IllustrationBRAKES, ALLIGNMENT, DRIVE SHAFT WAS BENT...4TH SET OF TIRES PURCHASED IN FEB. 2013 GAS TANK & FUEL PUMP NEEDED REPLACED APRIL 2013 CALIPER LOCKED UP CAUSING FIRE, VEHICLE NEEDED TO BE TOWED MAY 2013. *TR
2009 Dodge Journey
Owner reports · Recalls · Investigations
More warning signs than most Journey years
Owner complaints for the 2009 Dodge Journey are substantially higher than the model-year median of 293.
About this comparison →How this year compares
Owner complaints by model year
Compare all Journey years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
2200–25K
17225–50K
17650–75K
17275–100K
182100–150K
71150K+
993 reports with mileage · 440 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 767 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 269 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 195 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
41 crash reports30 fire reports27 injury reports
Tires complaints
52 reports2009 DODGE JOURNEY AIR PRESSURE SENSOR FAILURE. ON 4-23-13. I WAS TRAVELING A LOCAL HIGHWAY ABOUT 65 MPH WHEN THE VALVE STEM AND PRESSURE SENSOR CAME LOOSE AND FELL INTO THE TIRE ON THE RIGHT REAR TIRE. I MANAGED TO GET THE CAR STOPPED SAFELY AFTER LOOSING CONTROL. AFTER READING A DODGE FORUM ON-LINE. THE GENERAL IDEA IS THAT TH…
Read full complaint
2009 DODGE JOURNEY AIR PRESSURE SENSOR FAILURE. ON 4-23-13. I WAS TRAVELING A LOCAL HIGHWAY ABOUT 65 MPH WHEN THE VALVE STEM AND PRESSURE SENSOR CAME LOOSE AND FELL INTO THE TIRE ON THE RIGHT REAR TIRE. I MANAGED TO GET THE CAR STOPPED SAFELY AFTER LOOSING CONTROL. AFTER READING A DODGE FORUM ON-LINE. THE GENERAL IDEA IS THAT THIS 2009 DODGE JOURNEY PRESSURE SENSOR IS POORLY DESIGNED. FROM WHAT I UNDERSTAND. DODGE CHANGED THE MATERIAL THE SENSOR IS MADE OF IN 2011. *TR
TRAVELING AT 60MPH ON WEST BOUND M-59 HIGHWAY, IN MICHIGAN, WHEN ALL AIR PRESSURE LOST OUT OF RT. REAR TIRE. MANAGED TO GET CAR STOPPED IN FRONT OF A BELLE TIRE STORE. HAD THEM TAKE CAR IN FOR REPAIRS AND THEY TOLD ME THAT IT WAS JUST ONE MORE FAILURE, DUE TO ROAD SALT, OF THE ALUMINUM VALVE STEM ON A CHRYSLER TPMS AIR PRESSURE …
Read full complaint
TRAVELING AT 60MPH ON WEST BOUND M-59 HIGHWAY, IN MICHIGAN, WHEN ALL AIR PRESSURE LOST OUT OF RT. REAR TIRE. MANAGED TO GET CAR STOPPED IN FRONT OF A BELLE TIRE STORE. HAD THEM TAKE CAR IN FOR REPAIRS AND THEY TOLD ME THAT IT WAS JUST ONE MORE FAILURE, DUE TO ROAD SALT, OF THE ALUMINUM VALVE STEM ON A CHRYSLER TPMS AIR PRESSURE SENDING UNIT. THEY ADVISED ME TO REPLACE UNIT ON ALL FOUR WHEELS BECAUSE THEY WOULD SOON BE FAILING. I REPLACED TWO OF THEM AT A COST OF $65 EACH BECAUSE THAT WAS ALL THAT I COULD AFFORD. THEY SAID THAT IT WAS A COMMON PROBLEM AND SHOWED ME A BUSHEL OF DEFECTIVE CHRYSLER (SIEMENS) UNITS. SINCE ONLY THE VALVE STEMS ARE BAD, AND EASY TO REPLACE, I LOOKED FOR REPLACEMENTS ON THE INTERNET BUT FOUND NONE. TOO BAD THAT THEY MAKE YOU BUY A $65 PART OVER THE FAILURE OF A $1 PART. BY-THE WAY, THERE ARE UNITS OFFERED WITH RUBBER VALVE STEMS THAT HOLD UP JUST LIKE THE OLD ONES. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
DURING REGULAR OIL CHANGE THE SERVICE MANAGER NOTIFIED ME THAT MY TIRE PRESSURE VALVE STEMS ON THREE WHEELS HAD CORRODED TO THE POINT OF BREAKING OFF. ONE TIRE LOST PRESSURE COMPLETELY, REQUIRING ME TO HAVE IT REPLACED IMMEDIATELY. IF THIS HAD OCCURRED ON THE ROAD IT COULD HAVE BEEN DISASTROUS. *TR
