IllustrationTL*THE CONTACT OWNS A 2007 DODGE GRAND CARAVAN. THE CONTACT STATED THAT AFTER REFUELING, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 96,000.
2007 Dodge Grand Caravan
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2007 Dodge Grand Caravan do not stand out strongly from the model-year median of 284.
About this comparison →How this year compares
Owner complaints by model year
Compare all Grand Caravan years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
220–25K
2525–50K
4250–75K
3775–100K
29100–150K
11150K+
166 reports with mileage · 16 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Fuel/propulsion System. Review the 41 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 30 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine. Review the 26 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
14 crash reports7 fire reports11 injury reports
Engine complaints
26 reportsWHEN IT FIRST BEGAN THE VAN WOULD STALL AND SKIP UPON ACCELERATION BETWEEN 20-50 MPH. NOW THE VAN STALLS AND/OR SKIPS AT ANY POINT OF ACCELERATION. THE ENGINE LIGHT COMES ON RIGHT AFTER THERE IS FUEL ADDED TO THE TANK AND THIS IS WHEN THE STALLING IS THE WORSE. THE ENGINE LIGHT ALSO COMES ON WHEN THERE IS1/4 TANK OF GAS LEFT AN…
Read full complaint
WHEN IT FIRST BEGAN THE VAN WOULD STALL AND SKIP UPON ACCELERATION BETWEEN 20-50 MPH. NOW THE VAN STALLS AND/OR SKIPS AT ANY POINT OF ACCELERATION. THE ENGINE LIGHT COMES ON RIGHT AFTER THERE IS FUEL ADDED TO THE TANK AND THIS IS WHEN THE STALLING IS THE WORSE. THE ENGINE LIGHT ALSO COMES ON WHEN THERE IS1/4 TANK OF GAS LEFT AND THE DISTANCE TO EMPTY NUMBER JUMPS AROUND WHEN THERE IS LESS THAN 1/4 OF A TANK. *TR
AFTER GETTING GAS, WHEN I SLOW TO COME TO A STOP THE CAR STALLS OUT. IT WILL USUALLY START RIGHT BACK UP AND I DON'T HAVE A PROBLEM UNTIL I GET GAS AGAIN. THIS IS A CONCERN AS I AM USUALLY DRIVING MY CHILDREN AROUND AND IT HAPPENED AFTER I PULLED OUT ONTO A BUSY 4 LANE ROAD AND HAD TO SLOW DUE TO AN UPCOMING LIGHT. WE WERE ALMOS…
Read full complaint
AFTER GETTING GAS, WHEN I SLOW TO COME TO A STOP THE CAR STALLS OUT. IT WILL USUALLY START RIGHT BACK UP AND I DON'T HAVE A PROBLEM UNTIL I GET GAS AGAIN. THIS IS A CONCERN AS I AM USUALLY DRIVING MY CHILDREN AROUND AND IT HAPPENED AFTER I PULLED OUT ONTO A BUSY 4 LANE ROAD AND HAD TO SLOW DUE TO AN UPCOMING LIGHT. WE WERE ALMOST HIT BECAUSE THE CARS COMING UP SAW THAT THE LIGHT WAS NOW GREEN. I PUT ON MY BLINKERS AS FAST AS I COULD BUT THAT DID NOT SAVE US FROM NEARLY BEING HIT AS WE WERE SITTING DUCKS. *TR
