NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
548 reportsClear category filter58,000 miles · May 6, 2013
Electrical System
TL* THE CONTACT OWNS A 2010 DODGE GRAND CARAVAN. THE CONTACT STATED THAT THERE WAS A SEPARATE PLASTIC KEY TO START THE VEHICLE WHICH WAS FRACTURED ON ONE SIDE. THE CONTACT STATED THAT AFTER THE VEHICLE WAS PARKED AND ATTEMPTED TO SHUT OFF THE VEHICLE, THE VEHICLE FAILED TO TURN OFF. THE IGNITION REMAINED SEIZED ON THE ACC MODE. …
Read full complaint
TL* THE CONTACT OWNS A 2010 DODGE GRAND CARAVAN. THE CONTACT STATED THAT THERE WAS A SEPARATE PLASTIC KEY TO START THE VEHICLE WHICH WAS FRACTURED ON ONE SIDE. THE CONTACT STATED THAT AFTER THE VEHICLE WAS PARKED AND ATTEMPTED TO SHUT OFF THE VEHICLE, THE VEHICLE FAILED TO TURN OFF. THE IGNITION REMAINED SEIZED ON THE ACC MODE. THE CONTACT RESTARTED VEHICLE IN ORDER TO UNLOCK THE IGNITION AND TURN VEHICLE OFF. THE VEHICLE WAS NOT TAKEN TO A REPAIR SHOP OR THE DEALER FOR A DIAGNOSTIC TEST. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE BUT PROVIDED NO FURTHER ASSISTANCE. THE FAILURE MILEAGE WAS 58,000. THE CURRENT MILEAGE WAS 58,800.
NHTSA ODI #10510848
27,500 miles · Feb 25, 2013
Electrical System
TL* THE CONTACT OWNS A 2010 DODGE GRAND CARAVAN. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 35 MPH THE VEHICLE STALLED WITHOUT WARNING. THE FAILURE RECURRED FIVE TIMES INTERMITTENTLY. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE TECHNICIAN WAS UNABLE TO DUPLICATE OR DIAGNOSE THE FAILURE. THE CONTACT R…
Read full complaint
TL* THE CONTACT OWNS A 2010 DODGE GRAND CARAVAN. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 35 MPH THE VEHICLE STALLED WITHOUT WARNING. THE FAILURE RECURRED FIVE TIMES INTERMITTENTLY. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE TECHNICIAN WAS UNABLE TO DUPLICATE OR DIAGNOSE THE FAILURE. THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER: 11V139000 (ELECTRICAL SYSTEM) BUT WAS ADVISED BY THE MANUFACTURER THAT THE VIN WAS NOT INCLUDED IN THE RECALL. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 27,500.
NHTSA ODI #10499965
25,338 miles · Feb 13, 2013
Electrical SystemEngine
JAN 31, 2:00PM I PARKED THE VEHICLE TO PICK MY SON UP FROM PRE-SCHOOL. AFTER SECURING MY CHILDREN TO THEIR RESPECTIVE CAR SEATS, I BUCKLED MYSELF IN AND PROCEEDED TO START THE ENGINE, THE VEHICLE'S ENGINE WOULD NOT START. STRONG ELECTRICAL-SMELLING FUMES WERE EMITTED AND THE ETC LIGHT CAME ON. WE HAD THE VEHICLE TOWED TO A JEE…
Read full complaint
JAN 31, 2:00PM I PARKED THE VEHICLE TO PICK MY SON UP FROM PRE-SCHOOL. AFTER SECURING MY CHILDREN TO THEIR RESPECTIVE CAR SEATS, I BUCKLED MYSELF IN AND PROCEEDED TO START THE ENGINE, THE VEHICLE'S ENGINE WOULD NOT START. STRONG ELECTRICAL-SMELLING FUMES WERE EMITTED AND THE ETC LIGHT CAME ON. WE HAD THE VEHICLE TOWED TO A JEEP, DODGE, & CHRYSLER DEALERSHIP FOR SERVICING FOR 5 DAYS. THE SERVICE TECH INSISTED THAT NOTHING WAS DETECTED ASIDE FROM SLIGHT CORROSION IN THE BATTERY PLUGS, WHICH NEEDED TO BE REPLACED. WE DID WHAT WAS ADVISED AND TOOK OUR VEHICLE