Illustration2007 4X2 DODGE NITRO RECALL. THE AIRBAG LIGHT STAYS ON. IT JUST APPEARED OUT OF NOWHERE ABOUT A WEEK AGO
2007 Dodge Nitro 4X2
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Nitro 4X2 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
350–25K
1025–50K
950–75K
1075–100K
11100–150K
8150K+
83 reports with mileage · 12 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 37 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 21 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 10 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
3 crash reports1 fire reports5 injury reports
Air Bags complaints
10 reportsELECTRONICAL ISSUES, LIKE I'M UNABLE T OK OPEN TRUNK OR LOCK AND UNLOCK VEHICLE WITH KEYS CHECK ENGINE LIGHT AS WELL AS AN EXCLAMATION POINT TURNS ON AND OF WHILE CAR IS ON DRIVE. AIRBAG LIGHT DOESN'T TURN OFF EVEN IF BOTH PASSENGER AND DRIVER HAVE SEATBELTS ON IT BEEPS WHILE DRIVING
TL* THE CONTACT OWNS A 2007 DODGE NITRO 4X2. WHILE DRIVING 35 MPH, ALL FOUR WHEELS LOCKED UP AND THE VEHICLE STALLED. THE CONTACT ALSO STATED THAT THE DRIVER SIDE, PASSENGER SIDE, REAR DRIVER SIDE, AND REAR PASSENGER SIDE AIR BAGS DEPLOYED. THE FAILURE OCCURRED WITHOUT WARNING. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. T…
Read full complaint
TL* THE CONTACT OWNS A 2007 DODGE NITRO 4X2. WHILE DRIVING 35 MPH, ALL FOUR WHEELS LOCKED UP AND THE VEHICLE STALLED. THE CONTACT ALSO STATED THAT THE DRIVER SIDE, PASSENGER SIDE, REAR DRIVER SIDE, AND REAR PASSENGER SIDE AIR BAGS DEPLOYED. THE FAILURE OCCURRED WITHOUT WARNING. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT DID NOT RECEIVE NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 13V121000 (POWER TRAIN, AIR BAGS, STRUCTURE). THE CONTACT BELIEVED THAT THE RECALL NOTIFICATION WAS SENT TO THE OWNER FROM WHOM HE BOUGHT THE VEHICLE. THE PARTS TO DO THE REPAIR WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS CONTACTED AT 800-247-9753 AND STATED THAT THEY WOULD NOT REPAIR THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 288,000. *LN CONSUMER STATED AIR BAGS, POWER TRAIN BROKE, 4 WHEELS LOCKED UP. UPDATED 7/25/18*JB
WE WERE DRIVING LIKE EVERY MORNING TO OUR WORK AND WHEN WE TRY TO PASS THE INTERSECTION WE HAVE TO STOP ON A YIELD SIGN TO LET THE OTHER TRAFFIC PASS. WHEN I TRY TO HIT THE ACCELERATE ALL THE LATERAL AIR BAGS EXPLODED WITHOUT REASON AND THE1ST THING WE THOUGHT WAS THAT SOMEONE HIT US. I TRY TO MOVE THE CAR AND THE CAR WASN'T RUN…
Read full complaint
WE WERE DRIVING LIKE EVERY MORNING TO OUR WORK AND WHEN WE TRY TO PASS THE INTERSECTION WE HAVE TO STOP ON A YIELD SIGN TO LET THE OTHER TRAFFIC PASS. WHEN I TRY TO HIT THE ACCELERATE ALL THE LATERAL AIR BAGS EXPLODED WITHOUT REASON AND THE1ST THING WE THOUGHT WAS THAT SOMEONE HIT US. I TRY TO MOVE THE CAR AND THE CAR WASN'T RUNNING AT ALL ALSO I CANNOT STOP IT SO I HAVE TO TURN IN OFF. WE GO OUT OF THE CAR TO SEE IF WE GOT HIT BUT THE CAR DIDN'T HAVE ANYTHING SO WE TRY TO SEE UNDER THE CAR AND ALL THE DRIVE SHAFT WAS CRACKED IN HALF! THE SHERIFFS COME TO THE SCENE AND THEY CAN'T BELIEVE THAT THE CAR WAS IN THAT CONDITION IF WE DIDN'T HAVE A WRECK OR ANYTHING! THEY SAY THAT EVERYTHING LOOKS LIKE A SAFETY RECALL, WE DID A RESEARCH ONLINE AND WAS RIGHT MY CAR HAS A SAFETY RECALL SINCE 2013 AND THEY NEVER SEND ME A LETTER OR CALL ME TO LET ME KNOW ABOUT IT! I DROVE THAT CAR EVERYDAY TO WORK,TO PICK UP MY KIDS FROM SCHOOL ETC..ETC.. AND I CAN'T BELIEVE WHAT HAPPENED I COULD DIE IF MY CAR WASN'T STOP! I WAS VERY LUCKY THAT I WAS ON A YIELD SIGN WHEN EVERYTHING HAPPEN. NOW MY CAR INSURANCE DIDN'T WANT TO PAY ANYTHING BECAUSE THEY FOUND OUT ABOUT THE RECALL AND TOLD ME THAT THE AGENCY HAS TO PAY FOR EVERYTHING BECAUSE THAT WAS A MANUFACTURER PROBLEM! BUT THE DODGE DON'T WANT TO PAY OR FIX ANYTHING THEY ALSO HAVE THE NERVE TO TOLD ME THAT MY CAR DIDN'T HAD A SAFETY RECALL AT ALL EVEN WHEN THE MOPAR PAGE SAY THAT MY CAR DID HAD A RECALL! NOW I'M WITHOUT CAR AND DEALING WITH THE EXPENSES OF TOWING MY CAR ETC..ETC..
