← New search

2011 Dodge Grand Caravan

Owner reports · Recalls · Investigations

Similar to other model years

Owner complaints for the 2011 Dodge Grand Caravan do not stand out strongly from the model-year median of 284.

About this comparison →

When problems were reported

Mileage at the reported incident

383 reports with mileage · 147 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Electrical System. Review the 332 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Fuel/propulsion System. Review the 127 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Engine. Review the 92 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

9 crash reports17 fire reports15 injury reports

Fuel/propulsion System complaints

127 reports
Clear category filter
75,000 miles · Dec 29, 2014
Fuel/propulsion SystemTires

TL* THE CONTACT OWNS A 2011 DODGE GRAND CARAVAN. THE CONTACT STATED THAT THE FUEL PUMP FAILED TO SHUT OFF AFTER REMOVING THE KEY FROM THE IGNITION. AS A RESULT, THE BATTERY WAS DRAINED AND NEEDED TO BE REPLACED. THE CONTACT ALSO STATED THAT THERE WAS AN ABNORMAL NOISE COMING FROM THE REAR DRIVER SIDE TIRE. THE VEHICLE WAS NOT DI…

Read full complaint

TL* THE CONTACT OWNS A 2011 DODGE GRAND CARAVAN. THE CONTACT STATED THAT THE FUEL PUMP FAILED TO SHUT OFF AFTER REMOVING THE KEY FROM THE IGNITION. AS A RESULT, THE BATTERY WAS DRAINED AND NEEDED TO BE REPLACED. THE CONTACT ALSO STATED THAT THERE WAS AN ABNORMAL NOISE COMING FROM THE REAR DRIVER SIDE TIRE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 75,000.

NHTSA ODI #10668855

70,000 miles · Dec 3, 2014
Fuel/propulsion System

ABOUT A YEAR AGO THE VEHICLE STARTED SPORADICALLY NOT COMING ON. BATTERY WAS REPLACED, THAT WAS NOT THE ISSUE, ALTERNATOR WAS TESTED, THAT WAS NOT THE ISSUE?ABOUT 3-4 MONTHS AGO THE PROBLEM GOT MUCH WORSE AND WOULD SOMETIMES TAKE 2-5 ATTEMPTS BEFORE THE CAR WOULD START. SOMETIMES IT WOULD START THEN IMMEDIATELY STALL. LAST WEEK …

Read full complaint

ABOUT A YEAR AGO THE VEHICLE STARTED SPORADICALLY NOT COMING ON. BATTERY WAS REPLACED, THAT WAS NOT THE ISSUE, ALTERNATOR WAS TESTED, THAT WAS NOT THE ISSUE?ABOUT 3-4 MONTHS AGO THE PROBLEM GOT MUCH WORSE AND WOULD SOMETIMES TAKE 2-5 ATTEMPTS BEFORE THE CAR WOULD START. SOMETIMES IT WOULD START THEN IMMEDIATELY STALL. LAST WEEK IT JUST STOPPED RUNNING; WOULD NOT TURN ON AT ALL. TURNS OUT IT IS THE TIPM THAT HAS GONE BAD NOT ALLOWING THE FUEL RELAY TO WORK PROPERLY. THE PART IS AROUND $1200 TO REPLACE, IF YOU CAN EVEN FIND ONE. CHRYSLER/DODGE HAS RECALLED THIS IN VARIOUS OTHER VEHICLES BUT STILL REFUSES TO RECALL IT IN THE 2011-2012 DODGE GRAND CARAVAN. WE HAVE FRIENDS WHO ALSO HAVE A 2011 GRAND CARAVAN AND WERE HAVING THE SAME PROBLEMS BEFORE US. THEIR DEALER REPLACE ALL SORTS OF OTHER PARTS ON THE CAR BEFORE THEY TOOK IT TO A SHOP THAT TOLD THEM IT WAS THE TIPM; THE DODGE DEALERSHIP SAID THEY DOUBTED THAT WAS THE ISSUE BUT IF IT WAS THEY WOULD REPLACE IT FOR THEM AT NO COST. GUESS WHAT? IT TURNS OUT THAT WAS THE ISSUE AND NOW IT HAS BEEN REPLACED AND THEY HAVE NOT HAD AN ISSUE SINCE. I HAVE SINCE, AFTER MUCH RESEARCH ON THE INTERNET, MADE A BYPASS FOR THE VEHICLE; WHICH WILL WORK TEMPORARILY BUT IT WILL NOT BE A PERMANENT FIX. I WANT THEM TO FIX MY VEHICLE! *JS

