Electrical System. Review the 133 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Fuel System, Gasoline. Review the 82 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Fuel/propulsion System. Review the 57 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

16 crash reports11 fire reports14 injury reports

Electrical System complaints

133 reports

Clear category filter

Mileage unknown · Mar 9, 2011

Electrical SystemExterior LightingVisibility

THE WIPER BLADES STOPPED WORKING DURING A RAIN STORM AND THE TURN SIGNALS WOULDN'T WORK, COULDN'T TURN THE HEAD LAMPS OFF OR ON.

NHTSA ODI #10390788

39,000 miles · Jan 2, 2011

Electrical SystemEngine And Engine CoolingFuel System, Gasoline

Read full complaint

FIRST REPAIR: VEHICLE WOULD JERK (AS IF IT WAS SHIFTING TOO HARD) WHEN GOING OVER BUMPS IN THE ROAD AND WOULD STOP (RPM GAUGE DROPS TO 0, LOSE POWER STEERING, WOULD HAVE TO COAST TO SHOULDER AND RE-START VEHICLE). FUEL INJECTOR WAS REPLACED. SECOND REPAIR: VEHICLE WOULD NOT START WITHOUT SEVERAL ATTEMPTS, ONCE IT STARTED IT WOULD STOP DRIVING (RPM GAUGE DROPS TO 0, LOSE POWER STEERING, WOULD HAVE TO COAST TO SHOULDER AND RE-START VEHICLE). RELAY WAS REPLACED. THIRD REPAIR (ABOUT TO GO BACK TO SHOP TOMORROW)- CAR STARTED NORMALLY AND THEN STOPPED WHILE DRIVING (RPM GAUGE DROPS TO 0, LOSE POWER STEERING, WOULD HAVE TO COAST TO SHOULDER AND RE-START VEHICLE). THIS IS THE THIRD TIME IN 2 WEEKS THAT THE CAR HAS BEEN IN FOR SERVICING FOR THE SAME PROBLEM, AND THE MANUFACTURER'S DEALERSHIP CANNOT FIGURE OUT WHAT IS WRONG WITH THE VEHICLE. THIS HAS BECOME A MAJOR SAFETY CONCERN, AS I DO NOT KNOW WHEN THE VEHICLE WILL STOP UNEXPECTEDLY WHILE DRIVING. I HAVE RENTED A CAR UNTIL I CAN HAVE MY CAR REPAIRED AGAIN, BECAUSE I AM AFRAID TO DRIVE MY CAR. *TR

NHTSA ODI #10373806

19,000 miles · Sep 21, 2010

Electrical System

Read full complaint

I PURCHASED A '07 DODGE NITRO BACK IN JUNE OF THIS YEAR. RECENTLY IT BEGAN DOING A "SHUT OFF" WHILE GOING ABOUT 80 MPH, DID THAT TWICE WITHIN A FEW MINUTES, SCARED THE CRAP OUT OF ME. THE NEXT DAY IT STALLED WHILE TURNING INTO MY DRIVEWAY, EACH TIME IT HAS STARTED RIGHT BACK UP ON ITS OWN NO PROBLEM. LAST NIGHT I WENT TO GO PICK UP MY SON FROM CLASS GO TO UNLOCK THE DOORS AND GOT NO RESPONSE, TRUCK WAS DEAD AS DEAD CAN GET. HAD MY HUSBAND JUMP IT AND IT STARTED RIGHT UP. THIS MORNING IT WENT DEAD AGAIN WHILE I WAS WAITING IN A DRIVE-THRU LINE, HAD PEOPLE YELLING AT ME RATHER THEN ASKING IF I NEEDED HELP, FINALLY FLAGGED SOMEONE DOWN AND GOT A JUMP, AGAIN STARTED RIGHT UP NO PROBLEM. I KNOW THERE IS A RECALL OUT FOR TIPM ON VEHICLES BUILT BEFORE JANUARY 23, 2007. MINE WAS BUILT IN NOVEMBER OF '06 BUT WHEN I CHECKED THE DODGE SITE AND ENTERED MY VIN AS IT INSTRUCTED IT ONLY PULLED UP THE WIPER RELAY RECALL. I THEN CALLED MY LOCAL DODGE DEALERSHIP AND TOLD THEM ABOUT MY ISSUE AND HOW I FOUND THAT THERE WAS A RECALL ON CERTAIN VEHICLES FOR THE TIPM CAUSING IT TO STALL OUT, THEY TOLD ME THERE NEVER WAS SUCH A RECALL AND THEY HAD NEVER HEARD OF THAT EVER HAPPENING. I SET UP AN APPOINTMENT TO HAVE IT LOOKED AT( IT IS STILL UNDER WARRANTY) AND PRINTED OUT THE RECALL TO SHOW THEM WHEN I GET THERE, UNFORTUNATELY I CAN'T GET IN UNTIL THURSDAY WHICH MEANS I HAVE TO DRIVE SCARED OUT OF MY WITS FOR THE NEXT COUPLE DAYS. IF IT ISN'T FIXABLE THEN I MAY HAVE TO LOOK INTO GETTING RID OF MY BELOVED NITRO AS I CANNOT HAVE THIS HAPPENING WHEN I HAVE SMALL CHILDREN IN THE CAR. *TR

