← New search

2012 Dodge Grand Caravan

Owner reports · Recalls · Investigations

More warning signs than most Grand Caravan years

Owner complaints for the 2012 Dodge Grand Caravan are substantially higher than the model-year median of 284.

About this comparison →

When problems were reported

Mileage at the reported incident

374 reports with mileage · 209 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Electrical System. Review the 336 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Engine. Review the 118 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Fuel/propulsion System. Review the 68 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

7 crash reports14 fire reports8 injury reports

What owners actually said

583 reports
135,000 miles · Jan 10, 2020
Air BagsElectrical System

TL* THE CONTACT STATED THEIR DAUGHTER OWNS A 2012 DODGE GRAND CARAVAN. THE CONTACT STATED THAT WHILE HER DAUGHTER WAS DRIVING AT VARIOUS SPEEDS WHEN THE VEHICLE'S IGNITION INDEPENDENTLY SHIFTED TO THE OFF POSITION WHICH CAUSED THE VEHICLE TO TURN OFF. THE VEHICLE WAS TAKEN TO A CERTIFIED MECHANIC WHO REPLACED THE ALTERNATOR, S…

Read full complaint

TL* THE CONTACT STATED THEIR DAUGHTER OWNS A 2012 DODGE GRAND CARAVAN. THE CONTACT STATED THAT WHILE HER DAUGHTER WAS DRIVING AT VARIOUS SPEEDS WHEN THE VEHICLE'S IGNITION INDEPENDENTLY SHIFTED TO THE OFF POSITION WHICH CAUSED THE VEHICLE TO TURN OFF. THE VEHICLE WAS TAKEN TO A CERTIFIED MECHANIC WHO REPLACED THE ALTERNATOR, STARTER, SENSOR REGULATING SYSTEM, AND BATTERY. THE FAILURE PERSISTED. THE CONTACT RETURNED THE VEHICLE TO THE CERTIFIED MECHANIC WHO DIAGNOSED THAT THE WIN MODULE FAILED AND NEEDED TO BE REPLACED. THE REPAIR WAS STILL PENDING. THE CONTACT WAS CONCERNED THAT THE FAILURE WAS DUE NHTSA CAMPAIGN NUMBER: 14V373000 (ELECTRICAL SYSTEM, AIRBAGS). THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE APPROXIMATE FAILURE MILEAGE WAS 135,000. THE VIN WAS NOT AVAILABLE.

NHTSA ODI #11298440

108,616 miles · Jan 9, 2020
Fuel/propulsion SystemPower Train

ON 1/6/2020 I STARTED MY VAN AND NOTICED IT SPUTTERED A LITTLE DURING STARTUP. ON MY WAY HOME, I STOPPED AT A STORE TO PICKUP A FEW THINGS. WHEN I TRIED TO START THE VAN AGAIN IT WOULD NOT START. I KNEW IT WASN'T THE BATTERY BECAUSE THE LIGHTS AND RADIO STILL WORKED. WHILE WAITING FOR A FRIEND TO PICK ME UP, I TRIED TO START IT …

