← New search

2011 Dodge Grand Caravan

Owner reports · Recalls · Investigations

Similar to other model years

Owner complaints for the 2011 Dodge Grand Caravan do not stand out strongly from the model-year median of 284.

About this comparison →

When problems were reported

Mileage at the reported incident

383 reports with mileage · 147 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Electrical System. Review the 332 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Fuel/propulsion System. Review the 127 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Engine. Review the 92 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

9 crash reports17 fire reports15 injury reports

Engine And Engine Cooling complaints

5 reports
Clear category filter
151,000 miles · Dec 14, 2022
Engine And Engine Cooling

The contact owns a 2011 Dodge Grand Caravan. The contact stated while driving at an undisclosed speed, the vehicle went into LIMP Mode, with several unknown warning lights illuminated. The contact stated that she was able to maneuver the vehicle off the roadway. The vehicle was taken to an independent mechanic where it was diagn…

Read full complaint

The contact owns a 2011 Dodge Grand Caravan. The contact stated while driving at an undisclosed speed, the vehicle went into LIMP Mode, with several unknown warning lights illuminated. The contact stated that she was able to maneuver the vehicle off the roadway. The vehicle was taken to an independent mechanic where it was diagnosed that the ECM needed to be replaced. The vehicle was not repaired. The dealer was notified of the failure and the contact was informed that an unknown recall repair was previously performed. The manufacturer was not notified of the failure. The failure mileage was approximately 151,000.

NHTSA ODI #11497387

46,000 miles · Jul 22, 2015
Electrical SystemEngine And Engine Cooling

ON 7/03/2015 MY 2011 DODGE GRAND CARAVAN WITH 46000 MILES WAS HAVING STARTING, STALLING AND IDLE ISSUES. THROTTLE BODY WAS REPAIRED BY SHOP AND REFUNDED MONEY BECAUSE CAR STILL HAD SAME ISSUES. THE MECHANIC SAID TAKE IT TO THE DEALERSHIP BECAUSE IT WAS NOT KICKING OUT ANY CODES I CONTACTED THE DEALERSHIP AND HAD TO WAIT FOR AN A…

Read full complaint

ON 7/03/2015 MY 2011 DODGE GRAND CARAVAN WITH 46000 MILES WAS HAVING STARTING, STALLING AND IDLE ISSUES. THROTTLE BODY WAS REPAIRED BY SHOP AND REFUNDED MONEY BECAUSE CAR STILL HAD SAME ISSUES. THE MECHANIC SAID TAKE IT TO THE DEALERSHIP BECAUSE IT WAS NOT KICKING OUT ANY CODES I CONTACTED THE DEALERSHIP AND HAD TO WAIT FOR AN APPT UNTIL AUG 4TH. THE CAR WAS ACTING UP SO I WENT IN WITHOUT AN APPOINTMENT ON 07/21/15 THEY SAID BECAUSE THE ISSUE WAS SO INTERMITTENT THAT I WOULD HAVE TO LEAVE THE CAR FOR A FEW DAYS. ON 07/22/15 THE DEALERSHIP CALLED AND SAID THEY FOUND TWO ISSUES WITH THE VAN 1ST IT NEEDED THE LEFT CYLINDER HEAD REPLACED AND 2ND THE TIPM UNIT WAS BAD. THE GOOD NEWS WAS THE CYLINDER HEAD WHICH WOULD HAVE COST $2000 WAS COVERED UNDER WARRANTY. THE BAD NEWS WAS THE TIPM ( TOTALLY INTEGRATED POWER MODULE) WAS GOING TO COST $1100 TO FIX. THE WHOLE POINT OF BUYING A NEWER CAR WAS TO NOT HAVE THESE HUGE REPAIR BILLS. BUT IN ONE SHOT THIS VAN JUST COST $3600 IN REPAIRS THAT IS JUST INSANE, WHO HAS THIS KIND OF MONEY LAYING AROUND. THE SECOND THIS TIPM UNIT IS A SAFETY ISSUE AFTER DOING SOME RESEARCH A LOT OF OTHER CARS MANUFACTURED BY CHRYSLER ARE HAVING THIS SAME ISSUE. I COULD NOT IMAGINE BEING STRANDED SOMEWHERE WITH MY FIVE CHILDREN OR GOD FORBID STALLING OUT WHILE DRIVING IT COULD HAVE CAUSED AN ACCIDENT. THIS TIPM SHOULD BE RECALLED NOT HAPPY WITH OUR CHOICE IN THIS VEHICLE ON TOP OF EVERYTHING ELSE WRONG WITH THIS CAR I HAVE A HEAD AND TAIL LIGHT THAT ARE GETTING WATER INTO THEM. I SAY ONCE AGAIN THIS CAR IS 4 YEARS OLD AND HAS A WHOLE HECK OF A LOT OF PROBLEMS. UPDATED 09/09/15*LJ UPDATED 12/05/2017*CN