NHTSA ODI #10661935

88,000 miles · Nov 18, 2014
Electrical SystemFuel/propulsion System

BASES ON WHAT I FOUND WITH MY LOCAL MECHANIC AND ONLINE MY VAN A FAULTY TIPM. DODGE CURRENTLY HAS A RECALL OUT FOR OTHER VEHICLE WITH A BAD TIPM BUT CLAIMS MY VAN IN NOT AFFECTED BY IT. MY VAN HAS HARD STARTS OR IT WILL START THE STALL. IT TAKES ABOUT 8-10 TIMES BEFORE IT WILL START AND STAY RUNNING. ALSO MY FUEL PUMP WILL STAY…

Read full complaint

BASES ON WHAT I FOUND WITH MY LOCAL MECHANIC AND ONLINE MY VAN A FAULTY TIPM. DODGE CURRENTLY HAS A RECALL OUT FOR OTHER VEHICLE WITH A BAD TIPM BUT CLAIMS MY VAN IN NOT AFFECTED BY IT. MY VAN HAS HARD STARTS OR IT WILL START THE STALL. IT TAKES ABOUT 8-10 TIMES BEFORE IT WILL START AND STAY RUNNING. ALSO MY FUEL PUMP WILL STAY RUNNING EVEN AFTER I TAKE THE KEY OUT. IF I DO NOT REMOVE THE FUEL PUMP FUSE THE PUMP WILL UNTIL THE BATTERY DIES. *TR

NHTSA ODI #10658862

91,000 miles · Nov 16, 2014
Electrical SystemFuel/propulsion System

AFTER BEING TOLD BY THE DEALER OUR VAN WOULDN'T START DUE TO THE ALTERNATOR, WE DECIDED TO HAVE THE ALTERNATOR LOOKED AT. THE OTHER MECHANIC FOUND NOTHING TO BE WRONG WITH THE ALTERNATOR. THE DEALER ALSO SAID WE NEEDED OUR FUEL PUMP REPLACED. WE HAVE HAD OTHER VEHICLES THAT NEEDED FUEL PUMPS REPLACED AND WHEN THE FUEL PUMP WEN…

Read full complaint

AFTER BEING TOLD BY THE DEALER OUR VAN WOULDN'T START DUE TO THE ALTERNATOR, WE DECIDED TO HAVE THE ALTERNATOR LOOKED AT. THE OTHER MECHANIC FOUND NOTHING TO BE WRONG WITH THE ALTERNATOR. THE DEALER ALSO SAID WE NEEDED OUR FUEL PUMP REPLACED. WE HAVE HAD OTHER VEHICLES THAT NEEDED FUEL PUMPS REPLACED AND WHEN THE FUEL PUMP WENT OUT WE WERE NOT ABLE TO DRIVE IT AT ALL. MY HUSBAND WAS AT AN APPOINTMENT AND AFTER TURNING OFF VAN HE HEARD SOMETHING RUNNING. THE SOUND WAS TRACKED TO THE FUEL PUMP. SO THE DEALER WASTED OUR TIME AND MONEY ALL THE TIME TRYING TO HAVE US REPLACE PARTS THAT WOULD NOT HAVE CORRECTED THE PROBLEM. AFTER CALLING AND TRYING TO GET A FUEL PUMP REGULATOR WE DISCOVERED THE FUEL PUMP REGULATOR IS BUILT INTO THE TIPM. WE HAVE A FAULTY TIPM. I WISH DODGE WOULD GET OFF THEIR BUTT AND ISSUE A RECALL ALREADY. THE ONLY WAY A CAN SHUT THE FUEL PUMP OFF IS TO UNHOOK THE BATTERY. *TR