Read full complaint

ON 1/6/2020 I STARTED MY VAN AND NOTICED IT SPUTTERED A LITTLE DURING STARTUP. ON MY WAY HOME, I STOPPED AT A STORE TO PICKUP A FEW THINGS. WHEN I TRIED TO START THE VAN AGAIN IT WOULD NOT START. I KNEW IT WASN'T THE BATTERY BECAUSE THE LIGHTS AND RADIO STILL WORKED. WHILE WAITING FOR A FRIEND TO PICK ME UP, I TRIED TO START IT AGAIN AND IT STARTED RIGHT UP. DROVE IT ACROSS THE STREET TO O'REILLYS TO HAVE BATTERY TESTED, JUST IN CASE. HAD TO START IT AGAIN. WOULDN'T START AGAIN. WAITED A MINUTE. TRIED AGAIN, IT SPUTTERED, I GAVE IT SOME GAS AND IT STARTED. EMPLOYEE WHO WAS ASSISTING HEARD A WHISTLING NOISE. SUGGESTING A VACUUM LEAK. CALLED MY MECHANIC. SCHEDULED APPT FOR 1/8/2020. TRIED TO START IT THE MORNING ON 1/8/2020. WOULD NOT START. MECHANIC HAD IT TOWED TO SHOP. HIS DIAGNOSIS SHOWED TPIM MODULE HAD FAILED. HE SAID HE SPOKE TO PARTS REP AT THE LITHIA DODGE AND THEY SAID THEY HAVE 14 VANS WITH SAME ISSUE WAITING FOR TPIM MODULES AND THE PART IS BACKORDERED FOR AT LEAST A MONTH. DODGE HAS NOT ISSUED A RECALL YET. I HAVE FOUND BLOG POSTS DATING BACK TO 2014 WITH CONSUMERS HAVING THE SAME ISSUE AND DODGE IS NOT ACCOMMODATING OWNERS WITH ANYTHING. COST OF TPIM MODULE IS $994. LABOR IS $360. I ALSO HAD TO HAVE MY FLEX PLATE REPLACED THE WEEK PRIOR BECAUSE IT CRACKED. MY MECHANIC SAID IT WAS DUE TO WEAK STEAL. SERVICE GUY AT DEALERSHIP, JASON SAID (ON 1/9/2020) SAID THIS WAS NOT UNCOMMON FOR THIS PART TO HAVE TO BE REPLACED ON THIS PARTICULAR VEHICLE. THIS REPAIR COST ME $789.95. I HAVE INCLUDED PHOTOS OF THE FLEX PLATE. I FEEL LIKE DODGE IS SIMPLY NOT TAKING RESPONSIBILITY FOR THIS PARTICULAR VEHICLE MODELS FAILURES BECAUSE THEY MASS PRODUCED IT AND IF THEY HAD TO ISSUE RECALLS FOR THE FLEX PLATE AND TPIM MODULE, IT WOULD COST THE COMPANY HUNDREDS OF THOUSANDS, IF NOT MILLIONS OF DOLLARS. BUT THESE VANS CARRY PRECIOUS CARGO, OUR CHILDREN!!!

NHTSA ODI #11298289

102,000 miles · Jan 8, 2020
Electrical SystemFuel/propulsion System

THE VEHICLE IS HAVING ISSUES WITH TIPM. THE VAN WILL NOT START DUE TO A DEFECT IN THE TIPM RELAY THAT WILL NOT ALLOW THE FUEL PUMP TO FUNCTION. THIS HAS BEEN NOTED ON SEVERAL DODGE AND CHRYSLER VEHICLES. MOST RECENTLY A LAWSUIT WAS SETTLED BUT ONLY HALF OF THE AFFECTED VEHICLES WERE COVERED. FROM A COLD START, THE ENGINE WILL …

Read full complaint

THE VEHICLE IS HAVING ISSUES WITH TIPM. THE VAN WILL NOT START DUE TO A DEFECT IN THE TIPM RELAY THAT WILL NOT ALLOW THE FUEL PUMP TO FUNCTION. THIS HAS BEEN NOTED ON SEVERAL DODGE AND CHRYSLER VEHICLES. MOST RECENTLY A LAWSUIT WAS SETTLED BUT ONLY HALF OF THE AFFECTED VEHICLES WERE COVERED. FROM A COLD START, THE ENGINE WILL TURN OVER BUT NOT START, THE IGNITION SEQUENCE WILL CONTINUE UNTIL YOU TURN IT OFF. IT IS CURRENTLY IN THE DRIVEWAY UNTIL I CAN REPLACE THE TIPM,

NHTSA ODI #11298041

128,000 miles · Jan 8, 2020
Unknown Or Other

TROUBLE STARTING, THEN STARTS RUNS GREAT, THEN RAMDOMLY DIES ! VERY DANGEROUS!!! HARDTO FEEL SAFE WHEN YOU HAVE NO IDEA WHEN THIS WILL HAPPEN. CURRANTLY AT DEALER TRYING FIGURE OUT ..... I CAN NO LONGER TAKE MY GRANDCHILDREN IN HIS VAN, FOR FEAR OF BEING KILLED !

