NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
600 reportsClear category filterMileage unknown · Nov 20, 2017
Electrical System
MY HORN STARTED GOING OFF IN THE MIDDLE OF NIGHT,CONSTANTLY. IT EVEN GOES OFF WHILE DRIVING. THEN MY LOCKS DON'T PULL DOWN SO ANYONE CAN OPEN MY DOORS AND NO ALARM SINCE I HAD TO DISCONNECT MY HORN. I'VE SEEN MANY YOUTUBE VIDEOS OF OTHER VEHICLE OWNERS HAVE THE SAME ISSUE AND DODGE WILL NOT ACKNOWLEDGE THIS ISSUE. VERY DANGEROU…
Read full complaint
MY HORN STARTED GOING OFF IN THE MIDDLE OF NIGHT,CONSTANTLY. IT EVEN GOES OFF WHILE DRIVING. THEN MY LOCKS DON'T PULL DOWN SO ANYONE CAN OPEN MY DOORS AND NO ALARM SINCE I HAD TO DISCONNECT MY HORN. I'VE SEEN MANY YOUTUBE VIDEOS OF OTHER VEHICLE OWNERS HAVE THE SAME ISSUE AND DODGE WILL NOT ACKNOWLEDGE THIS ISSUE. VERY DANGEROUS TO NOT HAVE A HORN ESP. DRIVING IN NY. DON'T EVER BUY DODGE/JEEP/CHRYSLER..HORRIBLE COMPANY.
NHTSA ODI #11047594
50,000 miles · Nov 16, 2017
Electrical System
ISSUES WITH STARTING CAR, ERRATIC DASHBOARD LIGHTS, AND FLICKERING POWER DROPS WHEN VEHICLE IS IN MOTION. THIS IS RELATED TO THE IGNITION KEY AND THE IGNITION SWITCH (WIN MODULE) IT'S INSERTED TO. WHEN THE CAR WON'T START YOU HAVE TO MOVE THE KEY AROUND IN THE IGNITION SWITCH TO GET IT TO FINALLY START THE CAR. I'VE TAKEN IT …
Read full complaint
ISSUES WITH STARTING CAR, ERRATIC DASHBOARD LIGHTS, AND FLICKERING POWER DROPS WHEN VEHICLE IS IN MOTION. THIS IS RELATED TO THE IGNITION KEY AND THE IGNITION SWITCH (WIN MODULE) IT'S INSERTED TO. WHEN THE CAR WON'T START YOU HAVE TO MOVE THE KEY AROUND IN THE IGNITION SWITCH TO GET IT TO FINALLY START THE CAR. I'VE TAKEN IT TO THE DEALERSHIP ON A FEW OCCASIONS AND HAD THEM LOOK AT THIS PROBLEM. MOST OF THE TIME THEY COULD NOT FIND ANYTHING. ON ONE OCCASION THEY CHANGED OUT THE BATTERY. THAT DID NOT HELP. THIS ISSUE HAS HAPPENED RARELY BACK WHEN THE CAR HAD APPROXIMATELY 50,000 MILES ON IT. NOW IT HAS 140,000, AND HAPPENS QUITE OFTEN. I'M WORRIED IT MIGHT SHUT OFF DRIVING IN TRAFFIC AND CAUSE A MAJOR SAFETY ISSUE REGARDING MY WIFE, CHILD, AND ANYONE ELSE AROUND THE VEHICLE. I'M ALSO WORRIED, ESPECIALLY LATE AT NIGHT AT HER JOBS PARKING LOT, IT WILL LEAVE HER STRANDED DUE TO THE CAR NOT STARTING.
