NHTSA owner reports · September 18, 2026 snapshot.
Unknown Or Other complaints
111 reportsClear category filter31,000 miles · Sep 23, 2015
Unknown Or Other
WHEN KEY WAS PLACED IN THE IGNITION THE CAR WOULD NOT START. AFTER A FEW HOURS, THE CAR WOULD START. THIS HAPPENS RANDOMLY OVER AND OVER. BROUGHT THE CAR INTO THE DEALER AND HAD THE IGNITION REPLACED AT MY OWN COST. IN JULY 2015, I RECEIVED A RECALL NOTICE AND HAD THE IGNITION REPLACED AGAIN. THE ISSUE IS STILL CONTINUING WITH …
Read full complaint
WHEN KEY WAS PLACED IN THE IGNITION THE CAR WOULD NOT START. AFTER A FEW HOURS, THE CAR WOULD START. THIS HAPPENS RANDOMLY OVER AND OVER. BROUGHT THE CAR INTO THE DEALER AND HAD THE IGNITION REPLACED AT MY OWN COST. IN JULY 2015, I RECEIVED A RECALL NOTICE AND HAD THE IGNITION REPLACED AGAIN. THE ISSUE IS STILL CONTINUING WITH NO RESOLVE.
NHTSA ODI #10775407
72,000 miles · Sep 9, 2015
Unknown Or Other
I WENT TO CHECK THE AIR PRESSURE ON THE TIRES BECAUSE THE LOW PRESSURE WARNING LIGHT ILLUMINATED ON THE DASH. THE TIRE DID NOT APPEAR TO BE LOW. I TOOK THE CAP OFF THE TIRE TO CHECK IT AND THE SENSOR STEM CAME OFF IN MY HAND AND AS A RESULT THE AIR ESCAPE FROM THE TIRE. I HAD TO HAVE THE VEHICLE TOWED AND REPAIRED. I AM CONCERN…
Read full complaint
I WENT TO CHECK THE AIR PRESSURE ON THE TIRES BECAUSE THE LOW PRESSURE WARNING LIGHT ILLUMINATED ON THE DASH. THE TIRE DID NOT APPEAR TO BE LOW. I TOOK THE CAP OFF THE TIRE TO CHECK IT AND THE SENSOR STEM CAME OFF IN MY HAND AND AS A RESULT THE AIR ESCAPE FROM THE TIRE. I HAD TO HAVE THE VEHICLE TOWED AND REPAIRED. I AM CONCERNED THAT THIS COULD HAPPEN WHEN THE VEHICLE IS MOVING CAUSING A CRASH. THE CAPS ARE PLASTIC AND NOT METAL. I HAVE SEEN FROM THE INTERNET AND HEARD FROM DEALERS THIS IS A COMMON PROBLEM AND HAS TO DO WITH CORROSION.
NHTSA ODI #10762493
Mileage unknown · Aug 14, 2015
Electrical SystemUnknown Or Other
WHEN DRIVING WITH MY MOTHER AS PASSENGER FROM PHOENIX TO TUCSON TO VISIT RELATIVES, THE HORN SOUNDED INTERMITTENTLY. I HAD A MINOR ACCIDENT A FEW DAYS LATER, AND WHEN I TOOK THE CAR IN THE DEALER TO REPAIR, I ASKED THEM TO CHECK THE HORN. THEY REPORTED NOTHING AMISS. THE HORN CONTINUED TO INTERNITTENTLY SOUND OFF WHETHER I WAS D…
Read full complaint
