NHTSA owner reports · September 18, 2026 snapshot.
Steering complaints
69 reportsClear category filter140,000 miles · Jan 15, 2020
Steering
TL* THE CONTACT OWNS A 2010 DODGE JOURNEY. THE CONTACT STATED THAT SHE HAD NOTICED THE STEERING WHEEL WOULD BECOME DIFFICULT TO OPERATE WITHOUT WARNING AND ALSO NOTICED FLUID SPOTS ON HER DRIVEWAY. THE CONTACT TOOK THE VEHICLE TO AN INDEPENDENT MECHANIC WHO INFORMED HER THAT THERE HAD BEEN A RECALL PLACED ON THE VEHICLE FOR A DE…
Read full complaint
TL* THE CONTACT OWNS A 2010 DODGE JOURNEY. THE CONTACT STATED THAT SHE HAD NOTICED THE STEERING WHEEL WOULD BECOME DIFFICULT TO OPERATE WITHOUT WARNING AND ALSO NOTICED FLUID SPOTS ON HER DRIVEWAY. THE CONTACT TOOK THE VEHICLE TO AN INDEPENDENT MECHANIC WHO INFORMED HER THAT THERE HAD BEEN A RECALL PLACED ON THE VEHICLE FOR A DEFECTIVE POWER STEERING RETURN HOSE. THE CONTACT THEN CALLED SCHLOSSMANN DODGE CITY CHRYSLER JEEP RAM FIAT (19100 W CAPITOL DR, BROOKFIELD, WI 53045) WHERE IT WAS INFORMED THAT HER VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 16V273000 (STEERING). THE CONTACT SPOKE WITH THE MANUFACTURER WHO GAVE HER THE SAME INFORMATION; THEY THEN REFERRED HER TO NHTSA. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 140,000. *PM *TP
NHTSA ODI #11299518
106,000 miles · Jan 13, 2020
Steering
TL* THE CONTACT OWNS A 2010 DODGE JOURNEY. THE CONTACT STATED WHEN SHE ATTEMPTED TO START THE VEHICLE, THE POWER STEERING WENT COMPLETELY OUT AND PINK FLUID WAS RELEASED. THE CONTACT WAS ABLE TO DRIVE THE VEHICLE TO A LOCAL MECHANIC TO BE REPAIRED THREE TIMES. THE PARTS REPLACED WERE UNKNOWN; HOWEVER THE FAILURE REOCCURRED. THE …
Read full complaint
TL* THE CONTACT OWNS A 2010 DODGE JOURNEY. THE CONTACT STATED WHEN SHE ATTEMPTED TO START THE VEHICLE, THE POWER STEERING WENT COMPLETELY OUT AND PINK FLUID WAS RELEASED. THE CONTACT WAS ABLE TO DRIVE THE VEHICLE TO A LOCAL MECHANIC TO BE REPAIRED THREE TIMES. THE PARTS REPLACED WERE UNKNOWN; HOWEVER THE FAILURE REOCCURRED. THE CONTACT REFERRED THE FAILURE TO NHTSA CAMPAIGN NUMBER: 16V273000 (STEERING) AND NHTSA CAMPAIGN NUMBER: 10V475000 (STEERING). THE VEHICLE WAS NOT TAKEN TO A DEALER AND THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 106,000.
NHTSA ODI #11299006
105,000 miles · Nov 29, 2019
Electronic Stability Control (esc)Service BrakesSteering
SHORTLY AFTER BEGINNING TO DRIVE THE CAR, THE TRACTION CONTROL LIGHT COMES ON, THE STEERING TIGHTENS UP AND THE BRAKES FREEZE UP. THIS HAPPENS ON COMPLETELY DRY ROADS. THIS HAPPENED 2 TIMES WITHIN 1 MILE OF EACH TIME. THE FIRST TIME I ALMOST WENT THROUGH AN INTERSECTION BECAUSE I COULDN'T GET STOPPED, AND THE SECOND TIME I ALMOS…
Read full complaint
SHORTLY AFTER BEGINNING TO DRIVE THE CAR, THE TRACTION CONTROL LIGHT COMES ON, THE STEERING TIGHTENS UP AND THE BRAKES FREEZE UP. THIS HAPPENS ON COMPLETELY DRY ROADS. THIS HAPPENED 2 TIMES WITHIN 1 MILE OF EACH TIME. THE FIRST TIME I ALMOST WENT THROUGH AN INTERSECTION BECAUSE I COULDN'T GET STOPPED, AND THE SECOND TIME I ALMOST REAR ENDED A CAR. I HAD BOTH OF MY CHILDREN WHO ARE 7 AND 10 IN THE VEHICLE. THIS IS NOT THE FIRST TIME THIS ISSUE HAS HAPPENED. IT HAPPENED 6 MONTHS AGO, AND MY MECHANIC SAID THE CODE WAS A FAULTY TPM WHICH WAS REPLACED. IT THEN HAPPENED A MONTH AGO, AND THE MOST RECENT TIME WHICH WAS LAST WEEK. I'VE BEEN RESEARCHING THIS ISSUE AND IT SEEMS THAT THE DODGE JOURNEY HAS HAD THIS ISSUE, AMONG OTHERS. IT SEEMS AS IF THIS VEHICLE NEEDS A COMPLETE RECALL. SOMEBODY IS GOING TO END UP SERIOUSLY INJURED OR DEAD. I STILL OWE $10K ON MY VEHICLE AND CANNOT AFFORD TO BUY ANOTHER AND PAY THIS LOAN. I NEED TO GET RID OF THIS VEHICLE AND DODGE NEEDS TO TAKE RESPONSIBILITY.
