NHTSA owner reports · September 18, 2026 snapshot.
Service Brakes, Hydraulic complaints
195 reportsClear category filter20,000 miles · Nov 7, 2011
Service Brakes, Hydraulic
TL* THE CONTACT OWNS A 2009 DODGE JOURNEY. THE CONTACT STATED THAT THE VEHICLE WOULD EXHIBIT AN ABNORMAL GRINDING NOISE WHEN APPLYING THE BRAKES. IN ADDITION, THE ROTORS AND BRAKE PADS WERE WEARING PREMATURELY. THE VEHICLE WAS TAKEN TO THE DEALER THREE TIMES WHERE THEY REPLACED THE FRONT ROTORS AND FRONT BRAKE PADS. THE MANUFACT…
Read full complaint
TL* THE CONTACT OWNS A 2009 DODGE JOURNEY. THE CONTACT STATED THAT THE VEHICLE WOULD EXHIBIT AN ABNORMAL GRINDING NOISE WHEN APPLYING THE BRAKES. IN ADDITION, THE ROTORS AND BRAKE PADS WERE WEARING PREMATURELY. THE VEHICLE WAS TAKEN TO THE DEALER THREE TIMES WHERE THEY REPLACED THE FRONT ROTORS AND FRONT BRAKE PADS. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE WHO ADVISED THAT THERE WERE NO RECALLS FOR THE VEHICLE. THE CONTACT WAS REIMBURSED FOR FIFTY PERCENT OF THE REPAIR COSTS. THE FAILURE MILEAGE WAS 20,000 AND THE CURRENT MILEAGE WAS 37,500.
NHTSA ODI #10434791
Mileage unknown · Oct 14, 2011
Service Brakes, Hydraulic
PREMATURE BRAKE FAILURE. FRONT AND BACK BRAKES HAD TO BE REPLACED AT 17,179 MILES. *TR
NHTSA ODI #10430196
35,600 miles · Oct 12, 2011
Service Brakes, Hydraulic
DODGE GAVE ME AN EXTENDED WARRANTY ON THIS CAR TO 36,000 MILES. STARTED HAVING BRAKE PROBLEMS AND HAD THEM FIXED AT A SHOP BEFORE THE 36,000 MILE WARRANTY WAS UP. THEN AFTER FIXING THE BRAKES NOTICED A SHAKE IN THE FRONT END. TOOK IT BACK TO THE SHOP AT 36,400 MILES AND THEY THEN TOLD ME ABOUT THE PROBLEMS WITH THE JOURNEY. I CA…
Read full complaint
DODGE GAVE ME AN EXTENDED WARRANTY ON THIS CAR TO 36,000 MILES. STARTED HAVING BRAKE PROBLEMS AND HAD THEM FIXED AT A SHOP BEFORE THE 36,000 MILE WARRANTY WAS UP. THEN AFTER FIXING THE BRAKES NOTICED A SHAKE IN THE FRONT END. TOOK IT BACK TO THE SHOP AT 36,400 MILES AND THEY THEN TOLD ME ABOUT THE PROBLEMS WITH THE JOURNEY. I CALLED THE DEALER WHO COMPLETELY BLEW IT OFF. I HAVE PAID FOR THE REPAIR AND WAS TOLD TO SUBMIT A CLAIM TO CHRYSLER WHICH I DID AND IT WAS TURNED DOWN. THIS IS JUST NOT RIGHT! *KB
NHTSA ODI #10429646
7,536 miles · Oct 6, 2011
Engine And Engine CoolingPower TrainService Brakes, Hydraulic
IN TWO YEARS, FIVE (5) TIMES FOR BRAKE PROBLEMS. WITH 3,000 TO 6,000 MILES BETWEEN EACH BROKE. TWO TIMES ENGINE SUPPORT MOUNT. TWO TIMES WITH POWER TRAIN PROBLEMS. TODAY (10/06/2011) THE JOURNEY 2009 R/T IS IN THE SERVICE CENTER OF ALBERIC COLON CHRYSLER/JEEP IN KENNEDY AVE, SAN JUAN PR FOR THE SAME PROBLEMS AND ALSO : FOR…
Read full complaint
IN TWO YEARS, FIVE (5) TIMES FOR BRAKE PROBLEMS. WITH 3,000 TO 6,000 MILES BETWEEN EACH BROKE. TWO TIMES ENGINE SUPPORT MOUNT. TWO TIMES WITH POWER TRAIN PROBLEMS. TODAY (10/06/2011) THE JOURNEY 2009 R/T IS IN THE SERVICE CENTER OF ALBERIC COLON CHRYSLER/JEEP IN KENNEDY AVE, SAN JUAN PR FOR THE SAME PROBLEMS AND ALSO : FOR THE AIR CONDITIONER SYSTEM, SUSPENSION, MOTOR COOLING SYSTEM PROBLEMS,LEAKING GREASE IN THE BACK OF THE RIGHT FRONT WHEEL. AND GUESS!!!!!!, BRAKES AGAIN. BOTH, CHRYSLER AND THE DEALER HAS REFUSE TO OBEY THE LAW THAT SAYS, THEY