NHTSA ODI #10356741

57,000 miles · Jul 15, 2010

Electrical System

MY 2007 DODGE NITRO SPONTANEOUSLY LIT ALL WARNING INDICATORS AND STALLED. WHEN I CONTACTED DAIMLER CHRYSLER ABOUT RECALL G25 OR NHTSA CAMPAIGN ID 07V291. THEY INDICATED THAT ONLY CANADIAN MADE VEHICLES WERE PART OF THIS EARLIER RECALL. *TR

NHTSA ODI #10343459

27,629 miles · Mar 6, 2010

Electrical System

Read full complaint

MY 2007 DODGE NITRO HAS BEEN HAVING STALLING ISSUES THE LAST TWO WEEKS. WHEN I PRESS THE ACCELERATOR, IT HESITATES AND ALMOST CUTS OFF. THERE IS NO PATTERN AS TO WHEN IT HAPPENS; IT IS INCONSISTENT. YESTERDAY, AFTER I PICKED UP CARPOOL AT MY SON'S ELEMENTARY SCHOOL, I MADE A RIGHT TURN, AND THE CAR COMPLETELY CUT OFF WHEN I HIT THE ACCELERATOR. I HAD TO COAST TO A STOP (I HAD NO POWER STEERING OR POWER BRAKES) AND RESTART THE CAR. FORTUNATELY, I WAS NOT MAKING A RIGHT TURN ONTO A BUSY ROAD OR INTO AN INTERSECTION AS THERE WOULD HAVE BEEN NOTHING I COULD HAVE DONE TO PREVENT AN ACCIDENT WITH 2 SECOND GRADERS IN THE BACK SEAT. IT WILL BE HEADING TO THE DEALERSHIP TO BE CHECKED OUT. *TR

NHTSA ODI #10317303

16,750 miles · Nov 17, 2009

Electrical System

Read full complaint

ALARM SYSTEM MALFUNCTION. ALARM WOULD ACTIVATE AND STOP, ACTIVATE AND STOP. ACCORDING TO NEIGHBORS, THIS HAPPENED ON AND OFF FROM FRIDAY NIGHT 11/13/09 THROUGH SUNDAY 11/15/09. I WAS OUT OF TOWN AT THE TIME. VEHICLE WAS SITTING IN DRIVEWAY. THIS ISSUE ANNOYED MY NEIGHBORS BIG TIME. THIS PROBLEM HAS ANNOYED A NEIGHBOR SO BAD, THAT I FEEL THREATENED BY HIM, AND HAD TO CALL TO STATE POLICE ON HIM FOR PARKING ACROSS THE STREET FROM MY HOUSE AND REVVING HIS TRUCK ENGINE, FLASHING HIS HEADLIGHTS AND HONKING HIS HORN WHILE FACING MY HOUSE. I HAD TO HAVE THE VEHICLE TOWED TO THE DEALERSHIP WHERE I PURCHASE THE NITRO. THEY COULD NOT FIND ANY PROBLEMS WITH THE ALARM SYSTEM, BUT I DO NOT BUY THIS AT ALL. SOMETHING HAPPENED TO CAUSED THE ALARM SYSTEM TO MALFUNCTION OVER A 2 DAY PERIOD. I WAS TOLD BY THE DEALERSHIP, ONCE AN ALARM IS ACTIVATED, IT DOES NOT RESET ITSELF, AND SHOULD NOT GO OFF AGAIN UNTIL IT IS RESET. I WANT TO KNOW WHAT HAPPENED. THE CAR HAD BEEN VANDALIZED, I.E. CUT WIRES, BUT I THINK THIS WAS DONE OUT OF SHEAR ANGER BY SOMEONE ANNOYED BY THE ALARM GOING OFF ALL THE TIME, BUT I CANNOT PROVE THIS. BUT STILL, THE ALARM SYSTEM SHOULD NOT HAVE CONTINUED TO ACTIVATE ITSELF. *TR