NHTSA ODI #11046460
68,000 miles · Nov 13, 2017
Electrical System
VEHICLE WILL NOT START AFTER SITTING IDLE AND OFF AT RANDOM TIMES. IN PAST 2 WEEKS CAR WOULD NOT START AT LEAST TWICE, 3 TIMES IN THE PAST 6 MONTHS. BATTERY, STARTER, AND ALTERNATOR HAS ALL BEEN CHANGED AND STILL HAD A SHUTOFF. WHEN TURNING THE KEY A CLICK SOUND WOULD HAPPEN BUT NO TURNOVER. LIGHTS WOULD BE ON AND NO LOW BATTERY…
Read full complaint
VEHICLE WILL NOT START AFTER SITTING IDLE AND OFF AT RANDOM TIMES. IN PAST 2 WEEKS CAR WOULD NOT START AT LEAST TWICE, 3 TIMES IN THE PAST 6 MONTHS. BATTERY, STARTER, AND ALTERNATOR HAS ALL BEEN CHANGED AND STILL HAD A SHUTOFF. WHEN TURNING THE KEY A CLICK SOUND WOULD HAPPEN BUT NO TURNOVER. LIGHTS WOULD BE ON AND NO LOW BATTERY WARNING.
NHTSA ODI #11045843
121,000 miles · Nov 2, 2017
Electrical SystemExterior Lighting
WHILE DRIVING MY SON TO SCHOOL EVERYTHING SHUTS OFF IN CAR WHILE DRIVING FROM THE LIGHTS INTERIOR AND EXTERIOR, WIPERS, WINDOWS CAN NOT GO UP OR DOWN, UNABLE TO ALERT ANYONE IN TRAFFIC THAT I WAS COMING TO A STOP. THIS OCCURRED WHILE IT WAS STILL DARK OUTSIDE. HAS HAPPENED MULTIPLE TIMES NOW NO ONE KNOWS WHAT IS GOING ON AFTER T…
Read full complaint
WHILE DRIVING MY SON TO SCHOOL EVERYTHING SHUTS OFF IN CAR WHILE DRIVING FROM THE LIGHTS INTERIOR AND EXTERIOR, WIPERS, WINDOWS CAN NOT GO UP OR DOWN, UNABLE TO ALERT ANYONE IN TRAFFIC THAT I WAS COMING TO A STOP. THIS OCCURRED WHILE IT WAS STILL DARK OUTSIDE. HAS HAPPENED MULTIPLE TIMES NOW NO ONE KNOWS WHAT IS GOING ON AFTER TAKING INTO SHOP I WAS GIVEN THIS SITE TO REPORT IT DUE TO SEVERAL OTHERS CLAIMING SAME ISSUE.
NHTSA ODI #11042829
157,000 miles · Oct 17, 2017
Electrical System
TL* THE CONTACT OWNS A 2010 DODGE JOURNEY. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT HAD TO RESTART THE VEHICLE IN ORDER TO OPERATE. THE VEHICLE WAS TAKEN TO A PETERS CHEVROLET CHRYSLER JEEP DODGE (4181 US-259, LONGVIEW, TX 75605) WHERE IT WAS DIAGNOSED, BUT THE CONTACT WAS UNAWARE OF THE DIA…
Read full complaint
TL* THE CONTACT OWNS A 2010 DODGE JOURNEY. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT HAD TO RESTART THE VEHICLE IN ORDER TO OPERATE. THE VEHICLE WAS TAKEN TO A PETERS CHEVROLET CHRYSLER JEEP DODGE (4181 US-259, LONGVIEW, TX 75605) WHERE IT WAS DIAGNOSED, BUT THE CONTACT WAS UNAWARE OF THE DIAGNOSIS. THE VEHICLE WAS REPROGRAMMED; HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 157,000.
NHTSA ODI #11033975
74,000 miles · Oct 6, 2017
Electrical System
THE HORN WILL SOUND WITHOUT ANY NOTICE AND AT ANY TIME OF THE DAY. YOU CAN BE IN THE CAR OR OUT OF IT. IT CAN HAPPEN AT MULTIPLE TIMES OF THE DAY AND CAN WAKE YOU UP DURING THE NIGHT. I CONTACTED A DEALERSHIP AND WAS INFORMED THEY HAD NO KNOWLEDGE OF THE PROBLEM. ALTHOUGH YOU CAN GO ON THE INTERNET AND THERE ARE MANY COMPLAIN…
Read full complaint
THE HORN WILL SOUND WITHOUT ANY NOTICE AND AT ANY TIME OF THE DAY. YOU CAN BE IN THE CAR OR OUT OF IT. IT CAN HAPPEN AT MULTIPLE TIMES OF THE DAY AND CAN WAKE YOU UP DURING THE NIGHT. I CONTACTED A DEALERSHIP AND WAS INFORMED THEY HAD NO KNOWLEDGE OF THE PROBLEM. ALTHOUGH YOU CAN GO ON THE INTERNET AND THERE ARE MANY COMPLAINTS AND THEY SAY THEY HAVE HAD THEIR VEHICLE INTO THE DEALERSHIP WITH NO SOLUTION. IT CAN BE UNSAFE IF YOU ARE DRIVING DOWN THE ROAD AND THE HORN STARTS HONKING, BUT AS I SAY IT CAN HAPPEN IN YOUR GARAGE AT NIGHT. AS FAR AS I KNOW THERE IS NO RECALL FOR THIS, BUT THERE SHOULD BE. THIS HAS BEEN GOING ON FOR AT LEAST THE LAST 12 MONTHS.
