NHTSA owner reports · September 18, 2026 snapshot.
Service Brakes complaints
106 reportsClear category filter58,000 miles · Mar 3, 2013
Service Brakes
VEHICLE FAILED STATE INSPECTION THIRD YEAR IN A ROW ALL FOR SAME REASON AND IT GETS WORSE. IN FEB 2011 WHICH IS FIRST YEAR I OWNED THE VEHICLE AND GOT THE INSPECTION MYSELF, IT FAILED FOR REAR BRAKE ROTORS AND THEY WERE NOT ABLE TO BE RESURFACED. IN FEB 2012 THE VEHICLE AGAIN FAILED FOR REAR ROTORS AND AGAIN THEY WERE TO BAD O B…
Read full complaint
VEHICLE FAILED STATE INSPECTION THIRD YEAR IN A ROW ALL FOR SAME REASON AND IT GETS WORSE. IN FEB 2011 WHICH IS FIRST YEAR I OWNED THE VEHICLE AND GOT THE INSPECTION MYSELF, IT FAILED FOR REAR BRAKE ROTORS AND THEY WERE NOT ABLE TO BE RESURFACED. IN FEB 2012 THE VEHICLE AGAIN FAILED FOR REAR ROTORS AND AGAIN THEY WERE TO BAD O BE RESURFACED. IN FEB 2013 I CHECKED MY BRAKES BEFORE GOING IN CAUSE I HAD HEARD NOISES AND SCREECHING FROM THEM FOR ABOUT A COUPLE MONTHS LEADING UP TO INSPECTION TIME. REAR ROTORS WERE INDEED BAD AGAIN. THE RIGHT REAR ROTOR WORE A 7 MM GROOVE INTO IT AND THE PAD HAD A MIRRORING GROOVE WHERE IT HAD NOT WORN. NEXT BOTH REAR CALIPERS I FOUND WERE SEIZED (I DO KNOW THESE ARE SCREW TYPE CALIPERS INSTEAD OF COMPRESSION CALIPERS). 3 YEARS IN A ROW I HAVE CHANGED REAR ROTORS AND PADS. FRONT BRAKES ARE FINE AND HAVE HAD NORMAL WEAR. I HAVE ONLY CHANGED FRONT PADS ONCE AND HAD THE ROTORS RESURFACED ONCE. CALIPERS ARE FINE. *TR
NHTSA ODI #10501086
31,000 miles · Feb 15, 2013
Electrical SystemEngine And Engine CoolingParking Brake
I PURCHASED THIS CAR IN AUGUST 2010 (IT IS A 2009) AND SINCE THEN, I HAVE HAD THE VEHICLE IN THE SHOP 33 TIMES. I HAVE HAD TO REPLACE ALL BRAKES AND ROTORS, HAD FRONT PASSENGER-SIDE WINDOW MOTOR REPLACED, DRIVER-SIDE IS GOING OUT NOW, HAD LEAKING FROM THE CEILING, REPLACING THE CRACKED RADIATOR RIGHT NOW, HAD THE EMERGENCY BRAK…
Read full complaint
I PURCHASED THIS CAR IN AUGUST 2010 (IT IS A 2009) AND SINCE THEN, I HAVE HAD THE VEHICLE IN THE SHOP 33 TIMES. I HAVE HAD TO REPLACE ALL BRAKES AND ROTORS, HAD FRONT PASSENGER-SIDE WINDOW MOTOR REPLACED, DRIVER-SIDE IS GOING OUT NOW, HAD LEAKING FROM THE CEILING, REPLACING THE CRACKED RADIATOR RIGHT NOW, HAD THE EMERGENCY BRAKE FIXED, NEEDED NEW RODS AND BUSHINGS, FUEL INJECTORS RUN LOUD, THERE IS A DRONE NOISE FROM THE RIGHT SIDE OF THE VEHICLE WHEN GOING 1800-2000 RPM, ELECTRICAL SYSTEMS SHORT OUT, HAD THE ELECTRIC THROTTLE INDICATOR LIGHT COME ON, CAR DIES ALL THE TIME, YET THE BATTERY IS FINE, ...BOTTOM LINE, THIS IS A LEMON. I HAVE THE R/T MODEL WHICH THE DEALERSHIP LIKES TO CLAIM "IS JUST THE NOISY ONE." THAT IS A VERY POOR ANSWER TOWARDS A CONSUMER. I TAKE VERY GOOD CARE OF MY VEHICLES AND TO PUT UP WITH THIS IS UPSETTING. I HAVE SPENT OVER $3000 IN REPAIRS IN THE 2 1/2 YEARS THAT I HAVE OWNED THIS SUV. CHRYSLER HAS MADE NO ATTEMPTS TO HELP WITH THESE COMMON PROBLEMS AND I KNOW THAT I WILL NOT SUPPORT THIS COMPANY BUY PURCHASING WITH THEM AGAIN. WHEN I BOUGHT A JOURNEY...I DIDN'T REALIZE BEING ABLE TO DRIVE IT WITHOUT PROBLEMS, WOULD BE SUCH A "JOURNEY." *TR