WHEN DRIVING WITH MY MOTHER AS PASSENGER FROM PHOENIX TO TUCSON TO VISIT RELATIVES, THE HORN SOUNDED INTERMITTENTLY. I HAD A MINOR ACCIDENT A FEW DAYS LATER, AND WHEN I TOOK THE CAR IN THE DEALER TO REPAIR, I ASKED THEM TO CHECK THE HORN. THEY REPORTED NOTHING AMISS. THE HORN CONTINUED TO INTERNITTENTLY SOUND OFF WHETHER I WAS DRIVING ON A SIDE STREET ALONE OR IN TRAFFIC, BOTH ON SURFACE STREETS AND THE FREEWAYS. WHEN I RECEIVED THE NOTICE FOR THE FOBIK RECALL IN MAY, I MADE THE APPOINTMENT AND TOOK THE CAR IN, AND REMINDED THEM THE HORN GOES OFF; THE SAME DEALER TOLD ME THEY COULD NOT REPLICATE THE HORN ISSUE AGAIN. THEY ALSO FAILED TO COMPLETE THE RECALL FIX. I MADE ANOTHER APPOINTMENT TWO WEEKS AGO IN JULY AS THE HORN KEPT SOUNDING OFF ON ITS OWN AND IT IS GETTING WORSE. I ALSO HAD ALL THE REQUIRED MAINTENANCE COMPLETED AT A COST OF OVER $1500, AND WHILE IN THE SERVICE BAY THE CAR HORN SOUNDED OFF. THE SERVICE CREW ATTEMPTED TO FIX THE HORN OVER THREE DAYS BUT FAILED. AS I DROVE THE CAR AWAY FROM THE DEALERSHIP, THE HORN SOUNDED OFF AGAIN. THEY ALSO DID NOT COMPLETE THE RECALL FIX AGAIN, EVEN AFTER ORDERING THE PARTS NECESSARY. THEY BELIEVE THE HORN ISSUE IS RELATED TO THE ELECTRICAL ISSUE IN THE KEY FOBIK RECALL, AND ARE HOPING THE RECALL FIX WILL ALSO ADDRESS THE HORN ISSUE. MEANWHILE, THE HORN HAS CONTINUED TO ESCALATE AND LAST EVENING WHILE DRIVING HOME IN RUSH HOUR TRAFFIC, THE HORN SOUNDED OFF FOR LONGER PERIODS, ON SEVERAL OCCASIONS FOR AS LONG AS NEARLY A MILE ON THE SURFACE STREETS. AS THIS IS A SEVERE SAFETY ISSUE AS WELL AS A CITABLE OFFENSE, I HAVE MADE YET ANOTHER APPOINTMENT TO HAVE THE HORN ISSUE FIXED. THE DEALER HAS NOT RELAYED EXACTLY WHAT STEPS THEY HAVE TAKEN TO CORRECT THIS, OTHER THAN REPLACING THE *SPRING IN THE STEERING COLUMN. I HAVE READ ONLINE A POSSIBLE HORN FIX IS TO REPLACE THE AIRBAG - WHICH HAS NOT BEEN IDENTIFIED IN A RECALL YET.
NHTSA ODI #10748653
43,500 miles · Jul 31, 2015
Electrical SystemExterior LightingUnknown Or Other
MADE A LEFT HAND TURN AND SUDDENLY THE AIR CONDITIONER, RADIO, LIGHTS, WINDOWS STOPPED WORKING. DROVE TO A LOT AND PULLED OVER AND EVERYTHING CAME BACK ON. THEN MOVE THE STEERING WHEEL AND EVERYTHING SHUT OFF AGAIN. TURNED THE CAR OFF AND EVERYTHING CAME BACK AND HAS WORKED FINE SO FAR. HOWEVER, THE CAR WOULDN'T START EARLIER WH…
Read full complaint
MADE A LEFT HAND TURN AND SUDDENLY THE AIR CONDITIONER, RADIO, LIGHTS, WINDOWS STOPPED WORKING. DROVE TO A LOT AND PULLED OVER AND EVERYTHING CAME BACK ON. THEN MOVE THE STEERING WHEEL AND EVERYTHING SHUT OFF AGAIN. TURNED THE CAR OFF AND EVERYTHING CAME BACK AND HAS WORKED FINE SO FAR. HOWEVER, THE CAR WOULDN'T START EARLIER WHEN TURNED ON. HAD TO START THE CAR 3 TIMES BEFORE IT CAME ON.