NHTSA ODI #11282848
121,988 miles · Nov 15, 2019
Steering
TL* THE CONTACT OWNS A 2010 DODGE JOURNEY. WHILE STARTING THE VEHICLE, THE STEERING HOSE BURST WITHOUT WARNING. THE VEHICLE WAS TAKEN TO A REPAIR SHOP WHERE IT WAS DIAGNOSED THAT THE STEERING HOSE NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED ON 11/20/19. THE MANUFACTURER WAS CONTACTED AND REFERRED THE CONTACT TO NHTSA. THE DE…
Read full complaint
TL* THE CONTACT OWNS A 2010 DODGE JOURNEY. WHILE STARTING THE VEHICLE, THE STEERING HOSE BURST WITHOUT WARNING. THE VEHICLE WAS TAKEN TO A REPAIR SHOP WHERE IT WAS DIAGNOSED THAT THE STEERING HOSE NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED ON 11/20/19. THE MANUFACTURER WAS CONTACTED AND REFERRED THE CONTACT TO NHTSA. THE DEALER WAS CONTACTED. THE CONTACT STATED THAT THE FAILURE WAS SIMILAR TO NHTSA CAMPAIGN NUMBER: 16V373000 (STEERING). THE FAILURE MILEAGE WAS 121,988. *DT*JB
NHTSA ODI #11280315
155,000 miles · Nov 1, 2019
Steering
THE POWER STEERING HOSE KEEPS RUPTUREING WHEN YOU FIRST START IT UP
NHTSA ODI #11277522
121,000 miles · Sep 3, 2019
Electrical SystemPower TrainSteering
AS I WAS DRIVING I TIRED TO TURN THE WHEEL TO GO AROUND A SMALL CURVE ON A CITY STREET AND IT WOULDN'T TURN. I COULD FEEL THE CAR STARING TO DIE. AS I PUT THE CAR IN PARK TO TURN THE IGNITION OFF THE BREAK PEDAL WOULD NOT WORK. I WAS ABLE TO TURN THE CAR OFF AND RESTART WITHOUT ANY ISSUES. LATER MY HORN STARTED HONKING ON ITS…
Read full complaint
AS I WAS DRIVING I TIRED TO TURN THE WHEEL TO GO AROUND A SMALL CURVE ON A CITY STREET AND IT WOULDN'T TURN. I COULD FEEL THE CAR STARING TO DIE. AS I PUT THE CAR IN PARK TO TURN THE IGNITION OFF THE BREAK PEDAL WOULD NOT WORK. I WAS ABLE TO TURN THE CAR OFF AND RESTART WITHOUT ANY ISSUES. LATER MY HORN STARTED HONKING ON ITS OWN. AND CONTINUES TO HONK RANDOMLY. ALSO THE ALARM RANDOMLY WENT OFF ONCE YESTERDAY. TODAY IT HAS RANDOMLY HONKED ALL AFTERNOON.