NHTSA ODI #10498278
53,000 miles · Dec 20, 2012
Electrical SystemEngine And Engine CoolingService Brakes
ELECTRICAL SYSTEM FAILURE DUE TO WIRING HARNESS MELTING, RADIATOR CRACKED BECAUSE BRACKET FOR AC IS CONNECTED TOO TIGHT WHEN CAR IS MANUFACTURED, BATTERY DIED PREMATURELY BECAUSE OF FAILED WIRES, ROTORS WARPED CAUSING CAR TO SHAKE VIOLENTLY WHEN BRAKING. ALL THESE PROBLEMS AND OTHERS FOR A CAR WITH ONLY 60,000 MILES. HAVE SPENT …
Read full complaint
ELECTRICAL SYSTEM FAILURE DUE TO WIRING HARNESS MELTING, RADIATOR CRACKED BECAUSE BRACKET FOR AC IS CONNECTED TOO TIGHT WHEN CAR IS MANUFACTURED, BATTERY DIED PREMATURELY BECAUSE OF FAILED WIRES, ROTORS WARPED CAUSING CAR TO SHAKE VIOLENTLY WHEN BRAKING. ALL THESE PROBLEMS AND OTHERS FOR A CAR WITH ONLY 60,000 MILES. HAVE SPENT OVER $2000 TO DATE IN REPAIRS THAT NUMEROUS PEOPLE HAVE HAD RELATED TO THIS VEHICLE. BASED ON ONLINE COMPLAINTS AND TALKING TO MECHANICS WHO HAVE WORKED ON THIS CAR NO ONE CAN BELIEVE THAT THE CORRECT ELECTRICAL RECALL HAS TAKEN PLACE. THERE HAVE BEEN ELECTRICAL RECALLS ON VEHICLE, BUT NOT FOR MOST COMMON FAILURE. NO ONE UNDERSTANDS WHY BRAKE ISSUE HAS NOT BEEN RECALLED AND NO ONE UNDERSTANDS WHY THE RADIATORS KEEP FAILING WITHOUT A RECALL. WILL IT TAKE A SERIOUS CRASH? SAFETY OF THE CONSUMER IS AT RISK. YOU PAY $20,000 FOR A CAR AND THINK IT WILL LAST AWHILE. THIS CAR HAS MAJOR PROBLEMS THAT ARE CONSISTENT FROM BUYER TO BUYER. *TR
NHTSA ODI #10489331
10,900 miles · Dec 4, 2012
Power TrainService BrakesStructure
TL* THE CONTACT OWNS A 2009 DODGE JOURNEY. THE CONTACT STATED THAT WHILE DRIVING 45 MPH, THE BRAKES WERE APPLIED BUT THE VEHICLE WOULD NOT RESPOND. THE CONTACT MERGED ONTO THE SHOULDER IN ORDER TO STOP THE VEHICLE. THE VEHICLE WAS TOWED TO THE DEALER FOR INSPECTION WHERE THEY ADVISED THAT THE ROTORS NEEDED TO BE REPLACED. THE …
Read full complaint
TL* THE CONTACT OWNS A 2009 DODGE JOURNEY. THE CONTACT STATED THAT WHILE DRIVING 45 MPH, THE BRAKES WERE APPLIED BUT THE VEHICLE WOULD NOT RESPOND. THE CONTACT MERGED ONTO THE SHOULDER IN ORDER TO STOP THE VEHICLE. THE VEHICLE WAS TOWED TO THE DEALER FOR INSPECTION WHERE THEY ADVISED THAT THE ROTORS NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. THE CONTACT ALSO STATED THAT THE ROOF WAS LEAKING ABNORMALLY. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION WHERE THE CONTACT WAS ADVISED THAT THE SEAMS IN THE ROOF NEEDED REPLACING. THE DEALER MADE THE NECESSARY REPAIRS TO THE ROOF HOWEVER, THE FAILURE RECURRED. IN ADDITION, THE CONTACT MENTIONED THAT THE VEHICLE FAILED TO START AFTER BEING PARKED FOR A SHORT PERIOD OF TIME. THE DEALER WAS NOTIFIED AND ADVISED THAT SHE SHOULD SHAKE THE GEAR SHIFTER AND THEN TRY TO START THE VEHICLE. THE CONTACT FOLLOWED THE DEALER'S INSTRUCTIONS AND THE VEHICLE STARTED. THE CAUSE OF THE STARTING FAILURE WAS UNKNOWN. THE MANUFACTURER WAS NOTIFIED BUT DID NOT OFFER ANY ASSISTANCE. THE FAILURE MILEAGE WAS 10,900.