NHTSA ODI #10745358
73,876 miles · Jul 30, 2015
Service BrakesUnknown Or OtherWheelsFire
BRAKES HAVE BEEN A MAJOR ISSUE ON THIS VEHICLE. WE HAVE HAD TO REPLACE BRAKES, ROTORS AND CALIPERS MULTIPLE TIMES SINCE THE VEHICLE WAS PURCHASED NOT TO MENTION THE TIRES ALSO. THE FIRST TIME THEY WERE REPLACED, THE CAR HAD LESS THAN 36,000 MILES. SINCE THAT TIME THEY HAVE BEEN REPLACED MULTIPLE TIMES, WITH THE LAST TIME BEIN…
Read full complaint
BRAKES HAVE BEEN A MAJOR ISSUE ON THIS VEHICLE. WE HAVE HAD TO REPLACE BRAKES, ROTORS AND CALIPERS MULTIPLE TIMES SINCE THE VEHICLE WAS PURCHASED NOT TO MENTION THE TIRES ALSO. THE FIRST TIME THEY WERE REPLACED, THE CAR HAD LESS THAN 36,000 MILES. SINCE THAT TIME THEY HAVE BEEN REPLACED MULTIPLE TIMES, WITH THE LAST TIME BEING IN THE LAST 30 DAYS. IT IS LIKE THERE IS SOME TYPE OF DESIGN FLAW IN THE BRAKING SYSTEM, THAT CAUSES THE BRAKES AND TIRES TO BOTH WEAR OUT QUICKLY. LAST NIGHT THE BRAKING SYSTEM CAUGHT FIRE ON THIS VEHICLE, LUCKY I HAD JUST PULLED IN MY PARKING SPOT WHEN THEY STARTED BURNING AND DIDN'T HAVE MY CHILDREN WITH ME. FIRE DEPARTMENT WAS NOTIFIED AND THE FIRE WAS PUT OUT BY THEM. I HAVE NOTICED THAT I AM NOT THE ONLY PERSON WITH THE JOURNEY THAT HAS HAD BRAKE AND TIRE ISSUES. NOW I AM STUCK WITHOUT ANY MEANS OF TRANSPORTATION THANKS TO THE BRAKES CATCHING FIRE (WARPING RIMS AND MELTED TIRES FROM IT). THANKFULLY NO ONE WAS INJURED.
NHTSA ODI #10744989
Mileage unknown · Jul 27, 2015
Unknown Or Other
I RECEIVED A SAFETY RECALL RELATED TO MY WIRELESS IGNITION NODE (WIN). I CONTACTED MY LOCAL DODGE DEALERSHIP ON APPROX 5-23-2015 TO SCHEDULE THE REPAIRS AND WAS TOLD THIS WOULD BE 1.5 MONTHS FOR REPAIR. I HAVE NOT BE NOTIFIED AS OF TODAY (ALMOST 2 MONTHS) TO INFORM THE PARTS ARE AVAILABLE. I DRIVE 100 MILES / DAY AND AM AFRAI…
Read full complaint
I RECEIVED A SAFETY RECALL RELATED TO MY WIRELESS IGNITION NODE (WIN). I CONTACTED MY LOCAL DODGE DEALERSHIP ON APPROX 5-23-2015 TO SCHEDULE THE REPAIRS AND WAS TOLD THIS WOULD BE 1.5 MONTHS FOR REPAIR. I HAVE NOT BE NOTIFIED AS OF TODAY (ALMOST 2 MONTHS) TO INFORM THE PARTS ARE AVAILABLE. I DRIVE 100 MILES / DAY AND AM AFRAID THIS ISSUE COULD EXPOSE ITSELF AND LEAD TO AN INCIDENT. I WOULD LIKE TO THINK THIS TIME IS A LITTLE EXCESSIVE PUTTING ME AND OTHER DRIVERS AT RISK FOR A KNOWN ISSUE. THE DEALERSHIP INFO: MEDINA AUTO MALL 3205 MEDINA RD, MEDINA, OH 44256 (330) 723-3291
NHTSA ODI #10743588
96,478 miles · Jun 29, 2015
Unknown Or Other
WHEN I TRIED TO CRANK THE CAR IT WOULD NOT START. IT WOULD CLICK ONCE BUT NOT CRANK. FINALLY AFTER SEVERAL TIMES OF TRYING IT CRANKED. HAS A RECALL ON THE WIRELESS IGNITION NODE MODULE AND HOPING THIS WILL FIX THE PROBLEM BUT WON'T KNOW FOR SURE UNTIL IT IS REPLACED.
NHTSA ODI #10730889
3,800 miles · Jun 15, 2015
Unknown Or Other
CAR WOULD NOT START. EVERYTHING WORKED (RADIO, WINDOWS ETC) DID NOT EVEN MAKE A SOUND LIKE IT WANTED TO START. I CALLED PERFORMANCE DODGE WHERE PURCHASED, THEY TOLD ME TO HAVE IT TOWED TO THEM. I TRIED FOR OVER ONE HOUR TO START CAR. IT FINALLY STARTED. TOOK IT TO NEAREST REPAIR SHOP, TESTED AND FOUND NO CODES. TOOK IT TO P…
Read full complaint
CAR WOULD NOT START. EVERYTHING WORKED (RADIO, WINDOWS ETC) DID NOT EVEN MAKE A SOUND LIKE IT WANTED TO START. I CALLED PERFORMANCE DODGE WHERE PURCHASED, THEY TOLD ME TO HAVE IT TOWED TO THEM. I TRIED FOR OVER ONE HOUR TO START CAR. IT FINALLY STARTED. TOOK IT TO NEAREST REPAIR SHOP, TESTED AND FOUND NO CODES. TOOK IT TO PERFORMANCE DODGE, FOUND NO CODES.
