← New search

2011 Dodge Grand Caravan

Owner reports · Recalls · Investigations

Similar to other model years

Owner complaints for the 2011 Dodge Grand Caravan do not stand out strongly from the model-year median of 284.

About this comparison →

When problems were reported

Mileage at the reported incident

383 reports with mileage · 147 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Electrical System. Review the 332 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Fuel/propulsion System. Review the 127 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Engine. Review the 92 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

9 crash reports17 fire reports15 injury reports

Steering complaints

15 reports
Clear category filter
108,000 miles · Dec 23, 2016
Electrical SystemService BrakesSteering

DRIVING STRAIGHT, APPROX 35 MPH ON 2-LANE STATE HIGHWAY PASSING THROUGH SMALL TOWN WITH RUSH HOUR TRAFFIC ON BOTH LANES AND NO SHOULDER. WITH NO PRIOR WARNING, ALL RED INSTRUMENT WARNING LIGHTS WENT ON AT ONCE, INCLUDING FUEL PUMP/THROTTLE, BRAKES AND OTHERS. CAR STALLED DEAD AND INSTANTANEOUSLY LOST POWER TO STEERING AND BRAK…

Read full complaint

DRIVING STRAIGHT, APPROX 35 MPH ON 2-LANE STATE HIGHWAY PASSING THROUGH SMALL TOWN WITH RUSH HOUR TRAFFIC ON BOTH LANES AND NO SHOULDER. WITH NO PRIOR WARNING, ALL RED INSTRUMENT WARNING LIGHTS WENT ON AT ONCE, INCLUDING FUEL PUMP/THROTTLE, BRAKES AND OTHERS. CAR STALLED DEAD AND INSTANTANEOUSLY LOST POWER TO STEERING AND BRAKES, WAS IMPOSSIBLE TO CONTROL. WOULD NOT RESTART. FORTUNATELY DRIVER WAS ABLE TO STEER VEHICLE PARTLY OFF ROAD INTO A DRIVEWAY OF BUSY STORE, BLOCKING DRIVEWAY TO CUSTOMERS. STATE POLICE WERE UNABLE TO GET CAR IN NEUTRAL TO PUSH TO SAFE LOCATION. POLICE ORDERED CAR TOWED AND IT IS CURRENTLY AWAITING DIAGNOSIS FOR TOTALLY INTEGRATED POWER MODULE("TIPM") FAILURE AT DODGE DEALERSHIP. THIS WAS A LIFE-THREATENING FAILURE AND IF IT HAD HAPPENED AT NEARLY ANY OTHER LOCATION OR IN ADVERSE WEATHER THERE WOULD HAVE BEEN INJURY OR DEATH TO DRIVER AND PASSENGERS. WE HAVE TOW RECEIPT. WE DON'T KNOW WHETHER STATE POLICE FILED INCIDENT REPORT. MANY SIMILAR TIPM FAILURES OF DODGE AND CHRYSLER VEHICLES HAVE BEEN REPORTED TO NHTSA AND YOU HAVE RECENTLY REJECTED A CENTER FOR AUTO SAFETY PETITION FOR NHTSA INTERVENTION REGARDING THIS DEFECT. CHRYSLER/DODGE IS WELL AWARE OF THE PROBLEMS WITH THE TIPM BECAUSE 80,894 JEEP WRANGLERS AND DODGE NITRO VEHICLES WERE RECALLED IN 2007 FOR THE SAME PROBLEMS. IN THAT RECALL, DEFECTIVE TIPMS HAD A SOFTWARE PROBLEM THAT COULD CAUSE THE ENGINE TO STALL. NHTSA SHOULD REQUIRE DODGE TO RECALL EVERY MODEL THAT HAS THIS SAME TIPM INSTALLED AND TO IMMEDIATELY WARN THE PUBLIC THAT THEIR LIVES ARE IN DANGER EVERY TIME THEY DRIVE THEIR DODGE/CHRYSLER VEHICLE. IT IS UNCONSCIONABLE THAT THE MANUFACTURER AND NHTSA HAVE PREVIOUSLY BEEN INFORMED OF THIS DANGEROUS DEFECT AND FAILED TO PROTECT THE AMERICAN PUBLIC.