NHTSA ODI #10487304
59,600 miles · Dec 1, 2012
Service BrakesWheels
WHEELS, BRAKES, AND ROTORS DETERIORATE PREMATURELY AND/OR SHORTLY AFTER THE WARRANTY EXPIRES RESULTING IN AN EXCESSIVE COST TO THE CONSUMER AND THE POTENTIAL FOR A COMPLETE BRAKE AND TIRE FAILURE. *TR
NHTSA ODI #10486672
30,000 miles · Oct 27, 2012
Electrical SystemEngineService Brakes
WHEN I BOUGHT MY CAR IN 2009. I NOTICED THAT MY BRAKES SQUEAKED WHEN I STOP I TOOK IT BACK TO THE DEALERSHIP, I WAS TOLD THAT NOTHING WAS WRONG. KEEP COMPLAINING ALL THE TIME, THEN THE VIBRATION STARTED AND I NEEDED ROTORS AND BRAKES. THE AFTERMARKET BRAKES DOESN'T FIT HAD TO REPLACE THEM WITH THE DEALERSHIP BRAKES. HAD TO REP…
Read full complaint
WHEN I BOUGHT MY CAR IN 2009. I NOTICED THAT MY BRAKES SQUEAKED WHEN I STOP I TOOK IT BACK TO THE DEALERSHIP, I WAS TOLD THAT NOTHING WAS WRONG. KEEP COMPLAINING ALL THE TIME, THEN THE VIBRATION STARTED AND I NEEDED ROTORS AND BRAKES. THE AFTERMARKET BRAKES DOESN'T FIT HAD TO REPLACE THEM WITH THE DEALERSHIP BRAKES. HAD TO REPLACE A TWO TIRE SENSORS. HAD TO HAVE MY ROTORS RESURFACED WILL NEED NEW ROTORS. RECENTLY THE ENGINE COOLANT OVERHEATING LIGHT CAME ON. THE FAN STOP WORKING ITS ELECTRICAL THE MECHANIC CAN'T FIGURE OUT WHY IT STOP. MY CAR SOMETIMES DOESN'T START, TOOK IT TO A MECHANIC. NO REASON WHY. WHEN MY AIR IS ON IT TAKES THE CAR LONGER TO GAIN SPEED ON THE HIGHWAY. I CONTACTED THE DEALERSHIP WHERE I PURCHASED IT AND DODGE. BOTH WERE RUDE AND DIDN'T OFFER ANY HELP. I PURCHASED THE EXTENDED WARRANTY AND IT DIDN'T COVER ANYTHING. *TR
NHTSA ODI #10482422
84,000 miles · Oct 25, 2012
Service Brakes
I BROUGHT CAR USED FEB 2012 WITH AROUND 78500. SHORTLY AFTER I GOT THE CAR I STARTED NOTICING THE VIBRATION WHEN I APPLIED THE BRAKES. SO I TOOK IT AND HAD THE BRAKE PADS AND ROTORS REPLACED ON THE FRONT. WELL IT STILL WAS VIBRATING WHEN I WOULD APPLY THE BRAKES. SO I WAS TOLD THAT MAYBE THE CALIPERS WAS BAD. SO A COUPLE WEEKS L…
Read full complaint
I BROUGHT CAR USED FEB 2012 WITH AROUND 78500. SHORTLY AFTER I GOT THE CAR I STARTED NOTICING THE VIBRATION WHEN I APPLIED THE BRAKES. SO I TOOK IT AND HAD THE BRAKE PADS AND ROTORS REPLACED ON THE FRONT. WELL IT STILL WAS VIBRATING WHEN I WOULD APPLY THE BRAKES. SO I WAS TOLD THAT MAYBE THE CALIPERS WAS BAD. SO A COUPLE WEEKS LATER THEY PUT ON NEW PADS, ROTORS AND CALIPERS. WELL THE VIBRATION STOPPED. WELL AT LEAST FOR ABOUT 3 MONTHS AND THE VIBRATION WHEN I APPLY MY BRAKES CAME BACK. SO I TOOK IT BACK AND WAS TOLD THAT THEY ARE GOING TO PUT SOME DEALER PADS AND ROTORS ON AND THAT SHOULD TAKE CARE OF THE PROBLEM. SO IM WAITING TO GET THOSE PUT ON AND SEE IF IT WILL MAKE A DIFFERENCE LIKE THEY SAY. *TR
NHTSA ODI #10482214
15,000 miles · Sep 20, 2012
Service Brakes
BRAKES AND ROTORS HAVE BEEN REPLACED ON THIS CAR AT LEAST 3 TIMES ALREADY. ALONG WITH NUMEROUS OTHER PROBLEMS THAT JOURNEY OWNERS HAVE COMPLAINED ABOUT INCLUDING: STEERING SOUNDS WHEN TURNING, POWER WINDOWS HESITATING TO WORK, CAR NOT STARTING, BATTERY REPLACED TOO SOON. COSMETIC PROBLEMS SUCH AS VISOR MIRROR COVER BROKEN, SEATS…
Read full complaint
BRAKES AND ROTORS HAVE BEEN REPLACED ON THIS CAR AT LEAST 3 TIMES ALREADY. ALONG WITH NUMEROUS OTHER PROBLEMS THAT JOURNEY OWNERS HAVE COMPLAINED ABOUT INCLUDING: STEERING SOUNDS WHEN TURNING, POWER WINDOWS HESITATING TO WORK, CAR NOT STARTING, BATTERY REPLACED TOO SOON. COSMETIC PROBLEMS SUCH AS VISOR MIRROR COVER BROKEN, SEATS STAINING, AND SEALS AROUND DOORS AND TIRE WELLS FALL OFF. THIS CAR HAS SO MANY COMPLAINTS ONLINE I DON'T KNOW WHY WE CAN'T GET SOMETHING IN RETURN FOR ALL THESE PROBLEMS. *TR
NHTSA ODI #10476551
15,000 miles · Sep 13, 2012
Service Brakes
THIS JOURNEY HAS HAD PREMATURE WEARING ON THE BRAKES AND ROTORS. WE HAVE HAD THE CAR 3 YEARS NOW AND HAVE HAD BRAKES DONE AT LEAST 6 TIMES AND IT ONLY HAS 47,000. THIS IS A HUGE SAFETY CONCERN. ALSO IN ORDER TO CHANGE YOUR BATTER YOU HAVE TO TAKE IT TO THE DEALERSHIP, SO IF YOU BREAK DOWN YOU HAVE NO CHOICE BUT TO HAVE IT TOWED …
Read full complaint
THIS JOURNEY HAS HAD PREMATURE WEARING ON THE BRAKES AND ROTORS. WE HAVE HAD THE CAR 3 YEARS NOW AND HAVE HAD BRAKES DONE AT LEAST 6 TIMES AND IT ONLY HAS 47,000. THIS IS A HUGE SAFETY CONCERN. ALSO IN ORDER TO CHANGE YOUR BATTER YOU HAVE TO TAKE IT TO THE DEALERSHIP, SO IF YOU BREAK DOWN YOU HAVE NO CHOICE BUT TO HAVE IT TOWED AND TAKEN TO THE DEALERSHIP WHICH IS HUNDREDS OF DOLLARS. ALSO MY HUSBAND IS HANDICAP, AND THIS POSES A BIG PROBLEM FOR HIM OR ANYONE ELSE. THIS CAR WAS MADE POORLY. WE CANNOT AFFORD BRAKES EVERY 6 MONTHS AND EVEN AFTER YOU GET THE BRAKES DONE IT IS CONSTANT PROBLEMS. WE TRY TO USE OUR OTHER CAR WE WIN DRIVING WITH OUR KIDS FOR FEAR THE BRAKES WILL GO OUT OR SOMETHING. *TR
NHTSA ODI #10475370
38,000 miles · Aug 29, 2012
Service Brakes
NOTICED BRAKES WERE WEARING RECEIVED LETTER FROM DODGE EXTENDING WARRANTY BUT WE WERE SLIGHTLY OVER ON MILES. WE REPLACED FRONT PADS AND ROTOR. NOW A YEAR LATER THEY NEED REPLACED AGAIN. AT 55000 MILES. *TR