HAVE TO PROVIDE A VEHICLE IN CASES THAT REPAIR LEAST MORE THAN 5 LABOR DAYS INCLUDING SATURDAY.ALSO, TO ADDED MORE PROBLEMS,[XXX](PR CHRYSLER SERVICE MANAGER), HAS REFUSED TO AUTHORIZE THE BRAKE REPAIR. SAYING THAT IS NORMAL, THAT A BRAKE SYSTEM THAT WAS REPAIR IN 02/16/2011 NEEDS TO BE REPAIR AGAIN IN 09/19/2011(22033 TO 30200 M). I HAVE BEING WITHOUT TRANSPORTATION FOR THREE WEEKS, CAUSING ME AN MY FAMILY A LOT OF PROBLEMS BECAUSE, IS OUR ONLY VEHICLE FOR ALL THE FAMILY MATTERS INCLUDING, THAT I AM A CARDIOVASCULAR PATIENT. " SOMEONE COULD TELL ME IS THESE SEEMS TO LOOK LIKE A BIG JUICY LEMON " QUESTION IS, WHO COULD HELP US WITH THIS GIANT ABUSIVE CORPORATIONS? INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).*TR
NHTSA ODI #10428974
14,500 miles · Sep 25, 2011
Service Brakes, Hydraulic
AROUND 14,000 MILES THE BRAKE PEDAL WOULD SINK. DEALER FOUND BAD MASTER CYLINDER. DURING FURTHER INSPECTION OF BRAKE SYSTEM THEY ALSO FOUND FRONT BRAKE PADS WORN. AT 24,000 THE REAR PADS AND ROTORS ARE NO GOOD. YOU CAN FEEL CAR SHIMMY WHEN SLOWING DOWN ON FREEWAY. PRE-MATURE FAILURE ON PADS AND ROTORS. CAR IS MOSTLY FREEWAY…
Read full complaint
AROUND 14,000 MILES THE BRAKE PEDAL WOULD SINK. DEALER FOUND BAD MASTER CYLINDER. DURING FURTHER INSPECTION OF BRAKE SYSTEM THEY ALSO FOUND FRONT BRAKE PADS WORN. AT 24,000 THE REAR PADS AND ROTORS ARE NO GOOD. YOU CAN FEEL CAR SHIMMY WHEN SLOWING DOWN ON FREEWAY. PRE-MATURE FAILURE ON PADS AND ROTORS. CAR IS MOSTLY FREEWAY MILES WITH NO HARD BRAKING. *TR
NHTSA ODI #10427062
43,000 miles · Sep 17, 2011
Service Brakes, Hydraulic
THIS VEHICLE HAS HAD ISSUES WITH BRAKES AND ROTORS. I BOUGHT THE VEHICLE AND HAD TO REPLACE THE BRAKES AND ROTORS WITHIN MONTHS. ROUGHLY A YEAR LATER THEY HAD TO BE REPLACED AGAIN, AND IT HAS NOW GONE OUT AGAIN. I HAVE NEVER HAD A VEHICLE GO THROUGH BRAKES THE WAY THIS ONE DOES. OUR OTHER VEHICLE IS A 2007 FORD ESCAPE AND HAS NE…
Read full complaint
THIS VEHICLE HAS HAD ISSUES WITH BRAKES AND ROTORS. I BOUGHT THE VEHICLE AND HAD TO REPLACE THE BRAKES AND ROTORS WITHIN MONTHS. ROUGHLY A YEAR LATER THEY HAD TO BE REPLACED AGAIN, AND IT HAS NOW GONE OUT AGAIN. I HAVE NEVER HAD A VEHICLE GO THROUGH BRAKES THE WAY THIS ONE DOES. OUR OTHER VEHICLE IS A 2007 FORD ESCAPE AND HAS NEVER HAD ANY BRAKE ISSUES, THE FIRST INCIDENT DATE IS TENTATIVE. *TT
NHTSA ODI #10425882
Mileage unknown · Sep 16, 2011
Service Brakes, Hydraulic
VEHICLE BRAKES ARE TOO SMALL/THIN FOR THIS HEAVY OF A VEHICLE. PADS CONSTANTLY NEED REPLACING. *TT
NHTSA ODI #10425699
15,353 miles · Sep 14, 2011
Service Brakes, Hydraulic
BRAKES NEED REPLACEMENT AFTER ONLY 15000 NORMAL MILES. *KB
NHTSA ODI #10425472
26,542 miles · Sep 13, 2011
Service Brakes, HydraulicSuspension
PURCHASED VEHICLE NEW IN JUNE OF 2009. FRONT BRAKES GONE AND EATING INTO ROTORS BY 26,000 MILES. LITTLE OVER A YEAR. 90% OF DRIVING IS FREEWAY DRIVING. VERY LITTLE STOP AND GO. REPLACED BRAKES AND HAD ROTORS TURNED. ROTORS WARPED AND FRONT AND REAR BRAKES GONE AGAIN AT 35,245 MILES ONE YEAR LATER. REPLACED FRONT ROTORS AND ALL 4…
Read full complaint