NHTSA ODI #10725289
59,898 miles · May 17, 2015
Electrical SystemUnknown Or Other
ABOUT 3 MONTHS AGO MY HORN STARTED JUST RANDOMLY HONKING. IT DIDN'T MATTER IF IT WAS PARKED OR RUNNING. SEEMS TO HAPPEN MORE WHILE PARKED AND IN THE MIDDLE OF THE NIGHT. NOW THE LOCKS DON'T WANT TO UNLOCK WHEN I PRESS BUTTON ON REMOTE OR CAR JUST UNLOCKS ITSELF. I CAN GO OUTSIDE HOLDING KEYS IN HAND WITHOUT PRESSING ANYTHING CAR…
Read full complaint
ABOUT 3 MONTHS AGO MY HORN STARTED JUST RANDOMLY HONKING. IT DIDN'T MATTER IF IT WAS PARKED OR RUNNING. SEEMS TO HAPPEN MORE WHILE PARKED AND IN THE MIDDLE OF THE NIGHT. NOW THE LOCKS DON'T WANT TO UNLOCK WHEN I PRESS BUTTON ON REMOTE OR CAR JUST UNLOCKS ITSELF. I CAN GO OUTSIDE HOLDING KEYS IN HAND WITHOUT PRESSING ANYTHING CAR WILL UNLOCK OR LOCK. SEVERAL INCIDENTS SO FAR OF WINDOWS JUST RANDOMLY ROLLING DOWN. THE HONKING THING SCARES ME THE MOST ESPECIALLY WHILE IN TRAFFIC JAMS WHEN PEOPLE HAVE ROAD RAGE! I'VE GOTTEN PLENTY OF MIDDLE FINGERS BECAUSE OF THIS POSSESSED CAR. I'VE ALSO HAD THE CAR JUST SHUT OFF AT A STOP LIGHT. IT DID HOW EVER START IMMEDIATELY. THANKS DODGE FOR TAKING MY MONEY, DISREGARDING MY FAMILIES SAFETY AND GIVING ME A POS!
NHTSA ODI #10716908
3,200 miles · Jan 27, 2011
Electrical SystemUnknown Or Other
VEHICLE POWERS OFF WHILE IT'S BEING DRIVEN. THE FIRST TIME IT HAPPENED, MY WIFE WAS PULLING OUT OF THE DRIVEWAY. THIS HAS HAPPENED THREE DIFFERENT TIMES SINCE THEN. WHAT I MEAN BY POWER OFF IS, YOU HAVE TO PUT THE CAR IN NEUTRAL OR PARK TO RESTART IT. I CAN'T DUPLICATE THIS NOR CAN CHYRSLER'S REPAIR PERSONNEL. IT'S SCARY BECAUSE…
Read full complaint
VEHICLE POWERS OFF WHILE IT'S BEING DRIVEN. THE FIRST TIME IT HAPPENED, MY WIFE WAS PULLING OUT OF THE DRIVEWAY. THIS HAS HAPPENED THREE DIFFERENT TIMES SINCE THEN. WHAT I MEAN BY POWER OFF IS, YOU HAVE TO PUT THE CAR IN NEUTRAL OR PARK TO RESTART IT. I CAN'T DUPLICATE THIS NOR CAN CHYRSLER'S REPAIR PERSONNEL. IT'S SCARY BECAUSE YOU DON'T KNOW WHEN THIS IS GOING TO HAPPEN. CHRYSLER UPDATED THE SOFTWARE IN OCTOBER 2010, BUT IT HAS HAPPENED TWICE SINCE THEN. IT'S AT THE DEALERSHIP AS I FILE THIS REPORT FOR THE SAME PROBLEM.
