IllustrationHEADLIGHTS AND DASH LIGHTS RANDOMLY SHUT OFF WHILE IV AM DRIVING DOWN THE HIGHWAY STRAIGHTAWAY IN THE DARK I MONKEY WITH HEADLIGHT SWITCH AND THE LIGHTS COME BACK ON. THIS HAS HAPPENED TO ME ABOUT 8 TIMES IN THE LAST YEAR. BUT RECENTLY IT HAS GOTTEN WORSE.
2007 Dodge Grand Caravan
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2007 Dodge Grand Caravan do not stand out strongly from the model-year median of 284.
About this comparison →How this year compares
Owner complaints by model year
Compare all Grand Caravan years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
220–25K
2525–50K
4250–75K
3775–100K
29100–150K
11150K+
166 reports with mileage · 16 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Fuel/propulsion System. Review the 41 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 30 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine. Review the 26 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
14 crash reports7 fire reports11 injury reports
Exterior Lighting complaints
11 reportsENGINE STALLS POST REFUELING WHILE VEHICLE IN MOTION IN PARKING LOT AND ON ROADWAY INTERIOR READING LIGHTS MELTING AND SMOKING WHEN TURNED ON DOOR LOCK ON RIGHT AND LEFT REAR SLIDING DOOR WILL NOT LOCK OR UNLOCK VIA AUTO DOOR LOCKING/ UNLOCKING BUTTON.
THE INTERIOR IN THE FRONT OF THE VEHICLE WENT OUT. WHEN I TOOK IT OUT TO REPLACE IT, AND IT WAS MELTED ON ONE SIDE. THAT HAPPENED TO ME WITH THE OTHER SIDE OF THE FRONT INTERIOR LIGHTS, AROUND 2011 AND WHEN I WENT TO THE DEALERSHIP I WAS TOLD I WOULD HAVE TO BUY THE WHOLE ASSEMBLY AT A COST OF ABOUT $150.00 I THINK. I ASKED T…
Read full complaint
THE INTERIOR IN THE FRONT OF THE VEHICLE WENT OUT. WHEN I TOOK IT OUT TO REPLACE IT, AND IT WAS MELTED ON ONE SIDE. THAT HAPPENED TO ME WITH THE OTHER SIDE OF THE FRONT INTERIOR LIGHTS, AROUND 2011 AND WHEN I WENT TO THE DEALERSHIP I WAS TOLD I WOULD HAVE TO BUY THE WHOLE ASSEMBLY AT A COST OF ABOUT $150.00 I THINK. I ASKED THEN IF THERE HAD BEEN A RECALL ON THIS AND WAS TOLD NO. I ASKED WHAT WOULD CAUSE THE LIGHT TO MELT AND HE SAID HE DID NOT KNOW. I LEFT IT AS I STILL HAD THE ONE ON THE DRIVERS SIDE BUT NOW I DO NOT HAVE EITHER AND THERE ISN'T ANY LIGHT IN THE FRONT OF THE CAR WHEN OPENING THE DRIVERS OR FRONT PASSENGER DOOR. PLEASE ADVISE ME IF THIS HAS BEEN A PROBLEM AND OR WHAT CAN I DO ABOUT IT. *JS
JUST BOUGHT A 2007 DODGE GRAND CARAVAN AND REALIZED THE FRONT READING LIGHTS WERE NOT WORKING. I TOOK OF THE PLASTIC COVERS IN AN ATTEMPT TO CHANGE THEM AND OBSERVED THAT THE BULB HAD COMPLETELY MELTED THE PLASTIC AND BURNT PART OF THE CASING. IT APPEARS AS THOUGH THE PLASTIC HOUSING WAS VERY CLOSE TO, OR HAD ALREADY, CAUGHT O…
