← New search

2012 Dodge Grand Caravan

Owner reports · Recalls · Investigations

More warning signs than most Grand Caravan years

Owner complaints for the 2012 Dodge Grand Caravan are substantially higher than the model-year median of 284.

About this comparison →

When problems were reported

Mileage at the reported incident

374 reports with mileage · 209 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Electrical System. Review the 336 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Engine. Review the 118 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Fuel/propulsion System. Review the 68 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

7 crash reports14 fire reports8 injury reports

What owners actually said

583 reports
91,000 miles · Apr 23, 2019
Electrical SystemElectronic Stability Control (esc)Power Train

MY CAR WAS IN FOR A RECALL 2 YEARS AGO WHERE MY CAR WOULD NOT SWITCH GEARS WHEN DRIVING. PRIOR I COMPLAINED SEVERAL TIMES BEFORE TO THE DEALERSHIP AND THEY SAID NOTHING WAS WRONG UNTIL I FOUND THE RECALL OR CONCERN ON LINE. MY CAR IS NOW SHOWING THE SAME SIGNS AS BEFORE ALONG WITH STALLING WHEN I HIT THE BREAK AND MAKING A TICK…

Read full complaint

MY CAR WAS IN FOR A RECALL 2 YEARS AGO WHERE MY CAR WOULD NOT SWITCH GEARS WHEN DRIVING. PRIOR I COMPLAINED SEVERAL TIMES BEFORE TO THE DEALERSHIP AND THEY SAID NOTHING WAS WRONG UNTIL I FOUND THE RECALL OR CONCERN ON LINE. MY CAR IS NOW SHOWING THE SAME SIGNS AS BEFORE ALONG WITH STALLING WHEN I HIT THE BREAK AND MAKING A TICKING NOISE. HOW DO I GET THIS RESOLVED SINCE OBVIOUSLY IT IS A MANUFACTURER ISSUE WITH THE CAR. THIS HAPPENS ON HIGHWAYS, CITY STREETS WHEN THE CAR IS IN MOTION.

NHTSA ODI #11203053

100,000 miles · Apr 22, 2019
Electrical SystemEngine

WE JUST BOUGHT A USED 2012 DODGE GRAND CARAVAN WITH ABOUT 99,000 MILES. WHEN I DROVE IT THE NEXT MORNING, I MADE A TURN ONTO THE ROAD WHEN IT COMPLETELY SHUT OFF. IT ALARMED ME. I TURNED THE KEY TO THE OFF POSITION AND THEN BACK ON AND IT STARTED UP AGAIN. I DIDN'T THINK MUCH OF IT UNTIL TODAY (2 DAYS LATER) WHEN MY HUSBAND…

Read full complaint

WE JUST BOUGHT A USED 2012 DODGE GRAND CARAVAN WITH ABOUT 99,000 MILES. WHEN I DROVE IT THE NEXT MORNING, I MADE A TURN ONTO THE ROAD WHEN IT COMPLETELY SHUT OFF. IT ALARMED ME. I TURNED THE KEY TO THE OFF POSITION AND THEN BACK ON AND IT STARTED UP AGAIN. I DIDN'T THINK MUCH OF IT UNTIL TODAY (2 DAYS LATER) WHEN MY HUSBAND CALLED ME CONCERNED THAT THE CAR STOPPED ON HIM AS HE WAS TURNING ONTO A DIFFERENT ROAD. HE HAD OUR 2 YR. OLD AND 7 MONTH OLD IN THE CAR, SO THAT REALLY CONCERNED ME FOR THEIR SAFETY.

NHTSA ODI #11202808

115,000 miles · Apr 17, 2019
Engine

TL* THE CONTACT OWNS A 2012 DODGE GRAND CARAVAN. WHEN THE CONTACT APPLIED THE BRAKES, THE VEHICLE STALLED. THE CONTACT SHIFTED INTO PARK AND RESTARTED THE VEHICLE. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, BUT A FAILURE COULD NOT BE FOUND. THE DEALER AND MANUFACTURER WERE NOT…

Read full complaint

TL* THE CONTACT OWNS A 2012 DODGE GRAND CARAVAN. WHEN THE CONTACT APPLIED THE BRAKES, THE VEHICLE STALLED. THE CONTACT SHIFTED INTO PARK AND RESTARTED THE VEHICLE. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, BUT A FAILURE COULD NOT BE FOUND. THE DEALER AND MANUFACTURER WERE NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 115,000.