BACK ON FEB 6. FEB 13, 9:45AM AFTER MAKING A QUICK STOP AT A GROCERY STORE, THE SAME PROBLEM OCCURRED. THE VEHICLE ENGINE WOULD NOT START, BUT THE RADIO WAS COMING ON. I TURNED OFF THE VEHICLE AND PROCEEDED TO RESTART THE VEHICLE. ONCE AGAIN THE ETC LIGHT CAME ON AND THIS TIME, WHITE SMOKE WAS COMING OUT FROM UNDER THE HOOD. AFTER SEEING THE SMOKE, I QUICKLY TURNED OFF THE VEHICLE AND TOOK MY CHILD OUT. OUR VEHICLE IS NOW STRANDED IN THE PARKING LOT OF A GROCERY STORE WAITING TO BE TOWED TO THE SAME DEALERSHIP. *TR
NHTSA ODI #10498058
49,000 miles · Feb 11, 2013
Electrical System
I WAS DRIVING DOWN THE EXPRESS WAY AT 75 MPH AND THE CAR COMPLETELY SHUT OFF. THE CAR DIED AND EVERYTHING SHUT OFF (LIGHTS, HEATING, ENGINE) I WAS ABLE TO COAST TO THE SIDE OF THE EXPRESS WAY. I CALMED MYSELF DOWN AND STARTED THE CAR UP AGAIN AND DROVE HOME. THE IGNITION RING RECALL WAS ALREADY REPLACED BACK IN 2011 BEFORE WE …
Read full complaint
I WAS DRIVING DOWN THE EXPRESS WAY AT 75 MPH AND THE CAR COMPLETELY SHUT OFF. THE CAR DIED AND EVERYTHING SHUT OFF (LIGHTS, HEATING, ENGINE) I WAS ABLE TO COAST TO THE SIDE OF THE EXPRESS WAY. I CALMED MYSELF DOWN AND STARTED THE CAR UP AGAIN AND DROVE HOME. THE IGNITION RING RECALL WAS ALREADY REPLACED BACK IN 2011 BEFORE WE OWNED THE VAN. WE HAD A 2ND INCIDENT THAT HAPPENED ON FEBRUARY 6TH. THIS TIME I WAS DRIVING IN A PARKING LOT AND IT DIED AGAIN. I TURNED ON MY HAZARDS AND STARTED THE VAN AGAIN AND IT STARTED RIGHT UP. *TR
NHTSA ODI #10497709
67,477 miles · Jan 14, 2013
Electrical SystemPower Train
TL* THE CONTACT OWNS A 2010 DODGE GRAND CARAVAN. THE CONTACT STATED THAT THE VEHICLE CUT OFF WHILE DRIVING AT 70 MPH. THE CONTACT WAS ABLE TO COAST THE VEHICLE ONTO THE SHOULDER WHERE IT WAS RESTARTED. THE VEHICLE WAS ABLE TO BE DRIVEN TO A PRIVATE MECHANIC WHERE IT WAS FOUND THAT WIN MODULE HAD FAILED. THE VEHICLE WAS NOT REPAI…
Read full complaint
TL* THE CONTACT OWNS A 2010 DODGE GRAND CARAVAN. THE CONTACT STATED THAT THE VEHICLE CUT OFF WHILE DRIVING AT 70 MPH. THE CONTACT WAS ABLE TO COAST THE VEHICLE ONTO THE SHOULDER WHERE IT WAS RESTARTED. THE VEHICLE WAS ABLE TO BE DRIVEN TO A PRIVATE MECHANIC WHERE IT WAS FOUND THAT WIN MODULE HAD FAILED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER INFORMED THE CONTACT THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 11V139000 (ELECTRICAL SYSTEM: IGNITION). THE FAILURE AND THE CURRENT MILEAGE WAS 67,477. UPDATED 2/19/13 UPDATED 02/25/13 UPDATED 02/28/13 UPDATED 04/18/2017 *JS THE CONSUMER STATED AFTER THE VEHICLE WAS PURCHASED, IT BEGAN TO HAVE MECHANICAL PROBLEMS. THE DASHBOARD LIGHTS TO BE SERVICED WOULD TURN ON AND OFF. THE VAN OCCASIONALLY CUT OFF BUT WOULD START UP WITH THE TURN OF THE KEY. THE LIGHT INDICATORS WERE MALFUNCTION INDICATOR LIGHT. ELECTRONIC STABILITY LIGHT, AND THE ELECTRONIC THROTTLE CONTROL. THE WIN MODULE, BATTERY, STARTER, AND OXYGEN SENSORS WERE REPAIRED BY THE OWNER. THE CONSUMER REQUESTED TO BE ADVISED ON WHAT TO DO NEXT. UPDATED 06/19/2017*JS
NHTSA ODI #10492937
38,000 miles · Dec 28, 2012
Electrical System