TL* THE CONTACT OWNS A 2007 DODGE NITRO 4X2. THE CONTACT STATED THAT THE DOORS AND REAR HATCH WOULD NOT UNLOCK UNLESS THE ENGINE WAS RUNNING. THE CONTACT ALSO STATED THAT THE DRIVER'S SIDE AIR BAG WARNING INDICATOR WAS ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING, BUT THE DETAIL…
Read full complaint
TL* THE CONTACT OWNS A 2007 DODGE NITRO 4X2. THE CONTACT STATED THAT THE DOORS AND REAR HATCH WOULD NOT UNLOCK UNLESS THE ENGINE WAS RUNNING. THE CONTACT ALSO STATED THAT THE DRIVER'S SIDE AIR BAG WARNING INDICATOR WAS ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING, BUT THE DETAILS OF THE DIAGNOSTIC COULD NOT BE PROVIDED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 100,100.
TL* THE CONTACT OWNS A 2007 DODGE NITRO 4X2. THE CONTACT STATED THERE WAS A RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER 13V121000 (AIR BAGS , POWER TRAIN , STRUCTURE) AND THE PART WAS UNAVAILABLE. THE DEALER WAS UNABLE TO PROVIDE AN EXPECTED DATE FOR THE REMEDY PART TO BECOME AVAILABLE. THE MANUFACTURER WAS NOT NOTIFIED OF T…
Read full complaint
TL* THE CONTACT OWNS A 2007 DODGE NITRO 4X2. THE CONTACT STATED THERE WAS A RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER 13V121000 (AIR BAGS , POWER TRAIN , STRUCTURE) AND THE PART WAS UNAVAILABLE. THE DEALER WAS UNABLE TO PROVIDE AN EXPECTED DATE FOR THE REMEDY PART TO BECOME AVAILABLE. THE MANUFACTURER WAS NOT NOTIFIED OF THE PROBLEM. THE CONTACT HAD NOT EXPERIENCED ANY FAILURES. THE VIN WAS UNAVAILABLE.
I WAS AT A STOP LIGHT AND WHEN THE LIGHT TURN GREEN I WAS ABOUT TO GO WHEN I HEARD A LOUD BANG AND THE SIDE AIR BAGS DEPLOYED. MY TRUCK NEVER MOVED.THE DRIVE SHAFT COMPLETELY BROKE IN HALF ,IT LOOKS LIKE WHEN I WAS ABOUT TO TAKE OFF THE DRIVE SHAFT BROKE , SHOT UP AND HIT THE FLOOR BOARD AND THAT CAUSED THE AIR BAGS TO DEPLOY. T…
Read full complaint
I WAS AT A STOP LIGHT AND WHEN THE LIGHT TURN GREEN I WAS ABOUT TO GO WHEN I HEARD A LOUD BANG AND THE SIDE AIR BAGS DEPLOYED. MY TRUCK NEVER MOVED.THE DRIVE SHAFT COMPLETELY BROKE IN HALF ,IT LOOKS LIKE WHEN I WAS ABOUT TO TAKE OFF THE DRIVE SHAFT BROKE , SHOT UP AND HIT THE FLOOR BOARD AND THAT CAUSED THE AIR BAGS TO DEPLOY. THE DRIVE SHAFT LOOKS LIKE IT TWISTED. I HAVEN'T FIXED THE VEHICLE YET AND IM HOPING DODGE WILL COVER THE EXPENSES. LUCKILY I WASN'T IN THE HIGHWAY BECAUSE IT COULD HAVE CAUSED MY TRUCK TO FLIP. *TR
