IllustrationTHIS MAKES 3RD TRANSMISSION THAT HAS BEEN PUT IN THIS 2003 DODGE NEON XST . I HAVE PUT $10.000.00 IN TRANSMISSION REPLACEMENTS ! THESE ARE LEMONS!! I WILL NEVER BUY ANOTHER DODGE!!
2003 Dodge Neon
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2003 Dodge Neon do not stand out strongly from the model-year median of 173.
About this comparison →How this year compares
Owner complaints by model year
Compare all Neon years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
370–25K
2925–50K
3750–75K
3075–100K
18100–150K
8150K+
159 reports with mileage · 43 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 72 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Exterior Lighting. Review the 48 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 28 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
23 crash reports20 fire reports17 injury reports
Power Train complaints
28 reportsOIL PROBLEM ALTHOUGH I PAID THOUSANDS FOR REPAIRS.-BUT THE ENGINE LIGHT FLASHES WHEN CAR IS STOPPED AT A TRAFFIC LIGHT OR IDLING FOR EVEN A SHORT TIME. WHEN CAR IS IN MOTION, A STEADY ENGINE LIGHT IS ON ALL THE TIME, EXCEPT WHEN IT FLASHES. THIS HAS BEEN HAPPENING FOR A COUPLE OF YEARS. I NEED INFO ON THIS AND ALL RECALLS OR CO…
Read full complaint
OIL PROBLEM ALTHOUGH I PAID THOUSANDS FOR REPAIRS.-BUT THE ENGINE LIGHT FLASHES WHEN CAR IS STOPPED AT A TRAFFIC LIGHT OR IDLING FOR EVEN A SHORT TIME. WHEN CAR IS IN MOTION, A STEADY ENGINE LIGHT IS ON ALL THE TIME, EXCEPT WHEN IT FLASHES. THIS HAS BEEN HAPPENING FOR A COUPLE OF YEARS. I NEED INFO ON THIS AND ALL RECALLS OR COMPLIMENTARY REPAIRS AVAILABLE . I NEED TO BE SAFE .THANK YOU. *TR
TL*THE CONTACT OWNS A 2003 DODGE NEON SRT4 (NA). THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 15-20 MPH, THE 3RD GEAR SHIFTER SUDDENLYPOPPED OUT OF PLACE. THE CONTACT WAS ABLE TO CONTINUE DRIVING AFTER A LITTLE MANEUVERING. THE VEHICLE WAS INSPECTED BY A DEALER BUT THEY WERE UNABLE TO DIAGNOSE THE FAILURE. THE MANUFACTURE…
Read full complaint
TL*THE CONTACT OWNS A 2003 DODGE NEON SRT4 (NA). THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 15-20 MPH, THE 3RD GEAR SHIFTER SUDDENLYPOPPED OUT OF PLACE. THE CONTACT WAS ABLE TO CONTINUE DRIVING AFTER A LITTLE MANEUVERING. THE VEHICLE WAS INSPECTED BY A DEALER BUT THEY WERE UNABLE TO DIAGNOSE THE FAILURE. THE MANUFACTURER WAS CONTACTED BUT THEY OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS APPROXIMATELY 68,000.
TL*THE CONTACT OWNS 2003 DODGE NEON. THE CONTACT STATED THE CHECK ENGINE LIGHT REMAINED ILLUMINATED AND WITHIN A FEW MINUTES THE TRANSMISSIONS SECOND GEAR FAILED. THE VEHICLE WAS TAKEN TO THE DEALER NUMEROUS TIMES TO DIAGNOSE THE FAILURE. THE DEALER STATED THAT THE TRANSMISSION HAD METAL SHAVINGS, BUT THEY DID NOT CORRECT THE FA…
Read full complaint
TL*THE CONTACT OWNS 2003 DODGE NEON. THE CONTACT STATED THE CHECK ENGINE LIGHT REMAINED ILLUMINATED AND WITHIN A FEW MINUTES THE TRANSMISSIONS SECOND GEAR FAILED. THE VEHICLE WAS TAKEN TO THE DEALER NUMEROUS TIMES TO DIAGNOSE THE FAILURE. THE DEALER STATED THAT THE TRANSMISSION HAD METAL SHAVINGS, BUT THEY DID NOT CORRECT THE FAILURE. THE FAILURE MILEAGE WAS 34,000 AND THE CURRENT MILEAGE WAS 84,000. THE MANUFACTURER WILL BE CONTACTED.