NHTSA ODI #11197017

39,000 miles · Apr 14, 2019
Electrical System

WHENEVER I TURN ON THE HIGH BEAMS THE VEHICLE HAS ELECTRICAL PROBLEMS. IT IS LIKE WHEN THE VEHICLE IS INITIALLY TURNED ON AND IT GOES THROUGH A ELECTRICAL DIAGNOSTICS TEST . THE INDICATOR LIGHTS/SOUNDS FLASH ON THE DASHBOARD. AS SOON AS I TURN THE HIGH BEAMS OFF AGAIN THE VEHICLE WORKS PROPERLY. THERE DOESN'T SEEM TO AFFECT…

Read full complaint

WHENEVER I TURN ON THE HIGH BEAMS THE VEHICLE HAS ELECTRICAL PROBLEMS. IT IS LIKE WHEN THE VEHICLE IS INITIALLY TURNED ON AND IT GOES THROUGH A ELECTRICAL DIAGNOSTICS TEST . THE INDICATOR LIGHTS/SOUNDS FLASH ON THE DASHBOARD. AS SOON AS I TURN THE HIGH BEAMS OFF AGAIN THE VEHICLE WORKS PROPERLY. THERE DOESN'T SEEM TO AFFECT THE CONTROL OF THE VEHICLE, BUT WHEN THIS HAPPENS I IMMEDIATELY TURN THE HIGH BEAMS OFF BECAUSE I DO NOT KNOW IF THE ELECTRICAL PROBLEM WILL AFFECT THE STEERING AND OR BRAKING. SO ANY TRUE IMPACT IS NOT KNOWN. IT HAS BEEN HAPPENING FOR OVER A YEAR NOW. I JUST DON'T USE MY HIGH-BEAMS FOR FEAR OF HAVING AN ACCIDENT. THE ISSUE CAN BE REPLICATED (STILL HAPPENS TODAY).

NHTSA ODI #11196102

185,000 miles · Apr 12, 2019
Structure

DRIVER SIDE BACK DOOR QUIT WORKING AND CANNOT BE MANUALLY OVERRIDDEN. WE CANNOT OPEN IT AT ALL. HUGE SAFETY ISSUE IF WE ARE IN A WRECK AND THE PERSON IN THE BACK SEAT CANNOT EXIT THE VEHICLE. THIS IS A PROBLEM WITH MANY OF THESE VANS I HAVE NOTICED. THERE SHOULD BE A RECALL BEFORE SOMEONE DIES AS A RESULT!

NHTSA ODI #11195791

100,000 miles · Apr 3, 2019
Electrical System

VEHICLE ELECTRICAL SYSTEM CONTINUES TO GET WORSE. DRIVING DOWN THE HIGHWAY AT 70MPH ALL OF A SUDDEN THE VAN LOOSES ALL POWER AND KILLS THE ENGINE. HAVE TO PUT IT IN NEUTRAL IN ORDER TO RESTART. THIS IS A FAMILY VEHICLE AND I WILL NOT LOOSE MY FAMILY OVER A FAULTY ELECTRICAL SYSTEM. NUMEROUS TIMES PULLING OUT ONTO THE ROAD FROM A…

Read full complaint

VEHICLE ELECTRICAL SYSTEM CONTINUES TO GET WORSE. DRIVING DOWN THE HIGHWAY AT 70MPH ALL OF A SUDDEN THE VAN LOOSES ALL POWER AND KILLS THE ENGINE. HAVE TO PUT IT IN NEUTRAL IN ORDER TO RESTART. THIS IS A FAMILY VEHICLE AND I WILL NOT LOOSE MY FAMILY OVER A FAULTY ELECTRICAL SYSTEM. NUMEROUS TIMES PULLING OUT ONTO THE ROAD FROM A PARKING LOT THE VAN HAS STALLED AS I AM TURNING WITH ONCOMING SEMI TRUCKS NEARLY HITTING ME.

NHTSA ODI #11193594

110,000 miles · Mar 19, 2019
Structure

DRIVER SIDE SLIDING DOOR STUCK IN LOCKED POSITION RENDERING DOOR UNUSABLE. 03/12/2019. CANNOT GET IT TO UNLOCK MANUALLY OR WITH FOB. PASSENGER SLIDING DOOR WILL NOT LOCK MANUALLY OR WITH FOB, RENDERING A SECURITY ISSUE. 01/01/2018. I CAN NEVER FULLY LOCK MY VAN. WE JUST RISKED IT UNTIL THIS DOOR WENT ON US. AFTER RESEARCH FOUND …

Read full complaint

DRIVER SIDE SLIDING DOOR STUCK IN LOCKED POSITION RENDERING DOOR UNUSABLE. 03/12/2019. CANNOT GET IT TO UNLOCK MANUALLY OR WITH FOB. PASSENGER SLIDING DOOR WILL NOT LOCK MANUALLY OR WITH FOB, RENDERING A SECURITY ISSUE. 01/01/2018. I CAN NEVER FULLY LOCK MY VAN. WE JUST RISKED IT UNTIL THIS DOOR WENT ON US. AFTER RESEARCH FOUND MANY PEOPLE STRUGGLING WITH THIS ISSUE.