DRIVING ON INTERSTATE I-90 WHEN I LOST POWER TO WIPERS,TURN SIGNALS,RADIO,POWER WINDOWS. I TOOK THE VAN BACK TO THE DODGE DEALER SINCE THEY HAD FIXED THE WIRELESS IGNITION MODULE UNDER A RECALL NOTICE IN AUGUST OF 2010. I WAS TOLD TO TOUCH THE KEY AND THE POWER WOULD RETURN WHICH IT DID DO.I WAS ALSO TOLD THAT THE PROBLEM OF THE…
Read full complaint
DRIVING ON INTERSTATE I-90 WHEN I LOST POWER TO WIPERS,TURN SIGNALS,RADIO,POWER WINDOWS. I TOOK THE VAN BACK TO THE DODGE DEALER SINCE THEY HAD FIXED THE WIRELESS IGNITION MODULE UNDER A RECALL NOTICE IN AUGUST OF 2010. I WAS TOLD TO TOUCH THE KEY AND THE POWER WOULD RETURN WHICH IT DID DO.I WAS ALSO TOLD THAT THE PROBLEM OF THE KEY TURNING OFF THE ENGINE WAS FIXED UNDER THE RECALL BUT THEY NOW HAVE THIS PROBLEM. SINCE FIRST REPORTING THE PROBLEM IN OCTOBER THIS HAS OCCURRED MORE FREQUENTLY. *TR
NHTSA ODI #10490319
81,153 miles · Dec 26, 2012
Electrical SystemExterior Lighting
WHEN DRIVING ON THE FREEWAY AT NIGHT THE HEADLIGHTS SUDDENLY SHUT OFF THEY WOULD NOT COME BACK ON, NEITHER THE HEADLIGHTS OR THE HIGH BEAMS WOULD WORK, I PUT THE HAZARD LIGHTS ON AND GOT OFF THE ROAD, AFTER THAT THE HEADLIGHTS BLINKED WHEN TURNED ON AND THEN WOULD NOT COME ON AT ALL, AFTER THAT THEY CAME ON AND THEN SHUT BACK O…
Read full complaint
WHEN DRIVING ON THE FREEWAY AT NIGHT THE HEADLIGHTS SUDDENLY SHUT OFF THEY WOULD NOT COME BACK ON, NEITHER THE HEADLIGHTS OR THE HIGH BEAMS WOULD WORK, I PUT THE HAZARD LIGHTS ON AND GOT OFF THE ROAD, AFTER THAT THE HEADLIGHTS BLINKED WHEN TURNED ON AND THEN WOULD NOT COME ON AT ALL, AFTER THAT THEY CAME ON AND THEN SHUT BACK OFF AGAIN WHILE DRIVING ON CITY STREETS, THE HEADLIGHTS TURN OFF WHILE DRIVING OR DO NOT TURN ON AT ALL. *TR
NHTSA ODI #10490162
Mileage unknown · Nov 19, 2012
Electrical SystemEngine And Engine Cooling
2010 DODGE GRAND CARAVAN. CONSUMER WRITES IN REGARDS TO VEHICLE SHUTDOWN WHILE DRIVING. *SMD SHORTLY AFTER THE VEHICLE WAS PURCHASED, THE VEHICLE WOULD FULLY SHUTDOWN; ENGINE OFF, RADIO OFF, POWER LOCKS DISABLED, WINDSHIELD WIPES OFF ETC. THE VEHICLE WAS TAKEN TO THE DEALER SEVERAL TIMES, ONLY TO GET THE VEHICLE BACK, WITH THE…
Read full complaint
2010 DODGE GRAND CARAVAN. CONSUMER WRITES IN REGARDS TO VEHICLE SHUTDOWN WHILE DRIVING. *SMD SHORTLY AFTER THE VEHICLE WAS PURCHASED, THE VEHICLE WOULD FULLY SHUTDOWN; ENGINE OFF, RADIO OFF, POWER LOCKS DISABLED, WINDSHIELD WIPES OFF ETC. THE VEHICLE WAS TAKEN TO THE DEALER SEVERAL TIMES, ONLY TO GET THE VEHICLE BACK, WITH THE PROBLEM STILL PRESENT. *JB
NHTSA ODI #10485505
36,360 miles · Sep 26, 2012
Electrical SystemPower Train
THE CAR SHIFTS HARD. WHEN FIRST STARTED IN THE MORNING IT RUINS UP HIGH PRM'S BEFORE THE CAR SHIFTS. THE CAR TRANSMISSION SOMETIMES FAILS TO ENGAGE WHEN I ATTEMPT TO PASS A CAR ON THE HIGHWAY OR WHEN I JUST WANT TO SPEED UP. THIS CAN HAPPEN WHEN I AM GOING 30 MPH OR 60 MPH. IT HAPPENS AT RANDOM TIMES. RECENTLY THE ELECTRI…
Read full complaint