TL* THE CONTACT OWNS A 2009 DODGE JOURNEY. THE VEHICLE WAS EQUIPPED WITH KUMHO SOLUS KHH16 TIRES, TIRE SIZE 225/55/19. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 65 MPH, THE FRONT END OF THE VEHICLE BEGAN TO SHAKE CONTINUOUSLY. IN ADDITION, THERE WAS A VIBRATION IN THE STEERING WHEEL. THE VEHICLE WAS TAKEN TO AN AUTHORI…
Read full complaint
TL* THE CONTACT OWNS A 2009 DODGE JOURNEY. THE VEHICLE WAS EQUIPPED WITH KUMHO SOLUS KHH16 TIRES, TIRE SIZE 225/55/19. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 65 MPH, THE FRONT END OF THE VEHICLE BEGAN TO SHAKE CONTINUOUSLY. IN ADDITION, THERE WAS A VIBRATION IN THE STEERING WHEEL. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE BOTH FRONT TIRES WERE REPLACED WITH NEW TIRES. THE DEFECTIVE TIRES EXHIBITED SEVERE TREAD SEPARATION. THE MANUFACTURER WAS NOT NOTIFIED OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 26,800. UPDATED 12/14/12*LJ THE CONSUMER STATED AFTER HAVING THE TIRES BALANCED AND ROTATED, THE OWNER NOTICED THE STEERING WHEEL BEGAN TO SHAKE WHILE EXITING THE DEALERSHIP PARKING LOT. DEALER FOUND BOTH FRONT TIRES EXHIBITED BELT SEPERATION. UPDATED 12/17/2012 *JS
I SUSTAINED NONREPAIRABLE TO A TIRE ON MY VEHICLE DURING A HIGHWAY TRIP. WHEN I WENT TO A AUTHORIZED DEALER TO PURCHASE A NEW TIRE, I FOUND THAT THEY DO NOT STOCK A SINGLE TIRE OF THE TYPE AUTHORIZED BY THE VEHICLE MANUFACTURER PER WARRENTY SPECIFICATION. I HAD TO DRIVE ON THE FREEWAY AT NIGHT WITH A SKINNY EMERGENCY TIRE INST…
Read full complaint
I SUSTAINED NONREPAIRABLE TO A TIRE ON MY VEHICLE DURING A HIGHWAY TRIP. WHEN I WENT TO A AUTHORIZED DEALER TO PURCHASE A NEW TIRE, I FOUND THAT THEY DO NOT STOCK A SINGLE TIRE OF THE TYPE AUTHORIZED BY THE VEHICLE MANUFACTURER PER WARRENTY SPECIFICATION. I HAD TO DRIVE ON THE FREEWAY AT NIGHT WITH A SKINNY EMERGENCY TIRE INSTALLED FOR OVER 100 MILES. I FELT VERY UNSAFE AND NERVOUS BEING PLACED IN THIS SITUATION. *TR
ON THE FIRST INCIDENT, THE RIGHT DRIVER SIDE TIRE SUDDENLY WENT FLAT. VALVE ROTTED, THAT TIRE WAS FIXABLE. WE QUESTIONED THE COLD WEATHER. WE FIGURED IT WAS A FLUKE. ON JULY 15, 2012 REAR DRIVER SIDE TIRE SUDDENLY WENT FLAT WHILE DRIVING 55 MPH - WARM WEATHER - BROUGHT IT TO A TIRE COMPANY AND THEY STATED THE VALVE ROTTED ON …
Read full complaint
ON THE FIRST INCIDENT, THE RIGHT DRIVER SIDE TIRE SUDDENLY WENT FLAT. VALVE ROTTED, THAT TIRE WAS FIXABLE. WE QUESTIONED THE COLD WEATHER. WE FIGURED IT WAS A FLUKE. ON JULY 15, 2012 REAR DRIVER SIDE TIRE SUDDENLY WENT FLAT WHILE DRIVING 55 MPH - WARM WEATHER - BROUGHT IT TO A TIRE COMPANY AND THEY STATED THE VALVE ROTTED ON THIS TIRE AS WELL AND THAT THE TIRE WAS UNREPAIRABLE. BOTH TIMES OUR 3 AND 6 YEAR OLD CHILDREN WERE IN THE CAR WITH US- THIS IS A HUGE SAFETY ISSUE. I KNOW ANOTHER PERSON THAT RECENTLY OWNED A DODGE JOURNEY AND HAD A BLOW OUT - THEY ENDED UP ACROSS THE ROAD AND DOWN THE BANK. LUCKILY NO INJURIES. I DON'T THINK THIS IS A COINCIDENCE. THIS COULD RESULT IN BODILY INJURY. THE VALVES ON THESE CARS NEED TO BE ADDRESSED IMMEDIATELY. TODAY I AM SPENDING $1325 TO REPLACE ALL 4 TIRES AND RIMS SO THAT MYSELF AND MY CHILDREN DO NOT END UP IN A FATALITY. *TR
VALVE STEM SENSORS ON THE TWO REAR TIRES ARE CORRODED AND CRACKED. DRIVING DOWN ROAD METAL ON VALVE STEM FELL OFF CAUSING RAPID AIR LOSS IN TIRE. OTHER TIRE WITH CORRODED VALVE STEM BROKE AT CAR WASH. THIS IS A WELL KNOWN PROBABLY, I KNOW THIS BECAUSE I AM A DEPUTY SHERIFF AND THIS SAME PROBLEM HAPPENED TO OUR SQUAD CARS, WH…