NHTSA ODI #11253028
1 miles · Sep 2, 2019
Electrical SystemElectronic Stability Control (esc)Steering
CAR WILL NOT START AT TIMES. CANT PUT IT IN GEAR AT TIMES. EAP LIGHT COMES ON WITHOUT ANY ISSUES. SEEMS ALL ELECTRICALLY ISSUES MUST REPAIR BRAKE AND TURN SIGNAL LIGHTS EVERY OTHER MONTH
NHTSA ODI #11252743
56,000 miles · Aug 6, 2019
Electrical SystemElectronic Stability Control (esc)Steering
UNCONTROLLABLE CONSTANT HORN HONKING WHILE THE VEHICLE IS DRIVING, WHILE ON OR OFF, ALSO KEY FOB DOES NOT START OR STOP THE NOISE. BEEN TO THE DEALERSHIP NON STOP SINCE GETTING THE VEHICLE AS WELL AS A FEW OTHER SHOPS AND NO ONE HAS BEEN ABLE TO COMPLETELY FIX THE ISSUE IT HAS CONTINUED TO RETURN. EVERY TRIP TO THE DEALER THEY H…
Read full complaint
UNCONTROLLABLE CONSTANT HORN HONKING WHILE THE VEHICLE IS DRIVING, WHILE ON OR OFF, ALSO KEY FOB DOES NOT START OR STOP THE NOISE. BEEN TO THE DEALERSHIP NON STOP SINCE GETTING THE VEHICLE AS WELL AS A FEW OTHER SHOPS AND NO ONE HAS BEEN ABLE TO COMPLETELY FIX THE ISSUE IT HAS CONTINUED TO RETURN. EVERY TRIP TO THE DEALER THEY HAVE TOLD ME THE VEHICLE IS FINE, ERASE ANY SENSORS THAT APPEAR ON THE DASH, AND SEND ME HOME UNTIL THE PROBLEMS CONTINUE TO HAPPEN. REMOVED THE FUSE TO SILENCE THE HORN NOISE BUT HAS CONTINUED TO DRAIN THE NEW BATTERY. HAVE HAD NO LUCK WITH THE VEHICLE AND NOW I CANNOT DRIVE IT BECAUSE IT KEEPS DYING. THERE IS A LOT WRONG WITH THIS VEHICLE.
NHTSA ODI #11242132
20 miles · May 6, 2019
Steering
I STARTED MY 2010 DODGE JOURNEY AND WAS DRIVING DOWN THE INTERSTATE. I BEGAN TO GO AROUND A SHARP CURVE AND REALIZED I HAD LOST ALL POWER STEERING. THIS ALMOST RESULTED IN A CRASH INTO ANOTHER VEHICLE AND THEN ALMOST A BARRICADE. THANKFULLY I WAS ABLE TO SOMEWHAT GAIN CONTROL OF THE VEHICLE. MY WIFE AND 10 MONTH OLD BABY WER…
Read full complaint
I STARTED MY 2010 DODGE JOURNEY AND WAS DRIVING DOWN THE INTERSTATE. I BEGAN TO GO AROUND A SHARP CURVE AND REALIZED I HAD LOST ALL POWER STEERING. THIS ALMOST RESULTED IN A CRASH INTO ANOTHER VEHICLE AND THEN ALMOST A BARRICADE. THANKFULLY I WAS ABLE TO SOMEWHAT GAIN CONTROL OF THE VEHICLE. MY WIFE AND 10 MONTH OLD BABY WERE ALSO IN THE VEHICLE. I LATER LEARNED THAT THE POWER STEERING RETURN LINE HAD RUPTURED. I WOULD CONSIDER THIS A ISOLATED INCIDENT AND NOT A VEHICLE PROBLEM IF THERE WASN'T ALREADY A RECALL FOR OTHER DODGE JOURNEYS WITH THE EXACT SAME PROBLEM.
NHTSA ODI #11205920
119,000 miles · Apr 23, 2019
Steering
TL* THE CONTACT OWNS A 2010 DODGE JOURNEY. THE CONTACT STATED THAT THE HORN MALFUNCTIONED AND WOULD SOUND AT RANDOM. THE VEHICLE WAS TAKEN TO AUTONATION (3000 NORTH LAKE PARKWAY, COLUMBUS, GA 31909, (330) 238-3206) WHERE IT WAS DIAGNOSED THAT A NEW STEERING SYSTEM WAS NEEDED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT MA…
Read full complaint
TL* THE CONTACT OWNS A 2010 DODGE JOURNEY. THE CONTACT STATED THAT THE HORN MALFUNCTIONED AND WOULD SOUND AT RANDOM. THE VEHICLE WAS TAKEN TO AUTONATION (3000 NORTH LAKE PARKWAY, COLUMBUS, GA 31909, (330) 238-3206) WHERE IT WAS DIAGNOSED THAT A NEW STEERING SYSTEM WAS NEEDED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 119,000. THE VIN WAS INVALID.