THE CAR SHIFTS HARD. WHEN FIRST STARTED IN THE MORNING IT RUINS UP HIGH PRM'S BEFORE THE CAR SHIFTS. THE CAR TRANSMISSION SOMETIMES FAILS TO ENGAGE WHEN I ATTEMPT TO PASS A CAR ON THE HIGHWAY OR WHEN I JUST WANT TO SPEED UP. THIS CAN HAPPEN WHEN I AM GOING 30 MPH OR 60 MPH. IT HAPPENS AT RANDOM TIMES. RECENTLY THE ELECTRICAL SYSTEM HAS STARTED ACTING UP. LAST WEEK WHEN I WENT INTO THE GROCERY STORE THE WINDOW WENT DOWN BY THEMSELVES WHILE I WAS IN THE STORE.(IT WAS RAINING OUT SO I AM SURE THE WINDOWS WERE UP WHEN I LOCKED THE DOORS TO GO INSIDE) THE DRIVER'S SIDE DOOR DOES NOT LOCK OR UNLOCK WITH THE REMOTE CONTROL. ALSO WHEN I GO TO EXIT THE CAR THE LOCK IS STICKING AND IT IS AT TIMES DIFFICULT TO OPEN THE DOOR. TODAY WHEN MY WIFE WENT OUT TO THE VAN THE CAR HAD UNLOCKED AND THE FRONT LIGHTS WERE ON. I RE-LOCKED THE CAR AND IT UNLOCKED ITSELF AGAIN. I HAVE HAD THE CAR INTO THE DEALERSHIP WHERE I PURCHASED NUMEROUS TIMES(5 OR 6) TO HAVE THE TRANSMISSION LOOKED AT BUT THEY DON'T GET AN"ERROR CODE" SO THEY SAY THERE IS NOTHING THAT CAN BE DONE. *TR
NHTSA ODI #10477188
79,000 miles · Sep 17, 2012
Electrical System
MY VEHICLES IS HAVING STRANGE ELECTRICAL ISSUES. THE GAUGES MOVE ERRATICALLY, MY DASH LIGHTS AND HEAD LIGHTS FLICKER, MY RADIO AND AIR TURN OFF BY THEM SELVES. ALL THE WARNING LIGHT FLASH AND THE WARNING CHIME SOUNDS. ALL THESE THINGS HAPPEN WITHOUT WARNING. I CALLED THE DODGE DEALER AND THEY TOLD ME THAT IT SOUNDED LIKE THE TIP…
Read full complaint
MY VEHICLES IS HAVING STRANGE ELECTRICAL ISSUES. THE GAUGES MOVE ERRATICALLY, MY DASH LIGHTS AND HEAD LIGHTS FLICKER, MY RADIO AND AIR TURN OFF BY THEM SELVES. ALL THE WARNING LIGHT FLASH AND THE WARNING CHIME SOUNDS. ALL THESE THINGS HAPPEN WITHOUT WARNING. I CALLED THE DODGE DEALER AND THEY TOLD ME THAT IT SOUNDED LIKE THE TIPM. THIS COMPONENT HAS AFFECTED THOUSANDS AND THOUSANDS OF CARAVAN OWNERS. THEY QUOTED ME $900 PLUS DOLLARS TO GET FIX. THAT IS $900 PLUS DOLLARS THAT I DON'T HAVE. WITH THE NUMBERS OF INCIDENTS AND THE AMOUNT OF POTENTIAL DANGERS THAT THIS ISSUE PUTS THE COMMUNITY IN, I BELIEVE THAT THIS SHOULD BE A RECALL ISSUE. UNLIKE ME WHO HAS A FAMILY, AND I AM STILL AM MAKING PAYMENTS ON THE VEHICLE, A COSTLY REPAIR LIKE THIS THAT I CANT AFFORD, COULD BE AFFORDED BY DODGE TO RECALL IT. I MEAN THEY ARE A HUGE COMPANY. *TR
NHTSA ODI #10475639
Official recalls
6Dec 17, 2025
Rollx Vans (Rollx) is recalling certain GMC Yukon, Sierra, Chevrolet Express 2500, Ford Transit, E-250, Toyota Sienna, Sienna Hybrid, Honda Odyssey, Chrysler Town and Country, Voyager, Pacifica, Dodge Grand Caravan, and Ram Promaster vehicles equipped with QRT-Deluxe and QRT-Max wheelchair restraints. Please refer to Rollx's recall report for specific model year information. The retractors may not lock, preventing the wheelchair from being properly secured.
Consequence & remedy
Consequence: An unsecured wheelchair can move during transit, increasing the risk of injury.
Remedy: Rollx will work with Q'Straint to inspect and replace the retractors as necessary, free of charge. Owner notification letters were mailed February 5, 2026. Owners may contact Rollx's customer service at 1-800-956-6668.