NHTSA ODI #10380247
NHTSA investigations
4EA24003 · Vehicle Entrapment
Opened Aug 1, 2024 · No close date supplied
Status: open (inferred from source dates) · Latches/locks/linkages
The Office of Defects Investigation (ODI) opened PE23-008 on May 1, 2023 to investigate an incident involving a 2009 Dodge Journey alleging occupant entrapment during a vehicle fire that resulted in a fatality. During the investigation, ODI collected information from the manufacturer and involved parties to confirm or refute the defect allegation. ODI has determined that additional reports of vehicle entrapment exist for other model year Dodge Journey vehicles. ODI continues to explore the cause of the thermal event and its potential effect on the actuation of the door locks. ODI also continues to explore other potential causes for door lock malfunction. ODI has determined that an upgrade to an Engineering Analysis (EA) is necessary to continue the review of the investigative material and to assess the risk to motor vehicle safety . To review the ODI report cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
PE19014 · Active Head Rest Inadvertent Deployment
Opened Sep 9, 2019 · Closed Feb 25, 2026
Status: closed (inferred from source dates) · Seats; Seats:front Assembly:head Restraint
The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Seats
The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Seats:front Assembly:head Restraint
The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
DP14004 · Totally Integrated Power Module Failure
Opened Sep 25, 2014 · Closed Jul 24, 2015
Status: closed (inferred from source dates) · Electrical System
In a letter dated August 21, 2014, the Center for Auto Safety (CAS) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged failures associated with the Totally Integrated Power Module (TIPM) installed in Chrysler SUV?s, trucks, and vans beginning in the 2007 model year. The petitioner alleges that TIPM defects may result in engine stall, airbag non-deployment, failure of fuel pump shutoff resulting in unintended acceleration, fire, and other symptoms. On September 25, 2014, the Office of Defects Investigation (ODI) opened DP14-004 to evaluate the petition for a grant or deny decision. ODI analyzed complaint data provided by CAS as well as complaints submitted to ODI from consumers. In total, there were 296 complaints submitted by the petitioner in the original petition and five supplements, including 271 complaints related to the subject vehicles equipped with TIPM-7. Approximately 3 percent of CAS complaints are related to vehicles equipped with TIPM-6 and ODI?s review of these complaints did not identify any safety defect trends. ODI conducted a detailed review of complaints narratives submitted by CAS and consumers including careful analysis of vehicle repair histories, warranty claims obtained from the manufacturer and any available Customer Assistance Inquiry reports (CAIR). Analysis of the field data indicated that MY2011-2013 Jeep Grand Cherokee and Dodge Durango vehicles exhibited significantly higher complaint rates related to fuel pump relay (FPR) failures than other subject vehicles. In a September 3, 2014 letter to NHTSA, Chrysler submitted a Defect Information Report (DIR) identifying a defect in the FPR within the TIPM-7 which can result in a no start or stall condition in approximately 188,723 model year (MY) 2011 Jeep Grand Cherokee (WK) and Dodge Durango (WD) vehicles manufactured from January 5, 2010 through July 20, 2011 (14V-530).In a February 24, 2015 letter, Chrysler submitted a second DIR expanding the scope of the FPR defect condition to include an additional 338,216 MY 2012 through 2013 Jeep Grand Cherokee vehicles manufactured from September 17, 2010 through August 19, 2013 and MY 2012 through 2013 Dodge Durango vehicles manufactured from January 18, 2011 through August 19, 2013 (15V-115).ODI analysis of the CAS allegations of TIPM defects resulting in stall while driving, airbag non-deployment, unintended acceleration, fire and other faults identified a single defect condition related to 1 of over 60 different circuits in the TIPM assembly. The most common effect of this defect condition, related to the fuel pump relay, was a no-start concern, but it could also result in stall while driving (76 complaints). No valid evidence was presented in support of claims related to airbag non-deployment, unintended acceleration or fire resulting from TIPM faults and these claims were found to be wholly without merit based on review of the field data and design of the relevant systems and components.Except insofar as the petitioner's contentions relate to the defect condition addressed by the Chrysler recalls, the factual bases of the petitioner's contentions that any further investigation is necessary are unsupported. In our view, additional investigation is unlikely to result in a finding that a defect related to motor vehicle safety exists or a NHTSA order for the notification and remedy of a safety-related defect as alleged by the petitioner at the conclusion of the requested investigation. Therefore, in view of the need to allocate and prioritize NHTSA's limited resources to best accomplish the agency's safety mission, the petition is den
