NHTSA owner reports · September 18, 2026 snapshot.
Power Train complaints
95 reportsClear category filterMileage unknown · Oct 2, 2003
Power Train
WE HAVE A 1999 DODGE INTREPID, FOR THE LAST 2 YEARS THE SAME MECHANICAL PROBLEMS OCCURRED. YOU WOULD FEEL AND HEAR A CLUNKING NOISE, CHECK ENGINE LIGHT COMES ON AND THE CAR LOCKS IN LOW GEAR. WE HAD A 5 STAR DEALER SERVICE THE CAR 10 TIMES OVER THE PAST 2 YEARS. EACH TIME THEY THOUGHT THEY FIXED THE PROBLEM. NOW THEY TELL ME IT…
Read full complaint
WE HAVE A 1999 DODGE INTREPID, FOR THE LAST 2 YEARS THE SAME MECHANICAL PROBLEMS OCCURRED. YOU WOULD FEEL AND HEAR A CLUNKING NOISE, CHECK ENGINE LIGHT COMES ON AND THE CAR LOCKS IN LOW GEAR. WE HAD A 5 STAR DEALER SERVICE THE CAR 10 TIMES OVER THE PAST 2 YEARS. EACH TIME THEY THOUGHT THEY FIXED THE PROBLEM. NOW THEY TELL ME IT CAN'T BE FIXED. DAIMLER WOULD NOT GIVE US THE TIME OF DAY. THEY TELL US WE SHOULD GO TO A DIFFERENT DEALER. WE TOLD THEM WE WERE SICK OF GETTING THE RUN-AROUND, THE RESPONSE WAS: WE CAN'T FIX YOUR CAR OVER THE PHONE. IMAGINE GOING 55 MPH AND HAVING DOWN SHIFT INTO LOW GEAR. *JB
NHTSA ODI #10041079
Mileage unknown · Sep 29, 2003
Power Train
CONSUMER CALLED COMPLAINING ABOUT TRANSMISSION PROBLEMS. CONSUMER HAS REPLACED TRANSMISSION FIVE TIMES IN FOUR YEARS, AND THREE TIMES IN LESS THEN TWO MONTHS. MANUFACTURER WAS CONTACTED, AND STATED THAT THERE WAS NOTHING THEY COULD DO. DEALER WAS CONTACTED, AND STATED THAT WARRANTY EXPIRED.*AK
NHTSA ODI #10041902
70,000 miles · Sep 7, 2003
Power TrainSeat BeltsVisibility
TRANSMISSION GOES INTO LIMP MODE IN SECOND GEAR .DRIVER WINDOW OFF TRACK BACK WINDOW WORKS WHEN IT GET READY ANDENGINE LIGHT COMES WHEN IT GET READY SEAT BELT RETRACTS SOMETIME I BELIEVE MY CAR IS FALLING APART. *AK
NHTSA ODI #10037392
35,000 miles · Aug 22, 2003
Power Train
GEAR SHIFT CAN BE MOVED FROM PARK TO DRIVE WITHOUT A KEY BEING IN THE IGNITION.*AK
NHTSA ODI #10034371
109,754 miles · Jun 25, 2003
Electrical SystemEngine And Engine CoolingPower Train
1999 DODGE INTREPID 2.7 VIN#[XXX], 43,913 MILES, TRANSMISSION SENSOR WENT OUT, $132.84. 9/14/00 75,085 MILES, WATER OUTLET AND TRANSMISSION LINES NEEDED REPLACED. MECHANIC INFORMED ME THE TRANSMISSION LINES WERE FACTORY INSTALLED DEFECTIVE. $582.24. 12/14/01 86,992 MILES, TIMING CHAIN BROKE, REPLACED WATER PUMP. $1,188…
Read full complaint