PREMATURE FAILURE OF MOTOR MOUNTS. CAUSING POSSIBLE PROBLEMS WITH ELECTRICAL SYSTEM, EXHAUST SYSTEM, EXCESSIVE NOISE AND VIBRATION. *TR
I HAVE A 2003 DODGE NEON SXT. I PURCHASED THE CAR IN 2008. 6 MONTHS LATER THE TRANSMISSION GAVE OUT. THE CAR WOULD NOT RUN AT ALL. THERE WERE NO WARNINGS TO THIS. AAMACO SAID THAT THE RADIATOR BLEW WHICH LED TO THE COOLANT AND TRANS. FLUID MIXING TOGETHER AND DESTROYING THE TRANSMISSION. I HAD NO WARRANTY BECAUSE THE CAR WA…
Read full complaint
I HAVE A 2003 DODGE NEON SXT. I PURCHASED THE CAR IN 2008. 6 MONTHS LATER THE TRANSMISSION GAVE OUT. THE CAR WOULD NOT RUN AT ALL. THERE WERE NO WARNINGS TO THIS. AAMACO SAID THAT THE RADIATOR BLEW WHICH LED TO THE COOLANT AND TRANS. FLUID MIXING TOGETHER AND DESTROYING THE TRANSMISSION. I HAD NO WARRANTY BECAUSE THE CAR WAS BOUGHT USED. IT COST ME 3500 DOLLARS TO FIX THIS PROBLEM.NOW THE CHECK ENGINE LIGHT KEEPS COMING ON AND THE CAR IS BURNING FUEL. I AM GETTING ANYWHERE FROM 10 TO 17 MPG DEPENDING ON THE DAY. I HAVE TAKEN THE CAR TO THREE DIFFERENT MECHANICS, INCLUDING A DEALERSHIP, WHO CAN NOT FIGURE OUT WHAT IS WRONG WITH IT. THE WORST PROBLEM YET IS THAT WHEN IT IS RAINING OUTSIDE AND I AM DRIVING THE CAR THERE IS A SMALL THUNKING NOISE, AND THEN A LOUD THUNKING NOISE THAT LOCKS UP THE REAR TIRES AND BRINGS THE CAR TO A SKIDDING HALT. SO FAR, KNOW ON WOOD, NO ACCIDENTS, BUT IT IS A VERY DANGEROUS SITUATION. AGAIN, THE CAR HAS GONE TO SEVERAL MECHANICS WHO CLAIMED THEY FIGURED OUT THE PROBLEM. HAVE CHANGED EVERYTHING FROM AXLES, TO BRAKE CYLINDERS AND BRAKES. PAID APPROXIMATELY 1500 DOLLARS OUT OF POCKET, AND THE CAR IS STILL DOING THE SAME THING. I HAVE YOUNG CHILDREN WHO I REFUSE TO DRIVE ANYWHERE IN THIS CAR FOR THEIR OWN SAFETY. *TR
BOUGHT CAR NEW AND I AM METICULOUS ABOUT IT'S MAINTENANCE. OIL SEAL IN MANUAL TRANSMISSION HAS FAILED TWICE NOW. ONCE IN 2004 WITH ABOUT 10,000 MI. ON THE CAR WITH NO DAMAGE TO CLUTCH DISC AND AGAIN NOW IN 2008 WITH 45,000 MI. THIS TIME THE CLUTCH DISC WAS CONTAMINATED WITH OIL AND WAS NOT INCLUDED IN THE REPAIR UNDER CHRYSLER'S…
Read full complaint
BOUGHT CAR NEW AND I AM METICULOUS ABOUT IT'S MAINTENANCE. OIL SEAL IN MANUAL TRANSMISSION HAS FAILED TWICE NOW. ONCE IN 2004 WITH ABOUT 10,000 MI. ON THE CAR WITH NO DAMAGE TO CLUTCH DISC AND AGAIN NOW IN 2008 WITH 45,000 MI. THIS TIME THE CLUTCH DISC WAS CONTAMINATED WITH OIL AND WAS NOT INCLUDED IN THE REPAIR UNDER CHRYSLER'S 7 YR. 70,000 MI. DRIVETRAIN WARRANTY. ENDED UP PAYING FOR A NEW CLUTCH ASSEMBLY AS WELL AS THE 100.00 DEDUCTIBLE. THIS CAR HAS BEEN A NIGHTMARE. THIS IS JUST ONE OF ABOUT 15 TIMES THIS CAR HAS BEEN IN FOR MAJOR REPAIR. *TR
I AM THE 2ND HAND OWNER OF THIS VEHICLE. I HAVE BEEN IN POSSESSION OF IT FOR ABOUT A YEAR AND 1/2 HAVE METICULOUSLY MAINTAINED IT AND IT HAS 55,000 MILE ON IT. RECENTLY THE TRANSMISSION BECAME RATHER JUMPY AND IT WAS TO GO INTO SERVICE BUT THE DAY BEFORE I WAS TO SCHEDULE AN APPOINTMENT IT WAS MORE JUMPY THAN USUAL AND I SMELT…