NHTSA ODI #10472974
Official recalls
8May 6, 2016
Chrysler (FCA US LLC) is recalling certain model year 2009-2016 Dodge Journey vehicles manufactured July 31, 2007, to November 12, 2016. After exposure to cold temperatures, the power steering return hose may rupture at engine start-up causing a loss of power steering assist.
Consequence & remedy
Consequence: A loss of power steering assist may require extra steering effort, especially at lower speeds, increasing the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the power steering return hoses, steel tubes, and power steering oil cooler, free of charge. The recall began on May 24, 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S08.
Jan 29, 2016
FCA US LLC (Chrysler) is recalling certain model year 2009 Dodge Journey vehicles manufactured December 31, 2007, to August 31, 2008, 2008-2009 Dodge Grand Caravan and Chrysler Town and Country vehicles manufactured June 18, 2007, to August 31, 2008. In the affected vehicles, the air bag control units may corrode and fail.
Consequence & remedy
Consequence: If the air bag control unit fails, the air bags may not deploy in the event of a crash, increasing the risk of occupant injury. Additionally, the air bags may inadvertently deploy, increasing the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the air bag control unit, free of charge. The recall began on December 6, 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S07.
Jun 26, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. Chrysler Group LLC (Chrysler) is recalling certain model year 2009-2010 Dodge Journey vehicles manufactured June 29, 2007, to June 17, 2010, and 2008-2010 Dodge Grand Caravan and Chrysler Town and Country vehicles manufactured January 26, 2007, to June 17, 2010. Road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the ignition key inadvertently moves into the OFF or ACCESSORY position, the engine will turn off, which will then depower various key safety systems including but not limited to air bags, power steering, and power braking. Loss of functionality of these systems may increase the risk of crash and/or increase the risk of injury in the event of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the ignition switch and key FOBs, free of charge. The recall began on May 26, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R03. Note: This is an expansion of recall 11V-139.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. Chrysler Group LLC (Chrysler) is recalling certain model year 2009-2010 Dodge Journey vehicles manufactured June 29, 2007, to June 17, 2010, and 2008-2010 Dodge Grand Caravan and Chrysler Town and Country vehicles manufactured January 26, 2007, to June 17, 2010. Road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence: If the ignition key inadvertently moves into the OFF or ACCESSORY position, the engine will turn off, which will then depower various key safety systems including but not limited to air bags, power steering, and power braking. Loss of functionality of these systems may increase the risk of crash and/or increase the risk of injury in the event of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the ignition switch and key FOBs, free of charge. The recall began on May 26, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R03. Note: This is an expansion of recall 11V-139.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. Chrysler Group LLC (Chrysler) is recalling certain model year 2009-2010 Dodge Journey vehicles manufactured June 29, 2007, to June 17, 2010, and 2008-2010 Dodge Grand Caravan and Chrysler Town and Country vehicles manufactured January 26, 2007, to June 17, 2010. Road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence: If the ignition key inadvertently moves into the OFF or ACCESSORY position, the engine will turn off, which will then depower various key safety systems including but not limited to air bags, power steering, and power braking. Loss of functionality of these systems may increase the risk of crash and/or increase the risk of injury in the event of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the ignition switch and key FOBs, free of charge. The recall began on May 26, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R03. Note: This is an expansion of recall 11V-139.
Dec 24, 2010
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2009 DODGE JOURNEY VEHICLES MANUFACTURER FROM NOVEMBER 1, 2007, THROUGH NOVEMBER 7, 2008. THE WIRES WITHIN THE FRONT DOOR WIRE HARNESSES MAY FATIGUE AND BREAK, WHICH CAN INTERRUPT THE CIRCUITS FOR THE SIDE IMPACT SENSOR(S), RESULTING IN AN AIRBAG WARNING LAMP ILLUMINATION AND LOSS OF SIDE CRASH SENSING CAPABILITY.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE SIDE AIRBAG MAY NOT DEPLOY, REDUCING THE PROTECTION INTENDED FOR THE OCCUPANT AND INCREASING THE RISK OF INJURIES.