NHTSA ODI #11297855

72,000 miles · Jan 2, 2020
Fuel/propulsion System

TL* THE CONTACT OWNS A 2012 DODGE GRAND CARAVAN. THE CONTACT STATED THAT THE VEHICLE WOULD SHUT OFF HOWEVER, THE FUEL PUMP RELAY WAS RUNNING WITH THE IGNITION TURNED OFF AS A NOISE WAS HEARD COMING FROM THE ENGINE COMPARTMENT. THE FAILURE WOULD DRAIN THE BATTERY AS THE BATTERY WAS REPLACED SEVERAL TIMES. THE VEHICLE WOULD ALSO S…

Read full complaint

TL* THE CONTACT OWNS A 2012 DODGE GRAND CARAVAN. THE CONTACT STATED THAT THE VEHICLE WOULD SHUT OFF HOWEVER, THE FUEL PUMP RELAY WAS RUNNING WITH THE IGNITION TURNED OFF AS A NOISE WAS HEARD COMING FROM THE ENGINE COMPARTMENT. THE FAILURE WOULD DRAIN THE BATTERY AS THE BATTERY WAS REPLACED SEVERAL TIMES. THE VEHICLE WOULD ALSO STALL WHEN DRIVING AT 60-65 MPH WITHOUT WARNING ON SEVERAL OCCASIONS. THE VEHICLE WAS TAKEN TO SUBURBAN CHRYSLER DODGE JEEP OF ANN ARBOR ( 3900 JACKSON RD, ANN ARBOR, MI 48103) WHOM ADVISED NO RECALLS ON THE VEHICLE. THE CONTACT STATED THAT AN INDEPENDENT MECHANIC ADVISED THAT THE TOTAL INTEGRATED POWER MODULE (TIPM) WOULD NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 72,000.

NHTSA ODI #11296656

450,000 miles · Dec 30, 2019
Electrical SystemPower Train

TL* THE CONTACT OWNS A 2012 DODGE GRAND CARAVAN. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE SHUT OFF WITHOUT WARNING. THE VEHICLE WAS TOWED TO THE CONTACT'S HOME AFTER THE LATEST FAILURE. THE CONTACT ALSO STATED THAT THE KEY FOB DID NOT COOPERATE WITH THE TRANSMITTER AND FAILED TO OPERATE. THE DEALER AND MANUFACTURER WERE NOT NOT…

Read full complaint

TL* THE CONTACT OWNS A 2012 DODGE GRAND CARAVAN. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE SHUT OFF WITHOUT WARNING. THE VEHICLE WAS TOWED TO THE CONTACT'S HOME AFTER THE LATEST FAILURE. THE CONTACT ALSO STATED THAT THE KEY FOB DID NOT COOPERATE WITH THE TRANSMITTER AND FAILED TO OPERATE. THE DEALER AND MANUFACTURER WERE NOT NOTIFIED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS 450,000.

NHTSA ODI #11292001

106,000 miles · Dec 28, 2019
Electrical SystemElectronic Stability Control (esc)Fuel/propulsion System

I HAVE PREVIOUSLY REPORTED AN ISSUE WITH MY VEHICLE. THE PROBLEM HAS PERSISTED. THE ISSUE AT HAND IS THE VEHICLE LOSES POWER WITHOUT WARNING WHILE DRIVING. IT HAS HAPPENED AT LOW SPEEDS (25 MPH), MIDDLE SPEEDS (45 MPH) AND HIGH SPEEDS (65-70 MPH). ALL WARNING LIGHTS ARE DISABLED WHEN THE EVENTS OCCUR, SO THERE IS NO WAY TO W…

Read full complaint

I HAVE PREVIOUSLY REPORTED AN ISSUE WITH MY VEHICLE. THE PROBLEM HAS PERSISTED. THE ISSUE AT HAND IS THE VEHICLE LOSES POWER WITHOUT WARNING WHILE DRIVING. IT HAS HAPPENED AT LOW SPEEDS (25 MPH), MIDDLE SPEEDS (45 MPH) AND HIGH SPEEDS (65-70 MPH). ALL WARNING LIGHTS ARE DISABLED WHEN THE EVENTS OCCUR, SO THERE IS NO WAY TO WARN OTHER VEHICLES OF THE ISSUES AT HAND, INCREASING THE PROBABILITY OF A CRASH. I HAVE TAKEN MY VEHICLE TO CUTTER DODGE IN HONOLULU ONLY TO HAVE BEEN TOLD THAT THE BATTERY CABLES WERE LOOSE ($150 SERVICE FEE) AND THAT THE PRIMER THAT IS INCLUDED WITH NEW BATTERIES TO APPLY ON THE BATTERY POSTS WAS SOMETHING THAT THEY'D NEVER SEEN BEFORE. THE PROBLEM HAS PERSISTED. I CURRENTLY HAVE MY VEHICLE AT A REPAIR SHOP WITH A BATTERY THAT WON'T HOLD A CHARGE BECAUSE THE INTERGRATED POWER MODULE IS MALFUNCTIONING. AS SEEN IS PREVIOUS COMPLAINTS, THIS ISSUE IS ONGOING WITH 2012 DODGE GRAND CARAVANS. THIS ISSUE PRESENTS A SIGNIFICANT SAFETY HAZARD AND SHOULD BE RECALLED. I WILL REPEAT THAT THE DRIVER HAS NO WARNING THAT THIS ISSUE WILL OCCUR AND IT PUTS LIVES IN DANGER. MY VEHICLE HAS LESS THAN 110,000 MILES AND IT BEGAN BEFORE REACHING 100,000 MILES. RECALL THIS PART BEFORE LIVES ARE LOST OR MAIMED.