Read full complaint
I AM THE 2ND HAND OWNER OF THIS VEHICLE. I HAVE BEEN IN POSSESSION OF IT FOR ABOUT A YEAR AND 1/2 HAVE METICULOUSLY MAINTAINED IT AND IT HAS 55,000 MILE ON IT. RECENTLY THE TRANSMISSION BECAME RATHER JUMPY AND IT WAS TO GO INTO SERVICE BUT THE DAY BEFORE I WAS TO SCHEDULE AN APPOINTMENT IT WAS MORE JUMPY THAN USUAL AND I SMELT TRANS. FLUID THROUGH MY AIR VENTS. CHECKED TRANS. FLUID AND FOUND NOTHING ON THE STICK, SHUT IF OFF, LOOKED UNDER THE CAR AND THERE WAS A PUDDLE OF PINK FLUID UNDER ON THE GROUND. LOOKED AT THE LITTLE BIT OF FLUID THAT WAS THE TRANS STICK AND IT WAS THE SAME COLOR. LOOKED IN THE COOLANT, SAME FLUID AS ON THE STICK AND THE GROUND. MY RADIATOR HAD GIVEN OUT MIXING MY COOLANT WITH TRANS. FLUID. THIS LEFT ME TO PAY $974 OUT OF POCKET BECAUSE CHRYSLER WOULD NOT HELP PAY FOR THIS COMMON PROBLEM. CAR IS UNDER A 7/70K POWER TRAIN WARRANTY. RADIATOR IS NOT COVERED. *TR
I WAS DRIVING TO STORE AT MODERATELY SLOW SPEED AND TRANSMISSION SLIPPED OUT OF GEAR AND CAR WOULD NOT MOVE. CHECKED TRANSMISSION FLUID AND IT WAS EMPTY. CAR TOWED TO DEALER AND I WAS TOLD THE RADIATOR HAD GIVEN OUT AND THE COOLANT HAD CIRCULATED THROUGH THE TRANSMISSION. RADIATOR WAS REPLACED AND COOLANT WAS SUPPOSEDLY FLUSHED …
Read full complaint
I WAS DRIVING TO STORE AT MODERATELY SLOW SPEED AND TRANSMISSION SLIPPED OUT OF GEAR AND CAR WOULD NOT MOVE. CHECKED TRANSMISSION FLUID AND IT WAS EMPTY. CAR TOWED TO DEALER AND I WAS TOLD THE RADIATOR HAD GIVEN OUT AND THE COOLANT HAD CIRCULATED THROUGH THE TRANSMISSION. RADIATOR WAS REPLACED AND COOLANT WAS SUPPOSEDLY FLUSHED FROM TRANSMISSION. CHRYSLER DID PAY FOR MOST OF REPAIR BUT ONLY AFTER CALLING CHRYSLER. *AK
TOTAL TRANSMISSION FAILURE. YET TO BE REBUILT VERY EXPENSIVE! I WILL NEVER PURCHASE ANOTHER DODGE/CHRYSLER/JEEP PRODUCT AGAIN! *JB
Official recalls
0No recalls in this snapshot.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA06019 · Headlight Failure
Opened Nov 22, 2006 · Closed Nov 7, 2007
Status: closed (inferred from source dates) · Exterior Lighting:fog Lights; Exterior Lighting:fog Lights:switch; Exterior Lighting:headlights; Exterior Lighting:headlights:switch
THIS EA WAS OPENED AFTER RECEIVING REPORTS THAT THE MULTIFUNCTION SWITCH ON THESE VEHICLES WOULD FAIL, CAUSING A LOSS OF HEADLIGHT ILLUMINATION.SOME COMPLAINANTS REPORT LOSS OF HEADLIGHT FUNCTION WHILE FOR OTHERS TEMPORARY LIGHTING WAS AVAILABLE BY PULLING ON THE MULTIFUNCTION SWITCH STALK TO ILLUMINATE HIGH BEAM LIGHTING.ANALYSIS OF THE COMPLAINT AND WARRANTY DATA SHOW A LOW AND DECLINING FAILURE TREND.FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED; ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Additional source detail variants (4)
Exterior Lighting:fog Lights