RIGHT AFTER GAS TANK FILL UP ENGINE STALLS,AND ON SEVERAL OCCASIONS WAS ON HIGHWAY ,AND POWER WENT OFF AFTER STALLING WITH LOSS OF CONTROL OF STEERING,AND RAPID DECELERATION WITH NEAR MISS OF BEING REAR ENDED. SOMEONE IS GOING TO BE KILLED,AND ACCORDING TO THE REPORTED INCIDENCES ON THE INTERNET SOMEONE WILL EVENTUALLY BE KILLED…
Read full complaint
RIGHT AFTER GAS TANK FILL UP ENGINE STALLS,AND ON SEVERAL OCCASIONS WAS ON HIGHWAY ,AND POWER WENT OFF AFTER STALLING WITH LOSS OF CONTROL OF STEERING,AND RAPID DECELERATION WITH NEAR MISS OF BEING REAR ENDED. SOMEONE IS GOING TO BE KILLED,AND ACCORDING TO THE REPORTED INCIDENCES ON THE INTERNET SOMEONE WILL EVENTUALLY BE KILLED OR SEVERELY INJURED. *TR
IN MAY 2014, AT APPROXIMATELY 55MPH, AFTER REFUELING AND DRIVEN 50 MILES. THE ENGINE LIGHT CAME ON. STOPPED VEHICLE AND CHECKED EVERYTHING THAT I COULD CHECK, AS I HAD JUST HAD IT SERVICED APPROX. 300 MILES PRIOR. CONTINUED ON TRIP, AFTER SPENDING NIGHT IN MOTEL, TOOK VEHICLE TO REPAIR FACILITY AND THEY DID DIAGNOSTICS...CAME…
Read full complaint
IN MAY 2014, AT APPROXIMATELY 55MPH, AFTER REFUELING AND DRIVEN 50 MILES. THE ENGINE LIGHT CAME ON. STOPPED VEHICLE AND CHECKED EVERYTHING THAT I COULD CHECK, AS I HAD JUST HAD IT SERVICED APPROX. 300 MILES PRIOR. CONTINUED ON TRIP, AFTER SPENDING NIGHT IN MOTEL, TOOK VEHICLE TO REPAIR FACILITY AND THEY DID DIAGNOSTICS...CAME UP WITH CODE 461, WHICH WAS FUEL LEVER SENSOR IN GAS TANK. CONTINUED ON TRIP, (1300 MILES), AFTER THAT TWO TIMES WHEN I HAD FILLED UP WITH GAS AGAIN THE VEHICLE DIED WITHIN 2 MILES...NO ENGINE LIGHT EVER CAME BACK ON. THIS CONTINUED THROUGHOUT THE SUMMER, OCCURRING 80% OF THE TIME I REFUELED...TOOK TO DEALER AS I HAVE EXTENDED WARRANTY, THEY ARE LOOKING INTO IT, BUT SAID BECAUSE THE ENGINE LIGHT DOESN'T COME BACK ON, THEY CAN'T EVALUATE IT. READ SOMEWHERE SINCE I TOOK IT BACK TO THE DEALER, THAT IF I DON'T FILL THE TANK UP FULLY, THAT WILL CURE THE PROBLEM? THE ENGINE DYING HAPPENS WHILE DRIVING LESS THAN 20MPH, SO FAR...COULD BE A PROBLEM PULLING OUT IN TRAFFIC? THIS IS NOW OCTOBER, STILL EXPERIENCING PROBLEM. *TR
ON APPROXIMATELY 04/07/2014 THE VAN WAS FILLED UP WITH GAS, I TOOK THE NOZZLE OUT WHEN IT SHUT OFF AND DID NOT PUT ANY EXTRA GAS INTO TANK. I STARTED UP THE VAN TO EXIT THE STATION WE DROVE ABOUT 100 YARDS AND THE VAN JERKED WITH A KNOCKING SOUND TWICE AND STALLED. I STARTED THE VAN BACK UP, WHEN IT DID START THE IDLE WAS ROUGH …
Read full complaint
ON APPROXIMATELY 04/07/2014 THE VAN WAS FILLED UP WITH GAS, I TOOK THE NOZZLE OUT WHEN IT SHUT OFF AND DID NOT PUT ANY EXTRA GAS INTO TANK. I STARTED UP THE VAN TO EXIT THE STATION WE DROVE ABOUT 100 YARDS AND THE VAN JERKED WITH A KNOCKING SOUND TWICE AND STALLED. I STARTED THE VAN BACK UP, WHEN IT DID START THE IDLE WAS ROUGH AND LOW. I HELD MY FOOT ON THE GAS PEDDLE TO SLIGHTLY RAISE THE RPM'S FOR ABOUT 30 SECONDS BEFORE WE PROCEEDED. IT TOOK A COUPLE OF MILES BEFORE THE VAN SEEMED TO BE ABOUT NORMAL. THIS HAS HAPPENED TWO OTHER TIMES SINCE THEN. ANOTHER COMPLAINT, THE FRONT BRAKES SQUEAK EVERY TIME YOU APPLY THEM. *TR
