IllustrationTHE DRIVE SIDE SLIDING DOOR THE DOOR WON'T UNLOCK.
2017 Dodge Grand Caravan
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2017 Dodge Grand Caravan do not stand out strongly from the model-year median of 284.
About this comparison →How this year compares
Owner complaints by model year
Compare all Grand Caravan years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
80–25K
3425–50K
7450–75K
4475–100K
16100–150K
2150K+
178 reports with mileage · 235 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 144 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Structure. Review the 95 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine. Review the 58 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
6 crash reports3 fire reports4 injury reports
Electrical System complaints
144 reportsTHE DRIVERS SIDE PASSENGER SLIDING DOOR IS STUCK IN THE LOCK POSITION. I CAN NOT MANUALLY UNLOCK IT, IT WILL NOT UNLOCK WITH MY KEY FOB OR THE BUTTONS ON THE INTERIOR. THE DOOR IS STUCK CLOSED AND LOCKED.
THE REAR SLIDING DOORS OPENED, I LOADED MY CHILD AND GEAR INTO THE VAN. WHEN WE REACHED OUR DESTINATION, THE DIES WOULD NOT UNLOCK OR OPEN, TRAPPING HER IN THE CAR. WE HAD TO HAVE HER CLIMB INTO THE PASSENGER SEAT AND EXIT THAT WAY. THE VAN WAS PARKED, ENGINE OFF.
TL* THE CONTACT OWNS A 2017 DODGE GRAND CARAVAN. THE CONTACT STATED THAT THE SLIDING DOOR FAILED TO OPEN FROM INSIDE OR OUTSIDE THE VEHICLE. THE VEHICLE WAS NOT TAKEN TO A DEALER. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT INFORMED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 77,724.
THE DRIVER'S SIDE SLIDING DOOR BECAME STUCK IN THE LOCK POSITION. IT WILL NOT UNLOCK MANUALLY OR ELECTRICALLY WITH THE POWER LOCK BUTTON OR KEY FOB. THE DOOR WILL NOT OPEN AT ALL.
IN DEC, THE ENGINE LIGHT CAME ON. THE CAR WOULD DO LIKE GOING OVER SPEED TACKS, SHAKE, WHEN IT WAS BETWEEN 45 TO 60 MPH. TOOK TO DEALERSHIP FOR READING, THEY COULDN'T GET A GOOD READING, IT STOPPED. THEN I PAID EXTRA FOR THEM TO TAKE TRANSMISSION PAN OFF. TOLD I NEED A NEW TRANSMISSION. THIS VEHICLE IS A 2017. THIS WAS DEC 2020.…
Read full complaint
IN DEC, THE ENGINE LIGHT CAME ON. THE CAR WOULD DO LIKE GOING OVER SPEED TACKS, SHAKE, WHEN IT WAS BETWEEN 45 TO 60 MPH. TOOK TO DEALERSHIP FOR READING, THEY COULDN'T GET A GOOD READING, IT STOPPED. THEN I PAID EXTRA FOR THEM TO TAKE TRANSMISSION PAN OFF. TOLD I NEED A NEW TRANSMISSION. THIS VEHICLE IS A 2017. THIS WAS DEC 2020. HAD TRANSMISSION DONE. ABOUT 3 WEEKS LATER, ENGINE LIGHT CAME ON AGAIN. WHEN I CAME BACK , 180 MILES TO VISIT FAMILY, I HAD IT LOOKED AT AGAIN. SHOWING 6 COIL, MISFIRE. THE CAR HAD 85000 MILES. HAD THE 6 COIL REPLACED, ALL PLUGS AND WIRES. LEFT, DROVE 180 MILES , NEXT DAY LIGHT CAME ON. I WASN'T DRIVING THE CAR MUCH AND WAS COMING BACK , ENGINE LIGHT ON, CAR RAN FIND. NEXT DAY, WAS AT A RED LIGHT, GAVE GAS AND THE CAR SPUTTER LIKE IT WASN'T GETTING GAS AND WANTED TO DIED. I PUSH ON THE GAS PADDLE AND HURRIED TO GET TO MY DAD'S. HAD A READING SAYING IT WAS