NHTSA ODI #10937195

96,000 miles · Oct 21, 2015
Electrical SystemService BrakesSteering

THE VEHICLE OF RECORD HAS BEEN SPONTANEOUSLY SHUTTING OFF ALL DAY, IT SHUT OFF 15 TIMES IN 1 PARKING LOT, BUT THE MOST DANGEROUS ASPECT WAS WHEN IT SHUT OFF WHILE I WAS DOING THE SPEED LIMIT IN A 50 AND A 55 MPH ZONE. IT WILL GENERALLY SHUT OFF RANDOMLY, BUT PRIMARILY AT STOP SIGNS OR BACKING OUT OF PARKING SPACES, BUT THERE HAV…

Read full complaint

THE VEHICLE OF RECORD HAS BEEN SPONTANEOUSLY SHUTTING OFF ALL DAY, IT SHUT OFF 15 TIMES IN 1 PARKING LOT, BUT THE MOST DANGEROUS ASPECT WAS WHEN IT SHUT OFF WHILE I WAS DOING THE SPEED LIMIT IN A 50 AND A 55 MPH ZONE. IT WILL GENERALLY SHUT OFF RANDOMLY, BUT PRIMARILY AT STOP SIGNS OR BACKING OUT OF PARKING SPACES, BUT THERE HAVE BEEN 3 INSTANCES WHERE IT SHUT OFF AT 40 MPH OR HIGHER IN THE LAST 8 HOURS, WHEN THESE SHUT OFFS HAPPEN IT TAKES 5-10 ATTEMPTS TO RESTART THE CAR. WHEN THESE INSTANCES HAPPEN THE BRAKES AND STEERING WHEEL LOCK UP MAKING IT VERY DIFFICULT TO STOP AND/OR TURN.

NHTSA ODI #10785236

95,000 miles · May 14, 2015
Electrical SystemEngineSteering

I WAS DRIVING APPROXIMATELY 30 MPH AND THE VEHICLE JUST SHUT DOWN, THE POWERING STEERING WENT OUT AND THE ENGINE STALLED WHICH WE LATER FOUND OUT WAS DUE TO THE FAULTY TIPM. WE HAD ALSO BEEN HAVING A FEW ISSUES WITH THE FUEL PUMP.....THE FUEL PUMP WAS NOT SHUTTING OFF AND ALL LEAD TO PROBLEMS WITH BEING ABLE TO START THE VEHICL…

Read full complaint

I WAS DRIVING APPROXIMATELY 30 MPH AND THE VEHICLE JUST SHUT DOWN, THE POWERING STEERING WENT OUT AND THE ENGINE STALLED WHICH WE LATER FOUND OUT WAS DUE TO THE FAULTY TIPM. WE HAD ALSO BEEN HAVING A FEW ISSUES WITH THE FUEL PUMP.....THE FUEL PUMP WAS NOT SHUTTING OFF AND ALL LEAD TO PROBLEMS WITH BEING ABLE TO START THE VEHICLE SOMETIMES IT TOOK SEVERAL ATTEMPTS TO EVEN GET VEHICLE STARTED.

NHTSA ODI #10716449

82,000 miles · Jan 27, 2015
Electrical SystemEngineSteering

VEHICLE STALLED 6 TIMES WHILE TRAVELING ON EXPRESSWAY 70-75 MPH ,LIGHTS GOING ON AND OFF...LOSS OF POWER STEERING AND BRAKES WHEN STALLED. TOOK VEHICLE TO DEALERSHIP WHO COULD NOT DUPLICATE. THEY HAD BEEN CONFERRING WITH DODGE REPRESENTATIVE WHO AFTER 1 WEEK STATED TO GIVE VEHICLE BACK TO CUSTOMER. AFTER EXTENSIVE RESEARCH I FEE…

Read full complaint

VEHICLE STALLED 6 TIMES WHILE TRAVELING ON EXPRESSWAY 70-75 MPH ,LIGHTS GOING ON AND OFF...LOSS OF POWER STEERING AND BRAKES WHEN STALLED. TOOK VEHICLE TO DEALERSHIP WHO COULD NOT DUPLICATE. THEY HAD BEEN CONFERRING WITH DODGE REPRESENTATIVE WHO AFTER 1 WEEK STATED TO GIVE VEHICLE BACK TO CUSTOMER. AFTER EXTENSIVE RESEARCH I FEEL IT IS A FAULTY TIPM, HOWEVER DODGE APPARENTLY DOES NOT THINK SO. SO I HAVE A VEHICLE THAT CAN STALL AT ANY TIME...DODGE KNOWS THERE IS A PROBLEM AND THEY JUST DON'T CARE. I WILL SAY THE DEALERSHIP WAS GREAT, FREE LOANER CAR, NO CHARGE FOR DIAGNOSTIC AND THEY GENUINELY FELT BAD TO HAND THE CAR BACK OVER...I DID NOT BUY MY VEHICLE FROM THIS DEALERSHIP, HOWEVER THEY TREATED ME AS IF I WAS A CUSTOMER OF THEIRS. *TR