NHTSA ODI #11032052
130,000 miles · Oct 2, 2017
Electrical System
HORN CONSTANTLY GOING OFF DRAINING BATTERY. SO FAR I HAVE REPLACED MY BATTERY TWICE. THIS HAS HAPPENED A FEW TIMES, WHILE DRIVING, PARKED, ON AND OFF. DOESN'T MATTER JUST KEEPS GOING OFF. WE TOOK THE HOT FUSES OUT BUT THE BATTERY IS STILL BEING DRAINED BY IT.
NHTSA ODI #11030810
111,000 miles · Sep 23, 2017
Electrical System
WHEN CAR IS PARKED AND HAS SECURITY ALARM SET THE HORN WILL HONK ON AND OFF ON ITS OWN AND DEALERSHIP BLAMES THE PCM BRAIN OF VEHICLE AND KNOW OF A FEW OTHERS WHO HAVE TAKEN IN THEIR OWN DODGE JOURNEYS FOR THE SAME ISSUES AND THEY SAY IS A RECALL IN EFFECT ON THIS.
NHTSA ODI #11025144
72,000 miles · Sep 12, 2017
Electrical System
I HAVE BEEN HAVING IGNITION SWITCH ISSUES WITH MY 2010 DODGE JOURNEY--CURIOUSLY SIMILAR TO THE ISSUES THAT SPURRED A RECALL (RO3) WITH THE SAME MODEL/YEAR JOURNEYS--BUT MY VIN DIDN'T SHOW UP IN THE AFFECTED LIST. I TOOK THE JOURNEY IN TO MY CHRYSLER DEALER TO REPAIR AN IGNITION SWITCH GETTING STUCK, AND THE ESTIMATE WAS AROUND $…
Read full complaint
I HAVE BEEN HAVING IGNITION SWITCH ISSUES WITH MY 2010 DODGE JOURNEY--CURIOUSLY SIMILAR TO THE ISSUES THAT SPURRED A RECALL (RO3) WITH THE SAME MODEL/YEAR JOURNEYS--BUT MY VIN DIDN'T SHOW UP IN THE AFFECTED LIST. I TOOK THE JOURNEY IN TO MY CHRYSLER DEALER TO REPAIR AN IGNITION SWITCH GETTING STUCK, AND THE ESTIMATE WAS AROUND $800 TO REPAIR THE SWITCH AND REPROGRAM THE KEYS! *TR
NHTSA ODI #11022894
12 miles · Sep 6, 2017
Electrical System
INTERMITTEN HORN ISSUES WHEN PARKED STATIONARY OR WHEN DRIVING
NHTSA ODI #11021744
NHTSA investigations
4EA24003 · Vehicle Entrapment
Opened Aug 1, 2024 · No close date supplied
Status: open (inferred from source dates) · Latches/locks/linkages
The Office of Defects Investigation (ODI) opened PE23-008 on May 1, 2023 to investigate an incident involving a 2009 Dodge Journey alleging occupant entrapment during a vehicle fire that resulted in a fatality. During the investigation, ODI collected information from the manufacturer and involved parties to confirm or refute the defect allegation. ODI has determined that additional reports of vehicle entrapment exist for other model year Dodge Journey vehicles. ODI continues to explore the cause of the thermal event and its potential effect on the actuation of the door locks. ODI also continues to explore other potential causes for door lock malfunction. ODI has determined that an upgrade to an Engineering Analysis (EA) is necessary to continue the review of the investigative material and to assess the risk to motor vehicle safety . To review the ODI report cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
PE19014 · Active Head Rest Inadvertent Deployment
Opened Sep 9, 2019 · Closed Feb 25, 2026
Status: closed (inferred from source dates) · Seats; Seats:front Assembly:head Restraint
The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Seats
The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Seats:front Assembly:head Restraint
The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
DP14004 · Totally Integrated Power Module Failure
Opened Sep 25, 2014 · Closed Jul 24, 2015
Status: closed (inferred from source dates) · Electrical System
In a letter dated August 21, 2014, the Center for Auto Safety (CAS) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged failures associated with the Totally Integrated Power Module (TIPM) installed in Chrysler SUV?s, trucks, and vans beginning in the 2007 model year. The petitioner alleges that TIPM defects may result in engine stall, airbag non-deployment, failure of fuel pump shutoff resulting in unintended acceleration, fire, and other symptoms. On September 25, 2014, the Office of Defects Investigation (ODI) opened DP14-004 to evaluate the petition for a grant or deny decision. ODI analyzed complaint data provided by CAS as well as complaints submitted to ODI from consumers. In total, there were 296 complaints submitted by the petitioner in the original petition and five supplements, including 271 complaints related to the subject vehicles equipped with TIPM-7. Approximately 3 percent of CAS complaints are related to vehicles equipped with TIPM-6 and ODI?s review of these complaints did not identify any safety defect