NHTSA ODI #11291679

118,000 miles · Dec 27, 2019
Air Bags

THE AIR BAG LIGHT WOULD GO ON AND OFF AS I TURNED THE WHEEL STARTED IN 2016 AND NOW DEC 2019 ITS ON ALL THE TIME AND MY HORN DOESN'T WORK AND THERES A CRACK IN THE INTERIOR WHERE THE HORN IS.MY FEAR IS WHAT COULD HAPPEN NEXT COULD THE AIRBAG GO OFF WHILE IM DRIVING ALSO I NEED MY HORN WHERE I WAS OUT DRIVING 35 MINS AGO IN MY CI…

Read full complaint

THE AIR BAG LIGHT WOULD GO ON AND OFF AS I TURNED THE WHEEL STARTED IN 2016 AND NOW DEC 2019 ITS ON ALL THE TIME AND MY HORN DOESN'T WORK AND THERES A CRACK IN THE INTERIOR WHERE THE HORN IS.MY FEAR IS WHAT COULD HAPPEN NEXT COULD THE AIRBAG GO OFF WHILE IM DRIVING ALSO I NEED MY HORN WHERE I WAS OUT DRIVING 35 MINS AGO IN MY CITY A CAR ALMOST SIDE SWEEP ME I TRIED TO HONK THE HORN AND NOTICE I HAD NO HORN I HAD TO THINK FAST AND WENT HALF WAYS INTO THE ON COMING TRAFIC LANE THANKFULY THE LANE WAS EMPTY I DONT BELIEVE THAT THIS SHOULDNT HAVE BROKEN

NHTSA ODI #11291562

138,000 miles · Dec 21, 2019
Electrical System

WHILE DRIVING THE VEHICLE SHUT OFF ALL ELECTRICAL SYSTEMS GO DARK LOSE BREAKING STEERING. AFTER TURNING KEY SEVERAL TIMES THE ENGINE WILL RESTART. THIS HAS HAPPENED SEVERAL TIMES. ALSO WHILE TRYING TO START THE VEHICLE THE IGNITION KEY DOES NOT ALWAYS WORK HAVE TO TURN THE KEY MULTIPLE TIMES TO START VEHICLE.

NHTSA ODI #11290471

Mileage unknown · Dec 11, 2019
Electrical System

THIS ISSUE HAPPENED JUST THIS MORNING WHEN THE VAN WAS PARKED IN MY DRIVEWAY AND I ATTEMPTED TO OPEN THE SLIDING DOOR ON THE PASSENGER SIDE OF THE VAN. I HAVE ATTEMPTED TO OPEN IT MANY OTHER TIMES THIS MORNING WHILE PARKED AT MY OFFICE WITH NO SUCCESS. IT WORKED FINE LAST NIGHT. THE PASSENGER DOOR WILL NOT OPEN OR CLOSE EITHER M…

Read full complaint

THIS ISSUE HAPPENED JUST THIS MORNING WHEN THE VAN WAS PARKED IN MY DRIVEWAY AND I ATTEMPTED TO OPEN THE SLIDING DOOR ON THE PASSENGER SIDE OF THE VAN. I HAVE ATTEMPTED TO OPEN IT MANY OTHER TIMES THIS MORNING WHILE PARKED AT MY OFFICE WITH NO SUCCESS. IT WORKED FINE LAST NIGHT. THE PASSENGER DOOR WILL NOT OPEN OR CLOSE EITHER MANUALLY, USING THE AUTOMATIC SWITCH OR THE KEY FOB. IT MAKES A NOISE LIKE IT IS TRYING TO WORK, BUT THEN SHUTS OFF AFTER A FEW SECONDS. THIS IS AN OBVIOUS SAFETY ISSUE IF THERE WERE TO BE ANYBODY NEEDING TO GET OUT THAT DOOR IN CASE OF AN EMERGENCY. APPARENTLY (PER THE INTERNET) THIS IS A WELL KNOW ISSUE WITH DODGE.