NHTSA ODI #10679351

45,000 miles · Jun 2, 2014
Service BrakesSteering

WHEN TRYING TO STOP OR SLOW DOWN, STEERING WHEEL VIBRATES SO MUCH IT FEELS LIKE I WON'T BE ABLE TO HOLD ONTO IT. MY SON REPLACED THE ROTOR AND PADS ON FRONT BRAKES AS THEY SEEMED WORN. THEN IN APRIL 2014 WE TOOK THE CAR BACK TO THE DEALER BECAUSE BRAKES WERE GRINDING. THEY REPLACED ROTOR AND PADS AND THINGS SEEMED OK UNTIL MAY, …

Read full complaint

WHEN TRYING TO STOP OR SLOW DOWN, STEERING WHEEL VIBRATES SO MUCH IT FEELS LIKE I WON'T BE ABLE TO HOLD ONTO IT. MY SON REPLACED THE ROTOR AND PADS ON FRONT BRAKES AS THEY SEEMED WORN. THEN IN APRIL 2014 WE TOOK THE CAR BACK TO THE DEALER BECAUSE BRAKES WERE GRINDING. THEY REPLACED ROTOR AND PADS AND THINGS SEEMED OK UNTIL MAY, WHEN BRAKES STARTED SQUEALING AND STEERING WHEEL VIBRATING AGAIN WHILE BRAKING.. TOOK CAR BACK TO DEALER ON MAY 21, AND ASKED THEM TO CHECK BRAKES, ROTATE TIRES, AND CHANGE OIL. THEY SAID BRAKES WERE IN THE "GREEN". STILL HAVING VIBRATION OF STEERING WHEEL WHILE BRAKING, SO I ASKED TO BRING IT IN FOR ANOTHER CHECK, AND NOW THEY SAY THE NEW ROTORS, (ABOUT 2 MONTHS OLD) SHOW SIGNS OF SIGNIFICANT WEAR. THEY ASKED ME IF I DROVE WITH BOTH FEET, AND I DO NOT. THEY VERIFIED MY COMPLAINT OF VIBRATION IN THE STEERING WHEEL, AND ASKED ME TO BRING THE CAR BACK IN ON THIS COMING FRIDAY. THE BRAKES SHOULD NOT BE WEARING OUT THIS QUICKLY... *TR

NHTSA ODI #10595658

Official recalls

4

25V876000 · Equipment Adaptive/mobility:wheelchair Restraints/securement:latch/anchor:

Dec 17, 2025

Rollx Vans (Rollx) is recalling certain GMC Yukon, Sierra, Chevrolet Express 2500, Ford Transit, E-250, Toyota Sienna, Sienna Hybrid, Honda Odyssey, Chrysler Town and Country, Voyager, Pacifica, Dodge Grand Caravan, and Ram Promaster vehicles equipped with QRT-Deluxe and QRT-Max wheelchair restraints. Please refer to Rollx's recall report for specific model year information. The retractors may not lock, preventing the wheelchair from being properly secured.

Consequence & remedy

Consequence: An unsecured wheelchair can move during transit, increasing the risk of injury.

Remedy: Rollx will work with Q'Straint to inspect and replace the retractors as necessary, free of charge. Owner notification letters were mailed February 5, 2026. Owners may contact Rollx's customer service at 1-800-956-6668.

17V376000 · Air Bags:frontal

Jun 13, 2017

Chrysler (FCA US LLC) is recalling certain 2011-2012 Dodge Grand Caravan vehicles. In the affected vehicles, the driver's frontal air bag may unexpectedly deploy if the air bag wiring harness gets chafed within the steering wheel and short circuits.

Consequence & remedy

Consequence: Unexpected deployment of the driver's frontal air bag increases the risk of a crash or driver injury.

Remedy: Chrysler will notify owners, and dealers will inspect the air bag wiring within the steering wheel, replacing it if necessary. A protective cover will also be installed. These repairs will be made free of charge. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is T33.

14V234000 · Electrical System

May 7, 2014

Chrysler Group, LLC (Chrysler) is recalling certain model year 2010-2014 Chrysler Town and Country and Dodge Grand Caravan vehicles manufactured August 25, 2010, through October 31, 2013. The affected vehicles may experience overheating of the vent window switch in the driver's door armrest.

Consequence & remedy

Consequence: An overheated switch may result in a vehicle fire.

Remedy: Chrysler will notify owners, and dealers will replace the vent window switch with a newer version, free of charge. The owner notification letter was issued and the remedy campaign launched on on December 31, 2014. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is P25.

