← New search

2012 Dodge Grand Caravan

Owner reports · Recalls · Investigations

More warning signs than most Grand Caravan years

Owner complaints for the 2012 Dodge Grand Caravan are substantially higher than the model-year median of 284.

About this comparison →

When problems were reported

Mileage at the reported incident

374 reports with mileage · 209 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Electrical System. Review the 336 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Engine. Review the 118 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Fuel/propulsion System. Review the 68 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

7 crash reports14 fire reports8 injury reports

Power Train complaints

48 reports
Clear category filter
60,000 miles · Jan 26, 2017
Electrical SystemPower Train

VEHICLE SHUTS OFF DURING DRIVING. DODGE DID I NEED A WHOLE NEW IGNITION SETUP. OTHER 2012 DODGE CARAVANS HAVE THIS AS A RECALL. VEHICLE ALSO WON'T SWITCH GEARS AND RPMS GO UP TO 6000 AT TIMES. *TR

NHTSA ODI #10947722

60,525 miles · Sep 1, 2016
Power Train

AS I WAS DRIVING HOME ON WEDNESDAY, AUGUST 24, 2016 AT APPROXIMATELY 4:45 PM. AS I WAS DRIVING SOUTH ON FAIRVIEW IN DOWNERS GROVE, IL MY VEHICLE STARTED TO JERK AND AT ONE POINT, I THOUGHT SOMEONE HIT THE TRUNK. I BEGAN TO WORRY AS THERE WAS A LOT OF CARS IN FRONT AND NEXT TO ME. THE VEHICLE'S RPM STARTED TO GO CRAZY AND THEN…

Read full complaint

AS I WAS DRIVING HOME ON WEDNESDAY, AUGUST 24, 2016 AT APPROXIMATELY 4:45 PM. AS I WAS DRIVING SOUTH ON FAIRVIEW IN DOWNERS GROVE, IL MY VEHICLE STARTED TO JERK AND AT ONE POINT, I THOUGHT SOMEONE HIT THE TRUNK. I BEGAN TO WORRY AS THERE WAS A LOT OF CARS IN FRONT AND NEXT TO ME. THE VEHICLE'S RPM STARTED TO GO CRAZY AND THEN AS I PRESSED THE GAS THE CAR WAS NOT MOVING, IT WAS EXTREMELY DIFFICULT FOR ME AS I WAS ALONE. I THEN PUT MY HAZARDS ON BECAUSE I HAD TO TRY TO GET TO A SAFE PLACE. AFTER ABOUT 30 MINUTES, I MANAGED TO MOVE MY CAR INTO THE PARKING LOT OF A CVS BUT NOT BEFORE IT SHUT OFF ON ME. I HAD TO WAIT FOR 1 HOUR BEFORE THE TOW TRUCK CAME AND HE TOOK ME TO THE JACK PHELAN DEALERSHIP IN COUNTRYSIDE, IL. MY CAR HAS BEEN THERE SINCE THEN. I HAVE A RENTAL FOR 7 DAYS BUT AFTER THAT I HAVE NO CAR. I JUST WANT TO KNOW WHAT CHRYSLER CAN DO FOR ME AS I AM NOT ABLE TO HAVE MY CAR BECAUSE OF THE FAULTY TRANSMISSION. THE DEALERSHIP COMMUNICATED TO US THAT THIS TRANSMISSION SHOULD HAVE BEEN RECALLED AND THEY WILL DO WHAT THEY CAN TO REMOVE THEM FROM THE SHELVES. AT THIS MOMENT, I HAVE NO DOCUMENTATION BUT THE DEALERSHIP CAN BE CONTACTED, JACK PHELAN DODGE, 5859 S. LAGRANGE ROAD, COUNTRYSIDE, IL 60525 (708) 352-5300. I WOULD LIKE SOMEONE TO CONTACT ME AND I WILL DEFINITELY BE CONTACTING CHRYSLER CORPORATION TO SEE IF THERE IS ANYTHING THEY CAN DO FOR ME.