I WAS TAKING A LEFT TURN AT AN INTERSECTION TRAVELING APPROXIMATELY 5MPH. AT THE COMPLETION OF THE TURN I HEARD A LOUD BANG AND THE SIDE IMPACT AIRBAGS DEPLOYED. UPON INSPECTING THE VEHICLE IT WAS FOUND THAT THE DRIVE SHAFT HAD TWISTED AND FALLEN OUT OF THE TRANSMISSION. THE CASING ALONG THE TOP OF THE NITRO CRACKED, AND CAUSED …
Read full complaint
I WAS TAKING A LEFT TURN AT AN INTERSECTION TRAVELING APPROXIMATELY 5MPH. AT THE COMPLETION OF THE TURN I HEARD A LOUD BANG AND THE SIDE IMPACT AIRBAGS DEPLOYED. UPON INSPECTING THE VEHICLE IT WAS FOUND THAT THE DRIVE SHAFT HAD TWISTED AND FALLEN OUT OF THE TRANSMISSION. THE CASING ALONG THE TOP OF THE NITRO CRACKED, AND CAUSED DAMAGE TO THE INTERIOR HEADLINER AND WINDSHIELD. THE CAR WOULD NOT GO INTO DRIVE OR PARK INDICATING DAMAGE TO THE TRANSMISSION AS WELL. UPON INSPECTION BY TWO SEPARATE BODY SHOPS (ONE BEING A DEALERSHIP) IT WAS DETERMINED THAT THERE WAS DAMAGE TO THE DRIVE SHAFT THAT RESULTED IN THE INCIDENT. AT THIS TIME THE WARRANTY IS IN THE PROCESS OF REPLACING THE DRIVE SHAFT. *TR
TL*THE CONTACT OWNS A 2007 DODGE NITRO. WHILE THE CONTACT DROVE IN RUSH HOUR TRAFFIC AT APPROXIMATELY 25 MPH A VEHICLE CRASHED INTO THE LEFT FRONT END OF HER VEHICLE. THE DRIVERS FRONTAL AIR BAG DEPLOYED. THE CONTACT SUSTAINED BURNS TO HER HAND, ARM, AND LEGS. THE VEHICLE WAS TOWED TO A LOCAL REPAIR FACILITY. THE GWINNETT COUNTY…
Read full complaint
TL*THE CONTACT OWNS A 2007 DODGE NITRO. WHILE THE CONTACT DROVE IN RUSH HOUR TRAFFIC AT APPROXIMATELY 25 MPH A VEHICLE CRASHED INTO THE LEFT FRONT END OF HER VEHICLE. THE DRIVERS FRONTAL AIR BAG DEPLOYED. THE CONTACT SUSTAINED BURNS TO HER HAND, ARM, AND LEGS. THE VEHICLE WAS TOWED TO A LOCAL REPAIR FACILITY. THE GWINNETT COUNTY POLICE DEPARTMENT REPORT NUMBER IS 10-058161. THE MANUFACTURER WILL BE CONTACTED. THE FAILURE AND CURRENT MILEAGES WERE 52,000.
SIDE CURTAIN AIRBAG FAILED TO DEPLOY IN THE 2007 DODGE NITRO DURING A PASSENGER-SIDE IMPACT ACCIDENT. MY WIFE SUSTAINED FACIAL LACERATION, NUMEROUS BROKEN RIBS, AND INTERNAL ORGAN DAMAGE. THE IMPACT POINT WAS THE PASSENGER SIDE DOOR AND PART OF THE REAR QUARTER PANEL.*AK
Official recalls
106V341000 · Power Train:automatic Transmission
Sep 7, 2006
ON CERTAIN PASSENGER AND SPORT UTILITY VEHICLES AND PICKUP TRUCKS EQUIPPED WITH AUTOMATIC TRANSMISSIONS, THE SOFTWARE PROGRAMMED INTO THE POWERTRAIN CONTROL MODULE CAN CAUSE A MOMENTARY LOCK UP OF THE DRIVE WHEELS IF THE VEHICLE IS TRAVELING OVER 40 MPH AND THE OPERATOR SHIFTS FROM DRIVE TO NEUTRAL AND BACK TO DRIVE.