11V315000 · Steering:column

Jun 8, 2011

CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2011DODGE JOURNEY, JEEP WRANGLER, CHRYSLER 200, CHRYSLER 200 CONVERTIBLE, DODGE AVENGER, DODGE NITRO, JEEP LIBERTY, DODGE CALIBER, JEEP COMPASS, JEEP PATRIOT, DODGE GRAND CARAVAN AND CHRYSLER TOWN & COUNTRY VEHICLES. SOME OF THESE VEHICLES MAY HAVE BEEN BUILT WITH A MISSING OR INCORRECTLY INSTALLED STEERING COLUMN PIVOT RIVET.

Consequence & remedy

Consequence: A MISSING OR INCORRECTLY INSTALLED RIVET COULD COMPROMISE THE ABILITY OF THE STEERING COLUMN TO SUPPORT THE OCCUPANT LOADS IN THE EVENT OF A FRONTAL CRASH, DECREASING THE EFFECTIVENESS OF THE FRONTAL IMPACT SAFETY SYSTEM. AS A RESULT, THE CONDITION MAY INCREASE THE POTENTIAL FOR INJURY IN A FRONTAL CRASH.

Remedy: DEALERS WILL INSPECT FOR RIVET PRESENCE AND ALIGNMENT AND REPAIR THE STEERING COLUMN PIVOT AS REQUIRED, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JULY 4, 2011. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

2

PE19014 · Active Head Rest Inadvertent Deployment

Opened Sep 9, 2019 · Closed Feb 25, 2026

Status: closed (inferred from source dates) · Seats; Seats:front Assembly:head Restraint

The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

Additional source detail variants (2)

Seats

The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

Seats:front Assembly:head Restraint

The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

DP14004 · Totally Integrated Power Module Failure

Opened Sep 25, 2014 · Closed Jul 24, 2015

Status: closed (inferred from source dates) · Electrical System

In a letter dated August 21, 2014, the Center for Auto Safety (CAS) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged failures associated with the Totally Integrated Power Module (TIPM) installed in Chrysler SUV?s, trucks, and vans beginning in the 2007 model year. The petitioner alleges that TIPM defects may result in engine stall, airbag non-deployment, failure of fuel pump shutoff resulting in unintended acceleration, fire, and other symptoms. On September 25, 2014, the Office of Defects Investigation (ODI) opened DP14-004 to evaluate the petition for a grant or deny decision. ODI analyzed complaint data provided by CAS as well as complaints submitted to ODI from consumers. In total, there were 296 complaints submitted by the petitioner in the original petition and five supplements, including 271 complaints related to the subject vehicles equipped with TIPM-7. Approximately 3 percent of CAS complaints are related to vehicles equipped with TIPM-6 and ODI?s review of these complaints did not identify any safety defect trends. ODI conducted a detailed review of complaints narratives submitted by CAS and consumers including careful analysis of vehicle repair histories, warranty claims obtained from the manufacturer and any available Customer Assistance Inquiry reports (CAIR). Analysis of the field data indicated that MY2011-2013 Jeep Grand Cherokee and Dodge Durango vehicles exhibited significantly higher complaint rates related to fuel pump relay (FPR) failures than other subject vehicles. In a September 3, 2014 letter to NHTSA, Chrysler submitted a Defect Information Report (DIR) identifying a defect in the FPR within the TIPM-7 which can result in a no start or stall condition in approximately 188,723 model year (MY) 2011 Jeep Grand Cherokee (WK) and Dodge Durango (WD) vehicles manufactured from January 5, 2010 through July 20, 2011 (14V-530).In a February 24, 2015 letter, Chrysler submitted a second DIR expanding the scope of the FPR defect condition to include an additional 338,216 MY 2012 through 2013 Jeep Grand Cherokee vehicles manufactured from September 17, 2010 through August 19, 2013 and MY 2012 through 2013 Dodge Durango vehicles manufactured from January 18, 2011 through August 19, 2013 (15V-115).ODI analysis of the CAS allegations of TIPM defects resulting in stall while driving, airbag non-deployment, unintended acceleration, fire and other faults identified a single defect condition related to 1 of over 60 different circuits in the TIPM assembly. The most common effect of this defect condition, related to the fuel pump relay, was a no-start concern, but it could also result in stall while driving (76 complaints). No valid evidence was presented in support of claims related to airbag non-deployment, unintended acceleration or fire resulting from TIPM faults and these claims were found to be wholly without merit based on review of the field data and design of the relevant systems and components.Except insofar as the petitioner's contentions relate to the defect condition addressed by the Chrysler recalls, the factual bases of the petitioner's contentions that any further investigation is necessary are unsupported. In our view, additional investigation is unlikely to result in a finding that a defect related to motor vehicle safety exists or a NHTSA order for the notification and remedy of a safety-related defect as alleged by the petitioner at the conclusion of the requested investigation. Therefore, in view of the need to allocate and prioritize NHTSA's limited resources to best accomplish the agency's safety mission, the petition is den