Read full complaint
JUST BOUGHT A 2007 DODGE GRAND CARAVAN AND REALIZED THE FRONT READING LIGHTS WERE NOT WORKING. I TOOK OF THE PLASTIC COVERS IN AN ATTEMPT TO CHANGE THEM AND OBSERVED THAT THE BULB HAD COMPLETELY MELTED THE PLASTIC AND BURNT PART OF THE CASING. IT APPEARS AS THOUGH THE PLASTIC HOUSING WAS VERY CLOSE TO, OR HAD ALREADY, CAUGHT ON FIRE. I AM WORRIED THAT IF WE PUT A NEW LIGHT BULB IN THE SAME HOUSING IT WILL LIKELY CATCH THE WHOLE VAN ON FIRE. THE SAFETY OF MY FAMILY BEING PARAMOUNT, I DO NOT FEEL SAFE DOING SO. AFTER REVIEWING THIS PROBLEM ONLINE, I FOUND NUMEROUS OTHER GRAND CARAVAN OWNERS CLAIMING TO HAVE HAD THE SAME PROBLEM. THIS ISSUE NEEDS TO BE FIXED BEFORE SOMEONE GETS HURT, OR EVEN WORSE, KILLED. *TR
TL* THE CONTACT OWNS 2007 DODGE GRAND CARAVAN. THE CONTACT STATED THAT THE INTERIOR LIGHTS ON THE FRONT DOME WIRING SYSTEM BURNT OUT. THE INSTRUMENT PANEL WIRING SYSTEM WAS PARTIALLY BURNT OUT CAUSING THE LIGHT TO ILLUMINATE ON AND OFF. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEA…
Read full complaint
TL* THE CONTACT OWNS 2007 DODGE GRAND CARAVAN. THE CONTACT STATED THAT THE INTERIOR LIGHTS ON THE FRONT DOME WIRING SYSTEM BURNT OUT. THE INSTRUMENT PANEL WIRING SYSTEM WAS PARTIALLY BURNT OUT CAUSING THE LIGHT TO ILLUMINATE ON AND OFF. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 30,000 AND THE CURRENT MILEAGE WAS 98,000.
HEAD LIGHTS STOPPED WORKING. NOT SIMPLE BULB REPLACEMENT, MAJOR ELECTRICAL PROBLEM IN POWER DISTRIBUTION SYSTEM. *TR
INTERIOR DOME LIGHTS STOPPED WORKING. NOW, THE "MALFUNCTION LIGHT" IS LIT UP ON THE DASHBOARD AT 38,000 MILES. *TR
THE HEADLIGHTS INTERMITTENTLY SHUTOFF OR WILL NOT TURN ON WHILE DRIVING. I HAVE REPLACED THE BULBS, CHECKED FOR A LOOSE CONNECTIONS, AND CHECKED THE FUSES MANY TIMES. THIS IS OKAY DURING THE DAY, HOWEVER I LIVE OUT IN THE COUNTRY 15 MINUTES FROM THE NEAREST TOWN. I CANNOT DRIVE AT NIGHT WITHOUT HEADLIGHTS OR WITH THE POSSIBILITY…
Read full complaint
THE HEADLIGHTS INTERMITTENTLY SHUTOFF OR WILL NOT TURN ON WHILE DRIVING. I HAVE REPLACED THE BULBS, CHECKED FOR A LOOSE CONNECTIONS, AND CHECKED THE FUSES MANY TIMES. THIS IS OKAY DURING THE DAY, HOWEVER I LIVE OUT IN THE COUNTRY 15 MINUTES FROM THE NEAREST TOWN. I CANNOT DRIVE AT NIGHT WITHOUT HEADLIGHTS OR WITH THE POSSIBILITY THAT THEY WILL SHUTOFF WHILE DRIVING. THIS IS EXTREMELY DANGEROUS. I HAVE BEEN LUCKY SO FAR THAT NOTHING SERIOUS HAS HAPPENED BUT THIS IS A PROBLEM THAT MUST BE FIXED! MY WIFE AND 7 MONTH OLD CHILD USE THIS VEHICLE THE MOST AND I CAN'T FATHOM THE IDEA OF THEM BEING INJURED DUE TO THIS PROBLEM. OTHERS HAVE SUGGESTED A FAULTY HEADLIGHT SWITCH. I HAVE NOT HAD THE TIME TO TAKE THE VEHICLE IN TO THE DEALERSHIP TO HAVE IT INSPECTED. *TR