Remedy: CHRYSLER WILL NOTIFY OWNERS AND REPLACE THE LEFT AND RIGHT DOOR WIRING HARNESSES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 18, 2011. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Apr 9, 2009
CHRYSLER IS RECALLING 4,314 MY 2009 DODGE JOURNEY, JEEP GRAND CHEROKEE, COMMANDER AND WRANGLER VEHICLES. WIRING MAY BE REVERSED ON THE STEERING COLUMN CONTROL MODULE DRIVER AIRBAG SQUIB CONNECTOR. THE DRIVER'S AIRBAG MAY NOT DEPLOY AS INTENDED.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE DRIVER'S AIRBAG MAY NOT PROPERLY INFLATE AND MAY NOT BE ABLE TO PROPERLY PROTECT AN OCCUPANT, INCREASING THE RISK OF INJURIES.
Remedy: DEALERS WILL INSPECT THE DRIVER'S AIRBAG SQUIB WIRES AND REPLACE THE STEERING COLUMN CONTROL MODULE FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2009. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Additional source detail variants (3)
Air Bags:frontal
CHRYSLER IS RECALLING 4,314 MY 2009 DODGE JOURNEY, JEEP GRAND CHEROKEE, COMMANDER AND WRANGLER VEHICLES. WIRING MAY BE REVERSED ON THE STEERING COLUMN CONTROL MODULE DRIVER AIRBAG SQUIB CONNECTOR. THE DRIVER'S AIRBAG MAY NOT DEPLOY AS INTENDED.
Consequence: IN THE EVENT OF A CRASH, THE DRIVER'S AIRBAG MAY NOT PROPERLY INFLATE AND MAY NOT BE ABLE TO PROPERLY PROTECT AN OCCUPANT, INCREASING THE RISK OF INJURIES.
Remedy: DEALERS WILL INSPECT THE DRIVER'S AIRBAG SQUIB WIRES AND REPLACE THE STEERING COLUMN CONTROL MODULE FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2009. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Air Bags
CHRYSLER IS RECALLING 4,314 MY 2009 DODGE JOURNEY, JEEP GRAND CHEROKEE, COMMANDER AND WRANGLER VEHICLES. WIRING MAY BE REVERSED ON THE STEERING COLUMN CONTROL MODULE DRIVER AIRBAG SQUIB CONNECTOR. THE DRIVER'S AIRBAG MAY NOT DEPLOY AS INTENDED.
Consequence: IN THE EVENT OF A CRASH, THE DRIVER'S AIRBAG MAY NOT PROPERLY INFLATE AND MAY NOT BE ABLE TO PROPERLY PROTECT AN OCCUPANT, INCREASING THE RISK OF INJURIES.
Remedy: DEALERS WILL INSPECT THE DRIVER'S AIRBAG SQUIB WIRES AND REPLACE THE STEERING COLUMN CONTROL MODULE FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2009. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Electrical System:wiring
CHRYSLER IS RECALLING 4,314 MY 2009 DODGE JOURNEY, JEEP GRAND CHEROKEE, COMMANDER AND WRANGLER VEHICLES. WIRING MAY BE REVERSED ON THE STEERING COLUMN CONTROL MODULE DRIVER AIRBAG SQUIB CONNECTOR. THE DRIVER'S AIRBAG MAY NOT DEPLOY AS INTENDED.
Consequence: IN THE EVENT OF A CRASH, THE DRIVER'S AIRBAG MAY NOT PROPERLY INFLATE AND MAY NOT BE ABLE TO PROPERLY PROTECT AN OCCUPANT, INCREASING THE RISK OF INJURIES.
Remedy: DEALERS WILL INSPECT THE DRIVER'S AIRBAG SQUIB WIRES AND REPLACE THE STEERING COLUMN CONTROL MODULE FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2009. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Mar 12, 2009
CHRYSLER IS RECALLING 16,852 MY 2009 DODGE JOURNEY VEHICLES EQUIPPED WITHOUT OPTIONAL 115 VOLT AUXILIARY POWER OUTLET. AN UNUSED ELECTRICAL CONNECTOR FOR THE OPTIONAL 115 VOLT AUXILIARY POWER OUTLET OPTION MAY BECOME CORRODED AND COULD SHORT CIRCUIT.
Consequence & remedy
Consequence: IF THE FUSE FOR THIS CIRCUIT DOES NOT BLOW, THE CONNECTOR COULD OVERHEAT AND POTENTIALLY CATCH FIRE.
Remedy: DEALERS WILL RE-ROUTE AND STOW THE 115 VOLT AUXILIARY POWER OUTLET CONNECTOR AND PULL THE 25 AMP FUSE TO REMOVE POWER FROM THIS UNUSED CIRCUIT FREE OF CHARGE. THE RECALL BEGAN ON MARCH 30, 2009. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Oct 9, 2008
CHRYSLER IS RECALLING 712 MY 2009 SEBRING, DODGE CALIBER, AVENGER, JOURNEY, JEEP PATRIOT, AND COMPASS VEHICLES. A NEW ADHESIVE USED IN THE POWER TRAIN CONTROL MODULE (PCM) MANUFACTURING PROCESS CAN CAUSE THE PRINTED CIRCUIT BOARD TO BREAK.