NHTSA ODI #10735856

9,700 miles · Mar 2, 2012
Electronic Stability Control (esc)Engine And Engine Cooling

WHEN STARTING, THE ENGINE OCCASIONALLY MAKES A RATTLING NOISE AND CHECK ENGINE LIGHT COMES ON. I TOOK IT TO THE DEALER AND AFTER STATING THAT NO CODES WERE CAPTURED, THEY CLEARED THE CODE. THE CHECK ENGINE LIGHT CAME ON AGAIN SO I TOOK IT BACK AND THEY REPLACED THE CAM POSITION SENSOR, WHICH THEY SAID WOULD FIX IT. IT DIDN'T …

Read full complaint

WHEN STARTING, THE ENGINE OCCASIONALLY MAKES A RATTLING NOISE AND CHECK ENGINE LIGHT COMES ON. I TOOK IT TO THE DEALER AND AFTER STATING THAT NO CODES WERE CAPTURED, THEY CLEARED THE CODE. THE CHECK ENGINE LIGHT CAME ON AGAIN SO I TOOK IT BACK AND THEY REPLACED THE CAM POSITION SENSOR, WHICH THEY SAID WOULD FIX IT. IT DIDN'T AND THE CHECK ENGINE LIGHT CONTINUES TO COME ON WITH A RATTLING AT THE START WHICH NOW OCCURS MORE FREQUENTLY. NOW THE TRACTION CONTROL LIGHT COMES ON AT THE START AND OCCASIONALLY WHEN DRIVING AT ROAD SPEEDS AND DRY CONDITIONS. THE VAN LOSES POWER AND IS SLOW TO ACCELERATE. I HAVE TO PULL OVER WHEN DRIVING, OR IF IT OCCURS AT STARTING, I HAVE TO SHUT THE VAN DOWN AND RESTART THE VAN AND THIS CORRECTS THE PROBLEM. THE NEXT TIME IT OCCURS, I WILL JUST DRIVE IT TO THE DEALER AND SHOW THEM BECAUSE THEY DON'T SEEM TO BELIEVE ME OR THEY TELL ME THERE IS NOTHING THEY CAN DO. I SEE THAT I AM NOW NOT THE ONLY ONE THAT THIS IS HAPPENING TOO. *TR

NHTSA ODI #10450044

7,500 miles · Feb 20, 2012
Electrical SystemEngine And Engine CoolingPower Train

CHECK ENGINE LIGHT CAME ON IN EARLY DECEMBER. DEALER RESET THE ERROR CODE AND SAID IT WAS PROBABLY NOTHING. LIGHT CAME BACK ON A FEW DAYS LATER SO WE BROUGHT BACK TO THE DEALER - THE CONSULTED WITH CHRYSLER AND REPLACED THE CAM PHASERS AND SAID THAT SHOULD FIX THE PROBLEM. WITHIN A COUPLE OF DAYS THE CHECK ENGINE LIGHT AND TR…

