← New search

2011 Dodge Grand Caravan

Owner reports · Recalls · Investigations

Similar to other model years

Owner complaints for the 2011 Dodge Grand Caravan do not stand out strongly from the model-year median of 284.

About this comparison →

When problems were reported

Mileage at the reported incident

383 reports with mileage · 147 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Electrical System. Review the 332 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Fuel/propulsion System. Review the 127 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Engine. Review the 92 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

9 crash reports17 fire reports15 injury reports

Electronic Stability Control (esc) complaints

26 reports
Clear category filter
930,027 miles · Oct 9, 2020
Electrical SystemElectronic Stability Control (esc)Fuel/propulsion System

OCTOBER 8,2020 I WAS DRIVING STRAIGHT DOWN HILL ON A CITY STREET IN PUYALLUP, WA WHEN THE CAR COMPLETELY SHUT DOWN WITHOUT WARNING. I HAD NO STEERING, BRAKES, OR ANYWAY TO CONTROL THE VEHICLE. I MANAGED TO COAST INTO A NEARBY LOWES HARDWARE PARKING LOT AND RAN INTO A BARRIER IN ORDER TO STOP. I WAS LUCKY THERE WERE NO PEOPLE OR …

Read full complaint

OCTOBER 8,2020 I WAS DRIVING STRAIGHT DOWN HILL ON A CITY STREET IN PUYALLUP, WA WHEN THE CAR COMPLETELY SHUT DOWN WITHOUT WARNING. I HAD NO STEERING, BRAKES, OR ANYWAY TO CONTROL THE VEHICLE. I MANAGED TO COAST INTO A NEARBY LOWES HARDWARE PARKING LOT AND RAN INTO A BARRIER IN ORDER TO STOP. I WAS LUCKY THERE WERE NO PEOPLE OR OTHER CARS IN MY PATH OF TRAVEL WHEN I ENTERED AS I WAS UNABLE TO STOP. I CALLED MY INSURER, GEICI, AND ARRANGED FOR THE VEHICLE TO BE TOWED. TOWING WAS PERFORMED BY ENGELS TOWING , PUYALLUP, WA (253) 845-0034. CHECKING ONLINE I DISCOVERED THAT THIS IS A KNOWN PROBLEM WITH THE FUEL PUMP AND NO RECALL HAS BEEN ISSUED. I BELIEVE THAT THIS IS A SERIOUS SAFETY ISSUE. I, MY FAMILY, OR OTHERS COULD HAVE BEEN SERIOULY INJURED OR KILLED.

NHTSA ODI #11363556

175,000 miles · Mar 10, 2020
Electrical SystemElectronic Stability Control (esc)Unknown Or Other

SLIDING PASSENGER DOORS ON BOTH SIDES OF VAN REFUSE TO OPEN OR UNLOCK. DOORS CANNOT BE OPENED MANUALLY, WITH KEY FOB OR WITH THE BUTTON ON THE INTERIOR OF THE CAR. THIS PREVENTS PASSENGERS IN REAR (USUALLY CHILDREN) FROM BEING ABLE TO EXIT THE VEHICLE, WHICH COULD BE PARTICULARLY DANGEROUS IN THE EVENT OF A CRASH.

NHTSA ODI #11317196

130,000 miles · Feb 3, 2020
Electronic Stability Control (esc)

TL* THE CONTACT OWNS A 2011 DODGE GRAND CARAVAN. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 50 MPH, THE VEHICLE STALLED. THE CONTACT COASTED TO THE SHOULDER. THE ELECTRONIC STABILITY CONTROL AND THE SECURITY INDICATOR WARNING LIGHTS ILLUMINATED. THE VEHICLE WAS TOWED TO THE RESIDENCE. THE VEHICLE WAS NOT TAKEN TO THE DE…

Read full complaint

TL* THE CONTACT OWNS A 2011 DODGE GRAND CARAVAN. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 50 MPH, THE VEHICLE STALLED. THE CONTACT COASTED TO THE SHOULDER. THE ELECTRONIC STABILITY CONTROL AND THE SECURITY INDICATOR WARNING LIGHTS ILLUMINATED. THE VEHICLE WAS TOWED TO THE RESIDENCE. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR A DIAGNOSTIC. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 130,000. THE VIN WAS NOT AVAILABLE.