NHTSA ODI #10655309

79,127 miles · Nov 13, 2014
Electrical SystemFuel/propulsion System

THE CAR CUT OFF WHILE DRIVING, A WEEK BEFORE I TOOK THE CAR TO THE DEALER COMPLAINING ABOUT THE CAR NO STARTING INTERMITTENT. THE DEALER RETURN THE CAR SAYING NO PROBLEM FOUND. AFTER THIS HAPPENS CUTTING OFF WHILE DRIVING, I TOOK THE CAR AGAIN TO THE DEALER, THIS TIME THE DEALER REPLACE THE "TIPM" P/N 68244893AA, I WAS CHARGED $…

Read full complaint

THE CAR CUT OFF WHILE DRIVING, A WEEK BEFORE I TOOK THE CAR TO THE DEALER COMPLAINING ABOUT THE CAR NO STARTING INTERMITTENT. THE DEALER RETURN THE CAR SAYING NO PROBLEM FOUND. AFTER THIS HAPPENS CUTTING OFF WHILE DRIVING, I TOOK THE CAR AGAIN TO THE DEALER, THIS TIME THE DEALER REPLACE THE "TIPM" P/N 68244893AA, I WAS CHARGED $890.10, THE DEALER MECHANIC INFORMED ME THAT THIS IS WELL KNOWN PROBLEM, FOR THE SAFETY OF OTHER PLEASE FORCE CHRYSLER TO RECALL THIS "TIPM" AS THEY DID TO THE SUV'S. *TR

NHTSA ODI #10654698

66,000 miles · Aug 5, 2014
EngineFuel/propulsion System

TL* THE CONTACT OWNS A 2011 DODGE GRAND CARAVAN. THE CONTACT STATED THAT THE VEHICLE FAILED TO START AFTER SEVERAL ATTEMPTS. ONCE STARTED, THE VEHICLE STALLED WHILE DRIVING VARIOUS SPEEDS. THE VEHICLE WAS ABLE TO BE RESTARTED AND WAS TAKEN TO THE DEALER. THE CONTACT WAS INFORMED THAT THE TOTALLY INTEGRATED POWER MODULE WAS FAUL…

Read full complaint

TL* THE CONTACT OWNS A 2011 DODGE GRAND CARAVAN. THE CONTACT STATED THAT THE VEHICLE FAILED TO START AFTER SEVERAL ATTEMPTS. ONCE STARTED, THE VEHICLE STALLED WHILE DRIVING VARIOUS SPEEDS. THE VEHICLE WAS ABLE TO BE RESTARTED AND WAS TAKEN TO THE DEALER. THE CONTACT WAS INFORMED THAT THE TOTALLY INTEGRATED POWER MODULE WAS FAULTY AND CAUSED THE FUEL PUMP TO MALFUNCTION. THE VEHICLE WAS NOT REPAIRED BECAUSE THE NECESSARY PART WAS ON BACK ORDER. THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 66,000.

NHTSA ODI #10619081

52,000 miles · Jul 22, 2014
Electrical SystemFuel/propulsion System

I HAVE A 2011 DODGE GRAND CARAVAN WITH ABOUT 52,000 MILES ON IT. ON DAY THE RADIO JUST WENT OFF AND THEN TURNED BACK ON. IT DID THIS MULTIPLE TIMES BEFORE WE SENT IT IN TO THE SHOP. THEN ONE DAY IT WOULD NOT START. IT WOULD TURN OVER BUT WOULD NOT FIRE UNTIL I TRIED IT 6 TO 10 TIMES AND THEN IT WOULD START. WE TOOK IT IN TO THE…