NHTSA ODI #10903064

120,000 miles · Aug 27, 2016
Power Train

I HAD BEEN HAVING PROBLEMS WITH THE KEYLESS ENTRY NOT ALLOWING ME TO UNLOCK THE VEHICLE MULTIPLE TIMES. THEN ON A FEW OCCASIONS THE VEHICLE WOULDN'T START AND ALL THE LIGHTS WOULD FLASH ON THE DASHBOARD. THERE WAS NOTHING WRONG WITH THE BATTERY BECAUSE I REPLACED THAT SEVERAL TIMES IN THE FIRST MONTHS OF FINANCING THE VEHICLE.…

Read full complaint

I HAD BEEN HAVING PROBLEMS WITH THE KEYLESS ENTRY NOT ALLOWING ME TO UNLOCK THE VEHICLE MULTIPLE TIMES. THEN ON A FEW OCCASIONS THE VEHICLE WOULDN'T START AND ALL THE LIGHTS WOULD FLASH ON THE DASHBOARD. THERE WAS NOTHING WRONG WITH THE BATTERY BECAUSE I REPLACED THAT SEVERAL TIMES IN THE FIRST MONTHS OF FINANCING THE VEHICLE. THE LAST INCIDENT WHEN IT STOPPED WORKING I WAS DRIVING AND THE VEHICLE BEGAN TO SLOW DOWN ON ITS OWN, ALL THE LIGHTS ON THE DASHBOARD FLASHED, THE VEHICLE POWERED OFF, I COULDN'T SWITCH THE GEARS, THE BRAKES LOCKED, AND THE STEERING WHEEL LOCKED AS WELL. LUCKILY, THIS DIDN'T CAUSE AN ACCIDENT BUT THE VEHICLE DID STOP. I HAD IT TOWED TO THE DEALER WHO INFORMED ME THAT THE KEY FOB AND POWERTRAIN CONTROL MODULE WAS NOT WORKING. I LOOKED IT AND APPARENTLY THIS HAS ALREADY BEEN REPAIRED IN JAN 2013 BEFORE I FINANCED THE CAR AND THE VEHICLE MUST HAVE STILL BEEN HAVING ISSUES BECAUSE I HAVE HAD CONTINUAL PROBLEMS WITH IT.

NHTSA ODI #10901977

100,000 miles · Apr 19, 2016
Power Train

OVER THE PAST 5 MONTHS, VEHICLE DISENGAGING FROM PARK AND INTO DRIVE IS CLUNKY. RECENTLY ON A HIGHWAY (VEHICLE IN MOTION WITH CHILDREN IN THE CAR), TRANSMISSION WOULD NOT SHIFT OUT OF 2ND/3RD. VEHICLE WAS PARKED THE REST OF THE DAY. NEXT MORNING IT SEEMED TO DRIVE FINE. LATER SAME DAY SHIFTING ISSUE RETURNED. TOOK IT TO A TRANSM…

Read full complaint

OVER THE PAST 5 MONTHS, VEHICLE DISENGAGING FROM PARK AND INTO DRIVE IS CLUNKY. RECENTLY ON A HIGHWAY (VEHICLE IN MOTION WITH CHILDREN IN THE CAR), TRANSMISSION WOULD NOT SHIFT OUT OF 2ND/3RD. VEHICLE WAS PARKED THE REST OF THE DAY. NEXT MORNING IT SEEMED TO DRIVE FINE. LATER SAME DAY SHIFTING ISSUE RETURNED. TOOK IT TO A TRANSMISSION SPECIALIST FOR DIAGNOSTIC. TOOK IT TO THE DEALER. VEHICLE IS JUST OVER 100K MILES (NO LONGER UNDER WARRANTY). THE SOLENOID PACK WAS REPLACED. VEHICLE WAS PURCHASED NEW WITH 14 MILES. PCM WAS RECALLED AT 24K. LEFT SIDE CYLINDER HEAD REPLACED AT 33K.

NHTSA ODI #10860296

70,000 miles · Feb 22, 2016
Power Train

TRANSMISSION COOLER LINE LEAKING AT 70,000 MILE. LEAK CAUSED FLUID TO GET ALL OVER ENGINE COMPARTMENT

NHTSA ODI #10837532

53,000 miles · Feb 5, 2016
Power Train

TL* THE CONTACT OWNS A 2012 DODGE GRAND CARAVAN. WHILE DRIVING AT ANY SPEED, THE VEHICLE JERKED AND SLAMMED HARD WHEN PLACED IN GEAR. FOR THE SAME FAILURE, A LOCAL DEALER REBUILT THE TRANSMISSION ON AUGUST 4, 2014. THE FAILURE RECURRED AFTER 4,000 MILES. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND REFERRED THE CONTACT BAC…