Read full complaint
VALVE STEM SENSORS ON THE TWO REAR TIRES ARE CORRODED AND CRACKED. DRIVING DOWN ROAD METAL ON VALVE STEM FELL OFF CAUSING RAPID AIR LOSS IN TIRE. OTHER TIRE WITH CORRODED VALVE STEM BROKE AT CAR WASH. THIS IS A WELL KNOWN PROBABLY, I KNOW THIS BECAUSE I AM A DEPUTY SHERIFF AND THIS SAME PROBLEM HAPPENED TO OUR SQUAD CARS, WHICH OUR DODGE CHARGERS. AFTER TWO DEPUTIES HAD BLOWOUTS AT HIGH RATE OF SPEED SHERIFF ORDERED ALL SENSORS CHANGED. IF YOU GOOGLE ONLINE THIS PROBLEM IS COMING AND PEOPLE ARE GOING TO DIE IN AN ACCIDENT FROM THIS. THIS HAS TO BE RECALLED BY CHRYSLER. CHRYSLER KNOWS THIS PROBLEM EXISTS BECAUSE THEY CHANGED THE SENSORS IN 2011. *TR
ON APRIL 28, 2009 I HAVE A TIRE FAILURE WHILE DRIVING AN A WELL MAINTAINED PAVED HIGHWAY. SPECIFICALLY, I HAD A SIDEWALL FAILURE ON MY RIGHT REAR TIRE. UPON EXAMINATION OF THE TIRE I FOUND A "V" SHAPED FAILURE IN THE SIDEWALL OF ABOUT ONE HALF INCH. CLOSER EXAMINATION REVEALED THAT THE CHORDS IN THE TIRE WERE FRAYED AS OPPOS…
Read full complaint
ON APRIL 28, 2009 I HAVE A TIRE FAILURE WHILE DRIVING AN A WELL MAINTAINED PAVED HIGHWAY. SPECIFICALLY, I HAD A SIDEWALL FAILURE ON MY RIGHT REAR TIRE. UPON EXAMINATION OF THE TIRE I FOUND A "V" SHAPED FAILURE IN THE SIDEWALL OF ABOUT ONE HALF INCH. CLOSER EXAMINATION REVEALED THAT THE CHORDS IN THE TIRE WERE FRAYED AS OPPOSED TO BEING CUT CLEANLY. DURING THE FIRST WEEK OF APRIL 2011, I EXPERIENCED ANOTHER SIDEWALL FAILURE WITH THE SAME "V" SHAPED BREAK WHILE TRAVELING ON A WELL MAINTAINED PAVED HIGHWAY. I DECIDED AT THAT TIME TO REPLACE ALL FOUR TIRES WITH OME TIRES AND I KEPT THE REMAINING THREE GOOD TIRES. IN FEBRUARY, 2012, I EXPERIENCED A THIRD SIDEWALL FAILURE WITH THE SAME "V" SHAPED RUPTURE IN THE SIDEWALL OF THE LEFT FRONT TIRE. MY MILEAGE AT THIS TIME WAS APPROXIMATELY 40500. THE REPLACEMENT TIRE THAT WAS INSTALLED WAS FROM THE ORIGINAL OME TIRES THAT I HAD KEPT WHEN I REPLACED AFTER THE SECOND FAILURE. APPROXIMATELY 3 MONTHS LATER THAT REPLACEMENT TIRE DEVELOPED A BULGE ON THE OUTSIDE TREAD AREA OF APPROXIMATELY 12" LONG BY 2" WIDE. I THEN REPLACED ALL FOURS AGAIN WITH ANOTHER BRAND. THE OME TIRES ORIGINALLY ON MY VEHICLE AND THE FIRST SET OF REPLACEMENT TIRES WERE: KUMHO 225/55R BW KH16 99T. *TR
BRAKES CONTINUE TO GO BAD. VEHICLE CALLS FOR NUMEROUS BRAKE CHANGES INCLUDING THE ROTORS AS WELL. DODGE NOTIFIED AND NOTHING HAS BEEN RESOLVED. ALSO THEIR VALVE STEMS ARE BREAKING IN HALF IN COLD WEATHER. CAUSING TIRES AIR TO DEPLETE WITHIN 8 SECONDS. I HAVE THE VALVE STEM FROM MY CAR THAT BROKE AND THE OTHER WAS REPLACED EARLIE…
Read full complaint
BRAKES CONTINUE TO GO BAD. VEHICLE CALLS FOR NUMEROUS BRAKE CHANGES INCLUDING THE ROTORS AS WELL. DODGE NOTIFIED AND NOTHING HAS BEEN RESOLVED. ALSO THEIR VALVE STEMS ARE BREAKING IN HALF IN COLD WEATHER. CAUSING TIRES AIR TO DEPLETE WITHIN 8 SECONDS. I HAVE THE VALVE STEM FROM MY CAR THAT BROKE AND THE OTHER WAS REPLACED EARLIER UNDER WARRANTY. IF THIS VALVE STEM WAS TO BREAK IN HALF WHILE AT HIGH SPEEDS ON THE HIGHWAY, SOMEONE COULD BE KILLED. *TR
Official recalls
816V273000 · Steering:hydraulic Power Assist:hose, Piping, And Connections
May 6, 2016
Chrysler (FCA US LLC) is recalling certain model year 2009-2016 Dodge Journey vehicles manufactured July 31, 2007, to November 12, 2016. After exposure to cold temperatures, the power steering return hose may rupture at engine start-up causing a loss of power steering assist.