1999 DODGE INTREPID 2.7 VIN#[XXX], 43,913 MILES, TRANSMISSION SENSOR WENT OUT, $132.84. 9/14/00 75,085 MILES, WATER OUTLET AND TRANSMISSION LINES NEEDED REPLACED. MECHANIC INFORMED ME THE TRANSMISSION LINES WERE FACTORY INSTALLED DEFECTIVE. $582.24. 12/14/01 86,992 MILES, TIMING CHAIN BROKE, REPLACED WATER PUMP. $1,188.79. 6/14/02. 91,324 MILES, TRANSMISSION SPEED SENSOR BROKE. $350.60. 8/2/02 96,828 MILES, DASH LIGHTS WENT OUT. MECHANIC INFORMED ME THE DASH LIGHTS WERE AN INTERNAL WIRING DEFECT. $223.30. 10/2/02 98,003 MILES, COOLING FAN WENT OUT. MECHANIC INFORMED ME THIS WAS A FACTORY DEFECT. CHRYSLER HAD CHANGED THE DESIGN OF THE FANS SO I COULD NOT JUST REPAIR ONE SIDE OF THE FAN SINCE IT WAS NO LONGER AVAILABLE. $680.35. 10/24/02. 109,754 MILES, ENGINE BLEW, TAKING STARTER WITH IT. TOLD BY MECHANIC THAT CHRYSLER DESIGNED THE 2.7 ENGINE TO BE A DISPOSABLE ENGINE (COMPARED TO THE 3.2 THAT YEAR). REPLACED WITH USED ENGINE. $4174.49. 5/21/03 I HAD OVER $7000 IN REPAIRS IN UNDER A YEAR AND A HALF. WHILE IM GRAVELY DISAPPOINTED IN THE MECHANICS OF THIS VEHICLE, I FEEL THAT THE FAN ASSEMBLY, TRANSMISSION LINES, AND ELECTRICAL WIRING ARE THINGS THAT WERE OBVIOUSLY DEFECTIVE FROM THE START AND SHOULD BE REPAIRED FREE OF CHARGE. ADDITIONALLY, THE TRANSMISSION SENSOR GOING OUT AT ONLY 43,913 MILES SHOULD HAVE BEEN REPLACED FREE AS WELL. WHILE IT IS DIFFICULT TO PROVE THAT I TOOK CARE OF THE ENGINE, I HAVE OIL CHANGE RECEIPTS. *NLM INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
NHTSA ODI #10023730
88,500 miles · Jun 5, 2003
Engine And Engine CoolingPower Train
I PURCHASED A 1999 DODGE INTERPID ON APRIL 11, 2003, AFTER HAVING IT FOR 25 DAYS, THE TRANSMISSION WENT. WAS REPAIRED. IN THE SHOP FOR 2 WEEKS. AFTER HAVING IT FOR 9 DAYS, A LOUD NOISE IN ENGINE WAS NOTICED. IT WAS NOT DROVE, BUT WENT INTO THE SHOP AGAIN AND IS CURRENTLY THERE. THE ENGINE HAS GONE. REPAIR SHOP CALLED CHRYSLER C…
Read full complaint
I PURCHASED A 1999 DODGE INTERPID ON APRIL 11, 2003, AFTER HAVING IT FOR 25 DAYS, THE TRANSMISSION WENT. WAS REPAIRED. IN THE SHOP FOR 2 WEEKS. AFTER HAVING IT FOR 9 DAYS, A LOUD NOISE IN ENGINE WAS NOTICED. IT WAS NOT DROVE, BUT WENT INTO THE SHOP AGAIN AND IS CURRENTLY THERE. THE ENGINE HAS GONE. REPAIR SHOP CALLED CHRYSLER COMPANY AND THEY SAID TO REPLACE IT. OUR EXTENDED WARRANTY COMPANY WANTS ME TO AUTHORIZE REPAIRS AND WILL DECIDE WHAT PERCENTAGE THEY WILL PAY FOR IT. BUT THE POLICY WE HAVE STATES ENGINE REPAIRS AND REPLACEMENT., ACCORDING TO THEIR BOOKLET. THE COST TO REPLACE IT, $8,300.00! THAT IS MORE THAN WHAT WE PAID FOR THE CAR. THIS CAR HAS BEEN DRIVEABLE FOR 25 DAYS BEFORE FIRST BREAKDOWN WITH TRANSMISSION JOB, UNDRIVEABLE AND IN THE SHOP FOR 14 DAYS, OUT FOR 9 DAYS AND IS NOW IN THE SHOP AWAITING A NEW ENGINE. I HAVE READ ON THE INTERNET ABOUT OTHER 1999 DODGE INTERPID OWNERS WHO ARE HAVING THE SAME TROUBLES AS I AM WITH THEIR CARS. PLEASE HELP THIS ENGINE IS RUINNED! NEEDS TO BE REPLACES, 2.7L, V-6.. *AK
NHTSA ODI #10021086