NHTSA ODI #10292627

38,000 miles · Sep 23, 2009

Electrical SystemEngine And Engine Cooling

Read full complaint

I HAVE A 2007 DODGE NITRO THAT I PURCHASED IN 2007. WITHIN A FEW MONTHS OF OWNING I TOOK IT TOO THE DEALER TO HAVE THE BELOW RECALL ITEM FIXED. I HAVE HAD PROBLEMS RECENTLY (3 TO BE EXACT) WHEN DRIVING DOWN THE ROAD AT 50-60MPH THE ENGINE WILL SHUT OFF AND ALL THE LIGHTS ON THE INSTRUMENT PANEL WILL COME ON. ONCE THE ENGINE STALLS I AM UNABLE TO STEER OR BRAKE. I HAVE NOTICE ON THE WEB THAT THERE ARE SEVERAL OTHER 2007 DODGE NITRO OWNERS EXPERIENCING THE SAME ISSUE. PLEASE LET ME KNOW WHAT ACTION I CAN TAKE IN THIS MATTER WITH CHRYSLER DODGE. I HAVE YET ANOTHER SERVICE APPT SET WITH MY DEALER. MAKE: DODGE MODEL: NITRO MODEL YEAR: 2007 MANUFACTURER: DAIMLERCHRYSLER CORPORATION MFR'S REPORT DATE: JUL 03, 2007 NHTSA CAMPAIGN ID NUMBER: 07V291000 PE07027 NHTSA ACTION NUMBER: PE07027 COMPONENT: ELECTRICAL SYSTEM POTENTIAL NUMBER OF UNITS AFFECTED: 80894 SUMMARY: ON CERTAIN VEHICLES, THE TOTALLY INTEGRATED POWER MODULE (TIPM) WAS PROGRAMMED WITH SOFTWARE THAT MAY ALLOW THE ENGINE TO STALL UNDER CERTAIN OPERATING CONDITIONS. CONSEQUENCE: THIS COULD CAUSE A CRASH WITHOUT WARNING. REMEDY: DEALERS WILL REPROGRAM THE TIPM. THE RECALL BEGAN ON JULY 5, 2007. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403. NOTES: DAIMLERCHRYSLER RECALL NO. G25. CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV. *TR

NHTSA ODI #10285071

80,000 miles · Feb 7, 2009

Electrical System

DODGE NITRO PROBLEM WITH STATIC ELECTRICITY MAKING THE VEHICLE NOT START. THEY SAY IT IS NOT A SAFETY ISSUE WARRANTING A RECALL. I SAY THAT DEPENDS ON WHERE YOU ARE WHEN IT DECIDES NOT TO START. *TR

NHTSA ODI #10257789

13,000 miles · Jan 28, 2009

Electrical System

DRIVING TO WORK WHEN TRUCK STALLED AND STALLED AGAIN WHILE GOING TO MY FATHERS HOUSE THEN TOOK IT TO DEALER AND THEY SAID NOTHING WAS WRONG. *TR