Consequence & remedy
Consequence: IF THE DRIVE WHEELS LOCKED UP, LOSS OF VEHICLE CONTROL COULD OCCUR INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPROGRAM THE POWERTRAIN CONTROL MODULE FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 2, 2006. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2DP14004 · Totally Integrated Power Module Failure
Opened Sep 25, 2014 · Closed Jul 24, 2015
Status: closed (inferred from source dates) · Electrical System
In a letter dated August 21, 2014, the Center for Auto Safety (CAS) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged failures associated with the Totally Integrated Power Module (TIPM) installed in Chrysler SUV?s, trucks, and vans beginning in the 2007 model year. The petitioner alleges that TIPM defects may result in engine stall, airbag non-deployment, failure of fuel pump shutoff resulting in unintended acceleration, fire, and other symptoms. On September 25, 2014, the Office of Defects Investigation (ODI) opened DP14-004 to evaluate the petition for a grant or deny decision. ODI analyzed complaint data provided by CAS as well as complaints submitted to ODI from consumers. In total, there were 296 complaints submitted by the petitioner in the original petition and five supplements, including 271 complaints related to the subject vehicles equipped with TIPM-7. Approximately 3 percent of CAS complaints are related to vehicles equipped with TIPM-6 and ODI?s review of these complaints did not identify any safety defect trends. ODI conducted a detailed review of complaints narratives submitted by CAS and consumers including careful analysis of vehicle repair histories, warranty claims obtained from the manufacturer and any available Customer Assistance Inquiry reports (CAIR). Analysis of the field data indicated that MY2011-2013 Jeep Grand Cherokee and Dodge Durango vehicles exhibited significantly higher complaint rates related to fuel pump relay (FPR) failures than other subject vehicles. In a September 3, 2014 letter to NHTSA, Chrysler submitted a Defect Information Report (DIR) identifying a defect in the FPR within the TIPM-7 which can result in a no start or stall condition in approximately 188,723 model year (MY) 2011 Jeep Grand Cherokee (WK) and Dodge Durango (WD) vehicles manufactured from January 5, 2010 through July 20, 2011 (14V-530).In a February 24, 2015 letter, Chrysler submitted a second DIR expanding the scope of the FPR defect condition to include an additional 338,216 MY 2012 through 2013 Jeep Grand Cherokee vehicles manufactured from September 17, 2010 through August 19, 2013 and MY 2012 through 2013 Dodge Durango vehicles manufactured from January 18, 2011 through August 19, 2013 (15V-115).ODI analysis of the CAS allegations of TIPM defects resulting in stall while driving, airbag non-deployment, unintended acceleration, fire and other faults identified a single defect condition related to 1 of over 60 different circuits in the TIPM assembly. The most common effect of this defect condition, related to the fuel pump relay, was a no-start concern, but it could also result in stall while driving (76 complaints). No valid evidence was presented in support of claims related to airbag non-deployment, unintended acceleration or fire resulting from TIPM faults and these claims were found to be wholly without merit based on review of the field data and design of the relevant systems and components.Except insofar as the petitioner's contentions relate to the defect condition addressed by the Chrysler recalls, the factual bases of the petitioner's contentions that any further investigation is necessary are unsupported. In our view, additional investigation is unlikely to result in a finding that a defect related to motor vehicle safety exists or a NHTSA order for the notification and remedy of a safety-related defect as alleged by the petitioner at the conclusion of the requested investigation. Therefore, in view of the need to allocate and prioritize NHTSA's limited resources to best accomplish the agency's safety mission, the petition is den