Consequence & remedy
Consequence: A loss of power steering assist may require extra steering effort, especially at lower speeds, increasing the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the power steering return hoses, steel tubes, and power steering oil cooler, free of charge. The recall began on May 24, 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S08.
16V047000 · Air Bags:frontal
Jan 29, 2016
FCA US LLC (Chrysler) is recalling certain model year 2009 Dodge Journey vehicles manufactured December 31, 2007, to August 31, 2008, 2008-2009 Dodge Grand Caravan and Chrysler Town and Country vehicles manufactured June 18, 2007, to August 31, 2008. In the affected vehicles, the air bag control units may corrode and fail.
Consequence & remedy
Consequence: If the air bag control unit fails, the air bags may not deploy in the event of a crash, increasing the risk of occupant injury. Additionally, the air bags may inadvertently deploy, increasing the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the air bag control unit, free of charge. The recall began on December 6, 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S07.
14V373000 · Air Bags; Electrical System:ignition:switch
Jun 26, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. Chrysler Group LLC (Chrysler) is recalling certain model year 2009-2010 Dodge Journey vehicles manufactured June 29, 2007, to June 17, 2010, and 2008-2010 Dodge Grand Caravan and Chrysler Town and Country vehicles manufactured January 26, 2007, to June 17, 2010. Road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the ignition key inadvertently moves into the OFF or ACCESSORY position, the engine will turn off, which will then depower various key safety systems including but not limited to air bags, power steering, and power braking. Loss of functionality of these systems may increase the risk of crash and/or increase the risk of injury in the event of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the ignition switch and key FOBs, free of charge. The recall began on May 26, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R03. Note: This is an expansion of recall 11V-139.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. Chrysler Group LLC (Chrysler) is recalling certain model year 2009-2010 Dodge Journey vehicles manufactured June 29, 2007, to June 17, 2010, and 2008-2010 Dodge Grand Caravan and Chrysler Town and Country vehicles manufactured January 26, 2007, to June 17, 2010. Road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence: If the ignition key inadvertently moves into the OFF or ACCESSORY position, the engine will turn off, which will then depower various key safety systems including but not limited to air bags, power steering, and power braking. Loss of functionality of these systems may increase the risk of crash and/or increase the risk of injury in the event of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the ignition switch and key FOBs, free of charge. The recall began on May 26, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R03. Note: This is an expansion of recall 11V-139.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. Chrysler Group LLC (Chrysler) is recalling certain model year 2009-2010 Dodge Journey vehicles manufactured June 29, 2007, to June 17, 2010, and 2008-2010 Dodge Grand Caravan and Chrysler Town and Country vehicles manufactured January 26, 2007, to June 17, 2010. Road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence: If the ignition key inadvertently moves into the OFF or ACCESSORY position, the engine will turn off, which will then depower various key safety systems including but not limited to air bags, power steering, and power braking. Loss of functionality of these systems may increase the risk of crash and/or increase the risk of injury in the event of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the ignition switch and key FOBs, free of charge. The recall began on May 26, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R03. Note: This is an expansion of recall 11V-139.
10V658000 · Electrical System:wiring
Dec 24, 2010
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2009 DODGE JOURNEY VEHICLES MANUFACTURER FROM NOVEMBER 1, 2007, THROUGH NOVEMBER 7, 2008. THE WIRES WITHIN THE FRONT DOOR WIRE HARNESSES MAY FATIGUE AND BREAK, WHICH CAN INTERRUPT THE CIRCUITS FOR THE SIDE IMPACT SENSOR(S), RESULTING IN AN AIRBAG WARNING LAMP ILLUMINATION AND LOSS OF SIDE CRASH SENSING CAPABILITY.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE SIDE AIRBAG MAY NOT DEPLOY, REDUCING THE PROTECTION INTENDED FOR THE OCCUPANT AND INCREASING THE RISK OF INJURIES.
Remedy: CHRYSLER WILL NOTIFY OWNERS AND REPLACE THE LEFT AND RIGHT DOOR WIRING HARNESSES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 18, 2011. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
09V118000 · Air Bags; Air Bags:frontal; Electrical System:wiring
Apr 9, 2009
CHRYSLER IS RECALLING 4,314 MY 2009 DODGE JOURNEY, JEEP GRAND CHEROKEE, COMMANDER AND WRANGLER VEHICLES. WIRING MAY BE REVERSED ON THE STEERING COLUMN CONTROL MODULE DRIVER AIRBAG SQUIB CONNECTOR. THE DRIVER'S AIRBAG MAY NOT DEPLOY AS INTENDED.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE DRIVER'S AIRBAG MAY NOT PROPERLY INFLATE AND MAY NOT BE ABLE TO PROPERLY PROTECT AN OCCUPANT, INCREASING THE RISK OF INJURIES.