HEADLIGHTS WILL NOT COME ON INTERMITTENTLY. HEADLIGHTS TURN OFF WHILE DRIVING. *TR
TL*THE CONTACT OWNS A 2007 DODGE GRAND CARAVAN. FROM SEPTEMBER OF 2007 UNTIL MAY OF 2008, THE VEHICLE WAS TAKEN TO THE DEALER THREE TIMES FOR TRANSMISSION FAILURE. WHILE ATTEMPTING TO ACCELERATE FROM A RED LIGHT, THE TRANSMISSION FEELS AS IF IT WILL DROP TO THE GROUND WHEN SHIFTING FROM FIRST TO SECOND GEAR. ON MAY 14, 2008, …
Read full complaint
TL*THE CONTACT OWNS A 2007 DODGE GRAND CARAVAN. FROM SEPTEMBER OF 2007 UNTIL MAY OF 2008, THE VEHICLE WAS TAKEN TO THE DEALER THREE TIMES FOR TRANSMISSION FAILURE. WHILE ATTEMPTING TO ACCELERATE FROM A RED LIGHT, THE TRANSMISSION FEELS AS IF IT WILL DROP TO THE GROUND WHEN SHIFTING FROM FIRST TO SECOND GEAR. ON MAY 14, 2008, THE TRANSMISSION WAS FINALLY REPAIRED UNDER WARRANTY. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION BECAUSE PAINT WAS PEELING FROM THE REAR PASSENGER SIDE QUARTER PANEL. THE DEALER STATED THAT TAR ADHERED TO THE PAINT; THEREFORE, THEY WASHED THE QUARTER PANEL AND SCRAPED OFF THE PAINT. WHEN THE VEHICLE AND HEADLIGHTS ARE TURNED OFF, THE INSTRUMENT PANEL LIGHTS, FOG LIGHTS, AND HEADLIGHTS WOULD REMAIN ILLUMINATED, EVEN THOUGH THE SWITCH WAS IN THE OFF POSITION. WHILE THE VEHICLE WAS PARKED, THE EXTERIOR LIGHTS WOULD ILLUMINATE AUTOMATICALLY, WHICH DRAINED THE BATTERY. THE DEALER STATED THAT THE HEADLAMP SWITCH SHORTED OUT. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE CONTACT STATED THAT THE SWITCH ON THE PANEL TO SHUT THE VEHICLE DOORS DID NOT WORK FOR TWO DAYS. IT HAS BEGUN TO WORK AGAIN, BUT THE CONTACT BELIEVES IT IS ONLY A MATTER OF TIME BEFORE THE SWITCH FAILS AGAIN. THE CURRENT MILEAGE WAS 7,000 AND FAILURE MILEAGE WAS 2,500. UPDATED 07/10/08. *LJ UPDATED
Official recalls
210V338000 · Seats
Jul 27, 2010
DRIVING SPECIALTIES LTD IS RECALLING 2 MODEL YEAR 2006 AND 2007 CONVERSION VANS EQUIPPED WITH VMI/RICON 6-WAY POWER SEAT BASES. THERE IS A POSSIBILITY OF A DEFECTIVE WELD AT THE JOINT BETWEEN THE PIVOTING PLATE AND THE PIVOTING PLATE PIN.
Consequence & remedy
Consequence: THE SEAT OCCUPANT MAY BE INJURED IF THE SEAT BASE PIN WERE TO BREAK.
Remedy: DRIVING SPECIALTIES WILL NOTIFY OWNERS AND THE VEHICLES WILL BE REPAIRED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JULY 28, 2010. OWNERS MAY CONTACT DRIVING SPECIALTIES AT 1-707-553-1515.
10V261000 · Seats
Jun 14, 2010
ARIZONA MOBILITY PRODUCTS (AMP) IS RECALLING ONE 2005 AND ONE 2007 CONVERSION VANS BUILT ON DODGE GRAND CARAVAN CHASSIS EQUIPPED WITH VMI/RICON 6-WAY POWER SEAT BASES. THERE IS A POSSIBILITY OF A DEFECTIVE WELD AT THE JOINT BETWEEN THE PIVOTING PLATE AND THE PIVOTING PLATE PIN.