51,580 miles · May 30, 2003
Power Train
THE SHIFT LEVER IS HARD TO SHIFT, AND IT IS OUT OF ALIGNMENT. WHEN I PUT THE SHIFT LEVER IN THE DRIVE MODE, IT STOPS IN 2ND GEAR, BUT THE INDICATOR ON THE DASH WILL SAY "D". RIGHT NOW IT'S FUNCTIONING, BUT IT CAN GO ANYTIME NOW. I WOULD LIKE TO KNOW WHY THIS IS HAPPENING, AND HOW MUCH IT WILL COST TO FIX, AND BETTER YET WILL …
Read full complaint
THE SHIFT LEVER IS HARD TO SHIFT, AND IT IS OUT OF ALIGNMENT. WHEN I PUT THE SHIFT LEVER IN THE DRIVE MODE, IT STOPS IN 2ND GEAR, BUT THE INDICATOR ON THE DASH WILL SAY "D". RIGHT NOW IT'S FUNCTIONING, BUT IT CAN GO ANYTIME NOW. I WOULD LIKE TO KNOW WHY THIS IS HAPPENING, AND HOW MUCH IT WILL COST TO FIX, AND BETTER YET WILL IT FALL UNDER MY SILVER WARRANTY PLAN.*AK
NHTSA ODI #10020758
Mileage unknown · May 19, 2003
Power Train
THE VEHICLE FAILED TO SHIFT OUT OF SECOND GEAR.*AK *JB
NHTSA ODI #10019477
30,000 miles · May 12, 2003
Power Train
THE VEHICLE HAD PROBLEMS WITH THE TRANSMISSION, IT ONLY WENT INTO 2 GEARS. *JB
NHTSA ODI #10019682
60,000 miles · Apr 10, 2003
Electrical SystemEngine And Engine CoolingPower Train
HISTORY INCLUDES BLOWN TRANSMISSION SENSOR, FAILURE ON THE VERY FIRST YEAR INSPECTION FOR BRAKE ROTORS, DRIVER'S SIDE WINDOW STICKS IN UP POSITION, INTERMITTENT HEAT CONTROL BUTTON NOT FUNCTIONING PROPERLY, NOISY WHEN TURNING IN FRONT STRUT AREA, KEYLESS REMOTE DOES NOT FUNCTION PROPERLY AND NOW THE WORST OF IT. ONE MONTH AGO, …
Read full complaint
HISTORY INCLUDES BLOWN TRANSMISSION SENSOR, FAILURE ON THE VERY FIRST YEAR INSPECTION FOR BRAKE ROTORS, DRIVER'S SIDE WINDOW STICKS IN UP POSITION, INTERMITTENT HEAT CONTROL BUTTON NOT FUNCTIONING PROPERLY, NOISY WHEN TURNING IN FRONT STRUT AREA, KEYLESS REMOTE DOES NOT FUNCTION PROPERLY AND NOW THE WORST OF IT. ONE MONTH AGO, TOOK CAR IN WITH OIL AND ENGINE LIGHTS FLASHING, TICKING NOISE FROM ENGINE, STALLING OUT. DEALER DID ELECTRONIC SENSORS REPAIRS AND TUNE UP COSTING $500. ONE MONTH LATER, CAR HAD TO BE TOWED BACK TO DEALER WITH LOUD BANGING IN ENGINE. REPAIR BILL OF OVER $6,000 TO FIX A CAR I'VE OWNED 3 YEARS, 8 MONTHS AND 60,000 MILES. 2.7 L ENGINES ARE BLOWING IN THESE CARS ALL THE TIME MAKING IT NEXT TO IMPOSSIBLE TO PURCHASE A USED ONE TO DO REPAIRS MYSELF. ONE USED CAR PARTS PLACE SAID THEY HAVE A WAITING LIST. RECALL ANYONE???!! *NLM
NHTSA ODI #10014231
Official recalls
4Jan 13, 2004
ON CERTAIN PASSENGER VEHICLES, THE FLOOR SHIFTER IGNITION-PARK INTERLOCK MAY FAIL AND ALLOW THE SHIFTER TO BE MOVED OUT OF THE PARK POSITION WITH THE KEY REMOVED. AN INOPERATIVE INTERLOCK MAY ALSO ALLOW THE KEY TO BE REMOVED WHEN THE SHIFTER HAS NOT BEEN PLACED IN THE PARK POSITION.