trends. ODI conducted a detailed review of complaints narratives submitted by CAS and consumers including careful analysis of vehicle repair histories, warranty claims obtained from the manufacturer and any available Customer Assistance Inquiry reports (CAIR). Analysis of the field data indicated that MY2011-2013 Jeep Grand Cherokee and Dodge Durango vehicles exhibited significantly higher complaint rates related to fuel pump relay (FPR) failures than other subject vehicles. In a September 3, 2014 letter to NHTSA, Chrysler submitted a Defect Information Report (DIR) identifying a defect in the FPR within the TIPM-7 which can result in a no start or stall condition in approximately 188,723 model year (MY) 2011 Jeep Grand Cherokee (WK) and Dodge Durango (WD) vehicles manufactured from January 5, 2010 through July 20, 2011 (14V-530).In a February 24, 2015 letter, Chrysler submitted a second DIR expanding the scope of the FPR defect condition to include an additional 338,216 MY 2012 through 2013 Jeep Grand Cherokee vehicles manufactured from September 17, 2010 through August 19, 2013 and MY 2012 through 2013 Dodge Durango vehicles manufactured from January 18, 2011 through August 19, 2013 (15V-115).ODI analysis of the CAS allegations of TIPM defects resulting in stall while driving, airbag non-deployment, unintended acceleration, fire and other faults identified a single defect condition related to 1 of over 60 different circuits in the TIPM assembly. The most common effect of this defect condition, related to the fuel pump relay, was a no-start concern, but it could also result in stall while driving (76 complaints). No valid evidence was presented in support of claims related to airbag non-deployment, unintended acceleration or fire resulting from TIPM faults and these claims were found to be wholly without merit based on review of the field data and design of the relevant systems and components.Except insofar as the petitioner's contentions relate to the defect condition addressed by the Chrysler recalls, the factual bases of the petitioner's contentions that any further investigation is necessary are unsupported. In our view, additional investigation is unlikely to result in a finding that a defect related to motor vehicle safety exists or a NHTSA order for the notification and remedy of a safety-related defect as alleged by the petitioner at the conclusion of the requested investigation. Therefore, in view of the need to allocate and prioritize NHTSA's limited resources to best accomplish the agency's safety mission, the petition is den
RQ14002 · Air Bag Non-Deployment/Engine Stall
Opened Jun 16, 2014 · Closed Mar 2, 2015
Status: closed (inferred from source dates) · Air Bags; Electrical System:ignition:module
In March 2011 Chrysler submitted a defect information report for NHTSA Recall No. 11V139 declaring a defect condition that could cause the ignition key to inadvertently move from the RUN to the ACC position on model year (MY) 2010 Dodge Journey, Grand Caravan, and Chrysler Town and Country.The report identified engine stalling as the defect consequence and cited customer complaints and warranty claims, as well as two rear-end collisions, as leading to the recall action.Chrysler determined that a defective WIN module, which is effectively the equivalent of the ignition switch, was the cause of the inadvertent key rotation, and that a new design WIN module would be installed as a remedy.In Spring 2014 ODI conducted outreach to major light vehicle manufacturers regarding ignition key position and its effect on air bag system availability.The outreach was conducted in connection with NHTSA Recall No. 14V047, a recent recall involving inadvertent ignition key rotation and subsequent air bag disablement in certain GM products.During discussions held in April 2014, Chrysler advised ODI that Chrysler air bag systems of this vintage, including the subject vehicles, revert to energy reserve when the ignition key moves to the ACC or OFF position, and that under energy reserve the air bags would only be available for a short period, approximately two tenths of a second (ODI notes this consequence was not identified in the 11V139 recall report).A review of the ODI consumer database conducted after the April 2014 