NHTSA ODI #11190118

105,000 miles · Mar 12, 2019
Electrical System

TL* THE CONTACT OWNS A 2012 DODGE GRAND CARAVAN. AFTER THE VEHICLE WAS REFUELED, THE ENGINE WOULD NOT IMMEDIATELY START. AFTER RESTARTING THE ENGINE, THE WINDSHIELD WIPERS ACTIVATED INDEPENDENTLY AND THE DOORS WOULD RANDOMLY LOCK. IN ADDITION, THE BACKUP CAMERA MALFUNCTIONED AND THE SCREEN TURNED BLACK. THE VEHICLE WAS TAKEN TO …

Read full complaint

TL* THE CONTACT OWNS A 2012 DODGE GRAND CARAVAN. AFTER THE VEHICLE WAS REFUELED, THE ENGINE WOULD NOT IMMEDIATELY START. AFTER RESTARTING THE ENGINE, THE WINDSHIELD WIPERS ACTIVATED INDEPENDENTLY AND THE DOORS WOULD RANDOMLY LOCK. IN ADDITION, THE BACKUP CAMERA MALFUNCTIONED AND THE SCREEN TURNED BLACK. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE TOTALLY INTEGRATED POWER MODULE WAS FAULTY AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER AND LOCAL DEALER WERE NOT NOTIFIED OF THE FAILURES. THE FAILURE MILEAGE WAS 105,000.

NHTSA ODI #11186104

28,800 miles · Mar 7, 2019
Service Brakes

TL* THE CONTACT OWNS A 2012 DODGE GRAND CARAVAN. WHILE DRIVING AT HIGH SPEEDS, THE BRAKE PEDAL PULSATED AND FAILED TO STOP THE VEHICLE WHEN IT WAS DEPRESSED. THE CONTACT INSPECTED THE BRAKES AND FOUND THEM TO BE HOT. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE DEALER AND MANUFACTU…

Read full complaint

TL* THE CONTACT OWNS A 2012 DODGE GRAND CARAVAN. WHILE DRIVING AT HIGH SPEEDS, THE BRAKE PEDAL PULSATED AND FAILED TO STOP THE VEHICLE WHEN IT WAS DEPRESSED. THE CONTACT INSPECTED THE BRAKES AND FOUND THEM TO BE HOT. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE DEALER AND MANUFACTURER WERE NOT CONTACTED. THE FAILURE MILEAGE WAS 28,800.

NHTSA ODI #11184838

Mileage unknown · Mar 4, 2019
Electrical System

MY VAN CONTINUOUSLY LOOSES ALL POWER WHILE DRIVING. IT HAPPENS ON REGULAR ROADS AND HIGHWAYS. I LOSE MY POWER STEERING, BREAKS...EVERYTHING. THIS HAS HAPPENED TO ME WHILE DRIVING STRAIGHT AS WELL AS DURING TURNS. IT DOESN'T MATTER THE TRAVELING SPEED. I HAVE HAD SOME VERY CLOSE ENCOUNTERS THAT COULD HAVE ENDED WITH A TRAGEDY. WH…

Read full complaint

MY VAN CONTINUOUSLY LOOSES ALL POWER WHILE DRIVING. IT HAPPENS ON REGULAR ROADS AND HIGHWAYS. I LOSE MY POWER STEERING, BREAKS...EVERYTHING. THIS HAS HAPPENED TO ME WHILE DRIVING STRAIGHT AS WELL AS DURING TURNS. IT DOESN'T MATTER THE TRAVELING SPEED. I HAVE HAD SOME VERY CLOSE ENCOUNTERS THAT COULD HAVE ENDED WITH A TRAGEDY. WHEN THE VAN LOSSES ALL POWER, I WILL HAVE TO ACT FAST AND GET THE VAN IN NEUTRAL. THE DASH WILL GO ON A RANDOM SERIES OF FLASHING AS IF POWER IS BEING RESTORED. I AM UNABLE TO TRY TO RESTART MY VAN UNTIL THE VAN IS READY FOR ME TO DO SO. I HAVE HAD SOME VERY CLOSE ENCOUNTERS ON THE HIGHWAY AND THE VANS ELECTRICAL SYSTEM MALFUNCTION AT 65MPH AND I CAN NOT DO ANYTHING UNTIL THE ELECTRICAL SYSTEMS RECYCLES ITS GLITCH AND ALWAYS ME TO TRY TO RESTART WHILE IN NEURAL. IN THE MEANTIME SEMI'S AND CARS ARE APPROACHING FAST AND I AM HELPLESS WITH ZERO CONTROL OVER THIS VAN. THIS NEEDS TO RECALLED AN CORRECTED BEFORE MY CHILDREN OR MYSELF ARE KILLED OVER THIS ELECTRICAL GLITCH.