Consequence & remedy
Consequence: EITHER CIRCUMSTANCE MAY RESULT IN THE VEHICLE ROLLING AWAY WITHOUT WARNING.
Remedy: DEALERS WILL INSTALL A NEW LOAD-LIMITING PUSH ROD INTO THE FLOOR SHIFTER LEVER OF THE AFFECTED VEHICLES. OWNER NOTIFICATION BEGAN ON JUNE 14, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Feb 5, 2003
ON CERTAIN PASSENGER VEHICLES, SEAT BACK RECLINER BOLT BREAKAGE CAN OCCUR RESULTING IN THE SEAT BACK RECLINING UNEXPECTEDLY.
Consequence & remedy
Consequence: IF THE SEAT BACK UNEXPECTEDLY RECLINES WHILE THE CAR IS BEING DRIVEN, IT COULD RESULT IN LOSS OF VEHICLE CONTROL, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE RECLINER BOLTS. OWNER NOTIFICATION BEGAN ON APRIL 23, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Apr 11, 2001
VEHICLE DESCRIPTION: CERTAIN VAN, WAGON, PICKUP TRUCKS, PASSENGER AND SPORT UTILITY VEHICLES, FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 209, "SEAT BELT ASSEMBLIES." THE FRONT SEAT BELT RETRACTOR MAY NOT COMPLY WITH THE REQUIREMENTS OF THE STANDARD.
Consequence & remedy
Consequence: IF THE RETRACTOR DOES NOT WORK PROPERLY, IT WILL NOT ADEQUATELY PROTECT OCCUPANTS IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL REPLACE THE SEAT BELT RETRACTOR. OWNER NOTIFICATION BEGAN AUGUST 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Feb 4, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE SEAT BELT SHOULDER HEIGHT ADJUSTABLE TURNING LOOP (ATL) TOP MOUNTING BOLT WAS INADEQUATELY MANUFACTURED.
Consequence & remedy
Consequence: THE AFFECTED MOUNTING BOLTS MAY NOT WITHSTAND SUFFICIENT FORCE TO FUNCTION PROPERLY IN CERTAIN IMPACT SITUATIONS, INCREASING THE RISK OF INJURY TO A BELTED OCCUPANT.