NHTSA ODI #11306688

Mileage unknown · Jul 7, 2019
Electrical SystemElectronic Stability Control (esc)Exterior Lighting

2011 DODGE GRAND CARAVAN HAD A FAULTY TIPM AND IS A KNOWN PROBLEM COSTING WELL OVER $1500.00 AT DODGE TO GET A NEW TIPM. THIS EFFECTS THE STABILITY CONTROL MODULE, THE TRANSMISSION ELECTRONIC SHIFTING, THE BRAKE LIGHTS AND THE AIR CONDITIONING JUST TO NAME A FEW ISSUES. WE HAVE REACHED OUT TO DODGE AND THEY WILL NOT COVER IT.

NHTSA ODI #11229875

61,000 miles · Jun 25, 2019
Electrical SystemElectronic Stability Control (esc)Fuel/propulsion System

VAN WOULD TURN OVER BUT NOT START. THIS CONTINUES TO HAPPEN OVER AND OVER. THE DEALERSHIP TOLD ME I NEEDED A NEW TIPM AND FUEL PUMP. BUT FOUND OUT THIS IS A VERY COMMON PROBLEM, AND THEY ISSUED A RECALL FOR OTHER VEHICLES WITH THIS SAME PART. IT IS THE FUEL RELAY SWITCH INSIDE OF TIPM THAT GOES BAD. IT SEEMS THE FUEL PUMP IS FI…

Read full complaint

VAN WOULD TURN OVER BUT NOT START. THIS CONTINUES TO HAPPEN OVER AND OVER. THE DEALERSHIP TOLD ME I NEEDED A NEW TIPM AND FUEL PUMP. BUT FOUND OUT THIS IS A VERY COMMON PROBLEM, AND THEY ISSUED A RECALL FOR OTHER VEHICLES WITH THIS SAME PART. IT IS THE FUEL RELAY SWITCH INSIDE OF TIPM THAT GOES BAD. IT SEEMS THE FUEL PUMP IS FINE. I CAN BUY A REPAIR PART VERY CHEAP. THIS IS PLASTERED ALL OVER ONLINE AND I THINK THIS IS A KNOWN PROBLEM AND SHOULD BE A RECALL!

NHTSA ODI #11222595

Mileage unknown · Feb 6, 2019
Electrical SystemElectronic Stability Control (esc)Fuel/propulsion System

CAR INCIDENTALLY DOES T START !!!! DELAY FUEL PUMP TIPM DOESN'T WORK PROPERLY !

NHTSA ODI #11174681

50,000 miles · May 22, 2018
Electronic Stability Control (esc)Tires

TL* THE CONTACT OWNS A 2011 DODGE GRAND CARAVAN. WHILE DRIVING UNKNOWN SPEEDS, THE TIRE PRESSURE MONITORING SYSTEM (TPMS) INDICATOR SPONTANEOUSLY ILLUMINATED. ADDITIONALLY, THE CONTACT HEARD AN ABNORMAL NOISE. THE CONTACT WAS UNABLE TO DETERMINE IF THERE WAS A FAILURE WITH THE TIRES SINCE THE TPMS INDICATOR WAS ILLUMINATED. THE …

Read full complaint

TL* THE CONTACT OWNS A 2011 DODGE GRAND CARAVAN. WHILE DRIVING UNKNOWN SPEEDS, THE TIRE PRESSURE MONITORING SYSTEM (TPMS) INDICATOR SPONTANEOUSLY ILLUMINATED. ADDITIONALLY, THE CONTACT HEARD AN ABNORMAL NOISE. THE CONTACT WAS UNABLE TO DETERMINE IF THERE WAS A FAILURE WITH THE TIRES SINCE THE TPMS INDICATOR WAS ILLUMINATED. THE VEHICLE WAS TAKEN TO FERRARIO CHRYSLER TOWANDA (168 GOLDEN MILE RD, TOWANDA, PA 18848, (570) 485-0072) WHERE IT WAS DIAGNOSED THAT THE CODES NEEDED TO BE RESET. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED AND OPENED CASE NUMBER: 33719903. THE CONTACT WAS INFORMED THAT THE VEHICLE WAS NOT COVERED UNDER WARRANTY. THE FAILURE MILEAGE WAS 50,000.