Consequence & remedy
Consequence: THE SEAT OCCUPANT MAY BE INJURED IF THE SEAT BASE PIN WERE TO BREAK.
Remedy: AMP WILL NOTIFY OWNERS AND REPAIR VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JUNE 10, 2010. OWNERS MAY CONTACT AMP AT 1-602-385-5988.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1DP14002 · Engine Stall After Refueling
Opened Sep 5, 2014 · Closed Apr 6, 2015
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly
This defect petition evaluates July 7, 2014 allegations from an owner of a model year (MY) 2007 Dodge Grand Caravan minivan that engine stall occurs in these vehicles without warning after refueling.The petitioner's vehicle is a Chrysler RS platform minivan.The RS platform includes MY 2003 through 2007 Dodge Grand Caravan, Dodge Caravan, Chrysler Town and Country and Chrysler Voyager minivans.NHTSA evaluated the petition by analyzing consumer complaints submitted to the Agency, analyzing field data, reviewing technical information provided in Chrysler's response to an Agency information request and testing an RS minivan identified by its owner as experiencing post-refuel engine stalls.After completing this evaluation, NHTSA has concluded that further investigation is unlikely to result in a finding that a defect related to motor vehicle safety exists.The stalls occurring in these vehicles only occur immediately after filling up the fuel tank and happen at low engine speeds. The failure rate is low, even after 8 to 13 years of the vehicles being in service, and there are no reports of crashes or injuries resulting from the stall condition.In the Agency's view, additional investigation is unlikely to result in finding the existence of a safety-related defect in the subject vehicles.Given the need to allocate and prioritize NHTSA's limited resources to best accomplish the Agency's safety mission, the petition is denied.This action does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency will take further action if warranted by future circumstances. More details concerning our review can be found in the Federal Register Notice for this action.The following 161 VOQs are included in the petition evaluation: 10209242, 10229468, 10240708, 10260923, 10275939, 10276532, 10296487, 10298175, 10328669, 10330144, 10346517, 10349789, 10354758, 10363689, 10372112, 10372368, 10372514, 10378031, 10379764, 10382938, 10387448, 10394063, 10398877, 10413918, 10418652, 10420924, 10427063, 10437525, 10445392, 10446902, 10470028, 10471249, 10473733, 10502231, 10503114, 10504260, 10509862, 10511988, 10512120, 10512385, 10512650, 10513147, 10538154, 10549841, 10551763, 10555188, 10555418, 10556754, 10565367, 10574012, 10574398, 10586555, 10587212, 10587559, 10593433, 10607841, 10607913, 10608922, 10615810, 10622468, 10628141, 10632112, 10632128, 10632172, 10632175, 10632231, 10632262, 10632266, 10632270, 10632305, 10632316, 10632326, 10632370, 10632385, 10632399, 10632492, 10632542, 10632765, 10632833, 10632928, 10633197, 10633281, 10633409, 10633421, 10633483, 10633507, 10637752, 10637804, 10637950, 10637975, 10638032, 10638289, 10638290, 10638401, 10638968, 10639218, 10639623, 10641157, 10641603, 10641614, 10641836, 10644339, 10644705, 10649713, 10649895, 10649932, 10650313, 10652590, 10653147, 10653783, 10654533, 10655226, 10658900, 10659679, 10660320, 10662588, 10662645, 10662662, 10663473, 10667056, 10667437, 10668081, 10668094, 10668131, 10668612, 10668969, 10668970, 10669584, 10669678, 10669729, 10669775, 10669866, 10669895, 10669992, 10670422, 10670506, 10676348, 10676732, 10677120, 10679795, 10679934, 10680057, 10680290, 10680342, 10680714, 10681512, 10682584, 10682906, 10683022, 10683114, 10683549, 10683620, 10683697, 10683743, 10689898, 10690761, 10691284, 10691556, 10691751, 10693061, 10694300