Jul 7, 2020
Chrysler (FCA US LLC) is recalling certain 2008-2010 Chrysler Town and Country and Dodge Grand Caravan and 2007-2011 Dodge Nitro vehicles. These vehicles may have a loose or missing brand emblem in the center of the steering wheel. The loose emblem or the securing nuts for the emblem within the driver air bag module may become projectiles in the event of a driver air bag deployment.
Consequence & remedy
Consequence: Projectiles as a result of driver air bag deployment in the event of a crash can increase the risk of injury.
Remedy: Chrysler will notify owners, and dealers will replace the driver's air bag cover with a redesigned cover, free of charge. The recall began February 11, 2021. Owners may contact FCA US LLC customer service at 1-800-853-1403. Chrysler's number for this recall is W09.
Additional source detail variants (2)
Air Bags:frontal:driver Side:inflator Module
Chrysler (FCA US LLC) is recalling certain 2008-2010 Chrysler Town and Country and Dodge Grand Caravan and 2007-2011 Dodge Nitro vehicles. These vehicles may have a loose or missing brand emblem in the center of the steering wheel. The loose emblem or the securing nuts for the emblem within the driver air bag module may become projectiles in the event of a driver air bag deployment.
Consequence: Projectiles as a result of driver air bag deployment in the event of a crash can increase the risk of injury.
Remedy: Chrysler will notify owners, and dealers will replace the driver's air bag cover with a redesigned cover, free of charge. The recall began February 11, 2021. Owners may contact FCA US LLC customer service at 1-800-853-1403. Chrysler's number for this recall is W09.
Steering: Steering Wheel/handle Bar
Chrysler (FCA US LLC) is recalling certain 2008-2010 Chrysler Town and Country and Dodge Grand Caravan and 2007-2011 Dodge Nitro vehicles. These vehicles may have a loose or missing brand emblem in the center of the steering wheel. The loose emblem or the securing nuts for the emblem within the driver air bag module may become projectiles in the event of a driver air bag deployment.
Consequence: Projectiles as a result of driver air bag deployment in the event of a crash can increase the risk of injury.
Remedy: Chrysler will notify owners, and dealers will replace the driver's air bag cover with a redesigned cover, free of charge. The recall began February 11, 2021. Owners may contact FCA US LLC customer service at 1-800-853-1403. Chrysler's number for this recall is W09.
Jun 26, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. Chrysler Group LLC (Chrysler) is recalling certain model year 2009-2010 Dodge Journey vehicles manufactured June 29, 2007, to June 17, 2010, and 2008-2010 Dodge Grand Caravan and Chrysler Town and Country vehicles manufactured January 26, 2007, to June 17, 2010. Road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the ignition key inadvertently moves into the OFF or ACCESSORY position, the engine will turn off, which will then depower various key safety systems including but not limited to air bags, power steering, and power braking. Loss of functionality of these systems may increase the risk of crash and/or increase the risk of injury in the event of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the ignition switch and key FOBs, free of charge. The recall began on May 26, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R03. Note: This is an expansion of recall 11V-139.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. Chrysler Group LLC (Chrysler) is recalling certain model year 2009-2010 Dodge Journey vehicles manufactured June 29, 2007, to June 17, 2010, and 2008-2010 Dodge Grand Caravan and Chrysler Town and Country vehicles manufactured January 26, 2007, to June 17, 2010. Road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence: If the ignition key inadvertently moves into the OFF or ACCESSORY position, the engine will turn off, which will then depower various key safety systems including but not limited to air bags, power steering, and power braking. Loss of functionality of these systems may increase the risk of crash and/or increase the risk of injury in the event of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the ignition switch and key FOBs, free of charge. The recall began on May 26, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R03. Note: This is an expansion of recall 11V-139.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. Chrysler Group LLC (Chrysler) is recalling certain model year 2009-2010 Dodge Journey vehicles manufactured June 29, 2007, to June 17, 2010, and 2008-2010 Dodge Grand Caravan and Chrysler Town and Country vehicles manufactured January 26, 2007, to June 17, 2010. Road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence: If the ignition key inadvertently moves into the OFF or ACCESSORY position, the engine will turn off, which will then depower various key safety systems including but not limited to air bags, power steering, and power braking. Loss of functionality of these systems may increase the risk of crash and/or increase the risk of injury in the event of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the ignition switch and key FOBs, free of charge. The recall began on May 26, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R03. Note: This is an expansion of recall 11V-139.
May 7, 2014
Chrysler Group, LLC (Chrysler) is recalling certain model year 2010-2014 Chrysler Town and Country and Dodge Grand Caravan vehicles manufactured August 25, 2010, through October 31, 2013. The affected vehicles may experience overheating of the vent window switch in the driver's door armrest.