Consequence & remedy
Consequence: THIS CAN CAUSE THE ENGINE TO STALL AND CAUSE A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL REPLACE THE PCM FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 10, 2008. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Jun 3, 2008
CHRYSLER IS RECALLING 6,692 MY 2009 DODGE JOURNEY VEHICLES EQUIPPED WITH A 3.5L ENGINE. THE ENGINE WIRING HARNESS MAY CONTACT THE LEFT TRANSAXLE MOUNT.
Consequence & remedy
Consequence: DAMAGE TO THE WIRING HARNESS COULD RESULT IN AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL INSPECT THE ENGINE WIRING HARNESS FOR DAMAGE. IF THE HARNESS IS DAMAGED, THE WIRING WILL BE REPAIRED AND A TIE WRAP INSTALLED TO SECURE THE HARNESS AWAY FROM THE LEFT TRANSAXLE MOUNT. IF NO DAMAGE IS FOUND, A TIE WRAP WILL BE INSTALLED TO SECURE THE HARNESS AWAY FROM THE LEFT TRANSAXLE MOUNT. THE RECALL BEGAN ON JULY 7, 2008. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4EA24003 · Vehicle Entrapment
Opened Aug 1, 2024 · No close date supplied
Status: open (inferred from source dates) · Latches/locks/linkages
The Office of Defects Investigation (ODI) opened PE23-008 on May 1, 2023 to investigate an incident involving a 2009 Dodge Journey alleging occupant entrapment during a vehicle fire that resulted in a fatality. During the investigation, ODI collected information from the manufacturer and involved parties to confirm or refute the defect allegation. ODI has determined that additional reports of vehicle entrapment exist for other model year Dodge Journey vehicles. ODI continues to explore the cause of the thermal event and its potential effect on the actuation of the door locks. ODI also continues to explore other potential causes for door lock malfunction. ODI has determined that an upgrade to an Engineering Analysis (EA) is necessary to continue the review of the investigative material and to assess the risk to motor vehicle safety . To review the ODI report cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
PE23008 · Vehicle Entrapment
Opened May 1, 2023 · Closed Aug 15, 2024
Status: closed (inferred from source dates) · Latches/locks/linkages:doors:latch; Latches/locks/linkages:doors:lock; Latches/locks/linkages:electronic Lock/latch Actuator
The Office of Defects Investigation (ODI) opened PE23008 on May 1, 2023 to investigate an incident involving a 2009 Dodge Journey alleging occupant entrapment during a vehicle fire that resulted in a fatality. During this investigation, ODI collected information and evidence related to the defect allegation and incident, from the manufacturer and involved parties. The information and evidence collected in this initial phase was insufficient to make a defect determination. ODI has upgraded this investigation to an Engineering Analysis (EA24003) to develop a more comprehensive understanding of whether a potential safety defect exists. To review the ODI report cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (3)
Latches/locks/linkages:doors:latch
The Office of Defects Investigation (ODI) opened PE23008 on May 1, 2023 to investigate an incident involving a 2009 Dodge Journey alleging occupant entrapment during a vehicle fire that resulted in a fatality. During this investigation, ODI collected information and evidence related to the defect allegation and incident, from the manufacturer and involved parties. The information and evidence collected in this initial phase was insufficient to make a defect determination. ODI has upgraded this investigation to an Engineering Analysis (EA24003) to develop a more comprehensive understanding of whether a potential safety defect exists. To review the ODI report cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Latches/locks/linkages:doors:lock
The Office of Defects Investigation (ODI) opened PE23008 on May 1, 2023 to investigate an incident involving a 2009 Dodge Journey alleging occupant entrapment during a vehicle fire that resulted in a fatality. During this investigation, ODI collected information and evidence related to the defect allegation and incident, from the manufacturer and involved parties. The information and evidence collected in this initial phase was insufficient to make a defect determination. ODI has upgraded this investigation to an Engineering Analysis (EA24003) to develop a more comprehensive understanding of whether a potential safety defect exists. To review the ODI report cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Latches/locks/linkages:electronic Lock/latch Actuator
The Office of Defects Investigation (ODI) opened PE23008 on May 1, 2023 to investigate an incident involving a 2009 Dodge Journey alleging occupant entrapment during a vehicle fire that resulted in a fatality. During this investigation, ODI collected information and evidence related to the defect allegation and incident, from the manufacturer and involved parties. The information and evidence collected in this initial phase was insufficient to make a defect determination. ODI has upgraded this investigation to an Engineering Analysis (EA24003) to develop a more comprehensive understanding of whether a potential safety defect exists. To review the ODI report cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
DP14004 · Totally Integrated Power Module Failure
Opened Sep 25, 2014 · Closed Jul 24, 2015
Status: closed (inferred from source dates) · Electrical System
In a letter dated August 21, 2014, the Center for Auto Safety (CAS) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged failures associated with the Totally Integrated Power Module (TIPM) installed in Chrysler SUV?s, trucks, and vans beginning in the 2007 model year. The petitioner alleges that TIPM defects may result in engine stall, airbag non-deployment, failure of fuel pump shutoff resulting in unintended acceleration, fire, and other symptoms. On September 25, 2014, the Office of Defects Investigation (ODI) opened DP14-004 to evaluate the petition for a grant or deny decision. ODI analyzed complaint data provided by CAS as well as complaints submitted to ODI from consumers. In total, there were 296 complaints submitted by the petitioner in the original petition and five supplements, including 271 complaints related to the subject vehicles equipped with TIPM-7. Approximately 3 percent of CAS complaints are related to vehicles equipped with TIPM-6 and ODI?s review of these complaints did not