NHTSA ODI #10256612

17,000 miles · Dec 31, 2008

Electrical SystemFuel System, GasolinePower Train

Read full complaint

UNCONTROLLED ACCELLERATION OF 2007 DODGE NITRO, W/3.7 LITRE, HAS HAPPENED 5 TIMES IN SIX MONTHS OF OWNING . CANT BE FIXED BY DEALER CAUSE DOESN'T SHOW CODE OR ABLE TO DUPLICATE WHEN THEY HAVE IT , ONLY WAY TO STOP IT IS TO PUT IN NEUTRAL AND KILL ENGINE . HAVE HAD OTHER PROBLEMS LIKE IDLE ROUGH AND SURGING , AND LIKE SOMEONE TURNING KEY OFF AND ON FOR SPLIT SECOND WHILE DRIVING AT HIGHWAY SPEEDS. THERE HAS NOT BEEN ANY PATTERN TO WHEN SUDDEN ACEL HAPPENS , IT HAS BEEN RANDOM AND CAN SEEMINGLY HAPPEN W/OUT NOTICE. THE DEALER KEEPS TELLING ME TO KEEP DRIVING IT TILL IT DOES IT AGAIN SO THEY CAN TRY TO GET CODES OR SOMETHING TO TROUBLE SHOOT IT. BUT THIS IS VERY DANGEROUS AS YOU WOULD THINK. IM AT A LOSS TO WHAT TO DO , I HAVE CONTACTED DODGE COMPLAINT LINE AND THEY DON'T SEEM TO WORRIED ABOUT MY SAFETY AS IT WOULD SEEM , DO TO THEM WANTING ME TO KEEP BRINGING IT BACK TO DEALER . ALSO NO PARTS HAVE BEEN CHANGED IN ORDER TO TRY TO CORRECT ,ONLY HOOK UP SCANNER AND DRIVE AROUND BLOCK AND FLASH PROGRAMS AT IT WHICH HAS SEEMINGLY HAD ILL AFFECT ON IT AS IN MY FUEL MILEAGE HAS WENT 23-24 HIGHWAY TO ABOUT 15-18 NOW, AND THEY CANT GET IT BACK WHERE IT WAS, NOW IT IS PARKED IN DRIVEWAY AND FAMILY WONT DRIVE BECAUSE SCARED OF IT, AND I M STILL PAYING ON VEHICLE THAT IS UNSAFE AND NO IDEA HOW TO FIX , OR DODGE I SHOULD SAY, CANT FIX. *TR

NHTSA ODI #10253391

Official recalls

20V396000 · Air Bags:frontal:driver Side:inflator Module; Steering: Steering Wheel/handle Bar

Jul 7, 2020

Chrysler (FCA US LLC) is recalling certain 2008-2010 Chrysler Town and Country and Dodge Grand Caravan and 2007-2011 Dodge Nitro vehicles. These vehicles may have a loose or missing brand emblem in the center of the steering wheel. The loose emblem or the securing nuts for the emblem within the driver air bag module may become projectiles in the event of a driver air bag deployment.

Consequence & remedy

Consequence: Projectiles as a result of driver air bag deployment in the event of a crash can increase the risk of injury.

Remedy: Chrysler will notify owners, and dealers will replace the driver's air bag cover with a redesigned cover, free of charge. The recall began February 11, 2021. Owners may contact FCA US LLC customer service at 1-800-853-1403. Chrysler's number for this recall is W09.

Additional source detail variants (2)

Air Bags:frontal:driver Side:inflator Module

Consequence: Projectiles as a result of driver air bag deployment in the event of a crash can increase the risk of injury.

Remedy: Chrysler will notify owners, and dealers will replace the driver's air bag cover with a redesigned cover, free of charge. The recall began February 11, 2021. Owners may contact FCA US LLC customer service at 1-800-853-1403. Chrysler's number for this recall is W09.

Steering: Steering Wheel/handle Bar

Consequence: Projectiles as a result of driver air bag deployment in the event of a crash can increase the risk of injury.

13V121000 · Air Bags; Power Train:driveline:driveshaft; Structure

Apr 3, 2013

Chrysler Group LLC (Chrysler) is recalling certain model year 2007-2008 Dodge Nitro 4X2 vehicles manufactured March 21, 2006, through March 1, 2008; and 2008 Jeep Liberty 4X2 vehicles manufactured February 15, 2007, through March 1, 2008. The transfer case heat shield may drop down and rub on the drive shaft, weakening it and potentially causing the drive shaft to break.

Consequence & remedy

Consequence: If the drive shaft breaks, a section of it can strike the transfer case tunnel with enough force that the airbag computer will believe the vehicle is in a crash and thus deploy the airbags. Additionally, the drive shaft failure will result in a loss of motive power. Either condition may increase the risk of a crash.

Remedy: Chrysler will notify owners, and dealers will add a bracket to support the rear of the heat shield, free of charge. An interim letter was mailed to owners on May 29, 2013. Owners may contact Chrysler at 1-800-247-9753. Chrysler's recall campaign number is N10.

Additional source detail variants (3)

Structure

Consequence: If the drive shaft breaks, a section of it can strike the transfer case tunnel with enough force that the airbag computer will believe the vehicle is in a crash and thus deploy the airbags. Additionally, the drive shaft failure will result in a loss of motive power. Either condition may increase the risk of a crash.