Consequence & remedy
Consequence: An overheated switch may result in a vehicle fire.
Remedy: Chrysler will notify owners, and dealers will replace the vent window switch with a newer version, free of charge. The owner notification letter was issued and the remedy campaign launched on on December 31, 2014. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is P25.
Feb 11, 2014
Freedom Motors Inc., (Freedom Motors) of Savaria Vehicle Group (formerly The Liberty Motor Company) is recalling one model year 2009 Volkswagen Routan and certain model year 2008-2010 Dodge Grand Caravan and Chrysler Town & Country wheelchair accessible vehicles modified by The Liberty Motor Company from February 2008 through January 2011. Over time and with use, the vehicle's rear axle may develop cracks which could lead to axle failure.
Consequence & remedy
Consequence: Failure of the rear axle may increase the risk of a crash.
Remedy: Freedom Motors will notify owners, and dealers will replace the affected axles, free of charge. The recall began on April 1, 2014. Owners can contact Freedom Motors at 1-800-561-9600. Freedom Motors' number for this recall is ENGF0216-3.
Mar 1, 2011
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2010 DODGE JOURNEY, GRAND CARAVAN, AND CHRYSLER TOWN & COUNTRY VEHICLES MANUFACTURER FROM AUGUST 3, 2009, THROUGH JUNE 17, 2010. SOME VEHICLES MAY EXPERIENCE INADVERTENT IGNITION KEY DISPLACEMENT FROM THE RUN TO ACCESSORY POSITION WHILE DRIVING CAUSING THE ENGINE TO SHUT OFF.
Consequence & remedy
Consequence: ENGINE SHUT OFF WHILE DRIVING COULD INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE WIN MODULES FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING JULY 2011. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3PE19014 · Active Head Rest Inadvertent Deployment
Opened Sep 9, 2019 · Closed Feb 25, 2026
Status: closed (inferred from source dates) · Seats; Seats:front Assembly:head Restraint
The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Seats
The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Seats:front Assembly:head Restraint
The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
DP14004 · Totally Integrated Power Module Failure
Opened Sep 25, 2014 · Closed Jul 24, 2015
Status: closed (inferred from source dates) · Electrical System
In a letter dated August 21, 2014, the Center for Auto Safety (CAS) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged failures associated with the Totally Integrated Power Module (TIPM) installed in Chrysler SUV?s, trucks, and vans beginning in the 2007 model year. The petitioner alleges that TIPM defects may result in engine stall, airbag non-deployment, failure of fuel pump shutoff resulting in unintended acceleration, fire, and other symptoms. On September 25, 2014, the Office of Defects Investigation (ODI) opened DP14-004 to evaluate the petition for a grant or deny decision. ODI analyzed complaint data provided by CAS as well as complaints submitted to ODI from consumers. In total, there were 296 complaints submitted by the petitioner in the original petition and five supplements, including 271 complaints related to the subject vehicles equipped with TIPM-7. Approximately 3 percent of CAS complaints are related to vehicles equipped with TIPM-6 and ODI?s review of these complaints did not identify any safety defect trends. ODI conducted a detailed review of complaints narratives submitted by CAS and consumers including careful analysis of vehicle repair histories, warranty claims obtained from the manufacturer and any available Customer Assistance Inquiry reports (CAIR). Analysis of the field data indicated that MY2011-2013 Jeep Grand Cherokee and Dodge Durango vehicles exhibited significantly higher complaint rates related to fuel pump relay (FPR) failures than other subject vehicles. In a September 3, 2014 letter to NHTSA, Chrysler submitted a Defect Information Report (DIR) identifying a defect in the FPR within the TIPM-7 which can result in a no start or stall condition in approximately 188,723 model year (MY) 2011 Jeep Grand Cherokee (WK) and Dodge Durango (WD) vehicles manufactured from January 5, 2010 through July 20, 2011 (14V-530).In a February 24, 2015 letter, Chrysler submitted a second DIR expanding the scope of the FPR defect condition to include an additional 338,216 MY 2012 through 2013 Jeep Grand Cherokee vehicles manufactured from September 17, 2010 through August 19, 2013 and MY 2012 through 2013 Dodge Durango vehicles manufactured from January 18, 2011 through August 19, 2013 (15V-115).ODI analysis of the CAS allegations of TIPM defects resulting in stall while driving, airbag non-deployment, unintended acceleration, fire and other faults identified a single defect condition related to 1 of over 60 different circuits in the TIPM assembly. The most common effect of this defect condition, related to the fuel pump relay, was a no-start concern, but it could also result in stall while driving (76 complaints). No valid evidence was presented in support of claims related to airbag non-deployment, unintended acceleration or fire resulting from TIPM faults and these claims were found to be wholly without merit based on review of the field data and design of the relevant systems and components.Except insofar as the petitioner's contentions relate to the defect condition addressed by the Chrysler recalls, the factual bases of the petitioner's contentions that any further investigation is necessary are unsupported. In our view, additional investigation is unlikely to result in a finding that a defect related to motor vehicle safety exists or a NHTSA order for the notification and remedy of a safety-related defect as alleged by the petitioner at the conclusion of the requested investigation. Therefore, in view of the need to allocate and prioritize NHTSA's limited resources to best accomplish the agency's safety mission, the petition is den
