2007 Dodge Grand Caravan

TL*THE CONTACT OWNS A 2007 DODGE GRAND CARAVAN. THE CONTACT STATED THAT AFTER REFUELING AND DRIVING AT AN UNKNOWN SPEED, THE VEHICLE STALLED. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE FUEL FILTER WAS REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 150,000.

VEHICLE HESITATED FIRST TIME WHILE GOING 50 MPH AFTER REFUELING - REGULAR GAS. CHECKED THE TACH, WENT TO ALMOST ZERO, THEN BACK UP AGAIN. RODE ROUGH FOR A WHILE. STALLED FIRST TIME AFTER REFUELING W/ REGULAR GAS, @ 35 MPH, ALMOST CAUSING ME TO HIT A CURB - LOSS OF POWER STEERING AND BRAKES. RESTARTED OKAY. STALLED A 2ND TIME AFTER REFUELING AT RED LIGHT, JUST 500 FT FROM GAS STATION. TOOK 2 TIMES TO START IT. WHEN WE FIGURED IT WAS NOT A BAD TANK OF GAS, WE HAD OUR LOCAL MECHANIC CHECK IT, AND WE PAID OVER $200.00 FOR A CRANKSHAFT POSITION SENSOR TO BE REPLACED. BUT WE REFUELED THE VAN SOON AFTER, AND IT STALLED OUT AGAIN. THAT WAS WHEN I DECIDED TO LOOK ONLINE TO SEE IF ANYONE ELSE HAS ENCOUNTERED THE SAME PROBLEM. I WAS AMAZED AT HOW MANY PEOPLE HAD COMPLAINED, AND WERE TOLD IT?S NOT A KNOWN ISSUE. IT SOUNDS TO ME LIKE DODGE/CHRYSLER DOESN'T WANT TO ACCEPT RESPONSIBILITY FOR THE PROBLEM. I CHECKED ONLINE AND FOUND 40 COMPLAINTS FOR THE SAME ISSUE HERE: HTTP://EN.ALLEXPERTS.COM/Q/CHRYSLER-REPAIR-807/F/STALLING-REFUELING.HTM [DODGE CARAVAN AND/OR CHRYSLER TOWN & COUNTRY STALLING AFTER REFUELING]. THEY ALL CALLED DODGE/CHRYSLER AND WERE TOLD THAT IT WASN'T A KNOWN ISSUE. PLEASE FOLLOW THROUGH ON THIS, AND HAVE DODGE/CHRYSLER RECTIFY IT BEFORE SOMEONE IS KILLED. HERE IS A PAGE NOT BY DODGE THAT GIVES THE SOLUTION: HTTP://RICKSFREEAUTOREPAIRADVICE.COM/ENGINE-STALLS-AFTER-FILLING-TANK-CHRYSLER-MINIVAN/ THE REMEDY IS TO PAY OVER $700 FOR AN ENTIRE TANK, BECAUSE CHRYSLER DOESN'T SELL THE PART ALONE, WHICH IS THE VAPOR/LIQUID SEPARATOR VALVE. PLEASE HELP! *TR

WHEN IT FIRST BEGAN THE VAN WOULD STALL AND SKIP UPON ACCELERATION BETWEEN 20-50 MPH. NOW THE VAN STALLS AND/OR SKIPS AT ANY POINT OF ACCELERATION. THE ENGINE LIGHT COMES ON RIGHT AFTER THERE IS FUEL ADDED TO THE TANK AND THIS IS WHEN THE STALLING IS THE WORSE. THE ENGINE LIGHT ALSO COMES ON WHEN THERE IS1/4 TANK OF GAS LEFT AND THE DISTANCE TO EMPTY NUMBER JUMPS AROUND WHEN THERE IS LESS THAN 1/4 OF A TANK. *TR