NHTSA ODI #11097202

103,000 miles · Apr 14, 2018
Electronic Stability Control (esc)

TIPM IS BAD ON VEHICLE, CONFIRMED BY RICK KEFFER DODGE CHRYSLER JEEP RAM DEALERSHIP IN YULEE, FL TWO YEARS AGO. VEHICLE STALLED ON HIGHWAY AND THEN LATER WOULD NOT START. PURCHASED A BYPASS CABLE IN ORDER TO KEEP USING THE VEHICLE AND WHILE DRIVING WE GET INDICATOR LIGHTS FLASHING ON DASHBOARD SUCH AS BRAKE ON WHEN IT'S NOT, S…

Read full complaint

TIPM IS BAD ON VEHICLE, CONFIRMED BY RICK KEFFER DODGE CHRYSLER JEEP RAM DEALERSHIP IN YULEE, FL TWO YEARS AGO. VEHICLE STALLED ON HIGHWAY AND THEN LATER WOULD NOT START. PURCHASED A BYPASS CABLE IN ORDER TO KEEP USING THE VEHICLE AND WHILE DRIVING WE GET INDICATOR LIGHTS FLASHING ON DASHBOARD SUCH AS BRAKE ON WHEN IT'S NOT, SEATBELT LIGHT ON WHEN SEATBELTS ARE BUCKLED, LIGHTS FLASHING OR STAYING ON WHEN TURNED OFF. THIS IS A MAJOR SAFETY ISSUE !!! I HAVE THREE KIDS, AGES 13, 12, AND 10 AND THIS IS OUR PRIMARY FAMILY VEHICLE. THE TIPM HAS ALREADY BEEN RECALLED FOR OTHER MAKE AND MODELS WITH CHRYSLER DODGE JEEP FOR 2011-2014 BUT NOT THE GRAND CARAVANS.

NHTSA ODI #11085070

98,147 miles · Feb 12, 2018
Electrical SystemElectronic Stability Control (esc)Fuel/propulsion System

FEBRUARY 2,2018 DODGE GRAND CARAVAN TURNED OFF AND PARKED IN DRIVE WAY MY DAUGHTER COMES IN AND SAID THE VAN SOUNDS LIKE IT'S STILL RUNNING WENT OUT AND HEARD WHAT SHE HEARD ALSO CHECK ON THIS THREE TIMES BEFORE GOING TO BED( THIS NOISE CAME FROM THE GAS TANK). THE NEXT DAY 02/03/2018 NOISE WAS NOT THERE ANYMORE. I HAD SCHEDULE …

Read full complaint

FEBRUARY 2,2018 DODGE GRAND CARAVAN TURNED OFF AND PARKED IN DRIVE WAY MY DAUGHTER COMES IN AND SAID THE VAN SOUNDS LIKE IT'S STILL RUNNING WENT OUT AND HEARD WHAT SHE HEARD ALSO CHECK ON THIS THREE TIMES BEFORE GOING TO BED( THIS NOISE CAME FROM THE GAS TANK). THE NEXT DAY 02/03/2018 NOISE WAS NOT THERE ANYMORE. I HAD SCHEDULE RECALL WORK TO BE PERFORM ON 02/05/2018 BUT RE-SCHEDULE WITH SERVICE ADVISOR FOR 02/06/2018 CAR WOULD NOT START KEY STUCK IN IGNITION SWITCH. TOW TRUCK PICKED UP 02/07/2018 TOOK TO DEALERSHIP EXPLAIN WHAT HAPPEN I WAS TOLD BY THE SERVICE ADVISOR TO EXPECT A CALL ON FRIDAY 02/09/2018 CALL CAME DEAD BATTERY(NEW BATTERY 01/24/2018) AND THE TIPM KIT WAS NEEDED. THIS VEHICLE 2011 DODGE GRAND CARAVAN TIPM SHOULD BE LISTED AS A RECALL. I STARTED LAST YEAR HAVING STARTING CONCERNS WITH THIS VAN NOT WANTING TO START.