Read full complaint

TL* THE CONTACT OWNS A 2012 DODGE GRAND CARAVAN. WHILE DRIVING AT ANY SPEED, THE VEHICLE JERKED AND SLAMMED HARD WHEN PLACED IN GEAR. FOR THE SAME FAILURE, A LOCAL DEALER REBUILT THE TRANSMISSION ON AUGUST 4, 2014. THE FAILURE RECURRED AFTER 4,000 MILES. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND REFERRED THE CONTACT BACK TO THE DEALER. THE CONTACT STATED THAT THE DEALER WAS UNABLE TO DIAGNOSE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 53,000. UPDATED 04/07/16*LJ *JS

NHTSA ODI #10824447

325 miles · Nov 26, 2014
EnginePower TrainSteering

1. VEHICLE DRAGS TO THE RIGHT. 2. ENGINE LOSES POWER AT TIMES 45MPH AND OR 60 MPH 3. IT SEEMS THERE IS GEAR SHIFT PROBLEM BASED ON ITEM 2. STEVENS CREEK CHRYSLER JEEP DODGE, 4100 STEVENS CREEK BLVD, SAN JOSE, CA 95129 I HAVE TAKEN IT TO DEALERSHIP SEVERAL TIMES AND LATEST BEING: 8/20/2014 INVOICE #184949 MILEAGE :6669 TH…

Read full complaint

1. VEHICLE DRAGS TO THE RIGHT. 2. ENGINE LOSES POWER AT TIMES 45MPH AND OR 60 MPH 3. IT SEEMS THERE IS GEAR SHIFT PROBLEM BASED ON ITEM 2. STEVENS CREEK CHRYSLER JEEP DODGE, 4100 STEVENS CREEK BLVD, SAN JOSE, CA 95129 I HAVE TAKEN IT TO DEALERSHIP SEVERAL TIMES AND LATEST BEING: 8/20/2014 INVOICE #184949 MILEAGE :6669 THEY DID FIND THE PROBLEM AND DID SUSPENSION REPAIRS. THEY SAY THEY WERE UNABLE DUPLICATE PROBLEM OF LOSING POWER - IT SEEMS THEY DID NOT DO TEST DRIVE AT ALL OBVIOUSLY FROM MILEAGE RECORD! I TOOK IT AGAIN WITH SAME COMPLAINT ON 11/12/2014 AND THEY SAY EVERYTHING LOOKS OKAY IT IS JUST ROAD CROWNING ON THE RIGHT LANE CAUSES IT. AGAIN THEY COULD NOT FIND OR DUPLICATE LOSS OF POWER AND SHIFTING. I AM TERRIBLY AFRAID OF DRIVING THIS VEHICLE WITH FAMILY AND FRIENDS EVEN THOUGH MILEAGE IS LESS THAN 9000 MILES IN 3 YEARS. WARRANTY EXPIRES ON 7/21/2015. PLEASE HELP ME TO RESOLVE THESE ISSUES AND SAFETY OF DRIVER AND PASSENGERS. *TR

NHTSA ODI #10661118

11,720 miles · Nov 20, 2014
Electrical SystemPower TrainVisibility/wiper

DOCUMENTED SEVERAL TIMES SINCE 2013, THIS VAN HAS HAD PROBLEMS WITH THE FOLLOWING: SPEEDOMETER DOES NOT READ, GAUGES DO NOT READ, WINDSHIELD WIPERS TURN ON, ALL WARNING LIGHTS READ, HEADLIGHTS DO NOT WORK, A/C DOES NOT WORK; THEN ALL TURN OFF RANDOMLY AND INTERMITTENTLY TURN BACK ON AND OFF AGAIN. IN MAY 2014, THE VAN HAD TRANSM…