Read full complaint

CHECK ENGINE LIGHT CAME ON IN EARLY DECEMBER. DEALER RESET THE ERROR CODE AND SAID IT WAS PROBABLY NOTHING. LIGHT CAME BACK ON A FEW DAYS LATER SO WE BROUGHT BACK TO THE DEALER - THE CONSULTED WITH CHRYSLER AND REPLACED THE CAM PHASERS AND SAID THAT SHOULD FIX THE PROBLEM. WITHIN A COUPLE OF DAYS THE CHECK ENGINE LIGHT AND TRACTION CONTROL LIGHT BOTH CAME ON AND THE CAR LOST ALL ABILITY TO ACCELERATE. DRIVING ON HIGHWAY AT 70MPH, GAS PEDAL TO THE GROUND DID NOTHING AND CAR COASTED TO 50MPH BEFORE IT WOULD LURCH FORWARD AND COAST BACK DOWN AND EVENTUALLY CORRECTED ITSELF BUT LIGHTS REMAINED ON. DEALER CONSULTED WITH CHRYSLER AGAIN AND THEY REPLACED THE CAM PHASER SENSORS AND SAID THAT SHOULD FIX IT. WITHIN A FEW DAYS SAME THING HAPPENED, DRIVING ON HIGHWAY, CHECK ENGINE AND TRACTION CONTROL LIGHT TURNED ON AND CAR LOST ALL ACCELERATION AND COASTED DOWN TO 50MPH AND WOULD LURCH FORWARD AND THEN COST DOWN - RPMS WOULDN'T GO ABOVE 1300RPM AND COULDN'T GET ACCELERATION BACK. TOOK CAR BACK TO DEALER (FORTUNATELY WAS ONLY A FEW MILES FROM THE DEALER) AND THEY HAD IT FOR 2 WEEKS AND CHRYSLER RECOMMENDED REPLACING BOTH WIRING HARNESSES AND THAT SHOULD FIX THE PROBLEM. WITHIN A WEEK, SAME PROBLEM, DRIVING ON HIGHWAY AT 70MPH - CHECK ENGINE AND TRACTION CONTROL LIGHT COMES ON, NO ABILITY TO ACCELERATE OR MAINTAIN SPEED, CAR COASTED DOWN TO 50MPH AND WOULD LURCH FORWARD AND COST BACK DOWN. RETURNING CAR TO DEALER AGAIN (MID FEBRUARY). QUITE DANGEROUS TO (REPEATEDLY) LOOSE ACCELERATION AND WITH NO ABILITY TO MAINTAIN SPEED WHEN DRIVING AT 70MPH ON A HIGHWAY. *TR

NHTSA ODI #10448544

1,500 miles · Jul 22, 2011
Electrical SystemEngine And Engine CoolingSeat BeltsInjury

TL* THE CONTACT OWNS A 2011 DODGE GRAND CARAVAN. THE CONTACT STATED THAT THE CHECK ENGINE LIGHT WAS ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THEY ADVISED THAT THERE WAS AN ELECTRICAL ISSUE AND THEY RESET THE SYSTEM. LATER, WHILE DRIVING AT HIGHWAY SPEEDS THE VEHICLE SUDDENLY DECELERATED BEFORE STALLING. THE CONTAC…

Read full complaint

TL* THE CONTACT OWNS A 2011 DODGE GRAND CARAVAN. THE CONTACT STATED THAT THE CHECK ENGINE LIGHT WAS ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THEY ADVISED THAT THERE WAS AN ELECTRICAL ISSUE AND THEY RESET THE SYSTEM. LATER, WHILE DRIVING AT HIGHWAY SPEEDS THE VEHICLE SUDDENLY DECELERATED BEFORE STALLING. THE CONTACT WAS ABLE TO RESTART THE VEHICLE AND IT WAS TAKEN BACK TO THE DEALER WHERE SHE WAS ADVISED THAT THE CAM SENSOR HAD MALFUNCTIONED. THE VEHICLE WAS NOT REPAIRED. IN ADDITION, THE DRIVER SIDE REAR THIRD ROW SEAT BELT SUDDENLY LOCKED WITH A PASSENGER IN THE SEAT. WHILE TRYING TO LOOSEN THE SEATBELT, IT ONLY CONTINUED TO TIGHTEN AROUND THE PASSENGER. THE SEAT BELT WAS EVENTUALLY CUT AND THE PASSENGER RECEIVED MINOR BRUISES TO THE ABDOMEN AS A RESULT. THE VEHICLE WAS TAKEN TO THE DEALER AGAIN WHERE THEY REPLACED THE SEAT BELT. THE FAILURE MILEAGE WAS APPROXIMATELY 1,500 AND THE CURRENT MILEAGE WAS APPROXIMATELY 4,200.