PURCHASED VEHICLE NEW IN JUNE OF 2009. FRONT BRAKES GONE AND EATING INTO ROTORS BY 26,000 MILES. LITTLE OVER A YEAR. 90% OF DRIVING IS FREEWAY DRIVING. VERY LITTLE STOP AND GO. REPLACED BRAKES AND HAD ROTORS TURNED. ROTORS WARPED AND FRONT AND REAR BRAKES GONE AGAIN AT 35,245 MILES ONE YEAR LATER. REPLACED FRONT ROTORS AND ALL 4 SETS OF BRAKES. FRONT STRUTS HAVE GONE OUT NOW AS WELL. DEFINITELY TOO MUCH WEIGHT FOR VEHICLE BRAKES AND SUSPENSION. IF NOT WATCHED COMPLETE FAILURE EXPECTED BEFORE RECOMMENDED MAINTENANCE CHANGES!! *TR
NHTSA ODI #10425245
25,120 miles · Sep 13, 2011
Service Brakes, Hydraulic
THE BRAKES FOR THIS VEHICLE REPEATEDLY CONTINUE TO FAIL. SINCE THE FIRST REPAIR (11/6/2009) WE HAVE HAD TO HAVE HAD 10 REPAIRS TO THE BRAKES IN LESS THAN 2 YEARS! OUR MECHANIC SAYS THAT THERE IS OBVIOUSLY A DESIGN FLAW. THE LAST REPAIR (ON 9/9/2011) THE MECHANIC SAID IT APPEARED THAT THE REAR BRAKES WERE NOT BEING USED AND A…
Read full complaint
THE BRAKES FOR THIS VEHICLE REPEATEDLY CONTINUE TO FAIL. SINCE THE FIRST REPAIR (11/6/2009) WE HAVE HAD TO HAVE HAD 10 REPAIRS TO THE BRAKES IN LESS THAN 2 YEARS! OUR MECHANIC SAYS THAT THERE IS OBVIOUSLY A DESIGN FLAW. THE LAST REPAIR (ON 9/9/2011) THE MECHANIC SAID IT APPEARED THAT THE REAR BRAKES WERE NOT BEING USED AND ALL BRAKING IS BEING ACCOMPLISHED USING THE FRONT BRAKES. I DON'T BELIEVE THAT IS HOW THE BRAKING SYSTEM IS SUPPOSED TO WORK. I BELIEVE MOST OF THE BRAKING SHOULD FALL ON THE REAR BRAKES. THE FRONT BRAKES ARE OVERHEATING AND CAUSING THE ROTOR TO WARP AND THE BRAKE PADS TO FAIL (LITERALLY FALL APART). DODGE OBVIOUSLY REALIZES THERE IS A PROBLEM AS THEY SENT A LETTER OFFERING AN EXTENDED WARRANTY DATED 6/1/2011 FOR VEHICLES THAT HAVE HAD EARLY BRAKING SYSTEM FAILURE. SINCE 6/1/2011 WE HAVE HAD 5 REPAIRS TO THE FRONT ROTORS AND/OR PADS! DODGE DID COMPENSATE US FOR MUCH OF OUR EXPENSE. I APPRECIATE THE COMPENSATION BUT THAT IS NOT RESOLVING THE PROBLEM! THE PROBLEM IS THAT THERE IS A CONSTANT FAILURE IN THE BRAKING SYSTEM. I WOULD LIKE DODGE TO ADDRESS THE PROBLEM AND EITHER REPAIR THE DESIGN FLAW OR REPLACE THE VEHICLE! MY FEAR IS THAT THE CAR WILL NOT STOP WHILE I AM DRIVING IN HOUSTON, TEXAS TRAFFIC AND SOMEONE IN MY CAR OR SOMEONE ELSE'S CAR WILL BE SERIOUSLY INJURED OR KILLED AS A RESULT. IT APPEARS THAT DODGE WILL WAIT UNTIL THERE IS A DEATH OR INJURY TO TAKE RESPONSIBILITY FOR THE POOR OR INADEQUATE DESIGN OF THE BRAKING SYSTEM IN THIS VEHICLE. UNFORTUNATELY, I AM NOT IN A POSITION TO BUY ANOTHER CAR OR I WOULD GET RID OF THIS VEHICLE AND NEVER PURCHASE A DODGE VEHICLE AGAIN! *TR
NHTSA ODI #10425173
Official recalls
8May 6, 2016
Chrysler (FCA US LLC) is recalling certain model year 2009-2016 Dodge Journey vehicles manufactured July 31, 2007, to November 12, 2016. After exposure to cold temperatures, the power steering return hose may rupture at engine start-up causing a loss of power steering assist.
Consequence & remedy
Consequence: A loss of power steering assist may require extra steering effort, especially at lower speeds, increasing the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the power steering return hoses, steel tubes, and power steering oil cooler, free of charge. The recall began on May 24, 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S08.