PE07027 · Engine Stalling & Electric Power Loss
Opened May 29, 2007 · Closed Aug 2, 2007
Status: closed (inferred from source dates) · Electrical System; Engine And Engine Cooling; Power Train:automatic Transmission; Power Train:manual Transmission
ON JULY 3, 2007, DAIMLERCHRYSLER CORPORATION (DCC) SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA DESCRIBING A DEFECT THAT COULD RESULT IN ENGINE STALL WHILE DRIVING IN APPROXIMATELY 80,894 MODEL YEAR (MY) 2007 JEEP WRANGLER AND DODGE NITRO VEHICLES MANUFACTURED BETWEEN JANUARY 30, 2006 AND JANUARY 22, 2007 (NHTSA RECALL 07V-291, DCC RECALL G25).ACCORDING TO DCC, THE TOTALLY INTEGRATED POWER MODULE (TIPM) IN THESE VEHICLES WAS PROGRAMMED WITH SOFTWARE THAT MAY ALLOW THE ENGINE TO STALL UNDER CERTAIN CONDITIONS.DCC WILL REPROGRAM THE TIPM IN THE RECALLED VEHICLES WITH REVISED SOFTWARE. ODI OPENED PE07-027 ON MAY 29, 2007, BASED ON 53 COMPLAINTS ALLEGING ENGINE STALL AND/OR LOSS OF ELECTRICAL POWER IN MY 2007 JEEP WRANGLER VEHICLES.ODI WAS ALSO MONITORING SIMILAR COMPLAINTS IN MY 2007 DODGE NITRO VEHICLES.DCC'S ANALYSIS OF COMPLAINTS TO DCC AND NHTSA FOUND THAT MANY DESCRIBED EVENTS WITH A MOMENTARY LOSS OF ELECTRICAL POWER INSIDE THE VEHICLE AND A CORRESPONDING LOSS OF ENGINE POWER.MANY OF THE REPORTS ALSO INDICATED THAT THE INSTRUMENT CLUSTER TELLTALE LAMPS MOMENTARILY ILLUMINATED DURING THE EVENT. DCC'S ENGINEERING ANALYSIS DETERMINED THAT THE TIPM COULD INITIATE AN INTERNAL RESET CYCLE LASTING APPROXIMATELY 75 MS IN RESPONSE TO ERROR MESSAGES ON THE COMMUNICATION BUS.THE KEY ON SIGNAL FROM THE TIPM TO THE POWERTRAIN CONTROL MODULE (PCM) IS LOST DURING A TIPM RESET.IF THE PCM LOSES THE KEY ON SIGNAL FOR LONGER THAN 40 MS, IT INTERPRETS IT AS THE VEHICLE IGNITION BEING TURNED OFF AND BEGINS A POWER DOWN ROUTINE.AFTER THE TIPM RESET, THE KEY ON SIGNAL IS RESTORED AND THE PCM POWERS BACK UP.IF THE ROTATING COMPONENTS OF THE ENGINE CONTAIN SUFFICIENT INERTIA, THE VEHICLE MAY RESTART WITH NO INPUT FROM THE OPERATOR AS REPORTED IN SOME OF THE COMPLAINTS.IF THE ENGINE DOES NOT RESTART IN THIS MANNER, IT CAN BE RESTARTED BY THE OPERATOR.A REVISION TO THE TIPM SOFTWARE ON JANUARY 22, 2007 CHANGED THE TIPM RESET TIME TO 17 MS, REMOVING THE POTENTIAL FOR PCM POWER DOWN AND ENGINE STALL. ODI HAS RECEIVED 178 COMPLAINTS POTENTIALLY RELATED TO THE ALLEGED DEFECT IN MY 2007 JEEP WRANGLER VEHICLES AND 52 COMPLAINTS INVOLVING MY 2007 DODGE NITRO VEHICLES.TWO OF THE NITRO COMPLAINTS ALLEGE THAT A CRASH RESULTED FROM AN ENGINE STALL INCIDENT, ONE OF WHICH CAUSED MINOR INJURIES TO A PASSENGER.AS OF JUNE 1, 2007, DCC IDENTIFIED 151 WRANGLER COMPLAINTS AND 128 NITRO COMPLAINTS. THIS INVESTIGATION HAS BEEN CLOSED WITH DCC'S RECALL.
Additional source detail variants (4)
Electrical System
ON JULY 3, 2007, DAIMLERCHRYSLER CORPORATION (DCC) SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA DESCRIBING A DEFECT THAT COULD RESULT IN ENGINE STALL WHILE DRIVING IN APPROXIMATELY 80,894 MODEL YEAR (MY) 2007 JEEP WRANGLER AND DODGE NITRO VEHICLES MANUFACTURED BETWEEN JANUARY 30, 2006 AND JANUARY 22, 2007 (NHTSA RECALL 07V-291, DCC RECALL G25).ACCORDING TO DCC, THE TOTALLY INTEGRATED POWER MODULE (TIPM) IN THESE VEHICLES WAS PROGRAMMED WITH SOFTWARE THAT MAY ALLOW THE ENGINE TO STALL UNDER CERTAIN CONDITIONS.DCC WILL REPROGRAM THE TIPM IN THE RECALLED VEHICLES WITH REVISED SOFTWARE. ODI OPENED PE07-027 ON MAY 29, 2007, BASED ON 53 COMPLAINTS ALLEGING ENGINE STALL AND/OR LOSS OF ELECTRICAL POWER IN MY 2007 JEEP WRANGLER VEHICLES.ODI WAS ALSO MONITORING SIMILAR COMPLAINTS IN MY 2007 DODGE NITRO VEHICLES.DCC'S ANALYSIS OF COMPLAINTS TO DCC AND NHTSA FOUND THAT MANY DESCRIBED EVENTS WITH A MOMENTARY LOSS OF ELECTRICAL POWER INSIDE THE VEHICLE AND A CORRESPONDING LOSS OF ENGINE POWER.MANY OF