identify any safety defect trends. ODI conducted a detailed review of complaints narratives submitted by CAS and consumers including careful analysis of vehicle repair histories, warranty claims obtained from the manufacturer and any available Customer Assistance Inquiry reports (CAIR). Analysis of the field data indicated that MY2011-2013 Jeep Grand Cherokee and Dodge Durango vehicles exhibited significantly higher complaint rates related to fuel pump relay (FPR) failures than other subject vehicles. In a September 3, 2014 letter to NHTSA, Chrysler submitted a Defect Information Report (DIR) identifying a defect in the FPR within the TIPM-7 which can result in a no start or stall condition in approximately 188,723 model year (MY) 2011 Jeep Grand Cherokee (WK) and Dodge Durango (WD) vehicles manufactured from January 5, 2010 through July 20, 2011 (14V-530).In a February 24, 2015 letter, Chrysler submitted a second DIR expanding the scope of the FPR defect condition to include an additional 338,216 MY 2012 through 2013 Jeep Grand Cherokee vehicles manufactured from September 17, 2010 through August 19, 2013 and MY 2012 through 2013 Dodge Durango vehicles manufactured from January 18, 2011 through August 19, 2013 (15V-115).ODI analysis of the CAS allegations of TIPM defects resulting in stall while driving, airbag non-deployment, unintended acceleration, fire and other faults identified a single defect condition related to 1 of over 60 different circuits in the TIPM assembly. The most common effect of this defect condition, related to the fuel pump relay, was a no-start concern, but it could also result in stall while driving (76 complaints). No valid evidence was presented in support of claims related to airbag non-deployment, unintended acceleration or fire resulting from TIPM faults and these claims were found to be wholly without merit based on review of the field data and design of the relevant systems and components.Except insofar as the petitioner's contentions relate to the defect condition addressed by the Chrysler recalls, the factual bases of the petitioner's contentions that any further investigation is necessary are unsupported. In our view, additional investigation is unlikely to result in a finding that a defect related to motor vehicle safety exists or a NHTSA order for the notification and remedy of a safety-related defect as alleged by the petitioner at the conclusion of the requested investigation. Therefore, in view of the need to allocate and prioritize NHTSA's limited resources to best accomplish the agency's safety mission, the petition is den
RQ14002 · Air Bag Non-Deployment/Engine Stall
Opened Jun 16, 2014 · Closed Mar 2, 2015
Status: closed (inferred from source dates) · Air Bags; Electrical System:ignition:module
In March 2011 Chrysler submitted a defect information report for NHTSA Recall No. 11V139 declaring a defect condition that could cause the ignition key to inadvertently move from the RUN to the ACC position on model year (MY) 2010 Dodge Journey, Grand Caravan, and Chrysler Town and Country.The report identified engine stalling as the defect consequence and cited customer complaints and warranty claims, as well as two rear-end collisions, as leading to the recall action.Chrysler determined that a defective WIN module, which is effectively the equivalent of the ignition switch, was the cause of the inadvertent key rotation, and that a new design WIN module would be installed as a remedy.In Spring 2014 ODI conducted outreach to major light vehicle manufacturers regarding ignition key position and its effect on air bag system availability.The outreach was conducted in connection with NHTSA Recall No. 14V047, a recent recall involving inadvertent ignition key rotation and subsequent air bag disablement in certain GM products.During discussions held in April 2014, Chrysler advised ODI that Chrysler air bag systems of this vintage, including the subject vehicles, revert to energy reserve when the ignition key moves to the ACC or OFF position, and that under energy reserve the air bags would only be available for a short period, approximately two tenths of a second (ODI notes this consequence was not identified in the 11V139 recall report).A review of the ODI consumer database conducted after the April 2014 discussions identified complaints alleging that MY 2008-2009 vehicles may have a similar defect as the MY 2010 vehicles, and that some MY 2010 consumers reported experiencing ignition key position concerns after the 11V139 recall remedy was applied.Accordingly this investigation was opened.In response to ODI?s information request letter, Chrysler reported that MY 2008-2009 subject vehicles used the same design WIN module as the recalled vehicles, and also identified 66 consumer reports and one non-injury crash incident potentially related to inadvertent ignition key rotation.Chrysler?s review of the MY 2010 remedy used in 11V139, which involved installation of a Trim Ring as opposed to replacement of the WIN module, showed the remedy did not adequately address ignition key position concerns, and in some use-cases could cause other systems to operate improperly (radio, instrument panel lighting, HVAC fan motor, etc.).Chrysler subsequently filed multiple defect information reports to 1) add the MY 2008-2009 Dodge Grand Caravan and Chrysler Town and Country, and the MY 2009 Dodge Journey to the original recall scope, and 2) stating that the complete WIN module would be replaced with a new design component in all recalled vehicles (including those that had the Trim Ring installed during 11V139).Chrysler?s report also advises of constrained remedy parts availability, see NHTSA Recall No. 14V373 for further details.Accordingly, the investigation is closed based on the recall action Chrysler is undertaking.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10584873, 10583399, 10573295, 10566365, 10546805, 10513060, 10509284, 10503121, 10496599, 10475027, 10456099, 10450629, 10443680, 10422766, 10410447, 10409269, 10402947, 10402751, 10402660, 10396943, 10394957, 10356632, 10315972
Additional source detail variants (2)
Air Bags