discussions identified complaints alleging that MY 2008-2009 vehicles may have a similar defect as the MY 2010 vehicles, and that some MY 2010 consumers reported experiencing ignition key position concerns after the 11V139 recall remedy was applied.Accordingly this investigation was opened.In response to ODI?s information request letter, Chrysler reported that MY 2008-2009 subject vehicles used the same design WIN module as the recalled vehicles, and also identified 66 consumer reports and one non-injury crash incident potentially related to inadvertent ignition key rotation.Chrysler?s review of the MY 2010 remedy used in 11V139, which involved installation of a Trim Ring as opposed to replacement of the WIN module, showed the remedy did not adequately address ignition key position concerns, and in some use-cases could cause other systems to operate improperly (radio, instrument panel lighting, HVAC fan motor, etc.).Chrysler subsequently filed multiple defect information reports to 1) add the MY 2008-2009 Dodge Grand Caravan and Chrysler Town and Country, and the MY 2009 Dodge Journey to the original recall scope, and 2) stating that the complete WIN module would be replaced with a new design component in all recalled vehicles (including those that had the Trim Ring installed during 11V139).Chrysler?s report also advises of constrained remedy parts availability, see NHTSA Recall No. 14V373 for further details.Accordingly, the investigation is closed based on the recall action Chrysler is undertaking.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10584873, 10583399, 10573295, 10566365, 10546805, 10513060, 10509284, 10503121, 10496599, 10475027, 10456099, 10450629, 10443680, 10422766, 10410447, 10409269, 10402947, 10402751, 10402660, 10396943, 10394957, 10356632, 10315972
Additional source detail variants (2)
Air Bags
In March 2011 Chrysler submitted a defect information report for NHTSA Recall No. 11V139 declaring a defect condition that could cause the ignition key to inadvertently move from the RUN to the ACC position on model year (MY) 2010 Dodge Journey, Grand Caravan, and Chrysler Town and Country.The report identified engine stalling as the defect consequence and cited customer complaints and warranty claims, as well as two rear-end collisions, as leading to the recall action.Chrysler determined that a defective WIN module, which is effectively the equivalent of the ignition switch, was the cause of the inadvertent key rotation, and that a new design WIN module would be installed as a remedy.In Spring 2014 ODI conducted outreach to major light vehicle manufacturers regarding ignition key position and its effect on air bag system availability.The outreach was conducted in connection with NHTSA Recall No. 14V047, a recent recall involving inadvertent ignition key rotation and subsequent air bag disablement in certain GM products.During discussions held in April 2014, Chrysler advised ODI that Chrysler air bag systems of this vintage, including the subject vehicles, revert to energy reserve when the ignition key moves to the ACC or OFF position, and that under energy reserve the air bags would only be available for a short period, approximately two tenths of a second (ODI notes this consequence was not identified in the 11V139 recall report).A review of the ODI consumer database conducted after the April 2014 discussions identified complaints alleging that MY 2008-2009 vehicles may have a similar defect as the MY 2010 vehicles, and that some MY 2010 consumers reported experiencing ignition key position concerns after the 11V139 recall remedy was applied.Accordingly this investigation was opened.In response to ODI?s information request letter, Chrysler reported that MY 2008-2009 subject vehicles used the same design WIN module as the recalled vehicles, and also identified 66 consumer reports and one non-injury crash incident potentially related to inadvertent ignition key rotation.Chrysler?s review of the MY 2010 remedy used in 11V139, which involved installation of a Trim Ring as opposed to replacement of the WIN module, showed the remedy did not adequately address ignition key position concerns, and in some use-cases could cause other systems to operate improperly (radio, instrument panel lighting, HVAC fan motor, etc.).Chrysler subsequently filed multiple defect information reports to 1) add the MY 2008-2009 Dodge Grand Caravan and Chrysler Town and Country, and the MY 2009 Dodge Journey to the original recall scope, and 2) stating that the complete WIN module would be replaced with a new design component in all recalled vehicles (including those that had the Trim Ring installed during 11V139).Chrysler?s report also advises of constrained remedy parts availability, see NHTSA Recall No. 14V373 for further details.Accordingly, the investigation is closed based on the recall action Chrysler is undertaking.