REFUELED VEHICLE, AFTER SHUTTING OFF IGNITION, VEHICLE STALLS IMMEDIATELY AFTER STARTING. *TR
FREQUENTLY AFTER FILLING UP WITH GAS AT COSTCO, THE VAN STALLS, ESPECIALLY WHILE I AM GOING AROUND A TURN. IT HAS COME CLOSE TO CAUSING AN ACCIDENT BUT I HAVE BEEN ABLE TO PUT IT IN NEUTRAL AND GET IT STARTED QUICKLY ENOUGH TO AVOID GETTING REAR-ENDED. VERY STRANGE AND ANNOYING. *TR
WHEN I FILL UP MY VAN, THE VEHICLE WILL START HOWEVER AFTER A FEW MINUTES AND I AM ON THE HIGHWAY THE CAR COMPLETELY SHUTS OFF. HAVE HAD TO SEVERAL MECHANICS LOOK AT THE VAN, AND NO ONE KNOWS WHAT THE ISSUE IS. I TRY TO RIDE AROUND THE GAS STATION PARKING LOT TO INSURE THE VAN IS GOING TO RUN BECAUSE I HAVE HAD SEVERAL CLOSE C…
Read full complaint
WHEN I FILL UP MY VAN, THE VEHICLE WILL START HOWEVER AFTER A FEW MINUTES AND I AM ON THE HIGHWAY THE CAR COMPLETELY SHUTS OFF. HAVE HAD TO SEVERAL MECHANICS LOOK AT THE VAN, AND NO ONE KNOWS WHAT THE ISSUE IS. I TRY TO RIDE AROUND THE GAS STATION PARKING LOT TO INSURE THE VAN IS GOING TO RUN BECAUSE I HAVE HAD SEVERAL CLOSE CALLS WHEN THE VEHICLE SHUTS DOWN WHEN I AM TRYING TO CROSS TRAFFIC. I WILL THEN HAVE NO BRAKES, POWER STEERING, ETC. THE VAN SHUTS COMPLETELY OFF. I USUALLY ABLE TO RESTART THE VEHICLE. THIS IS A VERY UNSAFE ISSUE. *TR
ON THREE SEPARATE OCCASIONS WHEN DRIVING THE CAR, THE IGNITION KEY SUDDENLY SHUT OFF THE ENGINE CAUSING DIFFICULTY WITH STEERING AS WELL. THIS WAS CHECKED BY THE DEALERSHIP WHO COULD FIND NO REASON FOR THE ACTION. *TR
Official recalls
210V338000 · Seats
Jul 27, 2010
DRIVING SPECIALTIES LTD IS RECALLING 2 MODEL YEAR 2006 AND 2007 CONVERSION VANS EQUIPPED WITH VMI/RICON 6-WAY POWER SEAT BASES. THERE IS A POSSIBILITY OF A DEFECTIVE WELD AT THE JOINT BETWEEN THE PIVOTING PLATE AND THE PIVOTING PLATE PIN.
Consequence & remedy
Consequence: THE SEAT OCCUPANT MAY BE INJURED IF THE SEAT BASE PIN WERE TO BREAK.
Remedy: DRIVING SPECIALTIES WILL NOTIFY OWNERS AND THE VEHICLES WILL BE REPAIRED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JULY 28, 2010. OWNERS MAY CONTACT DRIVING SPECIALTIES AT 1-707-553-1515.
10V261000 · Seats
Jun 14, 2010
ARIZONA MOBILITY PRODUCTS (AMP) IS RECALLING ONE 2005 AND ONE 2007 CONVERSION VANS BUILT ON DODGE GRAND CARAVAN CHASSIS EQUIPPED WITH VMI/RICON 6-WAY POWER SEAT BASES. THERE IS A POSSIBILITY OF A DEFECTIVE WELD AT THE JOINT BETWEEN THE PIVOTING PLATE AND THE PIVOTING PLATE PIN.