NHTSA ODI #10414706

Official recalls

4

25V876000 · Equipment Adaptive/mobility:wheelchair Restraints/securement:latch/anchor:

Dec 17, 2025

Rollx Vans (Rollx) is recalling certain GMC Yukon, Sierra, Chevrolet Express 2500, Ford Transit, E-250, Toyota Sienna, Sienna Hybrid, Honda Odyssey, Chrysler Town and Country, Voyager, Pacifica, Dodge Grand Caravan, and Ram Promaster vehicles equipped with QRT-Deluxe and QRT-Max wheelchair restraints. Please refer to Rollx's recall report for specific model year information. The retractors may not lock, preventing the wheelchair from being properly secured.

Consequence & remedy

Consequence: An unsecured wheelchair can move during transit, increasing the risk of injury.

Remedy: Rollx will work with Q'Straint to inspect and replace the retractors as necessary, free of charge. Owner notification letters were mailed February 5, 2026. Owners may contact Rollx's customer service at 1-800-956-6668.

17V376000 · Air Bags:frontal

Jun 13, 2017

Chrysler (FCA US LLC) is recalling certain 2011-2012 Dodge Grand Caravan vehicles. In the affected vehicles, the driver's frontal air bag may unexpectedly deploy if the air bag wiring harness gets chafed within the steering wheel and short circuits.

Consequence & remedy

Consequence: Unexpected deployment of the driver's frontal air bag increases the risk of a crash or driver injury.

Remedy: Chrysler will notify owners, and dealers will inspect the air bag wiring within the steering wheel, replacing it if necessary. A protective cover will also be installed. These repairs will be made free of charge. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is T33.

14V234000 · Electrical System

May 7, 2014

Chrysler Group, LLC (Chrysler) is recalling certain model year 2010-2014 Chrysler Town and Country and Dodge Grand Caravan vehicles manufactured August 25, 2010, through October 31, 2013. The affected vehicles may experience overheating of the vent window switch in the driver's door armrest.

Consequence & remedy

Consequence: An overheated switch may result in a vehicle fire.

Remedy: Chrysler will notify owners, and dealers will replace the vent window switch with a newer version, free of charge. The owner notification letter was issued and the remedy campaign launched on on December 31, 2014. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is P25.

11V315000 · Steering:column

Jun 8, 2011

CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2011DODGE JOURNEY, JEEP WRANGLER, CHRYSLER 200, CHRYSLER 200 CONVERTIBLE, DODGE AVENGER, DODGE NITRO, JEEP LIBERTY, DODGE CALIBER, JEEP COMPASS, JEEP PATRIOT, DODGE GRAND CARAVAN AND CHRYSLER TOWN & COUNTRY VEHICLES. SOME OF THESE VEHICLES MAY HAVE BEEN BUILT WITH A MISSING OR INCORRECTLY INSTALLED STEERING COLUMN PIVOT RIVET.

Consequence & remedy

Consequence: A MISSING OR INCORRECTLY INSTALLED RIVET COULD COMPROMISE THE ABILITY OF THE STEERING COLUMN TO SUPPORT THE OCCUPANT LOADS IN THE EVENT OF A FRONTAL CRASH, DECREASING THE EFFECTIVENESS OF THE FRONTAL IMPACT SAFETY SYSTEM. AS A RESULT, THE CONDITION MAY INCREASE THE POTENTIAL FOR INJURY IN A FRONTAL CRASH.