CATALYTIC CONVERTED. AFTER THE WEEKEND I TOOK IT TO MUFFLER SHOP. SAID IT WASN'T GIVING THEM THAT READING, BUT MISFIRE AND 6 COIL. TOOK TO A MECHANIC, HE REPLACE 6 COIL AND SAID PLUGS WHERE GOOD, THAT THEY WERE NEW. BUT, I DID NEED AN AIR FILTER. GOT CAR. FEW HOURS LATER, ENGINE LIGHT WAS BACK ON. READING SHOWED COIL AND MISFIRE. GOING BACK TO MECHANIC, AGAIN. AFTER A RED LIGHT STOP, IT FELT LIKE IT WAS GOING TO DIED AS IF IT WASN'T GETTING GAS. I GAVE IT MORE GAS. THEY CHANGE EVERYTHING AGAIN, EVEN CROSS PARTS TO MAKE SURE. IT IDLES HARD IN PARK OR SITTING IN DRIVE. MORE GAS IT SEEMS TO DO OK. ALSO, ABOUT 6 MONTHS AFTER BUYING IT, HAD TO REPLACE BATTERY. 2013 WAS IN IT. SO, MUCH FOR WANTING TO RETIRE, THIS CAR HAS PUT ME INTO DEBT. I WISH I HAD STAYED WITH A TOYOTA. OWN 6 AND NEVER , COST ME MORE THAN REGULAR SERVICE. AND AGAIN, MISFIRE READING, COIL 6. WITHIN A MONTH ,TWICE ITS BEEN REPLACED AND PLUGS AND STILL BACK LIKE IT WAS. SINCE END OF DEC, BEEN IN SHOP 4 XS, SAME READING,SAME CRAP.
EVERYTIME I UNLOCK THE DOOR OR OPEN THE DOOR (SLIDING LEFT PASSENGER DOOR IN THE BACKSEAT) IT MAKES A LOUD BUZZING NOISE. IT SEEMS TO BE GETTING LOUDER AND LOUDER AND IS SO LOUD IT IS A DISTRACTION AND CAN BE HEARD FROM OUTSIDE OF THE VEHICLE.
2017 DODGE GRAND CARAVAN DRIVER SIDE DOOR JUST STOPPED OPERATING. CANNOT OPEN WITH KEY FOB OR MANUALLY INSIDE OR OUT. THIS POSES A SAFETY CONCERN AS YOU CANNOT GET IN OR OUR OF VEHICLE ON THAT SIDE IN THE BACK SEATS. THIS HAPPENED ALL OF A SUDDEN. JUST STOPPED WORKING AS SITTING IN DRIVEWAY.
FOR NO REASON MY RIGHT SLIDING DOOR STARTED MAKING A BUZZING SOUND WHEN UNLOCKING IT. SO, NOW EVERY TIME I OPEN OR UNLOCK THE DOOR I HEAR THIS VERY LOUD BUZZING SOUND. I HAVE READ THAT THIS IS VERY COMMON WITH DODGE GRAND CARAVANS. VEHICLE HAS NEVER BEEN IN AN ACCIDENT AND HAS NEVER BEEN HIT IN THE SIDE. THIS STARTED IN THE FALL…
Read full complaint
FOR NO REASON MY RIGHT SLIDING DOOR STARTED MAKING A BUZZING SOUND WHEN UNLOCKING IT. SO, NOW EVERY TIME I OPEN OR UNLOCK THE DOOR I HEAR THIS VERY LOUD BUZZING SOUND. I HAVE READ THAT THIS IS VERY COMMON WITH DODGE GRAND CARAVANS. VEHICLE HAS NEVER BEEN IN AN ACCIDENT AND HAS NEVER BEEN HIT IN THE SIDE. THIS STARTED IN THE FALL OF 2020 WHILE IN MY DRIVEWAY.
I OWN A 2017 DODGE GRAND CARAVAN GT AND MY REAR SLIDING DRIVER SIDE DOOR JUST STOPPED WORKING FOR NO REASON. IT IS LOCKED IN POSITION AND THE DOOR WON'T OPEN. I GOT IN THE VEHICLE ONE MORNING AND WHILE WARMING IT UP I WENT TO OPEN THE DOOR AND IT JUST WOULD NOT OPEN. SO I WENT TO THE DEALERSHIP THAT I PURCHASED THE VAN AT AND TH…
Read full complaint
I OWN A 2017 DODGE GRAND CARAVAN GT AND MY REAR SLIDING DRIVER SIDE DOOR JUST STOPPED WORKING FOR NO REASON. IT IS LOCKED IN POSITION AND THE DOOR WON'T OPEN. I GOT IN THE VEHICLE ONE MORNING AND WHILE WARMING IT UP I WENT TO OPEN THE DOOR AND IT JUST WOULD NOT OPEN. SO I WENT TO THE DEALERSHIP THAT I PURCHASED THE VAN AT AND THEY CHECKED IT OUT AND TOLD ME THAT THE LEFT SIDE SLIDING DOOR LOCK ACTUATOR IS BROKEN.