NHTSA ODI #11288339

Official recalls

6

25V876000 · Equipment Adaptive/mobility:wheelchair Restraints/securement:latch/anchor:

Dec 17, 2025

Rollx Vans (Rollx) is recalling certain GMC Yukon, Sierra, Chevrolet Express 2500, Ford Transit, E-250, Toyota Sienna, Sienna Hybrid, Honda Odyssey, Chrysler Town and Country, Voyager, Pacifica, Dodge Grand Caravan, and Ram Promaster vehicles equipped with QRT-Deluxe and QRT-Max wheelchair restraints. Please refer to Rollx's recall report for specific model year information. The retractors may not lock, preventing the wheelchair from being properly secured.

Consequence & remedy

Consequence: An unsecured wheelchair can move during transit, increasing the risk of injury.

Remedy: Rollx will work with Q'Straint to inspect and replace the retractors as necessary, free of charge. Owner notification letters were mailed February 5, 2026. Owners may contact Rollx's customer service at 1-800-956-6668.

17V376000 · Air Bags:frontal

Jun 13, 2017

Chrysler (FCA US LLC) is recalling certain 2011-2012 Dodge Grand Caravan vehicles. In the affected vehicles, the driver's frontal air bag may unexpectedly deploy if the air bag wiring harness gets chafed within the steering wheel and short circuits.

Consequence & remedy

Consequence: Unexpected deployment of the driver's frontal air bag increases the risk of a crash or driver injury.

Remedy: Chrysler will notify owners, and dealers will inspect the air bag wiring within the steering wheel, replacing it if necessary. A protective cover will also be installed. These repairs will be made free of charge. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is T33.

14V234000 · Electrical System

May 7, 2014

Chrysler Group, LLC (Chrysler) is recalling certain model year 2010-2014 Chrysler Town and Country and Dodge Grand Caravan vehicles manufactured August 25, 2010, through October 31, 2013. The affected vehicles may experience overheating of the vent window switch in the driver's door armrest.

Consequence & remedy

Consequence: An overheated switch may result in a vehicle fire.

Remedy: Chrysler will notify owners, and dealers will replace the vent window switch with a newer version, free of charge. The owner notification letter was issued and the remedy campaign launched on on December 31, 2014. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is P25.

12V191000 · Equipment

May 2, 2012

CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2012 TOWN AND COUNTRY AND DODGE GRAND CARAVAN VEHICLES, MANUFACTURED FROM MARCH 9, 2012 THROUGH MARCH 12, 2012. SOME VEHICLES MAY BE EQUIPPED WITH A RIGHT SIDE LIFTGATE PINCH SENSOR THAT DOES NOT FUNCTION PROPERLY. AS A RESULT, INCREASED FORCE MAY BE REQUIRED IN ORDER TO STOP THE POWER LIFTGATE DURING FINAL CLOSING STAGES.

Consequence & remedy

Consequence: THE POWER LIFTGATE DOOR MAY CLOSE ON AN APPENDAGE, INCREASING THE RISK OF INJURY.

Remedy: CHRYSLER WILL NOTIFY OWNERS, AND DEALERS WILL INSPECT AND REPLACE THE RIGHT SIDE LIFTGATE PINCH SENSORS, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 18, 2012. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

12V141000 · Suspension:rear

Apr 3, 2012

CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2012 TOWN AND COUNTRY AND DODGE GRAND CARAVAN VEHICLES MANUFACTURED FROM NOVEMBER 15, 2011, THROUGH NOVEMBER 21, 2011. SOME VEHICLES MAY BE EQUIPPED WITH RIGHT REAR HUB AND BEARING ASSEMBLIES THAT WERE NOT FULLY MACHINED.

Consequence & remedy

Consequence: THIS COULD RESULT IN A DECREASE IN DURABILITY, WHICH MAY LEAD TO WHEEL SEPARATION, INCREASING THE RISK OF A CRASH.