Read full complaint

I HAVE A 2011 DODGE GRAND CARAVAN WITH ABOUT 52,000 MILES ON IT. ON DAY THE RADIO JUST WENT OFF AND THEN TURNED BACK ON. IT DID THIS MULTIPLE TIMES BEFORE WE SENT IT IN TO THE SHOP. THEN ONE DAY IT WOULD NOT START. IT WOULD TURN OVER BUT WOULD NOT FIRE UNTIL I TRIED IT 6 TO 10 TIMES AND THEN IT WOULD START. WE TOOK IT IN TO THE DEALER FOR A MISFIRE IN CYLINDER #2 ( RECALL ON LEFT HEAD) BUT IT STARTED ALL THE TIME FOR THEM, UNTIL I WENT TO LEAVE, AND THEN NO START. THE TECH WAS ABLE TO DUPLICATE IT AND SAID WE WOULD TROUBLE SHOOT IT. A WEEK LATER THEY CALLED AND SAID IT IS MORE THEN LIKELY THE TIPM CAUSING THE PROBLEM AND THE PART IS BACKORDER NATIONALLY AND WOULD COST ME $1037 PLUS TAX FOR THE PARTS AND LABOR. IF IT IS BACK ORDERED THEN THERE IS A BIG PROBLEM AND CHRYSLER KNOWS ABOUT IT. I HOPE THEY ISSUE A RECALL SOON SO I CAN GET MY MONEY BACK. *TR

NHTSA ODI #10615389

Official recalls

4

25V876000 · Equipment Adaptive/mobility:wheelchair Restraints/securement:latch/anchor:

Dec 17, 2025

Rollx Vans (Rollx) is recalling certain GMC Yukon, Sierra, Chevrolet Express 2500, Ford Transit, E-250, Toyota Sienna, Sienna Hybrid, Honda Odyssey, Chrysler Town and Country, Voyager, Pacifica, Dodge Grand Caravan, and Ram Promaster vehicles equipped with QRT-Deluxe and QRT-Max wheelchair restraints. Please refer to Rollx's recall report for specific model year information. The retractors may not lock, preventing the wheelchair from being properly secured.

Consequence & remedy

Consequence: An unsecured wheelchair can move during transit, increasing the risk of injury.

Remedy: Rollx will work with Q'Straint to inspect and replace the retractors as necessary, free of charge. Owner notification letters were mailed February 5, 2026. Owners may contact Rollx's customer service at 1-800-956-6668.

17V376000 · Air Bags:frontal

Jun 13, 2017

Chrysler (FCA US LLC) is recalling certain 2011-2012 Dodge Grand Caravan vehicles. In the affected vehicles, the driver's frontal air bag may unexpectedly deploy if the air bag wiring harness gets chafed within the steering wheel and short circuits.

Consequence & remedy

Consequence: Unexpected deployment of the driver's frontal air bag increases the risk of a crash or driver injury.

Remedy: Chrysler will notify owners, and dealers will inspect the air bag wiring within the steering wheel, replacing it if necessary. A protective cover will also be installed. These repairs will be made free of charge. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is T33.

14V234000 · Electrical System

May 7, 2014

Chrysler Group, LLC (Chrysler) is recalling certain model year 2010-2014 Chrysler Town and Country and Dodge Grand Caravan vehicles manufactured August 25, 2010, through October 31, 2013. The affected vehicles may experience overheating of the vent window switch in the driver's door armrest.

Consequence & remedy

Consequence: An overheated switch may result in a vehicle fire.

Remedy: Chrysler will notify owners, and dealers will replace the vent window switch with a newer version, free of charge. The owner notification letter was issued and the remedy campaign launched on on December 31, 2014. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is P25.

11V315000 · Steering:column

Jun 8, 2011

CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2011DODGE JOURNEY, JEEP WRANGLER, CHRYSLER 200, CHRYSLER 200 CONVERTIBLE, DODGE AVENGER, DODGE NITRO, JEEP LIBERTY, DODGE CALIBER, JEEP COMPASS, JEEP PATRIOT, DODGE GRAND CARAVAN AND CHRYSLER TOWN & COUNTRY VEHICLES. SOME OF THESE VEHICLES MAY HAVE BEEN BUILT WITH A MISSING OR INCORRECTLY INSTALLED STEERING COLUMN PIVOT RIVET.