NHTSA ODI #11203179
NHTSA investigations
4EA24003 · Vehicle Entrapment
Opened Aug 1, 2024 · No close date supplied
Status: open (inferred from source dates) · Latches/locks/linkages
The Office of Defects Investigation (ODI) opened PE23-008 on May 1, 2023 to investigate an incident involving a 2009 Dodge Journey alleging occupant entrapment during a vehicle fire that resulted in a fatality. During the investigation, ODI collected information from the manufacturer and involved parties to confirm or refute the defect allegation. ODI has determined that additional reports of vehicle entrapment exist for other model year Dodge Journey vehicles. ODI continues to explore the cause of the thermal event and its potential effect on the actuation of the door locks. ODI also continues to explore other potential causes for door lock malfunction. ODI has determined that an upgrade to an Engineering Analysis (EA) is necessary to continue the review of the investigative material and to assess the risk to motor vehicle safety . To review the ODI report cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
PE19014 · Active Head Rest Inadvertent Deployment
Opened Sep 9, 2019 · Closed Feb 25, 2026
Status: closed (inferred from source dates) · Seats; Seats:front Assembly:head Restraint
The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Seats
The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Seats:front Assembly:head Restraint
The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
DP14004 · Totally Integrated Power Module Failure
Opened Sep 25, 2014 · Closed Jul 24, 2015
Status: closed (inferred from source dates) · Electrical System
In a letter dated August 21, 2014, the Center for Auto Safety (CAS) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged failures associated with the Totally Integrated Power Module (TIPM) installed in Chrysler SUV?s, trucks, and vans beginning in the 2007 model year. The petitioner alleges that TIPM defects may result in engine stall, airbag non-deployment, failure of fuel pump shutoff resulting in unintended acceleration, fire, and other symptoms. On September 25, 2014, the Office of Defects Investigation (ODI) opened DP14-004 to evaluate the petition for a grant or deny decision. ODI analyzed complaint data provided by CAS as well as complaints submitted to ODI from consumers. In total, there were 296 complaints submitted by the petitioner in the original petition and five supplements, including 271 complaints related to the subject vehicles equipped with TIPM-7. Approximately 3 percent of CAS complaints are related to vehicles equipped with TIPM-6 and ODI?s review of these complaints did not identify any safety defect trends. ODI conducted a detailed review of complaints narratives submitted by CAS and consumers including careful analysis of vehicle repair histories, warranty claims obtained from the manufacturer and any available Customer Assistance Inquiry reports (CAIR). Analysis of the field data indicated that MY2011-2013 Jeep Grand Cherokee and Dodge Durango vehicles exhibited significantly higher complaint rates related to fuel pump relay (FPR) failures than other subject vehicles. In a September 3, 2014 letter to NHTSA, Chrysler submitted a Defect Information Report (DIR) identifying a defect in the FPR within the TIPM-7 which can result in a no start or stall condition in approximately 188,723 model year (MY) 2011 Jeep Grand Cherokee (WK) and Dodge Durango (WD) vehicles manufactured from January 5, 2010 through July 20, 2011 (14V-530).In a February 24, 2015 letter, Chrysler submitted a second DIR expanding the scope of the FPR defect condition to include an additional 338,216 MY 2012 through 2013 Jeep Grand Cherokee vehicles manufactured from September 17, 2010 through August 19, 2013 and MY 2012 through 2013 Dodge Durango vehicles manufactured from January 18, 2011 through August 19, 2013 (15V-115).ODI analysis of the CAS allegations of TIPM defects resulting in stall while driving, airbag non-deployment, unintended acceleration, fire and other faults identified a single defect condition related to 1 of over 60 different circuits in the TIPM assembly. The most common effect of this defect condition, related to the fuel pump relay, was a no-start concern, but it could also result in stall while driving (76 complaints). No valid evidence was presented in support of claims related to airbag non-deployment, unintended acceleration or fire resulting from TIPM faults and these claims were found to be wholly without merit based on review of the field data and design of the relevant systems and components.Except insofar as the petitioner's contentions relate to the defect condition addressed by the Chrysler recalls, the factual bases of the petitioner's contentions that any further investigation is necessary are unsupported. In our view, additional investigation is unlikely to result in a finding that a defect related to motor vehicle safety exists or a NHTSA order for the notification and remedy of a safety-related defect as alleged by the petitioner at the conclusion of the requested investigation. Therefore, in view of the need to allocate and prioritize NHTSA's limited resources to best accomplish the agency's safety mission, the petition is den