NHTSA ODI #11184186

Official recalls

6

25V876000 · Equipment Adaptive/mobility:wheelchair Restraints/securement:latch/anchor:

Dec 17, 2025

Rollx Vans (Rollx) is recalling certain GMC Yukon, Sierra, Chevrolet Express 2500, Ford Transit, E-250, Toyota Sienna, Sienna Hybrid, Honda Odyssey, Chrysler Town and Country, Voyager, Pacifica, Dodge Grand Caravan, and Ram Promaster vehicles equipped with QRT-Deluxe and QRT-Max wheelchair restraints. Please refer to Rollx's recall report for specific model year information. The retractors may not lock, preventing the wheelchair from being properly secured.

Consequence & remedy

Consequence: An unsecured wheelchair can move during transit, increasing the risk of injury.

Remedy: Rollx will work with Q'Straint to inspect and replace the retractors as necessary, free of charge. Owner notification letters were mailed February 5, 2026. Owners may contact Rollx's customer service at 1-800-956-6668.

17V376000 · Air Bags:frontal

Jun 13, 2017

Chrysler (FCA US LLC) is recalling certain 2011-2012 Dodge Grand Caravan vehicles. In the affected vehicles, the driver's frontal air bag may unexpectedly deploy if the air bag wiring harness gets chafed within the steering wheel and short circuits.

Consequence & remedy

Consequence: Unexpected deployment of the driver's frontal air bag increases the risk of a crash or driver injury.

Remedy: Chrysler will notify owners, and dealers will inspect the air bag wiring within the steering wheel, replacing it if necessary. A protective cover will also be installed. These repairs will be made free of charge. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is T33.

14V234000 · Electrical System

May 7, 2014

Chrysler Group, LLC (Chrysler) is recalling certain model year 2010-2014 Chrysler Town and Country and Dodge Grand Caravan vehicles manufactured August 25, 2010, through October 31, 2013. The affected vehicles may experience overheating of the vent window switch in the driver's door armrest.

Consequence & remedy

Consequence: An overheated switch may result in a vehicle fire.

Remedy: Chrysler will notify owners, and dealers will replace the vent window switch with a newer version, free of charge. The owner notification letter was issued and the remedy campaign launched on on December 31, 2014. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is P25.

12V191000 · Equipment

May 2, 2012

CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2012 TOWN AND COUNTRY AND DODGE GRAND CARAVAN VEHICLES, MANUFACTURED FROM MARCH 9, 2012 THROUGH MARCH 12, 2012. SOME VEHICLES MAY BE EQUIPPED WITH A RIGHT SIDE LIFTGATE PINCH SENSOR THAT DOES NOT FUNCTION PROPERLY. AS A RESULT, INCREASED FORCE MAY BE REQUIRED IN ORDER TO STOP THE POWER LIFTGATE DURING FINAL CLOSING STAGES.

Consequence & remedy

Consequence: THE POWER LIFTGATE DOOR MAY CLOSE ON AN APPENDAGE, INCREASING THE RISK OF INJURY.

Remedy: CHRYSLER WILL NOTIFY OWNERS, AND DEALERS WILL INSPECT AND REPLACE THE RIGHT SIDE LIFTGATE PINCH SENSORS, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 18, 2012. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

12V141000 · Suspension:rear

Apr 3, 2012

CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2012 TOWN AND COUNTRY AND DODGE GRAND CARAVAN VEHICLES MANUFACTURED FROM NOVEMBER 15, 2011, THROUGH NOVEMBER 21, 2011. SOME VEHICLES MAY BE EQUIPPED WITH RIGHT REAR HUB AND BEARING ASSEMBLIES THAT WERE NOT FULLY MACHINED.

Consequence & remedy

Consequence: THIS COULD RESULT IN A DECREASE IN DURABILITY, WHICH MAY LEAD TO WHEEL SEPARATION, INCREASING THE RISK OF A CRASH.