2007 DODGE GRAND CARAVAN SXT STOW N GO HAVING SEVERAL ELECTRICAL ISSUES. 1. PASSENGER POWER SLIDING DOOR FAILED, REPLACED POWER DOOR MOTOR, LOCK ACTUATOR, AND REPAIRED WIRING AS THE WIRES ACTUALLY BREAK/SNAP OVERTIME. POOR DESIGN. 2. LESS THAN TWO YEARS LATER PASSENGER POWER SLIDING DOOR HAS FAILED AGAIN, & POWER LOCKS WILL NOT WORK, & I CAN OPEN PASSENGER SLIDING DOOR AFTER LOCKING VEHICLE WITH KEY FOB AND ALARM WON'T SOUND! CANNOT GET MY CHILDREN IN AND OUT OF THIS DOOR WITHOUT REACHING IN AND PULLING UP THE LEVER FROM INSIDE (TOO STIFF, MY DAUGHTER ISN'T STRONG ENOUGH). THIS IS A SAFETY ISSUE AND RESEARCHING IT ONLINE SHOWS THAT IT IS WIDESPREAD. 3. POWER SEAT MOTOR HAS FAILED. WE HAVE STOW N GO SEATING. IN ORDER TO STOW THE 2ND ROW SEAT YOU MUST MOVE FRONT SEAT TO FULL FORWARD POSITION, THEN MOVE DRIVER SEAT BACK......DRIVER SEAT IS ALL THE WAY BACK NOW (FOR MY SPOUSE) AND I CANNOT MOVE IT FORWARD. GEARS ARE BROKEN. I CANNOT REACH THE PEDALS AND MY SEVENTH SEAT IS STOWED! I CANNOT GET MY SEAT BACK. 4. ON PASSENGER SIDE A PART BELOW DASHBOARD (I THINK IS RELATED TO HEATING AND COOLING) FELL OFF. MY FLOOR IS NOW WET EVEN AFTER REATTACHING IT. 5. LIGHT GALORE! MY VEHICLE ROTATES BETWEEN CHECK ENGINE, AND SERVICE TIRE SYSTEM WARNINGS. I'VE HAD IT CHECKED BY SEVERAL MECHANICS AND ALL SAY IT'S ELECTRICAL. *TR

I WAS DRIVING MY VEHICLE AND MY ANTI-LOCK BRAKES SYSTEM RESPONDED TO THE ICE ON THE ROAD AND I PROCEEDED TO PUMP MY BRAKE PEDAL TO SLOW THE VEHICLE DOWN AND THEN I NOTICED THAT THE BRAKE PEDAL WOULD GO ALL THE WAY TO THE FLOOR TO STOP THE VEHICLE SO I GOT HOME AND CHECKED THE BRAKE LINES FOR LEAKS AND DIDN'T FIND ANY AND THAT MY BRAKE RESERVOIR WAS FULL. *TR

TL* THE CONTACT OWNS A 2007 DODGE GRAND CARAVAN. WHEN THE FRONT DRIVER SIDE DOOR WAS LOCKED WITH EITHER THE KEY FOB OR MANUALLY, AN ABNORMAL NOISE EMITTED FROM THE DOOR PANEL. WHEN UNLOCKING THE DOOR FROM THE OUTSIDE, THE DOOR FAILED TO UNLOCK. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 10,000. UPDATED 02/02/15*LJ UPDATED 6/8/2015 *JS

AFTER GETTING GAS, WHEN I SLOW TO COME TO A STOP THE CAR STALLS OUT. IT WILL USUALLY START RIGHT BACK UP AND I DON'T HAVE A PROBLEM UNTIL I GET GAS AGAIN. THIS IS A CONCERN AS I AM USUALLY DRIVING MY CHILDREN AROUND AND IT HAPPENED AFTER I PULLED OUT ONTO A BUSY 4 LANE ROAD AND HAD TO SLOW DUE TO AN UPCOMING LIGHT. WE WERE ALMOST HIT BECAUSE THE CARS COMING UP SAW THAT THE LIGHT WAS NOW GREEN. I PUT ON MY BLINKERS AS FAST AS I COULD BUT THAT DID NOT SAVE US FROM NEARLY BEING HIT AS WE WERE SITTING DUCKS. *TR

THE INTERIOR IN THE FRONT OF THE VEHICLE WENT OUT. WHEN I TOOK IT OUT TO REPLACE IT, AND IT WAS MELTED ON ONE SIDE. THAT HAPPENED TO ME WITH THE OTHER SIDE OF THE FRONT INTERIOR LIGHTS, AROUND 2011 AND WHEN I WENT TO THE DEALERSHIP I WAS TOLD I WOULD HAVE TO BUY THE WHOLE ASSEMBLY AT A COST OF ABOUT $150.00 I THINK. I ASKED THEN IF THERE HAD BEEN A RECALL ON THIS AND WAS TOLD NO. I ASKED WHAT WOULD CAUSE THE LIGHT TO MELT AND HE SAID HE DID NOT KNOW. I LEFT IT AS I STILL HAD THE ONE ON THE DRIVERS SIDE BUT NOW I DO NOT HAVE EITHER AND THERE ISN'T ANY LIGHT IN THE FRONT OF THE CAR WHEN OPENING THE DRIVERS OR FRONT PASSENGER DOOR. PLEASE ADVISE ME IF THIS HAS BEEN A PROBLEM AND OR WHAT CAN I DO ABOUT IT. *JS