Remedy: DEALERS WILL REPLACE THE SHOULDER BELT HEIGHT ADJUSTER MOUNTING BOLTS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA03011 · Auto Trans IGNITION-PARK Interlock
Opened Jul 17, 2003 · Closed Jan 30, 2004
Status: closed (inferred from source dates) · Power Train:automatic Transmission; Power Train:automatic Transmission:lever And Linkage:floor Shift
THE MANUFACTURER REPORTS ABOVE ARE BASED ON DAIMLERCHRYSLER?S (DC) ANALYSIS OF MODEL YEAR (MY) 1998 (POPULATION = 356,384) AND 1999 (POPULATION = 486,948) JA, JX AND LH FAMILY SUBJECT VEHICLE DATA (EARLIER MYS EXCLUDED).THE POPULATION NUMBER INCLUDES ALL MYS.THE PRECISE NUMBER OF DUPLICATES BETWEEN ODI AND DC REPORTS CANNOT BE DETERMINED DUE TO MISSING OR INCOMPLETE INFORMATION.THE FATALITY INCIDENT INVOLVED AN ELDERLY PERSON WHO ATTEMPTED TO STOP A ROLL AWAY VEHICLE AND RECEIVED FATAL INJURIES.ODI ALSO GATHERED INFORMATION ON MY 1997-99 PROWLER VEHICLES IN THIS INVESTIGATION. THE PROWLER VEHICLES WERE MANUFACTURED WITH A DIFFERENT DESIGN SHIFTER MECHANISM (THE SHIFT LEVER IS SHORTER).THERE ARE NO COMPLAINTS OF PROWLER INTERLOCK FAILURE IN ODI?S DATABASE, AND DC HAS RECEIVED NO REPORTS EITHER.THE PROWLER IS EXCLUDED FROM THE RECALL SCOPE.THE INVESTIGATION INVOLVED A CONDITION WHERE THE INTERLOCK SYSTEM COULD FAIL (OR BE MADE INOPERATIVE BY THE OPERATOR) DURING VEHICLE USE, POSSIBLY INADVERTENTLY.THE INTERLOCK SYSTEM IS REQUIRED UNDER FMVSS 114.WITH THE TRANSMISSION IN THE PARK POSITION AND THE IGNITION KEY OFF, THE COMBINED ACTION OF PRESSING THE SHIFT BUTTON AND PULLING THE SHIFT LEVER REARWARD MAY RESULT IN THE OPERATOR OVERCOMING THE INTERLOCK SYSTEM AND CAUSE THE MECHANICAL LINKAGE OF THE SYSTEM TO DISCONNECT.WHEN THIS OCCURS, THERE IS NO OVERT INDICATION TO AN OPERATOR THAT THE SYSTEM IS DEFEATED, AND AN INCREASED RISK OF VEHICLE ROLL-AWAY EXISTS.UNDER RECALL 04V021, DC WILL REPLACE DAMAGED SHIFT MECHANISMS, AND WILL INSTALL ON ALL VEHICLES A DEVICE WHICH INHIBITS THE OPERATOR?S ABILITY TO OVERCOME THE INTERLOCK AND DEFEAT THE SYSTEM.BEGINNING WITH MY 2000, DC INCORPORATED A BRAKE AND TRANSMISSION SHIFTER INTERLOCK (BTSI) SYSTEM INTO THE SUBJECT VEHICLES.INTRODUCTION OF BTSI INVOLVED DESIGN CHANGES TO THE SHIFT MECHANISM, ONE OF WHICH RESULTED IN REDUCED MECHANICAL ADVANTAGE (RMA) OF THE SHIFT BUTTON.THE RMA SHIFTER REQUIRES INCREASED FORCES TO OVERCOME THE INTERLOCK SYSTEM, MAKING THE SHIFTER LESS SUSCEPTIBLE TO DAMAGE.