Remedy: DEALERS WILL INSPECT FOR RIVET PRESENCE AND ALIGNMENT AND REPAIR THE STEERING COLUMN PIVOT AS REQUIRED, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JULY 4, 2011. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

2

PE19014 · Active Head Rest Inadvertent Deployment

Opened Sep 9, 2019 · Closed Feb 25, 2026

Status: closed (inferred from source dates) · Seats; Seats:front Assembly:head Restraint

The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

Additional source detail variants (2)

Seats

The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

Seats:front Assembly:head Restraint

The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

DP14004 · Totally Integrated Power Module Failure

Opened Sep 25, 2014 · Closed Jul 24, 2015

Status: closed (inferred from source dates) · Electrical System

In a letter dated August 21, 2014, the Center for Auto Safety (CAS) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged failures associated with the Totally Integrated Power Module (TIPM) installed in Chrysler SUV?s, trucks, and vans beginning in the 2007 model year. The petitioner alleges that TIPM defects may result in engine stall, airbag non-deployment, failure of fuel pump shutoff resulting in unintended acceleration, fire, and other symptoms. On September 25, 2014, the Office of Defects Investigation (ODI) opened DP14-004 to evaluate the petition for a grant or deny decision. ODI analyzed complaint data provided by CAS as well as complaints submitted to ODI from consumers. In total, there were 296 complaints submitted by the petitioner in the original petition and five supplements, including 271 complaints related to the subject vehicles equipped with TIPM-7. Approximately 3 percent of CAS complaints are related to vehicles equipped with TIPM-6 and ODI?s review of these complaints did not identify any safety defect trends. ODI conducted a detailed review of complaints narratives submitted by CAS and consumers including careful analysis of vehicle repair histories, warranty claims obtained from the manufacturer and any available Customer Assistance Inquiry reports (CAIR). Analysis of the field data indicated that MY2011-2013 Jeep Grand Cherokee and Dodge Durango vehicles exhibited significantly higher complaint rates related to fuel pump relay (FPR) failures than other subject vehicles. In a September 3, 2014 letter to NHTSA, Chrysler submitted a Defect Information Report (DIR) identifying a defect in the FPR within the TIPM-7 which can result in a no start or stall condition in approximately 188,723 model year (MY) 2011 Jeep Grand Cherokee (WK) and Dodge Durango (WD) vehicles manufactured from January 5, 2010 through July 20, 2011 (14V-530).In a February 24, 2015 letter, Chrysler submitted a second DIR expanding the scope of the FPR defect condition to include an additional 338,216 MY 2012 through 2013 Jeep Grand Cherokee vehicles manufactured from September 17, 2010 through August 19, 2013 and MY 2012 through 2013 Dodge Durango vehicles manufactured from January 18, 2011 through August 19, 2013 (15V-115).ODI analysis of the CAS allegations of TIPM defects resulting in stall while driving, airbag non-deployment, unintended acceleration, fire and other faults identified a single defect condition related to 1 of over 60 different circuits in the TIPM assembly. The most common effect of this defect condition, related to the fuel pump relay, was a no-start concern, but it could also result in stall while driving (76 complaints). No valid evidence was presented in support of claims related to airbag non-deployment, unintended acceleration or fire resulting from TIPM faults and these claims were found to be wholly without merit based on review of the field data and design of the relevant systems and components.Except insofar as the petitioner's contentions relate to the defect condition addressed by the Chrysler recalls, the factual bases of the petitioner's contentions that any further investigation is necessary are unsupported. In our view, additional investigation is unlikely to result in a finding that a defect related to motor vehicle safety exists or a NHTSA order for the notification and remedy of a safety-related defect as alleged by the petitioner at the conclusion of the requested investigation. Therefore, in view of the need to allocate and prioritize NHTSA's limited resources to best accomplish the agency's safety mission, the petition is den