RQ14002 · Air Bag Non-Deployment/Engine Stall
Opened Jun 16, 2014 · Closed Mar 2, 2015
Status: closed (inferred from source dates) · Air Bags; Electrical System:ignition:module
In March 2011 Chrysler submitted a defect information report for NHTSA Recall No. 11V139 declaring a defect condition that could cause the ignition key to inadvertently move from the RUN to the ACC position on model year (MY) 2010 Dodge Journey, Grand Caravan, and Chrysler Town and Country.The report identified engine stalling as the defect consequence and cited customer complaints and warranty claims, as well as two rear-end collisions, as leading to the recall action.Chrysler determined that a defective WIN module, which is effectively the equivalent of the ignition switch, was the cause of the inadvertent key rotation, and that a new design WIN module would be installed as a remedy.In Spring 2014 ODI conducted outreach to major light vehicle manufacturers regarding ignition key position and its effect on air bag system availability.The outreach was conducted in connection with NHTSA Recall No. 14V047, a recent recall involving inadvertent ignition key rotation and subsequent air bag disablement in certain GM products.During discussions held in April 2014, Chrysler advised ODI that Chrysler air bag systems of this vintage, including the subject vehicles, revert to energy reserve when the ignition key moves to the ACC or OFF position, and that under energy reserve the air bags would only be available for a short period, approximately two tenths of a second (ODI notes this consequence was not identified in the 11V139 recall report).A review of the ODI consumer database conducted after the April 2014 discussions identified complaints alleging that MY 2008-2009 vehicles may have a similar defect as the MY 2010 vehicles, and that some MY 2010 consumers reported experiencing ignition key position concerns after the 11V139 recall remedy was applied.Accordingly this investigation was opened.In response to ODI?s information request letter, Chrysler reported that MY 2008-2009 subject vehicles used the same design WIN module as the recalled vehicles, and also identified 66 consumer reports and one non-injury crash incident potentially related to inadvertent ignition key rotation.Chrysler?s review of the MY 2010 remedy used in 11V139, which involved installation of a Trim Ring as opposed to replacement of the WIN module, showed the remedy did not adequately address ignition key position concerns, and in some use-cases could cause other systems to operate improperly (radio, instrument panel lighting, HVAC fan motor, etc.).Chrysler subsequently filed multiple defect information reports to 1) add the MY 2008-2009 Dodge Grand Caravan and Chrysler Town and Country, and the MY 2009 Dodge Journey to the original recall scope, and 2) stating that the complete WIN module would be replaced with a new design component in all recalled vehicles (including those that had the Trim Ring installed during 11V139).Chrysler?s report also advises of constrained remedy parts availability, see NHTSA Recall No. 14V373 for further details.Accordingly, the investigation is closed based on the recall action Chrysler is undertaking.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10584873, 10583399, 10573295, 10566365, 10546805, 10513060, 10509284, 10503121, 10496599, 10475027, 10456099, 10450629, 10443680, 10422766, 10410447, 10409269, 10402947, 10402751, 10402660, 10396943, 10394957, 10356632, 10315972
Additional source detail variants (2)
Air Bags
In March 2011 Chrysler submitted a defect information report for NHTSA Recall No. 11V139 declaring a defect condition that could cause the ignition key to inadvertently move from the RUN to the ACC position on model year (MY) 2010 Dodge Journey, Grand Caravan, and Chrysler Town and Country.The report identified engine stalling as the defect consequence and cited customer complaints and warranty claims, as well as two rear-end collisions, as leading to the recall action.Chrysler determined that a defective WIN module, which is effectively the equivalent of the ignition switch, was the cause of the inadvertent key rotation, and that a new design WIN module would be installed as a remedy.In Spring 2014 ODI conducted outreach to major light vehicle manufacturers regarding ignition key position and its effect on air bag system availability.The outreach was conducted in connection with NHTSA Recall No. 14V047, a recent recall involving inadvertent ignition key rotation and subsequent air bag disablement in certain GM products.During discussions held in April 2014, Chrysler advised ODI that Chrysler air bag systems of this vintage, including the subject vehicles, revert to energy reserve when the ignition key moves to the ACC or OFF position, and that under energy reserve the air bags would only be available for a short period, approximately two tenths of a second (ODI notes this consequence was not identified in the 11V139 recall report).A review of the ODI consumer database conducted after the April 2014 