RQ14002 · Air Bag Non-Deployment/Engine Stall
Opened Jun 16, 2014 · Closed Mar 2, 2015
Status: closed (inferred from source dates) · Air Bags; Electrical System:ignition:module
In March 2011 Chrysler submitted a defect information report for NHTSA Recall No. 11V139 declaring a defect condition that could cause the ignition key to inadvertently move from the RUN to the ACC position on model year (MY) 2010 Dodge Journey, Grand Caravan, and Chrysler Town and Country.The report identified engine stalling as the defect consequence and cited customer complaints and warranty claims, as well as two rear-end collisions, as leading to the recall action.Chrysler determined that a defective WIN module, which is effectively the equivalent of the ignition switch, was the cause of the inadvertent key rotation, and that a new design WIN module would be installed as a remedy.In Spring 2014 ODI conducted outreach to major light vehicle manufacturers regarding ignition key position and its effect on air bag system availability.The outreach was conducted in connection with NHTSA Recall No. 14V047, a recent recall involving inadvertent ignition key rotation and subsequent air bag disablement in certain GM products.During discussions held in April 2014, Chrysler advised ODI that Chrysler air bag systems of this vintage, including the subject vehicles, revert to energy reserve when the ignition key moves to the ACC or OFF position, and that under energy reserve the air bags would only be available for a short period, approximately two tenths of a second (ODI notes this consequence was not identified in the 11V139 recall report).A review of the ODI consumer database conducted after the April 2014 discussions identified complaints alleging that MY 2008-2009 vehicles may have a similar defect as the MY 2010 vehicles, and that some MY 2010 consumers reported experiencing ignition key position concerns after the 11V139 recall remedy was applied.Accordingly this investigation was opened.In response to ODI?s information request letter, Chrysler reported that MY 2008-2009 subject vehicles used the same design WIN module as the recalled vehicles, and also identified 66 consumer reports and one non-injury crash incident potentially related to inadvertent ignition key rotation.Chrysler?s review of the MY 2010 remedy used in 11V139, which involved installation of a Trim Ring as opposed to replacement of the WIN module, showed the remedy did not adequately address ignition key position concerns, and in some use-cases could cause other systems to operate improperly (radio, instrument panel lighting, HVAC fan motor, etc.).Chrysler subsequently filed multiple defect information reports to 1) add the MY 2008-2009 Dodge Grand Caravan and Chrysler Town and Country, and the MY 2009 Dodge Journey to the original recall scope, and 2) stating that the complete WIN module would be replaced with a new design component in all recalled vehicles (including those that had the Trim Ring installed during 11V139).Chrysler?s report also advises of constrained remedy parts availability, see NHTSA Recall No. 14V373 for further details.Accordingly, the investigation is closed based on the recall action Chrysler is undertaking.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10584873, 10583399, 10573295, 10566365, 10546805, 10513060, 10509284, 10503121, 10496599, 10475027, 10456099, 10450629, 10443680, 10422766, 10410447, 10409269, 10402947, 10402751, 10402660, 10396943, 10394957, 10356632, 10315972
Additional source detail variants (2)
Air Bags
In March 2011 Chrysler submitted a defect information report for NHTSA Recall No. 11V139 declaring a defect condition that could cause the ignition key to inadvertently move from the RUN to the ACC position on model year (MY) 2010 Dodge Journey, Grand Caravan, and Chrysler Town and Country.The report identified engine stalling as the defect consequence and cited customer complaints and warranty claims, as well as two rear-end collisions, as leading to the recall action.Chrysler determined that a defective WIN module, which is effectively the equivalent of the ignition switch, was the cause of the inadvertent key rotation, and that a new design WIN module would be installed as a remedy.In Spring 2014 ODI conducted outreach to major light vehicle manufacturers regarding ignition key position and its effect on air bag system availability.The outreach was conducted in connection with NHTSA Recall No. 14V047, a recent recall involving inadvertent ignition key rotation and subsequent air bag disablement in certain GM products.During discussions held in April 2014, Chrysler advised ODI that Chrysler air bag systems of this vintage, including the subject vehicles, revert to energy reserve when the ignition key moves to the ACC or OFF position, and that under energy reserve the air bags would only