Remedy: Chrysler will notify owners, and dealers will add a bracket to support the rear of the heat shield, free of charge. An interim letter was mailed to owners on May 29, 2013. Owners may contact Chrysler at 1-800-247-9753. Chrysler's recall campaign number is N10.

Air Bags

Power Train:driveline:driveshaft

09V438000 · Visibility:windshield Wiper/washer

Nov 6, 2009

CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2007 DODGE NITRO PASSENGER VEHICLES. THE WINDSHIELD WIPER SYSTEM MAY EXPERIENCE A CONDITION OVER TIME WHERE HIGH USAGE OF THE VARIABLE PAUSE WIPER FUNCTION ("DELAY" MODE) MAY EVENTUALLY AFFECT PRIMARY WIPER FUNCTION, RENDERING THE WIPER SYSTEM INOPERABLE.

Consequence & remedy

Consequence: INOPERATIVE WIPERS UNDER INCLEMENT WEATHER CONDITIONS COULD CAUSE IMPAIRED VISIBILITY INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL INSPECT AND ADD EXTERNAL RELAYS AND UPDATE THE TOTALLY INTEGRATED POWER MODULE SOFTWARE TO CONTROL THE WIPER FUNCTIONS. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING FEBRUARY 2010. OWNERS MAY CONTACT CHRYSLER AT 1-800-835-1403.

08V525000 · Parking Brake

Oct 8, 2008

CHRYSLER IS RECALLING 3,663 MY 2007-2008 DODGE NITRO AND MY 2008 JEEP LIBERTY VEHICLES EQUIPPED WITH MANUAL TRANSMISSIONS. THE PARK BRAKE LEVER CLUTCH DRUM MAY DISTORT AND REDUCE THE EFFECTIVENESS OF THE PARK BRAKE SYSTEM.

Consequence & remedy

Consequence: THIS COULD ALLOW THE VEHICLE TO MOVE INADVERTENTLY AND CAUSE A CRASH WITHOUT WARNING.

Remedy: DEALERS WILL REPLACE THE PARK BRAKE LEVER ASSEMBLY FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 27, 2008. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

07V434000 · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module

Sep 14, 2007

ON CERTAIN SPORT UTILITY VEHICLES, THE SOFTWARE PROGRAMMED INTO THE ABS ELECTRONIC CONTROL MODULE MAY ALLOW A MOMENTARY DELAY IN BRAKING WHEN COASTING UP A HILL DURING CERTAIN CONDITIONS.

Consequence & remedy

Consequence: THIS COULD CAUSE A CRASH WITHOUT WARNING.

Remedy: DEALERS WILL REPROGRAM THE ABS ELECTRONIC CONTROL MODULE WITH NEW SOFTWARE THAT PREVENTS THIS CONDITION FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 22, 2007. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

07V291000 · Electrical System

Jul 3, 2007

ON CERTAIN VEHICLES, THE TOTALLY INTEGRATED POWER MODULE (TIPM) WAS PROGRAMMED WITH SOFTWARE THAT MAY ALLOW THE ENGINE TO STALL UNDER CERTAIN OPERATING CONDITIONS.

Consequence & remedy

Consequence: THIS COULD CAUSE A CRASH WITHOUT WARNING.

Remedy: DEALERS WILL REPROGRAM THE TIPM. THE RECALL BEGAN ON JULY 5, 2007. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

06V493000 · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module

Dec 29, 2006

ON CERTAIN VEHICLES, THE ANTILOCK BRAKE SYSTEM (ABS) CONTROL MODULE SOFTWARE MAY CAUSE THE REAR BRAKES TO LOCK UP DURING CERTAIN BRAKING CONDITIONS.

Consequence & remedy

Consequence: THIS COULD RESULT IN A LOSS OF VEHICLE CONTROL AND CAUSE A CRASH WITHOUT WARNING.

