TO COLLAPSE REARWARD IN REAR IMPACT CRASHES AS PART OF THE ENERGY ABSORPTIONCAPABILITIES OF THE SEATING SYSTEM TO REDUCE THE CHANCE OF SERIOUS INJURY TO THE OCCUPANT.RATES OF OCCURANCE WERE COMPARED TO PEER VEHICLES, AND IT WAS SHOWN THAT THE PERFORMACE OF THE SUBJECT VEHICLE WAS COMPARABLE TO THOSE VEHICLES.IN VIEW OF THE FORGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION REMEDY OF A SAFETY DEFECT IN THE SUBJECT VEHICLES AS DEFINED BY THE PETITIONER AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THERFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE THE NHTSA'S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY'S MISSION, THE PETITION IS DENIED.FOR FURTHER DETAILS, REFER TO ODI'S RESPONSE TO THE PETITION PUBLISHED IN THE FEDERAL REGISTER VOL.69, NO. 60 , DATED MARCH 29, 2004.
Seats:front Assembly:recliner
ODI HAS IDENTIFIED 30 INCIDENTS WHERE IT IS ALLEGED THE SEAT BACK COLLAPSED IN A REAR IMPACT CRASH.THESE INCIDENTS ARE ALLEGED TO HAVE CONTRIBUTED TO 23 INJURIES AND TWO DEATHS.THE DATA PRESENTED TO ODI SHOW THAT THE SEAT BACK STRENGTH OF THE FRONT SEATS COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 207. SEATING SYSTEM.ACCORDING TO DAIMLERCHRYLSER THE FRONT SEATS WERE DESIGNED TO COLLAPSE REARWARD IN REAR IMPACT CRASHES AS PART OF THE ENERGY ABSORPTIONCAPABILITIES OF THE SEATING SYSTEM TO REDUCE THE CHANCE OF SERIOUS INJURY TO THE OCCUPANT.RATES OF OCCURANCE WERE COMPARED TO PEER VEHICLES, AND IT WAS SHOWN THAT THE PERFORMACE OF THE SUBJECT VEHICLE WAS COMPARABLE TO THOSE VEHICLES.IN VIEW OF THE FORGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION REMEDY OF A SAFETY DEFECT IN THE SUBJECT VEHICLES AS DEFINED BY THE PETITIONER AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THERFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE THE NHTSA'S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY'S MISSION, THE PETITION IS DENIED.FOR FURTHER DETAILS, REFER TO ODI'S RESPONSE TO THE PETITION PUBLISHED IN THE FEDERAL REGISTER VOL.69, NO. 60 , DATED MARCH 29, 2004.
1997 Dodge RAM 1500 Problems, Complaints & Recalls | Skip That Year
Illustration