RQ14002 · Air Bag Non-Deployment/Engine Stall
Opened Jun 16, 2014 · Closed Mar 2, 2015
Status: closed (inferred from source dates) · Air Bags; Electrical System:ignition:module
In March 2011 Chrysler submitted a defect information report for NHTSA Recall No. 11V139 declaring a defect condition that could cause the ignition key to inadvertently move from the RUN to the ACC position on model year (MY) 2010 Dodge Journey, Grand Caravan, and Chrysler Town and Country.The report identified engine stalling as the defect consequence and cited customer complaints and warranty claims, as well as two rear-end collisions, as leading to the recall action.Chrysler determined that a defective WIN module, which is effectively the equivalent of the ignition switch, was the cause of the inadvertent key rotation, and that a new design WIN module would be installed as a remedy.In Spring 2014 ODI conducted outreach to major light vehicle manufacturers regarding ignition key position and its effect on air bag system availability.The outreach was conducted in connection with NHTSA Recall No. 14V047, a recent recall involving inadvertent ignition key rotation and subsequent air bag disablement in certain GM products.During discussions held in April 2014, Chrysler advised ODI that Chrysler air bag systems of this vintage, including the subject vehicles, revert to energy reserve when the ignition key moves to the ACC or OFF position, and that under energy reserve the air bags would only be available for a short period, approximately two tenths of a second (ODI notes this consequence was not identified in the 11V139 recall report).A review of the ODI consumer database conducted after the April 2014 discussions identified complaints alleging that MY 2008-2009 vehicles may have a similar defect as the MY 2010 vehicles, and that some MY 2010 consumers reported experiencing ignition key position concerns after the 11V139 recall remedy was applied.Accordingly this investigation was opened.In response to ODI?s information request letter, Chrysler reported that MY 2008-2009 subject vehicles used the same design WIN module as the recalled vehicles, and also identified 66 consumer reports and one non-injury crash incident potentially related to inadvertent ignition key rotation.Chrysler?s review of the MY 2010 remedy used in 11V139, which involved installation of a Trim Ring as opposed to replacement of the WIN module, showed the remedy did not adequately address ignition key position concerns, and in some use-cases could cause other systems to operate improperly (radio, instrument panel lighting, HVAC fan motor, etc.).Chrysler subsequently filed multiple defect information reports to 1) add the MY 2008-2009 Dodge Grand Caravan and Chrysler Town and Country, and the MY 2009 Dodge Journey to the original recall scope, and 2) stating that the complete WIN module would be replaced with a new design component in all recalled vehicles (including those that had the Trim Ring installed during 11V139).Chrysler?s report also advises of constrained remedy parts availability, see NHTSA Recall No. 14V373 for further details.Accordingly, the investigation is closed based on the recall action Chrysler is undertaking.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10584873, 10583399, 10573295, 10566365, 10546805, 10513060, 10509284, 10503121, 10496599, 10475027, 10456099, 10450629, 10443680, 10422766, 10410447, 10409269, 10402947, 10402751, 10402660, 10396943, 10394957, 10356632, 10315972
Additional source detail variants (2)
Air Bags
In March 2011 Chrysler submitted a defect information report for NHTSA Recall No. 11V139 declaring a defect condition that could cause the ignition key to inadvertently move from the RUN to the ACC position on model year (MY) 2010 Dodge Journey, Grand Caravan, and Chrysler Town and Country.The report identified engine stalling as the defect consequence and cited customer complaints and warranty claims, as well as two rear-end collisions, as leading to the recall action.Chrysler determined that a defective WIN module, which is effectively the equivalent of the ignition switch, was the cause of the inadvertent key rotation, and that a new design WIN module would be installed as a remedy.In Spring 2014 ODI conducted outreach to major light vehicle manufacturers regarding ignition key position and its effect on air bag system availability.The outreach was conducted in connection with NHTSA Recall No. 14V047, a recent recall involving inadvertent ignition key rotation and subsequent air bag disablement in certain GM products.During discussions held in April 2014, Chrysler advised ODI that Chrysler air bag systems of this vintage, including the subject vehicles, revert to energy reserve when the ignition key moves to the ACC or OFF position, and that under energy reserve the air bags would only be available for a short period, approximately two tenths of a second (ODI notes this consequence was not identified in the 11V139 recall report).A review of the ODI consumer database conducted after the April 2014 