NHTSA ODI #11072388

Mileage unknown · Nov 20, 2017
Electronic Stability Control (esc)

I HAVE COMPLAINT REGARDING TIPM BUT NOW MY BATTERY IS DRAINED AND CAR WON'T TURN ON. WHEN IS DODGE GOING TO STEP IN AND HELP THOUSANDS OF PEOPLE WITH SAME PROBLEM BEFORE SOMEONE DIES BC VAN TURN OFF WHILE DRIVING AND FAMILY SUES? WHY IT HAS TO TAKE A TRAGIC ACCIDENT BEFORE DODGE STEPS IN? I'M SURE AM NOT THE ONLY ONE WITH CHILDR…

Read full complaint

I HAVE COMPLAINT REGARDING TIPM BUT NOW MY BATTERY IS DRAINED AND CAR WON'T TURN ON. WHEN IS DODGE GOING TO STEP IN AND HELP THOUSANDS OF PEOPLE WITH SAME PROBLEM BEFORE SOMEONE DIES BC VAN TURN OFF WHILE DRIVING AND FAMILY SUES? WHY IT HAS TO TAKE A TRAGIC ACCIDENT BEFORE DODGE STEPS IN? I'M SURE AM NOT THE ONLY ONE WITH CHILDREN DRIVING AND STILL PAYING FOR THIS GARBAGE VAN. I WILL NEVER BUY DODGE AGAIN. GETTING A LAWYER.

NHTSA ODI #11047384

Official recalls

4

25V876000 · Equipment Adaptive/mobility:wheelchair Restraints/securement:latch/anchor:

Dec 17, 2025

Rollx Vans (Rollx) is recalling certain GMC Yukon, Sierra, Chevrolet Express 2500, Ford Transit, E-250, Toyota Sienna, Sienna Hybrid, Honda Odyssey, Chrysler Town and Country, Voyager, Pacifica, Dodge Grand Caravan, and Ram Promaster vehicles equipped with QRT-Deluxe and QRT-Max wheelchair restraints. Please refer to Rollx's recall report for specific model year information. The retractors may not lock, preventing the wheelchair from being properly secured.

Consequence & remedy

Consequence: An unsecured wheelchair can move during transit, increasing the risk of injury.

Remedy: Rollx will work with Q'Straint to inspect and replace the retractors as necessary, free of charge. Owner notification letters were mailed February 5, 2026. Owners may contact Rollx's customer service at 1-800-956-6668.

17V376000 · Air Bags:frontal

Jun 13, 2017

Chrysler (FCA US LLC) is recalling certain 2011-2012 Dodge Grand Caravan vehicles. In the affected vehicles, the driver's frontal air bag may unexpectedly deploy if the air bag wiring harness gets chafed within the steering wheel and short circuits.

Consequence & remedy

Consequence: Unexpected deployment of the driver's frontal air bag increases the risk of a crash or driver injury.

Remedy: Chrysler will notify owners, and dealers will inspect the air bag wiring within the steering wheel, replacing it if necessary. A protective cover will also be installed. These repairs will be made free of charge. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is T33.

14V234000 · Electrical System

May 7, 2014

Chrysler Group, LLC (Chrysler) is recalling certain model year 2010-2014 Chrysler Town and Country and Dodge Grand Caravan vehicles manufactured August 25, 2010, through October 31, 2013. The affected vehicles may experience overheating of the vent window switch in the driver's door armrest.

Consequence & remedy

Consequence: An overheated switch may result in a vehicle fire.

Remedy: Chrysler will notify owners, and dealers will replace the vent window switch with a newer version, free of charge. The owner notification letter was issued and the remedy campaign launched on on December 31, 2014. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is P25.

11V315000 · Steering:column

Jun 8, 2011

CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2011DODGE JOURNEY, JEEP WRANGLER, CHRYSLER 200, CHRYSLER 200 CONVERTIBLE, DODGE AVENGER, DODGE NITRO, JEEP LIBERTY, DODGE CALIBER, JEEP COMPASS, JEEP PATRIOT, DODGE GRAND CARAVAN AND CHRYSLER TOWN & COUNTRY VEHICLES. SOME OF THESE VEHICLES MAY HAVE BEEN BUILT WITH A MISSING OR INCORRECTLY INSTALLED STEERING COLUMN PIVOT RIVET.