Jan 29, 2016
FCA US LLC (Chrysler) is recalling certain model year 2009 Dodge Journey vehicles manufactured December 31, 2007, to August 31, 2008, 2008-2009 Dodge Grand Caravan and Chrysler Town and Country vehicles manufactured June 18, 2007, to August 31, 2008. In the affected vehicles, the air bag control units may corrode and fail.
Consequence & remedy
Consequence: If the air bag control unit fails, the air bags may not deploy in the event of a crash, increasing the risk of occupant injury. Additionally, the air bags may inadvertently deploy, increasing the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the air bag control unit, free of charge. The recall began on December 6, 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S07.
Jun 26, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. Chrysler Group LLC (Chrysler) is recalling certain model year 2009-2010 Dodge Journey vehicles manufactured June 29, 2007, to June 17, 2010, and 2008-2010 Dodge Grand Caravan and Chrysler Town and Country vehicles manufactured January 26, 2007, to June 17, 2010. Road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the ignition key inadvertently moves into the OFF or ACCESSORY position, the engine will turn off, which will then depower various key safety systems including but not limited to air bags, power steering, and power braking. Loss of functionality of these systems may increase the risk of crash and/or increase the risk of injury in the event of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the ignition switch and key FOBs, free of charge. The recall began on May 26, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R03. Note: This is an expansion of recall 11V-139.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. Chrysler Group LLC (Chrysler) is recalling certain model year 2009-2010 Dodge Journey vehicles manufactured June 29, 2007, to June 17, 2010, and 2008-2010 Dodge Grand Caravan and Chrysler Town and Country vehicles manufactured January 26, 2007, to June 17, 2010. Road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence: If the ignition key inadvertently moves into the OFF or ACCESSORY position, the engine will turn off, which will then depower various key safety systems including but not limited to air bags, power steering, and power braking. Loss of functionality of these systems may increase the risk of crash and/or increase the risk of injury in the event of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the ignition switch and key FOBs, free of charge. The recall began on May 26, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R03. Note: This is an expansion of recall 11V-139.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. Chrysler Group LLC (Chrysler) is recalling certain model year 2009-2010 Dodge Journey vehicles manufactured June 29, 2007, to June 17, 2010, and 2008-2010 Dodge Grand Caravan and Chrysler Town and Country vehicles manufactured January 26, 2007, to June 17, 2010. Road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence: If the ignition key inadvertently moves into the OFF or ACCESSORY position, the engine will turn off, which will then depower various key safety systems including but not limited to air bags, power steering, and power braking. Loss of functionality of these systems may increase the risk of crash and/or increase the risk of injury in the event of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the ignition switch and key FOBs, free of charge. The recall began on May 26, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R03. Note: This is an expansion of recall 11V-139.
Dec 24, 2010
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2009 DODGE JOURNEY VEHICLES MANUFACTURER FROM NOVEMBER 1, 2007, THROUGH NOVEMBER 7, 2008. THE WIRES WITHIN THE FRONT DOOR WIRE HARNESSES MAY FATIGUE AND BREAK, WHICH CAN INTERRUPT THE CIRCUITS FOR THE SIDE IMPACT SENSOR(S), RESULTING IN AN AIRBAG WARNING LAMP ILLUMINATION AND LOSS OF SIDE CRASH SENSING CAPABILITY.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE SIDE AIRBAG MAY NOT DEPLOY, REDUCING THE PROTECTION INTENDED FOR THE OCCUPANT AND INCREASING THE RISK OF INJURIES.
Remedy: CHRYSLER WILL NOTIFY OWNERS AND REPLACE THE LEFT AND RIGHT DOOR WIRING HARNESSES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 18, 2011. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Apr 9, 2009
CHRYSLER IS RECALLING 4,314 MY 2009 DODGE JOURNEY, JEEP GRAND CHEROKEE, COMMANDER AND WRANGLER VEHICLES. WIRING MAY BE REVERSED ON THE STEERING COLUMN CONTROL MODULE DRIVER AIRBAG SQUIB CONNECTOR. THE DRIVER'S AIRBAG MAY NOT DEPLOY AS INTENDED.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE DRIVER'S AIRBAG MAY NOT PROPERLY INFLATE AND MAY NOT BE ABLE TO PROPERLY PROTECT AN OCCUPANT, INCREASING THE RISK OF INJURIES.
Remedy: DEALERS WILL INSPECT THE DRIVER'S AIRBAG SQUIB WIRES AND REPLACE THE STEERING COLUMN CONTROL MODULE FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2009. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Additional source detail variants (3)
Air Bags:frontal
CHRYSLER IS RECALLING 4,314 MY 2009 DODGE JOURNEY, JEEP GRAND CHEROKEE, COMMANDER AND WRANGLER VEHICLES. WIRING MAY BE REVERSED ON THE STEERING COLUMN CONTROL MODULE DRIVER AIRBAG SQUIB CONNECTOR. THE DRIVER'S AIRBAG MAY NOT DEPLOY AS INTENDED.
Consequence: IN THE EVENT OF A CRASH, THE DRIVER'S AIRBAG MAY NOT PROPERLY INFLATE AND MAY NOT BE ABLE TO PROPERLY PROTECT AN OCCUPANT, INCREASING THE RISK OF INJURIES.
