2007 Dodge Grand Caravan

DURING PARK REAR PASSENGER DOOR WOULD NOT OPEN FROM THE INSIDE MANUALLY AND ELECTRONICALLY, SOMEONE FROM THE OUTSIDE HAS TO OPEN THE DOOR. THE UNLOCK MECHANISM IS UP BUT THE DOOR BUTTON FROM THE INSIDE WOULD NOT PUSH DOWN, THEREFORE NOT ALLOWING THE VAN DOOR TO OPEN. THIS IS BIG SAFETY PROBLEM, NO ONE CAN GET OUT MANUALLY AND ELECTRONICALLY FROM THE INSIDE. TOOK IT TO DODGE AND THEY CLAIM IT'S THE WIRE, BUT IT'S NOT BECAUSE THE WIRE IN GREAT CONDITION, BECAUSE IT'S BEEN REPLACE AND STILL HAVING THE SAME PROBLEM. IT'S NOT MOTOR BECAUSE ONCE IN A BLUE MOON IT WOULD OPEN PARTIALLY, BUT IT WOULD CLOSED AUTOMATICALLY IMMEDIATELY. I HAVE FILE NUMEROUS COMPLAINTS TO DODGE BUT NOTHING WAS DONE. I BELIEVE IT'S ELECTRONIC PROBLEM, WHICH HAS TO DO WITH ECM (ELECTRONIC CONTROL MODULAR). PLEASE CONTACT DODGE GRAND CARAVAN TO DILIGENTLY CHECK INTO THIS SAFETY ISSUE. THANK YOU. *TR

TL* THE CONTACT OWNS A 2007 DODGE GRAND CARAVAN. WHILE MAKING A RIGHT TURN AT VARIOUS SPEEDS, THE VEHICLE STALLED. THE CONTACT WAS ABLE TO RESTART THE VEHICLE. THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 115,000. THE VIN WAS UNAVAILABLE.

EVERY TIME THE FUEL TANK IS FILLED UP, AND AFTER WE START DRIVING, THE ENGINE WILL JUST STALL. IT COULD LEAD TO AN ACCIDENT IF THIS HAPPENS IN TRAFFIC. LUCKILY THIS HASN'T HAPPENED YET. THERE ARE SEVERAL OTHER CASES ON THE INTERNET,FOR EXAMPLE, ON THIS WEBSITE: HTTP://EN.ALLEXPERTS.COM/Q/CHRYSLER-REPAIR-807/F/STALLING-REFUELING.HTM

1ST OCCURRENCE: WHILE DRIVING ON FREEWAY ON A HOT DAY THE CAR STALLED WITHOUT WARNING. ON ATTEMPTED RESTARTS CAR WOULD FIRE FOR A COUPLE OF SECONDS AND QUIT. TRIED OTHER KEY: NO HELP. AFTER ABOUT 7 OR 8 ATTEMPTS THE CAR WOULD NOT CRANK AND SOLENOID CLICKED. TOWED HOME. CAR SET CODES P0339 AND P0344(INTERMITTENT CRANK AND CAM SENSOR). CHARGED BATTERY . REPLACED BOTH SENSORS CAR INITIALLY WOULD NOT START, THEN MYSTERIOUSLY FIRED UP AND RAN FINE. OK FOR ABOUT A MONTH. BATTERY TESTED OK CHARGING VOLTAGE GOOD WHEN RUNNING. NOT RELATED TO HAVING JUST (OVER)FILLED GAS TANK. (MUCH ON INTERNET ABOUT THIS: BAD VALVE IN TANK ALLOWS EVAP TO FLOOD) 2ND OCCURRENCE. ONCE AGAIN DRIVING ON HIGHWAY HOT DAY. ONCE AGAIN STALLED WITHOUT WARNING. SAME SYMPTOMS ON ATTEMPTED RESTART. AFTER WAITING ABOUT 15 MINUTES, CAR RESTARTED, RAN ABOUT 4 MILES AND STALLED AGAIN. ATTEMPTED FOUR OR FIVE RESTARTS, THEN BATTERY APPEARED TO RUN DOWN. HEADLIGHTS WOULD DIM ON START ATTEMPT. AFTER A WHILE THE CAR STARTED AGAIN BUT RAN ROUGHLY ON ACCELERATION. ONCE AGAIN SET SAME CODES. AT THIS POINT I NOTICED SOME ELECTRICAL ANOMALIES. UPON KEY ON, THE TEMP, FUEL, AND TACH GAUGES WOULD PEG HIGH AND THEN FALL BACK TO NORMAL. THE POWER WINDOWS BEGAN TO OPERATE WITHOUT THE KEY ON. TOW TRUCK ARRIVED AND GOT IT HOME. CAR RESTARTED IN GARAGE. REPLACED BOTH SENSORS AGAIN AND BATTERY (SUSPECTED INTERMITTENT OPEN). 3RD OCCURRENCE ON TEST DRIVE GOT ABOUT 5 MILES AND ONTO HIGHWAY. ONCE AGAIN STALLED. THIS TIME RESTARTED, TURNED AROUND AND GOT ABOUT 2 MILES THEN QUIT AGAIN. THIS TIME NO RESTART( SAME 2-3 SECONDS). THIS TIME SET CODE P0344 ONLY(CAM SENSOR INTERMITTENT). CAR RESTARTED LATER BACK IN SHOP. RESEARCH ON THE INTERNET HAS GOT ME THINKING ABOUT THE TIPM (TOTALLY INTEGRATED POWER MODULE)