Remedy: CHRYSLER WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE RIGHT REAR HUB AND BEARING ASSEMBLY, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 27, 2012. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

11V487000 · Engine And Engine Cooling

Sep 29, 2011

CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2012 CHRYSLER VEHICLES, INCLUDING 200 AND TOWN AND COUNTRY MODELS, DODGE VEHICLES, INCLUDING CHARGER, DURANGO, GRAND CARAVAN AND JOURNEY MODELS AND JEEP GRAND CHEROKEE VEHICLES MANUFACTURED FROM AUGUST 31, 2011, THROUGH SEPTEMBER 13, 2011, THAT ARE EQUIPPED WITH 3.6L ENGINES. THESE ENGINES MAY EXPERIENCE CONNECTING ROD BEARING FAILURE DUE TO DEBRIS INSIDE THE ENGINE BLOCK.

Consequence & remedy

Consequence: CONNECTING ROD FAILURE MAY LEAD TO ENGINE SEIZURE WHICH MAY INCREASE THE RISK OF A CRASH.

Remedy: CHRYSLER WILL NOTIFY OWNERS AND REPLACE THE ENGINE FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR ABOUT NOVEMBER 18, 2011. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

2

PE19014 · Active Head Rest Inadvertent Deployment

Opened Sep 9, 2019 · Closed Feb 25, 2026

Status: closed (inferred from source dates) · Seats; Seats:front Assembly:head Restraint

The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

Additional source detail variants (2)

Seats

The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

Seats:front Assembly:head Restraint

The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

DP14004 · Totally Integrated Power Module Failure

Opened Sep 25, 2014 · Closed Jul 24, 2015

Status: closed (inferred from source dates) · Electrical System

In a letter dated August 21, 2014, the Center for Auto Safety (CAS) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged failures associated with the Totally Integrated Power Module (TIPM) installed in Chrysler SUV?s, trucks, and vans beginning in the 2007 model year. The petitioner alleges that TIPM defects may result in engine stall, airbag non-deployment, failure of fuel pump shutoff resulting in unintended acceleration, fire, and other symptoms. On September 25, 2014, the Office of Defects Investigation (ODI) opened DP14-004 to evaluate the petition for a grant or deny decision. ODI analyzed complaint data provided by CAS as well as complaints submitted to ODI from consumers. In total, there were 296 complaints submitted by the petitioner in the original petition and five supplements, including 271 complaints related to the subject vehicles equipped with TIPM-7. Approximately 3 percent of CAS complaints are related to vehicles equipped with TIPM-6 and ODI?s review of these complaints did not identify any safety defect trends. ODI conducted a detailed review of complaints narratives submitted by CAS and consumers including careful analysis of vehicle repair histories, warranty claims obtained from the manufacturer and any available Customer Assistance Inquiry reports (CAIR). Analysis of the field data indicated that MY2011-2013 Jeep Grand Cherokee and Dodge Durango vehicles exhibited significantly higher complaint rates related to fuel pump relay (FPR) failures than other subject vehicles. In a September 3, 2014 letter to NHTSA, Chrysler submitted a Defect Information Report (DIR) identifying a defect in the FPR within the TIPM-7 which can result in a no start or stall condition in approximately 188,723 model year (MY) 2011 Jeep Grand Cherokee (WK) and Dodge Durango (WD) vehicles manufactured from January 5, 2010 through July 20, 2011 (14V-530).In a February 24, 2015 letter, Chrysler submitted a second DIR expanding the scope of the FPR defect condition to include an additional 338,216 MY 2012 through 2013 Jeep Grand Cherokee vehicles manufactured from September 17, 2010 through August 19, 2013 and MY 2012 through 2013 Dodge Durango vehicles manufactured from January 18, 2011 through August 19, 2013 (15V-115).ODI analysis of the CAS allegations of TIPM defects resulting in stall while driving, airbag non-deployment, unintended acceleration, fire and other faults identified a single defect condition related to 1 of over 60 different circuits in the TIPM assembly. The most common effect of this defect condition, related to the fuel pump relay, was a no-start concern, but it could also result in stall while driving (76 complaints). No valid evidence was presented in support of claims related to airbag non-deployment, unintended acceleration or fire resulting from TIPM faults and these claims were found to be wholly without merit based on review of the field data and design of the relevant systems and components.Except insofar as the petitioner's contentions relate to the defect condition addressed by the Chrysler recalls, the factual bases of the petitioner's contentions that any further investigation is necessary are unsupported. In our view, additional investigation is unlikely to result in a finding that a defect related to motor vehicle safety exists or a NHTSA order for the notification and remedy of a safety-related defect as alleged by the petitioner at the conclusion of the requested investigation. Therefore, in view of the need to allocate and prioritize NHTSA's limited resources to best accomplish the agency's safety mission, the petition is den