Remedy: DEALERS WILL INSPECT THE DRIVER'S AIRBAG SQUIB WIRES AND REPLACE THE STEERING COLUMN CONTROL MODULE FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2009. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Air Bags
CHRYSLER IS RECALLING 4,314 MY 2009 DODGE JOURNEY, JEEP GRAND CHEROKEE, COMMANDER AND WRANGLER VEHICLES. WIRING MAY BE REVERSED ON THE STEERING COLUMN CONTROL MODULE DRIVER AIRBAG SQUIB CONNECTOR. THE DRIVER'S AIRBAG MAY NOT DEPLOY AS INTENDED.
Consequence: IN THE EVENT OF A CRASH, THE DRIVER'S AIRBAG MAY NOT PROPERLY INFLATE AND MAY NOT BE ABLE TO PROPERLY PROTECT AN OCCUPANT, INCREASING THE RISK OF INJURIES.
Remedy: DEALERS WILL INSPECT THE DRIVER'S AIRBAG SQUIB WIRES AND REPLACE THE STEERING COLUMN CONTROL MODULE FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2009. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Electrical System:wiring
CHRYSLER IS RECALLING 4,314 MY 2009 DODGE JOURNEY, JEEP GRAND CHEROKEE, COMMANDER AND WRANGLER VEHICLES. WIRING MAY BE REVERSED ON THE STEERING COLUMN CONTROL MODULE DRIVER AIRBAG SQUIB CONNECTOR. THE DRIVER'S AIRBAG MAY NOT DEPLOY AS INTENDED.
Consequence: IN THE EVENT OF A CRASH, THE DRIVER'S AIRBAG MAY NOT PROPERLY INFLATE AND MAY NOT BE ABLE TO PROPERLY PROTECT AN OCCUPANT, INCREASING THE RISK OF INJURIES.
Remedy: DEALERS WILL INSPECT THE DRIVER'S AIRBAG SQUIB WIRES AND REPLACE THE STEERING COLUMN CONTROL MODULE FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2009. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Mar 12, 2009
CHRYSLER IS RECALLING 16,852 MY 2009 DODGE JOURNEY VEHICLES EQUIPPED WITHOUT OPTIONAL 115 VOLT AUXILIARY POWER OUTLET. AN UNUSED ELECTRICAL CONNECTOR FOR THE OPTIONAL 115 VOLT AUXILIARY POWER OUTLET OPTION MAY BECOME CORRODED AND COULD SHORT CIRCUIT.
Consequence & remedy
Consequence: IF THE FUSE FOR THIS CIRCUIT DOES NOT BLOW, THE CONNECTOR COULD OVERHEAT AND POTENTIALLY CATCH FIRE.
Remedy: DEALERS WILL RE-ROUTE AND STOW THE 115 VOLT AUXILIARY POWER OUTLET CONNECTOR AND PULL THE 25 AMP FUSE TO REMOVE POWER FROM THIS UNUSED CIRCUIT FREE OF CHARGE. THE RECALL BEGAN ON MARCH 30, 2009. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Oct 9, 2008
CHRYSLER IS RECALLING 712 MY 2009 SEBRING, DODGE CALIBER, AVENGER, JOURNEY, JEEP PATRIOT, AND COMPASS VEHICLES. A NEW ADHESIVE USED IN THE POWER TRAIN CONTROL MODULE (PCM) MANUFACTURING PROCESS CAN CAUSE THE PRINTED CIRCUIT BOARD TO BREAK.
Consequence & remedy
Consequence: THIS CAN CAUSE THE ENGINE TO STALL AND CAUSE A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL REPLACE THE PCM FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 10, 2008. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Jun 3, 2008
CHRYSLER IS RECALLING 6,692 MY 2009 DODGE JOURNEY VEHICLES EQUIPPED WITH A 3.5L ENGINE. THE ENGINE WIRING HARNESS MAY CONTACT THE LEFT TRANSAXLE MOUNT.