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10584873, 10583399, 10573295, 10566365, 10546805, 10513060, 10509284, 10503121, 10496599, 10475027, 10456099, 10450629, 10443680, 10422766, 10410447, 10409269, 10402947, 10402751, 10402660, 10396943, 10394957, 10356632, 10315972
Electrical System:ignition:module
In March 2011 Chrysler submitted a defect information report for NHTSA Recall No. 11V139 declaring a defect condition that could cause the ignition key to inadvertently move from the RUN to the ACC position on model year (MY) 2010 Dodge Journey, Grand Caravan, and Chrysler Town and Country.The report identified engine stalling as the defect consequence and cited customer complaints and warranty claims, as well as two rear-end collisions, as leading to the recall action.Chrysler determined that a defective WIN module, which is effectively the equivalent of the ignition switch, was the cause of the inadvertent key rotation, and that a new design WIN module would be installed as a remedy.In Spring 2014 ODI conducted outreach to major light vehicle manufacturers regarding ignition key position and its effect on air bag system availability.The outreach was conducted in connection with NHTSA Recall No. 14V047, a recent recall involving inadvertent ignition key rotation and subsequent air bag disablement in certain GM products.During discussions held in April 2014, Chrysler advised ODI that Chrysler air bag systems of this vintage, including the subject vehicles, revert to energy reserve when the ignition key moves to the ACC or OFF position, and that under energy reserve the air bags would only be available for a short period, approximately two tenths of a second (ODI notes this consequence was not identified in the 11V139 recall report).A review of the ODI consumer database conducted after the April 2014 discussions identified complaints alleging that MY 2008-2009 vehicles may have a similar defect as the MY 2010 vehicles, and that some MY 2010 consumers reported experiencing ignition key position concerns after the 11V139 recall remedy was applied.Accordingly this investigation was opened.In response to ODI?s information request letter, Chrysler reported that MY 2008-2009 subject vehicles used the same design WIN module as the recalled vehicles, and also identified 66 consumer reports and one non-injury crash incident potentially related to inadvertent ignition key rotation.Chrysler?s review of the MY 2010 remedy used in 11V139, which involved installation of a Trim Ring as opposed to replacement of the WIN module, showed the remedy did not adequately address ignition key position concerns, and in some use-cases could cause other systems to operate improperly (radio, instrument panel lighting, HVAC fan motor, etc.).Chrysler subsequently filed multiple defect information reports to 1) add the MY 2008-2009 Dodge Grand Caravan and Chrysler Town and Country, and the MY 2009 Dodge Journey to the original recall scope, and 2) stating that the complete WIN module would be replaced with a new design component in all recalled vehicles (including those that had the Trim Ring installed during 11V139).Chrysler?s report also advises of constrained remedy parts availability, see NHTSA Recall No. 14V373 for further details.Accordingly, the investigation is closed based on the recall action Chrysler is undertaking.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10584873, 10583399, 10573295, 10566365, 10546805, 10513060, 10509284, 10503121, 10496599, 10475027, 10456099, 10450629, 10443680, 10422766, 10410447, 10409269, 10402947, 10402751, 10402660, 10396943, 10394957, 10356632, 10315972
Illustration