Read full complaint

DOCUMENTED SEVERAL TIMES SINCE 2013, THIS VAN HAS HAD PROBLEMS WITH THE FOLLOWING: SPEEDOMETER DOES NOT READ, GAUGES DO NOT READ, WINDSHIELD WIPERS TURN ON, ALL WARNING LIGHTS READ, HEADLIGHTS DO NOT WORK, A/C DOES NOT WORK; THEN ALL TURN OFF RANDOMLY AND INTERMITTENTLY TURN BACK ON AND OFF AGAIN. IN MAY 2014, THE VAN HAD TRANSMISSION ISSUES WHERE IT WOULD NOT SHIFT OUT OF LOW GEAR AND DRIVER HAD TO TWICE SHIFT INTO NEUTRAL AND BACK INTO DRIVE TO SHIFT PROPERLY. 6 REPAIR ATTEMPTS WERE MADE ON THE VAN BEGINNING IN MAY 2013 AND ENDING IN JULY 2013 WITH NO SUCCESS ON REPAIRS. THE VAN WAS STILL UNDER WARRANTY SO REPAIR WAS FREE OF CHARGE. REPLACEMENT OF THE TIPM WAS TWICE ATTEMPTED BUT FAILED BECAUSE OF THE FAULTY 2012 TIPMS. THIS VAN IS USED BY RSVP, A FEDERALLY FUNDED NATIONWIDE NON-PROFIT, TO TRANSPORT SENIOR VOLUNTEERS TO THEIR WORK SITES. THIS VAN HAS THE POTENTIAL TO PUT PEOPLE INTO A DANGEROUS CRASH AND NEEDS CHRYSLER TO REPAIR THE TIPMS IMMEDIATELY. *TR

NHTSA ODI #10659738

18,515 miles · Aug 26, 2014
Power Train

EVERY MORNING I GET INTO MY VEHICLE, START IT UP AND PUT THE VEHICLE FROM PARK TO DRIVE IT GOES INTO DRIVE ROUGH..THE VEHICLE HAS BEEN AT THE DODGE SERVICE CENTER ON THREE OCCASIONS TO TRY AND FIX THIS PROBLEM, THE FOURTH SERVICE APPT IS SCHEDULED FOR THIS THURSDAY, EACH TIME I WAS TOLD NOTHING WAS WRONG WITH THE VEHICLE...I TOO…

Read full complaint

EVERY MORNING I GET INTO MY VEHICLE, START IT UP AND PUT THE VEHICLE FROM PARK TO DRIVE IT GOES INTO DRIVE ROUGH..THE VEHICLE HAS BEEN AT THE DODGE SERVICE CENTER ON THREE OCCASIONS TO TRY AND FIX THIS PROBLEM, THE FOURTH SERVICE APPT IS SCHEDULED FOR THIS THURSDAY, EACH TIME I WAS TOLD NOTHING WAS WRONG WITH THE VEHICLE...I TOOK THE VEHICLE TO A PRIVATE MECHANIC TO BE INSPECTED AUG 1ST, WAS TOLD BY THE MECHANIC THAT THERE IS SOMETHING WRONG WITH THE TRANSMISSION, IT IS CHANGING GEARS ROUGHLY...I HAVE 18,515 MILES ON THE VEHICLE AND HAVE HAD THIS PROBLEM SINCE I BOUGHT IT IN 2012 BRAND NEW. *TR

NHTSA ODI #10628443

55,000 miles · Apr 28, 2014
EnginePower TrainVehicle Speed Control

ENGINE RUNS VERY ROUGH, IDLES LOW ALMOST DIES AT INTERSECTIONS. DOES NOT HAVE POWER WHEN GAS PEDAL IS PUSHED DOWN, LOOSES POWER WHILE DRIVING AS WELL. THESE VANS HAVE SOMETHING MAJORLY WRONG WITH THE ENGINES AND TRANSMISSIONS. DODGE NEEDS TO INVESTIGATE AND RECALL/REPAIR THESE VANS. THEY ARE HAZARDOUS. I CANNOT WAIT TO BE…

Read full complaint

ENGINE RUNS VERY ROUGH, IDLES LOW ALMOST DIES AT INTERSECTIONS. DOES NOT HAVE POWER WHEN GAS PEDAL IS PUSHED DOWN, LOOSES POWER WHILE DRIVING AS WELL. THESE VANS HAVE SOMETHING MAJORLY WRONG WITH THE ENGINES AND TRANSMISSIONS. DODGE NEEDS TO INVESTIGATE AND RECALL/REPAIR THESE VANS. THEY ARE HAZARDOUS. I CANNOT WAIT TO BE RID OF MINE BEFORE SOMETHING HAPPENS TO ME AND MY FOUR CHILDREN. DOESN'T SOUND LIKE I'M THE ONLY ONE WITH THE PROBLEMS EITHER. MAYBE DODGE/CHRYSLER IS GOING TO BE LIKE GM AND LET PEOPLE DIE BEFORE REPAIR A MINOR PART. VERY DISAPPOINTED IN THIS VEHICLE. IT WILL BE MY LAST DODGE PURCHASE. *JS