THE REPORTS ALSO INDICATED THAT THE INSTRUMENT CLUSTER TELLTALE LAMPS MOMENTARILY ILLUMINATED DURING THE EVENT. DCC'S ENGINEERING ANALYSIS DETERMINED THAT THE TIPM COULD INITIATE AN INTERNAL RESET CYCLE LASTING APPROXIMATELY 75 MS IN RESPONSE TO ERROR MESSAGES ON THE COMMUNICATION BUS.THE KEY ON SIGNAL FROM THE TIPM TO THE POWERTRAIN CONTROL MODULE (PCM) IS LOST DURING A TIPM RESET.IF THE PCM LOSES THE KEY ON SIGNAL FOR LONGER THAN 40 MS, IT INTERPRETS IT AS THE VEHICLE IGNITION BEING TURNED OFF AND BEGINS A POWER DOWN ROUTINE.AFTER THE TIPM RESET, THE KEY ON SIGNAL IS RESTORED AND THE PCM POWERS BACK UP.IF THE ROTATING COMPONENTS OF THE ENGINE CONTAIN SUFFICIENT INERTIA, THE VEHICLE MAY RESTART WITH NO INPUT FROM THE OPERATOR AS REPORTED IN SOME OF THE COMPLAINTS.IF THE ENGINE DOES NOT RESTART IN THIS MANNER, IT CAN BE RESTARTED BY THE OPERATOR.A REVISION TO THE TIPM SOFTWARE ON JANUARY 22, 2007 CHANGED THE TIPM RESET TIME TO 17 MS, REMOVING THE POTENTIAL FOR PCM POWER DOWN AND ENGINE STALL. ODI HAS RECEIVED 178 COMPLAINTS POTENTIALLY RELATED TO THE ALLEGED DEFECT IN MY 2007 JEEP WRANGLER VEHICLES AND 52 COMPLAINTS INVOLVING MY 2007 DODGE NITRO VEHICLES.TWO OF THE NITRO COMPLAINTS ALLEGE THAT A CRASH RESULTED FROM AN ENGINE STALL INCIDENT, ONE OF WHICH CAUSED MINOR INJURIES TO A PASSENGER.AS OF JUNE 1, 2007, DCC IDENTIFIED 151 WRANGLER COMPLAINTS AND 128 NITRO COMPLAINTS. THIS INVESTIGATION HAS BEEN CLOSED WITH DCC'S RECALL.
Engine And Engine Cooling
ON JULY 3, 2007, DAIMLERCHRYSLER CORPORATION (DCC) SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA DESCRIBING A DEFECT THAT COULD RESULT IN ENGINE STALL WHILE DRIVING IN APPROXIMATELY 80,894 MODEL YEAR (MY) 2007 JEEP WRANGLER AND DODGE NITRO VEHICLES MANUFACTURED BETWEEN JANUARY 30, 2006 AND JANUARY 22, 2007 (NHTSA RECALL 07V-291, DCC RECALL G25).ACCORDING TO DCC, THE TOTALLY INTEGRATED POWER MODULE (TIPM) IN THESE VEHICLES WAS PROGRAMMED WITH SOFTWARE THAT MAY ALLOW THE ENGINE TO STALL UNDER CERTAIN CONDITIONS.DCC WILL REPROGRAM THE TIPM IN THE RECALLED VEHICLES WITH REVISED SOFTWARE. ODI OPENED PE07-027 ON MAY 29, 2007, BASED ON 53 COMPLAINTS ALLEGING ENGINE STALL AND/OR LOSS OF ELECTRICAL POWER IN MY 2007 JEEP WRANGLER VEHICLES.ODI WAS ALSO MONITORING SIMILAR COMPLAINTS IN MY 2007 DODGE NITRO VEHICLES.DCC'S ANALYSIS OF COMPLAINTS TO DCC AND NHTSA FOUND THAT MANY DESCRIBED EVENTS WITH A MOMENTARY LOSS OF ELECTRICAL POWER INSIDE THE VEHICLE AND A CORRESPONDING LOSS OF ENGINE POWER.MANY OF THE REPORTS ALSO INDICATED THAT THE INSTRUMENT CLUSTER TELLTALE LAMPS MOMENTARILY ILLUMINATED DURING THE EVENT. DCC'S ENGINEERING ANALYSIS DETERMINED THAT THE TIPM COULD INITIATE AN INTERNAL RESET CYCLE LASTING APPROXIMATELY 75 MS IN RESPONSE TO ERROR MESSAGES ON THE COMMUNICATION BUS.THE KEY ON SIGNAL FROM THE TIPM TO THE POWERTRAIN CONTROL MODULE (PCM) IS LOST DURING A TIPM RESET.IF THE PCM LOSES THE KEY ON SIGNAL FOR LONGER THAN 40 MS, IT INTERPRETS IT AS THE VEHICLE IGNITION BEING TURNED OFF AND BEGINS A POWER DOWN ROUTINE.AFTER THE TIPM RESET, THE KEY ON SIGNAL IS RESTORED AND THE PCM POWERS BACK UP.IF THE ROTATING COMPONENTS OF THE ENGINE CONTAIN SUFFICIENT INERTIA, THE VEHICLE MAY RESTART WITH NO INPUT FROM THE OPERATOR AS REPORTED IN SOME OF THE COMPLAINTS.IF THE ENGINE DOES NOT RESTART IN THIS MANNER, IT CAN BE RESTARTED BY THE OPERATOR.A REVISION TO THE TIPM SOFTWARE ON JANUARY 22, 2007 CHANGED THE TIPM RESET TIME TO 17 MS, REMOVING THE POTENTIAL FOR PCM POWER DOWN AND ENGINE STALL. ODI HAS RECEIVED 178 COMPLAINTS POTENTIALLY RELATED TO THE ALLEGED DEFECT IN MY 2007 JEEP WRANGLER VEHICLES AND 52 COMPLAINTS INVOLVING MY 2007 DODGE NITRO VEHICLES.TWO OF THE NITRO COMPLAINTS ALLEGE THAT A CRASH RESULTED FROM AN ENGINE STALL INCIDENT, ONE OF WHICH CAUSED MINOR INJURIES TO A PASSENGER.AS OF JUNE 1, 2007, DCC IDENTIFIED 151 WRANGLER COMPLAINTS AND 128 NITRO COMPLAINTS. THIS INVESTIGATION HAS BEEN CLOSED WITH DCC'S RECALL.