Consequence & remedy
Consequence: THE SEAT OCCUPANT MAY BE INJURED IF THE SEAT BASE PIN WERE TO BREAK.
Remedy: AMP WILL NOTIFY OWNERS AND REPAIR VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JUNE 10, 2010. OWNERS MAY CONTACT AMP AT 1-602-385-5988.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1DP14002 · Engine Stall After Refueling
Opened Sep 5, 2014 · Closed Apr 6, 2015
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly
This defect petition evaluates July 7, 2014 allegations from an owner of a model year (MY) 2007 Dodge Grand Caravan minivan that engine stall occurs in these vehicles without warning after refueling.The petitioner's vehicle is a Chrysler RS platform minivan.The RS platform includes MY 2003 through 2007 Dodge Grand Caravan, Dodge Caravan, Chrysler Town and Country and Chrysler Voyager minivans.NHTSA evaluated the petition by analyzing consumer complaints submitted to the Agency, analyzing field data, reviewing technical information provided in Chrysler's response to an Agency information request and testing an RS minivan identified by its owner as experiencing post-refuel engine stalls.After completing this evaluation, NHTSA has concluded that further investigation is unlikely to result in a finding that a defect related to motor vehicle safety exists.The stalls occurring in these vehicles only occur immediately after filling up the fuel tank and happen at low engine speeds. The failure rate is low, even after 8 to 13 years of the vehicles being in service, and there are no reports of crashes or injuries resulting from the stall condition.In the Agency's view, additional investigation is unlikely to result in finding the existence of a safety-related defect in the subject vehicles.Given the need to allocate and prioritize NHTSA's limited resources to best accomplish the Agency's safety mission, the petition is denied.This action does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency will take further action if warranted by future circumstances. More details concerning our review can be found in the Federal Register Notice for this action.The following 161 VOQs are included in the petition evaluation: 10209242, 10229468, 10240708, 10260923, 10275939, 10276532, 10296487, 10298175, 10328669, 10330144, 10346517, 10349789, 10354758, 10363689, 10372112, 10372368, 10372514, 10378031, 10379764, 10382938, 10387448, 10394063, 10398877, 10413918, 10418652, 10420924, 10427063, 10437525, 10445392, 10446902, 10470028, 10471249, 10473733, 10502231, 10503114, 10504260, 10509862, 10511988, 10512120, 10512385, 10512650, 10513147, 10538154, 10549841, 10551763, 10555188, 10555418, 10556754, 10565367, 10574012, 10574398, 10586555, 10587212, 10587559, 10593433, 10607841, 10607913, 10608922, 10615810, 10622468, 10628141, 10632112, 10632128, 10632172, 10632175, 10632231, 10632262, 10632266, 10632270, 10632305, 10632316, 10632326, 10632370, 10632385, 10632399, 10632492, 10632542, 10632765, 10632833, 10632928, 10633197, 10633281, 10633409, 10633421, 10633483, 10633507, 10637752, 10637804, 10637950, 10637975, 10638032, 10638289, 10638290, 10638401, 10638968, 10639218, 10639623, 10641157, 10641603, 10641614, 10641836, 10644339, 10644705, 10649713, 10649895, 10649932, 10650313, 10652590, 10653147, 10653783, 10654533, 10655226, 10658900, 10659679, 10660320, 10662588, 10662645, 10662662, 10663473, 10667056, 10667437, 10668081, 10668094, 10668131, 10668612, 10668969, 10668970, 10669584, 10669678, 10669729, 10669775, 10669866, 10669895, 10669992, 10670422, 10670506, 10676348, 10676732, 10677120, 10679795, 10679934, 10680057, 10680290, 10680342, 10680714, 10681512, 10682584, 10682906, 10683022, 10683114, 10683549, 10683620, 10683697, 10683743, 10689898, 10690761, 10691284, 10691556, 10691751, 10693061, 10694300