Consequence & remedy
Consequence: DAMAGE TO THE WIRING HARNESS COULD RESULT IN AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL INSPECT THE ENGINE WIRING HARNESS FOR DAMAGE. IF THE HARNESS IS DAMAGED, THE WIRING WILL BE REPAIRED AND A TIE WRAP INSTALLED TO SECURE THE HARNESS AWAY FROM THE LEFT TRANSAXLE MOUNT. IF NO DAMAGE IS FOUND, A TIE WRAP WILL BE INSTALLED TO SECURE THE HARNESS AWAY FROM THE LEFT TRANSAXLE MOUNT. THE RECALL BEGAN ON JULY 7, 2008. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4EA24003 · Vehicle Entrapment
Opened Aug 1, 2024 · No close date supplied
Status: open (inferred from source dates) · Latches/locks/linkages
The Office of Defects Investigation (ODI) opened PE23-008 on May 1, 2023 to investigate an incident involving a 2009 Dodge Journey alleging occupant entrapment during a vehicle fire that resulted in a fatality. During the investigation, ODI collected information from the manufacturer and involved parties to confirm or refute the defect allegation. ODI has determined that additional reports of vehicle entrapment exist for other model year Dodge Journey vehicles. ODI continues to explore the cause of the thermal event and its potential effect on the actuation of the door locks. ODI also continues to explore other potential causes for door lock malfunction. ODI has determined that an upgrade to an Engineering Analysis (EA) is necessary to continue the review of the investigative material and to assess the risk to motor vehicle safety . To review the ODI report cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
PE23008 · Vehicle Entrapment
Opened May 1, 2023 · Closed Aug 15, 2024
Status: closed (inferred from source dates) · Latches/locks/linkages:doors:latch; Latches/locks/linkages:doors:lock; Latches/locks/linkages:electronic Lock/latch Actuator
The Office of Defects Investigation (ODI) opened PE23008 on May 1, 2023 to investigate an incident involving a 2009 Dodge Journey alleging occupant entrapment during a vehicle fire that resulted in a fatality. During this investigation, ODI collected information and evidence related to the defect allegation and incident, from the manufacturer and involved parties. The information and evidence collected in this initial phase was insufficient to make a defect determination. ODI has upgraded this investigation to an Engineering Analysis (EA24003) to develop a more comprehensive understanding of whether a potential safety defect exists. To review the ODI report cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (3)
Latches/locks/linkages:doors:latch
The Office of Defects Investigation (ODI) opened PE23008 on May 1, 2023 to investigate an incident involving a 2009 Dodge Journey alleging occupant entrapment during a vehicle fire that resulted in a fatality. During this investigation, ODI collected information and evidence related to the defect allegation and incident, from the manufacturer and involved parties. The information and evidence collected in this initial phase was insufficient to make a defect determination. ODI has upgraded this investigation to an Engineering Analysis (EA24003) to develop a more comprehensive understanding of whether a potential safety defect exists. To review the ODI report cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Latches/locks/linkages:doors:lock
The Office of Defects Investigation (ODI) opened PE23008 on May 1, 2023 to investigate an incident involving a 2009 Dodge Journey alleging occupant entrapment during a vehicle fire that resulted in a fatality. During this investigation, ODI collected information and evidence related to the defect allegation and incident, from the manufacturer and involved parties. The information and evidence collected in this initial phase was insufficient to make a defect determination. ODI has upgraded this investigation to an Engineering Analysis (EA24003) to develop a more comprehensive understanding of whether a potential safety defect exists. To review the ODI report cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Latches/locks/linkages:electronic Lock/latch Actuator
The Office of Defects Investigation (ODI) opened PE23008 on May 1, 2023 to investigate an incident involving a 2009 Dodge Journey alleging occupant entrapment during a vehicle fire that resulted in a fatality. During this investigation, ODI collected information and evidence related to the defect allegation and incident, from the manufacturer and involved parties. The information and evidence collected in this initial phase was insufficient to make a defect determination. ODI has upgraded this investigation to an Engineering Analysis (EA24003) to develop a more comprehensive understanding of whether a potential safety defect exists. To review the ODI report cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
DP14004 · Totally Integrated Power Module Failure
Opened Sep 25, 2014 · Closed Jul 24, 2015
Status: closed (inferred from source dates) · Electrical System
In a letter dated August 21, 2014, the Center for Auto Safety (CAS) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged failures associated with the Totally Integrated Power Module (TIPM) installed in Chrysler SUV?s, trucks, and vans beginning in the 2007 model year. The petitioner alleges that TIPM defects may result in engine stall, airbag non-deployment, failure of fuel pump shutoff resulting in unintended acceleration, fire, and other symptoms. On September 25, 2014, the Office of Defects Investigation (ODI) opened DP14-004 to evaluate the petition for a grant or deny decision. ODI analyzed complaint data provided by CAS as well as complaints submitted to ODI from consumers. In total, there were 296 complaints submitted by the petitioner in the original petition and five supplements, including 271 complaints related to the subject vehicles equipped with TIPM-7. Approximately 3 percent of CAS complaints are related to vehicles equipped with TIPM-6 and ODI?s review of these complaints did not identify any safety defect trends. ODI conducted a detailed review of complaints narratives submitted by CAS and consumers including careful analysis of vehicle repair histories, warranty claims obtained from the manufacturer and any available Customer Assistance Inquiry reports (CAIR). Analysis