Remedy: CHRYSLER WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE RIGHT REAR HUB AND BEARING ASSEMBLY, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 27, 2012. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

11V487000 · Engine And Engine Cooling

Sep 29, 2011

CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2012 CHRYSLER VEHICLES, INCLUDING 200 AND TOWN AND COUNTRY MODELS, DODGE VEHICLES, INCLUDING CHARGER, DURANGO, GRAND CARAVAN AND JOURNEY MODELS AND JEEP GRAND CHEROKEE VEHICLES MANUFACTURED FROM AUGUST 31, 2011, THROUGH SEPTEMBER 13, 2011, THAT ARE EQUIPPED WITH 3.6L ENGINES. THESE ENGINES MAY EXPERIENCE CONNECTING ROD BEARING FAILURE DUE TO DEBRIS INSIDE THE ENGINE BLOCK.

Consequence & remedy

Consequence: CONNECTING ROD FAILURE MAY LEAD TO ENGINE SEIZURE WHICH MAY INCREASE THE RISK OF A CRASH.

Remedy: CHRYSLER WILL NOTIFY OWNERS AND REPLACE THE ENGINE FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR ABOUT NOVEMBER 18, 2011. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

2

PE19014 · Active Head Rest Inadvertent Deployment

Opened Sep 9, 2019 · Closed Feb 25, 2026

Status: closed (inferred from source dates) · Seats; Seats:front Assembly:head Restraint

The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

Additional source detail variants (2)

Seats

The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

Seats:front Assembly:head Restraint

The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

DP14004 · Totally Integrated Power Module Failure

Opened Sep 25, 2014 · Closed Jul 24, 2015

Status: closed (inferred from source dates) · Electrical System

In a letter dated August 21, 2014, the Center for Auto Safety (CAS) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged failures associated with the Totally Integrated Power Module (TIPM) installed in Chrysler SUV?s, trucks, and vans beginning in the 2007 model year. The petitioner alleges that TIPM defects may result in engine stall, airbag non-deployment, failure of fuel pump shutoff resulting in unintended acceleration, fire, and other symptoms. On September 25, 2014, the Office of Defects Investigation (ODI) opened DP14-004 to evaluate the petition for a grant or deny decision. ODI analyzed complaint data provided by CAS as well as complaints submitted to ODI from consumers. In total, there were 296 complaints submitted by the petitioner in the original petition and five supplements, including 271 complaints related to the subject vehicles equipped with TIPM-7. Approximately 3 percent of CAS complaints are related to vehicles equipped with TIPM-6 and ODI?s review of these complaints did not identify any safety defect trends. ODI conducted a detailed review of complaints narratives submitted by CAS and consumers including careful analysis of vehicle repair histories, warranty claims obtained from the manufacturer and any available Customer Assistance Inquiry reports (CAIR). Analysis of the field data indicated that MY2011-2013 Jeep Grand Cherokee and Dodge Durango vehicles exhibited significantly higher complaint rates related to fuel pump relay (FPR) failures than other subject vehicles. In a September 3, 2014 letter to NHTSA, Chrysler submitted a Defect Information Report (DIR) identifying a defect in the FPR within the TIPM-7 which can result in a no start or stall condition in approximately 188,723 model year (MY) 2011 Jeep Grand Cherokee (WK) and Dodge Durango (WD) vehicles manufactured from January 5, 2010 through July 20, 2011 (14V-530).In a February 24, 2015 letter, Chrysler submitted a second DIR expanding the scope of the FPR defect condition to include an additional 338,216 MY 2012 through 2013 Jeep Grand Cherokee vehicles manufactured from September 17, 2010 through August 19, 2013 and MY 2012 through 2013 Dodge Durango vehicles manufactured from January 18, 2011 through August 19, 2013 (15V-115).ODI analysis of the CAS allegations of TIPM defects resulting in stall while driving, airbag non-deployment, unintended acceleration, fire and other faults identified a single defect condition related to 1 of over 60 different circuits in the TIPM assembly. The most common effect of this defect condition, related to the fuel pump relay, was a no-start concern, but it could also result in stall while driving (76 complaints). No valid evidence was presented in support of claims related to airbag non-deployment, unintended acceleration or fire resulting from TIPM faults and these claims were found to be wholly without merit based on review of the field data and design of the relevant systems and components.Except insofar as the petitioner's contentions relate to the defect condition addressed by the Chrysler recalls, the factual bases of the petitioner's contentions that any further investigation is necessary are unsupported. In our view, additional investigation is unlikely to result in a finding that a defect related to motor vehicle safety exists or a NHTSA order for the notification and remedy of a safety-related defect as alleged by the petitioner at the conclusion of the requested investigation. Therefore, in view of the need to allocate and prioritize NHTSA's limited resources to best accomplish the agency's safety mission, the petition is den