NHTSA ODI #10585201

Official recalls

6

25V876000 · Equipment Adaptive/mobility:wheelchair Restraints/securement:latch/anchor:

Dec 17, 2025

Rollx Vans (Rollx) is recalling certain GMC Yukon, Sierra, Chevrolet Express 2500, Ford Transit, E-250, Toyota Sienna, Sienna Hybrid, Honda Odyssey, Chrysler Town and Country, Voyager, Pacifica, Dodge Grand Caravan, and Ram Promaster vehicles equipped with QRT-Deluxe and QRT-Max wheelchair restraints. Please refer to Rollx's recall report for specific model year information. The retractors may not lock, preventing the wheelchair from being properly secured.

Consequence & remedy

Consequence: An unsecured wheelchair can move during transit, increasing the risk of injury.

Remedy: Rollx will work with Q'Straint to inspect and replace the retractors as necessary, free of charge. Owner notification letters were mailed February 5, 2026. Owners may contact Rollx's customer service at 1-800-956-6668.

17V376000 · Air Bags:frontal

Jun 13, 2017

Chrysler (FCA US LLC) is recalling certain 2011-2012 Dodge Grand Caravan vehicles. In the affected vehicles, the driver's frontal air bag may unexpectedly deploy if the air bag wiring harness gets chafed within the steering wheel and short circuits.

Consequence & remedy

Consequence: Unexpected deployment of the driver's frontal air bag increases the risk of a crash or driver injury.

Remedy: Chrysler will notify owners, and dealers will inspect the air bag wiring within the steering wheel, replacing it if necessary. A protective cover will also be installed. These repairs will be made free of charge. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is T33.

14V234000 · Electrical System

May 7, 2014

Chrysler Group, LLC (Chrysler) is recalling certain model year 2010-2014 Chrysler Town and Country and Dodge Grand Caravan vehicles manufactured August 25, 2010, through October 31, 2013. The affected vehicles may experience overheating of the vent window switch in the driver's door armrest.

Consequence & remedy

Consequence: An overheated switch may result in a vehicle fire.

Remedy: Chrysler will notify owners, and dealers will replace the vent window switch with a newer version, free of charge. The owner notification letter was issued and the remedy campaign launched on on December 31, 2014. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is P25.

12V191000 · Equipment

May 2, 2012

CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2012 TOWN AND COUNTRY AND DODGE GRAND CARAVAN VEHICLES, MANUFACTURED FROM MARCH 9, 2012 THROUGH MARCH 12, 2012. SOME VEHICLES MAY BE EQUIPPED WITH A RIGHT SIDE LIFTGATE PINCH SENSOR THAT DOES NOT FUNCTION PROPERLY. AS A RESULT, INCREASED FORCE MAY BE REQUIRED IN ORDER TO STOP THE POWER LIFTGATE DURING FINAL CLOSING STAGES.

Consequence & remedy

Consequence: THE POWER LIFTGATE DOOR MAY CLOSE ON AN APPENDAGE, INCREASING THE RISK OF INJURY.

Remedy: CHRYSLER WILL NOTIFY OWNERS, AND DEALERS WILL INSPECT AND REPLACE THE RIGHT SIDE LIFTGATE PINCH SENSORS, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 18, 2012. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

12V141000 · Suspension:rear

Apr 3, 2012

CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2012 TOWN AND COUNTRY AND DODGE GRAND CARAVAN VEHICLES MANUFACTURED FROM NOVEMBER 15, 2011, THROUGH NOVEMBER 21, 2011. SOME VEHICLES MAY BE EQUIPPED WITH RIGHT REAR HUB AND BEARING ASSEMBLIES THAT WERE NOT FULLY MACHINED.

Consequence & remedy

Consequence: THIS COULD RESULT IN A DECREASE IN DURABILITY, WHICH MAY LEAD TO WHEEL SEPARATION, INCREASING THE RISK OF A CRASH.