of the field data indicated that MY2011-2013 Jeep Grand Cherokee and Dodge Durango vehicles exhibited significantly higher complaint rates related to fuel pump relay (FPR) failures than other subject vehicles. In a September 3, 2014 letter to NHTSA, Chrysler submitted a Defect Information Report (DIR) identifying a defect in the FPR within the TIPM-7 which can result in a no start or stall condition in approximately 188,723 model year (MY) 2011 Jeep Grand Cherokee (WK) and Dodge Durango (WD) vehicles manufactured from January 5, 2010 through July 20, 2011 (14V-530).In a February 24, 2015 letter, Chrysler submitted a second DIR expanding the scope of the FPR defect condition to include an additional 338,216 MY 2012 through 2013 Jeep Grand Cherokee vehicles manufactured from September 17, 2010 through August 19, 2013 and MY 2012 through 2013 Dodge Durango vehicles manufactured from January 18, 2011 through August 19, 2013 (15V-115).ODI analysis of the CAS allegations of TIPM defects resulting in stall while driving, airbag non-deployment, unintended acceleration, fire and other faults identified a single defect condition related to 1 of over 60 different circuits in the TIPM assembly. The most common effect of this defect condition, related to the fuel pump relay, was a no-start concern, but it could also result in stall while driving (76 complaints). No valid evidence was presented in support of claims related to airbag non-deployment, unintended acceleration or fire resulting from TIPM faults and these claims were found to be wholly without merit based on review of the field data and design of the relevant systems and components.Except insofar as the petitioner's contentions relate to the defect condition addressed by the Chrysler recalls, the factual bases of the petitioner's contentions that any further investigation is necessary are unsupported. In our view, additional investigation is unlikely to result in a finding that a defect related to motor vehicle safety exists or a NHTSA order for the notification and remedy of a safety-related defect as alleged by the petitioner at the conclusion of the requested investigation. Therefore, in view of the need to allocate and prioritize NHTSA's limited resources to best accomplish the agency's safety mission, the petition is den
RQ14002 · Air Bag Non-Deployment/Engine Stall
Opened Jun 16, 2014 · Closed Mar 2, 2015
Status: closed (inferred from source dates) · Air Bags; Electrical System:ignition:module
In March 2011 Chrysler submitted a defect information report for NHTSA Recall No. 11V139 declaring a defect condition that could cause the ignition key to inadvertently move from the RUN to the ACC position on model year (MY) 2010 Dodge Journey, Grand Caravan, and Chrysler Town and Country.The report identified engine stalling as the defect consequence and cited customer complaints and warranty claims, as well as two rear-end collisions, as leading to the recall action.Chrysler determined that a defective WIN module, which is effectively the equivalent of the ignition switch, was the cause of the inadvertent key rotation, and that a new design WIN module would be installed as a remedy.In Spring 2014 ODI conducted outreach to major light vehicle manufacturers regarding ignition key position and its effect on air bag system availability.The outreach was conducted in connection with NHTSA Recall No. 14V047, a recent recall involving inadvertent ignition key rotation and subsequent air bag disablement in certain GM products.During discussions held in April 2014, Chrysler advised ODI that Chrysler air bag systems of this vintage, including the subject vehicles, revert to energy reserve when the ignition key moves to the ACC or OFF position, and that under energy reserve the air bags would only be available for a short period, approximately two tenths of a second (ODI notes this consequence was not identified in the 11V139 recall report).A review of the ODI consumer database conducted after the April 2014 discussions identified complaints alleging that MY 2008-2009 vehicles may have a similar defect as the MY 2010 vehicles, and that some MY 2010 consumers reported experiencing ignition key position concerns after the 11V139 recall remedy was applied.Accordingly this investigation was opened.In response to ODI?s information request letter, Chrysler reported that MY 2008-2009 subject vehicles used the same design WIN module as the recalled vehicles, and also identified 66 consumer reports and one non-injury crash incident potentially related to inadvertent ignition key rotation.Chrysler?s review of the MY 2010 remedy used in 11V139, which involved installation of a Trim Ring as opposed to replacement of the WIN module, showed the remedy did not adequately address ignition key position concerns, and in some use-cases could cause other systems to operate improperly (radio, instrument panel lighting, HVAC fan motor, etc.).Chrysler subsequently filed multiple defect information reports to 1) add the MY 2008-2009 Dodge Grand Caravan and Chrysler Town and Country, and the MY 2009 Dodge Journey to the original recall scope, and 2) stating that the complete WIN module would be replaced with a new design component in all recalled vehicles (including those that had the Trim Ring installed during 11V139).Chrysler?s report also advises of constrained remedy parts availability, see NHTSA Recall No. 14V373 for further details.Accordingly, the investigation is closed based on the recall action Chrysler is undertaking.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10584873, 10583399, 10573295, 10566365, 10546805, 10513060, 10509284, 10503121, 10496599, 10475027, 10456099, 10450629, 10443680, 10422766, 10410447, 10409269, 10402947, 10402751, 10402660, 10396943, 10394957, 10356632, 10315972
Additional source detail variants (2)
Air Bags