THIS EA WAS OPENED AFTER RECEIVING REPORTS THAT THE MULTIFUNCTION SWITCH ON THESE VEHICLES WOULD FAIL, CAUSING A LOSS OF HEADLIGHT ILLUMINATION.SOME COMPLAINANTS REPORT LOSS OF HEADLIGHT FUNCTION WHILE FOR OTHERS TEMPORARY LIGHTING WAS AVAILABLE BY PULLING ON THE MULTIFUNCTION SWITCH STALK TO ILLUMINATE HIGH BEAM LIGHTING.ANALYSIS OF THE COMPLAINT AND WARRANTY DATA SHOW A LOW AND DECLINING FAILURE TREND.FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED; ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Exterior Lighting:fog Lights:switch
THIS EA WAS OPENED AFTER RECEIVING REPORTS THAT THE MULTIFUNCTION SWITCH ON THESE VEHICLES WOULD FAIL, CAUSING A LOSS OF HEADLIGHT ILLUMINATION.SOME COMPLAINANTS REPORT LOSS OF HEADLIGHT FUNCTION WHILE FOR OTHERS TEMPORARY LIGHTING WAS AVAILABLE BY PULLING ON THE MULTIFUNCTION SWITCH STALK TO ILLUMINATE HIGH BEAM LIGHTING.ANALYSIS OF THE COMPLAINT AND WARRANTY DATA SHOW A LOW AND DECLINING FAILURE TREND.FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED; ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Exterior Lighting:headlights
THIS EA WAS OPENED AFTER RECEIVING REPORTS THAT THE MULTIFUNCTION SWITCH ON THESE VEHICLES WOULD FAIL, CAUSING A LOSS OF HEADLIGHT ILLUMINATION.SOME COMPLAINANTS REPORT LOSS OF HEADLIGHT FUNCTION WHILE FOR OTHERS TEMPORARY LIGHTING WAS AVAILABLE BY PULLING ON THE MULTIFUNCTION SWITCH STALK TO ILLUMINATE HIGH BEAM LIGHTING.ANALYSIS OF THE COMPLAINT AND WARRANTY DATA SHOW A LOW AND DECLINING FAILURE TREND.FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED; ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Exterior Lighting:headlights:switch
THIS EA WAS OPENED AFTER RECEIVING REPORTS THAT THE MULTIFUNCTION SWITCH ON THESE VEHICLES WOULD FAIL, CAUSING A LOSS OF HEADLIGHT ILLUMINATION.SOME COMPLAINANTS REPORT LOSS OF HEADLIGHT FUNCTION WHILE FOR OTHERS TEMPORARY LIGHTING WAS AVAILABLE BY PULLING ON THE MULTIFUNCTION SWITCH STALK TO ILLUMINATE HIGH BEAM LIGHTING.ANALYSIS OF THE COMPLAINT AND WARRANTY DATA SHOW A LOW AND DECLINING FAILURE TREND.FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED; ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
PE06028 · Headlight Failure
Opened Jul 28, 2006 · Closed Nov 22, 2006
Status: closed (inferred from source dates) · Exterior Lighting:fog Lights; Exterior Lighting:fog Lights:switch; Exterior Lighting:headlights; Exterior Lighting:headlights:switch
ODI HAS REVIEWED COMPLAINTS FROM CONSUMERS STATING THAT THEY DO NOT HAVE HEADLIGHT FUNCTION WHILE OPERATING THEIR VEHICLE.THE REPORTS INDICATE THAT A LOSS OF BOTH HIGH AND LOW BEAM HEADLIGHTS IS THE RESULT OF PROBLEMS WITH THE VEHICLES MULTIFUNCTION SWITCH AND CONNECTING WIRING HARNESS.CONSUMERSNOTICED THAT THE STEERING COLUMN AREA (WHERE THESE PARTS ARE LOCATED) IS HEATING UP.IN SOME CASES, SMOKE WOULD COME OUT OF THE STEERING COLUMN AREA AND THE PLASTIC TRIM WOULD BEGIN TO MELT.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA06-019) TO FURTHER STUDY THIS ISSUE.