Remedy: DEALERS WILL INSPECT THE DRIVER'S AIRBAG SQUIB WIRES AND REPLACE THE STEERING COLUMN CONTROL MODULE FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2009. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Additional source detail variants (3)
Air Bags:frontal
CHRYSLER IS RECALLING 4,314 MY 2009 DODGE JOURNEY, JEEP GRAND CHEROKEE, COMMANDER AND WRANGLER VEHICLES. WIRING MAY BE REVERSED ON THE STEERING COLUMN CONTROL MODULE DRIVER AIRBAG SQUIB CONNECTOR. THE DRIVER'S AIRBAG MAY NOT DEPLOY AS INTENDED.
Consequence: IN THE EVENT OF A CRASH, THE DRIVER'S AIRBAG MAY NOT PROPERLY INFLATE AND MAY NOT BE ABLE TO PROPERLY PROTECT AN OCCUPANT, INCREASING THE RISK OF INJURIES.
Remedy: DEALERS WILL INSPECT THE DRIVER'S AIRBAG SQUIB WIRES AND REPLACE THE STEERING COLUMN CONTROL MODULE FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2009. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Air Bags
CHRYSLER IS RECALLING 4,314 MY 2009 DODGE JOURNEY, JEEP GRAND CHEROKEE, COMMANDER AND WRANGLER VEHICLES. WIRING MAY BE REVERSED ON THE STEERING COLUMN CONTROL MODULE DRIVER AIRBAG SQUIB CONNECTOR. THE DRIVER'S AIRBAG MAY NOT DEPLOY AS INTENDED.
Consequence: IN THE EVENT OF A CRASH, THE DRIVER'S AIRBAG MAY NOT PROPERLY INFLATE AND MAY NOT BE ABLE TO PROPERLY PROTECT AN OCCUPANT, INCREASING THE RISK OF INJURIES.
Remedy: DEALERS WILL INSPECT THE DRIVER'S AIRBAG SQUIB WIRES AND REPLACE THE STEERING COLUMN CONTROL MODULE FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2009. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Electrical System:wiring
CHRYSLER IS RECALLING 4,314 MY 2009 DODGE JOURNEY, JEEP GRAND CHEROKEE, COMMANDER AND WRANGLER VEHICLES. WIRING MAY BE REVERSED ON THE STEERING COLUMN CONTROL MODULE DRIVER AIRBAG SQUIB CONNECTOR. THE DRIVER'S AIRBAG MAY NOT DEPLOY AS INTENDED.
Consequence: IN THE EVENT OF A CRASH, THE DRIVER'S AIRBAG MAY NOT PROPERLY INFLATE AND MAY NOT BE ABLE TO PROPERLY PROTECT AN OCCUPANT, INCREASING THE RISK OF INJURIES.
Remedy: DEALERS WILL INSPECT THE DRIVER'S AIRBAG SQUIB WIRES AND REPLACE THE STEERING COLUMN CONTROL MODULE FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2009. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
09V082000 · Electrical System
Mar 12, 2009
CHRYSLER IS RECALLING 16,852 MY 2009 DODGE JOURNEY VEHICLES EQUIPPED WITHOUT OPTIONAL 115 VOLT AUXILIARY POWER OUTLET. AN UNUSED ELECTRICAL CONNECTOR FOR THE OPTIONAL 115 VOLT AUXILIARY POWER OUTLET OPTION MAY BECOME CORRODED AND COULD SHORT CIRCUIT.
Consequence & remedy
Consequence: IF THE FUSE FOR THIS CIRCUIT DOES NOT BLOW, THE CONNECTOR COULD OVERHEAT AND POTENTIALLY CATCH FIRE.
Remedy: DEALERS WILL RE-ROUTE AND STOW THE 115 VOLT AUXILIARY POWER OUTLET CONNECTOR AND PULL THE 25 AMP FUSE TO REMOVE POWER FROM THIS UNUSED CIRCUIT FREE OF CHARGE. THE RECALL BEGAN ON MARCH 30, 2009. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
08V528000 · Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
Oct 9, 2008
CHRYSLER IS RECALLING 712 MY 2009 SEBRING, DODGE CALIBER, AVENGER, JOURNEY, JEEP PATRIOT, AND COMPASS VEHICLES. A NEW ADHESIVE USED IN THE POWER TRAIN CONTROL MODULE (PCM) MANUFACTURING PROCESS CAN CAUSE THE PRINTED CIRCUIT BOARD TO BREAK.
Consequence & remedy
Consequence: THIS CAN CAUSE THE ENGINE TO STALL AND CAUSE A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL REPLACE THE PCM FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 10, 2008. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
08V247000 · Electrical System:wiring
Jun 3, 2008
CHRYSLER IS RECALLING 6,692 MY 2009 DODGE JOURNEY VEHICLES EQUIPPED WITH A 3.5L ENGINE. THE ENGINE WIRING HARNESS MAY CONTACT THE LEFT TRANSAXLE MOUNT.