In March 2011 Chrysler submitted a defect information report for NHTSA Recall No. 11V139 declaring a defect condition that could cause the ignition key to inadvertently move from the RUN to the ACC position on model year (MY) 2010 Dodge Journey, Grand Caravan, and Chrysler Town and Country.The report identified engine stalling as the defect consequence and cited customer complaints and warranty claims, as well as two rear-end collisions, as leading to the recall action.Chrysler determined that a defective WIN module, which is effectively the equivalent of the ignition switch, was the cause of the inadvertent key rotation, and that a new design WIN module would be installed as a remedy.In Spring 2014 ODI conducted outreach to major light vehicle manufacturers regarding ignition key position and its effect on air bag system availability.The outreach was conducted in connection with NHTSA Recall No. 14V047, a recent recall involving inadvertent ignition key rotation and subsequent air bag disablement in certain GM products.During discussions held in April 2014, Chrysler advised ODI that Chrysler air bag systems of this vintage, including the subject vehicles, revert to energy reserve when the ignition key moves to the ACC or OFF position, and that under energy reserve the air bags would only be available for a short period, approximately two tenths of a second (ODI notes this consequence was not identified in the 11V139 recall report).A review of the ODI consumer database conducted after the April 2014 discussions identified complaints alleging that MY 2008-2009 vehicles may have a similar defect as the MY 2010 vehicles, and that some MY 2010 consumers reported experiencing ignition key position concerns after the 11V139 recall remedy was applied.Accordingly this investigation was opened.In response to ODI?s information request letter, Chrysler reported that MY 2008-2009 subject vehicles used the same design WIN module as the recalled vehicles, and also identified 66 consumer reports and one non-injury crash incident potentially related to inadvertent ignition key rotation.Chrysler?s review of the MY 2010 remedy used in 11V139, which involved installation of a Trim Ring as opposed to replacement of the WIN module, showed the remedy did not adequately address ignition key position concerns, and in some use-cases could cause other systems to operate improperly (radio, instrument panel lighting, HVAC fan motor, etc.).Chrysler subsequently filed multiple defect information reports to 1) add the MY 2008-2009 Dodge Grand Caravan and Chrysler Town and Country, and the MY 2009 Dodge Journey to the original recall scope, and 2) stating that the complete WIN module would be replaced with a new design component in all recalled vehicles (including those that had the Trim Ring installed during 11V139).Chrysler?s report also advises of constrained remedy parts availability, see NHTSA Recall No. 14V373 for further details.Accordingly, the investigation is closed based on the recall action Chrysler is undertaking.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10584873, 10583399, 10573295, 10566365, 10546805, 10513060, 10509284, 10503121, 10496599, 10475027, 10456099, 10450629, 10443680, 10422766, 10410447, 10409269, 10402947, 10402751, 10402660, 10396943, 10394957, 10356632, 10315972
Electrical System:ignition:module
In March 2011 Chrysler submitted a defect information report for NHTSA Recall No. 11V139 declaring a defect condition that could cause the ignition key to inadvertently move from the RUN to the ACC position on model year (MY) 2010 Dodge Journey, Grand Caravan, and Chrysler Town and Country.The report identified engine stalling as the defect consequence and cited customer complaints and warranty claims, as well as two rear-end collisions, as leading to the recall action.Chrysler determined that a defective WIN module, which is effectively the equivalent of the ignition switch, was the cause of the inadvertent key rotation, and that a new design WIN module would be installed as a remedy.In Spring 2014 ODI conducted outreach to major light vehicle manufacturers regarding ignition key position and its effect on air bag system availability.The outreach was conducted in connection with NHTSA Recall No. 14V047, a recent recall involving inadvertent ignition key rotation and subsequent air bag disablement in certain GM products.During discussions held in April 2014, Chrysler advised ODI that Chrysler air bag systems of this vintage, including the subject vehicles, revert to energy reserve when the ignition key moves to the ACC or OFF position, and that under energy reserve the air bags would only be available for a short period, approximately two tenths of a second (ODI notes this consequence was not identified in the 11V139 recall report).A review of the ODI consumer database conducted after the April 2014 discussions identified complaints alleging that MY 2008-2009 vehicles may have a similar defect as the MY 2010 vehicles, and that some MY 2010 consumers reported experiencing ignition key position concerns after the 11V139 recall remedy was applied.Accordingly this investigation was opened.In response to ODI?s information request letter, Chrysler reported that MY 2008-2009 subject vehicles used the same design WIN module as the recalled vehicles, and also identified 66 consumer reports and one non-injury crash incident potentially related to inadvertent ignition key rotation.Chrysler?s review of the MY 2010 remedy used in 11V139, which involved installation of a Trim Ring as opposed to replacement of the WIN module, showed the remedy did not adequately address ignition key position concerns, and in some use-cases could cause other systems to operate improperly (radio, instrument panel lighting, HVAC fan motor, etc.).Chrysler subsequently filed multiple defect information reports to 1) add the MY 2008-2009 Dodge Grand Caravan and Chrysler Town and Country, and the MY 2009 Dodge Journey to the original recall scope, and 2) stating that the complete WIN module would be replaced with a new design component in all recalled vehicles (including those that had the Trim Ring installed during 11V139).Chrysler?s report also advises of constrained remedy parts availability, see NHTSA Recall No. 14V373 for further details.Accordingly, the investigation is closed based on the recall action Chrysler is undertaking.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10584873, 10583399, 10573295, 10566365, 10546805, 10513060, 10509284, 10503121, 10496599, 10475027, 10456099, 10450629, 10443680, 10422766, 10410447, 10409269, 10402947, 10402751, 10402660, 10396943, 10394957, 10356632, 10315972
Illustration