In March 2011 Chrysler submitted a defect information report for NHTSA Recall No. 11V139 declaring a defect condition that could cause the ignition key to inadvertently move from the RUN to the ACC position on model year (MY) 2010 Dodge Journey, Grand Caravan, and Chrysler Town and Country.The report identified engine stalling as the defect consequence and cited customer complaints and warranty claims, as well as two rear-end collisions, as leading to the recall action.Chrysler determined that a defective WIN module, which is effectively the equivalent of the ignition switch, was the cause of the inadvertent key rotation, and that a new design WIN module would be installed as a remedy.In Spring 2014 ODI conducted outreach to major light vehicle manufacturers regarding ignition key position and its effect on air bag system availability.The outreach was conducted in connection with NHTSA Recall No. 14V047, a recent recall involving inadvertent ignition key rotation and subsequent air bag disablement in certain GM products.During discussions held in April 2014, Chrysler advised ODI that Chrysler air bag systems of this vintage, including the subject vehicles, revert to energy reserve when the ignition key moves to the ACC or OFF position, and that under energy reserve the air bags would only be available for a short period, approximately two tenths of a second (ODI notes this consequence was not identified in the 11V139 recall report).A review of the ODI consumer database conducted after the April 2014 discussions identified complaints alleging that MY 2008-2009 vehicles may have a similar defect as the MY 2010 vehicles, and that some MY 2010 consumers reported experiencing ignition key position concerns after the 11V139 recall remedy was applied.Accordingly this investigation was opened.In response to ODI?s information request letter, Chrysler reported that MY 2008-2009 subject vehicles used the same design WIN module as the recalled vehicles, and also identified 66 consumer reports and one non-injury crash incident potentially related to inadvertent ignition key rotation.Chrysler?s review of the MY 2010 remedy used in 11V139, which involved installation of a Trim Ring as opposed to replacement of the WIN module, showed the remedy did not adequately address ignition key position concerns, and in some use-cases could cause other systems to operate improperly (radio, instrument panel lighting, HVAC fan motor, etc.).Chrysler subsequently filed multiple defect information reports to 1) add the MY 2008-2009 Dodge Grand Caravan and Chrysler Town and Country, and the MY 2009 Dodge Journey to the original recall scope, and 2) stating that the complete WIN module would be replaced with a new design component in all recalled vehicles (including those that had the Trim Ring installed during 11V139).Chrysler?s report also advises of constrained remedy parts availability, see NHTSA Recall No. 14V373 for further details.Accordingly, the investigation is closed based on the recall action Chrysler is undertaking.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10584873, 10583399, 10573295, 10566365, 10546805, 10513060, 10509284, 10503121, 10496599, 10475027, 10456099, 10450629, 10443680, 10422766, 10410447, 10409269, 10402947, 10402751, 10402660, 10396943, 10394957, 10356632, 10315972
Electrical System:ignition:module
In March 2011 Chrysler submitted a defect information report for NHTSA Recall No. 11V139 declaring a defect condition that could cause the ignition key to inadvertently move from the RUN to the ACC position on model year (MY) 2010 Dodge Journey, Grand Caravan, and Chrysler Town and Country.The report identified engine stalling as the defect consequence and cited customer complaints and warranty claims, as well as two rear-end collisions, as leading to the recall action.Chrysler determined that a defective WIN module, which is effectively the equivalent of the ignition switch, was the cause of the inadvertent key rotation, and that a new design WIN module would be installed as a remedy.In Spring 2014 ODI conducted outreach to major light vehicle manufacturers regarding ignition key position and its effect on air bag system availability.The outreach was conducted in connection with NHTSA Recall No. 14V047, a recent recall involving inadvertent ignition key rotation and subsequent air bag disablement in certain GM products.During discussions held in April 2014, Chrysler advised ODI that Chrysler air bag systems of this vintage, including the subject vehicles, revert to energy reserve when the ignition key moves to the ACC or OFF position, and that under energy reserve the air bags would only be available for a short period, approximately two tenths of a second (ODI notes this consequence was not identified in the 11V139 recall report).A review of the ODI consumer database conducted after the April 2014 discussions identified complaints alleging that MY 2008-2009 vehicles may have a similar defect as the MY 2010 vehicles, and that some MY 2010 consumers reported experiencing ignition key position concerns after the 11V139 recall remedy was applied.Accordingly this investigation was opened.In response to ODI?s information request letter, Chrysler reported that MY 2008-2009 subject vehicles used the same design WIN module as the recalled vehicles, and also identified 66 consumer reports and one non-injury crash incident potentially related to inadvertent ignition key rotation.Chrysler?s review of the MY 2010 remedy used in 11V139, which involved installation of a Trim Ring as opposed to replacement of the WIN module, showed the remedy did not adequately address ignition key position concerns, and in some use-cases could cause other systems to operate improperly (radio, instrument panel lighting, HVAC fan motor, etc.).Chrysler subsequently filed multiple defect information reports to 1) add the MY 2008-2009 Dodge Grand Caravan and Chrysler Town and Country, and the MY 2009 Dodge Journey to the original recall scope, and 2) stating that the complete WIN module would be replaced with a new design component in all recalled vehicles (including those that had the Trim Ring installed during 11V139).Chrysler?s report also advises of constrained remedy parts availability, see NHTSA Recall No. 14V373 for further details.Accordingly, the investigation is closed based on the recall action Chrysler is undertaking.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10584873, 10583399, 10573295, 10566365, 10546805, 10513060, 10509284, 10503121, 10496599, 10475027, 10456099, 10450629, 10443680, 10422766, 10410447, 10409269, 10402947, 10402751, 10402660, 10396943, 10394957, 10356632, 10315972
Illustration