Official recalls
325V876000 · Equipment Adaptive/mobility:wheelchair Restraints/securement:latch/anchor:
Dec 17, 2025
Rollx Vans (Rollx) is recalling certain GMC Yukon, Sierra, Chevrolet Express 2500, Ford Transit, E-250, Toyota Sienna, Sienna Hybrid, Honda Odyssey, Chrysler Town and Country, Voyager, Pacifica, Dodge Grand Caravan, and Ram Promaster vehicles equipped with QRT-Deluxe and QRT-Max wheelchair restraints. Please refer to Rollx's recall report for specific model year information. The retractors may not lock, preventing the wheelchair from being properly secured.
Consequence & remedy
Consequence: An unsecured wheelchair can move during transit, increasing the risk of injury.
Remedy: Rollx will work with Q'Straint to inspect and replace the retractors as necessary, free of charge. Owner notification letters were mailed February 5, 2026. Owners may contact Rollx's customer service at 1-800-956-6668.
20V278000 · Fuel System, Gasoline:delivery:fuel Pump; Fuel System, Gasoline:storage:tank Assembly
May 15, 2020
Vantage Mobility International, LLC (Vantage) is recalling certain Vantage-modified 2016-2019 Dodge Grand Caravan vehicles. The fuel pump gasket may deteriorate, allowing fuel to leak.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source can increase the risk of a fire.
Remedy: Vantage will notify owners, and will provide parts and reimbursement to owners for repair facilities to replace the fuel tank gasket, free of charge. The recall began May 19, 2020. Owners may contact Vantage customer service at 1-800-488-9082.
Additional source detail variants (2)
Fuel System, Gasoline:delivery:fuel Pump
Vantage Mobility International, LLC (Vantage) is recalling certain Vantage-modified 2016-2019 Dodge Grand Caravan vehicles. The fuel pump gasket may deteriorate, allowing fuel to leak.
Consequence: A fuel leak in the presence of an ignition source can increase the risk of a fire.
Remedy: Vantage will notify owners, and will provide parts and reimbursement to owners for repair facilities to replace the fuel tank gasket, free of charge. The recall began May 19, 2020. Owners may contact Vantage customer service at 1-800-488-9082.
Fuel System, Gasoline:storage:tank Assembly
Vantage Mobility International, LLC (Vantage) is recalling certain Vantage-modified 2016-2019 Dodge Grand Caravan vehicles. The fuel pump gasket may deteriorate, allowing fuel to leak.
Consequence: A fuel leak in the presence of an ignition source can increase the risk of a fire.
Remedy: Vantage will notify owners, and will provide parts and reimbursement to owners for repair facilities to replace the fuel tank gasket, free of charge. The recall began May 19, 2020. Owners may contact Vantage customer service at 1-800-488-9082.
18V524000 · Electrical System:wiring:front Underhood
Aug 9, 2018
Chrysler (FCA US LLC) is recalling certain 2018 Jeep Renegade, Compass and Grand Cherokee, RAM 1500 and Promaster, Fiat 500x, Dodge Journey, Challenger, Charger and Durango and Chrysler 300x vehicles, 2017-2018 Jeep Wrangler, Dodge Grand Caravan and Chrysler Town and Country vehicles and 2018-2019 Jeep Cherokee and 2018 Chrysler Pacifica and Pacifica Hybrid vehicles. The powertrain control module may be equipped with a voltage regulator chip in the circuit board that may fail, causing a stall or a no start condition.
Consequence & remedy
Consequence: A vehicle stall can increase the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the powertrain control module, free of charge. The recall began October 2, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is U87.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE19014 · Active Head Rest Inadvertent Deployment
Opened Sep 9, 2019 · Closed Feb 25, 2026
Status: closed (inferred from source dates) · Seats; Seats:front Assembly:head Restraint
The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Seats
The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Seats:front Assembly:head Restraint
The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.