Power Train:automatic Transmission
ON JULY 3, 2007, DAIMLERCHRYSLER CORPORATION (DCC) SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA DESCRIBING A DEFECT THAT COULD RESULT IN ENGINE STALL WHILE DRIVING IN APPROXIMATELY 80,894 MODEL YEAR (MY) 2007 JEEP WRANGLER AND DODGE NITRO VEHICLES MANUFACTURED BETWEEN JANUARY 30, 2006 AND JANUARY 22, 2007 (NHTSA RECALL 07V-291, DCC RECALL G25).ACCORDING TO DCC, THE TOTALLY INTEGRATED POWER MODULE (TIPM) IN THESE VEHICLES WAS PROGRAMMED WITH SOFTWARE THAT MAY ALLOW THE ENGINE TO STALL UNDER CERTAIN CONDITIONS.DCC WILL REPROGRAM THE TIPM IN THE RECALLED VEHICLES WITH REVISED SOFTWARE. ODI OPENED PE07-027 ON MAY 29, 2007, BASED ON 53 COMPLAINTS ALLEGING ENGINE STALL AND/OR LOSS OF ELECTRICAL POWER IN MY 2007 JEEP WRANGLER VEHICLES.ODI WAS ALSO MONITORING SIMILAR COMPLAINTS IN MY 2007 DODGE NITRO VEHICLES.DCC'S ANALYSIS OF COMPLAINTS TO DCC AND NHTSA FOUND THAT MANY DESCRIBED EVENTS WITH A MOMENTARY LOSS OF ELECTRICAL POWER INSIDE THE VEHICLE AND A CORRESPONDING LOSS OF ENGINE POWER.MANY OF THE REPORTS ALSO INDICATED THAT THE INSTRUMENT CLUSTER TELLTALE LAMPS MOMENTARILY ILLUMINATED DURING THE EVENT. DCC'S ENGINEERING ANALYSIS DETERMINED THAT THE TIPM COULD INITIATE AN INTERNAL RESET CYCLE LASTING APPROXIMATELY 75 MS IN RESPONSE TO ERROR MESSAGES ON THE COMMUNICATION BUS.THE KEY ON SIGNAL FROM THE TIPM TO THE POWERTRAIN CONTROL MODULE (PCM) IS LOST DURING A TIPM RESET.IF THE PCM LOSES THE KEY ON SIGNAL FOR LONGER THAN 40 MS, IT INTERPRETS IT AS THE VEHICLE IGNITION BEING TURNED OFF AND BEGINS A POWER DOWN ROUTINE.AFTER THE TIPM RESET, THE KEY ON SIGNAL IS RESTORED AND THE PCM POWERS BACK UP.IF THE ROTATING COMPONENTS OF THE ENGINE CONTAIN SUFFICIENT INERTIA, THE VEHICLE MAY RESTART WITH NO INPUT FROM THE OPERATOR AS REPORTED IN SOME OF THE COMPLAINTS.IF THE ENGINE DOES NOT RESTART IN THIS MANNER, IT CAN BE RESTARTED BY THE OPERATOR.A REVISION TO THE TIPM SOFTWARE ON JANUARY 22, 2007 CHANGED THE TIPM RESET TIME TO 17 MS, REMOVING THE POTENTIAL FOR PCM POWER DOWN AND ENGINE STALL. ODI HAS RECEIVED 178 COMPLAINTS POTENTIALLY RELATED TO THE ALLEGED DEFECT IN MY 2007 JEEP WRANGLER VEHICLES AND 52 COMPLAINTS INVOLVING MY 2007 DODGE NITRO VEHICLES.TWO OF THE NITRO COMPLAINTS ALLEGE THAT A CRASH RESULTED FROM AN ENGINE STALL INCIDENT, ONE OF WHICH CAUSED MINOR INJURIES TO A PASSENGER.AS OF JUNE 1, 2007, DCC IDENTIFIED 151 WRANGLER COMPLAINTS AND 128 NITRO COMPLAINTS. THIS INVESTIGATION HAS BEEN CLOSED WITH DCC'S RECALL.