Additional source detail variants (2)
Power Train:automatic Transmission
THE MANUFACTURER REPORTS ABOVE ARE BASED ON DAIMLERCHRYSLER?S (DC) ANALYSIS OF MODEL YEAR (MY) 1998 (POPULATION = 356,384) AND 1999 (POPULATION = 486,948) JA, JX AND LH FAMILY SUBJECT VEHICLE DATA (EARLIER MYS EXCLUDED).THE POPULATION NUMBER INCLUDES ALL MYS.THE PRECISE NUMBER OF DUPLICATES BETWEEN ODI AND DC REPORTS CANNOT BE DETERMINED DUE TO MISSING OR INCOMPLETE INFORMATION.THE FATALITY INCIDENT INVOLVED AN ELDERLY PERSON WHO ATTEMPTED TO STOP A ROLL AWAY VEHICLE AND RECEIVED FATAL INJURIES.ODI ALSO GATHERED INFORMATION ON MY 1997-99 PROWLER VEHICLES IN THIS INVESTIGATION. THE PROWLER VEHICLES WERE MANUFACTURED WITH A DIFFERENT DESIGN SHIFTER MECHANISM (THE SHIFT LEVER IS SHORTER).THERE ARE NO COMPLAINTS OF PROWLER INTERLOCK FAILURE IN ODI?S DATABASE, AND DC HAS RECEIVED NO REPORTS EITHER.THE PROWLER IS EXCLUDED FROM THE RECALL SCOPE.THE INVESTIGATION INVOLVED A CONDITION WHERE THE INTERLOCK SYSTEM COULD FAIL (OR BE MADE INOPERATIVE BY THE OPERATOR) DURING VEHICLE USE, POSSIBLY INADVERTENTLY.THE INTERLOCK SYSTEM IS REQUIRED UNDER FMVSS 114.WITH THE TRANSMISSION IN THE PARK POSITION AND THE IGNITION KEY OFF, THE COMBINED ACTION OF PRESSING THE SHIFT BUTTON AND PULLING THE SHIFT LEVER REARWARD MAY RESULT IN THE OPERATOR OVERCOMING THE INTERLOCK SYSTEM AND CAUSE THE MECHANICAL LINKAGE OF THE SYSTEM TO DISCONNECT.WHEN THIS OCCURS, THERE IS NO OVERT INDICATION TO AN OPERATOR THAT THE SYSTEM IS DEFEATED, AND AN INCREASED RISK OF VEHICLE ROLL-AWAY EXISTS.UNDER RECALL 04V021, DC WILL REPLACE DAMAGED SHIFT MECHANISMS, AND WILL INSTALL ON ALL VEHICLES A DEVICE WHICH INHIBITS THE OPERATOR?S ABILITY TO OVERCOME THE INTERLOCK AND DEFEAT THE SYSTEM.BEGINNING WITH MY 2000, DC INCORPORATED A BRAKE AND TRANSMISSION SHIFTER INTERLOCK (BTSI) SYSTEM INTO THE SUBJECT VEHICLES.INTRODUCTION OF BTSI INVOLVED DESIGN CHANGES TO THE SHIFT MECHANISM, ONE OF WHICH RESULTED IN REDUCED MECHANICAL ADVANTAGE (RMA) OF THE SHIFT BUTTON.THE RMA SHIFTER REQUIRES INCREASED FORCES TO OVERCOME THE INTERLOCK SYSTEM, MAKING THE SHIFTER LESS SUSCEPTIBLE TO DAMAGE.
Power Train:automatic Transmission:lever And Linkage:floor Shift
THE MANUFACTURER REPORTS ABOVE ARE BASED ON DAIMLERCHRYSLER?S (DC) ANALYSIS OF MODEL YEAR (MY) 1998 (POPULATION = 356,384) AND 1999 (POPULATION = 486,948) JA, JX AND LH FAMILY SUBJECT VEHICLE DATA (EARLIER MYS EXCLUDED).THE POPULATION NUMBER INCLUDES ALL MYS.THE PRECISE NUMBER OF DUPLICATES BETWEEN ODI AND DC REPORTS CANNOT BE DETERMINED DUE TO MISSING OR INCOMPLETE INFORMATION.THE FATALITY INCIDENT INVOLVED AN ELDERLY PERSON WHO ATTEMPTED TO STOP A ROLL AWAY VEHICLE AND RECEIVED FATAL INJURIES.ODI ALSO GATHERED INFORMATION ON MY 1997-99 PROWLER VEHICLES IN THIS INVESTIGATION. THE PROWLER VEHICLES WERE MANUFACTURED WITH A DIFFERENT DESIGN SHIFTER MECHANISM (THE SHIFT LEVER IS SHORTER).THERE ARE NO COMPLAINTS OF PROWLER INTERLOCK FAILURE IN ODI?S DATABASE, AND DC HAS