Consequence & remedy
Consequence: DAMAGE TO THE WIRING HARNESS COULD RESULT IN AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL INSPECT THE ENGINE WIRING HARNESS FOR DAMAGE. IF THE HARNESS IS DAMAGED, THE WIRING WILL BE REPAIRED AND A TIE WRAP INSTALLED TO SECURE THE HARNESS AWAY FROM THE LEFT TRANSAXLE MOUNT. IF NO DAMAGE IS FOUND, A TIE WRAP WILL BE INSTALLED TO SECURE THE HARNESS AWAY FROM THE LEFT TRANSAXLE MOUNT. THE RECALL BEGAN ON JULY 7, 2008. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4EA24003 · Vehicle Entrapment
Opened Aug 1, 2024 · No close date supplied
Status: open (inferred from source dates) · Latches/locks/linkages
The Office of Defects Investigation (ODI) opened PE23-008 on May 1, 2023 to investigate an incident involving a 2009 Dodge Journey alleging occupant entrapment during a vehicle fire that resulted in a fatality. During the investigation, ODI collected information from the manufacturer and involved parties to confirm or refute the defect allegation. ODI has determined that additional reports of vehicle entrapment exist for other model year Dodge Journey vehicles. ODI continues to explore the cause of the thermal event and its potential effect on the actuation of the door locks. ODI also continues to explore other potential causes for door lock malfunction. ODI has determined that an upgrade to an Engineering Analysis (EA) is necessary to continue the review of the investigative material and to assess the risk to motor vehicle safety . To review the ODI report cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
PE23008 · Vehicle Entrapment
Opened May 1, 2023 · Closed Aug 15, 2024
Status: closed (inferred from source dates) · Latches/locks/linkages:doors:latch; Latches/locks/linkages:doors:lock; Latches/locks/linkages:electronic Lock/latch Actuator
The Office of Defects Investigation (ODI) opened PE23008 on May 1, 2023 to investigate an incident involving a 2009 Dodge Journey alleging occupant entrapment during a vehicle fire that resulted in a fatality. During this investigation, ODI collected information and evidence related to the defect allegation and incident, from the manufacturer and involved parties. The information and evidence collected in this initial phase was insufficient to make a defect determination. ODI has upgraded this investigation to an Engineering Analysis (EA24003) to develop a more comprehensive understanding of whether a potential safety defect exists. To review the ODI report cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (3)
Latches/locks/linkages:doors:latch
The Office of Defects Investigation (ODI) opened PE23008 on May 1, 2023 to investigate an incident involving a 2009 Dodge Journey alleging occupant entrapment during a vehicle fire that resulted in a fatality. During this investigation, ODI collected information and evidence related to the defect allegation and incident, from the manufacturer and involved parties. The information and evidence collected in this initial phase was insufficient to make a defect determination. ODI has upgraded this investigation to an Engineering Analysis (EA24003) to develop a more comprehensive understanding of whether a potential safety defect exists. To review the ODI report cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Latches/locks/linkages:doors:lock
The Office of Defects Investigation (ODI) opened PE23008 on May 1, 2023 to investigate an incident involving a 2009 Dodge Journey alleging occupant entrapment during a vehicle fire that resulted in a fatality. During this investigation, ODI collected information and evidence related to the defect allegation and incident, from the manufacturer and involved parties. The information and evidence collected in this initial phase was insufficient to make a defect determination. ODI has upgraded this investigation to an Engineering Analysis (EA24003) to develop a more comprehensive understanding of whether a potential safety defect exists. To review the ODI report cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Latches/locks/linkages:electronic Lock/latch Actuator
The Office of Defects Investigation (ODI) opened PE23008 on May 1, 2023 to investigate an incident involving a 2009 Dodge Journey alleging occupant entrapment during a vehicle fire that resulted in a fatality. During this investigation, ODI collected information and evidence related to the defect allegation and incident, from the manufacturer and involved parties. The information and evidence collected in this initial phase was insufficient to make a defect determination. ODI has upgraded this investigation to an Engineering Analysis (EA24003) to develop a more comprehensive understanding of whether a potential safety defect exists. To review the ODI report cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
DP14004 · Totally Integrated Power Module Failure
Opened Sep 25, 2014 · Closed Jul 24, 2015
Status: closed (inferred from source dates) · Electrical System
In a letter dated August 21, 2014, the Center for Auto Safety (CAS) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged failures associated with the Totally Integrated Power Module (TIPM) installed in Chrysler SUV?s, trucks, and vans beginning in the 2007 model year. The petitioner alleges that TIPM defects may result in engine stall, airbag non-deployment, failure of fuel pump shutoff resulting in unintended acceleration, fire, and other symptoms. On September 25, 2014, the Office of Defects Investigation (ODI) opened DP14-004 to evaluate the petition for a grant or deny decision. ODI analyzed complaint data provided by CAS as well as complaints submitted to ODI from consumers. In total, there were 296 complaints submitted by the petitioner in the original petition and five supplements, including 271 complaints related to the subject vehicles equipped with TIPM-7. Approximately 3 percent of CAS complaints are related to vehicles equipped with TIPM-6 and ODI?s review of these complaints did not identify any safety defect trends. ODI conducted a detailed review of complaints narratives submitted by CAS and consumers including careful analysis of vehicle repair histories, warranty claims obtained from the manufacturer and any available Customer Assistance Inquiry reports (CAIR). Analysis of the field data indicated that MY2011-2013 Jeep Grand Cherokee and Dodge Durango vehicles exhibited significantly higher complaint rates related to fuel pump relay (FPR) failures than other subject vehicles. In a September 3, 2014 letter to NHTSA, Chrysler submitted a Defect Information Report (DIR) identifying a defect in the FPR within the TIPM-7 which can result in a no start or stall condition in approximately 188,723 model year (MY) 2011 Jeep Grand Cherokee (WK) and Dodge Durango (WD) vehicles manufactured from January 5, 2010 through July 20, 2011 (14V-530).In a February 24, 2015 letter, Chrysler submitted a second DIR expanding the scope of the FPR defect condition to include an additional 338,216 MY 2012 through 2013 Jeep Grand Cherokee vehicles manufactured from September 17, 2010 through August 19, 2013 and MY 2012 through 2013 Dodge Durango vehicles manufactured from January 18, 2011 through August 19, 2013 (15V-115).ODI analysis of the CAS allegations of TIPM defects resulting in stall while driving, airbag non-deployment, unintended acceleration, fire and other faults identified a single defect condition related to 1 of over 60 different circuits in the TIPM assembly. The most common effect of this defect condition, related to the fuel pump relay, was a no-start concern, but it could also result in stall while driving (76 complaints). No valid evidence was presented in support of claims related to airbag non-deployment, unintended acceleration or fire resulting from TIPM faults and these claims were found to be wholly without merit based on review of the field data and design of the relevant systems and components.Except insofar as the petitioner's contentions relate to the defect condition addressed by the Chrysler recalls, the factual bases of the petitioner's contentions that any further investigation is necessary are unsupported. In our view, additional investigation is unlikely to result in a finding that a defect related to motor vehicle safety exists or a NHTSA order for the notification and remedy of a safety-related defect as alleged by the petitioner at the conclusion of the requested investigation. Therefore, in view of the need to allocate and prioritize NHTSA's limited resources to best accomplish the agency's safety mission, the petition is den
RQ14002 · Air Bag Non-Deployment/Engine Stall
Opened Jun 16, 2014 · Closed Mar 2, 2015
Status: closed (inferred from source dates) · Air Bags; Electrical System:ignition:module
In March 2011 Chrysler submitted a defect information report for NHTSA Recall No. 11V139 declaring a defect condition that could cause the ignition key to inadvertently move from the RUN to the ACC position on model year (MY) 2010 Dodge Journey, Grand Caravan, and Chrysler Town and Country.The report identified engine stalling as the defect consequence and cited customer complaints and warranty claims, as well as two rear-end collisions, as leading to the recall action.Chrysler determined that a defective WIN module, which is effectively the equivalent of the ignition switch, was the cause of the inadvertent key rotation, and that a new design WIN module would be installed as a remedy.In Spring 2014 ODI conducted outreach to major light vehicle manufacturers regarding ignition key position and its effect on air bag system availability.The outreach was conducted in connection with NHTSA Recall No. 14V047, a recent recall involving inadvertent ignition key rotation and subsequent air bag disablement in certain GM products.During discussions held in April 2014, Chrysler advised ODI that Chrysler air bag systems of this vintage, including the subject vehicles, revert to energy reserve when the ignition key moves to the ACC or OFF position, and that under energy reserve the air bags would only be available for a short period, approximately two tenths of a second (ODI notes this consequence was not identified in the 11V139 recall report).A review of the ODI consumer database conducted after the April 2014 discussions identified complaints alleging that MY 2008-2009 vehicles may have a similar defect as the MY 2010 vehicles, and that some MY 2010 consumers reported experiencing ignition key position concerns after the 11V139 recall remedy was applied.Accordingly this investigation was opened.In response to ODI?s information request letter, Chrysler reported that MY 2008-2009 subject vehicles used the same design WIN module as the recalled vehicles, and also identified 66 consumer reports and one non-injury crash incident potentially related to inadvertent ignition key rotation.Chrysler?s review of the MY 2010 remedy used in 11V139, which involved installation of a Trim Ring as opposed to replacement of the WIN module, showed the remedy did not adequately address ignition key position concerns, and in some use-cases could cause other systems to operate improperly (radio, instrument panel lighting, HVAC fan motor, etc.).Chrysler subsequently filed multiple defect information reports to 1) add the MY 2008-2009 Dodge Grand Caravan and Chrysler Town and Country, and the MY 2009 Dodge Journey to the original recall scope, and 2) stating that the complete WIN module would be replaced with a new design component in all recalled vehicles (including those that had the Trim Ring installed during 11V139).Chrysler?s report also advises of constrained remedy parts availability, see NHTSA Recall No. 14V373 for further details.Accordingly, the investigation is closed based on the recall action Chrysler is undertaking.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10584873, 10583399, 10573295, 10566365, 10546805, 10513060, 10509284, 10503121, 10496599, 10475027, 10456099, 10450629, 10443680, 10422766, 10410447, 10409269, 10402947, 10402751, 10402660, 10396943, 10394957, 10356632, 10315972
Additional source detail variants (2)
Air Bags