Power Train:manual Transmission
ON JULY 3, 2007, DAIMLERCHRYSLER CORPORATION (DCC) SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA DESCRIBING A DEFECT THAT COULD RESULT IN ENGINE STALL WHILE DRIVING IN APPROXIMATELY 80,894 MODEL YEAR (MY) 2007 JEEP WRANGLER AND DODGE NITRO VEHICLES MANUFACTURED BETWEEN JANUARY 30, 2006 AND JANUARY 22, 2007 (NHTSA RECALL 07V-291, DCC RECALL G25).ACCORDING TO DCC, THE TOTALLY INTEGRATED POWER MODULE (TIPM) IN THESE VEHICLES WAS PROGRAMMED WITH SOFTWARE THAT MAY ALLOW THE ENGINE TO STALL UNDER CERTAIN CONDITIONS.DCC WILL REPROGRAM THE TIPM IN THE RECALLED VEHICLES WITH REVISED SOFTWARE. ODI OPENED PE07-027 ON MAY 29, 2007, BASED ON 53 COMPLAINTS ALLEGING ENGINE STALL AND/OR LOSS OF ELECTRICAL POWER IN MY 2007 JEEP WRANGLER VEHICLES.ODI WAS ALSO MONITORING SIMILAR COMPLAINTS IN MY 2007 DODGE NITRO VEHICLES.DCC'S ANALYSIS OF COMPLAINTS TO DCC AND NHTSA FOUND THAT MANY DESCRIBED EVENTS WITH A MOMENTARY LOSS OF ELECTRICAL POWER INSIDE THE VEHICLE AND A CORRESPONDING LOSS OF ENGINE POWER.MANY OF THE REPORTS ALSO INDICATED THAT THE INSTRUMENT CLUSTER TELLTALE LAMPS MOMENTARILY ILLUMINATED DURING THE EVENT. DCC'S ENGINEERING ANALYSIS DETERMINED THAT THE TIPM COULD INITIATE AN INTERNAL RESET CYCLE LASTING APPROXIMATELY 75 MS IN RESPONSE TO ERROR MESSAGES ON THE COMMUNICATION BUS.THE KEY ON SIGNAL FROM THE TIPM TO THE POWERTRAIN CONTROL MODULE (PCM) IS LOST DURING A TIPM RESET.IF THE PCM LOSES THE KEY ON SIGNAL FOR LONGER THAN 40 MS, IT INTERPRETS IT AS THE VEHICLE IGNITION BEING TURNED OFF AND BEGINS A POWER DOWN ROUTINE.AFTER THE TIPM RESET, THE KEY ON SIGNAL IS RESTORED AND THE PCM POWERS BACK UP.IF THE ROTATING COMPONENTS OF THE ENGINE CONTAIN SUFFICIENT INERTIA, THE VEHICLE MAY RESTART WITH NO INPUT FROM THE OPERATOR AS REPORTED IN SOME OF THE COMPLAINTS.IF THE ENGINE DOES NOT RESTART IN THIS MANNER, IT CAN BE RESTARTED BY THE OPERATOR.A REVISION TO THE TIPM SOFTWARE ON JANUARY 22, 2007 CHANGED THE TIPM RESET TIME TO 17 MS, REMOVING THE POTENTIAL FOR PCM POWER DOWN AND ENGINE STALL. ODI HAS RECEIVED 178 COMPLAINTS POTENTIALLY RELATED TO THE ALLEGED DEFECT IN MY 2007 JEEP WRANGLER VEHICLES AND 52 COMPLAINTS INVOLVING MY 2007 DODGE NITRO VEHICLES.TWO OF THE NITRO COMPLAINTS ALLEGE THAT A CRASH RESULTED FROM AN ENGINE STALL INCIDENT, ONE OF WHICH CAUSED MINOR INJURIES TO A PASSENGER.AS OF JUNE 1, 2007, DCC IDENTIFIED 151 WRANGLER COMPLAINTS AND 128 NITRO COMPLAINTS. THIS INVESTIGATION HAS BEEN CLOSED WITH DCC'S RECALL.