discussions identified complaints alleging that MY 2008-2009 vehicles may have a similar defect as the MY 2010 vehicles, and that some MY 2010 consumers reported experiencing ignition key position concerns after the 11V139 recall remedy was applied.Accordingly this investigation was opened.In response to ODI?s information request letter, Chrysler reported that MY 2008-2009 subject vehicles used the same design WIN module as the recalled vehicles, and also identified 66 consumer reports and one non-injury crash incident potentially related to inadvertent ignition key rotation.Chrysler?s review of the MY 2010 remedy used in 11V139, which involved installation of a Trim Ring as opposed to replacement of the WIN module, showed the remedy did not adequately address ignition key position concerns, and in some use-cases could cause other systems to operate improperly (radio, instrument panel lighting, HVAC fan motor, etc.).Chrysler subsequently filed multiple defect information reports to 1) add the MY 2008-2009 Dodge Grand Caravan and Chrysler Town and Country, and the MY 2009 Dodge Journey to the original recall scope, and 2) stating that the complete WIN module would be replaced with a new design component in all recalled vehicles (including those that had the Trim Ring installed during 11V139).Chrysler?s report also advises of constrained remedy parts availability, see NHTSA Recall No. 14V373 for further details.Accordingly, the investigation is closed based on the recall action Chrysler is undertaking.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10584873, 10583399, 10573295, 10566365, 10546805, 10513060, 10509284, 10503121, 10496599, 10475027, 10456099, 10450629, 10443680, 10422766, 10410447, 10409269, 10402947, 10402751, 10402660, 10396943, 10394957, 10356632, 10315972
Electrical System:ignition:module
In March 2011 Chrysler submitted a defect information report for NHTSA Recall No. 11V139 declaring a defect condition that could cause the ignition key to inadvertently move from the RUN to the ACC position on model year (MY) 2010 Dodge Journey, Grand Caravan, and Chrysler Town and Country.The report identified engine stalling as the defect consequence and cited customer complaints and warranty claims, as well as two rear-end collisions, as leading to the recall action.Chrysler determined that a defective WIN module, which is effectively the equivalent of the ignition switch, was the cause of the inadvertent key rotation, and that a new design WIN module would be installed as a remedy.In Spring 2014 ODI conducted outreach to major light vehicle manufacturers regarding ignition key position and its effect on air bag system availability.The outreach was conducted in connection with NHTSA Recall No. 14V047, a recent recall involving inadvertent ignition key rotation and subsequent air bag disablement in certain GM products.During discussions held in April 2014, Chrysler advised ODI that Chrysler air bag systems of this vintage, including the subject vehicles, revert to energy reserve when the ignition key moves to the ACC or OFF position, and that under energy reserve the air bags would only be available for a short period, approximately two tenths of a second (ODI notes this consequence was not identified in the 11V139 recall report).A review of the ODI consumer database conducted after the April 2014 discussions identified complaints alleging that MY 2008-2009 vehicles may have a similar defect as the MY 2010 vehicles, and that some MY 2010 consumers reported experiencing ignition key position concerns after the 11V139 recall remedy was applied.Accordingly this investigation was opened.In response to ODI?s information request letter, Chrysler reported that MY 2008-2009 subject vehicles used the same design WIN module as the recalled vehicles, and also identified 66 consumer reports and one non-injury crash incident potentially related to inadvertent ignition key rotation.Chrysler?s review of the MY 2010 remedy used in 11V139, which involved installation of a Trim Ring as opposed to replacement of the WIN module, showed the remedy did not adequately address ignition key position concerns, and in some use-cases could cause other systems to operate improperly (radio, instrument panel lighting, HVAC fan motor, etc.).Chrysler subsequently filed multiple defect information reports to 1) add the MY 2008-2009 Dodge Grand Caravan and Chrysler Town and Country, and the MY 2009 Dodge Journey to the original recall scope, and 2) stating that the complete WIN module would be replaced with a new design component in all recalled vehicles (including those that had the Trim Ring installed during 11V139).Chrysler?s report also advises of constrained remedy parts availability, see NHTSA Recall No. 14V373 for further details.Accordingly, the investigation is closed based on the recall action Chrysler is undertaking.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10584873, 10583399, 10573295, 10566365, 10546805, 10513060, 10509284, 10503121, 10496599, 10475027, 10456099, 10450629, 10443680, 10422766, 10410447, 10409269, 10402947, 10402751, 10402660, 10396943, 10394957, 10356632, 10315972
Illustration