TL* THE CONTACT OWNS A 2007 DODGE GRAND CARAVAN. WHILE REFUELING THE VEHICLE, THE FUEL STOPPED FLOWING THROUGH THE VEHICLE WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER TO BE DIAGNOSED. THE TECHNICIAN DIAGNOSED THAT THE FUEL TANK NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 115,000. MA 09/22 UPDATED 11/14/2017*CN

TL* THE CONTACT OWNS A 2007 DODGE GRAND CARAVAN. WHILE DRIVING AT 65 MPH, THE AIR BAG WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE FRONT DRIVER SIDE SEAT BELT LATCH NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE RECURRED. THE VEHICLE WAS TAKEN TO A DEALER WHO DIAGNOSED THAT THE BLADDER PRESSURE SENSOR NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 74,000.

VEHICLE STALLS INTERMITTENTLY WHILE DRIVING SHORTLY AFTER FILLING UP WITH FUEL. VEHICLE CONTINUES TO STALL PERIODICALLY WITHOUT ANY KNOWN CONSISTENCY. DURING THE STALL, THE ENGINE CUTS OUT AND THE STEERING WHEEL LOCKS UP. THIS HAS OCCURRED SEVERAL TIMES IN THE PARKING LOT AFTER FILLING UP AND WHILE ENTERING THE ROADWAY AFTER FILLING UP. THIS A VERY DANGEROUS AND SERIOUS CONCERN FOR WHEN A LOSS OF POWER OCCURS ON THE ROADWAY SERIOUS AND POTENTIALLY FATAL ACCIDENTS MAY OCCUR. *TR

THE LAST FEW TIMES I HAVE COMPLETELY FILLED UP MY GAS TANK - THE VEHICLE HAS STALLED. I HAVE HAD TO TRIED TO STOP AND RESTART THE IGNITION/ENGINE A NUMBER OF TIMES FOR THE VEHICLE TO RUN. THIS IS HAPPENING WITH FULL GAS FULL-UP AND HAPPENED TO ME AGAIN LAST NIGHT. I HAVE SEEN THIS AS BEING A COMMON PROBLEM FOR CHRYSLER/DODGE MINIVANS IN A FEW ON-LINE FORUMS. SOME REPORTS HAVE THE VEHICLES STALLING ON HIGHWAYS AND/OR WHEN DRIVING. MY VEHICLE IS A 2007 DODGE GRAND CARAVAN SXT. *TR

TL* THE CONTACT OWNS A 2007 DODGE GRAND CARAVAN. WHILE DRIVING AT AN UNKNOWN SPEED, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT STATED THAT THE VEHICLE STALLED AFTER THE VEHICLE WAS REFUELED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 50,000. THE VIN WAS NOT AVAILABLE.