RECEIVED NO REPORTS EITHER.THE PROWLER IS EXCLUDED FROM THE RECALL SCOPE.THE INVESTIGATION INVOLVED A CONDITION WHERE THE INTERLOCK SYSTEM COULD FAIL (OR BE MADE INOPERATIVE BY THE OPERATOR) DURING VEHICLE USE, POSSIBLY INADVERTENTLY.THE INTERLOCK SYSTEM IS REQUIRED UNDER FMVSS 114.WITH THE TRANSMISSION IN THE PARK POSITION AND THE IGNITION KEY OFF, THE COMBINED ACTION OF PRESSING THE SHIFT BUTTON AND PULLING THE SHIFT LEVER REARWARD MAY RESULT IN THE OPERATOR OVERCOMING THE INTERLOCK SYSTEM AND CAUSE THE MECHANICAL LINKAGE OF THE SYSTEM TO DISCONNECT.WHEN THIS OCCURS, THERE IS NO OVERT INDICATION TO AN OPERATOR THAT THE SYSTEM IS DEFEATED, AND AN INCREASED RISK OF VEHICLE ROLL-AWAY EXISTS.UNDER RECALL 04V021, DC WILL REPLACE DAMAGED SHIFT MECHANISMS, AND WILL INSTALL ON ALL VEHICLES A DEVICE WHICH INHIBITS THE OPERATOR?S ABILITY TO OVERCOME THE INTERLOCK AND DEFEAT THE SYSTEM.BEGINNING WITH MY 2000, DC INCORPORATED A BRAKE AND TRANSMISSION SHIFTER INTERLOCK (BTSI) SYSTEM INTO THE SUBJECT VEHICLES.INTRODUCTION OF BTSI INVOLVED DESIGN CHANGES TO THE SHIFT MECHANISM, ONE OF WHICH RESULTED IN REDUCED MECHANICAL ADVANTAGE (RMA) OF THE SHIFT BUTTON.THE RMA SHIFTER REQUIRES INCREASED FORCES TO OVERCOME THE INTERLOCK SYSTEM, MAKING THE SHIFTER LESS SUSCEPTIBLE TO DAMAGE.
PE03010 · Throttle Control Failure
Opened Feb 27, 2003 · Closed Sep 2, 2003
Status: closed (inferred from source dates) · Vehicle Speed Control; Vehicle Speed Control:accelerator Pedal; Vehicle Speed Control:cables; Vehicle Speed Control:linkages
BASED ON THE LOW FAILURE RATE, THE ABSENCE OF FAILURES OVER THE PAST YEAR, THE ABSENCE OF INJURIES, AND ODI'S FIELD INVESTIGATION OF INCIDENT VEHICLES, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. SEE ATTACHED REPORT FOR ADDITIONAL INFORMATION.
Additional source detail variants (4)
Vehicle Speed Control:accelerator Pedal
BASED ON THE LOW FAILURE RATE, THE ABSENCE OF FAILURES OVER THE PAST YEAR, THE ABSENCE OF INJURIES, AND ODI'S FIELD INVESTIGATION OF INCIDENT VEHICLES, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. SEE ATTACHED REPORT FOR ADDITIONAL INFORMATION.
Vehicle Speed Control:cables
BASED ON THE LOW FAILURE RATE, THE ABSENCE OF FAILURES OVER THE PAST YEAR, THE ABSENCE OF INJURIES, AND ODI'S FIELD INVESTIGATION OF INCIDENT VEHICLES, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. SEE ATTACHED REPORT FOR ADDITIONAL INFORMATION.
Vehicle Speed Control
BASED ON THE LOW FAILURE RATE, THE ABSENCE OF FAILURES OVER THE PAST YEAR, THE ABSENCE OF INJURIES, AND ODI'S FIELD INVESTIGATION OF INCIDENT VEHICLES, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. SEE ATTACHED REPORT FOR ADDITIONAL INFORMATION.
Vehicle Speed Control:linkages
BASED ON THE LOW FAILURE RATE, THE ABSENCE OF FAILURES OVER THE PAST YEAR, THE ABSENCE OF INJURIES, AND ODI'S FIELD INVESTIGATION OF INCIDENT VEHICLES, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. SEE ATTACHED REPORT FOR ADDITIONAL INFORMATION.
Illustration