Remedy: CHRYSLER WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE RIGHT REAR HUB AND BEARING ASSEMBLY, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 27, 2012. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

11V487000 · Engine And Engine Cooling

Sep 29, 2011

CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2012 CHRYSLER VEHICLES, INCLUDING 200 AND TOWN AND COUNTRY MODELS, DODGE VEHICLES, INCLUDING CHARGER, DURANGO, GRAND CARAVAN AND JOURNEY MODELS AND JEEP GRAND CHEROKEE VEHICLES MANUFACTURED FROM AUGUST 31, 2011, THROUGH SEPTEMBER 13, 2011, THAT ARE EQUIPPED WITH 3.6L ENGINES. THESE ENGINES MAY EXPERIENCE CONNECTING ROD BEARING FAILURE DUE TO DEBRIS INSIDE THE ENGINE BLOCK.

Consequence & remedy

Consequence: CONNECTING ROD FAILURE MAY LEAD TO ENGINE SEIZURE WHICH MAY INCREASE THE RISK OF A CRASH.

Remedy: CHRYSLER WILL NOTIFY OWNERS AND REPLACE THE ENGINE FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR ABOUT NOVEMBER 18, 2011. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

2

PE19014 · Active Head Rest Inadvertent Deployment

Opened Sep 9, 2019 · Closed Feb 25, 2026

Status: closed (inferred from source dates) · Seats; Seats:front Assembly:head Restraint

The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

Additional source detail variants (2)

Seats

The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

Seats:front Assembly:head Restraint

The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

DP14004 · Totally Integrated Power Module Failure

Opened Sep 25, 2014 · Closed Jul 24, 2015

Status: closed (inferred from source dates) · Electrical System

In a letter dated August 21, 2014, the Center for Auto Safety (CAS) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged failures associated with the Totally Integrated Power Module (TIPM) installed in Chrysler SUV?s, trucks, and vans beginning in the 2007 model year. The petitioner alleges that TIPM defects may result in engine stall, airbag non-deployment, failure of fuel pump shutoff resulting in unintended acceleration, fire, and other symptoms. On September 25, 2014, the Office of Defects Investigation (ODI) opened DP14-004 to evaluate the petition for a grant or deny decision. ODI analyzed complaint data provided by CAS as well as complaints submitted to ODI from consumers. In total, there were 296 complaints submitted by the petitioner in the original petition and five supplements, including 271 complaints related to the subject vehicles equipped with TIPM-7. Approximately 3 percent of CAS complaints are related to vehicles equipped with TIPM-6 and ODI?s review of these complaints did not identify any safety defect trends. ODI conducted a detailed review of complaints narratives submitted by CAS and consumers including careful analysis of vehicle repair histories, warranty claims obtained from the manufacturer and any available Customer Assistance Inquiry reports (CAIR). Analysis of the field data indicated that MY2011-2013 Jeep Grand Cherokee and Dodge Durango vehicles exhibited significantly higher complaint rates related to fuel pump relay (FPR) failures than other subject vehicles. In a September 3, 2014 letter to NHTSA, Chrysler submitted a Defect Information Report (DIR) identifying a defect in the FPR within the TIPM-7 which can result in a no start or stall condition in approximately 188,723 model year (MY) 2011 Jeep Grand Cherokee (WK) and Dodge Durango (WD) vehicles manufactured from January 5, 2010 through July 20, 2011 (14V-530).In a February 24, 2015 letter, Chrysler submitted a second DIR expanding the scope of the FPR defect condition to include an additional 338,216 MY 2012 through 2013 Jeep Grand Cherokee vehicles manufactured from September 17, 2010 through August 19, 2013 and MY 2012 through 2013 Dodge Durango vehicles manufactured from January 18, 2011 through August 19, 2013 (15V-115).ODI analysis of the CAS allegations of TIPM defects resulting in stall while driving, airbag non-deployment, unintended acceleration, fire and other faults identified a single defect condition related to 1 of over 60 different circuits in the TIPM assembly. The most common effect of this defect condition, related to the fuel pump relay, was a no-start concern, but it could also result in stall while driving (76 complaints). No valid evidence was presented in support of claims related to airbag non-deployment, unintended acceleration or fire resulting from TIPM faults and these claims were found to be wholly without merit based on review of the field data and design of the relevant systems and components.Except insofar as the petitioner's contentions relate to the defect condition addressed by the Chrysler recalls, the factual bases of the petitioner's contentions that any further investigation is necessary are unsupported. In our view, additional investigation is unlikely to result in a finding that a defect related to motor vehicle safety exists or a NHTSA order for the notification and remedy of a safety-related defect as alleged by the petitioner at the conclusion of the requested investigation. Therefore, in view of the need to allocate and prioritize NHTSA's limited resources to best accomplish the agency's safety mission, the petition is den