Consequence & remedy

Consequence: A MISSING OR INCORRECTLY INSTALLED RIVET COULD COMPROMISE THE ABILITY OF THE STEERING COLUMN TO SUPPORT THE OCCUPANT LOADS IN THE EVENT OF A FRONTAL CRASH, DECREASING THE EFFECTIVENESS OF THE FRONTAL IMPACT SAFETY SYSTEM. AS A RESULT, THE CONDITION MAY INCREASE THE POTENTIAL FOR INJURY IN A FRONTAL CRASH.

Remedy: DEALERS WILL INSPECT FOR RIVET PRESENCE AND ALIGNMENT AND REPAIR THE STEERING COLUMN PIVOT AS REQUIRED, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JULY 4, 2011. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

2

PE19014 · Active Head Rest Inadvertent Deployment

Opened Sep 9, 2019 · Closed Feb 25, 2026

Status: closed (inferred from source dates) · Seats; Seats:front Assembly:head Restraint

The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

Additional source detail variants (2)

Seats

The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

Seats:front Assembly:head Restraint

The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

DP14004 · Totally Integrated Power Module Failure

Opened Sep 25, 2014 · Closed Jul 24, 2015

Status: closed (inferred from source dates) · Electrical System

In a letter dated August 21, 2014, the Center for Auto Safety (CAS) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged failures associated with the Totally Integrated Power Module (TIPM) installed in Chrysler SUV?s, trucks, and vans beginning in the 2007 model year. The petitioner alleges that TIPM defects may result in engine stall, airbag non-deployment, failure of fuel pump shutoff resulting in unintended acceleration, fire, and other symptoms. On September 25, 2014, the Office of Defects Investigation (ODI) opened DP14-004 to evaluate the petition for a grant or deny decision. ODI analyzed complaint data provided by CAS as well as complaints submitted to ODI from consumers. In total, there were 296 complaints submitted by the petitioner in the original petition and five supplements, including 271 complaints related to the subject vehicles equipped with TIPM-7. Approximately 3 percent of CAS complaints are related to vehicles equipped with TIPM-6 and ODI?s review of these complaints did not identify any safety defect trends. ODI conducted a detailed review of complaints narratives submitted by CAS and consumers including careful analysis of vehicle repair histories, warranty claims obtained from the manufacturer and any available Customer Assistance Inquiry reports (CAIR). Analysis of the field data indicated that MY2011-2013 Jeep Grand Cherokee and Dodge Durango vehicles exhibited significantly higher complaint rates related to fuel pump relay (FPR) failures than other subject vehicles. In a September 3, 2014 letter to NHTSA, Chrysler submitted a Defect Information Report (DIR) identifying a defect in the FPR within the TIPM-7 which can result in a no start or stall condition in approximately 188,723 model year (MY) 2011 Jeep Grand Cherokee (WK) and Dodge Durango (WD) vehicles manufactured from January 5, 2010 through July 20, 2011 (14V-530).In a February 24, 2015 letter, Chrysler submitted a second DIR expanding the scope of the FPR defect condition to include an additional 338,216 MY 2012 through 2013 Jeep Grand Cherokee vehicles manufactured from September 17, 2010 through August 19, 2013 and MY 2012 through 2013 Dodge Durango vehicles manufactured from January 18, 2011 through August 19, 2013 (15V-115).ODI analysis of the CAS allegations of TIPM defects resulting in stall while driving, airbag non-deployment, unintended acceleration, fire and other faults identified a single defect condition related to 1 of over 60 different circuits in the TIPM assembly. The most common effect of this defect condition, related to the fuel pump relay, was a no-start concern, but it could also result in stall while driving (76 complaints). No valid evidence was presented in support of claims related to airbag non-deployment, unintended acceleration or fire resulting from TIPM faults and these claims were found to be wholly without merit based on review of the field data and design of the relevant systems and components.Except insofar as the petitioner's contentions relate to the defect condition addressed by the Chrysler recalls, the factual bases of the petitioner's contentions that any further investigation is necessary are unsupported. In our view, additional investigation is unlikely to result in a finding that a defect related to motor vehicle safety exists or a NHTSA order for the notification and remedy of a safety-related defect as alleged by the petitioner at the conclusion of the requested investigation. Therefore, in view of the need to allocate and prioritize NHTSA's limited resources to best accomplish the agency's safety mission, the petition is den