discussions identified complaints alleging that MY 2008-2009 vehicles may have a similar defect as the MY 2010 vehicles, and that some MY 2010 consumers reported experiencing ignition key position concerns after the 11V139 recall remedy was applied.Accordingly this investigation was opened.In response to ODI?s information request letter, Chrysler reported that MY 2008-2009 subject vehicles used the same design WIN module as the recalled vehicles, and also identified 66 consumer reports and one non-injury crash incident potentially related to inadvertent ignition key rotation.Chrysler?s review of the MY 2010 remedy used in 11V139, which involved installation of a Trim Ring as opposed to replacement of the WIN module, showed the remedy did not adequately address ignition key position concerns, and in some use-cases could cause other systems to operate improperly (radio, instrument panel lighting, HVAC fan motor, etc.).Chrysler subsequently filed multiple defect information reports to 1) add the MY 2008-2009 Dodge Grand Caravan and Chrysler Town and Country, and the MY 2009 Dodge Journey to the original recall scope, and 2) stating that the complete WIN module would be replaced with a new design component in all recalled vehicles (including those that had the Trim Ring installed during 11V139).Chrysler?s report also advises of constrained remedy parts availability, see NHTSA Recall No. 14V373 for further details.Accordingly, the investigation is closed based on the recall action Chrysler is undertaking.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10584873, 10583399, 10573295, 10566365, 10546805, 10513060, 10509284, 10503121, 10496599, 10475027, 10456099, 10450629, 10443680, 10422766, 10410447, 10409269, 10402947, 10402751, 10402660, 10396943, 10394957, 10356632, 10315972
Electrical System:ignition:module
In March 2011 Chrysler submitted a defect information report for NHTSA Recall No. 11V139 declaring a defect condition that could cause the ignition key to inadvertently move from the RUN to the ACC position on model year (MY) 2010 Dodge Journey, Grand Caravan, and Chrysler Town and Country.The report identified engine stalling as the defect consequence and cited customer complaints and warranty claims, as well as two rear-end collisions, as leading to the recall action.Chrysler determined that a defective WIN module, which is effectively the equivalent of the ignition switch, was the cause of the inadvertent key rotation, and that a new design WIN module would be installed as a remedy.In Spring 2014 ODI conducted outreach to major light vehicle manufacturers regarding ignition key position and its effect on air bag system availability.The outreach was conducted in connection with NHTSA Recall No. 14V047, a recent recall involving inadvertent ignition key rotation and subsequent air bag disablement in certain GM products.During discussions held in April 2014, Chrysler advised ODI that Chrysler air bag systems of this vintage, including the subject vehicles, revert to energy reserve when the ignition key moves to the ACC or OFF position, and that under energy reserve the air bags would only be available for a short period, approximately two tenths of a second (ODI notes this consequence was not identified in the 11V139 recall report).A review of the ODI consumer database conducted after the April 2014 discussions identified complaints alleging that MY 2008-2009 vehicles may have a similar defect as the MY 2010 vehicles, and that some MY 2010 consumers reported experiencing ignition key position concerns after the 11V139 recall remedy was applied.Accordingly this investigation was opened.In response to ODI?s information request letter, Chrysler reported that MY 2008-2009 subject vehicles used the same design WIN module as the recalled vehicles, and also identified 66 consumer reports and one non-injury crash incident potentially related to inadvertent ignition key rotation.Chrysler?s review of the MY 2010 remedy used in 11V139, which involved installation of a Trim Ring as opposed to replacement of the WIN module, showed the remedy did not adequately address ignition key position concerns, and in some use-cases could cause other systems to operate improperly (radio, instrument panel lighting, HVAC fan motor, etc.).Chrysler subsequently filed multiple defect information reports to 1) add the MY 2008-2009 Dodge Grand Caravan and Chrysler Town and Country, and the MY 2009 Dodge Journey to the original recall scope, and 2) stating that the complete WIN module would be replaced with a new design component in all recalled vehicles (including those that had the Trim Ring installed during 11V139).Chrysler?s report also advises of constrained remedy parts availability, see NHTSA Recall No. 14V373 for further details.Accordingly, the investigation is closed based on the recall action Chrysler is undertaking.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10584873, 10583399, 10573295, 10566365, 10546805, 10513060, 10509284, 10503121, 10496599, 10475027, 10456099, 10450629, 10443680, 10422766, 10410447, 10409269, 10402947, 10402751, 10402660, 10396943, 10394957, 10356632, 10315972
Illustration