Consequence & remedy

Consequence: A MISSING OR INCORRECTLY INSTALLED RIVET COULD COMPROMISE THE ABILITY OF THE STEERING COLUMN TO SUPPORT THE OCCUPANT LOADS IN THE EVENT OF A FRONTAL CRASH, DECREASING THE EFFECTIVENESS OF THE FRONTAL IMPACT SAFETY SYSTEM. AS A RESULT, THE CONDITION MAY INCREASE THE POTENTIAL FOR INJURY IN A FRONTAL CRASH.

Remedy: DEALERS WILL INSPECT FOR RIVET PRESENCE AND ALIGNMENT AND REPAIR THE STEERING COLUMN PIVOT AS REQUIRED, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JULY 4, 2011. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

2

PE19014 · Active Head Rest Inadvertent Deployment

Opened Sep 9, 2019 · Closed Feb 25, 2026

Status: closed (inferred from source dates) · Seats; Seats:front Assembly:head Restraint

The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

Additional source detail variants (2)

Seats

The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

Seats:front Assembly:head Restraint

The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

DP14004 · Totally Integrated Power Module Failure

Opened Sep 25, 2014 · Closed Jul 24, 2015

Status: closed (inferred from source dates) · Electrical System

In a letter dated August 21, 2014, the Center for Auto Safety (CAS) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged failures associated with the Totally Integrated Power Module (TIPM) installed in Chrysler SUV?s, trucks, and vans beginning in the 2007 model year. The petitioner alleges that TIPM defects may result in engine stall, airbag non-deployment, failure of fuel pump shutoff resulting in unintended acceleration, fire, and other symptoms. On September 25, 2014, the Office of Defects Investigation (ODI) opened DP14-004 to evaluate the petition for a grant or deny decision. ODI analyzed complaint data provided by CAS as well as complaints submitted to ODI from consumers. In total, there were 296 complaints submitted by the petitioner in the original petition and five supplements, including 271 complaints related to the subject vehicles equipped with TIPM-7. Approximately 3 percent of CAS complaints are related to vehicles equipped with TIPM-6 and ODI?s review of these complaints did not identify any safety defect trends. ODI conducted a detailed review of complaints narratives submitted by CAS and consumers including careful analysis of vehicle repair histories, warranty claims obtained from the manufacturer and any available Customer Assistance Inquiry reports (CAIR). Analysis of the field data indicated that MY2011-2013 Jeep Grand Cherokee and Dodge Durango vehicles exhibited significantly higher complaint rates related to fuel pump relay (FPR) failures than other subject vehicles. In a September 3, 2014 letter to NHTSA, Chrysler submitted a Defect Information Report (DIR) identifying a defect in the FPR within the TIPM-7 which can result in a no start or stall condition in approximately 188,723 model year (MY) 2011 Jeep Grand Cherokee (WK) and Dodge Durango (WD) vehicles manufactured from January 5, 2010 through July 20, 2011 (14V-530).In a February 24, 2015 letter, Chrysler submitted a second DIR expanding the scope of the FPR defect condition to include an additional 338,216 MY 2012 through 2013 Jeep Grand Cherokee vehicles manufactured from September 17, 2010 through August 19, 2013 and MY 2012 through 2013 Dodge Durango vehicles manufactured from January 18, 2011 through August 19, 2013 (15V-115).ODI analysis of the CAS allegations of TIPM defects resulting in stall while driving, airbag non-deployment, unintended acceleration, fire and other faults identified a single defect condition related to 1 of over 60 different circuits in the TIPM assembly. The most common effect of this defect condition, related to the fuel pump relay, was a no-start concern, but it could also result in stall while driving (76 complaints). No valid evidence was presented in support of claims related to airbag non-deployment, unintended acceleration or fire resulting from TIPM faults and these claims were found to be wholly without merit based on review of the field data and design of the relevant systems and components.Except insofar as the petitioner's contentions relate to the defect condition addressed by the Chrysler recalls, the factual bases of the petitioner's contentions that any further investigation is necessary are unsupported. In our view, additional investigation is unlikely to result in a finding that a defect related to motor vehicle safety exists or a NHTSA order for the notification and remedy of a safety-related defect as alleged by the petitioner at the conclusion of the requested investigation. Therefore, in view of the need to allocate and prioritize NHTSA's limited resources to best accomplish the agency's safety mission, the petition is den