In March 2011 Chrysler submitted a defect information report for NHTSA Recall No. 11V139 declaring a defect condition that could cause the ignition key to inadvertently move from the RUN to the ACC position on model year (MY) 2010 Dodge Journey, Grand Caravan, and Chrysler Town and Country.The report identified engine stalling as the defect consequence and cited customer complaints and warranty claims, as well as two rear-end collisions, as leading to the recall action.Chrysler determined that a defective WIN module, which is effectively the equivalent of the ignition switch, was the cause of the inadvertent key rotation, and that a new design WIN module would be installed as a remedy.In Spring 2014 ODI conducted outreach to major light vehicle manufacturers regarding ignition key position and its effect on air bag system availability.The outreach was conducted in connection with NHTSA Recall No. 14V047, a recent recall involving inadvertent ignition key rotation and subsequent air bag disablement in certain GM products.During discussions held in April 2014, Chrysler advised ODI that Chrysler air bag systems of this vintage, including the subject vehicles, revert to energy reserve when the ignition key moves to the ACC or OFF position, and that under energy reserve the air bags would only be available for a short period, approximately two tenths of a second (ODI notes this consequence was not identified in the 11V139 recall report).A review of the ODI consumer database conducted after the April 2014 discussions identified complaints alleging that MY 2008-2009 vehicles may have a similar defect as the MY 2010 vehicles, and that some MY 2010 consumers reported experiencing ignition key position concerns after the 11V139 recall remedy was applied.Accordingly this investigation was opened.In response to ODI?s information request letter, Chrysler reported that MY 2008-2009 subject vehicles used the same design WIN module as the recalled vehicles, and also identified 66 consumer reports and one non-injury crash incident potentially related to inadvertent ignition key rotation.Chrysler?s review of the MY 2010 remedy used in 11V139, which involved installation of a Trim Ring as opposed to replacement of the WIN module, showed the remedy did not adequately address ignition key position concerns, and in some use-cases could cause other systems to operate improperly (radio, instrument panel lighting, HVAC fan motor, etc.).Chrysler subsequently filed multiple defect information reports to 1) add the MY 2008-2009 Dodge Grand Caravan and Chrysler Town and Country, and the MY 2009 Dodge Journey to the original recall scope, and 2) stating that the complete WIN module would be replaced with a new design component in all recalled vehicles (including those that had the Trim Ring installed during 11V139).Chrysler?s report also advises of constrained remedy parts availability, see NHTSA Recall No. 14V373 for further details.Accordingly, the investigation is closed based on the recall action Chrysler is undertaking.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10584873, 10583399, 10573295, 10566365, 10546805, 10513060, 10509284, 10503121, 10496599, 10475027, 10456099, 10450629, 10443680, 10422766, 10410447, 10409269, 10402947, 10402751, 10402660, 10396943, 10394957, 10356632, 10315972
Electrical System:ignition:module
In March 2011 Chrysler submitted a defect information report for NHTSA Recall No. 11V139 declaring a defect condition that could cause the ignition key to inadvertently move from the RUN to the ACC position on model year (MY) 2010 Dodge Journey, Grand Caravan, and Chrysler Town and Country.The report identified engine stalling as the defect consequence and cited customer complaints and warranty claims, as well as two rear-end collisions, as leading to the recall action.Chrysler determined that a defective WIN module, which is effectively the equivalent of the ignition switch, was the cause of the inadvertent key rotation, and that a new design WIN module would be installed as a remedy.In Spring 2014 ODI conducted outreach to major light vehicle manufacturers regarding ignition key position and its effect on air bag system availability.The outreach was conducted in connection with NHTSA Recall No. 14V047, a recent recall involving inadvertent ignition key rotation and subsequent air bag disablement in certain GM products.During discussions held in April 2014, Chrysler advised ODI that Chrysler air bag systems of this vintage, including the subject vehicles, revert to energy reserve when the ignition key moves to the ACC or OFF position, and that under energy reserve the air bags would only be available for a short period, approximately two tenths of a second (ODI notes this consequence was not identified in the 11V139 recall report).A review of the ODI consumer database conducted after the April 2014 discussions identified complaints alleging that MY 2008-2009 vehicles may have a similar defect as the MY 2010 vehicles, and that some MY 2010 consumers reported experiencing ignition key position concerns after the 11V139 recall remedy was applied.Accordingly this investigation was opened.In response to ODI?s information request letter, Chrysler reported that MY 2008-2009 subject vehicles used the same design WIN module as the recalled vehicles, and also identified 66 consumer reports and one non-injury crash incident potentially related to inadvertent ignition key rotation.Chrysler?s review of the MY 2010 remedy used in 11V139, which involved installation of a Trim Ring as opposed to replacement of the WIN module, showed the remedy did not adequately address ignition key position concerns, and in some use-cases could cause other systems to operate improperly (radio, instrument panel lighting, HVAC fan motor, etc.).Chrysler subsequently filed multiple defect information reports to 1) add the MY 2008-2009 Dodge Grand Caravan and Chrysler Town and Country, and the MY 2009 Dodge Journey to the original recall scope, and 2) stating that the complete WIN module would be replaced with a new design component in all recalled vehicles (including those that had the Trim Ring installed during 11V139).Chrysler?s report also advises of constrained remedy parts availability, see NHTSA Recall No. 14V373 for further details.Accordingly, the investigation is closed based on the recall action Chrysler is undertaking.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10584873, 10583399, 10573295, 10566365, 10546805, 10513060, 10509284, 10503121, 10496599, 10475027, 10456099, 10450629, 10443680, 10422766, 10410447, 10409269, 10402947, 10402751, 10402660, 10396943, 10394957, 10356632, 10315972