Remedy: DEALERS WILL REPROGRAM THE ABS ELECTRONIC CONTROL UNIT. THE RECALL BEGAN ON FEBRUARY 19, 2007. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

DP14004 · Totally Integrated Power Module Failure

Opened Sep 25, 2014 · Closed Jul 24, 2015

Status: closed (inferred from source dates) · Electrical System

In a letter dated August 21, 2014, the Center for Auto Safety (CAS) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged failures associated with the Totally Integrated Power Module (TIPM) installed in Chrysler SUV?s, trucks, and vans beginning in the 2007 model year. The petitioner alleges that TIPM defects may result in engine stall, airbag non-deployment, failure of fuel pump shutoff resulting in unintended acceleration, fire, and other symptoms. On September 25, 2014, the Office of Defects Investigation (ODI) opened DP14-004 to evaluate the petition for a grant or deny decision. ODI analyzed complaint data provided by CAS as well as complaints submitted to ODI from consumers. In total, there were 296 complaints submitted by the petitioner in the original petition and five supplements, including 271 complaints related to the subject vehicles equipped with TIPM-7. Approximately 3 percent of CAS complaints are related to vehicles equipped with TIPM-6 and ODI?s review of these complaints did not identify any safety defect trends. ODI conducted a detailed review of complaints narratives submitted by CAS and consumers including careful analysis of vehicle repair histories, warranty claims obtained from the manufacturer and any available Customer Assistance Inquiry reports (CAIR). Analysis of the field data indicated that MY2011-2013 Jeep Grand Cherokee and Dodge Durango vehicles exhibited significantly higher complaint rates related to fuel pump relay (FPR) failures than other subject vehicles. In a September 3, 2014 letter to NHTSA, Chrysler submitted a Defect Information Report (DIR) identifying a defect in the FPR within the TIPM-7 which can result in a no start or stall condition in approximately 188,723 model year (MY) 2011 Jeep Grand Cherokee (WK) and Dodge Durango (WD) vehicles manufactured from January 5, 2010 through July 20, 2011 (14V-530).In a February 24, 2015 letter, Chrysler submitted a second DIR expanding the scope of the FPR defect condition to include an additional 338,216 MY 2012 through 2013 Jeep Grand Cherokee vehicles manufactured from September 17, 2010 through August 19, 2013 and MY 2012 through 2013 Dodge Durango vehicles manufactured from January 18, 2011 through August 19, 2013 (15V-115).ODI analysis of the CAS allegations of TIPM defects resulting in stall while driving, airbag non-deployment, unintended acceleration, fire and other faults identified a single defect condition related to 1 of over 60 different circuits in the TIPM assembly. The most common effect of this defect condition, related to the fuel pump relay, was a no-start concern, but it could also result in stall while driving (76 complaints). No valid evidence was presented in support of claims related to airbag non-deployment, unintended acceleration or fire resulting from TIPM faults and these claims were found to be wholly without merit based on review of the field data and design of the relevant systems and components.Except insofar as the petitioner's contentions relate to the defect condition addressed by the Chrysler recalls, the factual bases of the petitioner's contentions that any further investigation is necessary are unsupported. In our view, additional investigation is unlikely to result in a finding that a defect related to motor vehicle safety exists or a NHTSA order for the notification and remedy of a safety-related defect as alleged by the petitioner at the conclusion of the requested investigation. Therefore, in view of the need to allocate and prioritize NHTSA's limited resources to best accomplish the agency's safety mission, the petition is den

AQ10001 · Fleet Vehicle Recall Completion Audit

Opened Nov 18, 2010 · Closed Dec 28, 2015

Status: closed (inferred from source dates) · Unknown Or Other

On November 18, 2010, NHTSA's Recall Management Division (RMD) opened an audit query (AQ10-001) to investigate recall remedy completion by rental car companies on safety recall campaigns.It was expected to provide the agency an indication of how completely and how quickly rental car fleets perform necessary recall-related remedies on the vehicles owned and then rented/leased for use on the roadways.RMD queried three (3) major motor vehicle manufacturers (Ford, Chrysler, and General Motors) and requested data regarding completion figures for fifteen (15) discreet safety recalls.Analysis of this data demonstrated that rental car recalls completion was neither complete nor consistent.The rental car companies representing the largest market share in the industry were then queried as to their respective policies for the rental, lease, and sale of vehicles with open recalls.The data and responses from the manufacturers and the rental car companies can be found in the document repository by accessing the ?Associated Documents link above.In December 2015, Congress enacted the Fixing America's Surface Transportation (FAST) Act.One section of the Act prohibits rental car companies from renting, leasing, or selling motor vehicles subject to open safety recalls.With the passage of the FAST Act and its prohibition, there is no continuing need for the agency to investigate rental car recall completions.Accordingly, this investigation is closed.The agency reserves the right to open any future investigations, including audits of individual recalls, or groups of recalls, or rental car companies, to examine more closely safety recalls performance and completion issues in this area.