be available for a short period, approximately two tenths of a second (ODI notes this consequence was not identified in the 11V139 recall report).A review of the ODI consumer database conducted after the April 2014 discussions identified complaints alleging that MY 2008-2009 vehicles may have a similar defect as the MY 2010 vehicles, and that some MY 2010 consumers reported experiencing ignition key position concerns after the 11V139 recall remedy was applied.Accordingly this investigation was opened.In response to ODI?s information request letter, Chrysler reported that MY 2008-2009 subject vehicles used the same design WIN module as the recalled vehicles, and also identified 66 consumer reports and one non-injury crash incident potentially related to inadvertent ignition key rotation.Chrysler?s review of the MY 2010 remedy used in 11V139, which involved installation of a Trim Ring as opposed to replacement of the WIN module, showed the remedy did not adequately address ignition key position concerns, and in some use-cases could cause other systems to operate improperly (radio, instrument panel lighting, HVAC fan motor, etc.).Chrysler subsequently filed multiple defect information reports to 1) add the MY 2008-2009 Dodge Grand Caravan and Chrysler Town and Country, and the MY 2009 Dodge Journey to the original recall scope, and 2) stating that the complete WIN module would be replaced with a new design component in all recalled vehicles (including those that had the Trim Ring installed during 11V139).Chrysler?s report also advises of constrained remedy parts availability, see NHTSA Recall No. 14V373 for further details.Accordingly, the investigation is closed based on the recall action Chrysler is undertaking.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10584873, 10583399, 10573295, 10566365, 10546805, 10513060, 10509284, 10503121, 10496599, 10475027, 10456099, 10450629, 10443680, 10422766, 10410447, 10409269, 10402947, 10402751, 10402660, 10396943, 10394957, 10356632, 10315972
Electrical System:ignition:module
In March 2011 Chrysler submitted a defect information report for NHTSA Recall No. 11V139 declaring a defect condition that could cause the ignition key to inadvertently move from the RUN to the ACC position on model year (MY) 2010 Dodge Journey, Grand Caravan, and Chrysler Town and Country.The report identified engine stalling as the defect consequence and cited customer complaints and warranty claims, as well as two rear-end collisions, as leading to the recall action.Chrysler determined that a defective WIN module, which is effectively the equivalent of the ignition switch, was the cause of the inadvertent key rotation, and that a new design WIN module would be installed as a remedy.In Spring 2014 ODI conducted outreach to major light vehicle manufacturers regarding ignition key position and its effect on air bag system availability.The outreach was conducted in connection with NHTSA Recall No. 14V047, a recent recall involving inadvertent ignition key rotation and subsequent air bag disablement in certain GM products.During discussions held in April 2014, Chrysler advised ODI that Chrysler air bag systems of this vintage, including the subject vehicles, revert to energy reserve when the ignition key moves to the ACC or OFF position, and that under energy reserve the air bags would only be available for a short period, approximately two tenths of a second (ODI notes this consequence was not identified in the 11V139 recall report).A review of the ODI consumer database conducted after the April 2014 discussions identified complaints alleging that MY 2008-2009 vehicles may have a similar defect as the MY 2010 vehicles, and that some MY 2010 consumers reported experiencing ignition key position concerns after the 11V139 recall remedy was applied.Accordingly this investigation was opened.In response to ODI?s information request letter, Chrysler reported that MY 2008-2009 subject vehicles used the same design WIN module as the recalled vehicles, and also identified 66 consumer reports and one non-injury crash incident potentially related to inadvertent ignition key rotation.Chrysler?s review of the MY 2010 remedy used in 11V139, which involved installation of a Trim Ring as opposed to replacement of the WIN module, showed the remedy did not adequately address ignition key position concerns, and in some use-cases could cause other systems to operate improperly (radio, instrument panel lighting, HVAC fan motor, etc.).Chrysler subsequently filed multiple defect information reports to 1) add the MY 2008-2009 Dodge Grand Caravan and Chrysler Town and Country, and the MY 2009 Dodge Journey to the original recall scope, and 2) stating that the complete WIN module would be replaced with a new design component in all recalled vehicles (including those that had the Trim Ring installed during 11V139).Chrysler?s report also advises of constrained remedy parts availability, see NHTSA Recall No. 14V373 for further details.Accordingly, the investigation is closed based on the recall action Chrysler is undertaking.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10584873, 10583399, 10573295, 10566365, 10546805, 10513060, 10509284, 10503121, 10496599, 10475027, 10456099, 10450629, 10443680, 10422766, 10410447, 10409269, 10402947, 10402751, 10402660, 10396943, 10394957, 10356632, 10315972
Illustration