Additional source detail variants (4)
Exterior Lighting:fog Lights
ODI HAS REVIEWED COMPLAINTS FROM CONSUMERS STATING THAT THEY DO NOT HAVE HEADLIGHT FUNCTION WHILE OPERATING THEIR VEHICLE.THE REPORTS INDICATE THAT A LOSS OF BOTH HIGH AND LOW BEAM HEADLIGHTS IS THE RESULT OF PROBLEMS WITH THE VEHICLES MULTIFUNCTION SWITCH AND CONNECTING WIRING HARNESS.CONSUMERSNOTICED THAT THE STEERING COLUMN AREA (WHERE THESE PARTS ARE LOCATED) IS HEATING UP.IN SOME CASES, SMOKE WOULD COME OUT OF THE STEERING COLUMN AREA AND THE PLASTIC TRIM WOULD BEGIN TO MELT.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA06-019) TO FURTHER STUDY THIS ISSUE.
Exterior Lighting:fog Lights:switch
ODI HAS REVIEWED COMPLAINTS FROM CONSUMERS STATING THAT THEY DO NOT HAVE HEADLIGHT FUNCTION WHILE OPERATING THEIR VEHICLE.THE REPORTS INDICATE THAT A LOSS OF BOTH HIGH AND LOW BEAM HEADLIGHTS IS THE RESULT OF PROBLEMS WITH THE VEHICLES MULTIFUNCTION SWITCH AND CONNECTING WIRING HARNESS.CONSUMERSNOTICED THAT THE STEERING COLUMN AREA (WHERE THESE PARTS ARE LOCATED) IS HEATING UP.IN SOME CASES, SMOKE WOULD COME OUT OF THE STEERING COLUMN AREA AND THE PLASTIC TRIM WOULD BEGIN TO MELT.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA06-019) TO FURTHER STUDY THIS ISSUE.
Exterior Lighting:headlights
ODI HAS REVIEWED COMPLAINTS FROM CONSUMERS STATING THAT THEY DO NOT HAVE HEADLIGHT FUNCTION WHILE OPERATING THEIR VEHICLE.THE REPORTS INDICATE THAT A LOSS OF BOTH HIGH AND LOW BEAM HEADLIGHTS IS THE RESULT OF PROBLEMS WITH THE VEHICLES MULTIFUNCTION SWITCH AND CONNECTING WIRING HARNESS.CONSUMERSNOTICED THAT THE STEERING COLUMN AREA (WHERE THESE PARTS ARE LOCATED) IS HEATING UP.IN SOME CASES, SMOKE WOULD COME OUT OF THE STEERING COLUMN AREA AND THE PLASTIC TRIM WOULD BEGIN TO MELT.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA06-019) TO FURTHER STUDY THIS ISSUE.
Exterior Lighting:headlights:switch
ODI HAS REVIEWED COMPLAINTS FROM CONSUMERS STATING THAT THEY DO NOT HAVE HEADLIGHT FUNCTION WHILE OPERATING THEIR VEHICLE.THE REPORTS INDICATE THAT A LOSS OF BOTH HIGH AND LOW BEAM HEADLIGHTS IS THE RESULT OF PROBLEMS WITH THE VEHICLES MULTIFUNCTION SWITCH AND CONNECTING WIRING HARNESS.CONSUMERSNOTICED THAT THE STEERING COLUMN AREA (WHERE THESE PARTS ARE LOCATED) IS HEATING UP.IN SOME CASES, SMOKE WOULD COME OUT OF THE STEERING COLUMN AREA AND THE PLASTIC TRIM WOULD BEGIN TO MELT.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA06-019) TO FURTHER STUDY THIS ISSUE.
PE02082 · Safety Belt Cinching Latch Plate
Opened Nov 6, 2002 · Closed Apr 23, 2003
Status: closed (inferred from source dates) · Seat Belts
THERE ARE NO INJURIES OR FATALITIES ASSOCIATED WITH THIS ALLEGED DEFECT.WHILE CONDUCTING THIS INVESTIGATION, ODI FOUND THAT THE SUBJECT CINCHES MEET THE LOAD BEARING REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD 208, AND THAT MANY OF THE REPORTED FAILURES WERE DUE TO INCORRECT CHILD SAFETY SEAT INSTALLATIONS. ADDITIONALLY, THE REPORT RATE IS LOW (1.60/100K).THE INFORMATION AVAILABLE FAILS TO ESTABLISH THE EXISTENCE OF A DEFECT TREND AT THIS TIME.FURTHER ALLOCATION OF AGENCY RESOURCES TO THIS ISSUE IS UNWARRANTED AND THE PRELIMINARY EVALUATION IS BEING CLOSED.