PE07027 · Engine Stalling & Electric Power Loss

Opened May 29, 2007 · Closed Aug 2, 2007

Status: closed (inferred from source dates) · Electrical System; Engine And Engine Cooling; Power Train:automatic Transmission; Power Train:manual Transmission

ON JULY 3, 2007, DAIMLERCHRYSLER CORPORATION (DCC) SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA DESCRIBING A DEFECT THAT COULD RESULT IN ENGINE STALL WHILE DRIVING IN APPROXIMATELY 80,894 MODEL YEAR (MY) 2007 JEEP WRANGLER AND DODGE NITRO VEHICLES MANUFACTURED BETWEEN JANUARY 30, 2006 AND JANUARY 22, 2007 (NHTSA RECALL 07V-291, DCC RECALL G25).ACCORDING TO DCC, THE TOTALLY INTEGRATED POWER MODULE (TIPM) IN THESE VEHICLES WAS PROGRAMMED WITH SOFTWARE THAT MAY ALLOW THE ENGINE TO STALL UNDER CERTAIN CONDITIONS.DCC WILL REPROGRAM THE TIPM IN THE RECALLED VEHICLES WITH REVISED SOFTWARE. ODI OPENED PE07-027 ON MAY 29, 2007, BASED ON 53 COMPLAINTS ALLEGING ENGINE STALL AND/OR LOSS OF ELECTRICAL POWER IN MY 2007 JEEP WRANGLER VEHICLES.ODI WAS ALSO MONITORING SIMILAR COMPLAINTS IN MY 2007 DODGE NITRO VEHICLES.DCC'S ANALYSIS OF COMPLAINTS TO DCC AND NHTSA FOUND THAT MANY DESCRIBED EVENTS WITH A MOMENTARY LOSS OF ELECTRICAL POWER INSIDE THE VEHICLE AND A CORRESPONDING LOSS OF ENGINE POWER.MANY OF THE REPORTS ALSO INDICATED THAT THE INSTRUMENT CLUSTER TELLTALE LAMPS MOMENTARILY ILLUMINATED DURING THE EVENT. DCC'S ENGINEERING ANALYSIS DETERMINED THAT THE TIPM COULD INITIATE AN INTERNAL RESET CYCLE LASTING APPROXIMATELY 75 MS IN RESPONSE TO ERROR MESSAGES ON THE COMMUNICATION BUS.THE KEY ON SIGNAL FROM THE TIPM TO THE POWERTRAIN CONTROL MODULE (PCM) IS LOST DURING A TIPM RESET.IF THE PCM LOSES THE KEY ON SIGNAL FOR LONGER THAN 40 MS, IT INTERPRETS IT AS THE VEHICLE IGNITION BEING TURNED OFF AND BEGINS A POWER DOWN ROUTINE.AFTER THE TIPM RESET, THE KEY ON SIGNAL IS RESTORED AND THE PCM POWERS BACK UP.IF THE ROTATING COMPONENTS OF THE ENGINE CONTAIN SUFFICIENT INERTIA, THE VEHICLE MAY RESTART WITH NO INPUT FROM THE OPERATOR AS REPORTED IN SOME OF THE COMPLAINTS.IF THE ENGINE DOES NOT RESTART IN THIS MANNER, IT CAN BE RESTARTED BY THE OPERATOR.A REVISION TO THE TIPM SOFTWARE ON JANUARY 22, 2007 CHANGED THE TIPM RESET TIME TO 17 MS, REMOVING THE POTENTIAL FOR PCM POWER DOWN AND ENGINE STALL. ODI HAS RECEIVED 178 COMPLAINTS POTENTIALLY RELATED TO THE ALLEGED DEFECT IN MY 2007 JEEP WRANGLER VEHICLES AND 52 COMPLAINTS INVOLVING MY 2007 DODGE NITRO VEHICLES.TWO OF THE NITRO COMPLAINTS ALLEGE THAT A CRASH RESULTED FROM AN ENGINE STALL INCIDENT, ONE OF WHICH CAUSED MINOR INJURIES TO A PASSENGER.AS OF JUNE 1, 2007, DCC IDENTIFIED 151 WRANGLER COMPLAINTS AND 128 NITRO COMPLAINTS. THIS INVESTIGATION HAS BEEN CLOSED WITH DCC'S RECALL.

Additional source detail variants (4)

Electrical System

Engine And Engine Cooling

Power Train:automatic Transmission

Power Train:manual Transmission